FITTING INSTRUCTIONS FOR
RA RODEO TRAILER HARNESS
FD1221
17MY04
COPYRIGHT
Reproduction in whole or part
prohibited without written approval
HOLDEN LTD
Division of HOLDEN Ltd ACN 006 893 232
DRAFT
DRAFT
Page 1 of 2
TOOLS REQUIRED:
Phillips Head Screw Driver, 8mm Spanner, Side Cutters
FITTING INSTRUCTIONS:
1. From under the rear left side of the vehicle remove the
dust plug (1) from the body trailer harness connector (2).
Refer to Figure 1
2. Remove the tape binding the Gray reverse park sensor
wire against the trailer harness and straighten out the
wire.
3. Connect the male trailer harness connector into the
female body harness connector.
A
VIEW
A
Part No.92148289
FIGURE 1
1
2
FITTING INSTRUCTIONS FOR
RA RODEO TRAILER HARNESS
FD1221
17MY04
COPYRIGHT
Reproduction in whole or part
prohibited without written approval
HOLDEN LTD
Division of HOLDEN Ltd ACN 006 893 232
DRAFT
DRAFT
FIGURE 2
FITTING INSTRUCTIONS: continued...
Refer to Figure 2 for the following:
4. Route the trailer harness under the tow bar and using
the screws, washers and nuts supplied, mount the 7 pin
flat connector to the tow bar. Tighten to specified torque.
5. Use cable tie to secure the patch harness to the tow bar.
6. Run the Gray wire along the rear body rails to the right
hand side of the body to tail lamp connecter and secure.
Refer to Figure 3.
NOTE: If the vehicle is fitted with the reverse parking
sensor system, connect the Gray trailer harness wire
connector into the female reverse park sensor system
patch harness.
7. Use cable ties to secure the gray wire along the vehicle
body rails.
CAUTION: Make sure that the Gray wire is clear of
the spare wheel and will not be damaged when the
spare wheel is used.
8. Place fitting instructions in the glovebox.
Page 2 of 2
NUT, 2 PLACES
TIE STRAP
SCREW, 2 PLACES
1
SPRING WASHER,
2 PLACES
2.0 ~ 3.0 Nm 1
FIGURE 3
LAMP
HARNESS
RPA
PATC H
HARNESS
CONNECTORS
PART NUMBER DESCRIPTIONS QUANTITY
92148289 TRAILER WIRING HARNESS. 1
FD1221 FITTING INSTRUCTIONS 1
FD796 PROOF OF WARRANTY CARD. 1
SCREW 2
WASHER - SPRING 2
NUT 2
CABLE TIE 6
GRAY TRAILER
HARNESS
CONNECTOR
GRAY TRAILER
HARNESS WIRE