Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–1
Page 12O–1
Section 12O
Fuses, Relays and Wiring Harnesses –
AWD Wagon
ATTENTION
Before performing any service operation or other procedure described in this Section, refer to Section 00
Warnings, Cautions and Notes for correct workshop practices with regard to safety and/or property damage.
1 General Information ...............................................................................................................................5
1.1 Fuses ...................................................................................................................................................................... 5
1.2 Circuit Breakers..................................................................................................................................................... 8
1.3 Fusible Links.......................................................................................................................................................... 9
1.4 Relays ................................................................................................................................................................... 11
Passenger Compartment Relays........................................................................................................................ 11
Engine Compartment Relays.............................................................................................................................. 12
1.5 Diodes................................................................................................................................................................... 13
1.6 Wiring Harnesses................................................................................................................................................. 14
1.7 Wiring Harness Connectors................................................................................................................................ 15
1.8 Electronic Control Device Locations ................................................................................................................. 16
2 Service Operations...............................................................................................................................21
2.1 Fuses .................................................................................................................................................................... 21
Passenger Compartment Fuse and Relay Panel Assembly.............................................................................21
Replace............................................................................................................................................................ 21
Engine Compartment Fuse and Relay Panel Assembly................................................................................... 22
Replace............................................................................................................................................................ 22
2.2 Circuit Breakers................................................................................................................................................... 23
Remove................................................................................................................................................................. 23
Test ....................................................................................................................................................................... 23
Reinstall................................................................................................................................................................ 23
2.3 Fusible Links........................................................................................................................................................ 24
All Plug-in Type Fusible Links Except F104...................................................................................................... 24
Replace............................................................................................................................................................ 24
Plug-in Type Fusible Link F104 ................................................................................................. ......................... 25
Replace............................................................................................................................................................ 25
One-Wire Type Fusible Link................................................................................................................................ 26
Replace............................................................................................................................................................ 26
2.4 Relays ................................................................................................................................................................... 27
Passenger Compartment Relays........................................................................................................................ 27
Replace............................................................................................................................................................ 27
Engine Compartment Relays.............................................................................................................................. 28
Remove............................................................................................................................................................ 28
2.5 Diodes................................................................................................................................................................... 29
A/C Compressor Suppression Diode................................................................................................................. 29
Remove............................................................................................................................................................ 29
Test.................................................................................................................................................................. 29
Reinstall ........................................................................................................................................................... 29
2.6 Wiring Repairs...................................................................................................................................................... 30
Techline
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–2
Page 12O–2
3 Wiring Installation Diagrams...............................................................................................................31
3.1 Battery Wiring Harness – 1 ................................................................................................................................. 31
V6 Engine ............................................................................................................................................................. 31
3.2 Battery Wiring Harness – 2 ................................................................................................................................. 32
V6 Engine ............................................................................................................................................................. 32
3.3 Battery Wiring Harness – 3 ................................................................................................................................. 33
GEN III V8 Engine................................................................................................................................................. 33
3.4 Battery Wiring Harness – 4 ................................................................................................................................. 34
GEN III V8 Engine................................................................................................................................................. 34
3.5 Engine Harness – 1.............................................................................................................................................. 35
V6 Engine ............................................................................................................................................................. 35
3.6 Engine Harness – 2.............................................................................................................................................. 37
V6 Engine ............................................................................................................................................................. 37
3.7 Engine Harness – 3.............................................................................................................................................. 38
V6 Engine ............................................................................................................................................................. 38
3.8 Engine Harness – 4.............................................................................................................................................. 40
V6 Engine ............................................................................................................................................................. 40
3.9 Engine Harness – 5.............................................................................................................................................. 42
V6 Engine ............................................................................................................................................................. 42
3.10 Engine Harness – 6.............................................................................................................................................. 43
V6 Engine ............................................................................................................................................................. 43
3.11 Transmission Harness – 1 .................................................................................................................................. 45
V6 Engine ............................................................................................................................................................. 45
3.12 Transmission Harness – 2 .................................................................................................................................. 46
V6 Engine – Automatic Transmission................................................................................................................ 46
3.13 Transmission Harness – 3 .................................................................................................................................. 48
V6 Engine – Automatic Transmission................................................................................................................ 48
3.14 Powertrain Harness – 1 ....................................................................................................................................... 49
GEN III V8 Engine................................................................................................................................................. 49
3.15 Powertrain Harness – 2 ....................................................................................................................................... 50
GEN III V8 Engine................................................................................................................................................. 50
3.16 Powertrain Harness – 3 ....................................................................................................................................... 51
GEN III V8 Engine................................................................................................................................................. 51
3.17 Powertrain Harness – 4 ....................................................................................................................................... 52
GEN III V8 Engine................................................................................................................................................. 52
3.18 Powertrain Harness – 5 ....................................................................................................................................... 53
GEN III V8 Engine – Automatic Transmission................................................................................................... 53
3.19 Powertrain Harness – 6 ....................................................................................................................................... 54
GEN III V8 Engine – Automatic Transmission................................................................................................... 54
3.20 Front Body Harness – 1....................................................................................................................................... 56
V6 Engine – Engine Compartment ..................................................................................................................... 56
3.21 Front Body Harness – 2....................................................................................................................................... 57
GEN III V8 Engine – Engine Compartment......................................................................................................... 57
3.22 Front Body Harness – 3....................................................................................................................................... 58
Protector Assembly, Brake Master Cylinder and Booster................................................................................ 58
3.23 Front Body Harness – 4....................................................................................................................................... 59
Under Hood Fuse and Relay Panel and Wiper Motor ....................................................................................... 59
3.24 Front Body Harness – 5....................................................................................................................................... 60
Body Ground and Washer Pump........................................................................................................................ 60
3.25 Front Body Harness – 6....................................................................................................................................... 61
Headlamp, Park Lamp and Turn Indicator – SX6 .............................................................................................. 61
3.26 Front Body Harness – 7....................................................................................................................................... 62
Headlamp, Park Lamp and Turn Indicator – CX6, LX6 & LX8........................................................................... 62
3.27 Front Body Harness – 8....................................................................................................................................... 63
V6 Engine – 400W Fans, Ambient Sensor and Theft Deterrent Connectors................................................... 63
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–3
Page 12O–3
3.28 Front Body Harness – 9....................................................................................................................................... 64
GEN III V8 Engine – 400W Fans, Ambient Sensor and Theft Deterrent Connectors...................................... 64
3.29 Front Body Harness – 10..................................................................................................................................... 65
GEN III V8 Engine – 430W Fans, Ambient Sensor and Theft Deterrent Connectors...................................... 65
3.30 Front Body Harness – 11..................................................................................................................................... 66
Ambient Sensor, Fan and Theft Deterrent Connectors .................................................................................... 66
3.31 Front Body Harness – 12..................................................................................................................................... 67
Front Lamps, Fog Lamps and Horn Connectors............................................................................................... 67
3.32 Front Body Harness – 13..................................................................................................................................... 68
V6 Engine – Engine Control Module .................................................................................................................. 68
3.33 Front Body Harness – 14..................................................................................................................................... 69
V6 Engine – ABS, Air Intake and Front Wheel Speed Sensor.......................................................................... 69
3.34 Front Body Harness – 15..................................................................................................................................... 70
GEN III V8 Engine – ABS, Air Intake and Front Wheel Speed Sensor ............................................................. 70
3.35 Front Body Harness – 16..................................................................................................................................... 71
V6 Engine – Cockpit Module – SX6.................................................................................................................... 71
3.36 Front Body Harness – 17..................................................................................................................................... 73
V6 Engine – Cockpit Module – LX6 and CX6..................................................................................................... 73
3.37 Front Body Harness – 18..................................................................................................................................... 75
GEN III V8 Engine – Cockpit Module – LX8........................................................................................................ 75
3.38 Front Body Harness – 19..................................................................................................................................... 77
Cockpit Module – V6 Engine............................................................................................................................... 77
3.39 Front Body Harness – 20..................................................................................................................................... 78
Cockpit Module – GEN III V8 Engine.................................................................................................................. 78
3.40 Front Body Harness – 21..................................................................................................................................... 79
Cockpit Module.................................................................................................................................................... 79
3.41 Front Body Harness – 22..................................................................................................................................... 80
V6 Engine – Fuse Block, BCM and PIM.............................................................................................................. 80
3.42 Front Body Harness – 23..................................................................................................................................... 81
GEN III V8 Engine – Fuse Block, PIM, TAC and BCM........................................................................................ 81
3.43 Front Body Harness – 24..................................................................................................................................... 83
V6 Engine – Steering Column............................................................................................................................. 83
3.44 Front Body Harness – 25..................................................................................................................................... 84
GEN III V8 Engine – Steering Column................................................................................................................ 84
3.45 Front Body Harness – 26..................................................................................................................................... 85
Ignition Lock and Theft Dete rrent Receiver....................................................................................................... 85
3.46 Front Body Harness – 27..................................................................................................................................... 86
Cruise Control, Stop Lamp Switches, Data Link Connector and Stepwell Lamps......................................... 86
3.47 Front Body Harness – 28..................................................................................................................................... 87
Accelerator Pedal Position ................................................................................................................................. 87
3.48 Front Body Harness – 29..................................................................................................................................... 88
Auxiliary Gauges.................................................................................................................................................. 88
3.49 Front Body Harness – 30..................................................................................................................................... 89
Inside Air Temperature Sensor and Floor Console .......................................................................................... 89
3.50 Front Body Harness – 31..................................................................................................................................... 91
Instrument Cluster Assembly............................................................................................................................. 91
3.51 Front Body Harness – 32..................................................................................................................................... 92
Air-conditioning and Heating Controls.............................................................................................................. 92
3.52 Front Body Harness – 33..................................................................................................................................... 93
Daytime Running Lamp Control......................................................................................................................... 93
3.53 Front Body Harness – 34..................................................................................................................................... 94
Instrument Panel Facia Trim Switches .............................................................................................................. 94
3.54 Front Body Harness – 35..................................................................................................................................... 95
Radio Assembly................................................................................................................................................... 95
3.55 Front Body Harness – 36..................................................................................................................................... 96
V6 Engine – Passenger Side Airbag and Radio/Mobile Telephone Connectors ............................................ 96
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–4
Page 12O–4
3.56 Front Body Harness – 37..................................................................................................................................... 98
GEN III V8 Engine – Passenger Side Airbag and Radio/Mobile Telephone Connectors................................ 98
3.57 Front Body Harness – 38................................................................................................................................... 100
Light Sensor/Key Receiver Module and Instrument Panel Speakers............................................................ 100
3.58 Front Body Harness – 39................................................................................................................................... 101
HVAC Climate Control (Manual A/C) ................................................................................................................ 101
3.59 Front Body Harness – 40................................................................................................................................... 102
HVAC Occupant Climate Control (Auto A/C)................................................................................................... 102
3.60 Front Body Harness – 41................................................................................................................................... 104
Instrument Panel Compartment........................................................................................................................ 104
3.61 Front Body Harness – 42................................................................................................................................... 105
V6 Engine – Interior........................................................................................................................................... 105
3.62 Front Body Harness – 43................................................................................................................................... 106
GEN III V8 Engine – Interior............................................................................................................................... 106
3.63 Front Body Harness – 44................................................................................................................................... 107
Transmission Selector Connectors .................................................................................................................. 107
3.64 Body Wiring Harness – 1................................................................................................................................... 108
V6 Engine – Interior........................................................................................................................................... 108
3.65 Body Wiring Harness – 2................................................................................................................................... 109
GEN III V8 Engine – Interior............................................................................................................................... 109
3.66 Body Wiring Harness – 3................................................................................................................................... 110
Interior ................................................................................................................................................................ 110
3.67 Body Wiring Harness – 4................................................................................................................................... 112
Interior ................................................................................................................................................................ 112
3.68 Body Wiring Harness – 5................................................................................................................................... 114
Interior ................................................................................................................................................................ 114
3.69 Body Wiring Harness – 6................................................................................................................................... 116
Interior ................................................................................................................................................................ 116
3.70 Body Wiring Harness – 7................................................................................................................................... 118
Level Ride........................................................................................................................................................... 118
3.71 Body Wiring Harness – 8................................................................................................................................... 120
Speakers............................................................................................................................................................. 120
3.72 Body Wiring Harness – 9................................................................................................................................... 121
3.73 Body & Roof Lamp Harnesses – 1.................................................................................................................... 123
Interior ................................................................................................................................................................ 123
3.74 Body & Roof Lamp Harnesses – 2.................................................................................................................... 124
Interior ................................................................................................................................................................ 124
3.75 Visor Lamp Harness .......................................................................................................................................... 125
Interior ................................................................................................................................................................ 125
3.76 Endgate Harness – 1.......................................................................................................................................... 126
3.77 Endgate Harness – 2.......................................................................................................................................... 127
3.78 Endgate Harness – 3.......................................................................................................................................... 129
3.79 Endgate Harness – 4.......................................................................................................................................... 131
3.80 Radio Antenna Wiring ....................................................................................................................................... 132
3.81 Front Door Wiring Harness – 1......................................................................................................................... 134
SX6 and CX6....................................................................................................................................................... 134
3.82 Front Door Wiring Harness – 2......................................................................................................................... 136
LX6 and LX8 ....................................................................................................................................................... 136
3.83 Front Door Wiring Harness – 3......................................................................................................................... 138
LX6 and LX8 ....................................................................................................................................................... 138
3.84 Rear Door Wiring Harness ................................................................................................................................ 139
3.85 Sunroof System Wiring ..................................................................................................................................... 140
3.86 9C1 Option – 1.................................................................................................................................................... 142
3.87 9C1 Option – 2.................................................................................................................................................... 143
V6 Engine ........................................................................................................................................................... 143
3.88 9C1 Option – 3.................................................................................................................................................... 144
GEN III V8 Engine............................................................................................................................................... 144
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–5
Page 12O–5
1 General Information
All electrical circuits are protected again st damage that might occur due to short circuits or overloads in the wiring system
by fuses, circuit breakers, fusible links and relays.
1.1 Fuses
Fuses are a blade type mini construction, with the current
rating in amps indicated on the top of the fuse assembly,
above the element, or identified by the plastic body colour of
the fuse. The fuse current ratings and corres ponding colour
are listed in the following table.
Figure 12O – 1
Current Rating
(Amps) Fuse Colour
3 Violet
5 Tan
7.5 Brown
10 Red
15 Blue
20 Yellow
25 White
30 Green
Fuses are located in two positions on the vehicle. One group is located in the passenger compartment fuse and relay
panel assembly. Refer to Figure 12O – 2. A label on the inside of the instrument panel lower cover indicates the circuits
protected by each fuse.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–6
Page 12O–6
Figure 12O – 2
Legend
1 F4 – Park Lamps Fuse (10A)
2 F5 – Stop Lamps Fuse (15A)
3 F6 – Interior Illumination Fuse (10A)
4 F7 – Hazard Lamps/Antenna Drive Fuse (15A)
5 F8 – Automatic Transmission (V6) Fuse (10A)
6 F9 – Horn Fuse (15A)
7 F10 – Ignition Fuse (7.5A)
8 F11 – Instrument Illumination Fuse (7.5A)
9 F12 – Turn Signals & Back-up Lamps Fuse (15A)
10 F13 – Heated Rear Window, HVAC & Instruments Fuse
(7.5A)
11 F14 – Cigar Lighter Fuse (20A)
12 F15 – Cruise Control, Power Mirrors & Engine (V6) Fuse
(10A)
13 F16 – Radio, Navigation & Cell Phone Fuse (7.5A)
14 F17 – Accessory Socket Fuse (20A)
15 F18 – Front/Rear Wiper Washer Fuse (20A)
16 F19 – Spare
17 F20 – Power Locks, Power Windows & Theft Horn Fuse
(15A)
18 F21 – Instruments & Climate Control Fuse (10A)
19 F22 – Heated Rear Window & Blower Fan Fuse (20A)
20 F23 – Radio, Cell Phone & Navigation Fuse (15A)
21 F24 – Sub-woofer Amplifier Fuse (V6 – 30A) / (V8 – 20A)
22 F25 – Spare
23 F26 – SRS Fuse (15A)
24 F27 – ABS & ESP Fuse (10A)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–7
Page 12O–7
The second group of fuses ar e located in the engine compartment fuse and relay panel assembly, situated forward of
the right-hand side front suspension strut tower. A label on the insid e of the panel cover indicates the circuits protected
by each fuse. Refer to Figure 12O – 3.
Figure 12O – 3
Legend
1 F36 – ABS, TCS & ESP Fuse (25A)
2 F37 – Engine Sensors 2 (V6) Fuse (15A)
3 F38 – Level Ride Fuse (25A)
4 F39 – AC Clutch (V6) Fuse (10A) / TAC Module (V8) Fuse
(15A)
5 F28 – Fuel Pump Fuse (15A)
6 F29 – Engine, BCM & Automatic Transmission (V6) Fuse
(10A)
7 F30 – Right-hand Headlamp Fuse (20A)
8 F31 – Left-hand Headlamp Fuse (20A)
9 F32 – Automatic Transmission (V8) / ECM (V6 & V8) Fuse
(15A)
10 F33 – Engine Sensors Fuse (15A)
11 F34 – Fuel Injectors & Ignition Modules Fuse (15A)
12 F35 – Fuel Injectors & Ignition Modules Fuse (15A)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–8
Page 12O–8
1.2 Circuit Breakers
A circuit breaker is a circuit protection device that will trip
when the circuit current exceeds its rating. The circuit
breaker is activated by heat and will reset after being
allowed to cool. The circuit breaker has a limited number of
tripping cycles before its tripping time will change. The
circuit breaker will continue to open a nd close until the
cause of the excess current is corrected.
Figure 12O – 4
All the circuit breakers are located in the passenger compartment fuse and relay panel assembly and have a 20A current
rating. A label on the inside of the panel cover indicates the circuits protected by each circuit breaker.
Refer to Figure 12O – 5.
Figure 12O – 5
Legend
1 F1 – Power Windows Circuit Breaker (20A)
2 F2 – Power Seats Circuit Breaker (20A) 3 F3 – Sunroof Circuit Breaker (20A)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–9
Page 12O–9
1.3 Fusible Links
The chassis and engine electrical wiring is protected against
short circuit damage by fusible links.
Plug-in type fusible links (1) have an insp ection window (2)
that allows a visual check of the condition of the element (3).
Figure 12O – 6
The plug-in type fusible links are located in the engine compartment fuse and relay panel assembly.
Refer to Figure 12O – 7 for the location and usage of the fusible links. A label on the inside of the panel cover indicates
the circuits protected by each fusible link.
Figure 12O – 7
Legend
1 F101 – Engine Cooling Large Fan (30A)
2 F102 – Lighting (60A)
3 F103 – Anti-lock Brakes (V6 – 40A) / (V8 – 50A)
4 F104 – Engine (60A)
5 F105 – Main (60A)
6 F106 – Blower Fan (40A)
7 F107 – Engine Cooling Small Fan (30A)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–10
Page 12O–10
A one-wire type fusible link, c onsisting of an insulated fuse
wire (1) is attached to the battery harness with cable ties.
This is integrated as part of the battery harne ss and is
located adjacent to the battery harness positive terminal.
Figure 12O – 8
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–11
Page 12O–11
1.4 Relays
There are a variety of relay assemblies (1) used in the vehicle. The relays a r e located in the engine compartment and
passenger compartment fuse and relay panel assemblies.
Figure 12O – 9
Passenger Compartment Relays
The passenger compartment fuse an d relay panel assembly is located be hin d the instrument panel lower cover. A label
on the inside of the cover indicates the relay location and the circuits protected by each relay. Refer to Figure 12O – 10.
Figure 12O – 10
Legend
1 R17 – Relay Assembly – Rear Wiper (4 Pin Micro)
2 R18 – Relay Assembly – Park Lamps (4 Pin Micro)
3 R19 – Flasher Assembly – Turn Signal (3 Pin)
4 R20 – Relay Assembly – Accessory Control (4 Pin Mini)
5 R21 – Relay Assembly – Ignition Control (4 Pin Mini)
6 R22 – Relay Assembly – Power Windows (4 Pin Mini)
7 R23 – Relay Assembly – Blower Inhibit (4 Pin Mini)
8 R24 – Relay Assembly – Interior Illumination (4 Pin Mini)
9 R25 – Relay Assembly – Defog (4 Pin Micro)
10 R26 – Spare
11 R27 – Spare
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–12
Page 12O–12
Engine Compartment Relays
The engine compartment fuse and relay panel assembly is located forward of the right-hand side front suspensio n strut
tower. A label on the inside of the cover lists the relay location and the circuits protected by each relay.
Refer to Figure 12O – 11.
Figure 12O – 11
Legend
1 R1 – Start Relay (4 Pin)
2 R2 – Blower Relay (4 Pin)
3 R3 – Headlamp Hi-beam Relay (4 Pin)
4 R4 – Engine Control Relay (4 Pin)
5 R5 – Engine Cooling Fan Relay 2 – High Speed (4 Pin)
6 R8 – Horn Relay (4 Pin Micro)
7 R9 – Spare
8 R12 – Reverse Relay (4 Pin)
9 R10 – Fog Lamp Relay (4 Pin Micro)
10 R13 – Spare
11 R16 – Fuel Pump Relay (4 Pin Micro)
12 R15 – Spare
13 R11 – A/C Relay (4 Pin Micro)
14 R14 – Headlamp Lo-beam Relay (4 Pin Micro)
15 R7 – Engine Cooling Fan Relay 1 – Lo Speed (5 Pin)
16 R6 – Spare
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–13
Page 12O–13
1.5 Diodes
All vehicles with air conditioni ng have an air-conditioning
compressor clutch suppression diode (1) fitted to the engine
harness.
For location of the air-conditioning compress or clutch
feedback diode, refer to the following figures:
a Figure 12O – 43, item 8.
B Figure 12O – 53, item 6.
Figure 12O – 12
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–14
Page 12O–14
1.6 Wiring Harnesses
Refer to Figure 12O – 13 for the location of the wiring harnesses used in the vehicle. For a detailed layout of the various
wiring harnesses and connectors, refer to 3 Wiring Installati on Diagrams.
Figure 12O – 13
Legend
1 Battery Wiring Harness
2 Front Body Harness
3 Right-hand Front Door Wiring Harness
4 Roof Lamp Harness
5 Right-hand Rear Door Wiring Harness
6 Body Wiring Harness
7 End Gate Wiring Harness
8 End Gate Sub Harness
9 Left-hand Rear Door Wiring Harness
10 Left-hand Front Door Wiring Harness
11 Powertrain Harness
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–15
Page 12O–15
1.7 Wiring Harness Connectors
The majority of the wiring har ness connectors used are of an interlocking design.
The male and female conn ector bodies, when pushed together, cannot be pulled apart due to the prese nce of a locking
tang on the connector body. Some connectors have anti-backout combs fitted for increased connector terminal security.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–16
Page 12O–16
1.8 Electronic Control Device Locations
The following figures illustrate the locati on of the various electronic control devices fitted.
Ensure the precautionar y and special handling instructions are followed (where applicable) for each electronic control
device as described in the corresponding sections.
Figure 12O – 14
Legend
1 Fusible Links – Engine compartment
2 Relays & Fuses – Engine compartment
3 Relays & Fuses – Instrument Panel
4 Body Control Module
5 Steering Wheel Radio & CD Player Controls
6 Climate Control Module
7 Ambient Light Sensor
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–17
Page 12O–17
Figure 12O – 15
Legend
1 Engine Control Module (V6)
2 Vehicle Speed Sensor – Manual Transmission (V6)
3 Vehicle Speed Sensor – Automatic Transmission (V6)
4 ABS Electronic Control Unit (V6)
5 ABS-TCS Electronic Control Unit (V6)
6 Transmission Control Module – 5 Speed Automatic
Transmission (V6)
7 Transmission Control Module – 4 Speed Automatic
Transmission (V6)
8 Powertrain Interface Module (V6)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–18
Page 12O–18
Figure 12O – 16
Legend
1 Vehicle Speed Sensor – Manual Transmission (V8)
2 Vehicle Speed Sensor – Automatic Transmission (V8)
3 ABS & Traction Control Module (V8)
4 Powertrain Control Module (V8)
5 Powertrain Interface Module & Throttle Actuator Control
Module (V8)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–19
Page 12O–19
Figure 12O – 17
Legend
1 Yaw Rate Sensor
2 Modular Fuel Pump & Sender Assembly
3 Sensing & Diagnostic Module – Occupant Protection System
4 Rear Object Sensor Assembly
5 Rear Object Sensor Control Module
6 Rear Object Sensor Alarm
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–20
Page 12O–20
Figure 12O – 18
Legend
1 Door Ajar Warning Switch Assembly (4 places)
2 Radio Assembly
3 Radio Rear Speaker Amplifier
4 Rear Speaker Assembly (2 places)
5 Front Door Speaker Assembly (2 places)
6 Rear Door Speaker Assembly (2 places)
7 Theft Deterrent Horn
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–21
Page 12O–21
2 Service Operations
2.1 Fuses
Passenger Compartment Fuse and Relay Panel Assembly
Replace
1 To gain access to the passenger compartme nt fuse
and relay panel assembly (1) move the steering
column to the upmost position. Firmly grasp the
instrument panel lower cover (4) and pull the cover
downwards to disengage the locating clips (3).
2 Refer to the label (2) on the inside of the instrument
panel lower cover to identify the circuits protected by
each fuse.
Figure 12O – 19
3 Use the fuse remover (1) located in the passenger
compartment fuse and relay panel assembly to
remove the suspect fuse. To use, pull the remover
from its location in the panel assembly and f ully insert
the remover over the top of the fuse and pull the fuse
from the panel.
Figure 12O – 20
4 Determine if the fuse has blown by examining the
element for a break:
a A good fuse (1) has an intact element.
b A blown fuse (2) has a broken element.
5 Replace a blown fuse with a fuse of the same current
rating. If the replacement fuse blows rectify the fault
within the circuit before replacing the fus e ag ain.
6 Close the instrument panel lower cover. Ensure the
locating clips are correctly alig ned and slot into the
corresponding mating retainer s securely.
Figure 12O – 21
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–22
Page 12O–22
Engine Compartment Fuse and Relay Panel Assembly
Replace
1 Remove the engine compartment fuse an d relay panel
assembly cover (2) by releasing the retaining tang (1)
and lifting the cover up and towards the sus pension
strut tower.
2 Refer to the label on the inside cover of the engine
compartment fuse and relay panel assembl y to identify
the circuits protected by each fuse.
3 Use the fuse remover located in the passeng er
compartment fuse and relay panel assembly to
remove the suspect fuse. Refer to Passenger
Compartment Fuse and Relay Panel Assembly for the
location and usage of the fuse remover.
Figure 12O – 22
4 Determine if the fuse has blown by examining the
element for a break:
a A good fuse (1) has an intact element.
b A blown fuse (2) has a broken element.
5 Replace a blown fuse with a fuse of the same current
rating. If the replacement fuse blows rectify the fault
before replacing the fuse agai n.
6 Replace the engine compartm ent fuse and relay panel
assembly cover. Ensure the retaining tang locks into
place.
Figure 12O – 23
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–23
Page 12O–23
2.2 Circuit Breakers
Remove
1 To gain access to the passenger compartme nt fuse
and relay panel assembly (1) move the steering
column to the upmost position. Firmly grasp the
instrument panel lower cover (4) and pull the cover
downwards to disengage the locating clips (3).
2 Refer to the label (2) on the inside of the instrument
panel lower cover to identify the circuits protected by
each fuse.
3 Pull the suspect circuit breaker from the passenger
compartment fuse and relay panel assembly.
Figure 12O – 24
Test
1 Remove the circuit breaker as described in this
Section.
2 Perform a continuity check on the circuit breaker. If
there is no continuity wait 15 seconds and check the
circuit breaker again.
a If continuity exists after 15 seconds have
elapsed the circuit breaker has reset and can be
replaced in the passenger compartment fuse
and relay panel assembly. If the circuit breaker
trips again there is a problem within th e circuit it
is protecting and the problem should be rectified
before continuing.
b If there is no continuity after 15 seconds have
elapsed, the circuit breaker has blown and must
be replaced with another circuit breaker of the
same current rating.
3 Install the circuit breaker as described in this Section.
Figure 12O – 25
Reinstall
Replace the passenger compartment fuse and relay panel assembly cover, ensuring the retaining tang locks into place.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–24
Page 12O–24
2.3 Fusible Links
All Plug-in Type Fusible Links Except F104
Replace
1 Remove the engine compartment fuse an d relay panel
assembly cover by releasing the retaining tang (1) on
the cover (2) and lifting the cover up and to wards the
suspension strut tower.
2 Refer to the label on the inside of the engine
compartment fuse and relay panel assembly cov er to
identify the circuits protected by each fusible link.
Figure 12O – 26
3 Pull the suspect fusible link (1) from the panel
assembly and perform a visual check of the element
(3) through the inspection window (2) to determine
whether or not it has blown.
a A good fusible link has an intact element.
b A blown fusible link has a broken element.
4 Replace a blown fusible link with one of the same
current rating. If the replacement fusible link blows this
indicates a problem with the circuit it is protecting.
Rectify this fault before replacing the fusible link again.
5 Replace the engine compartm ent fuse and relay panel
assembly cover. Ensure the retaining tang locks into
place. Figure 12O – 27
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–25
Page 12O–25
Plug-in Type Fusible Link F104
Replace
1 Remove the engine compartment fuse an d relay panel
assembly cover by releasing the retaining tang (1) on
the cover (2) and lifting the cover up and to wards the
suspension strut tower.
2 Refer to the label on the inside of the engine
compartment fuse and relay panel assembly cov er to
identify the circuits protected by each fusible link.
Figure 12O – 28
3 Remove the fusible link terminal attaching screw (2)
and pull fusible link F104 (1) from engine compartment
fuse and relay panel assembly (3).
Figure 12O – 29
4 Perform a visual check of the element (3) through the
inspection window (2) to determine whether or not it
has blown.
a A good fusible link has an intact element.
b A blown fusible link has a broken element.
5 Replace a blown fusible link with another with a 60A
current rating. If the replacement fusible link blows this
indicates a problem within the engine circuitry it is
protecting. Rectify this fault before replacing the
fusible link again.
6 Tighten the fusible link terminal attachi ng screw to the
correct torque specification.
Fusible link terminal attaching
screw torque specification 5.0 – 6.0 Nm
7 Replace the engine compartm ent fuse and relay panel
assembly cover. Ensure the retaining tang locks into
place.
Figure 12O – 30
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–26
Page 12O–26
One-Wire Type Fusible Link
Replace
1 Disconnect the end of the fusible link (1) further from
the positive battery terminal by cutting the cable tie.
2 Test for a voltage drop bet ween the positive battery
terminal and the end of the fusible link.
a If there is a voltage drop the fusible link has
blown and must be replac ed. If the new fusible
link blows this indicates a fault in the circuit a nd it
should be rectified before replacing the fusible
link again.
b If there is no voltage drop the fusible link has not
blown and the problem lies elsewhere.
3 Reattach the fusible link to the battery wiring harness.
Use new cable ties to fasten the fusible link to the
battery wiring harness and cut the cable tie ends to a
suitable length.
Figure 12O – 31
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–27
Page 12O–27
2.4 Relays
Passenger Compartment Relays
Replace
1 To gain access to the passenger compartme nt fuse
and relay panel assembly (1) move the steering
column to the upmost position. Then firml y grasp the
instrument panel lower cover (4) and pull the cover
downwards to disengage the locating clips (3).
2 Use the label (2) on the insid e of the instru ment panel
lower cover to identify the circuits protected by each
relay.
Figure 12O – 32
Figure 12O – 33
3 Pull the suspect relay assembly (1) from the passenger compartment fuse and relay panel assembly by hand and
replace it with a relay of the same type, refer to Figure 12O – 33.
4 If the circuit functions as normal the problem was with the relay and has been rectified.
5 If the circuit does not function as normal or functions for a short time then stops it can be assumed the problem lies
within the circuit and must be rectified before replacing the relay again.
6 Close the instrument panel lower cover. Ensure the locating clips are correctly aligned and slot into the
corresponding mating retainer s securely.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–28
Page 12O–28
Engine Compartment Relays
Remove
1 Remove the engine compartment fuse an d relay panel
assembly cover (2) by releasing the retaining tang (1)
and lifting the cover up and towards the sus pension
strut tower.
2 Refer to the label on the inside cover of the engine
compartment fuse and relay panel assembl y to identify
the circuits protected by each relay.
Figure 12O – 34
Figure 12O – 35
3 Pull the suspect relay assembly (1) from the passenger compartment fuse and relay panel assembly by hand and
replace it with a relay of the same type, refer to Figure 12O – 35.
4 If the circuit function as normal the problem was with the relay and has been rectified.
5 If the circuit does not functions as normal or functions for a short time then stops it can be assumed the problem
lies within the circuit and must be rectified before replacing the relay again.
6 Close the instrument panel lower cover. Ensure the locating clips are correctly aligned and slot into the
corresponding mating retainer s securely.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–29
Page 12O–29
2.5 Diodes
A/C Compressor Suppression Diode
Remove
1 Locate the diode on the engi ne harness at the
injectors, refer to 1.5 Diodes.
2 Remove the tape securing the diode co nnector to the
wiring harness conduit.
3 Pull back the diode retainer on the diode connector
and use a pair of fine long nosed pliers to pull the
diode out of the connector.
Figure 12O – 36
Test
1 Remove the diode as described in this Section.
2 Select ‘diode testing’ on a digital multimeter (DMM)
probably marked with a diode symbol.
3 Measure the resistance acr oss the diode.
4 Reverse the multimeter probes and measure the
resistance again to determine the condition of the
diode.
a If a finite and an infinite measurement are
obtained the diode does n ot require
replacement.
b If both measurements are infinite or are both
very low resistances the diode must be repl aced.
5 Reinstall the diodes as described in this Section.
Figure 12O – 37
Reinstall
1 Insert the diode into the connector aligning the tab on the side of the diode with the connector retainer.
2 Using suitable tape, secure diode connector to wiring harness conduit.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–30
Page 12O–30
2.6 Wiring Repairs
Refer to Section 12P Wiring Diagrams for the service procedures and installation details for wiring harnesses and
connectors.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–31
Page 12O–31
3 Wiring Installation Diagrams
The following figures illustrate the vehicle wiring installation diagrams.
NOTE
Some of the following wiring installation diagrams
illustrate the upper level harnesses which
incorporate all necessary wiring harness
connectors for all production options. Depending
on equipment level and vehicle model, some of
the connectors may be taped back to the h arness
when a particular option is not fitted, or the
particular level of harness fitted to the vehicle
may not incorporate some of the connectors
illustrated.
3.1 Battery Wiring Harness – 1
V6 Engine
Figure 12O – 38
Legend
1 Battery Wiring Harness to Front Body Harness Co nnector
(X106)
2 Nut
3 Body Ground Terminal (X119 – G3 – GP3)
4 Battery Ground Terminal (X119 – G4 – GP3)
5 Battery Wiring Harness Terminal (X86 – C)
6 Battery Negative Terminal (G1 – X2 – GP1)
7 Nut
8 Battery Positive Terminal Cover
9 Nut
10 Washer
11 Battery Wiring Harness Positive Terminal (G1 – X1)
12 Battery Wiring Harness to Starter Motor and Generator
13 Battery Positive Post Assembly (X86 – B)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–32
Page 12O–32
3.2 Battery Wiring Harness – 2
V6 Engine
Figure 12O – 39
Legend
1 Starter Motor Terminal (M15 – X2)
2 Nut
3 Starter Motor Terminal Connector (M15 – X1 – V6)
4 Engine Block Ground Bolt
5 Engine Ground Terminal (X119 – GP4)
6 Battery Wiring Harness
7 Generator Terminal (G8 – X1)
8 Nut
A Battery wiring harness attached to engine block as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–33
Page 12O–33
3.3 Battery Wiring Harness – 3
GEN III V8 Engine
Figure 12O – 40
Legend
1 Battery Wiring Harness to Front Body Harness Co nnector
(X106)
2 Nut
3 Body Ground Terminal (X119 – G3 – GP3)
4 Battery Ground Terminal (X119 – G4 – GP3)
5 Battery Wiring Harness Terminal (X86 – C)
6 Battery Negative Terminal (G1 – X2 – GP1)
7 Nut
8 Battery Positive Terminal Cover
9 Nut
10 Washer
11 Battery Wiring Harness Positive Terminal (G1–X1)
12 Battery Wiring Harness to Starter Motor and Generator
13 Battery Positive Post Assembly (X86 – B)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–34
Page 12O–34
3.4 Battery Wiring Harness – 4
GEN III V8 Engine
Figure 12O – 41
Legend
1 Battery Wiring Harness Bracket to Engine Mounting Screw
2 Engine Ground Terminal (X119 – GP4)
3 Battery Wiring Harness Ground to Block Screw
4 Battery Wiring Harness Bracket
5 Starter Motor Terminal (M15 – X2)
6 Starter Motor Terminal Attaching Nut
7 Starter Motor Terminal Connector (M15 – X1 – V8)
8 Battery Wiring Harness
9 Battery Wiring Harness to Generator B+ Terminal Nut
10 Generator Terminal (G8 – X1)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–35
Page 12O–35
3.5 Engine Harness – 1
V6 Engine
Figure 12O – 42
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–36
Page 12O–36
Legend
1 Engine Harness to Transmission Harness Connector (X104)
2 Engine Harness Former, Rear
3 Engine Harness Former Rear Attaching Bolts
4 Engine Harness Former, Right-hand Side
5 Engine Harness Ground Terminal Attaching Bolt
6 Engine Harness Ground Terminals (X119 – GP 19A and
X119 – GP19B)
7 Throttle Actuator Connector (Y38 – V6)
8 Engine Harness Former, Left-hand Side
9 Engine Harness Ground Terminals (X119 – GP 20A and
X119 – GP20&B)
10 Engine Harness Ground Terminal Attaching Bolt
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–37
Page 12O–37
3.6 Engine Harness – 2
V6 Engine
Figure 12O – 43
Legend
1 Engine Harness Ground Terminal (X119 – GP18)
2 Engine Harness Ground Terminal Attaching Bolt
3 Oil Level Indicator Tube Attaching Bolt
4 Engine Harness Former Attaching Bolt
5 Suppression Diode A/C Compressor (V5)
6 A/C Clutch Connector (L7)
7 Engine Harness Former
8 Engine Oil Level Sensor Connector (B41)
9 Generator Connector (G8 – X2)
A Harness attached to engine block as shown.
B Harness attached to engine block as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–38
Page 12O–38
3.7 Engine Harness – 3
V6 Engine
Figure 12O – 44
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–39
Page 12O–39
Legend
1 Engine Harness to Front Body Harness Connector (X103)
2 Engine Harness to ECM Bracket Ground Terminal Attaching
Bolt
3 Engine Harness to ECM Bracket Ground (X119 – GP17)
4 Ignition Coil Connectors, Right-hand Side (L3)
5 Knock Sensor Connector, Right-hand Side (B65 – V6)
6 Crankshaft Position Sensor Connector (B30 – V6)
7 Engine Control Module
8 Engine Control Module Connector (A43 – X1)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–40
Page 12O–40
3.8 Engine Harness – 4
V6 Engine
Figure 12O – 45
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–41
Page 12O–41
Legend
1 Ignition Coil Connectors, Left-hand Side (L3)
2 Engine Oil Pressure Sensor Connector (B42)
3 Knock Sensor Connector, Left-hand Side (B65 – V6)
4 Engine Harness to Fuel Injector Harness Connector (X102)
5 Canister Purge Solenoid Valve Connector (Y123 – V6)
6 Fuel Injector Harness to Engine Harness Connector (X102)
7 Fuel Injector Harness
8 Fuel Injector Connector (L2 – V6)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–42
Page 12O–42
3.9 Engine Harness – 5
V6 Engine
Figure 12O – 46
Legend
1 Engine Coolant Temperature Sensor Connector (B39 – V6)
2 M.A.P. Sensor Connector (B67 – V6) A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–43
Page 12O–43
3.10 Engine Harness – 6
V6 Engine
Figure 12O – 47
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–44
Page 12O–44
Legend
1 Engine Harness Former, Left-hand Side
2 Pre-O2 Sensor Connector, 2, 4 & 6 (B57 – V6)
3 Pre-O2 Sensor Connector, 1, 3 & 5 (B166 – V6)
4 Engine Harness Former, Right-hand Side
5 Variable Manifold Valve Connector (Y21)
6 Camshaft Position Sensor Connector, Intake 1, 3 & 5 (B28)
7 Camshaft Position Actuator Connector, Intake 1, 3 & 5 (Y4)
8 Engine Harness Former, Right-hand Side Front
9 Camshaft Position Sensor Connector, Exhaust 1, 3 & 5
(B28)
10 Camshaft Position Actuator Connector, Exhaust 1, 3 & 5
(Y4)
11 Camshaft Position Sensor Connector, Exhaust 2, 4 & 6
(B28)
12 Camshaft Position Actuator Connector, Intake 2, 4 & 6 (Y4)
13 Camshaft Position Sensor Connector, Intake 2, 4 & 6 (B28)
14 Engine Harness Former, Left-hand Side Front
15 Camshaft Position Actuator Connector, Exhaust 2, 4 & 6
(Y4)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–45
Page 12O–45
3.11 Transmission Harness – 1
V6 Engine
Figure 12O – 48
Legend
1 Theft Deterrent Horn Connector (B9)
2 Theft Deterrent Horn 3 Transmission Harness to Engine Harness Connector (X104)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–46
Page 12O–46
3.12 Transmission Harness – 2
V6 Engine – Automatic Transmission
Figure 12O – 49
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–47
Page 12O–47
Legend
1 Transmission Assembly Connector (X121 – 5SPD)
2 Post-Right-hand O2 Sensor Connector (B58 – V6)
3 Post-Left-hand O2 Sensor Connector (B56 – V6)
A Transmission harness clipped to rear of engine block
(2 places).
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–48
Page 12O–48
3.13 Transmission Harness – 3
V6 Engine – Automatic Transmission
Figure 12O – 50
Legend
1 Transmission Harness to Front Body Harness Connector
(X203)
2 Transmission Control Module, 5 Speed Transmission
3 Transmission Control Module Connector (A112 – 5SPD)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–49
Page 12O–49
3.14 Powertrain Harness – 1
GEN III V8 Engine
Figure 12O – 51
Legend
1 Fuel Injector Connector (L2 – V8)
2 C.P.A. Lock
3 Electronic Ignition Control Module Connector (A40 – L)
4 Canister Purge Solenoid Valve Connector (Y123 – V8)
5 Engine Coolant Temperature Sensor Connector (B39 – V8)
6 Powertrain Harness to Front Body Harness Connector
(X101)
7 A/C Pressure Sensor Connector (B18 – V8)
8 Mass Airflow and Intake Air Temperature Sensor Connector
(B69 – V8)
9 Generator Connector (G8 – X2)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–50
Page 12O–50
3.15 Powertrain Harness – 2
GEN III V8 Engine
Figure 12O – 52
Legend
1 Powertrain Harness to Front Body Harness Connector
(X101)
2 A/C Pressure Sensor Connector (B18 – V8)
3 Mass Airflow and Intake Air Temperature Sensor Connector
(B69 – V8)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–51
Page 12O–51
3.16 Powertrain Harness – 3
GEN III V8 Engine
Figure 12O – 53
Legend
1 Fuel Injector Connector (L2 – V8)
2 A/C Compressor Powertrain Harness Support Bracket
3 A/C Clutch Connector (L7)
4 A/C Compressor Mounting Bolt
5 C.P.A. Lock
6 Suppression Diode, A/C Compressor (V5)
7 Electronic Ignition Control Module Connector (A40 – R)
8 Throttle Actuator Connector (Y38 – V8)
9 Ground Terminal Attaching Bolt
10 Powertrain Harness Ground Terminal (X119 – GP5)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–52
Page 12O–52
3.17 Powertrain Harness – 4
GEN III V8 Engine
Figure 12O – 54
Legend
1 Powertrain Harness to Front Body Harness Connector
(X206)
2 Theft Deterrent Horn Connector (B9)
3 Theft Deterrent Horn
4 Powertrain Control Module Connector (A84 – X2)
5 Powertrain Control Module Connector (A84 – X1)
6 Powertrain Control Module
7 Throttle Actuator Control Module Connector (A111 – X1)
8 Throttle Actuator Control Module
A Ensure PCM connector attaching bolts are not over
tightened.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–53
Page 12O–53
3.18 Powertrain Harness – 5
GEN III V8 Engine – Automatic Transmission
Figure 12O – 55
Legend
1 M.A.P. Sensor Connector (B67 – V8)
2 Engine Oil Pressure Sensor Connector (B42)
3 Camshaft Position Sensor Connector (B28 – V8)
4 Vehicle Speed Sensor Connector (B83)
5 Transmission Assembly Connector (X121 – 4SPD)
6 Crankshaft Position Sensor Connector (B30 – V8)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–54
Page 12O–54
3.19 Powertrain Harness – 6
GEN III V8 Engine – Automatic Transmission
Figure 12O – 56
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–55
Page 12O–55
Legend
1 Left-hand O2 Sensor Connector (B57 – V8)
2 Right-hand O2 Sensor Connector (B166 – V8)
3 Powertrain Harness to Knock Sensor Harness Connector
(X107)
4 Engine Ground Terminal (X119 – GP6)
5 Engine Ground Terminal Attaching Bolt
6 Powertrain Harness Support Bracket
7 Powertrain Harness Support Bracket Attaching Bolt
8 Powertrain Harness Former
9 Knock Sensor Harness to Powertrain Harness Connector
(X107)
10 Knock Sensor Connector (B65 – SNSR2)
11 Knock Sensor Connector (B65 – SNSR1)
12 C.P.A. Lock
13 Park/Neutral Position and Back-up Lamp Switch Connector
(S187)
14 Bolt
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–56
Page 12O–56
3.20 Front Body Harness – 1
V6 Engine – Engine Compartment
Figure 12O – 57
Legend
1 Windshield Wiper Motor Connector (M17)
2 Brake Fluid Level Indicator Switch Connector (S36)
3 Front Wheel Speed Sensor Connector (B52 – R)
4 Electronic Brake and Traction Control module Connector
(A38) or Vehicle Control Module Connector (A116)
5 Front Body Harness to Battery Wiring Harness Connector
(X106)
6 Body Ground Terminal (X119 – G3 – GP3)
7 Front Body Harness Junction Connector (X100)
8 Front Body Harness to Engine Harness Connector (X103)
9 Fusible Link Supply Connector (X86 – A)
10 Ground Connector (X157)
11 Engine Control Module Connector (A43 – X2)
12 Turn Signal Lamp Connector (E76 – R)
13 Headlamp Connector (E119 – R)
14 Windshield Washer Motor Connector (M19)
15 Hood Theft Deterrent Switch Connectors (S135)
16 Fog Lamp Connector (E69 – R)
17 Horn Connectors (B9)
18 Ambient Air Temperature Sensor Connector (B23)
19 Engine Cooling Fan Connector (M7 – X1)
20 Mass Airflow and Intake Air Temperature Sensor Connector
(B69 – V6)
21 Fog Lamp Connector (E69 – L)
22 Horn Connectors (B9)
23 Headlamp Connector (E119 – L)
24 A/C Pressure Sensor Connector (B18 – V6)
25 Turn Signal Lamp Connector (E76 – L)
26 Front Wheel Speed Sensor Connector (B52 – L)
27 Sealing Patch Grommet
28 Grommet Insert
29 Instrument Panel to Body Ground Strap Terminal
(X118 – GP9)
30 Body to Instrument Panel Ground Strap
31 Body to Instrument Panel Ground Strap Terminal
(X119 – GP10)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–57
Page 12O–57
3.21 Front Body Harness – 2
GEN III V8 Engine – Engine Compartment
Figure 12O – 58
Legend
1 Windshield Wiper Motor Connector (M17)
2 Brake Fluid Level Indicator Switch Connector (S36)
3 Front Wheel Speed Sensor Connector (B52 – R)
4 Electronic Brake and Traction Control Module Connector
(A37)
5 Body Ground Terminal (X119 – G3 – GP3)
6 Front Body Harness to Battery Wiring Harness Connector
(X106)
7 Front Body Harness Junction Connector (X100)
8 Fusible Link Supply Connector (X86 – A)
9 Ground Connector (X157)
10 Turn Signal Lamp Connector (E76 – R)
11 Headlamp Connector (E119 – R)
12 Windshield Washer Motor Connector (M19)
13 Hood Theft Deterrent Switch Connectors (S135)
14 Fog Lamp Connector (E69 – R)
15 Horn Connectors (B9)
16 Ambient Air Temperature Sensor Connector (B23)
17 Engine Cooling Fan Connector (M7 – X1)
18 Front Body Harness to Powertrain Harness Connector
(X101)
19 Fog Lamp Connector (E69 – L)
20 Horn Connectors (B9)
21 Headlamp Connector (E119 – L)
22 Turn Signal Lamp Connector (E76 – L)
23 Front Wheel Speed Sensor Connector (B52 – L)
24 Sealing Patch Grommet
25 Grommet Insert
26 Instrument Panel to Body Ground Strap Terminal
(X118 – GP9)
27 Body to Instrument Panel Ground Strap
28 Body to Instrument Panel Ground Strap Terminal
(X119 – GP10)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–58
Page 12O–58
3.22 Front Body Harness – 3
Protector Assembly, Brake Master Cylinder and Booster
Figure 12O – 59
Legend
1 Brake Master Cylinder and Brake Booster
2 Brake Fluid Level Indicator Switch Connector (S36) 3 Front Body Harness Former
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–59
Page 12O–59
3.23 Front Body Harness – 4
Under Hood Fuse and Relay Panel and Wiper Motor
Figure 12O – 60
Legend
1 Front Body Harness Junction Connector Cover
2 Front Body Harness Junction Connector (X100)
3 Attaching Screw
4 Windshield Wiper Motor Connector (M17)
5 Firewall Clip (2 places)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–60
Page 12O–60
3.24 Front Body Harness – 5
Body Ground and Washer Pump
Figure 12O – 61
Legend
1 Battery Tray
2 Body Ground Connector (X157)
3 Body Ground Connector (X157 – GP2)
4 Attaching Nut, Body Ground
5 Attaching Stud, Body Ground
6 Windshield Washer Motor Connector (M19)
7 Windshield Washer Reservoir
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–61
Page 12O–61
3.25 Front Body Harness – 6
Headlamp, Park Lamp and Turn Indicator – SX6
Figure 12O – 62
Legend
1 Front Body Harness
2 Turn Signal Lamp Connector (E76)
3 Headlamp Connector (E119)
4 Headlamp Low Beam Dust Cover
5 Headlamp Adjuster
6 Headlamp High Beam Dust Cover
A Harness leads attached to wheelhouse as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–62
Page 12O–62
3.26 Front Body Harness – 7
Headlamp, Park Lamp and Turn Indicator – CX6, LX6 & LX8
Figure 12O – 63
Legend
1 Front Body Harness
2 Turn Signal Lamp Connector (E76)
3 Headlamp Connector (E119)
4 Headlamp Low Beam Dust Cover
5 Headlamp Adjuster
6 Headlamp High Beam Dust Cover
A Harness leads attached to wheelhouse as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–63
Page 12O–63
3.27 Front Body Harness – 8
V6 Engine – 400W Fans, Ambient Sensor and Theft Deterrent Connectors
Figure 12O – 64
Legend
1 Front Body Harness
2 Engine Cooling Fan Connectors (M7 – X2 – V6HP)
3 Engine Cooling Fan Assembly to Front Body Harness
Connector (M7 – X1)
4 Front Body Harness to Engine Cooling Fan Assembly
Connector (M7 – X1)
5 Ambient Air Temperature Sensor Connector (B23)
6 Hood Theft Deterrent Switch Connectors (S135)
A Front of vehicle.
B Harness attached to front wheelhouse panel bracket as
shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–64
Page 12O–64
3.28 Front Body Harness – 9
GEN III V8 Engine – 400W Fans, Ambient Sensor and Theft Deterrent Connectors
Figure 12O – 65
Legend
1 Front Body Harness
2 Engine Cooling Fan Connectors (M7 – X2 – V8)
3 Engine Cooling Fan Assembly to Front Body Harness
Connector (M7 – X1)
4 Front Body Harness to Engine Cooling Fan Assembly
Connector (M7 – X1)
5 Ambient Air Temperature Sensor Connector (B23)
6 Hood Theft Deterrent Switch Connectors (S135)
A Front of vehicle.
B Harness attached to front wheelhouse panel bracket as
shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–65
Page 12O–65
3.29 Front Body Harness – 10
GEN III V8 Engine – 430W Fans, Ambient Sensor and Theft Deterrent Connectors
Figure 12O – 66
Legend
1 Front Body Harness
2 Engine Cooling Fan Connectors (M7 – X2 – V8)
3 Engine Cooling Fan Assembly to Front Body Harness
Connector (M7 – X1)
4 Front Body Harness to Engine Cooling Fan Assembly
Connector (M7 – X1)
5 Ambient Air Temperature Sensor Connector (B23)
6 Hood Theft Deterrent Switch Connectors (S135)
A Front of vehicle.
B Harness attached to front wheelhouse panel bracket as
shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–66
Page 12O–66
3.30 Front Body Harness – 11
Ambient Sensor, Fan and Theft Deterrent Connectors
Figure 12O – 67
Legend
1 Hood Anti-theft Deterrent Switch Connectors (S135)
2 Front Body Harness to Engine Cooling Fan Assembly
Connector (M7 – X1)
3 Ambient Air Temperature Sensor Connector (B23)
4 Attaching Screw, Hood Theft Deterrent Switch
5 Hood Anti-theft Switch
A Front of vehicle.
B Harness attached to radiator lower support assembly as
shown (5 places).
C Blue strap to be aligned with centre line of vehicle as shown.
D Harness attached to side rail assembly as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–67
Page 12O–67
3.31 Front Body Harness – 12
Front Lamps, Fog Lamps and Horn Connectors
Figure 12O – 68
Legend
1 Front Fog Lamp
2 Front Fog Lamp Connector (E69)
3 Turn Signal Lamp Connector (E76)
4 Headlamp Connector (E119)
5 Front Wheel Speed Sensor Connector (B52)
6 Clip
7 Horn Connectors (B9)
A Harness attached to wheelhouse panel as shown.
B Front of vehicle.
C Left-hand side shown.
D Right-hand side shown.
E Not on SX6 and CX6.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–68
Page 12O–68
3.32 Front Body Harness – 13
V6 Engine – Engine Control Module
Figure 12O – 69
Legend
1 Engine Control Module 2 Engine Control Module Connector (A43 – X2)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–69
Page 12O–69
3.33 Front Body Harness – 14
V6 Engine – ABS, Air Intake and Front Wheel Speed Sensor
Figure 12O – 70
Legend
1 Mass Airflow and Air Intake Temperature Sensor Connector
(B69 – V6)
2 A/C Pressure Sensor Connector (B18 – V6)
3 Vehicle Control Module Connector (A116)
4 Front Wheel Speed Sensor Connector (B52)
5 Clip
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–70
Page 12O–70
3.34 Front Body Harness – 15
GEN III V8 Engine – ABS, Air Intake and Front Wheel Speed Sensor
Figure 12O – 71
Legend
1 Electronic Brake and Traction Control Module Connector
(A37) 2 Front Wheel Speed Sensor Connector (B52)
3 Clip
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–71
Page 12O–71
3.35 Front Body Harness – 16
V6 Engine – Cockpit Module – SX6
Figure 12O – 72
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–72
Page 12O–72
Legend
1 Front Body Harness to Global Positioning System Harness
Connector (X207)
2 Radio Front Speaker Dash Upper Connector (B112 – L)
3 Front Body Harness to Transmission Harness Connector
(X203)
4 Instrument Panel Compartment Lamp Connectors (E82)
5 Instrument Panel Compartment Lamp Switch Connectors
(S142)
6 Front Body Harness to Passenger Airbag Harness
Connector (X205)
7 Liftgate Window Release Switch Connector (S161)
8 Radio, Clock & CD Player Connector (A133 – X1)
9 Heater & A/C Evaporator Module Connector (A60 – X1)
10 Hazard Warning Switch Connector (S120)
11 Ambient Light Sensor Connector (B55)
12 Heater & A/C Evaporator Module Connector (A60 – X2)
13 Trip Odometer Reset Switch Connector (S237)
14 Stop Lamp, Traction & Cruise Control Release Switch
Connector (S220 – X3)
15 Stop Lamp, Traction & Cruise Control Release Switch
Connector (S220 – X1)
16 Ignition & Start Switch Connector (S149 – X1)
17 Instruments Connector (P3)
18 Radio Front Speaker Dash Upper Connector (B112 – R)
19 Headlamp Automatic Control Switch Connector (S125)
20 Resistor Assembly Connector (R30)
21 Powertrain Interface Module Connector (A5 – V6)
22 Accelerator Pedal Position Sensor Connector (B22)
23 Endgate Diode 3 Connector (V5)
24 Endgate Diode 2 Connector (V5)
25 Front Body Harness to Body Wiring Harness Connector
(X200)
26 Front Body Harness to Body Wiring Harness Connector
(X201)
27 Wiring (Diagnostics) Connector (X40)
28 Windshield Wiper Dwell Module Connector (A121)
29 Steering Angle Sensor Connector (B161)
30 Ignition Lock Cylinder Bulb Connector (E30)
31 Ignition & Start Switch Connector (S149 – X2)
32 Windshield Wiper and Washer Switch Connector (S247)
33 Cruise Control Switch Connector (S43)
34 Turn Signal & Headlamp Switch Connector (S231)
35 Steering Wheel Clock Spring Coil Connector (X116)
36 Ignition & Start Switch Connector (S149 – GP15 – X3)
37 Front Cigar Lighter Connector (X113 – F)
38 Front Body Harness to Body Wiring Harness Connector
(X303)
39 Hill Descent Switch Connector (S25)
40 ESP/Traction Control Switch Connector (S73)
41 Front Body Harness to Console Wiring Harness Connector
(X309)
42 Yaw Rate Sensor Connector (B85)
43 Front Body Harness to Transmission Selector Harness
Connector (X301)
44 Radio Ground Terminal (X118 – GP8)
45 Inline to Radio & Mobile Telephone Connector (X155)
46 Blower Motor Resistor Connector (R6)
47 Front Body Harness to Blower Motor Harness Connector
(X204)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–73
Page 12O–73
3.36 Front Body Harness – 17
V6 Engine – Cockpit Module – LX6 and CX6
Figure 12O – 73
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–74
Page 12O–74
Legend
1 Front Body Harness to Global Positioning System Harness
Connector (X207)
2 Radio Front Speaker Dash Upper Connector (B112 – L)
3 Front Body Harness to Transmission Harness Connector
(X203)
4 Instrument Panel Compartment Lamp Connectors (E82)
5 Instrument Panel Compartment Lamp Switch Connectors
(S142)
6 Front Body Harness to Passenger Airbag Harness
Connector (X205)
7 Liftgate Window Release Switch Connector (S161)
8 Radio, Clock & CD Player Connector (A133 – X1)
9 Hazard Warning Switch Connector (S120)
10 Auxiliary Gauges Connector (P2) [LX6 only]
11 Ambient Light Sensor Connector (B55)
12 Blower Motor & A/C Compressor Connector (A14 – X1)
13 Trip Odometer Reset Switch Connector (S237)
14 Inside Air Temperature Sensor Connector (B59)
15 Stop Lamp, Traction & Cruise Control Release Switch
Connector (S220 – X3)
16 Stop Lamp, Traction & Cruise Control Release Switch
Connector (S220 – X1)
17 Ignition & Start Switch Connector (S149 – X1)
18 Instruments Connector (P3)
19 Radio Front Speaker Dash Upper Connector (B112 – R)
20 Headlamp Automatic Control Switch Connector (S125)
21 Resistor Assembly Connector (R30)
22 Powertrain Interface Module Connector (A5 – V6)
23 Accelerator Pedal Position Sensor Connector (B22)
24 Endgate Diode 3 Connector (V5)
25 Endgate Diode 2 Connector (V5)
26 Right-hand Front Stepwell Lamp Connector (E105)
27 Front Body Harness to Body Wiring Harness Connector
(X200)
28 Front Body Harness to Body Wiring Harness Connector
(X201)
29 Wiring (Diagnostics) Connector (X40)
30 Windshield Wiper Dwell Module Connector (A121)
31 Steering Angle Sensor Connector (B161)
32 Ignition Lock Cylinder Bulb Connector (E30)
33 Ignition & Start Switch Connector (S149 – X2)
34 Windshield Wiper and Washer Switch Connector (S247)
35 Cruise Control Switch Connector (S43)
36 Turn Signal & Headlamp Switch Connector (S231)
37 Steering Wheel Clock Spring Coil Connector (X116)
38 Ignition & Start Switch Connector (S149 – GP15 – X3)
39 Front Cigar Lighter Connector (X113 – F)
40 Front Body Harness to Body Wiring Harness Connector
(X303)
41 Hill Descent Switch Connector (S25)
42 ESP/Traction Control Switch Connector (S73)
43 Front Body Harness to Console Wiring Harness Connector
(X309)
44 Yaw Rate Sensor Connector (B85)
45 Front Body Harness to Transmission Selector Harness
Connector (X301)
46 Radio Ground Terminal (X118 – GP8)
47 Inline to Radio & Mobile Telephone Connector (X155)
48 Blower and Air Inlet Connector (A13)
49 Front Body Harness to Blower Motor Harness Connector
(X204)
50 Left-hand Front Stepwell Lamp Connector (E105)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–75
Page 12O–75
3.37 Front Body Harness – 18
GEN III V8 Engine – Cockpit Module – LX8
Figure 12O – 74
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–76
Page 12O–76
Legend
1 Front Body Harness to Global Positioning System Harness
Connector (X207)
2 Radio Front Speaker Dash Upper Connector (B112 – L)
3 Front Body Harness to Powertrain Harness Connector
(X206)
4 Instrument Panel Compartment Lamp Connectors (E82)
5 Instrument Panel Compartment Lamp Switch Connectors
(S142)
6 Front Body Harness to Passenger Airbag Harness
Connector (X205)
7 Liftgate Window Release Switch Connector (S161)
8 Radio, Clock & CD Player Connector (A133 – X1)
9 Hazard Warning Switch Connector (S120)
10 Auxiliary Gauges Connector (P2)
11 Ambient Light Sensor Connector (B55)
12 Blower Motor & A/C Compressor Connector (A14 – X1)
13 Trip Odometer Reset Switch Connector (S237)
14 Inside Air Temperature Sensor Connector (B59)
15 Stop Lamp, Traction & Cruise Control Release Switch
Connector (S220 – X3)
16 Stop Lamp, Traction & Cruise Control Release Switch
Connector (S220 – X1)
17 Ignition & Start Switch Connector (S149 – X1)
18 Instruments Connector (P3)
19 Headlamp Automatic Control Switch Connector (S125)
20 Radio Front Speaker Dash Upper Connector (B112 – R)
21 Endgate Diode 3 Connector (V5)
22 Accelerator Pedal Position Sensor Connector (B22)
23 Endgate Diode 2 Connector (V5)
24 Right-hand Front Stepwell Lamp Connector (E105)
25 Front Body Harness to Body Wiring Harness Connector
(X200)
26 Front Body Harness to Body Wiring Harness Connector
(X201)
27 Wiring (Diagnostics) Connector (X40)
28 Windshield Wiper Dwell Module Connector (A121)
29 Ignition Lock Cylinder Bulb Connector (E30)
30 Ignition & Start Switch Connector (S149 – X2)
31 Windshield Wiper and Washer Switch Connector (S247)
32 Cruise Control Switch Connector (S43)
33 Turn Signal & Headlamp Switch Connector (S231)
34 Steering Wheel Clock Spring Coil Connector (X116)
35 Ignition & Start Switch Connector (S149 – GP15 – X3)
36 Front Body Harness to Body Wiring Harness Connector
(X303)
37 Accelerometer Connector (B1)
38 Front Body Harness to Console Wiring Harness Connector
(X309)
39 Front Body Harness to Transmission Selector Harness
Connector (X301)
40 Front Cigar Lighter Connector (X113 – F)
41 Radio Ground Terminal (X118 – GP8)
42 Inline to Radio & Mobile Telephone Connector (X155)
43 Blower and Air Inlet Connector (A13)
44 Front Body Harness to Blower Motor Harness Connector
(X204)
45 Left-hand Front Stepwell Lamp Connector (E105)
46 Powertrain Interface Module Connector (A5 – V8)
47 Throttle Actuator Control Module Connector (A111 – X2)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–77
Page 12O–77
3.38 Front Body Harness – 19
Cockpit Module – V6 Engine
Figure 12O – 75
Legend
1 Front Body Harness to Body Wiring Harness Connector
(X200)
2 Front Body Harness to Body Wiring Harness Connector
(X201)
3 Endgate Diode 2 Connector (V5)
4 Endgate Diode 3 Connector (V5)
5 Front Body Harness to Hill Descent Resistor Harness
Connector (X213)
6 Body Control Module
7 Body Control Module Connector (A15 – X1)
8 Body Control Module Connector (A15 – X2)
9 Body Control Module Connector (A15 – X3)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–78
Page 12O–78
3.39 Front Body Harness – 20
Cockpit Module – GEN III V8 Engine
Figure 12O – 76
Legend
1 Front Body Harness to Body Wiring Harness Connector
(X200)
2 Front Body Harness to Body Wiring Harness Connector
(X201)
3 Endgate Diode 2 Connector (V5)
4 Endgate Diode 3 Connector (V5)
5 Body Control Module
6 Body Control Module Connector (A15 – X1)
7 Body Control Module Connector (A15 – X2)
8 Body Control Module Connector (A15 – X3)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–79
Page 12O–79
3.40 Front Body Harness – 21
Cockpit Module
Figure 12O – 77
Legend
1 Attaching Nut – Wiring Harness Retainer to Instrument
Panel
2 Front Body Harness Cable Retainer
A Refer to 3.20 Front Body Harness – 1 for sealing patch
grommet and insert installation.
B Front body harness former attached to instrument panel
cover assembly as shown.
C Front body harness former attached to instrument panel
cover assembly as shown.
D Front body harness former attached to instrument panel
cover assembly as shown.
E Front body harness retainer attached to steering column
bracket as shown.
F Front body harness former attached to instrument panel
cover assembly as shown.
G Front body harness retainer attached to vehicle as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–80
Page 12O–80
3.41 Front Body Harness – 22
V6 Engine – Fuse Block, BCM and PIM
Figure 12O – 78
Legend
1 Instrument Panel Wiring Harness Fuse Block Support
Bracket
2 Instrument Panel Compartment Fuse & Relay Panel (X129)
3 Body Control Module
4 Attaching Screw, Body Control Module Mounting to Support
5 Powertrain Interface Module Connector (A5 – V6)
6 Powertrain Interface Module
A Instrument panel wiring harness fuse block – installed as
shown.
B For installation of relays, fuses and circuit breakers refer to
1 General Information.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–81
Page 12O–81
3.42 Front Body Harness – 23
GEN III V8 Engine – Fuse Block, PIM, TAC and BCM
Figure 12O – 79
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–82
Page 12O–82
Legend
1 Throttle Actuator Control Module
2 Throttle Actuator Control Module Connector (A111 – X2)
3 Powertrain Interface Module Connector (A5 – V8)
4 Powertrain Interface Module
5 Attaching Screw, Body Control Module Mounting to Support
6 Body Control Module
7 Instrument Panel Compartment Fuse & Relay Panel (X129)
8 Instrument Panel Compartment Fuse & Relay Panel Support
Bracket
A Instrument panel wiring harness fuse block installed as
shown.
B For installation of relays, fuses and circuit breakers, refer to
1 General Information.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–83
Page 12O–83
3.43 Front Body Harness – 24
V6 Engine – Steering Column
Figure 12O – 80
Legend
1 Windshield Wiper Dwell Module Connector (A121)
2 Cruise Control Switch Connector (S43)
3 Turn Signal and Headlamp Switch Connector (S231)
4 Steering Wheel Clock Spring Coil Connector (X116)
5 Windshield Wiper and Washer Switch Connector (S247)
6 Clock Spring Harness to Steering Wheel Harness Connector
(S208)
7 Steering Wheel Inflator Restraint Module Connector (A106)
8 Vehicle Steering Angle Sensor Connector (B161)
9 Steering Wheel Harness to Clock Spring Harness Connector
(S208)
10 Steering Wheel Harness to Transmission Control Selector
Harness Connector (X212)
11 Transmission Control Selector Harness to Steering Wheel
Harness Connector (X212)
12 Steering Wheel Horn Connector (S7)
A Front body harness attached to steering column as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–84
Page 12O–84
3.44 Front Body Harness – 25
GEN III V8 Engine – Steering Column
Figure 12O – 81
Legend
1 Windshield Wiper Dwell Module Connector (A121)
2 Cruise Control Switch Connector (S43)
3 Turn Signal and Headlamp Switch Connector (S231)
4 Steering Wheel Clock Spring Coil Connector (X116)
5 Windshield Wiper and Washer Switch Connector (S247)
6 Clock Spring Harness to Steering Wheel Harness Connector
(S208)
7 Steering Wheel Inflator Restraint Module Connector (A106)
A Front body harness attached to steering column as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–85
Page 12O–85
3.45 Front Body Harness – 26
Ignition Lock and Theft Deterrent Receiver
Figure 12O – 82
Legend
1 Front Body Harness
2 Ignition and Start Switch Connector (S149 – X1)
3 Ignition and Start Switch to Ignition Lock Retaining Screw
4 Ground Terminal to Ignition Key Attaching Screw
5 Ignition and Start Switch Terminal (S149 – GP15 – X3)
6 Ignition Lock Housing
7 Ignition and Start Switch Connector (S149 – X2)
8 Ignition Lock
9 Ignition Lock Cylinder Bulb Connector (E30)
10 Ignition Lock Locking Pin
11 Ignition Lock Cylinder Bulb
12 Theft Deterrent Receiver Assembly
13 Coded Key Assembly
14 Coded Key Assembly Attaching Screw
15 Remote Control Transmitter
16 Key
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–86
Page 12O–86
3.46 Front Body Harness – 27
Cruise Control, Stop Lamp Switches, Data Link Connector and Stepw ell Lamps
Figure 12O – 83
Legend
1 Stop Lamp, Traction Control and Cruise Control Release
Switch Connector (S220 – X1)
2 Stop Lamp, Traction Control and Cruise Control Release
Switch Connector (S220 – X3)
3 Cruise Control Release Switch
4 Stop Lamp Switch
5 Wiring (Diagnostics) Connector (X40)
6 Instrument Panel Lower Cover – Right-hand Side
7 Stepwell Lamp
8 Stepwell Lamp Connector (E105 – R)
9 Instrument Panel Lower Cover – Left-hand Side
10 Stepwell Lamp Connector (E105 – L)
A Brake pedal.
B Not fitted on SX6.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–87
Page 12O–87
3.47 Front Body Harness – 28
Accelerator Pedal Position
Figure 12O – 84
Legend
1 Accelerator Pedal Position Sensor Connector (B22) 2 Accelerator Pedal Position Sensor
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–88
Page 12O–88
3.48 Front Body Harness – 29
Auxiliary Gauges
Figure 12O – 85
Legend
1 Auxiliary Gauges Connector (P2) 2 Auxiliary Gauges
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–89
Page 12O–89
3.49 Front Body Harness – 30
Inside Air Temperature Sensor and Floor Console
Figure 12O – 86
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–90
Page 12O–90
Legend
1 Inside Air Temperature Sensor Connector (B59)
2 Inside Air Temperature Sensor Attaching Screw
3 Inside Air Temperature Sensor
4 Accessory Power Socket
5 Accessory Power Connector (X112 – AUX)
6 Rear Cigar Lighter Connector (X113 – R)
7 Rear Cigar Lighter
8 Console Wiring Harness to Front Body Harness Connector
(X309)
9 Front Body Harness to Console Wiring Harness Connector
(X309)
10 Console Wiring Harness
11 Front Cigar Lighter Connector (X113 – F)
12 Console Compartment Lamp Connectors (E16)
13 Console Compartment Lamp Bulb
14 Console Compartment Lamp
15 Console Compartment Lamp Switch
16 Console Compartment Lamp Switch Connectors (S94)
A Harness attached to lower radio bracket as shown.
B Harness attached as shown.
C Harness attached to instrument panel as shown.
D Only on LX6 and LX8.
E Not on SX6.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–91
Page 12O–91
3.50 Front Body Harness – 31
Instrument Cluster Assembly
Figure 12O – 87
Legend
1 Instrument Cluster Attaching Screws (4 places)
2 Instrument Cluster Assembly 3 Instrument Cluster Connector (P3)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–92
Page 12O–92
3.51 Front Body Harness – 32
Air-conditioning and Heating Controls
Figure 12O – 88
Legend
1 Heater and A/C Evaporative Module
2 Attaching Screw (4 places)
3 Radio Carrier
4 Vacuum Manifold Plug
5 Heater and A/C Evaporator Module Connector (A60 – X2)
6 Heater and A/C Evaporator Module Connector (A60 – X1)
7 Control Assembly
8 Heating and A/C Evaporative Module Rod
9 Centre Facia Escutcheon Assembly
10 Attaching Screws (4 places)
11 Electronic Climate Control Module
12 Blower Motor and A/C Compressor Connector (A14 – X1)
13 Blower Motor and A/C Compressor Connector (A14 – X2)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–93
Page 12O–93
3.52 Front Body Harness – 33
Daytime Running Lamp Control
Figure 12O – 89
Legend
1 Daytime Running Lamp Control Module Assembly
2 Daytime Running Lamp Control Connector (A25 – X2)
3 Headlamp Automatic Control Switch
4 Headlamp Automatic Control Switch Connector (S125)
5 Daytime Running Lamp Control Connector (A25 – X1)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–94
Page 12O–94
3.53 Front Body Harness – 34
Instrument Panel Facia Trim Switches
Figure 12O – 90
Legend
1 Headlamp Automatic Control Switch
2 Headlamp Automatic Control Switch Connector (S125)
3 Centre Air Outlet Assembly
4 Attaching Screws (3 places)
5 Hazard Warning Switch
6 Hazard Warning Switch Connector (S120)
7 Trip Odometer Reset Switch Connector (S237)
8 Trip Odometer Reset Switch
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–95
Page 12O–95
3.54 Front Body Harness – 35
Radio Assembly
Figure 12O – 91
Legend
1 Radio, Clock and CD Player Assembly
2 Radio, Clock and CD Player Connector (A133 – X1) 3 Power Antenna Connector (A133 – X2)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–96
Page 12O–96
3.55 Front Body Harness – 36
V6 Engine – Passenger Side Airbag and Radio/Mobile Telephone Connectors
Figure 12O – 92
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–97
Page 12O–97
Legend
1 Front Body Harness to Passenger Air Bag Harness
Connector (X205)
2 Front Body Harness to Global Positioning System Harness
Connector (X207)
3 Inline to Radio and Mobile Telephone Connector (X155)
4 Radio Ground Terminal Attaching Screw
5 Radio Ground Terminal (X118 – GP8)
A Harness former attached to instrument panel cover
assembly as shown (2 places).
B Harness attached to heating, ventilation and air-conditioning
unit as shown.
C Harness attached to instrument panel cover assembly as
shown.
D Instrument panel cover assembly.
E Harness attached to bracket as shown.
F Harness attached to vehicle as shown.
G Harness attached to vehicle as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–98
Page 12O–98
3.56 Front Body Harness – 37
GEN III V8 Engine – Passenger Side Airbag and Radio/Mobile Telephone Connectors
Figure 12O – 93
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–99
Page 12O–99
Legend
1 Front Body Harness to Passenger Air Bag Harness
Connector (X205)
2 Front Body Harness to Global Positioning System Harness
Connector (X207)
3 Inline to Radio and Mobile Telephone Connector (X155)
4 Radio Ground Terminal Attaching Screw
5 Radio Ground Terminal (X118 – GP8)
A Harness former attached to instrument panel cover
assembly as shown (2 places).
B Harness attached to heating, ventilation and air-conditioning
unit as shown.
C Harness attached to instrument panel cover assembly as
shown.
D Instrument panel cover assembly.
E Harness attached to bracket as shown.
F Harness attached to vehicle as shown.
G Harness attached to vehicle as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–100
Page 12O–100
3.57 Front Body Harness – 38
Light Sensor/Key Receiver Module and Instrument Panel Speakers
Figure 12O – 94
Legend
1 Radio Front Speaker Dash Upper Connector (B112)
2 Attaching Screw
3 Radio Front Speaker Dash Upper
4 Carrier Instrument Panel Pad
5 Ambient Light Sensor and Key Receiver Module
6 Ambient Light Sensor and Key Receiver Module Connector
(B55)
A Harness attached to light sensor and key receiver module as
shown.
B Harness attached as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–101
Page 12O–101
3.58 Front Body Harness – 39
HVAC Climate Control (Manual A/C)
Figure 12O – 95
Legend
1 Blower Motor Connector (X126 – BLO – MOT)
2 Blower Motor Harness to Front Body Harness Connector
(X204)
3 Front Body Harness to Blower Motor Harness Connector
(X204)
4 Blower Motor Connector (M3)
5 Blower Motor Resistor Connector (R6)
A Harness attached to body as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–102
Page 12O–102
3.59 Front Body Harness – 40
HVAC Occupant Climate Control (Auto A/C)
Figure 12O – 96
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–103
Page 12O–103
Legend
1 Blower Motor Connector (X126 – BLO – MOT)
2 Blower Motor Harness to Front Body Harness Connector
(X204)
3 Front Body Harness to Blower Motor Harness Connector
(X204)
4 Blower Motor Connector (M3)
5 Blower and Air Inlet Connector (A13)
6 Inside Air Valve Vacuum Solenoid Pack Connector (Y19)
7 Actuator Temperature Valve Connector (Y37 – L)
8 Actuator Temperature Valve Connector (Y37 – R)
9 Duct Air Temperature Sensor (B34)
A Harness attached to body as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–104
Page 12O–104
3.60 Front Body Harness – 41
Instrument Panel Compartment
Figure 12O – 97
Legend
1 Instrument Panel Compartment Lamp Switch Connectors
(S142)
2 Instrument Panel Compartment Lamp Switch
3 Instrument Panel Compartment Lamp Connector (E82)
4 Instrument Panel Compartment Lamp
5 Instrument Panel Compartment Lamp Bulb
6 Liftgate Window Release Switch Connector (S161)
7 Liftgate Window Release Switch
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–105
Page 12O–105
3.61 Front Body Harness – 42
V6 Engine – Interior
Figure 12O – 98
Legend
1 Front Body Harness to Body Wiring Harness Connector
(X303)
2 Yaw Rate Sensor
3 Yaw Rate Sensor Connector (B85)
A Front body harness attached to tunnel as shown.
B Front body harness attached to tunnel as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–106
Page 12O–106
3.62 Front Body Harness – 43
GEN III V8 Engine – Interior
Figure 12O – 99
Legend
1 Front Body Harness to Body Wiring Harness Connector
(X303)
2 Accelerometer Module
3 Accelerometer Module Connector (B1)
A Front body harness attached to tunnel as shown.
B Front body harness attached to tunnel as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–107
Page 12O–107
3.63 Front Body Harness – 44
Transmission Selector Connectors
Figure 12O – 100
Legend
1 PRNDL Selector Housing
2 Automatic Transmission Shift Program Switch Connector
(S22)
3 Front Body Harness to Transmission Selector Harness
Connector (X301)
4 Transmission Selector Harness to Front Body Harness
Connector (X301)
5 Electronic Traction Control Switch Connector (S73)
6 Automatic Transmission Control Position Indicator Lamp
Connector (E125)
7 Automatic Transmission Down Shift Connector (S18)
8 Hill Descent Control (HDC) Switch
9 Hill Descent Control (HDC) Switch Connector (S25)
10 ESP Switch
11 ESP Switch Connector (S73)
A Automatic transmission selector.
B Automatic transmission selector with remote transmission
shift.
C Front of vehicle.
Note: When remote transmission shift is optioned, electronic
traction control switch S73 is moved from the transmission
selector harness to the front body harness.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–108
Page 12O–108
3.64 Body Wiring Harness – 1
V6 Engine – Interior
Figure 12O – 101
Legend
1 Body Wiring Harness to Front Body Harness Connector
(X303)
2 Ground Terminal (X118 – GP12)
3 Body Wiring Harness Ground Terminal Attaching Screw
4 Ground Terminal (X118 – GP11)
5 Inflation Restraint Sensor Connector (A65)
6 Park Brake Switch Connector (S181)
7 Side Window (Master) Switch Connector (S222)
A Front of vehicle.
B Body wiring harness attached to tunnel as shown.
C Lead clipped as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–109
Page 12O–109
3.65 Body Wiring Harness – 2
GEN III V8 Engine – Interior
Figure 12O – 102
Legend
1 Body Wiring Harness to Front Body Harness Connector
(X303)
2 Ground Terminal (X118 – GP12)
3 Body Wiring Harness Ground Terminal Attaching Screw
4 Ground Terminal (X118 – GP11)
5 Inflation Restraint Sensor Connector (A65)
6 Park Brake Switch Connector (S181)
7 Side Window (Master) Switch Connector (S222)
A Front of vehicle.
B Body wiring harness attached to tunnel as shown.
C Lead clipped as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–110
Page 12O–110
3.66 Body Wiring Harness – 3
Interior
Figure 12O – 103
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–111
Page 12O–111
Legend
1 Body Wiring Harness
2 Door Ajar Indicator Switch Connector (S156)
3 Body Wiring Harness to Left-hand Front Door Wiring
Harness Connector (X500)
4 Front Side Turn Signal Lamp Connector (E75 – L)
5 Radio Power Antenna Connector (W6 – X1)
6 Side Air Bag Harness to Body Wiring Harness Connector
(X307 – R)
7 Body Wiring Harness to Side Air Bag Harness Connector
(X307 – R)
8 Power Seat Harness to Body Wiring Harness Connector
(X302)
9 Body Wiring Harness to Power Seat Harness Connector
(X302)
10 Seat Belt Pre-tensioner Connector (Y128 – R)
11 Power Seat Harness to Body Wiring Harness Connector
(X315)
12 Body Wiring Harness to Power Seat Harness Connector
(X315)
13 Power Seat Harness to Body Wiring Harness Connector
(X308)
14 Body Wiring Harness to Power Seat Harness Connector
(X308)
15 Seat Belt Pre-tensioner Connector (Y129 – L)
16 Side Air Bag Harness to Body Wiring Harness Connector
(X306 – L)
17 Body Wiring Harness to Side Air Bag Harness Connector
(X306 – L)
A Body wiring harness attached to underbody as shown (6
places).
B Attach body wiring harness to shroud side panel (2 places).
C Harness clipped to underbody as shown (4 places).
D Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–112
Page 12O–112
3.67 Body Wiring Harness – 4
Interior
Figure 12O – 104
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–113
Page 12O–113
Legend
1 Rear Object Sensor Control Module
2 Rear Object Sensor Control Module Connector (A98)
3 Body Wiring Harness
4 Rear Object Sensor Alarm
5 Rear Object Sensor Alarm Connector (H31)
6 Body Wiring Harness to Right-hand Tail Lamp Harness
Connector (X903)
7 Right-hand Tail Lamp Harness to Body Wiring Harness
Connector (X903)
8 Right-hand Tail Lamp Harness
9 Body Wiring Harness Ground Lead Terminal (X118 – GP13)
10 Ground Voltage Drop Connector (X148)
11 Left-hand Tail Lamp Harness
12 Left-hand Tail Lamp Harness to Body Wiring Harn ess
Connector (X904)
13 Body Wiring Harness to Left-hand Tail Lamp Harness
Connector (X904)
A Only on SX6 and CX6 vehicles.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–114
Page 12O–114
3.68 Body Wiring Harness – 5
Interior
Figure 12O – 105
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–115
Page 12O–115
Legend
1 Rear Floor Panel Front
2 End Gate Harness
3 Body Wiring Harness
4 End Gate Harness to Body Wiring Harness Connector
(X902)
5 End Gate Harness to Body Wiring Harness Connector
(X901)
6 Body Wiring Harness to End Gate Harness Connector
(X901)
7 Tail Lamp Harness to Body Wiring Harness Connector
(X903 – R)
8 Body Wiring Harness to Tail Lamp Harness Connector
(X903 – R)
9 Body Wiring Harness Ground Tail Lamp Terminal
(X118 – GP13)
10 Body Wiring Harness to End Gate Harness Connector
(X902)
11 Quarter Inner Lower Rear Extension
12 Ground Terminal Attaching Screw
13 Body Wiring Harness to Tail Lamp Harness Connector
(X904 – L)
14 Rear Compartment Courtesy Lamp Connectors (E36)
A Body wiring harness clipped to inner side panel – right-hand
side (7 places).
B End gate harness clipped to inner side panel (3 places).
C Body wiring harness clipped to inner side panel (4 places).
D Body wiring harness clipped to rear floor panel front.
E Body wiring harness clipped to rear roof frame (4 places).
F Provision for electric brake unit.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–116
Page 12O–116
3.69 Body Wiring Harness – 6
Interior
Figure 12O – 106
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–117
Page 12O–117
Legend
1 Body Wiring Harness
2 Body Wiring Harness to Reverse Parking Aid Harness
Connector (X905)
3 Body Wiring Harness to Trailer Plug Harness Connector
(X909)
4 Inline to Reverse Parking Aid Harness Connector (X156)
5 Body Wiring Harness to Body Wiring Harness Trailer A
Connector (X907)
6 Body Wiring Harness to Body Wiring Harness Trailer B
Connector (X907)
7 Body Wiring Harness to Body Wiring Harness Tow Hook A
Connector (X906)
8 Body Wiring Harness to Body Wiring Harness Tow Hook B
Connector (X906)
9 Reverse Parking Aid Harness to Body Wiring Harness
Connector (X905)
10 Reverse Parking Aid Harness
11 Trailer Plug Harness
12 Trailer Plug Harness to Body Wiring Harness Connector
(X909)
13 Rear Object Sensor Assembly
14 Rear Object Sensor Connector (B133)
15 Rear Object Sensor Ring
16 Rear Object Sensor Housing
17 Trailer Harness Connector (X109)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–118
Page 12O–118
3.70 Body Wiring Harness – 7
Level Ride
Figure 12O – 107
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–119
Page 12O–119
Legend
1 Level Ride Supression Diode Connector (V5)
2 Body Wiring Harness
3 Auto Level Control Module Connector (A8 – SNSR)
4 Level Ride Harness
5 Body Wiring Harness to Level Ride Harness Connector
(X401)
6 Level Ride Harness to Body Wiring Harness Connector
(X401)
7 Auto Level Control Module Connector (A8 – COMP)
8 Rear Wheel Speed Sensor Connector (B76)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–120
Page 12O–120
3.71 Body Wiring Harness – 8
Speakers
Figure 12O – 108
Legend
1 Front Door Radio Speaker Assembly
2 Front Door Radio Speaker Mounting Box Assembly
3 Front Door Radio Speaker Connector (B108)
4 Rear Door Radio Speaker Assembly
5 Rear Door Radio Speaker Mounting Box Assembly
6 Rear Door Radio Speaker Connector (B117)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–121
Page 12O–121
3.72 Body Wiring Harness – 9
Figure 12O – 109
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–122
Page 12O–122
Legend
1 Radio Rear Speaker Amplifier
2 Body Wiring Harness
3 Radio Rear Speaker Amplifier Connector (N6)
4 Radio Rear Speaker Assembly
5 Radio Rear Speaker Assembly Connector (B125)
6 Rear Auxiliary Power Outlet Connector (X112 – AUX)
7 Rear Auxiliary Power Outlet
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–123
Page 12O–123
3.73 Body & Roof Lamp Harnesses – 1
Interior
Figure 12O – 110
Legend
1 Roof Lamp Harness to Visor Lamp Harness Connector
(X310)
2 Roof Lamp Harness
3 Door Ajar Indicator Switch Connector (S156)
4 Body Wiring Harness to Right-hand Rear Door Wiring
Harness Connector (X800)
5 Roof Lamp Harness to Body Wiring Harness Connector
(X300)
6 Body Wiring Harness to Roof Lamp Harness Connector
(X300)
7 Inflation Restraint Side Impact Sensor Connector (A66)
8 Body Wiring Harness to Front Body Harness Connector
(X201)
9 Body Wiring Harness to Front Body Harness Connector
(X200)
10 Door Ajar Indicator Switch Connector (S156)
11 Body Wiring Harness to Right-hand Front Door Wiring
Harness Connector (X600)
12 Body Control Module Connector (A15 – X4)
A Harness clipped to underbody.
For views A to E, refer to 3.74 Body & Roof Lamp Harnesses – 2.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–124
Page 12O–124
3.74 Body & Roof Lamp Harnesses – 2
Interior
Figure 12O – 111
Legend
1 Roof Lamp Harness
2 Body Wiring Harness
3 Inflation Restraint Side Impact Sensor Connector (A66)
4 Body Wiring Harness to Roof Lamp Harness Connector
(X300)
5 Roof Lamp Harness to Body Wiring Harness Connector
(X300)
6 Roof Lamp Harness to Visor Lamp Harness Connector
(X310)
7 Visor Lamp Harness to Roof Lamp Harness Connector
(X310)
8 Door Ajar Indicator Switch
9 Door Ajar Indicator Switch Connector (S156)
10 Body Wiring Harness to Right-hand Front Door Wiring
Harness Connector (X600)
11 Body Wiring Harness to Front Body Harness Connector
(X201)
12 Body Wiring Harness to Front Body Harness Connector
(X200)
13 Body Control Module Connector (A15 – X4)
14 Front Side Turn Signal Lamp Connector (E75 – R)
A Body wiring harness attached to underbody as shown (6
places).
B Front body harness connectors clipped to shroud side panel
as shown.
C Front of vehicle.
For location of views A to E,
refer to 3.73 Body & Roof Lamp Harnesses – 1.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–125
Page 12O–125
3.75 Visor Lamp Harness
Interior
Figure 12O – 112
Legend
1 Sun Shade Lamp Connector (E120)
2 Reading Lamp Connector (E94 – X1)
3 Reading Lamp Connector (E94 – X3)
4 Reading Lamp Connector (E94 – X2)
5 Reading Lamp Assembly
6 Roof Console Lamp Connector (E67)
7 Attaching Screws, Roof Console
8 Roof Console
A Front of vehicle.
B Install lamp with switch facing rear on right-hand side,
forward on left-hand side.
C Only on LX6 and LX8 vehicles.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–126
Page 12O–126
3.76 Endgate Harness – 1
Figure 12O – 113
Legend
1 End Gate Harness
2 End Gate Harness to Heated Rear Window Harness
Connector (X913)
3 Heated Rear Window Harness to End Gate Harn ess
Connector (X913)
4 Heated Rear Window Harness
5 Rear Window Defog Grid Connector (R22 – X1)
6 Rear Window Defog Grid Connector (R22 – X2)
7 Rear Window Defog Grid Earth Lead Terminal (X118 – GP7)
8 Rear Compartment Courtesy Lamp/Theft Deterrent Switch
9 Rear Compartment Courtesy Lamp Switch
Connector (S189 – X1)
10 End Gate Sub Harness
11 Rear Compartment Theft Deterrent Switch
Connector (S189 – X2)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–127
Page 12O–127
3.77 Endgate Harness – 2
Figure 12O – 114
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–128
Page 12O–128
Legend
1 Left-hand Back-up Lamp Connector (E56 – L)
2 End Gate Sub Harness
3 Right-hand Back-up Lamp Connector (E56 – R)
4 End Gate Sub Harness to License Plate Lamp Harness
Connector (X914)
5 License Plate Lamp Harness to End Gate Sub Harness
Connector (X914)
6 License Plate Lamp Harness
7 License Plate Lamp Connector (E44)
8 High Mount Stop Lamp Connector (E79)
9 End Gate Harness
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–129
Page 12O–129
3.78 Endgate Harness – 3
Figure 12O – 115
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–130
Page 12O–130
Legend
1 Rear Window Wiper Module Connector (A122)
2 End Gate Sub Harness
3 Rear Window Wiper Motor Connector (M12)
4 Liftgate Window Release Diode (V5)
5 Liftgate Window Release Actuator Connector (Y7)
6 Liftgate Window Release Switch Connector (S69)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–131
Page 12O–131
3.79 Endgate Harness – 4
Figure 12O – 116
Legend
1 Liftgate Lock Actuator Connector (Y23)
2 End Gate Sub Harness
3 End Gate Sub Harness to End Gate Harness Connector
(X912)
4 End Gate Harness to End Gate S ub Harness Connector
(X912)
5 End Gate Sub Harness to End Gate Harness Connector
(X911)
6 End Gate Harness to End Gate S ub Harness Connector
(X911)
7 End Gate Harness
8 Body Wiring Harness Ground Terminal (X118 – GP14)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–132
Page 12O–132
3.80 Radio Antenna Wiring
Figure 12O – 117
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–133
Page 12O–133
Legend
1 Antenna Lead Panel Blanking Grommet
2 Power Antenna Lead Connector (X209)
3 Radio Power Antenna Connector (W6 – X1)
A Leads clipped to underside of heating, ventilation and
air-conditioning assembly as shown.
B Leads clipped to front side of heating, ventilation and
air-conditioning assembly as shown.
C Leads tucked behind routing post on heating, ventilation and
air-conditioning assembly as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–134
Page 12O–134
3.81 Front Door Wiring Harness – 1
SX6 and CX6
Figure 12O – 118
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–135
Page 12O–135
Legend
1 Outside Rear-view Mirror Motor Connector (M11)
2 Door Lock Switch Connector (S63)
3 Front Door Lock Actuator Connector ( Y13)
4 Front Door Courtesy Lamp Connectors (E72)
5 Front Door Wiring Harness
6 Door Radio Speaker Connector (B108)
7 Body Wiring Harness to Right-hand Front Door Wiring
Harness Connector (X600)
8 Right-hand Front Door Wiring Harness to Body Wiring
Harness Connector (X600)
9 Left-hand Front Door Wiring Harness to Body Wiring
Harness Connector (X500)
10 Body Wiring Harness to Left-hand Front Door Wiring
Harness Connector (X500)
11 Outside Rear-view Mirror Remote Control Switch Connector
(S169)
12 Outside Rear-view Mirror Remote Control Switch
13 Front Door Window Regulator Connector (M10)
A Right-hand door shown.
B Left-hand door shown.
C Front of vehicle.
D Harness clipped to inner door panel as shown.
E Harness routed as shown.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–136
Page 12O–136
3.82 Front Door Wiring Harness – 2
LX6 and LX8
Figure 12O – 119
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–137
Page 12O–137
Legend
1 Right-hand Front Door Wiring Harness to Power Mirror
Harness Connector (X602)
2 Door Lock Switch Connector (S63)
3 Front Side Door Courtesy Lamp Connectors (E72)
4 Front Door Wiring Harness
5 Radio Door Speaker Connector (B108)
6 Body Wiring Harness to Right-hand Front Door Wiring
Harness Connector (X600)
7 Right-hand front Door Wiring Harness to Body Wiring
Harness Connector (X600)
8 Left-hand Front Door Wiring Harness to Body Wiring
Harness Connector (X500)
9 Body Wiring Harness to Left-hand Front Door Wiring
Harness Connector (X500)
10 Front Side Door Courtesy Lamp
11 Rear-view Mirror Memory Module Connector (A73 – X1)
12 Rear-view Mirror Memory Module
A Right-hand door shown.
B Left-hand door shown.
C Harness clipped to door inner panel as shown.
D Harness routed as shown.
For views H to L, refer to 3.83 Front Door Wiring Harness – 3.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–138
Page 12O–138
3.83 Front Door Wiring Harness – 3
LX6 and LX8
Figure 12O – 120
Legend
1 Outside Rear-view Mirror Remote Control Switch
2 Outside Rear-view Mirror Remote Control Switch Connector
(S169)
3 Outside Rear-view Mirror Connector (M11 – X3)
4 Outside Rear-view Mirror Connector (M11 – X2)
5 Outside Rear-view Mirror Connector (M11 – X1)
6 Power Mirror Harness to Left-hand Front Door Wiring
Harness Connector (X502)
7 Left-hand Front Door Wiring Harness to Power Mirror
Harness Connector (X502)
8 Power Mirror Harness to Right-hand Front Door Wiring
Harness Connector (X602)
9 Right-hand Front Door Wiring Harness to Power Mirror
Harness Connector (X602)
10 Front Side Door Lock Actuator Connector (Y13)
11 Front Side Door Window Regulator Connector (M10)
A Front of vehicle.
For location of views H to J,
refer to 3.82 Front Door Wiring Harness – 2.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–139
Page 12O–139
3.84 Rear Door Wiring Harness
Figure 12O – 121
Legend
1 Side Window Switch Connector (S221)
2 Rear Door Lock Actuator Connector (Y31)
3 Rear Door Courtesy Lamp Connectors (E99)
4 Rear Door Window Regulator Connector (M14)
5 Door Wiring Harness
6 Door Radio Speaker Connector (B117)
7 Left-hand Rear Door Wiring Harness Connector to Body
Wiring Harness Connector (X700)
8 Body Wiring Harness to Left-hand Rear Door Wiring
Harness Connector (X700)
9 Body Wiring Harness to Right-hand rear Door Wiring
Harness Connector (X800)
10 Right-hand Rear Door Wiring Harness to Body Wiring
Harness Connector (X800)
11 Rear Door Courtesy Lamp
12 Rear Door Window Switch
A Front of vehicle.
B Left-hand door shown.
C Right-hand door shown.
D Typical (8 places).
E Door wiring harness clipped to door inner panel as shown.
F Door wiring harness clipped to door inner panel.
G Rear door inner seal pierced and then door harness clipped
to rear door inner panel (2 places).
H Rear door courtesy lamp connectors (E99) are taped back
when not used.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–140
Page 12O–140
3.85 Sunroof System Wiring
Figure 12O – 122
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–141
Page 12O–141
Legend
1 Sunroof Switch Connector (S228)
2 Sunroof Control Harness
3 Sunroof Control Harness to Sunroof Harness
Connector (X321)
4 Sunroof Harness to Sunroof Control Harness
Connector (X321)
5 Sunroof Harness
6 Sunroof Switch Assembly
7 Sunroof Power Harness
8 Sunroof Control Module Connector (A108 – X1)
9 Sunroof Control Module
10 Sunroof Control Module Connector (A108 – X2)
11 Sunroof Motor Assembly
12 Sunroof Control Module Connector (A108 – X3)
13 Sunroof Control Module Ground Terminal (X118 – GP16)
14 Sunroof Control Module Ground Terminal Attaching Screw
15 Sunroof Power Harness to Body Wiring Harness
Connector (X322)
16 Body Wiring Harness to Sunroof Power Harness
Connector (X322)
17 Body Wiring Harness
A Front of vehicle.
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–142
Page 12O–142
3.86 9C1 Option – 1
Figure 12O – 123
Legend
1 Auxiliary Negative Terminal (X86 – F)
2 Auxiliary Positive Terminal (X86 – E)
3 Fuse Block Assembly (X126 – AUX)
4 Interior Lights Over-ride Switch Connector (S156 – 9C1)
5 Fuse Block (X133)
6 Fuse (X7)
7 Roof Lamp Harness to Lights Out Harness Connector
(X317)
8 Lights Out Harness to Roof Lamp Harness Connector
(X317)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–143
Page 12O–143
3.87 9C1 Option – 2
V6 Engine
Figure 12O – 124
Legend
1 Battery Negative Cable Junction Block Connector
(X91 – AUX4)
2 Battery Positive Cable Junction Block Connector
(X89 – AUX1)
3 Battery Negative Cable Junction Block Connector
(X91 – AUX3)
4 Battery Positive Cable Junction Block Connector
(X89 – AUX2)
5 Auxiliary Battery Harness Junction Block (X94)
Fuses, Relays and Wiring Harnesses – AWD Wagon Page 12O–144
Page 12O–144
3.88 9C1 Option – 3
GEN III V8 Engine
Figure 12O – 125
Legend
1 Battery Negative Cable Junction Block Connector
(X91 – AUX4)
2 Battery Positive Cable Junction Block Connector
(X89 – AUX1)
3 Battery Negative Cable Junction Block Connector
(X91 – AUX3)
4 Battery Positive Cable Junction Block Connector
(X89 – AUX2)
5 Auxiliary Battery Harness Junction Block (X94)