SECTION 6C2-4 – SPECIFICATIONS -
V6 SUPERCHARGED ENGINE
INFORMATION SENSORS
Camshaft Position (CMP) Sensor ................................. Hall Effect, magnetically triggered
Engine Coolant Temperature (ECT) Sensor................. Negative Temperature Coefficient Thermistor
Resistance/Temperature Range................................ 28,939 Ω @ –20° C to 180 Ω @ 100° C
Oxygen Sensor (HO2S) (one in each exhaust pipe)..... Four wire, heated Zirconia, galvanic cell
Operating Range (above 360° C)............................... 10 – 1,000 millivolts
Closed Loop Operating Range................................... 300 – 600 millivolts
Intake Air Temperature (IAT) Sensor)........................... Negative Temperature Coefficient Thermistor
Resistance/Temperature Range................................ 100,866 Ω @ –40° C to 78 Ω @ 130° C
Mass Air Flow (MAF) Sensor ........................................ Three Sensing Element Type
Throttle Position (TP) Sensor........................................ Three Wire Potentiometer
Operating Range – Closed Throttle .......................... Below 1.25 volts
Wide Open Throttle (WOT)........................................ Approximately 4 volts
Vehicle Speed Sensor (VSS) ........................................ Inductive Type, producing an AC voltage
Operating Range........................................................ From 0.5 volts @ 100 rpm to 100 Volts @ 8,000 rpm
Crankshaft Position (CKP) Sensor................................ Twin Hall Effect, interrupter ring triggered
ENGINE COOLING
Right Hand Side Electric Fan – Power.......................... 120 Watt
Fan Diameter ............................................................. 268 mm
Left Hand Side Electric Fan – Power ............................ 160 Watt
Fan Diameter ............................................................. 370 mm
AUTOMATIC TRANSMISSION 4L60E Component Re sistance Table
COMPONENT TERMINAL WIRE COLOUR
PASS-THRU
CONNECTOR
TERMINAL
RESISTANCE AT 20
DEGREES C CIRCUIT
NO.
1-2 SHIFT SOLENOID B PK/B U E, 339
VALVE ‘A’ A L-GN A 19 – 24 OHMS 1222
2-3 SHIFT SOLENOID A PK/B U E, 339
VALVE ‘B’ B YE/BK B 19 – 24 OHMS 1223
3-2 CONTROL A PK/B U E, 339
SOLENOID VALVE B GN/WH S 20 – 24 OHMS 898
PRESS URE CONTROL A RD C 1228
SOLENOID VALVE B GY/BU D 3 – 5 OHMS 1229
TRANSMISS ION FLUID A BK / YE L Temperat ure V ari abl e 1227
TEMPERATURE S E NSOR (TFT) B BK M (refer Table 4) 2753
TCC "PWM" S O LE NOID A PK/ B U E, 339
VALVE B BN U
9 – 11 OHMS 418
TCC ENABLE A PK/BU E, 339
SOLENOID VALVE B GY/RD T 21 – 26 OHMS 422
Table 1
,
,,
,
Spliced internally to pin E Shift Solenoid ON/OFF States
GEAR 1-2 SHIFT
SOLENOID ‘A’ 2-3 SHIFT
SOLENOID ‘B’
1 ON ON
2 OFF ON
3 OFF OFF
4 ON OFF
Table 2
Transmission Fluid Pressure (TFP) Manual Valve Position Switch Logic Table
Gear
Position Range Signal
Switch A Range Signal
Switch B Range Signal
Switch C
P Open 12V Closed 0V Open 12V
R Closed 0V Closed 0V Open 12V
N Open 12V Closed 0V Open 12V
D Open 12V Closed 0V Clos ed 0V
3 Open 12V Open 12V Closed 0V
2 Open 12V Open 12V Open 12V
1 Closed 0V Open 12V Open 12V
Illegal Closed 0V Open 12V Closed 0V
Illegal Closed 0V Closed 0V Closed 0V
Table 3
Transmission Fluid Temperature (TFT) Sensor Temperature To Resistance Table
Temperature TFT Resistance (Ohm) Signal
Degrees C Minimum Normal Maximum Volts
-20 25809 28677 31545 4.90
-10 14558 16176 17784 4.80
0 8481 9423 10365 4.80
10 5104 5671 6238 4.70
20 3164 3515 3867 4.50
30 2013 2237 2461 4.30
40 1313 1459 1605 4.00
50 876 973 1070 3.70
60 600 667 734 3.20
70 420 467 514 2.80
80 299 332 365 2.40
90 217 241 265 2.00
100 159 177 195 1.70
110 119 132 145 1.40
120 89.9 99.9 109.9 1.10
130 69.1 76.8 84.5 0.90
140 53.8 59.8 65.8 0.70
150 42.5 47.2 51.9 0.40
Table 4
FUEL SYSTEM
Fuel Injector Resistance @ 20° C................................. 11.8 – 12.8 Ω
Idle Air Control (IAC) Valve ........................................... PCM Controlled Stepper Motor
Fuel System Pressure (V6 Supercharged Engine) ....... 290-410 kPa
Fuel Pump Flow Rate (High Speed Operation Only) .... 30 gm/sec at 410 kPa with 12 volts applied
IGNITION SYSTEM
Spark Plug (V6 Supercharged) .................................. NGK BPR6EF-13
Spark Plug Gap.......................................................... 1.3 mm + 0/– 0.1 mm
Spark Plug Leads
Type ........................................................................ ‘Electricfil’
Spark Plug Lead Resistance (V6 Supercharged) ... 475 Ohm per 30 cm lead length approximately.
Ignition Coil
Primary Winding Resistance (@ 20° C)..................... 0.3 – 1.5 Ω
Secondary Winding Resistance (@ 20° C)................ 5,000 – 7,000 Ω
SUPERCHARGER
Supercharger Boost Pressure....................................... 50 – 80 kPa