Fuses, Relays and Wiring Harnesses Page 12O–1
Page 12O–1
Section 12O
Fuses, Relays and Wiring Harnesses - Coupe
ATTENTION
Before performing any service operation or other procedure described in this Section, refer to Section 00
Warnings, Cautions and Notes for correct workshop practices with regard to safety and/or property damage.
1 General Information ...............................................................................................................................4
1.1 Fuses ...................................................................................................................................................................... 4
1.2 Circuit Breakers..................................................................................................................................................... 7
1.3 Fusible Links.......................................................................................................................................................... 8
1.4 Relays ................................................................................................................................................................... 10
Passenger Compartment Relays........................................................................................................................ 10
Engine Compartment Relays.............................................................................................................................. 11
1.5 Diodes................................................................................................................................................................... 12
1.6 Wiring Harnesses................................................................................................................................................. 13
1.7 Wiring Harness Connectors................................................................................................................................ 14
1.8 Electronic Control Device Locations ................................................................................................................. 15
2 Service Operations...............................................................................................................................20
2.1 Fuses .................................................................................................................................................................... 20
Passenger Compartment Fuse and Relay Panel Assembly.............................................................................20
Replace............................................................................................................................................................ 20
Engine Compartment Fuse and Relay Panel Assembly................................................................................... 21
Replace............................................................................................................................................................ 21
2.2 Circuit Breakers................................................................................................................................................... 22
Remove................................................................................................................................................................. 22
Test ....................................................................................................................................................................... 22
Reinstall................................................................................................................................................................ 22
2.3 Fusible Links........................................................................................................................................................ 23
All Plug-in Type Fusible Links Except F104...................................................................................................... 23
Replace............................................................................................................................................................ 23
Plug-in Type Fusible Link F104 ................................................................................................. ......................... 24
Replace............................................................................................................................................................ 24
One-Wire Type Fusible Link................................................................................................................................ 25
Replace............................................................................................................................................................ 25
2.4 Relays ................................................................................................................................................................... 26
Passenger Compartment Relays........................................................................................................................ 26
Replace............................................................................................................................................................ 26
Engine Compartment Relays.............................................................................................................................. 27
Remove............................................................................................................................................................ 27
2.5 Diodes................................................................................................................................................................... 28
A/C Compressor Suppression Diode................................................................................................................. 28
Remove............................................................................................................................................................ 28
Test.................................................................................................................................................................. 28
Reinstall ........................................................................................................................................................... 28
2.6 Wiring Repairs...................................................................................................................................................... 29
Techline
Fuses, Relays and Wiring Harnesses Page 12O–2
Page 12O–2
3 Wiring Installation Diagrams...............................................................................................................30
3.1 Battery Wiring Harness – 1 ................................................................................................................................. 30
3.2 Battery Wiring Harness – 2 ................................................................................................................................. 31
3.3 Powertrain Harness – 1 ....................................................................................................................................... 32
3.4 Powertrain Harness – 2 ....................................................................................................................................... 33
3.5 Powertrain Harness – 3 ....................................................................................................................................... 34
3.6 Powertrain Harness – 4 ....................................................................................................................................... 35
3.7 Powertrain Harness – 5 ....................................................................................................................................... 36
Automatic Transmission..................................................................................................................................... 36
3.8 Powertrain Harness – 6 ....................................................................................................................................... 37
Automatic Transmission..................................................................................................................................... 37
3.9 Powertrain Harness – 7 ....................................................................................................................................... 39
Manual Transmission .......................................................................................................................................... 39
3.10 Powertrain Harness – 8 ....................................................................................................................................... 40
Manual Transmission .......................................................................................................................................... 40
3.11 Front Body Harness – 1....................................................................................................................................... 42
Engine Compartment........................................................................................................................................... 42
3.12 Front Body Harness – 2....................................................................................................................................... 43
Protector Assembly, Brake Master Cylinder and Booster................................................................................ 43
3.13 Front Body Harness – 3....................................................................................................................................... 44
Under Hood Fuse and Relay Panel and Wiper Motor ....................................................................................... 44
3.14 Front Body Harness – 4....................................................................................................................................... 45
Body Ground and Washer Pump........................................................................................................................ 45
3.15 Front Body Harness – 5....................................................................................................................................... 46
Headlamp, Park Lamp and Turn Indicator......................................................................................................... 46
3.16 Front Body Harness – 6....................................................................................................................................... 47
Fans, Ambient Sensor and Theft Deterrent Connectors .................................................................................. 47
3.17 Front Body Harness – 7....................................................................................................................................... 48
Ambient Sensor, Fan and Theft Deterrent Connectors .................................................................................... 48
3.18 Front Body Harness – 8....................................................................................................................................... 49
Front Lamps, Fog Lamps and Horn Connectors............................................................................................... 49
3.19 Front Body Harness – 9....................................................................................................................................... 50
ABS, Air Intake and Front Wheel Speed Sensor............................................................................................... 50
3.20 Front Body Harness – 10..................................................................................................................................... 51
Cockpit Module.................................................................................................................................................... 51
3.21 Front Body Harness – 11..................................................................................................................................... 53
Cockpit Module.................................................................................................................................................... 53
3.22 Front Body Harness – 12..................................................................................................................................... 54
Cockpit Module.................................................................................................................................................... 54
3.23 Front Body Harness – 13..................................................................................................................................... 55
Fuse Block, PIM, TAC and BCM.......................................................................................................................... 55
3.24 Front Body Harness – 14..................................................................................................................................... 57
Steering Column.................................................................................................................................................. 57
3.25 Front Body Harness – 15..................................................................................................................................... 58
Ignition Lock and Theft Dete rrent Receiver....................................................................................................... 58
3.26 Front Body Harness – 16..................................................................................................................................... 59
Manual Transmission – Cruise Control, Stop Lamp Switches, Data Link Connector
and Stepwell Lamps....................................................................................................................................... 59
3.27 Front Body Harness – 17..................................................................................................................................... 60
Automatic Transmission – Cruise Control, Stop Lamp Switches, Data Link Connector
and Stepwell Lamps....................................................................................................................................... 60
3.28 Front Body Harness – 18..................................................................................................................................... 61
Accelerator Pedal Position ................................................................................................................................. 61
3.29 Front Body Harness – 19..................................................................................................................................... 62
Inside Air Temperature Sensor and Floor Console .......................................................................................... 62
3.30 Front Body Harness – 20..................................................................................................................................... 63
Instrument Cluster Assembly............................................................................................................................. 63
Fuses, Relays and Wiring Harnesses Page 12O–3
Page 12O–3
3.31 Front Body Harness – 21..................................................................................................................................... 64
Air-conditioning and Heating Controls.............................................................................................................. 64
3.32 Front Body Harness – 22..................................................................................................................................... 65
Instrument Panel Facia Trim Switches .............................................................................................................. 65
3.33 Front Body Harness – 23..................................................................................................................................... 66
Auxiliary Gauges.................................................................................................................................................. 66
3.34 Front Body Harness – 24..................................................................................................................................... 67
Radio Assembly................................................................................................................................................... 67
3.35 Front Body Harness – 25..................................................................................................................................... 68
Passenger Side Airbag and Radio/Mobile Tele phone Conne c tors.................................................................. 68
3.36 Front Body Harness – 26..................................................................................................................................... 70
Light Sensor/Key Receiver Module and Instrument Panel Speakers.............................................................. 70
3.37 Front Body Harness – 27..................................................................................................................................... 71
HVAC Occupant Climate Control........................................................................................................................ 71
3.38 Front Body Harness – 28..................................................................................................................................... 73
Instrument Panel Compartment.......................................................................................................................... 73
3.39 Front Body Harness – 29..................................................................................................................................... 74
Interior .................................................................................................................................................................. 74
3.40 Front Body Harness – 30..................................................................................................................................... 75
Transmission Selector Connectors .................................................................................................................... 75
3.41 Body Wiring Harness – 1..................................................................................................................................... 76
3.42 Body Wiring Harness – 2..................................................................................................................................... 77
Interior .................................................................................................................................................................. 77
3.43 Body Wiring Harness – 3..................................................................................................................................... 78
Interior .................................................................................................................................................................. 78
3.44 Body Wiring Harness – 4..................................................................................................................................... 79
Interior .................................................................................................................................................................. 79
3.45 Body Wiring Harness – 5..................................................................................................................................... 80
Rear Compartment............................................................................................................................................... 80
3.46 Body Wiring Harness – 6..................................................................................................................................... 81
Rear Compartment Lid........................................................................................................................................ 81
3.47 Body Wiring Harness – 7..................................................................................................................................... 82
Rear Compartment............................................................................................................................................... 82
3.48 Body Wiring Harness – 8..................................................................................................................................... 83
Rear Compartment............................................................................................................................................... 83
3.49 Body Wiring Harness – 9..................................................................................................................................... 84
Rear Compartment, Fuel Tank and ABS............................................................................................................ 84
3.50 Body Wiring Harness – 10................................................................................................................................... 85
Speakers and Radio Amplifier............................................................................................................................ 85
3.51 Body Wiring Harness – 11................................................................................................................................... 86
Rear Park Assist .................................................................................................................................................. 86
3.52 Body & Visor Lamp Harnesses – 1..................................................................................................................... 87
Interior .................................................................................................................................................................. 87
3.53 Body & Visor Lamp Harnesses – 2..................................................................................................................... 88
Interior .................................................................................................................................................................. 88
3.54 Visor Lamp Harness ............................................................................................................................................ 89
Interior .................................................................................................................................................................. 89
3.55 Radio Antenna Wiring – 1 ................................................................................................................................... 90
3.56 Radio Antenna Wiring – 2 ................................................................................................................................... 91
Antenna and Rear Window Defog ...................................................................................................................... 91
3.57 Door Wiring Harness........................................................................................................................................... 93
3.58 Navigation System Wiring – 1............................................................................................................................. 94
3.59 Navigation System Wiring – 2............................................................................................................................. 95
Fuses, Relays and Wiring Harnesses Page 12O–4
Page 12O–4
1 General Information
All electrical circuits are protected again st da mage that might occur due to short circuits or overloads in the wiring system
by fuses, circuit breakers, fusible links and relays.
1.1 Fuses
Fuses are a blade type mini construction, with the current
rating in amps indicated on the top of the fuse assembly,
above the element, or identified by the plastic body colour of
the fuse. The fuse current ratings and corres ponding colour
are listed in the following table.
Figure 12O – 1
Current Rating
(Amps) Fuse Colour
3 Violet
5 Tan
7.5 Brown
10 Red
15 Blue
20 Yellow
25 White
30 Green
Fuses are located in two positions on the vehicle. One group is located in the passenger compartment fuse and relay
panel assembly. Refer to Figure 12O – 2. A label on the inside of the instrument panel lower cover indicates the circuits
protected by each fuse.
Fuses, Relays and Wiring Harnesses Page 12O–5
Page 12O–5
Figure 12O – 2
Legend
1 F4 – Park Lamps Fuse (10A)
2 F5 – Stop Lamps Fuse (15A)
3 F6 – Interior Illumination Fuse (10A)
4 F7 – Hazard Lamps Fuse (15A)
5 F8 – Spare
6 F9 – Horn Fuse (15A)
7 F10 – Ignition Fuse (7.5A)
8 F11 – Instrument Illumination Fuse (7.5A)
9 F12 – Turn Signals & Back-up Lamps Fuse (15A)
10 F13 – Heated Rear Window, HVAC & Instruments Fuse
(7.5A)
11 F14 – Cigar Lighter Fuse (20A)
12 F15 – Cruise Control & Power Mirrors Fuse (10A)
13 F16 – Radio, Navigation & Cell Phone Fuse (7.5A)
14 F17 – Accessory Socket Fuse (20A)
15 F18 – Wiper Washer Fuse (20A)
16 F19 – Spare
17 F20 – Power Locks, Power Windows & Theft Horn Fuse
(15A)
18 F21 – Instruments & Climate Control Fuse (10A)
19 F22 – Heated Rear Window & Blower Fan Fuse (30A)
20 F23 – Radio, Cell Phone & Navigation Fuse (15A)
21 F24 – Sub-woofer Amplifier Fuse (20A)
22 F25 – Spare
23 F26 – SRS Fuse (15A)
24 F27 – ABS & TCS Fuse (10A)
Fuses, Relays and Wiring Harnesses Page 12O–6
Page 12O–6
The second group of fuses ar e located in the engine compartment fuse and relay panel assembly, situated forward of
the right-hand side front suspension strut tower. A label on the insid e of the pan el cover indicates the circuits protected
by each fuse. Refer to Figure 12O – 3.
Figure 12O – 3
Legend
1 F36 – ABS & TCS Fuse (25A)
2 F37 – Spare
3 F38 – Spare
4 F39 – TAC Module Fuse (15A)
5 F28 – Fuel Pump Fuse (15A)
6 F29 – Engine & BCM Fuse (10A)
7 F30 – Right-hand Headlamp Fuse (20A)
8 F31 – Left-hand Headlamp Fuse (20A)
9 F32 – Automatic Transmission Fuse (15A)
10 F33 – Engine Sensors Fuse (15A)
11 F34 – Fuel Injectors & Ignition Modules Fuse (15A)
12 F35 – Fuel Injectors & Ignition Modules Fuse (15A)
Fuses, Relays and Wiring Harnesses Page 12O–7
Page 12O–7
1.2 Circuit Breakers
A circuit breaker is a circuit protection device that will trip
when the circuit current exceeds its rating. The circuit
breaker is activated by heat and will reset after being
allowed to cool. The circuit breaker has a limited number of
tripping cycles before its tripping time will change. The
circuit breaker will continue to open a nd close until the
cause of the excess current is corrected.
Figure 12O – 4
All the circuit breakers are located in the passenger compartment fuse and relay panel assembly and have a 20A current
rating. A label on the inside of the panel cove r indicates the circuits protected by each circuit break er.
Refer to Figure 12O – 5.
Figure 12O – 5
Legend
1 F1 – Power Windows Circuit Breaker (20A)
2 F2 – Power Seats Circuit Breaker (20A) 3 F3 – Spare
Fuses, Relays and Wiring Harnesses Page 12O–8
Page 12O–8
1.3 Fusible Links
The chassis and engine electrical wiring is protected against
short circuit damage by fusible links.
Plug-in type fusible links (1) have an insp ection window (2)
that allows a visual check of the condition of the element (3).
Figure 12O – 6
The plug-in type fusible links are located in the engine compartment fuse and relay panel assembly. Refer to
Figure 12O – 7 for the location and usag e of the fusible links. A label on the inside of the panel cover indicates the
circuits protected by each fusible li nk.
Figure 12O – 7
Legend
1 F101 – Engine Cooling Large Fan (30A)
2 F102 – Lighting (60A)
3 F103 – Anti-lock Brakes (60A)
4 F104 – Engine (60A)
5 F105 – Main (60A)
6 F106 – Blower Fan (40A)
7 F107 – Engine Cooling Small Fan (30A)
Fuses, Relays and Wiring Harnesses Page 12O–9
Page 12O–9
A one-wire type fusible link, c onsisting of an insulated fuse
wire (1) is attached to the battery harness with cable ties.
This is integrated as part of the battery harne ss and is
located adjacent to the battery harness positive terminal.
Figure 12O – 8
Fuses, Relays and Wiring Harnesses Page 12O–10
Page 12O–10
1.4 Relays
There are a variety of relay assemblies (1) used in the vehicle. The relays a r e located in the engine compartment and
passenger compartment fuse and relay panel assemblies.
Figure 12O – 9
Passenger Compartment Relays
The passenger compartment fuse an d relay panel assembly is located behind the instrument panel lower cover. A label
on the inside of the cover indicates the relay location and the circuits protected by each relay. Refer to Figure 12O – 10.
Figure 12O – 10
Legend
1 R17 – Spare
2 R18 – Relay Assembly – Park Lamps (4 Pin Micro)
3 R19 – Flasher Assembly – Turn Signal (3 Pin)
4 R20 – Relay Assembly – Accessory Control (4 Pin Mini)
5 R21 – Relay Assembly – Ignition Control (4 Pin Mini)
6 R22 – Relay Assembly – Power Windows (4 Pin Mini)
7 R23 – Relay Assembly – Blower Inhibit (4 Pin Mini)
8 R24 – Relay Assembly – Interior Illumination (4 Pin Mini)
9 R25 – Spare
10 R26 – Spare
11 R27 – Spare
Fuses, Relays and Wiring Harnesses Page 12O–11
Page 12O–11
Engine Compartment Relays
The engine compartment fuse and re lay panel assembly is located forward of the right-hand side front suspension strut
tower. A label on the inside of the cover lists the relay location and the circuits protected by each relay.
Refer to Figure 12O – 11.
Figure 12O – 11
Legend
1 R1 – Start Relay (4 Pin)
2 R2 – Blower Relay (4 Pin)
3 R3 – Defog Relay (4 Pin)
4 R4 – Engine Control Relay (4 Pin)
5 R5 – Engine Cooling Fan Relay 2 – High Speed (4 Pin)
6 R8 – Horn Relay (4 Pin Micro)
7 R9 – Spare
8 R12 – Headlamp Hi-beam Relay (4 Pin)
9 R10 – Fog Lamp Relay (4 Pin Micro)
10 R13 – Spare
11 R16 – Fuel Pump Relay (4 Pin Micro)
12 R15 – Spare
13 R11 – A/C Relay (4 Pin Micro)
14 R14 – Headlamp Lo-beam Relay (4 Pin Micro)
15 R7 – Engine Cooling Fan Relay 1 – Lo Speed (5 Pin)
16 R6 – Spare
Fuses, Relays and Wiring Harnesses Page 12O–12
Page 12O–12
1.5 Diodes
All vehicles with air conditioning have an air-conditioning
compressor clutch suppressio n dio de (1) fitted to the engine
harness.
For location of the air-conditioning compressor clutch
feedback diode, refer to the following figure:
Figure 12O – 42, item 6.
Figure 12O – 12
Fuses, Relays and Wiring Harnesses Page 12O–13
Page 12O–13
1.6 Wiring Harnesses
Refer to Figure 12O – 13 for the location of the wiring harnesses used in the vehicle. For a detailed layout of the various
wiring harnesses and connectors, refer to 3 Wiring Installati on Diagrams.
Figure 12O – 13
Legend
1 Battery Wiring Harness
2 Front Body Harness
3 Right-hand Door Wiring Harness
4 Visor Lamp Harness
5 Body Wiring Harness
6 Reverse Parking Aid Harness
7 Left-hand Door Wiring Harness
8 Powertrain Harness
Fuses, Relays and Wiring Harnesses Page 12O–14
Page 12O–14
1.7 Wiring Harness Connectors
The majority of the wiring har ness connectors used are of an interlocking design.
The male and female connector bodies, when pushed together, cannot be pulled apart due to the presence of a locking
tang on the connector body. Some connectors have anti-backout combs fitted for increased connector terminal security.
Fuses, Relays and Wiring Harnesses Page 12O–15
Page 12O–15
1.8 Electronic Control Device Locations
The following figures illustrate the locati on of the various electronic control devices fitted.
Ensure the precautionary and special handling instructions are followed (where applicable) for each electronic control
device as described in the corresponding sections.
Figure 12O – 14
Legend
1 Fusible Links – Engine compartment
2 Relays & Fuses – Engine compartment
3 Relays & Fuses – Instrument Panel
4 Body Control Module
5 Steering Wheel Radio & CD Player Controls
6 Climate Control Module
7 Ambient Light Sensor
Fuses, Relays and Wiring Harnesses Page 12O–16
Page 12O–16
Figure 12O – 15
Legend
1 Vehicle Speed Sensor – Manual Transmission
2 Vehicle Speed Sensor – Automatic Transmission
3 ABS & Traction Control Module
4 Powertrain Control Module
5 Powertrain Interface Module & Throttle Actuator Control
Module
Fuses, Relays and Wiring Harnesses Page 12O–17
Page 12O–17
Figure 12O – 16
Legend
1 Sensing & Diagnostic Module – Occupant Protection System
2 Rear Object Sensor Assembly 3 Modular Fuel Pump & Sender Assembly
4 Rear Object Sensor Control Module
Fuses, Relays and Wiring Harnesses Page 12O–18
Page 12O–18
Figure 12O – 17
Legend
1 Rear Speaker Amplifier
2 Radio Assembly
3 Rear Speaker
4 Antenna and Rear Window Defog Unit
5 Rear Quarter Trim Speaker Assembly
6 Theft Deterrent Horn
7 Door Speaker Assembly
Fuses, Relays and Wiring Harnesses Page 12O–19
Page 12O–19
Figure 12O – 18
Legend
1 Navigation System Display Assembly
2 Antenna 3 Navigation Control Processor Assembly
4 Navigation System Speaker
Fuses, Relays and Wiring Harnesses Page 12O–20
Page 12O–20
2 Service Operations
2.1 Fuses
Passenger Compartment Fuse and Relay Panel Assembly
Replace
1 To gain access to the passenger compartment fuse
and relay panel assembly (1) move the steering
column to the upmost position. Firmly grasp the
instrument panel lower cover (4) and pull the cover
downwards to disengage the locating clips (3).
2 Refer to the label (2) on the inside of the instrument
panel lower cover to identify the circu its protected b y
each fuse.
Figure 12O – 19
3 Use the fuse remover (1) located in the passenger
compartment fuse and relay panel assembl y to
remove the suspect fuse. To use, pull the remover
from its location in the panel assembly and f ully insert
the remover over the top of the fuse and pull the fuse
from the panel.
Figure 12O – 20
4 Determine if the fuse has blown by examining the
element for a break:
a A good fuse (1) has an intact element.
b A blown fuse (2) has a broken element.
5 Replace a blown fuse with a fuse of the same current
rating. If the replacement fuse blows rectify the fault
within the circuit before replacing the fus e ag ain.
6 Close the instrument panel lower cover. Ensure the
locating clips are correctly alig ned and slot into the
corresponding mating retainer s securely.
Figure 12O – 21
Fuses, Relays and Wiring Harnesses Page 12O–21
Page 12O–21
Engine Compartment Fuse and Relay Panel Assembly
Replace
1 Remove the engine compartment fuse and relay panel
assembly cover (2) by releasing the retai ning tang (1)
and lifting the cover up and towards the sus pension
strut tower.
2 Refer to the label on the inside cover of the engine
compartment fuse and relay panel assembl y to identify
the circuits protected by each fuse.
3 Use the fuse remover located in the passeng er
compartment fuse and relay panel assembl y to
remove the suspect fuse. Refer to Passenger
Compartment Fuse and Relay Panel Assembly for the
location and usage of the fuse remover.
Figure 12O – 22
4 Determine if the fuse has blown by examining the
element for a break:
a A good fuse (1) has an intact element.
b A blown fuse (2) has a broken element.
5 Replace a blown fuse with a fuse of the same current
rating. If the replacement fuse blows rectify the fault
before replacing the fuse again.
6 Replace the engine compartm ent fuse and relay panel
assembly cover. Ensure the retaining tang locks into
place.
Figure 12O – 23
Fuses, Relays and Wiring Harnesses Page 12O–22
Page 12O–22
2.2 Circuit Breakers
Remove
1 To gain access to the passenger compartment fuse
and relay panel assembly (1) move the steering
column to the upmost position. Firmly grasp the
instrument panel lower cover (4) and pull the cover
downwards to disengage the locating clips (3).
2 Refer to the label (2) on the inside of the instrument
panel lower cover to identify the circu its protected b y
each fuse.
3 Pull the suspect circuit breaker from the passenger
compartment fuse and relay panel assembly.
Figure 12O – 24
Test
1 Remove the circuit breaker as described in this
Section.
2 Perform a continuity check on the circuit breaker. If
there is no continuity wait 15 seconds and check the
circuit breaker again.
a If continuity exists after 15 seconds have
elapsed the circuit breaker has reset and can be
replaced in the passenger compartment fuse
and relay panel assembly. If the circuit breaker
trips again there is a problem within th e circuit it
is protecting and the problem should be rectified
before continuing.
b If there is no continuity after 15 seconds have
elapsed, the circuit breaker has blown and must
be replaced with another circuit breaker of the
same current rating.
3 Install the circuit breaker as described in this Section.
Figure 12O – 25
Reinstall
Replace the passenger compartment fuse and relay panel assembly cover, ensuring the retaining tang locks into place.
Fuses, Relays and Wiring Harnesses Page 12O–23
Page 12O–23
2.3 Fusible Links
All Plug-in Type Fusible Links Except F104
Replace
1 Remove the engine compartment fuse and relay panel
assembly cover by releasing the retaining tang (1) on
the cover (2) and lifting the cover up and towards the
suspension strut tower.
2 Refer to the label on the inside of the engine
compartment fuse and relay panel assembl y cov er to
identify the circuits protected by each fusible link.
Figure 12O – 26
3 Pull the suspect fusible link (1) from the panel
assembly and perform a visual check of the element
(3) through the inspection window (2) to determine
whether or not it has blown.
a A good fusible link has an intact element.
b A blown fusible link has a broken element.
4 Replace a blown fusib le link with one of the same
current rating. If the replacement fusible link blows this
indicates a problem with the circuit it is protecting.
Rectify this fault before replacing the fusible link again.
5 Replace the engine compartm ent fuse and relay panel
assembly cover. Ensure the retaining tang locks into
place. Figure 12O – 27
Fuses, Relays and Wiring Harnesses Page 12O–24
Page 12O–24
Plug-in Type Fusible Link F104
Replace
1 Remove the engine compartment fuse and relay panel
assembly cover by releasing the retaining tang (1) on
the cover (2) and lifting the cover up and towards the
suspension strut tower.
2 Refer to the label on the inside of the engine
compartment fuse and relay panel assembl y cov er to
identify the circuits protected by each fusible link.
Figure 12O – 28
3 Remove the fusible link terminal attaching screw (2)
and pull fusible link F104 (1) from engine compartment
fuse and relay panel assembly (3).
Figure 12O – 29
4 Perform a visual check of the element (3) through the
inspection window (2) to determine whether or not it
has blown.
a A good fusible link has an intact element.
b A blown fusible link has a broken element.
5 Replace a blown fusib le link with another with a 60A
current rating. If the replacement fusible link blows this
indicates a problem within the engine circuitry it is
protecting. Rectify this fault before replacing the
fusible link again.
6 Tighten the fusible link terminal attachi ng screw to the
correct torque specification.
Fusible link terminal attaching
screw torque specification 5.0 – 6.0 Nm
7 Replace the engine compartm ent fuse and relay panel
assembly cover. Ensure the retaining tang locks into
place.
Figure 12O – 30
Fuses, Relays and Wiring Harnesses Page 12O–25
Page 12O–25
One-Wire Type Fusible Link
Replace
1 Disconnect the end of the fusible link (1) further from
the positive battery terminal by cutting the cable tie.
2 Test for a voltage drop between the positive battery
terminal and the end of the fusible link.
a If there is a voltage drop the fusible link has
blown and must be replac ed. If the new fusible
link blows this indicates a fault in the circuit and it
should be rectified before replacing the fusible
link again.
b If there is no voltage drop the fusible link has not
blown and the problem lies elsewhere.
3 Reattach the fusible link to the battery wiring harness.
Use new cable ties to fasten the fusible link to the
battery wiring harness and cut the cable tie ends to a
suitable length.
Figure 12O – 31
Fuses, Relays and Wiring Harnesses Page 12O–26
Page 12O–26
2.4 Relays
Passenger Compartment Relays
Replace
1 To gain access to the passenger compartment fuse
and relay panel assembly (1) move the steering
column to the upmost position. Then firml y grasp the
instrument panel lower cover (4) and pull the cover
downwards to disengage the locating clips (3).
2 Use the label (2) on the insid e of the instrument panel
lower cover to identify the circuits protected by each
relay.
Figure 12O – 32
Figure 12O – 33
3 Pull the suspect relay assembly (1) from the passenger compartment fuse and relay panel assembly by hand and
replace it with a relay of the same type, refer to Figure 12O – 33.
4 If the circuit functions as normal the problem was with the relay and has been rectified.
5 If the circuit does not function as normal or functions for a short time then stops it can be assumed the problem lies
within the circuit and must be rectified before replacing the relay again.
6 Close the instrument panel lower cover. Ensure the locating clips are correctl y aligned and slot into the
corresponding mating retainer s securely.
Fuses, Relays and Wiring Harnesses Page 12O–27
Page 12O–27
Engine Compartment Relays
Remove
1 Remove the engine compartment fuse and relay panel
assembly cover (2) by releasing the retai ning tang (1)
and lifting the cover up and towards the sus pension
strut tower.
2 Refer to the label on the inside cover of the engine
compartment fuse and relay panel assembl y to identify
the circuits protected by each relay.
Figure 12O – 34
Figure 12O – 35
3 Pull the suspect relay assembly (1) from the passenger compartment fuse and relay panel assembly by hand and
replace it with a relay of the same type, refer to Figure 12O – 35.
4 If the circuit function as normal the problem was with the relay and has been rectified.
5 If the circuit does not functions as normal or functions for a short time then stops it can be assumed the problem
lies within the circuit and must be rectified before replacing the relay again.
6 Close the instrument panel lower cover. Ensure the locating clips are correctl y aligned and slot into the
corresponding mating retainer s securely.
Fuses, Relays and Wiring Harnesses Page 12O–28
Page 12O–28
2.5 Diodes
A/C Compressor Suppression Diode
Remove
1 Locate the diode on the engine harness at the
injectors, refer to 1.5 Diodes.
2 Remove the tape securing the diode co nnector to the
wiring harness conduit.
3 Pull back the diode retainer on the diode connector
and use a pair of fine long nosed pliers to pull the
diode out of the connector.
Figure 12O – 36
Test
1 Remove the diode as described in this Section.
2 Select ‘diode testing’ on a digital multimeter (DMM)
probably marked with a diode symbol.
3 Measure the resistance acr oss the diode.
4 Reverse the multimeter probes and measure the
resistance again to determine the condition of the
diode.
a If a finite and an infinite measurement are
obtained the diode does not require
replacement.
b If both measurements are infinite or are both
very low resistances the diode must be replaced.
5 Reinstall the diodes as descri bed in this Section.
Figure 12O – 37
Reinstall
1 Insert the diode into the connector aligning the tab on the side of the diode with the connector retainer.
2 Using suitable tape, secure diode connector to wiring harness conduit.
Fuses, Relays and Wiring Harnesses Page 12O–29
Page 12O–29
2.6 Wiring Repairs
Refer to Section 12P Wiring Diagrams for the service procedures and installation details for wiring harnesses and
connectors.
Fuses, Relays and Wiring Harnesses Page 12O–30
Page 12O–30
3 Wiring Installation Diagrams
3.1 Battery Wiring Harness – 1
Figure 12O – 38
Legend
1 Battery Wiring Harness to Front Body Harness Connector
(X106)
2 Nut
3 Body Ground Terminal (X119 – G3 – GP3)
4 Battery Ground Terminal (X119 – G4 – GP3)
5 Battery Wiring Harness Terminal (X86 – C)
6 Battery Negative Terminal (G1 – X2 – GP1)
7 Nut
8 Battery Positive Terminal Cover
9 Nut
10 Washer
11 Battery Wiring Harness Positive Terminal (G1–X1)
12 Battery Wiring Harness to Starter Motor and Generator
13 Battery Positive Post Assembly (X86 – B)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses Page 12O–31
Page 12O–31
3.2 Battery Wiring Harness – 2
Figure 12O – 39
Legend
1 Battery Wiring Harness Bracket to Engine Mounting Screw
2 Engine Ground Terminal (X119 – GP4)
3 Battery Wiring Harness Ground to Block Screw
4 Battery Wiring Harness Bracket
5 Starter Motor Terminal (M15 – X2)
6 Starter Motor Terminal Attaching Nut
7 Starter Motor Terminal Connector (M15 – X1)
8 Battery Wiring Harness
9 Battery Wiring Harness to Generator B+ Terminal Nut
10 Generator Terminal (G8 – X1)
Fuses, Relays and Wiring Harnesses Page 12O–32
Page 12O–32
3.3 Powertrain Harness – 1
Figure 12O – 40
Legend
1 Fuel Injector Connector (L2)
2 C.P.A. Lock
3 Electronic Ignition Control Module Connector (A40 – L)
4 Canister Purge Solenoid Valve Connector (Y123)
5 Engine Coolant Temperature Sensor Connector (B39)
6 Powertrain Harness to Front Body Harness Connector
(X101)
7 A/C Pressure Sensor Connector (B18)
8 Mass Airflow and Intake Air Temperature Sensor Connector
(B69)
9 Generator Connector (G8 – X2)
Fuses, Relays and Wiring Harnesses Page 12O–33
Page 12O–33
3.4 Powertrain Harness – 2
Figure 12O – 41
Legend
1 Powertrain Harness to Front Body Harness Connector
(X101)
2 A/C Pressure Sensor Connector (B18)
3 Mass Airflow and Intake Air Temperature Sensor Connector
(B69)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses Page 12O–34
Page 12O–34
3.5 Powertrain Harness – 3
Figure 12O – 42
Legend
1 Fuel Injector Connector (L2)
2 A/C Compressor Powertrain Harness Support Bracket
3 A/C Clutch Connector (L7)
4 A/C Compressor Mounting Bolt
5 C.P.A. Lock
6 Suppression Diode, A/C Compressor (V5)
7 Electronic Ignition Control Module Connector (A40 – R)
8 Throttle Actuator Connector (Y38)
9 Ground Terminal Attaching Bolt
10 Powertrain Harness Ground Terminal (X119 – GP5)
Fuses, Relays and Wiring Harnesses Page 12O–35
Page 12O–35
3.6 Powertrain Harness – 4
Figure 12O – 43
Legend
1 Powertrain Harness to Front Body Harness Connector
(X206)
2 Theft Deterrent Horn Connector (B9)
3 Theft Deterrent Horn
4 Powertrain Control Module Connector (A84 – X2)
5 Powertrain Control Module Connector (A84 – X1)
6 Powertrain Control Module
7 Throttle Actuator Control Module Connector (A111 – X1)
8 Throttle Actuator Control Module
A Ensure PCM connector attaching bolts are not over
tightened.
Fuses, Relays and Wiring Harnesses Page 12O–36
Page 12O–36
3.7 Powertrain Harness – 5
Automatic Transmission
Figure 12O – 44
Legend
1 M.A.P. Sensor Connector (B67)
2 Engine Oil Pressure Sensor Connector (B42)
3 Camshaft Position Sensor Connector (B28)
4 Vehicle Speed Sensor Connector (B83)
5 Right-hand Rear O2 Sensor Connector (B58 – RT – RR)
6 Transmission Assembly Connector (X121)
7 Crankshaft Position Sensor Connector (B30)
Fuses, Relays and Wiring Harnesses Page 12O–37
Page 12O–37
3.8 Powertrain Harness – 6
Automatic Transmission
Figure 12O – 45
Fuses, Relays and Wiring Harnesses Page 12O–38
Page 12O–38
Legend
1 Left-hand Front O2 Sensor Connector (B57 – LT – FR)
2 Right-hand Front O2 Sensor Connector (B166 – RT – FR)
3 Powertrain Harness to Knock Sensor Harness Connector
(X107)
4 Engine Ground Terminal (X119 – GP6)
5 Engine Ground Terminal Attaching Bolt
6 Powertrain Harness Support Bracket
7 Powertrain Harness Support Bracket Attaching Bolt
8 Powertrain Harness Former
9 Knock Sensor Harness to Powertrain Harness Connector
(X107)
10 Knock Sensor Connector (B65 – SNSR2)
11 Knock Sensor Connector (B65 – SNSR1)
12 Left-hand Rear O2 Sensor Connector (B56 – LT – RR)
13 C.P.A. Lock
14 Park/Neutral Position and Back-up Lamp Switch Connector
(S187)
15 Bolt
A Front of vehicle.
Fuses, Relays and Wiring Harnesses Page 12O–39
Page 12O–39
3.9 Powertrain Harness – 7
Manual Transmission
Figure 12O – 46
Legend
1 M.A.P. Sensor Connector (B67)
2 Engine Oil Pressure Sensor Connector (B42)
3 Camshaft Position Sensor Connector (B28)
4 Transmission Breather Assembly
5 Powertrain Harness
6 Right-hand Rear O2 Sensor Connector (B58 – RT – RR)
7 Back-up Lamp Switch Connector (S32)
8 Crankshaft Position Sensor Connector (B30)
Fuses, Relays and Wiring Harnesses Page 12O–40
Page 12O–40
3.10 Powertrain Harness – 8
Manual Transmission
Figure 12O – 47
Fuses, Relays and Wiring Harnesses Page 12O–41
Page 12O–41
Legend
1 Left-hand Front O2 Sensor Connector (B57 – LT – FR)
2 Powertrain Harness Support Bracket
3 Powertrain Harness Support Bracket Attaching Bolt
4 Powertrain Harness Former
5 Right-hand Front O2 Sensor Connector (B166 – RT – FR)
6 Powertrain Harness to Knock Sensor Harness Connector
(X107)
7 Engine Ground Terminal (X119 – GP6)
8 Engine Ground Terminal Attaching Bolt
9 Knock Sensor Harness to Powertrain Harness Connector
(X107)
10 Knock Sensor Connector (B65 – SNSR2)
11 Knock Sensor Connector (B65 – SNSR1)
12 Vehicle Speed Sensor Connector (B83)
13 Reverse Lockout Solenoid Connector (Y144)
14 Left-hand Rear O2 Sensor Connector (B56 – LT – RR)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses Page 12O–42
Page 12O–42
3.11 Front Body Harness – 1
Engine Compartment
Figure 12O – 48
Legend
1 Windshield Wiper Motor Connector (M17)
2 Brake Fluid Level Indicator Switch Connector (S36)
3 Front Wheel Speed Sensor Connector (B52 – R)
4 Electronic Brake and Traction Control Module Connector
(A37)
5 Body Ground Terminal (X119 – G3 – GP3)
6 Front Body Harness to Battery Wiring Harness Connector
(X106)
7 Front Body Harness Junction Connector (X100)
8 Fusible Link Supply Connector (X86 – A)
9 Ground Connector (X157)
10 Turn Signal Lamp Connector (E76 – R)
11 Headlamp Connector (E119 – R)
12 Windshield Washer Motor Connector (M19)
13 Hood Theft Deterrent Switch Connectors (S135)
14 Right-hand Fog & Park Lamp Connector (X110)
15 Horn Connector (B9)
16 Ambient Air Temperature Sensor Connector (B23)
17 Engine Cooling Fan Connector (M7 – X1)
18 Front Body Harness to Powertrain Harness Connector
(X101)
19 Horn Connector (B9)
20 Left-hand Fog & Park Lamp Connector (X111)
21 Headlamp Connector (E119 – L)
22 Turn Signal Lamp Connector (E76 – L)
23 Front Wheel Speed Sensor Connector (B52 – L)
24 Sealing Patch Grommet
25 Grommet Insert
26 Instrument Panel to Body Ground Strap Terminal
(X118 – GP9)
27 Body to Instrument Panel Ground Strap
28 Body to Instrument Panel Ground Strap Terminal
(X119 – GP10)
Fuses, Relays and Wiring Harnesses Page 12O–43
Page 12O–43
3.12 Front Body Harness – 2
Protector Assembly, Brake Master Cylinder and Booster
Figure 12O – 49
Legend
1 Brake Master Cylinder and Brake Booster
2 Brake Fluid Level Indicator Switch Connector (S36) 3 Front Body Harness Former
Fuses, Relays and Wiring Harnesses Page 12O–44
Page 12O–44
3.13 Front Body Harness – 3
Under Hood Fuse and Relay Panel and Wiper Motor
Figure 12O – 50
Legend
1 Front Body Harness Junction Connector Cover
2 Front Body Harness Junction Connector (X100)
3 Attaching Screw
4 Windshield Wiper Motor Connector (M17)
5 Firewall Clip (2 places)
Fuses, Relays and Wiring Harnesses Page 12O–45
Page 12O–45
3.14 Front Body Harness – 4
Body Ground and Washer Pump
Figure 12O – 51
Legend
1 Battery Tray
2 Body Ground Connector (X157)
3 Body Ground Connector (X157 – GP2)
4 Attaching Nut, Body Ground
5 Attaching Stud, Body Ground
6 Windshield Washer Motor Connector (M19)
7 Windshield Washer Reservoir
A Front of vehicle.
Fuses, Relays and Wiring Harnesses Page 12O–46
Page 12O–46
3.15 Front Body Harness – 5
Headlamp, Park Lamp and Turn Indicator
Figure 12O – 52
Legend
1 Front Body Harness
2 Turn Signal Lamp Connector (E76)
3 Headlamp Connector (E119)
4 Headlamp Low Beam Dust Cover
5 Headlamp Adjuster
6 Headlamp High Beam Dust Cover
A Harness leads attached to wheelhouse as shown.
Fuses, Relays and Wiring Harnesses Page 12O–47
Page 12O–47
3.16 Front Body Harness – 6
Fans, Ambient Sensor and Theft Deterrent Connectors
Figure 12O – 53
Legend
1 Front Body Harness
2 Engine Cooling Fan Connectors (M7 – X2)
3 Engine Cooling Fan Assembly to Front Body Harness
Connector (M7 – X1)
4 Front Body Harness to Engine Cooling Fan Assembly
Connector (M7 – X1)
5 Ambient Air Temperature Sensor Connector (B23)
6 Hood Theft Deterrent Switch Connectors (S135)
A Front of vehicle.
B Harness attached to front wheelhouse panel bracket as
shown.
Fuses, Relays and Wiring Harnesses Page 12O–48
Page 12O–48
3.17 Front Body Harness – 7
Ambient Sensor, Fan and Theft Deterrent Connectors
Figure 12O – 54
Legend
1 Hood Anti-theft Deterrent Switch Connectors (S135)
2 Front Body Harness to Engine Cooling Fan Assembly
Connector (M7 – X1)
3 Ambient Air Temperature Sensor Connector (B23)
4 Attaching Screw, Hood Theft Deterrent Switch
5 Hood Anti-theft Switch
A Front of vehicle.
B Harness attached to radiator lower support assembly as
shown (5 places).
C Blue strap to be aligned with centre line of vehicle as shown.
D Harness attached to side rail assembly as shown.
Fuses, Relays and Wiring Harnesses Page 12O–49
Page 12O–49
3.18 Front Body Harness – 8
Front Lamps, Fog Lamps and Horn Connectors
Figure 12O – 55
Legend
1 Park Lamp Connector (E71)
2 Left-hand Fog & Park Lamp Harness to Front Body Harness
Connector (X111)
3 Front Body Harness to Left-hand Fog & Park Lamp Harness
Connector (X111)
4 Fog Lamp Connector (E69)
5 Turn Signal Lamp Connector (E76)
6 Headlamp Connector (E119)
7 Front Wheel Speed Sensor Connector (B52)
8 Clip
9 Horn
10 Horn Connector (B9)
11 Right-hand Fog & Park Lamp Harness to Front Body
Harness Connector (X110)
12 Front Body Harness to Right-hand Fog & Park Lamp
Harness Connector (X110)
A Harness attached to wheelhouse panel as shown.
B Front of vehicle.
C Left-hand side shown.
D Right-hand side shown.
Fuses, Relays and Wiring Harnesses Page 12O–50
Page 12O–50
3.19 Front Body Harness – 9
ABS, Air Intake and Front Wheel Speed Sensor
Figure 12O – 56
Legend
1 Electronic Brake and Traction Control Module Connector
(A37) 2 Front Wheel Speed Sensor Connector (B52)
3 Clip
Fuses, Relays and Wiring Harnesses Page 12O–51
Page 12O–51
3.20 Front Body Harness – 10
Cockpit Module
Figure 12O – 57
Fuses, Relays and Wiring Harnesses Page 12O–52
Page 12O–52
Legend
1 Front Body Harness to Global Positioning System Harness
Connector (X207)
2 Radio Front Speaker Dash Upper Connector (B112 – L)
3 Front Body Harness to Powertrain Harness Connector
(X206)
4 Instrument Panel Compartment Lamp Switch Connectors
(S142)
5 Blower Motor Connector (X204)
6 Front Body Harness to Passenger Airbag Harness
Connector (X205)
7 Rear Compartment Lid Release Switch Connector (S195)
8 Radio, Clock & CD Player Connector (A133 – X1)
9 Hazard Warning Switch Connector (S120)
10 Auxiliary Gauges Connector (P2)
11 Ambient Light Sensor Connector (B55)
12 Blower Motor & A/C Compressor Connector (A14 – X1)
13 Trip Odometer Reset Switch Connector (S237)
14 Inside Air Temperature Sensor Connector (B59)
15 Stop Lamp, Traction & Cruise Control Release Switch
Connector (S220 – X3)
16 Stop Lamp, Traction & Cruise Control Release Switch
Connector (S220 – X1)
17 Cruise Cancel Switch / Clutch Patch Connector (X86)
18 Instruments Connector (P3)
19 Radio Front Speaker Dash Upper Connector (B112 – R)
20 Headlamp Automatic Control Switch Connector (S125)
21 Accelerator Pedal Position Sensor Connector (B22)
22 Right-hand Front Stepwell Lamp Connector (E105)
23 Front Body Harness to Body Wiring Harness Connector
(X200)
24 Front Body Harness to Body Wiring Harness Connector
(X201)
25 Wiring (Diagnostics) Connector (X40)
26 Windshield Wiper Dwell Module Connector (A121)
27 Ignition & Start Switch Connector (S149 – X1)
28 Ignition Lock Cylinder Bulb Connector (E30)
29 Ignition & Start Switch Connector (S149 – X2)
30 Windshield Wiper and Washer Switch Connector (S247)
31 Cruise Control Switch Connector (S43)
32 Turn Signal & Headlamp Switch Connector (S231)
33 Steering Wheel Clock Spring Coil Connector (X116)
34 Ignition & Start Switch Connector (S149 – GP15 – X3)
35 Stop Lamp, Traction & Cruise Control Release Switch
Connector (S220 – X2)
36 Front Cigar Lighter Connector (X113 – F)
37 Front Body Harness to Body Wiring Harness Connector
(X303)
38 Front Body Harness to Console Wiring Harness Connector
(X309)
39 Front Body Harness to Transmission Selector Harness
Connector (X301)
40 Radio Ground Terminal (X118 – GP8)
41 Inline to Radio & Mobile Telephone Connector (X155)
42 Blower & Air Inlet Connector (A13 – RHD)
43 Left-hand Front Stepwell Lamp Connector (E105)
44 Instrument Panel Compartment Lamp Connectors (E82)
45 Powertrain Interface Module Connector (A5)
46 Throttle Actuator Control Module Connector (A111 – X2)
47 Radio Antenna Amplifier Connector (N3)
Fuses, Relays and Wiring Harnesses Page 12O–53
Page 12O–53
3.21 Front Body Harness – 11
Cockpit Module
Figure 12O – 58
Legend
1 Front Body Harness to Body Wiring Harness Connector
(X200)
2 Front Body Harness to Body Wiring Harness Connector
(X201)
3 Body Control Module
4 Body Control Module Connector (A15 – X1)
5 Body Control Module Connector (A15 – X2)
6 Body Control Module Connector (A15 – X3)
Fuses, Relays and Wiring Harnesses Page 12O–54
Page 12O–54
3.22 Front Body Harness – 12
Cockpit Module
Figure 12O – 59
Legend
1 Attaching Nut – Wiring Harness Retainer to Instrument
Panel
2 Front Body Harness Cable Retainer
A Refer to 3.11 Front Body Harness – 1 for sealing patch
grommet and insert installation.
B Front body harness former attached to instrument panel
cover assembly as shown.
C Front body harness former attached to instrument panel
cover assembly as shown.
D Front body harness former attached to instrument panel
cover assembly as shown.
E Front body harness retainer attached to steering column
bracket as shown.
F Front body harness former attached to instrument panel
cover assembly as shown.
G Front body harness retainer attached to vehicle as shown.
Fuses, Relays and Wiring Harnesses Page 12O–55
Page 12O–55
3.23 Front Body Harness – 13
Fuse Block, PIM, TAC and BCM
Figure 12O – 60
Fuses, Relays and Wiring Harnesses Page 12O–56
Page 12O–56
Legend
1 Throttle Actuator Control Module
2 Throttle Actuator Control Module Connector (A111 – X2)
3 Powertrain Interface Module Connector (A5)
4 Powertrain Interface Module
5 Attaching Screw, Body Control Module Mounting to Support
6 Body Control Module
7 Instrument Panel Compartment Fuse & Relay Panel (X129)
8 Instrument Panel Compartment Fuse & Relay Panel Support
Bracket
A Instrument panel wiring harness fuse block installed as
shown.
B For installation of relays, fuses and circuit breakers, refer to
1 General Information.
Fuses, Relays and Wiring Harnesses Page 12O–57
Page 12O–57
3.24 Front Body Harness – 14
Steering Column
Figure 12O – 61
Legend
1 Windshield Wiper Dwell Module Connector (A121)
2 Cruise Control Switch Connector (S43)
3 Turn Signal and Headlamp Switch Connector (S231)
4 Steering Wheel Clock Spring Coil Connector (X116)
5 Windshield Wiper and Washer Switch Connector (S247)
6 Clock Spring Harness to Steering Wheel Harness Connector
(S208)
7 Steering Wheel Inflator Restraint Module Connector (A106)
A Front body harness attached to steering column as shown.
Fuses, Relays and Wiring Harnesses Page 12O–58
Page 12O–58
3.25 Front Body Harness – 15
Ignition Lock and Theft Deterrent Receiver
Figure 12O – 62
Legend
1 Front Body Harness
2 Ignition and Start Switch Connector (S149 – X1)
3 Ignition and Start Switch to Ignition Lock Retaining Screw
4 Ground Terminal to Ignition Key Attaching Screw
5 Ignition and Start Switch Terminal (S149 – GP15 – X3)
6 Ignition Lock Housing
7 Ignition and Start Switch Connector (S149 – X2)
8 Ignition Lock
9 Ignition Lock Cylinder Bulb Connector (E30)
10 Ignition Lock Locking Pin
11 Ignition Lock Cylinder Bulb
12 Theft Deterrent Receiver Assembly
13 Coded Key Assembly
14 Coded Key Assembly Attaching Screw
15 Remote Control Transmitter
16 Key
Fuses, Relays and Wiring Harnesses Page 12O–59
Page 12O–59
3.26 Front Body Harness – 16
Manual Transmission – Cruise Control, Stop Lamp Switches, Data Link Connector and
Stepwell Lamps
Figure 12O – 63
Legend
1 Clutch Pedal Position Switch Connector (S42 – X2)
2 Stop Lamp, Traction Control and Cruise Control Release
Switch Connector (S220 – X3)
3 Cruise Cancel Switch – Clutch Patch Connector (X86)
4 Cruise Cancel Switch – Clutch Patch Connector (X86)
5 Cruise Control Patch Harness
6 Stop Lamp, Traction Control and Cruise Control Release
Switch Connector (S220 – X2)
7 Stop Lamp, Traction Control and Cruise Control Release
Switch Connector (S220 – X1)
8 Wiring (Diagnostics) Connector (X40)
9 Instrument Panel Lower Cover – Right-hand Side
10 Instrument Panel Lower Cover – Left-hand Side
11 Stepwell Lamp Connector (E105 – L)
12 Stepwell Lamp
13 Stepwell Lamp Connector (E105 – R)
A Brake and clutch pedals.
Fuses, Relays and Wiring Harnesses Page 12O–60
Page 12O–60
3.27 Front Body Harness – 17
Automatic Transmission – Cruise Control, Stop Lamp Switches, Data Link Connector and
Stepwell Lamps
Figure 12O – 64
Legend
1 Cruise Control Release Switch
2 Stop Lamp, Traction Control and Cruise Control Release
Switch Connector (S220 – X1)
3 Stop Lamp, Traction Control and Cruise Control Release
Switch Connector (S220 – X3)
4 Cruise Cancel Switch – Clutch Patch Connector (X86)
5 Jumper Connector (X86)
6 Stop Lamp, Traction Control and Cruise Control Release
Switch Connector (S220 – X2)
7 Stop Lamp Switch
8 Wiring (Diagnostics) Connector (X40)
9 Instrument Panel Lower Cover – Right-hand Side
10 Instrument Panel Lower Cover – Left-hand Side
11 Stepwell Lamp Connector (E105 – L)
12 Stepwell Lamp
13 Stepwell Lamp Connector (E105 – R)
A Automatic brake pedal.
Fuses, Relays and Wiring Harnesses Page 12O–61
Page 12O–61
3.28 Front Body Harness – 18
Accelerator Pedal Position
Figure 12O – 65
Legend
1 Accelerator Pedal Position Sensor Connector (B22) 2 Accelerator Pedal Position Sensor
Fuses, Relays and Wiring Harnesses Page 12O–62
Page 12O–62
3.29 Front Body Harness – 19
Inside Air Temperature Sensor and Floor Console
Figure 12O – 66
Legend
1 Inside Air Temperature Sensor Connector (B59)
2 Inside Air Temperature Sensor Attaching Screw
3 Inside Air Temperature Sensor
4 Accessory Power Socket
5 Accessory Power Connector (X112 – AUX)
6 Console Wiring Harness to Front Body Harness Connector
(X309)
7 Front Body Harness to Console Wiring Harness Connector
(X309)
8 Console Wiring Harness
9 Front Cigar Lighter Connector (X113 – F)
10 Console Compartment Lamp Connectors (E16)
11 Console Compartment Lamp Bulb
12 Console Compartment Lamp
13 Console Compartment Lamp Switch
14 Console Compartment Lamp Switch Connectors (S94)
A Harness attached to lower radio bracket as shown.
B Harness attached as shown.
C Harness attached to instrument panel as shown.
Fuses, Relays and Wiring Harnesses Page 12O–63
Page 12O–63
3.30 Front Body Harness – 20
Instrument Cluster Assembly
Figure 12O – 67
Legend
1 Instrument Cluster Attaching Screws (4 places)
2 Instrument Cluster Assembly 3 Instrument Cluster Connector (P3)
Fuses, Relays and Wiring Harnesses Page 12O–64
Page 12O–64
3.31 Front Body Harness – 21
Air-conditioning and Heating Controls
Figure 12O – 68
Legend
1 Centre Facia Escutcheon Assembly
2 Attaching Screws (4 places)
3 Blower Motor and A/C Compressor Connector (A14 – X1)
4 Blower Motor and A/C Compressor Connector (A14 – X2)
5 Electronic Climate Control Module
Fuses, Relays and Wiring Harnesses Page 12O–65
Page 12O–65
3.32 Front Body Harness – 22
Instrument Panel Facia Trim Switches
Figure 12O – 69
Legend
1 Headlamp Automatic Control Switch
2 Headlamp Automatic Control Switch Connector (S125)
3 Centre Air Outlet Assembly
4 Attaching Screws (3 places)
5 Hazard Warning Switch
6 Hazard Warning Switch Connector (S120)
7 Trip Odometer Reset Switch Connector (S237)
8 Trip Odometer Reset Switch
Fuses, Relays and Wiring Harnesses Page 12O–66
Page 12O–66
3.33 Front Body Harness – 23
Auxiliary Gauges
Figure 12O – 70
Legend
1 Auxiliary Gauges Connector (P2) 2 Auxiliary Gauges
Fuses, Relays and Wiring Harnesses Page 12O–67
Page 12O–67
3.34 Front Body Harness – 24
Radio Assembly
Figure 12O – 71
Legend
1 Radio, Clock and CD Player Assembly
2 Radio, Clock and CD Player Connector (A133 – X1) 3 Power Antenna Connector (A133 – X2)
4 Diversity Antenna Connector (A133 – X3)
Fuses, Relays and Wiring Harnesses Page 12O–68
Page 12O–68
3.35 Front Body Harness – 25
Passenger Side Airbag and Radio/Mobile Telephone Connectors
Figure 12O – 72
Fuses, Relays and Wiring Harnesses Page 12O–69
Page 12O–69
Legend
1 Front Body Harness to Passenger Air Bag Harness
Connector (X205)
2 Front Body Harness to Global Positioning System Harness
Connector (X207)
3 Inline to Radio and Mobile Telephone Connector (X155)
4 Radio Ground Terminal Attaching Screw
5 Radio Ground Terminal (X118 – GP8)
A Harness former attached to instrument panel cover
assembly as shown (2 places).
B Harness attached to heating, ventilation and air-conditioning
unit as shown.
C Harness attached to instrument panel cover assembly as
shown.
D Instrument panel cover assembly.
E Harness attached to bracket as shown.
F Harness attached to vehicle as shown.
G Harness attached to vehicle as shown.
Fuses, Relays and Wiring Harnesses Page 12O–70
Page 12O–70
3.36 Front Body Harness – 26
Light Sensor/Key Receiver Module and Instrument Panel Speakers
Figure 12O – 73
Legend
1 Radio Front Speaker Dash Upper Connector (B112)
2 Attaching Screw
3 Radio Front Speaker Dash Upper
4 Carrier Instrument Panel Pad
5 Ambient Light Sensor and Key Receiver Module
6 Ambient Light Sensor and Key Receiver Module Connector
(B55)
A Harness attached to light sensor and key receiver module as
shown.
B Harness attached as shown.
Fuses, Relays and Wiring Harnesses Page 12O–71
Page 12O–71
3.37 Front Body Harness – 27
HVAC Occupant Climate Control
Figure 12O – 74
Fuses, Relays and Wiring Harnesses Page 12O–72
Page 12O–72
Legend
1 Blower Motor Connector (X126 – BLO – MOT)
2 Blower Motor Harness to Front Body Harness Connector
(X204)
3 Front Body Harness to Blower Motor Harness Connector
(X204)
4 Blower Motor Connector (M3)
5 Blower and Air Inlet Connector (A13)
6 Inside Air Valve Vacuum Solenoid Pack Connector (Y19)
7 Actuator Temperature Valve Connector (Y37 – L)
8 Actuator Temperature Valve Connector (Y37 – R)
9 Duct Air Temperature Sensor (B34)
A Harness attached to body as shown.
Fuses, Relays and Wiring Harnesses Page 12O–73
Page 12O–73
3.38 Front Body Harness – 28
Instrument Panel Compartment
Figure 12O – 75
Legend
1 Instrument Panel Compartment Lamp Switch Connectors
(S142)
2 Instrument Panel Compartment Lamp Switch
3 Instrument Panel Compartment Lamp Connector (E82)
4 Instrument Panel Compartment Lamp
5 Instrument Panel Compartment Lamp Bulb
6 Rear Compartment Lid Release Switch Connector (S195)
7 Rear Compartment Lid Release Switch
Fuses, Relays and Wiring Harnesses Page 12O–74
Page 12O–74
3.39 Front Body Harness – 29
Interior
Figure 12O – 76
Legend
1 Front Body Harness to Body Wiring Harness Connector
(X303) A Front body harness attached to tunnel as shown.
B Front body harness attached to tunnel as shown.
Fuses, Relays and Wiring Harnesses Page 12O–75
Page 12O–75
3.40 Front Body Harness – 30
Transmission Selector Connectors
Figure 12O – 77
Legend
1 PRNDL Selector Housing
2 Electronic Traction Control Switch Connector (S73)
3 Front Body Harness to Transmission Selector Harness
Connector (X301)
4 Transmission Selector Harness to Front Body Harness
Connector (X301)
5 Automatic Transmission Control Position Indicator Lamp
Connector (E125)
6 Electronic Traction Control Switch
A Automatic transmission selector.
B Manual transmission.
C Front of vehicle.
Fuses, Relays and Wiring Harnesses Page 12O–76
Page 12O–76
3.41 Body Wiring Harness – 1
Figure 12O – 78
Legend
1 Body Wiring Harness to Front Body Harness Connector
(X202)
Fuses, Relays and Wiring Harnesses Page 12O–77
Page 12O–77
3.42 Body Wiring Harness – 2
Interior
Figure 12O – 79
Legend
1 Body Wiring Harness to Front Body Harness Connector
(X303)
2 Ground Terminal (X118 – GP12)
3 Body Wiring Harness Ground Terminal Attaching Screw
4 Ground Terminal (X118 – GP11)
5 Inflation Restraint Sensor Connector (A65)
6 Park Brake Switch Connector (S181)
7 Side Window (Master) Switch Connector (S222)
A Front of vehicle.
B Body wiring harness attached to tunnel as shown.
C Lead clipped as shown.
Fuses, Relays and Wiring Harnesses Page 12O–78
Page 12O–78
3.43 Body Wiring Harness – 3
Interior
Figure 12O – 80
Legend
1 Front Side Turn Signal Lamp Connector (E75)
Fuses, Relays and Wiring Harnesses Page 12O–79
Page 12O–79
3.44 Body Wiring Harness – 4
Interior
Figure 12O – 81
Legend
1 Body Wiring Harness
2 Door Ajar Indicator Switch Connector (S156)
3 Body Wiring Harness to Left-hand Front Door Wiring
Harness Connector (X500)
4 Body Wiring Harness to Front Body Harness Connector
(X202)
5 Front Side Turn Signal Lamp Connector (E75 – L)
6 Side Air Bag Harness to Body Wiring Harness Connector
(X307 – R)
7 Body Wiring Harness to Side Air Bag Harness Connector
(X307 – R)
8 Power Seat Harness to Body Wiring Harness Connector
(X315)
9 Body Wiring Harness to Power Seat Harness Connector
(X315)
10 Seat Belt Pre-tensioner Connector (Y128 – R)
11 Power Seat Harness to Body Wiring Harness Connector
(X308)
12 Body Wiring Harness to Power Seat Harness Connector
(X308)
13 Seat Belt Pre-tensioner Connector (Y129 – L)
14 Side Air Bag Harness to Body Wiring Harness Connector
(X306 – L)
15 Body Wiring Harness to Side Air Bag Harness Connector
(X306 – L)
A Body wiring harness attached to underbody as shown
(6 places).
B Attach body wiring harness to shroud side panel (2 places).
C Harness clipped to underbody as shown (4 places).
D Front of vehicle.
Fuses, Relays and Wiring Harnesses Page 12O–80
Page 12O–80
3.45 Body Wiring Harness – 5
Rear Compartment
Figure 12O – 82
Legend
1 Rear Compartment Courtesy Lamp Switch
2 Attaching Screw
3 Rear Compartment Courtesy Lamp Switch Connectors
(S189)
4 Attaching Screw
5 Body Wiring Harness Ground Terminal (X118 – GP14)
6 Liftgate Latch Actuator
7 Liftgate Latch Actuator Connector (Y29)
8 Rear Licence Plate Lamp Connector (E44)
9 Spoiler Stop lamp Connector (E80)
A Connector clipped to body as shown.
For location of views A to D,
refer to 3.46 Body Wiring Harness – 6.
Fuses, Relays and Wiring Harnesses Page 12O–81
Page 12O–81
3.46 Body Wiring Harness – 6
Rear Compartment Lid
Figure 12O – 83
Legend
1 Rear License Plate Lamp Connector (E44)
2 Rear Compartment Courtesy Lamp Switch Connectors
(S189)
3 Body Wiring Harness Ground Rear Compartment Lid
Terminal (X118 – GP14)
4 Rear Compartment Lid Latch Actuator Connector (Y29)
5 Rear Spoiler Stop Lamp Connector (E80)
A Body wiring harness clipped to rear compartment lid inner
(4 places).
B Body wiring harness clipped to rear compartment lid hinge
(4 places).
For views A to D, refer to 3.45 Body Wiring Harness – 5.
Fuses, Relays and Wiring Harnesses Page 12O–82
Page 12O–82
3.47 Body Wiring Harness – 7
Rear Compartment
Figure 12O – 84
Legend
1 Body Ground Attaching Screw
2 Body Wiring Harness Ground Terminal (X118 – GP13)
3 Tail Lamp Harness to Body Wiring Harness Connector
(X904)
4 Body Wiring Harness to Tail Lamp Harness Connector
(X904)
5 Body Wiring Harness to Trailer Harness Connector (X908)
6 Tail Lamp Harness to Body Wiring Harness Connector
(X903)
7 Body Wiring Harness to Tail Lamp Harness Connector
(X903)
8 Body Wiring Harness to Body Wiring Harness Tow Hook A
Connector (X906)
9 Body Wiring Harness to Body Wiring Harness Trailer
Connector (X907)
Fuses, Relays and Wiring Harnesses Page 12O–83
Page 12O–83
3.48 Body Wiring Harness – 8
Rear Compartment
Figure 12O – 85
Legend
1 Right-hand Rear Speaker Connector (B131)
2 Left-hand Rear Speaker Connector (B131)
3 Rear Compartment Courtesy Lamp
4 Rear Compartment Courtesy Lamp Connectors (E36)
5 High Mounted Stop Lamp
6 High Mounted Stop Lamp Connector (E79)
7 Rear Compartment Courtesy Lamp Bulb
Fuses, Relays and Wiring Harnesses Page 12O–84
Page 12O–84
3.49 Body Wiring Harness – 9
Rear Compartment, Fuel Tank and ABS
Figure 12O – 86
Legend
1 Fuel Tank Harness to Body Wiring Harness Connector
(X402)
2 Body Wiring Harness to Fuel Tank Harness Connector
(X402)
3 Rear Wheel Speed Sensor Connector (B76)
4 Rear Wheel Speed Sensor Connector Retainer
5 Sensor Assembly Rear Wheel Speed
6 Fuel Pressure Sensor Connector (B54)
7 Fuel Pump Motor Connector (M8)
8 Cannister Vent Valve Connector (Y57)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses Page 12O–85
Page 12O–85
3.50 Body Wiring Harness – 10
Speakers and Radio Amplifier
Figure 12O – 87
Legend
1 Rear Quarter Panel Speaker (2 places)
2 Left-hand Rear Quarter Panel Speaker Mounting Bracket
3 Rear Quarter Panel Speaker Connector (B117) (2 places)
4 Rear Speaker Amplifier
5 Rear Speaker Amplifier Connector (N6)
6 Front Door Radio Speaker Connector (B108)
7 Front Door Radio Speaker Mounting Box Assembly
8 Front Door Radio Speaker
9 Rear Shelf Radio Speaker Connector (B131)
A Amplifier attaching screw positioned through hole (4 places).
Fuses, Relays and Wiring Harnesses Page 12O–86
Page 12O–86
3.51 Body Wiring Harness – 11
Rear Park Assist
Figure 12O – 88
Legend
1 Rear Park Aid Harness
2 Body Wiring Harness
3 Rear Object Sensor Ring
4 Rear Object Sensor Assembly
5 Rear Object Sensor Connector (B133)
6 Rear Object Sensor Housing
7 Body Wiring Harness to Rear Park Aid Harness Connector
(X905)
8 Rear Park Aid Harness to Body Wiring Harness Connector
(X905)
9 Inline to Rear Object Sensor Harness Connector (X156)
10 Rear Object Sensor Control Module
11 Rear Object Sensor Alarm Connector (H31)
12 Rear Object Sensor Control Connector (A98)
13 Body Wiring Harness to Body Wiring Harness Tow Hook A
Connector (X906)
14 Body Wiring Harness to Body Wiring Harness Trailer A
Connector (X907)
Fuses, Relays and Wiring Harnesses Page 12O–87
Page 12O–87
3.52 Body & Visor Lamp Harnesses – 1
Interior
Figure 12O – 89
Legend
1 Body Wiring Harness
2 Body Wiring Harness to Front Body Harness Connector
(X200)
3 Body Control Module Connector (A15 – X4)
4 Front Side Turn Lamp Connector (E75)
5 Body Wiring Harness to Right-hand Door Wiring Harness
Connector (X600)
6 Body Wiring Harness to Right-hand Door Wiring Harness
Connector (X601)
7 Door Ajar Indicator Switch Connector (S156)
8 Body Wiring Harness to Front Body Harness Connector
(X201)
8 Body Wiring Harness to Power Seat Harness Connector
(X315)
10 Inflation Restraint Side Impact Sensor Connector (A66)
11 Radio Rear Side Speaker Connector (B117)
12 Rear Object Sensor Control Module
13 Visor Lamp Harness to Body Wiring Harness Connector
(X300)
14 Body Wiring Harness to Visor Lamp Harness Connector
(X300)
15 Rear Compartment Actuator Suppression Diode (V5)
16 Dome Lamp Connector (E67)
17 Dome Lamp
For views A to C, refer to 3.53 Body & Visor Lamp Harnesses – 2.
Fuses, Relays and Wiring Harnesses Page 12O–88
Page 12O–88
3.53 Body & Visor Lamp Harnesses – 2
Interior
Figure 12O – 90
Legend
1 Visor Lamp Harness
2 Visor Lamp Harness to Body Wiring Harness Connector
(X300)
3 Body Wiring Harness to Visor Lamp Harness Connector
(X300)
4 Body Wiring Harness
5 Radio Rear Side Speaker Connector (B117)
6 Inflation Restraint Side Impact Sensor Connector (A66)
7 Body Wiring Harness to Front Body Harness Connector
(X200)
8 Body Control Module Connector (A15 – X4)
9 Front Side Turn Lamp Connector (E75)
10 Body Wiring Harness to Right-hand Door Wiring Harness
Connector (X600)
11 Body Wiring Harness to Right-hand Door Wiring Harness
Connector (X601)
12 Body Wiring Harness to Front Body Harness Connector
(X201)
13 Door Ajar Indicator Switch
14 Door Ajar Indicator Switch Connector (S156)
A Body wiring harness attached to underbody as shown
(6 places).
B Front body harness connectors clipped to shroud side panel
as shown.
C Front of vehicle.
For location of views A to C,
refer to 3.52 Body & Visor Lamp Harnesses – 1.
Fuses, Relays and Wiring Harnesses Page 12O–89
Page 12O–89
3.54 Visor Lamp Harness
Interior
Figure 12O – 91
Legend
1 Rear-view Mirror Connector (E124)
2 Sun Shade Lamp Connector (E120)
3 Visor Lamp Harness to Body Wiring Harness Connector
(X300)
4 Body Wiring Harness to Visor Lamp Harness Connector
(X300)
A Front of vehicle.
Fuses, Relays and Wiring Harnesses Page 12O–90
Page 12O–90
3.55 Radio Antenna Wiring – 1
Figure 12O – 92
Legend
1 Diversity Antenna Lead Connector (X208)
2 Integrated Antenna and Defog Connector (X210) A Leads clipped to underside of heating, ventilation and
air-conditioning assembly as shown.
B Leads clipped to front side of heating, ventilation and
air-conditioning assembly as shown.
C Leads tucked behind routing post on heating, ventilation and
air-conditioning assembly as shown.
Fuses, Relays and Wiring Harnesses Page 12O–91
Page 12O–91
3.56 Radio Antenna Wiring – 2
Antenna and Rear Window Defog
Figure 12O – 93
Fuses, Relays and Wiring Harnesses Page 12O–92
Page 12O–92
Legend
1 Radio Left-hand Side Speaker Connector (B117)
2 Inflation Restraint Side Impact Sensor Connector (A66)
3 Telematics Mirror Patch Connector
4 Radio Diversity Antenna Connector (W4)
5 Antenna Grid Connector (L4 – X1)
6 Antenna and Rear Window Defog Control Module
Connector (A93 – X3)
7 Antenna and Rear Window Defog Control Module
Connector (A93 – X1)
8 Audio Antenna Harness
9 Antenna and Rear Window Defog Control Module
Connector (A93 – X2)
10 Diversity Antenna Amplifier Assembly
11 Antenna and Rear Window Defog Control Module
12 Defog Grid Connector (L4 – X2)
13 Antenna Module Connector (L4 – X3)
14 Antenna Ground Lead Terminal (X118 – GP7)
15 Antenna Lead
16 Sill Attaching Clip
17 Radio Antenna Amplifier Connector (N3)
Fuses, Relays and Wiring Harnesses Page 12O–93
Page 12O–93
3.57 Door Wiring Harness
Figure 12O – 94
Legend
1 Door Wiring Harness to Door Attaching Clip (11 places0
2 Outside Rear-view Mirror Motor Connector (M11)
3 Outside Rear-view Mirror Remote Control Switch
4 Door Lock Switch Connector (S63)
5 Door Lock Actuator Connector (Y13)
6 Door Courtesy Lamp Connectors (E72)
7 Door Window Regulator Connector (M10)
8 Door Radio Speaker Connector (B108)
9 Door Courtesy Lamp
10 Door Wiring Harness
11 Outside Rear-view Mirror Remote Control Switch Connector
(S169)
12 Body Wiring Harness to Right-hand Door Wiring Harness
Connector (X600)
13 Right-hand Door Wiring Harness to Body Wiring Harness
Connector (X600)
14 Right-hand Door Wiring Harness to Body Wiring Harness
Connector (X601)
15 Body Wiring Harness to Right-hand Door Wiring Harness
Connector (X601)
16 Right-hand Door Wiring Harness to Body Wiring Harness
Connector (X500)
17 Body Wiring Harness to Right-hand Door Wiring Harness
Connector (X500)
A Ensure harness is routed behind guide piece.
B Right-hand door shown.
C Left-hand door shown.
Fuses, Relays and Wiring Harnesses Page 12O–94
Page 12O–94
3.58 Navigation System Wiring – 1
Figure 12O – 95
Legend
1 Speaker Assembly
2 Global Positioning System Harness
3 Display Assembly
4 Driver Information Display Connector (P6)
5 Driver Information Display Control Connector (A35)
6 Remote Control Cradle
7 Front Body Harness to Global Positioning System Harness
Connector (X207)
8 Global Positioning System Harness to Front Body Harness
Connector (X207)
9 Navigation Speaker Assembly Connector (B104)
10 Global Positioning System Harness Connector (XO2)
11 Global Positioning System Harness Connector (XO1)
A Harness attached to passenger side airbag support rail
assembly as shown.
For views D, H & J, refer to 3.59 Navigation System Wiring – 2.
Fuses, Relays and Wiring Harnesses Page 12O–95
Page 12O–95
3.59 Navigation System Wiring – 2
Figure 12O – 96
Fuses, Relays and Wiring Harnesses Page 12O–96
Page 12O–96
Legend
1 Global Positioning System Harness
2 Global Positioning System Harness Vehicle Attaching Clip
3 Diversity Antenna Lead
4 Processor Assembly Mounting Points
5 Processor Assembly Mounting Screws
6 Navigation Control Processor Connector (A139 – X2)
7 Navigation Control Processor Connector (A139 – X1)
8 Navigation Control Processor Connector (A139 – X3)
9 Navigation Control Processor Connector (A139 – X4)
10 Processor Assembly Mounting Brackets
11 Navigation Control Processor Assembly
12 Antenna
13 Antenna Connector (W2 – GPS – 2)
A Processor assembly bracket mounting holes.
For location of views D, H & J,
refer to 3.58 Navigation System Wiring – 1.