LTG GI_GRP

04A

04M

04T

04B

PAINT

WARRANTY

PROCESSING

LABOUR TIME MANUAL

HOLDEN’S PASSENGER CARS

THESE LABOUR TIME ALLOWANCES ARE PUBLISHED BY HOLDEN LIMITED FOR THE

PURPOSE OF COMPUTING THE LABOUR COMPONENT OF CLAIMS MADE BY

HOLDEN DEALERS IN THE PERFORMANCE OF WARRANTY, POLICY AND CAMPAIGN

ADJUSTMENTS ETC., CARRIED OUT PURSUANT TO THE TERMS OF THE HOLDEN

LIMITED SALES AND SERVICE AGREEMENT.

THE USE OF THESE ALLOWANCES FOR ANY OTHER PURPOSE WILL BE AT THE

DISCRETION OF EACH DEALER.

ALL LABOUR TIME ALLOWANCES ARE SUBJECT TO CHANGE AT ANY TIME BY

HOLDEN LIMITED.

A.C.N. 006 893 232

REPRODUCTION IN WHOLE OR PART PROHIBITED WITHOUT WRITTEN APPROVAL.

WARRANTY

PROCESSING

INTRODUCTION

THESE UPDATED REPRINT PAGES OF THE HOLDEN PASSENGER CAR LABOUR TIME MANUAL

REPLACES ALL PAGES AND REVISIONS PREVIOUSLY PUBLISHED.

TO PROVIDE FOR FAST LOCATION OF OPERATIONS, ALPHABETIC AND OPERATION NUMBER

INDEXES ARE PROVIDED. THESE INDEXES LIST EVERY MAJOR LABOUR OPERATION IN ALPHABETIC

AND OPERATION NUMBER ORDER RESPECTIVELY, GIVING A DESCRIPTION AND PAGE LOCATION.

DEFINITION OF TERMS USED

MAJOR OPERATIONS: ALL OPERATIONS ALLOCATED A LABOUR OPERATION NUMBER ARE

CLASSED AS MAJOR OPERATIONS. THE TIME ALLOWED INDICATED IS

SUFFICIENT TO DO THE WORK DESCRIBED AS A SINGLE COMPLETE

OPERATION.

ADD: ADDITIONAL TIME ALLOWANCES WHICH MAY BE REQUIRED FOR

PERFORMING A MAJOR OPERATION OR SUPPLEMENT A MAJOR

OPERATION ARE INCLUDED IN THE ‘ADD’ SECTION UNDER THE

‘OPERATION DESCRIPTION’ HEADING.

REMOVE AND REINSTALL: THIS TERM MEANS TO REMOVE A MAJOR COMPONENT OR ASSEMBLY,

REINSTALL THIS ASSEMBLY, AND MAKE ALL NECESSARY

ADJUSTMENTS. GENERALLY, THIS TERM IS USED TO DESIGNATE A

MAJOR OPERATION AND NORMALLY ONE OR MORE OF THE ADDS

LISTED BELOW THE MAJOR OPERATION WILL BE NECESSARY TO

COMPLETE THE WORK.

REPLACE: WHEN THIS TERM IS USED WITH A MAJOR OPERATION, IT MEANS TO

TAKE OFF A PART OR ASSEMBLY AND PUT BACK A NEW PART OR

ASSEMBLY. THIS INCLUDES REMOVE AND REINSTALL AND ALL

NECESSARY ADJUSTMENTS. WHEN THIS TERM IS USED WITH AN ‘ADD’

OPERATION, IT DOES NOT INCLUDE REMOVE AND REINSTALL, BUT

ONLY THAT WORK NECESSARY TO PREPARE A NEW PART OR

ASSEMBLY FOR INSTALLATION IN THE VEHICLE.

OVERHAUL: WHEN THIS TERM IS USED WITH A MAJOR OPERATION, IT MEANS TO

REMOVE AN ASSEMBLY FROM THE VEHICLE, DISASSEMBLE, CLEAN

AND INSPECT ALL PARTS, REBUILD THE ASSEMBLY WITH SAME OR

NEW PARTS, REINSTALL THE ASSEMBLY IN THE VEHICLE AND MAKE

ALL NECESSARY ADJUSTMENTS. WHEN THIS TERM IS USED WITH AN

‘ADD’ OPERATION, IT DOES NOT INCLUDE REMOVE AND REINSTALL BUT

ONLY THAT WORK NECESSARY TO OVERHAUL AN ASSEMBLY ONCE IT

IS REMOVED FROM THE VEHICLE.

ADJUST: TO BRING THE PARTS DESCRIBED TO AN ESTABLISHED STANDARD

FOR FIT OR PERFORMANCE.

ST (STRAIGHT TIME) : WHERE THIS TERM IS INDICATED IN THE LABOUR TIME MANUAL, THE

ACTUAL TIME TAKEN TO PERFORM THE REPAIR SHOULD BE ENTERED

ON THE WARRANTY CLAIM FOR CONSIDERATION OF CREDIT.

WARRANTY

PROCESSING

PAINT FINISH OPERATIONS

PAINT REFINISH TIMES INCLUDED IN THIS MANUAL ARE FOR RECTIFICATION OF BLEMISHES

RESULTING EITHER FROM PAINT AND ASSOCIATED MATERIALS, OR THEIR PROCESSING

OPERATION NOT CONFORMING TO REGULAR HOLDEN’S STANDARDS.

THE TIMES ARE BASED ON THE OPERATION BEING CARRIED OUT DURING THE WARRANTY PERIOD

OR WITHIN A REASONABLE TIME FOLLOWING IT.

NOTE: TIMES DO NOT APPLY TO CRASH REPAIRS, THE REPAIRING OF AGED OR NEGLECTED

VEHICLES.

LABOUR TIMES COVER THE COMPLETE AREA AND OPERATION AS DESIGNATED AND INCLUDE

PREPARATION, MASKING UP AND THE CLEANING OF EQUIPMENT. RECTIFICATION OF ONLY A

SECTION OF THE PART INVOLVED IS TO BE APPORTIONED ACCORDINGLY.

SPOT REPAIR: SPOT REPAIR APPLIES TO A REPAIR OR TOUCH-UP FOR THE

CORRECTION OF CHIPPING AT PANEL EDGES OR OTHER ISOLATED

MINOR IMPERFECTIONS, AND WHEN IT IS NOT POSSIBLE TO CORRECT

THE MINOR IMPERFECTIONS WITH A BRUSH TOUCH-UP.

TOP COAT REPAIR: APPLIES TO PAINT REPAIR OPERATIONS THAT DO NOT REQUIRE THE

USE OF PRIMER BUT MERELY INVOLVE REMOVING BY WIPING THE

SURFACE WITH A SOLVENT, SANDING THE ORIGINAL COLOUR COAT,

MASKING THE AREA AS NECESSARY, APPLYING COLOUR COAT AND

BUFF POLISH WHEN DRY. TOP COAT REPAIR SHOULD BE USED WHEN

CORRECTING CONDITIONS SUCH AS THIN PAINT, OFF COLOUR, RUB

THROUGHS, OR SURFACE SCRATCHES.

STRIP AND REPAINT: APPLIED TO PAINT REPAIR OF A PANEL WHEN COLOUR COATS AND

UNDERCOATS ARE AFFECTED. THE PAINT DAMAGE IS OF SUCH A

NATURE THAT UNDERCOAT MUST BE REMOVED DURING THE SANDING

OPERATION, RESULTING IN THE EXPOSURE OF BARE METAL FOR THE

ENTIRE PANEL. REPAIR OPERATIONS REQUIRE SANDING, CLEANING

THE AFFECTED AREA OF CONTAMINANTS (OIL, WAX, SILICONE, PAINT

STRIPPER, ETC.), MASKING THE AREA AS NECESSARY, PRIMING,

FILLING WHEN NECESSARY, SANDING PRIMER, SEALING, APPLYING

COLOUR AND BUFF POLISH WHEN DRY. THE REFINISH OPERATION

ALSO INCLUDES MATERIAL PREPARATION AS WELL AS CLEANING

EQUIPMENT. A STRIP AND REPAINT OPERATION WOULD BE USED

WHEN CORRECTING ANY CONDITIONS EXTENDING INTO OR THROUGH

THE PAINT UNDERCOATS AND FOR OVER THE ENTIRE PANEL.

COMBINATION PANEL

WORK: WHERE MORE THAN ONE PANEL IS INVOLVED, ADD THE PAINT

MATERIAL ALLOWANCES TOGETHER AND REDUCE THE TOTAL BY 10%

PER PANEL, UP TO A MAXIMUM OF 40%.

E.G. TWO PANELS: TOTAL THE MATERIAL ALLOWANCE AND SUBTRACT 20%

THREE PANELS: TOTAL THE MATERIAL ALLOWANCE AND SUBTRACT 30%

FOUR PANELS: TOTAL THE MATERIAL ALLOWANCE AND SUBTRACT 40%

(OR MORE)

NOTE: ALL PAINT OPERATION TIME ALLOWANCES INCLUDE REMOVAL AND REPLACEMENT OF

PARTS TO FACILITATE THE PAINT OPERATION. PAINT MATERIAL ALLOWANCE FOR EACH

PASSENGER VEHICLE IS LISTED DIRECTLY BELOW THE TIME ALLOWANCE.

E.G. VS VR SB JM JP

B001199 MOULDING, FRONT DOOR RH

— TOP COAT REPAIR 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $33 $33 $33 $33 $33

WARRANTY

PROCESSING

LOW BAKE OVEN ALLOWANCE

APPLIES TO THE TIME ALLOWED FOR THE OVEN BAKING OF ENAMEL PAINTED VEHICLES ONLY,

AND IS APPLICABLE TO THE ACTUAL PAINT REPAIR TIME ONLY.

AN ALLOWANCE OF $20.00 UP TO THE FIRST $100.00 PAINT LABOUR AND AN ADDITIONAL $7.50 FOR

EACH $100.00 PAINT LABOUR OR PART THEREOF FOR THE REMAINDER. IT IS NOT TO INCLUDE

PAINT MATERIAL ALLOWANCE.

CLAIMING FOR LOW BAKE OVEN ALLOWANCE:

CLAIMS FOR TOTAL OVEN ALLOWANCE PLUS PAINT MATERIAL ALLOWANCE MUST BE ENTERED IN

THE NET ITEMS EXPENSE COLUMN, USING NET ITEM TYPE ‘M’.

THE OVEN ALLOWANCE IS TO BE CALCULATED BY THE FOLLOWING FORMULA:

SINGLE PANEL PAINT REPAIR — BAKED ENAMEL:

OVEN ALLOWANCE: $20.00 FOR FIRST $100.00 OF LABOUR COST PLUS

$7.50 FOR EACH REMAINING $100.00 OR PART THEREOF

EXAMPLE: FOR A VR STATION WAGON, PAINTED IN METALLIC, BAKED ENAMEL (REF. PAGE 99-050)

LABOUR OP. NO. DESCRIPTION TIME

B004530 PANEL, ROOF - STRIP & REPAINT, STATION WAGON 10.3 HOURS (TOTAL)

IF WARRANTY RATE IS $40.00, 10.3 HOURS X $40.00 = $412.00 (TOTAL LABOUR)

OVEN ALLOWANCE IS: $20.00 FOR FIRST $100.00

$ 7.50 FOR SECOND $100.00

$ 7.50 FOR THIRD $100.00

$ 7.50 FOR FOURTH $100.00

$ 7.50 FOR REMAINING $12.00

TOTAL: $50.00 OVEN ALLOWANCE

COMBINATION PANEL PAINT REPAIRS — BAKED ENAMEL:

FOR MULTIPLE PAINT REPAIRS ON ONE VEHICLE, PAINTED IN BAKED ENAMEL, THE OVEN

ALLOWANCE MUST BE CALCULATED AS PER THE FORMULA NOTED ABOVE. (I.E. $20.00 FOR FIRST

$100.00, $7.50 FOR EACH ADDITIONAL $100.00 OR PART THEREOF.) THE TOTAL OVEN ALLOWANCE

AMOUNT CALCULATED USING THE ABOVE FORMULA MUST BE CLAIMED ON THE MAJOR PAINT

REPAIR FOR THE VEHICLE.

IDENTIFICATION OF BAKED ENAMEL PAINT — VR MODEL:

THE BODY AND OPTION PLATE ATTACHED TO THE DASH PANEL HAS THE VEHICLE’S PAINT CODE

MARKED ON IT.

LACQUER PAINTS HAVE A 5 DIGIT CODE PREFIXED WITH A ‘1’ FOR SOLID COLOUR, OR A ‘2’ FOR A

METALLIC COLOUR. ENAMEL PAINTS HAVE A 4 DIGIT CODE ONLY.

E.G.: ALASKAN WHITE LACQUER CODE — 1J064

ENAMEL CODE — J064

TIME ALLOWANCES

THE TIME ALLOWANCES LISTED IN THIS MANUAL HAVE BEEN DETERMINED BY PERFORMING THE

OPERATION A SUFFICIENT NUMBER OF TIMES TO ESTABLISH AN AVERAGE TIME REQUIREMENT,

USING HOLDEN LIMITED RECOMMENDED SPECIAL TOOLS AS REQUIRED, AND NORMAL WORKSHOP

TOOLS. SPECIAL TIME SAVING TOOLS OR DEVICES, INCLUDING IMPACT WRENCHES ARE USED IN

PERFORMING TIME STUDIES. PROCEDURES OUTLINED IN SERVICE MANUALS, PRODUCT SERVICE

LETTERS AND OTHER SERVICE PUBLICATIONS ARE GENERALLY USED AS A GUIDE WHEN

PERFORMING THE WORK NECESSARY TO ESTABLISH TIME ALLOWANCES. SUFFICIENT TIME IS

PROVIDED TO PERMIT THE WORK TO BE PERFORMED PROPERLY IN EITHER LARGE OR SMALL

SERVICE AREAS.

WARRANTY

PROCESSING

REQUEST FOR REVIEW

IF A DEALER’S SERVICE MANAGER FEELS THAT ANY TIME ALLOWANCE OR OPERATION IS NOT

CORRECT, HOLDEN LIMITED WILL APPRECIATE RECEIVING A REPORT ON THE OPERATION. IN

REPORTING, HOWEVER, IT IS ASKED THAT YOU COMPLETELY FILL OUT THE FORM ENTITLED

‘REQUEST FOR REVIEW’, PROVIDED FOR THIS PURPOSE. NOTE THAT THE REQUEST FOR REVIEW

FORM HAS SPACE PROVIDED FOR DETAILED VEHICLE IDENTIFICATION WHICH AFFECTS OR

INFLUENCES THE OPERATION IN QUESTION. PLEASE SUPPLY THIS INFORMATION AND DESCRIBE

THE PROCEDURE YOU FOLLOWED SO THAT HOLDEN LIMITED MAY DETERMINE WHETHER THE

ERROR IS IN THE PROCEDURE, THE DESCRIPTION OF THE OPERATION, OR THE PUBLISHED TIME

ALLOWANCE. REQUEST FOR REVIEW FORMS MAY BE USED BY DEALERS TO REQUEST THE

ADDITION OF OPERATIONS TO THE LABOUR TIME MANUAL.

WARRANTY

PROCESSING

REQUEST FOR REVIEW

ZONE OFFICE: ......................................................... DATE: ......................................................................

(LOCATION)

FROM: DEALER NAME: ........................................... DEALER CODE: .....................................................

CITY/TOWN: ............................................................. STATE: ....................................................................

WE REQUEST THAT THE TIME ALLOWANCE FOR THE FOLLOWING OPERATION BE REVIEWED.

OPERATION NUMBER: ............................................ TIME ALLOWANCE (HRS): ....................................

NAME OF OPERATION: ......................................................................................................................................

SUGGESTED TIME ALLOWANCE: ....................... (HRS) REFERENCE NO: ...........................................

(HOLDEN’S OFFICE USE ONLY)

SIGNED: ................................................................... TITLE: .....................................................................

PRINT YOUR NAME HERE: ...............................................................................................................................

ON COMPLETION — MAIL THIS FORM TO YOUR ZONE FIXED OPERATIONS MANAGER, FIELD

EXECUTIVE OR D.S.M.

VEHICLE IDENTIFICATION

MODEL & YEAR: ...................................................... ENGINE NO: ...........................................................

VEHICLE SERIAL NO. - V.I.N.: ............................................................................................................................

ACCESSORIES AND OPTIONS WHICH ALSO AFFECT THIS OPERATION

..............................................................................................................................................................................

ON THE BACK OF THIS SHEET, DESCRIBE IN DETAIL EXACTLY HOW THE OPERATION WAS

PERFORMED, WHAT SPECIAL TOOLS AND EQUIPMENT WERE USED AND WHAT STEPS, IF ANY,

PRESENTED A SPECIFIC PROBLEM.

* THIS FORM MUST ALSO BE USED TO REQUEST THE ADDITION OF AN OPERATION TO THE LABOUR

TIME GUIDE.

REQUEST FOR REVIEW FORMS

FORM No. 2000-3-996

WARRANTY

PROCESSING

DESCRIPTION OF WORK PERFORMED

IN ORDER TO ADEQUATELY EVALUATE AND TAKE ACTION ON YOUR STANDARD TIME CHANGE

REQUEST, WE MUST HAVE A DETAILED DESCRIPTION OF EACH MAJOR STEP REQUIRED TO

PERFORM THE OPERATION. THE STATEMENT ‘FOLLOWED SHOP MANUAL PROCEDURE’ IS NOT

SUFFICIENT EXPLANATION SINCE THE ORIGINAL SHOP MANUAL PROCEDURE MAY HAVE

BEEN REVISED IN LATER SERVICE PUBLICATIONS.

TIME TAKEN

STEP NO. IN MINUTES

1/ ............................................................................................................................................................................

2/ ............................................................................................................................................................................

3/ ............................................................................................................................................................................

4/ ............................................................................................................................................................................

5/ ............................................................................................................................................................................

6/ ............................................................................................................................................................................

7/ ............................................................................................................................................................................

ACTUAL TIME REQUIRED TO PERFORM OPERATION IN OUR SHOP: (MORE THAN ONE STUDY WHEN

POSSIBLE)

FIRST TIME STUDY: ...................................... (HRS) SECOND TIME STUDY: .............................. (HRS)

THIRD TIME STUDY: ..................................... (HRS)

COMMENTS: .......................................................................................................................................................

..............................................................................................................................................................................

TO BE COMPLETED BY HOLDEN LIMITED

ZONE REPRESENTATIVE COMMENTS: ...........................................................................................................

..............................................................................................................................................................................

I HAVE REVIEWED THE REQUEST AND AGREE THAT THE LISTED OPERATION SHOULD BE REVIEWED

BY CENTRAL OFFICE SERVICE DEPARTMENT.

SIGNED: .................................................................... DATE: .....................................................................

(ZONE FIXED OPERATIONS MANAGER, FIELD EXECUTIVE, OR DSM)

REQUEST FOR REVIEW FORMS

FORM No. 2000-3-996

WARRANTY

PROCESSING

PROPER USE OF FAILURE CODES

THE FOLLOWING FAILURE CODE SECTION IS DEVOTED TO AN EXPLANATION OF THE VARIOUS

TYPES OF PROBLEMS WHICH MAY BE ENCOUNTERED IN THE FIELD AND TO ACQUAINT DEALER

PERSONNEL WITH THE PROPER MEANING AND DESCRIPTION OF THE INDIVIDUAL FAILURE CODES.

FAILURE

CODE NO. NAME EXPLANATION

01 BROKEN

02 WELD BROKEN SHOULD BE USED TO INDICATE BREAKS AT A

WELD, OR POOR WELD(S) ONLY.

03 STRIPPED USED FOR STRIPPED THREADS ONLY.

04 TORN OR PUNCTURED PRIMARILY USED FOR SOFT TRIM MATERIALS,

BUT CAN BE USED FOR TORN OR PUNCTURED

METAL.

05 CRACKED

06 WORN

07 SCORED OR SCRATCHED INCLUDES SCRATCH OR SCORE MARKS ON ANY

SURFACE.

08 POOR METAL FINISH USED ON BODY PANELS, OTHER PARTS, AND

FENDERS OR HOODS THAT HAVE GRINDING

WHEEL OR FILE MARKS, OR ROUGH OR WAVY

METAL UNDER THE PAINT.

09 CHIPPED USED PRIMARILY FOR CHIPPED GEAR TEETH OR

OTHER METAL PARTS. DO NOT USE FOR PAINT.

10 SOILED OR STAINED USED FOR SOILED OR STAINED SOFT TRIM.

11 BENT INCLUDES ‘DENTED’ OR ‘WARPED’.

12 FOREIGN MATERIAL EXAMPLE: METAL CHIPS IN CARBURETTOR, DIRT

IN HYDRAULIC VALVES, INCLUDES LOOSE PARTS

LEFT IN. DO NOT USE ON PAINT ITEMS.

13 OVERHEAT ENGINE OVERHEATING.

14 BURNT USE FOR PARTS DAMAGED BY EXCESSIVE HEAT.

DO NOT USE ON ELECTRICAL FAILURES - USE

CODES 48-51.

15 SEIZED PARTS STUCK TOGETHER SO THEY ARE

IMMOVABLE.

PAINT CODES 16 THROUGH 23 ARE TO BE USED FOR DESCRIPTION OF BODY AND

CHASSIS PAINT CONDITIONS ONLY.

16 DIRT OR FOREIGN MATERIAL INDICATED DIRT OR FOREIGN MATERIAL IN PAINT

FILM (INCLUDES OVERSPRAY). NOT RELATED TO

PAINT REPAIR.

17 DRY SPRAY, MOTTLING, SAGS, POOR PAINT APPLICATION (ROUGH INCLUDES

OFF-COLOUR, ROUGH ORANGE PEEL). NOT RELATED TO PAINT REPAIR.

18 FILM MARRED OR SCRATCHED INDICATED SCRATCHES, SWIRLS, ABRASIONS IN

PAINT FILM. NOT RELATED TO PAINT REPAIR.

19 THIN OR RUBBED THROUGH THIN OR RUBBED THROUGH RESULTING IN THIN

PAINT. NOT RELATED TO PAINT REPAIR.

WARRANTY

PROCESSING

FAILURE

CODE NO. NAME EXPLANATION

20 CORROSION, CRAZING, PAINT FILM FAILURE. NOT RELATED TO PAINT

CRACKING, CHALKING REPAIR.

21 POOR SPOT REPAIR REPAIR AREAS NOTICEABLE - DRY, RINGED, OFF-

COLOUR, DIRT AND CRAZING.

22 FILM SPOTTED WATER SPOTTING, CHEMICAL SPOTTING,

ETCHING, DISTORTION.

23 FINISH COMES OFF INDICATES ANY LOSS OF PAINT ADHESION SUCH

AS BLISTERING, PEELING OR EXCESSIVE

CHIPPING. NOT RELATED TO PAINT REPAIR.

24 CHROME PLATING DEFECTIVE USE FOR ALL CHROME DEFECTS. ALSO USE FOR

SURFACE DEFECTS ON STAINLESS AND

ALUMINIUM BRIGHT WORK WHEN CODE 8 DOES

NOT APPLY.

25 MISALIGNED USE FOR PARTS THAT DO NOT FIT PROPERLY,

PRIMARILY FOR BODY ‘APPEARANCE’ ITEMS.

26 MISADJUSTED USE FOR COMPONENTS THAT ARE NOT

ADJUSTED PROPERLY.

27 LOOSE

28 RATTLE USE THIS CODE TO DESCRIBE A RATTLE/

RATTLING CONDITION, BUT NOT TO BE CONFUSED

WITH FAILURE CODE 27 LOOSE

29 PART MISSING

30 POROSITY INDICATES SAND HOLE IN CASTING.

31 POOR MACHINING SURFACES NOT MACHINED TO LIMITS, CAUSING

LEAKS, DISTORTION OR OTHER DAMAGE. DO NOT

USE TO INDICATE POOR FIT, UNLESS THE POOR

FIT IS CAUSED BY POOR MACHINING.

32 GLASS - POOR VISION INDICATES GLASS THAT ADVERSELY AFFECTS

THE VISION OF THE DRIVER. EXAMPLES: GLASS

PRODUCING DISTORTED OR DOUBLE VISION;

CLOUDY OR DISCOLOURED GLASS.

33 WEAK PRIMARILY USED FOR WEAK SPRINGS, BUT MAY

BE USED TO INDICATE WEAKNESS IN OTHER

PARTS.

34 OUT OF BALANCE INDICATES ROTATING PARTS OUT OF BALANCE.

35 OUT OF ROUND USED ON CIRCULAR PARTS; INCLUDES ‘RUN-OUT’

AND BRAKE DISC/DRUM OUT-OF-ROUND. DO NOT

CONFUSE WITH CODE 34 - OUT OF BALANCE

36 VIBRATES

37 POOR ENGAGEMENT INDICATES PARTS THAT DO NOT ENGAGE

PROPERLY, OR THAT PRODUCE FAULTY

OPERATION DUE TO PARTIAL CONTACT. ROUGH

TRANSMISSION SHIFT.

38 DOES NOT SEAT USED PRIMARILY ON ENGINE I.E. RINGS, SEALS,

VALVES, ETC.

39 GRABS USED PRIMARILY TO INDICATE GRABBING

BRAKES.

WARRANTY

PROCESSING

FAILURE

CODE NO. NAME EXPLANATION

40 NOISY DO NOT USE THIS CODE IF THE PRIMARY CAUSE

OF THE NOISE (SUCH AS LOOSE PARTS, ETC.) IS

DEFINITELY KNOWN. USE APPROPRIATE CODE 27,

ETC. IN GENERAL, CODE 40 SHOULD BE USED

ONLY FOR NOISES SUCH AS BRAKE SQUEAL,

SEALS RUBBING ON SHAFTS, A/C SYSTEM, ETC.

41 CHATTERS INDICATES BOTH NOISE (INTERMITTENT) AND

JERKY ACTION. PRIMARILY USED FOR

CHATTERING CLUTCH OR BRAKES.

42 LEAKS USE THIS CODE ONLY TO INDICATE THAT A

PARTICULAR CONTAINER OR CONDUCTOR OF

FLUID IS ACTUALLY LEAKING.

43 SHIFTS HARD REFERS TO TRANSMISSION OR TRANSMISSION

PARTS, AND INCLUDES ROUGH SHIFTING OF

BOTH MANUAL AND AUTOMATIC TRANSMISSIONS.

44 SLIPS OUT OF GEAR REFERS TO TRANSMISSION OR TRANSMISSION

PARTS SLIPPING OUT OF GEAR.

45 WIND NOISE A) UNSEALED, MISALIGNED OR DAMAGED SIDE

ROOF RAIL AND DOOR WEATHERSTRIPS

(INCLUDES SIDE ROOF RAIL WEATHERSTRIP

RETAINER);

B) UNSEALED HOLES OR JOINTS IN METAL

PANELS;

C) POOR FITTING EXTERIOR MOULDINGS.

46 FLOODS ENGINE OVER-FUELLING.

47 FLAT SPOT OR HESITATES ENGINE HESITATION OR DRIVEABILITY PROBLEM.

48 ELECTRICAL HARNESS PROBLEM ELECTRICAL HARNESS RELATED DEFECT/

PROBLEM.

49 ELECTRICAL TERMINAL PROBLEM ELECTRICAL TERMINAL RELATED DEFECT/

PROBLEM.

50 ELECTRICAL COMPONENT FAILURE ELECTRICAL COMPONENT FAILURE OTHER THAN

A HARNESS.

NOTE: WHEN CLAIMING FOR LABOUR OPERATIONS FROM THE ‘‘WIRING AND CONNECTOR

WARRANTY CLAIM SUBMISSION MANUAL’’ — USE THE FAILURE CODES SUPPLIED IN THAT MANUAL.

51 ELECTRICAL CONNECTOR PROBLEM ELECTRICAL CONNECTOR OR RELATED DEFECT/

PROBLEM.

52 BINDS, STICKS

53 NOT DRILLED RESTRICTED PASSAGE FROM INCOMPLETE

DRILLING.

54 WRONG PART INCORRECT PART ORIGINALLY INSTALLED, TRIM

ETC.

55 POOR FIT BODY PANELS, BODY COMPONENTS, TRIM, ETC.

56 INOPERATIVE USE WHEN EXACT CAUSE CANNOT BE DEFINED.

57 REGISTERS INCORRECTLY USED FOR GAUGES, SENSORS, SENDERS,

SPEEDOMETER, ETC.

58 PARTS IMPROPERLY INSTALLED APPLIES TO AN INCORRECT PART INSTALLED, AS

WELL AS A CORRECT PART IMPROPERLY

INSTALLED.

WARRANTY

PROCESSING

FAILURE

CODE NO. NAME EXPLANATION

59 PULLS USED FOR BRAKE PULL.

60 ENGINE PING DETONATION OR PRE-IGNITION.

61 INCORRECT PRESSURE TOO HIGH OR LOW.

62 IMPROPER CLEARANCE

63 FADE OR HARD PEDAL BRAKES.

64 GLAZED BRAKES.

65 SLIPS CLUTCH.

66 COLLAPSED PERTAINS PRINCIPALLY TO CONTAINERS OR

CONDUCTORS.

67 EXCESSIVE LUBRICATION BRAKES, CLUTCH ETC.

OR OIL SOAKED

68 INSUFFICIENT LUBRICATION

69 HIGH OIL CONSUMPTION

70 POOR FUEL CONSUMPTION

71 PULLED LOOSE PERTAINS TO ITEM THAT WAS ORIGINALLY

INSTALLED.

72 SPLIT SEAMS STITCHING FRAYED.

73 IMPROPERLY PADDED SOFT TRIM.

74 FUMES

75 RUSTED OR CORRODED METAL ITEMS.

76 WRINKLED SOFT TRIM.

78 DISCOLOURED

79 POOR RELEASE

80 PITTED

81 HARD RIDE

82 SURGE INDICATES UNEVEN ENGINE OPERATION FROM

FUEL INJECTION, IGNITION OR FUEL SUPPLY.

83 HARD STARTING (COLD) INDICATES HARD STARTING FROM ANY CAUSE

AND INCLUDES SLOW CRANKING, EXCESS

CRANKING AND FALSE STARTS/STALLS.

84 HARD STARTING (HOT) INDICATES HARD STARTING FROM ANY CAUSE

AND INCLUDES SLOW CRANKING, EXCESS

CRANKING AND FALSE STARTS/STALLS.

85 SHEARED

87 WATER LEAK USE THIS CODE SPECIFICALLY WHEN REPORTING

BODY WATER LEAKS IN THE VEHICLE CABIN OR

BOOT/REAR COMPARTMENT.

88 DUST LEAK USE THIS CODE SPECIFICALLY WHEN REPORTING

BODY DUST LEAKS IN THE VEHICLE CABIN OR

BOOT/REAR COMPARTMENT.

90 SQUEAK USE THIS CODE SPECIFICALLY TO DESCRIBE A

SQUEAK/SQUEAKING CONDITION.

93 DISCHARGED BATTERY RUN DOWN.

WARRANTY

PROCESSING

FAILURE

CODE NO. NAME EXPLANATION

95 REWORK

96 CAMPAIGN THIS CODE NUMBER TO BE USED ONLY TO

INDICATE REPAIRS PERFORMED ON VEHICLES

DURING A DESIGNATED PERIOD OF TIME OR

BETWEEN DESIGNATED VEHICLE IDENTIFICATION

NUMBERS AS REQUESTED BY HOLDEN LIMITED

DEALER PRODUCT CAMPAIGN.

WARRANTY

PROCESSING

FAILURE CODES (NOW SYSTEM)

THE FOLLOWING FAILURE CODE SECTION IS DEVOTED TO AN EXPLAINATION OF THE VARIOUS

TYPES OF PROBLEMS WHICH MAY BE ENCOUNTERED IN THE FIELD AND TO ACQUAINT RETAILER

PERSONNEL WITH THE PROPER MEANING AND DESCRIPTION OF THE INDIVIDUAL FAILURE CODES

* Indicates that the failure code is relevant for the Labour Operation Number Prefix.

** Indicates for use with LC&RV only.

Replace the ? in front of failure code with the appropriate Labour Operation Number Prefix.

FAILURE CODE USAGE MATRIX

Failure

Code Descriptions Labour Operation Number Prefix

ABCDEF HJ KLMNPRST W

?0001 Broken * ** * * * * * * * * *

?0002 Weld Broken * * * * * * * * * **

?0003 Stripped ******* ***** *

?0004 Torn or Punctured * ** * * * * * * * * *

?0005 Cracked ************* ***

?0006 Worn ********** ** ***

?0007 Scored or Scratched * ** * * * * * * * * * *

?0008 Poor Metal Finish * * * * *

?0009 Chipped * ** * * * *

?0010 Soiled or Stained * ** * * * * *

?0011 Bent ************* ***

?0012 Foreign Material * ** * * * * * * * * *

?0013 Overheat * * * *

?0014 Burnt or Blown * * * * * * * *

?0015 Seized ************ *

?0016 Dirt or Foreign Material ** * * * *

?0017 “Dry Spray, Mottling, Sags, Off-Colour, Rough” ** * * *

?0018 Film Marred or Scratched ** * * * *

?0019 Thin or Rubbed Through ** * * *

?0020 “Corrosion, Crazing, Cracking, Chalking” ** * * * **

?0021 Poor Spot Repair. ** * * *

?0022 Film Spotted. ** * * * *

?0023 Finish Comes Off ** * * * * * *

?0024 Chrome Plating Defective * * * *

?0025 Misaligned *****************

?0026 Misadjusted ***************

?0027 Loose ************* ***

?0028 Rattle ************* ***

?0029 Part Missing ************* *

?0030 Porosity * * * * *

?0031 Poor Machining ** * * * * * * * * *

?0032 Glass - Poor Vision * ** * * *

?0033 Weak ********** * *

?0034 Out of Balance * * * * * * *

?0035 Out of Round * * * * * * *

WARRANTY

PROCESSING

?0036 Vibrates *****************

?0037 Poor Engagement * ** * * * * * * *

?0038 Does Not Seat * * * *

?0039 Grabs * * * * *

?0040 Noisy ************* *

?0041 Chatters * * * * *

?0042 Leaks (Oil/Fluid) ** * * * * * * * * * *

?0043 Shifts Hard * * *

?0044 Slips Out of Gear * *

?0045 Wind Noise * ** * * **

?0046 Floods * * *

?0047 Flat Spot or Hesitates * * * * *

?0050 Electrical Component Failure * * * * * * * * *

?0052 Binds or Sticks ************* *

?0053 Not Drilled * ** * * * * *

?0054 Wrong Part *********** *****

?0055 Poor Fit ****************

?0056 Inoperative * * *

?0057 Registers Incorrectly * * * * * * * * * *

?0058 Parts Improperly installed ************* ***

?0059 Pulls * * * *

?0060 Engine Ping * * *

?0061 Incorrect Pressure * * * * * * * * *

?0062 Improper Clearance ************* ***

?0063 Fade or Hard Pedal * * *

?0064 Glazed * *

?0065 Slips * * *

?0066 Collapsed * * * * * * * * * *

?0067 Excessive Lubrication or Oil Soaked ** * * * * * * *

?0068 Insufficient Lubrication. ** * * * * * * * *

?0069 High Oil Consumption * * *

?0070 Poor Fuel Consumption * * *

?0071 Pulled Loose ************* *

?0072 Split Seams * ** * * * * * **

?0073 Improperly Padded * ** * * * * *

?0074 Fumes * * * *

?0075 Rusted or Corroded * * * * * * * * * * * **

?0076 Wrinkled * * * * * **

?0078 Discoloured * ** * * * * * *

?0079 Poor Release * ** * * * * * * *

?0080 Pitted * * * * *

?0081 Hard Ride * * * *

?0082 Surge * * * * *

?0083 Hard Starting (cold) * * * *

?0084 Hard Starting (hot) * * * *

?0085 Sheared ***** ***** * *

Failure

Code Descriptions Labour Operation Number Prefix

ABCDEF HJ KLMNPRST W

WARRANTY

PROCESSING

?0087 Water Leak * ** * * * * * **

?0088 Dust Leak * ** * * **

?0089 Knock or Thump * * * *

?0090 Squeak ************* ***

?0093 Discharge **

?0095 Rework ****************

?0096 Campaign *

?0097 Servicing **

?0100 Terminal - Corroded *

?0101 Terminal - Poorly Crimped *

?0102 Terminal - Not retained *

?0103 Terminal - Loose Terminal *

?0104 Terminal - Wrong Part *

?0105 Terminal - Wrong Position *

?0106 Terminal - Poor Earth *

?0107 Terminal - Terminal damage *

?0108 Terminal - Dry solder connection *

?0109 Connector - Not connected *

?0110 Connector - Will not lock *

?0111 Wiring - Pinched cut *

?0112 Wiring - Too Short *

?0113 Wiring - Splice open circuit *

?0114 Wiring - Wrong routed *

?0115 Wiring - Short circuit *

?0116 Wiring - Dry solder connection *

?0117 DTC Cleared - NFF * * * * * * * *

Failure

Code Descriptions Labour Operation Number Prefix

ABCDEF HJ KLMNPRST W

WARRANTY

PROCESSING

INDEX ABBREVIATIONS

THE FOLLOWING ABBREVIATIONS WILL BE USED IN THE LABOUR TIME GUIDE

ABBREVIATION DESCRIPTION

ACCUM ........................ ACCUMULATOR

A/C ............................... AIR CONDITIONING

ABS .............................. ANTI-LOCK BRAKING SYSTEM

ADJ .............................. ADJUST

ASM ............................. ASSEMBLY

A/T ................................ AUTOMATIC TRANSMISSION

B/LINE .......................... BELT LINE

B/ ................................. BELOW

CARB ........................... CARBURETTOR

CEN ............................. CENTRE

CNR ............................. CORNER

COMM .......................... COMMODORE

COMP .......................... COMPRESSOR

COND .......................... CONDENSER

CV ................................ CONSTANT VELOCITY

DEFL ........................... DEFLECTOR

DIFF ............................. DIFFERENTIAL

DOHC ........................... DUAL OVERHEAD CAMSHAFT

ENGINE

ECM ............................. ELECTRONIC CONTROL MODULE

ELEC ........................... ELECTRIC

EFI ................................ ELECTRONIC FUEL INJECTION

EMS.............................. ENGINE MANAGEMENT SYSTEM

ENG ............................. ENGINE

FRT............................... FRONT

HARN ........................... HARNESS

HYD .............................. HYDRAULIC

INDIC ........................... INDICATOR

INTERM ....................... INTERMEDIATE

IRS................................ INDEPENDENT REAR SUSPENSION

LH ................................ LEFT HAND SIDE

LWR.............................. LOWER

L4 ................................. 4 CYLINDER ENGINE

MAN ............................. MANIFOLD

M/T .............................. MANUAL TRANSMISSION

MLDG ........................... MOULDING

ABBREVIATION DESCRIPTION

NON-TURBO ................ NON-TURBOCHARGED ENGINE

OHC .............................. SINGLE OVERHEAD CAM ENGINE

P/S ................................ POWER STEERING

PCM .............................. POWERTRAIN CONTROL MODULE

PFI................................. PORT FUEL INJECTION

PRES ............................ PRESSURE

PROP............................ PROPORTIONING

RECIRC ........................ RECIRCULATION/ING

REG .............................. REGULATOR

REPL............................. REPLACE

REV............................... REVERSE

RH................................. RIGHT HAND SIDE

RR................................. REAR

R & R............................. REMOVE & REINSTALL

S/C ................................ SUPERCHARGED ENGINE

S/MLDG ........................ SIDE MOULDING

SPEEDO ....................... SPEEDOMETER

SRS............................... SUPPLEMENTAL RESTRAINT

SYSTEM (AIR BAG)

ST.................................. STRAIGHT TIME

STD............................... STANDARD

S/REPAINT ................... STRIP AND REPAINT

SUSP ............................ SUSPENSION

T/COAT ......................... TOP COAT

TEMP ............................ TEMPERATURE

T/S................................. TURN SIGNAL

TURBO.......................... TURBOCHARGED ENGINE

V6.................................. V6 ENGINE

V8.................................. V8 ENGINE

VENT............................. VENTILATION

W/SHIELD..................... WINDSHIELD

4SP ............................... 4 SPEED TRANSMISSION

4WD .............................. 4 WHEEL DRIVE

5SP ............................... 5 SPEED TRANSMISSION

/ ..................................... OR

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

"O" RING, ANY/AL L — REPL A CE ............. ... ... ....................M048600 0 6- 400

"O" RING, CONDENSE R (LOWER ) — REPL A C E.... ... ... .....D308220 08-200

"O" RING, CONDENSER (U P PER ) — REPLA CE ....... ... ... ..D 308 210 08-200

"O" RING, CONDENSE R — REPL A C E........ ... ....................D308200 08-200

"O" RINGS, COMPRESSOR — REPLACE..........................D301120 08-200

A/C COMPRESSOR & CLUTCH ASM. — REPLACE..........D301100 08-200

A/C SYSTEM PURGE, LEAK TEST & CHARGE.................D904100 08-200

ACTUATOR ASM, DECK LID/TAILGATE/HATCH...............N253400 12-680

ACTUATOR ASM. DOOR CENTRAL LOCKING LH............N242200 11-360

ACTUATOR ASM. DOOR CENTRAL LOCKING LH............N243200 11-725

ACTUATOR ASM. DOOR CENTRAL LOCKING RH...........N242100 11-360

ACTUATOR ASM. DOOR CENTRAL LOCKING RH...........N243100 11-725

ACTUATOR , DEMIS T & FL OOR (V A CUU M ) —.......... ... ... ..D 021420 0 8- 15 0

ACTUATOR, RECIRCULATION (VACUUM) —...................D021120 08-150

ACTUATOR, VACUUM CENTRE VENT — REPLACE........D021320 08-150

ADAPTOR ASM. THROTTLE BODY (S/C ONLY) —...........J805210 03-300

ADAPTOR/HOU SI NG AS M. OIL FILT E R —. ... ... ............... ..J3 1 630 0 01-500

ADD TO: REPLACE BOTH SIDES.......................................E109200 06-205

ADJUSTE R WHE E L , FR T SE A T R ECL IN ER —....... ... ... .....C534500 14-275

AIR BAG UNIT, DR IV E R SRS — RE PL A CE....... ... ... ...........M200 10 0 06-225

AIR BAG UNIT, LH FRONT SEAT LATERAL —..................C885600 06-225

AIR BAG UNIT, PASSENGER SRS — REPLACE...............M200300 06-225

AIR BAG UNIT, RH FRONT SEAT LATERAL —.................C885500 06-225

AIR DEFLECTOR, TAILGATE — REPLACE .......................A506600 10-350

AIR LINE ASM LH. S/LIFT SHOCK ABSORBER —............F400600 07-150

AIR LINE ASM LH. S/LIFT SHOCK ABSORBER —............F400600 AA-225

AIR LINE ASM RH. S/LIFT SHOCK ABSORBER —...... ......F400650 AA-225

AIR LINE ASM RH. S/LIFT SHOCK ABSORBER —............F400650 07-150

AIRBAG UNIT, CURTAIN — REPLACE BOTH....................C454700 06-225

AIRBAG UNIT, CURTAIN — REPLACE LEFT HAND..........C454710 06-225

AIRBAG UNIT, CURTAIN — REPLACE RIGHT HAND.......C454720 06-225

ALTERNATOR ASM. — REPLACE .....................................J591200 02-140

AMPLIFIER & LEAD, DIVERSITY/SCREEN........................R201000 09-400

AMPLIFIER, AUDIO SYSTEM — R&R/REPLACE...............R205700 09-515

ANTENNA & LEAD ASM. (ELECTRIC) — R&R/..................R200300 09-400

ANTENNA & LEAD ASM. (MANUAL) — REPLACE............R200100 09-400

ANTENNA ROD (MAST) — REPLACE................................R200200 09-400

ANTENNA, MOBILE PHONE — REPLACE.........................R300100 09-525

ANTENNA, TELEMATICS — REPLACE..............................N446300 09-540

APPLIQUE, QUARTER WINDOW REAR (L/H)....................C847400 10-250

APPLIQUE, QUARTER WINDOW REAR (R/H)...................C847300 10-250

APPLIQUE/IN SE RT , RE A R BUMP ER — R&R/...................A571 600 07- 525

ARM ASM. LH FRONT LOWER CONTROL —....................E100200 06-200

ARM ASM. LOWER CONTROL BOTH — REPLACE..........F110000 07-150

ARM ASM. LOWER CONTROL LH — REPLACE ...............F110200 07-150A

ARM ASM. LOWER CONTROL RH — REPLACE...............F110100 07-150A

ARM ASM. RH FRONT LOWER CONTROL —...................E100100 06-200

ARM ASM. TAILGATE/HATCH WIPER — REPLACE.........N752100 10-525

ARM ASM. UPPER CONTR OL BOTH — REPLACE...........F112000 07-150

ARM ASM. UPPER CONTR OL BOTH — REPLACE...........F112000 07-150A

ARM ASM. UPPER CONTR O L LH — REPLACE................F112200 07-150A

ARM ASM. UPPER CONTR O L RH — REPLACE........... .....F112100 07-150A

ARM ASM. WINDSH IE L D WIP ER (1 OR 2) — .......... ..........N 35 6 100 10-505

ARM, VALVE ROCKER (1 OR ALL) — REPLACE ..............J307210 00-050

ARM, VALVE ROCKER (1 OR ALL) — REPLACE ..............J307110 00-050

ARM, VALVE ROCKER (1 OR ALL) — REPLACE ..............J307010 00-050

ARMREST ASM. TRANSMISSION CONSOLE —...............C474400 14-900

ARMREST, "C" PILLAR LOWER LH — R&R/......................C410400 14-120

ARMREST, "C" PILLAR LOWE R RH — R&R/.............. .......C410 350 14-120

ARMREST/HATCH ASM. REAR SEAT CENTRE —...........C572600 14-350

AUTO FILL LIMITER VALVE — REPLACE..........................L701450 AA-650Q

AUTO TRANS ASM. — AC DELCO (POLICY......................K700100 04-200

AUTO TRANS ASM. — R&R................................................K700500 04-200

AUTO TRANS ASM. — SRTA CHANGEOVER PRO—.......K000225 04-200

AUTO TRANS. OIL PRESSURE — CHECK........................K600500 04-200

BALL JOINT, LOWER FRONT — REPL ACE BOTH............E103000 06-200

BALL JOINT, LOWER LH FRONT — REPLACE.................E103400 06-200

BALL JOINT, LOWER RH FRONT — REPLACE.................E103300 06-200

BAR, FRONT ST A B IL IZ ER — REP L AC E... ... ... ............ ... ....E10910 0 06 -2 05

BASE, MOBILE PHONE ANTENNA (INNER) —..................R300250 09-525

BASE, MOBILE PHONE ANTENNA (OUTER) —................R300200 09-525

BATTERY ASM. — REPLACE.............................................N000500 02-200

BATTERY ASM. — TEST & RECHARGE............................N000550 02-200

BATTERY REPLACEMENT — CENTURY YUASA.............N000333 02-200

BATTERY, DVD REMOTE CONTROL — REPLACE..........N780650 09-515

BATTERY, TE L EMAT IC S CONT ROL UNIT —................ ....N446100 09-540

BEARING ASM. CLUTCH PILOT — REPLACE (M/T).........K013500 00-400

BEARING ASM. CLUTCH THROWOUT — REPLACE........K012100 00-400

BEARING ASM. INPUT SHAFT — REPLACE.....................K108700 04-125

BEARING ASM. M/T INTERNAL ANY ONE —....................K108300 04-125

BEARING, AXLE SHAFT — REPLACE BOTH SIDES.........F506000 05-400

BEARING, AXLE SHAFT LH — REPLACE..........................F506200 05-400

BEARING, AXLE SHAFT RH — REPLACE.........................F506100 05-400

BEARING, BALANCE SHAFT (REAR) — REPLACE ..........J314910 00-150

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

BEARING, CONNECTING ROD (ONE/ALL) — ...................J320510 00-550

BEARING, CONSTANT VELOCITY JOINT — R&R/............F911100 05-050

BEARING, CRANKSHAFT MAIN (ONE) — REPLACE........J320700 00-200

BEARING, DIFFERENTIAL SIDE — REPLACE..................K009820 05-250

BEARING, FRONT PROPELLER SHAFT —.......................F905200 05-250

BEARING, PROPELLER SHAFT CENTRE —.....................F912100 05-050

BEARING/HUB, REAR WHEEL — REPLACE BOTH..........F701000 05-290

BEARING/HUB, REAR WHEEL LH — REPLACE...............F701200 05-290

BEARING/HUB, REAR WHEEL RH — REPLACE...............F701100 05-290

BELLOW, TIE ROD END — REPLACE BOTH SIDES.........M037000 06-310

BELLOW, TIE ROD END LH — REPLACE..........................M037200 06-310

BELLOW, TIE ROD END RH — REPLACE.........................M037100 06-310

BELT ASM. CENTRE RETRACTOR/BUCKLE —................C452500 14-425

BELT ASM. RETRACTOR LH FRONT SEAT —..................C451200 14-400

BELT ASM. RETRACTOR LH REAR SEAT —....................C452200 14-425

BELT ASM. RETR AC T O R R H FR ON T SE A T —............ .....C45110 0 14-400

BELT ASM. RETRACTOR RH REAR SEAT —....................C452100 14-425

BELT, A/C COMPRESSOR — REPLACE.......... ................. .D312100 01-003

BELT, MAIN DRIVE — REPLACE .......................................J607100 01-003

BELT, P/S PUMP — REPLACE...........................................M042500 01-003

BELT, SUPERCHARGER ....................................................J607050 01-003

BELT, WATER PUMP & ALTERNATOR — RE PLACE........J607150 01-003

BLADE ASM. TA IL GA TE /H A T CH WIPE R —..................... ..N75 2 20 0 10-525

BLADE ASM. WINDS H IE L D WIPE R (1 OR 2) —.................N356000 10-505

BLOCK, CYLINDER CASE — REPLACE............................J340500 00-248

BODY ASM. THROTTLE — REPLACE................................J805170 03-300

BODY, AIR CLEANER LOWER — REPLACE.....................J817600 03-250

BODY, AIR CLEANER UPPER — REPLACE......................J817500 03-250

BOLT, CONVERTER TO DRIVEPLATE — REPLACE..... ...K604500 04-010

BOLT, SEAT BELT ANCHOR — REPLACE........................C455100 14-425

BOLT, SEAT BELT ANCHOR — REPLACE........................C455100 14-400

BOLT/PIN CHECK ASM. ALL FOUR DOORS —.................C634000 11-730

BOLT/PIN CHECK ASM. ALL FOUR DOORS —.................C634000 11-370

BOLT/PIN CHECK ASM. BOTH FRONT DOORS —...........C634050 11-370

BOLT/PIN CHECK ASM. BOTH REAR DOORS — .............C636050 11-730

BOLT/PIN CHECK ASM. LH FRONT DOOR —...................C634250 11-370

BOLT/PIN CHECK ASM. LH REAR DOOR —.....................C636250 11-730

BOLT/PIN CHECK ASM. RH FRONT DOOR —..................C634150 11-370

BOLT/PIN CHECK ASM. RH REAR DOOR —.....................C636150 11-730

BOLT/PLATE, SPARE WHEEL RETAINING —...................E001300 05-825

BOOSTER ASM. POWER BRAKE — R&R/REPLACE........H502500 04-725

BOOT LID OPENING — SPOT REPAIR..............................B100350 99-050

BOOT, AIR CLE A NER TO MASS AI R FL OW SEN—...... ....J81 8 52 0 0 3 -2 50

BOOT, AIR FLOW METER TO THROTTLE BODY —.........J818510 03-250

BOOT, AUTO TRANSMISSION SELECTOR — R&R/.........K600550 04-190

BOOT/BUMPER, PISTON ROD LH — REPLACE...............E130220 06-210

BOOT/BUMPER, PISTON ROD RH — REPLACE..............E130210 06-210

BOOT/SEAL, STEERING COLUMN TO FLOOR — .............M018200 06-253

BRACE, FRONT LONGí BOTH — TIGHTEN/......................A500000 12-425

BRACE, FRONT LONGí LH — TIGHTEN/REPLACE..........A500200 12-425

BRACE, FRONT LONGí RH — TIGHTEN/REPLACE..........A500100 12-425

BRACE, REAR QUARTER (TOW BAR ACC) —..................R603700 AA-025

BRACE/ADJUSTER, ALTERNATOR MOUNTING...............J712300 02-140

BRACKET & GUIDE ASM. ENDGATE LOCK......................C613300 12-685

BRACKET & GUIDE ASM. ENDGATE LOCK......................C613350 12-685

BRACKET, ALTERNATOR MOUNTING — REPLACE........J712100 02-140

BRACKET, ENGINE MOUNTING & COMPRESSOR..........D311100 08-200

BRACKET, LEAF SPRING/SHOCKER MOUNTING............F102400 07-150

BRACKET, LEAF SPRING/SHOCKER MOUNTING............F102300 07-150

BRACKET, OUTER DOOR HANDLE LH FRONT — ...........C621400 11-360

BRACKET, OUTER DOOR HANDLE RH FRONT —...........C621300 11-360

BRACKET/BUSHING, POWER STEERING PUMP........ .....M048100 06-400

BRAKE SYSTEM — BLEED.................................................H902500 04-725

BRIDGE, CROSSMEMBER CENTRE — REPLACE...........F 913800 04-020

BUCKLE ASM. LH REAR SEAT BELT — REPLACE..........C452600 14-425

BUCKLE ASM. RH REAR SEAT BELT — REPLACE..........C452400 14-425

BULB HOLDER, TURN SIGNAL LAMP LH — .....................N104240 02-300

BULB HOLDER, TURN SIGNAL LAMP RH —.....................N104230 02-300

BULB, 12V 55/60W HEADLAMP LH — REPLACE..............N104440 02-300

BULB, 12V 55/60W HEADLAMP RH — REPLACE........ .....N104340 02-300

BULB, 12V 55W DRIVING LAMP LH — REPLACE.......... ...N104320 02-300

BULB, 12V 55W DRIVING LAMP RH — REPLACE............N104310 02-300

BULB, BACK UP LAMP — REPLACE..................................N104380 02-375

BULB, DECKLID TAIL LAMP — REPLACE.........................N104370 02-375

BULB, FRONT FOG LAMP — REPLACE............................N104410 02-325

BULB, HEATER CON TROL — REPLACE ONE/ALL...........N221990 08-155A

BULB, HIGH MOUNTED STOP LAMP — REPLACE..........N104280 02-350

BULB, INSTRUMENT CLUSTER — REPLACE ONE/.........N221970 09-120

BULB, INSTRUMENT CLUSTER — REPLACE ONE/.........N221970 09-100

BULB, LH STOP/TAIL/TURN/REV — REPLACE ANY/.......N104400 02-350

BULB, PARK LAMP LH — REPLACE..................................N104270 02-300

BULB, PARK LAMP RH — REPLACE .................................N104300 02-300

BULB, REAR LICENCE PLATE LAMP— REPLACE...........N104290 02-385

BULB, REAR LICENCE PLATE LAMP— REPLACE...........N104290 02-375

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

BULB, RH STOP/TAIL/TURN/REV — REPLACE ANY/.......N104500 02-350

BULB, SHIFT CONTROL — REPLACE...............................N221000 04-190

BULB, TURN SIGNAL LAMP LH — REPLACE....................N104330 02-300

BULB, TURN SIGNAL LAMP RH — REPLACE...................N104350 02-300

BULB, VEHICLE INTERIOR — REPLACE...........................N104420 02-780

BULB/HOLDER, FRONT SIDE T/S LAMP LH —.................N104450 02-300

BULB/HOLDER, FRONT SIDE T/S LAMP RH —.................N104360 02-300

BUMPER ASM. PINION NOSE — REPLACE..... .................F109300 0 7- 15 0

BUMPER BAR ASM FRONT — ADJUST ............................P006100 07-500

BUMPER BAR ASM. REAR — ADJUST..............................P006900 07-525

BUMPER BAR, FRONT OR CENTRE OR ENDS —............B076520 99-050

BUMPER BAR, REAR — TOP COAT REPAIR....................B077520 99-050

BUMPER, REAR AXLE LH — REPLACE............................F109200 07-150

BUMPER, REAR AXLE RH — REPLACE............................F109100 07-150

BUMPERETTE BAR ASM, REAR LH — REPLACE............A569600 07-525

BUMPERETTE BAR ASM, REAR RH — REPLACE............A569500 07-525

BUMPERETTE , RE A R LH — TOP C OAT RE PA IR ........ ... ..B 07 7 620 99- 05 0

BUMPERETTE, REAR RH — TOP COAT REPAIR.............B077600 99-050

BUSH ASM. FRONT CONTROL ARM ROD —....................E112000 06-200

BUSH ASM. FRONT LOWER CONTROL ARM —..............E100010 06-200

BUSH ASM. LH FRONT CONTROL ARM ROD —..............E112200 06-200

BUSH ASM. LH FRONT LOWER CONTROL ARM —.........E100210 06-200

BUSH ASM. RH FRONT CONTROL ARM ROD — .............E112100 06-200

BUSH ASM. RH FRONT LOWER CONTROL ARM —........E100110 06-200

BUSH, EXTENSION HOUSING — REPLACE.....................K608120 04-200

BUSH, LEAF SPRING FRONT EYE BOTH —.....................F106000 07-150

BUSH, LEAF SPRING FRONT EYE LH — REPLACE.........F106200 07-150

BUSH, LEAF SPRING FRONT EYE RH — REPLACE....... .F106100 07-150

BUSH, REAR CROSSMEMBER/AXLE BOTH —.................F650500 07-150A

BUSH, REAR CROSSMEMBER/AXLE LH —......................F650520 07-150A

BUSH, REAR CROSSMEMBER/AXLE RH —.....................F650510 07-150A

BUSH, TRAILING ARM RR LH — REPLACE......................F111400 07-150A

BUSH, TRAILING ARM RR RH — REPLACE......................F111300 07-150A

BUSH/PLATE, RR STABILIZER BAR LH —........................F125200 07-150A

BUSH/PLATE, RR STABILIZER BAR LH —........................F125200 07-125

BUSH/PLATE, RR STABILIZER BAR RH —........................F125100 07-150A

BUSH/PLATE, RR STABILIZER BAR RH —........................F125100 07-125

BUSH/PLATE, STABILIZER BAR TO CROSSMEM—.........E109150 06-205

BUSHES, LOWER CONTROL ARM — REPLACE..............F111000 07-150

BUTTON ASM. LOCKING DOOR (1 OR ALL) —.................C622900 11-725

BUTTON ASM. LOCKING DOOR (1/ALL) —.......................C622900 11-360

BUTTON, LEVER ASM FLR SHIFT CONTROL........ ...........K500110 04-190

CABLE & LINK ASM. ENDGATE — REPLACE BOTH........C613400 12-685

CABLE & LINK ASM. ENDGATE LH — REPLACE..............C613450 12-685

CABLE & LINK ASM. ENDGATE RH — REPLACE.............C613425 12-685

CABLE ASM. ACCELERATOR CONTROL —.....................J816900 03-325

CABLE ASM. ENGINE HOOD — REPLACE .......................A517500 12-050

CABLE ASM. PARK BRAKE FRONT/CENTRE —...............H327300 04-675

CABLE ASM. PARK BRAKE LH REAR — REPLACE.........H321200 04-675

CABLE ASM. PARK BRAKE REAR BOTH SIDES —..........H321000 04-675

CABLE ASM. PARK BRAKE RH REAR — REPLACE.........H321100 04-675

CABLE, CRUISE CONTROL MOTOR — REPLACE...........R401200 03-400

CABLE, DECK LI D RELEASE — REPLACE......... ...............C456000 12-680

CABLE, FILLER DOOR RELEASE — REPLACE................C459900 03-028

CABLE, FLOOR SHIFT CONTROL — REPLACE ...............K503100 04-170

CABLE, GEARSHIFT CONTROL (ONE/BOTH) —..............K107500 04-100

CABLE, SUN ROOF — REPLACE.......................................A504300 AA-000

CABLE, THIRD S EAT BACK RELEASE — REPLACE........R902210 AA-020

CALIPER ASM. BOTH FRONT— REPLACE.......................H107000 04-750

CALIPER ASM. LH FRONT — REPLACE ...........................H107200 04-750

CALIPER ASM. REAR BOTH — REPLACE ........................H127000 04-825

CALIPER ASM. REAR LH — REPLACE..............................H127200 04-825

CALIPER ASM. REAR RH — REPLACE.............................H127100 04-825

CALIPER ASM. RH FRONT — REPLACE...........................H107100 04-750

CAM/BRACKET — THROTTLE & CRUISE CABLE.............J816910 03-325

CAMSHAFT ASM CYLS 1,3,5 EXHAUST — .......................J314570 00-175

CAMSHAFT ASM CYLS 1,3,5 INTAKE — REPLACE..........J314590 00-175

CAMSHAFT ASM. — REPLACE (EXCLUDING HFV6).......J314500 00-175

CAMSHAFT ASM. — REPLACE ALL HFV6 ........................J351000 00-175

CAMSHAFT ASM. CYLS 2,4,6 EXHAUST — ......................J314580 00-175

CAMSHAFT ASM. CYLS 2,4,6 INTAKE — REPLACE....... ..J314610 00-175

CANISTER, CHARCOAL — REPLACE ...............................L014100 03-165

CAP (PLASTIC), WHEEL NUTS — REPLACE (ONE/.........E006400 05-800

CAP ASM. FUEL TANK FILLER — REPLACE....................L006400 03-055

CAP ASM. FUEL TANK FILLER, LOCKING —....................R606000 03-055

CAP ASM. WHEEL CENTRE (ONE OR ALL) —..................E000500 05-800

CAP, CONSOLE — REPLACE (AUTO)...............................C474200 14-900

CAP, CONSOLE — REPLACE (M/T)...................................C474100 14-900

CAP, CRANKSHAFT MAIN BEARING — REPLACE...........J320100 00-200

CAP, LH TAIL LAMP — REPLACE......................................C614400 12-480

CAP, OIL FILLER — REPLACE...........................................J318500 00-025

CAP, OVERFLOW RESERVOIR/SURGE TANK .................J600150 01-140

CAP, POWER STEERING PUMP RESERVOIR — .............M048300 06-400

CAP, RADIATOR FILLER — REPL A C E ........ ... ............ ... ....J600 100 01-105

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

CAP, RH TAIL LAMP — REPLACE .....................................C614300 12-480

CAP, WINDSHIELD WASHER RESERVOIR —..................N358600 10-500

CAP/SEAL, RESERVOIR CLUTCH MASTER CYL—..........K013750 00-430

CAPPING, LH REAR ROOF — REPLACE.......... ................C897500 10-265

CAPPING, RH REAR ROOF — REPLACE........ ................. .C897400 10-265

CAPPING/MOULDING, REAR ROOF CENTRE —........ ......C897300 10-265

CARGO BARRIER — REPLACE.........................................R601250 AA-015

CARGO COVER (WAGON) — REPLACE...........................R609100 AA-000

CARGO COVER (WAGON) — REPLACE...........................R609100 14-130

CARPET & INSULATOR ASM. REAR COMPART—...........C432600 14-490

CARPET ASM. FRONT FLOOR — REPLACE....................C449100 14-475

CARPET, DECK LID LINER — REPLACE...........................C432700 14-480

CARPET, REAR SEAT BACK — REPLACE........................C431300 14-480

CARPET/INSULATOR ASM. FLOOR — REPLACE 1.........C449200 14-475

CARPET/INSULATOR ASM. REAR COMPART—..............C432600 14-480

CARPET/TRIM ASM. REAR END PANEL —.......................C431600 14-480

CASE ASM. MANUAL TRANS — REPLACE....... ................K205200 04-090

CASE, HEATER & A/C — REPLACE...................................D318150 08-150

CATCH, TAILGATE WINDOW (AWD) — REPLACE...........C020100 11-030

CD PLAYER, SATEL LITE NAVIGATION — REPLACE.......R604200 AA-000

CENTRE BOLT, LEAF SPRING LH — REPLACE...............F102200 07-150

CENTRE BOLT, LEAF SPRING RH — REPLACE..............F102100 07-150

CHAIN, L/ H SI D E SE C O ND A R Y TIMING — R&R/... ...........J2 13700 00- 22 5

CHAIN, PRIMARY TIMING — R&R/REPLACE....................J213550 00-225

CHAIN, R/H S ID E SE C O N DARY TIMING — R&R/ ... ... ........J21 36 0 0 0 0- 22 5

CHAIN/BELT, TIMING — REPLACE (EX HFV6).................J213510 00-225

CHAINS, TI MING — R&R/REPLACE ALL PRIMARY..........J213800 00-225

CHECK ASM. LH FR ONT DOOR — REPLA CE ............. .....C634200 11-370

CHECK ASM. RH FRON T DOOR — REPLA CE................ ..C 634 10 0 11-370

CHECK LINK/SPRING, LH REAR DOOR —........................C636200 11-730

CHECK LINK/SPRING, RH REAR DOOR —.......................C636100 11-730

CHILD RESTRAINT FITTING — REPLACE ........................R600100 AA-020

CIGAR LIGHTER & WIRING ASM. (COMPLETE) —...........N311650 09-300

CIGAR LIGHTER & WIRING ASM. (COMPLETE) —...........N311650 14-900

CIRCUIT BO A RD , H EAT ER A/C CONTROL —..... ............ ..D33 3 30 0 08-155A

CIRCUIT BREAKER, MAIN WIRING HARNESS.................N414600 02-425

CIRCUIT BREAKER, MAIN WIRING HARNESS.................N001790 02-425

CLAMP, BATTERY — REPLACE ........................................N002500 02-200

CLAMP, POWER STEERING HOSE ANY/ALL —...............M048700 06-400

CLAMP, RADIATOR HOSE — REPLACE (ANY).................J601400 01-160

CLAMP, RADIATOR OVERFLOW HOSES —.....................J601450 01-140

CLIP/GUIDE SLEEVE, HEAD RESTRAINT FRT............. ....C505210 14-275

CLIP/GUIDE SLEEVE, HEAD RESTRAINT REAR..............C505230 14-350

CLOCK (DIGITAL/ANALOGUE) — REPLACE.....................N308500 09-120

COCKPIT MODULE PANEL — REPAIR/REPLACE....... .....A500300 12-425

COIL ASM. (DFI) EL E CTR ONI C IGN IT ION —.. ... ... .............J724510 02 -2 25

COIL, IGNITION — REPLACE (GEN III, GEN IV)................J715100 02-235

COIL, SRS AIR B AG — REPL A CE.......... ... ... ............... .......M 2 00 200 06-225

COMBINATION VALVE/SEAL, SECONDARY AIR —.........J980930 03-300A

COMPACT DISC PLAYER/CHANGER — REPLACE....... ...R205650 09-515

COMPARTMENT ASSEMBLY FRONT FLOOR.......... .........C457500 14-900

COMPARTMENT/ASHTRAY ASM. FRONT —....................C457100 09-300

COMPARTMENT/ASHTRAY ASM. FRONT —....................C457100 14-900

COMPARTMENT/ASHTRAY ASM. REAR — ......................C457200 14-900

COMPRESSOR ASM. (LEVEL RIDE) — REPLACE............F400500 AA-225

CONDENSER ASM, PIPE & BRACKET — REPLACE........D314100 08-200

CONTAINER, JA C K ASM — REPLACE ..............................E001000 05-825

CONTENTS GAUGE LPG — REPLACE..............................L701600 AA-650R

CONTROL ASM, HEATER A/C — REPLACE......................D333100 08-155A

CONTROL ASM, RADI O & HEATER — REPLACE........... ..R205560 09-440

CONTROL CABLES, TEMP & DIRECTIONAL —................P101100 08-150

CONTROL UNIT, AUTO TRANSMISSION —......................K509600 04-170

CONTROL UNIT, TELEMATICS — REPLACE....................N446000 09-540

CONTROL UNIT/MODULE, (ABS) — REPLACE.................N506700 04-730

CONTROL VALVE LPG — REPLACE.................................L700500 AA-650R

CONTROLLE R, FUEL PUMP SPEED — REPLACE...........J546500 03-074

CONVERTER — REPLACE.................................................L700600 AA-650Q

CONVERTER ASM. — REPLACE.......................................K701100 04-200

CONVERTER COOLANT PIPES — REPLACE...................L701100 AA-650Q

COOLER, POWER STEERING — REPLACE .....................M044300 06-400

CORE ASM. HEATER WITH A/C — REPLACE...................D337100 08-150

COVER ASM. COMPLETE PARK BRAKE LEVER —.........C474700 04-675

COVER ASM. INNER WINDOW FRAME LH —...................R005400 10-400

COVER ASM. INNER WINDOW FRAME RH —..................R005300 10-400

COVER ASM. INSTRUMENT LOWER RH —......................C456700 09-200

COVER ASM. VALVE ROCKER — REPLACE BOTH.........J307050 00-025

COVER ASM. VALVE ROCKER — REPLACE CYLS..........J307250 00-025

COVER ASM. VALVE ROCKER — REPLACE CYLS..........J307150 00-025

COVER ASM. WHEEL TRIM (ONE OR ALL) —..................E000510 05-800

COVER INSTRUMENT PANEL END LH — REPLACE.......C461300 09-135

COVER INSTRUMENT PANEL END RH — ........................C461200 09-135

COVER SPEAKER, LH REAR DOOR TRIM 1/4...... ............R211900 14-270

COVER SPEAKER, RH REAR DOOR TRIM 1 /4 .................R211800 14-270

COVER, CONVERTER/CLUTCH — REPLACE...................K604400 04-010

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

COVER, DIFFERENTIAL INSPECTION — REPLACE........F653100 05-400

COVER, DOME LAMP — REPLACE...................................N112400 02-780

COVER, ENGINE BLOCK VALLEY — REPLACE...............J300620 00-375

COVER, ENGINE FRON T — RE PL ACE....... ... ... .................J313250 0 0- 508

COVER, ENGINE SIDE LH — REPLAC E.. ............ ... ...........J31 32 0 0 0 0- 50 8

COVER, ENGINE SIDE RH — REPLACE...........................J313100 00-508

COVER, ENGINE UPPER — REPLACE ONE/BOTH..........J313300 00-508

COVER, INNER ROCK ER P ANE L LH — REPL A CE...... ... ..C621700 14-100

COVER, INNER ROCKER PANEL RH — REPLACE..........C621600 14-100

COVER, LH FRONT SEAT BACK — REPLACE..................C504100 14-322

COVER, LH FRT SEAT INNER RAIL FRONT —............. ....C503550 14-322

COVER, LH FRT SEAT INNER RAIL REAR — ...................C503500 14-322

COVER, LH FRT SEAT OUTER RAIL FRONT —......... .......C503750 14-322

COVER, LH FRT SEAT OUTER RAIL REAR —..................C503700 14-322

COVER, LH FRT SEAT SIDE OUTER — REPLACE.......... .C503900 14-322

COVER, MANUAL TRANS CASE — REPLACE..................K205170 04-090

COVER, OIL TRANSFER — REPLACE (GEN III, GEN.......J315700 00-275

COVER, PLENUM CHAMBER LH — REPLACE.................D907500 10-510

COVER, PLENUM CHAMBER RH — REPLACE.................D907400 10-510

COVER, REAR CROSSOVER — REPLACE.......................C623600 14-130

COVER, REAR CROSSOVER — REPLACE.......................C623600 14-120

COVER, RELAY & FUSE HOUSING — REPLACE.............N002250 02-250

COVER, RH FRONT SEAT BACK — REPLACE.................C504000 14-322

COVER, RH FRT SEAT INNER RAIL FRONT — ................C503450 14-322

COVER, RH FRT SEAT INNER RAIL REAR —...................C503400 14-322

COVER, RH FRT SEAT OUTER RAIL FRONT —...............C503650 14-322

COVER, RH FRT SEAT OUTER RAIL REAR —........... ......C503600 14-322

COVER, RH FRT SEAT SIDE OUTER — REPLACE..........C503800 14-322

COVER, RIGID TONNEAU — REPLACE............................R407250 AA-025

COVER, SEAT BELT TENSIONER LH — REPLACE..........C520240 14-322

COVER, SEAT BELT TENSIONER RH — REPLACE........ .C520140 14-322

COVER, SOFT TONNEAU — REPLACE.............................R407200 AA-025

COVER, SPEAKER FRONT DOOR TRIM LH —.................R211300 14-220

COVER, SPEAKER FRONT DOOR TRIM RH —................R211200 14-220

COVER, STEERING COLUMN LOWER — REPLACE........M018150 06-250

COVER, STEERING COLUMN UPPER — REPLACE ........M018100 06-250

COVER, TOW BAR/TOWING EYE — REPLACE................A571520 07-525

COVER, TOWING EYE — REPLACE..................................A561520 07-500

COVER, TRANSMISSION SELECTION CONTROL —.......K508220 04-190

COVER/GASKET, GEARSHIFT MECHANISM —...............K203200 04-100

COVER/GASKET, REAR AXLE HOUSING INSPEC—........F653100 05-290

COVER/HOUSING, ENGINE FRONT — REPLACE............J313500 00-325

COVER/INS E RT, FR ON T SE A TS — REPLA CE .... ... ... ... ....R602400 AA-000

COVER/PRESSUR E PLATE ASM. — REPLACE (M/..........K013100 00-400

CRANKSHAFT — R&R/REPLACE.......................................J320000 00-200

CROSSMEMBE R ASM. FR ON T SU S P ENS ION —.............E400400 06-2 00

CROSSMEMBER ASM. REAR — RESEAL.........................A202000 12-000

CROSSMEMBER/AXLE — R&R/REPLACE........................F110300 07-150A

CROSSMEMBER/AXLE REAR — ALIGNMENT..................F209900 07-150A

CRUISE CONTROL — ADJUST..........................................R902100 03-400

CUP HOLDER — REPLACE................................................C457300 14-900

CUP HOLDER, CENTRE FASCIA (ONE/BOTH)—..............C457400 09-125

CURTAIN AIRB AG HARNESS — REPLACE BOTH............N401900 06-225

CUSHION, FRONT SEAT EXTENSIO N LH —.....................C502900 14-295

CUSHION, FRONT SEAT EXTENSIO N RH —....................C502800 14-295

CV JOINT/BOOT, LH FRONT DRIVE SHAFT —.................E303210 06-200

CV JOINT/BOOT, RH FRONT DRIVE SHAFT — ................E303110 06-200

CYLINDE R AS M. DE C K LID/T AI LGA T E/ HAT C H............. ... .C733500 12-680

CYLINDER ASM. DOOR LOCKING RH — REPLACE........C622100 11-360

CYLINDE R AS M. GL OV E BOX — REPL A CE............... ... ....C459 700 09-140

CYLINDER AS M. IGN IT ION LOC K — REPLAC E............... .N312500 06-255

CYLINDER, BRAKE MASTER — REPLACE.......................H4001 00 04-725

CYLINDER, CLUTCH MASTER — OVERHAUL..................K013900 00-430

CYLINDER, CLUTCH MASTER — REPLACE.....................K013800 00-430

CYLINDE R, CLU T CH SL A VE — OVER H A UL.............. ... ....K01370 0 00 -4 30

CYLINDE R, CLU T CH SL A VE — REPL A CE.. ... ... ............ ... .K013600 00-4 30

DAMPER ASM. TORSION AL — REPLA CE... ... ... ............... .J312500 00 -5 40

DAMPER BLOCK ASM. DIFFERENTIAL — ........................F504150 05-290

DECAL, HEATER A/C CONTROL — REPLACE .................D333200 08-155A

DECK LID ASM. — ALIGN...................................................P003900 12-660

DECK LID ASM. REAR COMPARTMENT —.......................A319910 12-660

DECK LID ASM. REAR COMPARTMENT — R & R............A319900 12-660

DECK LID ASM. RR COMPARTMENT — SPOT.................B001719 99-050

DECK LID ASM. RR COMPARTMENT — STRIP &.............B001710 99-050

DECK LID ASM. RR COMPARTMENT — TOP COAT........B001720 99-050

DECKLID PANEL/LAMP ASM. (ONE PIECE) — .................N124000 02-375

DEFLECT O R AS M. WAT E R — REPLAC E.......... ... ............ .D 90 7200 1 0 -5 10

DEFLECTOR PANEL, SUN ROOF — REPLACE................A504150 AA-000

DEFLECTOR, WATER LH FRONT DOOR —......................C406800 14-220

DEFLECTOR, WATER LH REAR DOOR —........................C417200 14-270

DEFLECTOR, WATER RH FRONT DOOR —.....................C406700 14-220

DEFLECTOR, WATER RH REAR DOOR —........................C417100 14-270

DEFLECTOR/SPOILER, ROOF — REPLACE.....................R100500 AA-005

DETECTION PAD, SEAT OCCUPANCY DRIVERS —...... ..C453400 14-295

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

DETECTION PAD, SEAT OCCUPANCY PASSEN—..........C453500 14-295

DIFFERENTIAL ASM. (COMPLETE) — REPLACE.............F650100 05-290

DIFFEREN T IA L ASM. (F WD) — REPLACE.. ... ....................K70315 6 05-25 0

DIFFEREN T IA L ASM. (R E COND IT ION ) — R & R....... ... .....F650200 05- 29 0

DIFFEREN T IA L ASM. (R E COND IT ION ) — R & R....... ... .....F650200 05- 40 0

DIFFERENTIAL ASM. FRONT (AWD) — REPLACE...........E200130 05-250

DISC ASM. FRON T BR A K E BOT H SIDE S — R& R.. ...........H10 6 00 0 04-805

DISC ASM. FRON T BR A K E LH — R&R.......... ... ............ ... ..H 10 6 200 04-805

DISC ASM. FRON T BR A K E RH — R&R....... ... ............ ... .....H106100 04-805

DISC ASM. REAR BRAKE BOTH SIDES — R&R...............H126000 04-825

DISC ASM. REAR BRAKE LH — R&R.................................H126200 04-825

DISC ASM. REAR BRAKE RH — R&R................................H126100 04-825

DOOR ASM, PASSENGER AIR BAG — REPLACE............C461600 09-125

DOOR ASM. FUEL TANK FILLER — REPLACE.................L006200 03-028

DOOR ASM. LH FRONT — ALIGN......................................P001220 12-460

DOOR ASM. LH FRONT — R & R.......................................A313600 12-460

DOOR ASM. REAR LH — ALIGN........................................P001420 12-460

DOOR ASM. REAR LH — R & R .........................................A314600 12-460

DOOR ASM. REAR RH — ALIGN........................................P001320 12-460

DOOR ASM. REAR RH — R & R.........................................A314500 12-460

DOOR ASM. RH FRONT — ALIGN .....................................P001120 12-460

DOOR ASM. RH FRONT — R & R.......................................A313500 12-460

DOOR OPENING LH FRONT — SPOT REPAIR.................B100310 99-050

DOOR OPENING LH REAR — SPOT REPAIR...................B100330 99-050

DOOR OPENING RH FRONT — SPOT REPAIR................B100300 99-050

DOOR OPENING RH REAR — SPOT REPAIR...................B100320 99-050

DOOR, FUEL TANK FILLER — TOP COAT REPAIR..........B081199 99-050

DOOR, SIDE STOWAGE REAR COMPARTMENT.............C435300 14-480

DOOR, SIDE STOWAGE, RE A R COMP A R TME N T.......... ..C 435 30 0 14-490

DOOR, SIDE STOWAGE, RE A R COMP A R TME N T.......... ..C 435 40 0 14-490

DRAIN HOSE, SUN ROOF FRONT — REPLACE...............C248500 AA-000

DRAIN HOSE, SUN ROOF REAR — REPLACE.................C249100 AA-000

DRIVE SHAFT ASM. INTERMEDIATE — R&R/..................E303300 06-200

DRIVE SHAFT ASM. LH FRONT — R&R/REPLACE..........E303200 06-200

DRIVE SHAFT ASM. RH FRONT — R&R/REPLACE..........E303100 06-200

DRIVE SHAFT, RR AXLE — REPLACE BOTH SIDES........F504000 05-290

DRIVE SHAFT, RR AXLE LH — REPLACE (RR)................F504200 05-290

DRIVE SHAFT, RR AXLE RH — REPLACE (RR)................F504100 05-290

DUCT ASM. AIR DISTRIBUTION TO CONSOLE................D352300 08-175

DUCT ASM. AIR DISTRIBUTION TO LH VENT —..............D013200 08-175

DUCT ASM. AIR DISTRIBUTION TO RH FLOOR...............D013600 08-175

DUCT ASM. AIR DISTRIBUTION TO RH VENT..................D013300 08-175

DUCT ASM. AIR DISTRIBUTION TO RH VENT..................D013100 08-175

DUCT ASM. AIR INTAKE TO AIR CLEANER —..................J818530 03-250

DUCT ASM. REAR COMPARTMENT AIR — ......................D013500 08-175

DUCT, BLOWER TRANSFER — REPLACE........................D021300 08-150

DUST CAP/O RING, DRIVING LIGHT BULB LH —.... .........N104490 02-300

DUST CAP/O RING, DRIVING LIGHT BULB RH —.......... ..N104480 02-300

DUST CAP/O RING, HEADLAMP BULB LH —....................N104470 02-300

DUST CAP/O RING, HEADLAMP BULB RH —...................N104460 02-300

DVD PLAYER — R&R/REPLACE........................................N780100 09-515

DVD PLAYER — REPROGRAM..........................................N780150 09-515

ELBOW INLET NO. 8—5 — REPLACE ...............................L700300 AA-650R

ELBOW NO. 8 LPG — REPLACE........................................L702300 AA-650R

ELEMENT ASM. AIR CLEANER — REPLACE....................J817900 03-250

EMBLEM ASM. GRILL E — REPLAC E.............. ...................C891 50 0 10-150

EMBLEM ASM. HOOD — REPL AC E... ............................ ....C881 50 0 10-150

EMBLEM/NAMEPLATE, REAR PANEL/BOOT LID/............C870900 10-150

ENGINE & TRANS. ASM. — R & R (EXCL. GEN III,...........J340100 00-500

ENGINE & TRANS. ASM. — R & R (GEN III, GEN IV)........J340200 00-500

ENGINE ASM. AS SHIPPED — REPLACE (EXCL..............J340010 00-500

ENGINE ASM. AS SHI PPED — REPLACE (G EN III, ..........J340020 00-500

ENGINE HOOD — ALIGN....................................................P003100 12-425

ENGINE HOOD OPENING — SPOT REPAIR.....................B100340 99-050

ENGINE PIPE /C A TA L Y TIC CONVERT E R (L H) —.... ... .......L50 4 10 0 03 -7 50

ENGINE PIPE /C A TA L Y TIC CONVERT E R (R H) —.............L 50 4 20 0 03-750

ENGINE PIPE/CATALYTIC CONVERTER, (ONE................L504150 03-750

ESCUTCHEON, DOOR LOCKING BUTTON (1 OR ............C622400 11-725

ESCUTCHEON, DOOR LOCKING BUTTON (1/ALL)..........C622400 11-36 0

ESCUTCHEON, REAR SIDE SEAT BELT — ......................C452700 14-425

EVAPORAT O R C OI L AS M, A/ C — REPLACE.... ... ... ..........D 33 0 20 0 08-150

EXTENSI ON AS M . FL OOR PA N EL FR ONT —............ ... ....A202 300 12 -0 00

EXTENSI ON , C ON S OLE SI DE (LH ) — RE PL A C E.......... ... .C474600 14-900

EXTENSION, CONSOLE SIDE (RH) — REPLACE.............C474500 14-900

EXTENSION, INSTRUMENT PANEL END —......................C461400 09-135

EXTENSI ON , TA I L PI PE — REPLACE................ ... ............ .R60750 0 03-750

EXTENSION/ADAPTOR HOUSING/REAR COVER —........K608100 04-200

FAN BLADE, RADIATOR COOLING — REPLACE .............J606100 01-105

FASCIA ASM. FRONT BUMPER BAR LOWER —..............A560500 07-500

FASCIA ASM. LOWER INSTRUMENT PAD CEN—............C461500 09-300

FASCIA ASM. LOWER INSTRUMENT PAD CEN—............C461540 09-300

FASCIA ASM. LOWER INSTRUMENT PAD CEN—............C461520 09-300

FASCIA ASM. RADIO/HEATER CONTROL SUR— ............C461120 09-300

FASCIA ASM. REAR BUMPER BAR COMPLETE —..........A570500 07-525

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

FASCIA, DVD PLAYER — REPLACE..................................C500500 09- 515

FASCIA, DVD SCREEN LH — REPLACE...........................C500800 09-515

FASCIA, DVD SCREEN RH — REPLACE...........................C500700 09-515

FASCIA, HEATER A/C CONTROL — REPLACE................D333150 08-155A

FASCIA, INSTRUMENT CLUSTER SURROUND —...........C462100 09-100

FENDER, PANEL LH — R & R ............................................A530200 12-425

FENDER, PANEL LH — SPOT REPAIR..............................B062300 99-050

FENDER, PANEL LH — STRIP & REPAINT........................B062310 99-050

FENDER, PANEL LH — TOP COAT REPAIR.....................B062320 99-050

FENDER, PA N E L RH — R & R..... ... ............. ... ............ ... .....A530100 12-42 5

FENDER, PA N E L RH — SPOT REP AI R ............ ... ............ ..B06 2 20 0 99-05 0

FENDER, PANEL RH — STRIP & REPAINT............ ...........B062210 99-050

FENDER, PA N E L RH — TOP COA T REPA IR.... ............ ... ..B 06 2 220 99- 05 0

FILLER BOX/VALVE, LPG — REPLACE.............................L702000 AA-650R

FILLER HOSE VENT TUBE — REPLACE...........................L702400 AA-650Q

FILLER PIP E ASM. FU E L TAN K — REPLAC E ............ ... .....L00210 0 03- 05 5

FILTER ASM, LPG VAPOUR — REPLACE.........................L701070 AA-650Q

FILTER/CARTRIDGE ASM. OIL — REPLACE....................J316200 01-500

FILTER/SEAL ASM. AUTO OIL — REPLACE.....................K611200 04-220

FINISH STRIP, HEADLINING FRONT — REPLACE...........C440100 14-150

FINISH STRIP, HEADLINING REAR — REPLACE.............C623800 14-120

FINISH STRIP, HEADLINING REAR — REPLACE.............C623800 14-130

FIRE EXTINGUISHER — REPLACE ...................................R700300 AA-000

FIRST AID KIT — REPLACE ...............................................R700100 AA-000

FLANGE ASM. DIFFERENTIAL PINION — REPLACE.......F501100 05-4 00

FLANGE ASM. DIFFERENTIAL PINION — REPLACE.......F501100 05-2 90

FLANGE ASM. TRUNION LH RR AXLE — REPLACE..... ...F201450 05-290

FLANGE ASM. TRUNION RH RR AXLE — REPLACE.......F201350 05-290

FLANGE, PROPELLER SHAFT, REAR — REPLACE.........F908300 05-050

FLARE ASM. LH FRONT WHEEL ARCH —........................C884205 10-250

FLARE ASM. LH REAR WHEEL ARCH — REPLACE.........C847205 10-250

FLARE ASM. RH FRONT WHEEL ARCH — .......................C884105 10-250

FLARE ASM. RH REAR WHEEL ARCH — REPLACE........C847105 10-250

FLARE ASM. WHEEL ARCH — REPLACE ALL (AWD.......C847005 10-250

FLASHER/RELAY ASM. TURN SIGNAL/HAZARD....... .......N117500 02-425

FLEXPLATE & RING GEAR ASM. — REPLACE.................J335550 00-400

FLOOR ASM. FRONT — RESEA L ..................... .................A201598 12-000

FLOOR ASM. REAR — RESEAL.........................................A203098 12-000

FLOOR FLANGE — REPL A CE..... ............. ... ............ ... ........L70120 0 AA -6 50 Q

FLYWHEEL & RING GEAR ASM. — REPLACE..................J335500 00-400

FOG LAMP, BOTH FRONT — REPLACE............................N008000 02-325

FOG LAMP, LH FRONT — REPLACE.................................N008020 02-325

FOG LAMP, RH FRONT — REPLACE................................N008010 02-325

FORK, M/T SHIFT, ANY ONE — REPLACE........................K108100 04-125

FORK, M/T SHIFT, ANY ONE — REPLACE........................K009710 04-090

FORK, PIN & DAMPER ASM CLUTCH — REPLACE.........K012150 00-400

FRAME ASM. FRONT SEAT BACK LH — REPLACE.........C502610 14-275

FRAME ASM. FRONT SEAT BACK LH ELEC — ................C502810 14-275

FRAME ASM. FRONT SEAT BACK RH — REPLACE........C502710 14-275

FRAME ASM. FRONT SEAT BACK RH ELEC —................C502910 14-275

FRAME ASM. FRONT SEAT CUSHION LH —....................C502700 14-275

FRAME ASM. FRONT SEAT CUSHION RH — ...................C502600 14-275

FRAME ASM. REAR SEAT BACK (COMPLETE/.............. ..C573020 14-350

FRAME, FRONT DOOR WINDOW LH — STRIP &.............B014610 99-050

FRAME, FRONT DOOR WINDOW LH — TOP COAT.........B014620 99-050

FRAME, FRONT DOOR WINDOW RH — STRIP &.............B014510 99-050

FRAME, FRONT DOOR WINDOW RH — TOP COAT........B014520 99-050

FRAME, FRONT SEAT EXTENSION LH — REPLACE.......C5598 20 14-295

FRAME, FRONT SEAT EXTENSION RH —........................C559720 14-295

FRAME, LICENCE PLATE — REPLACE.............................R608000 AA-005

FRAME, REAR DOOR WINDOW LH — STRIP &................B020610 99-050

FRAME, REAR DOOR WINDOW LH — TOP COAT...........B020620 99-050

FRAME, REAR DOOR WINDOW RH — STRIP &...............B020510 99-050

FRAME, REAR DOOR WINDOW RH — TOP COAT...........B020520 99-050

FRAME, REAR HALF (CAB CHASSIS/CREWMAN)............F110500 07-150

FUEL CHANGE OVER SWITCH — REPLACE....................L790500 AA-650Q

FUEL FILTER — REPLACE.................................................L010500 03-075

FUEL GAUGE INTERFACE OR RELAY — REPLACE........L701700 AA-650Q

FUEL HOSE (TANK AREA) ANY — REPLACE...................L008100 03-165

FUEL TANK ASM. — R&R/REPLACE.................................L001100 03-055

FUSE 10 AMP — REPLACE................................................N414510 02-425

FUSE 10 AMP — REPLACE................................................N414510 02-250

FUSE 15 AMP — REPLACE................................................N414515 02-250

FUSE 15 AMP — REPLACE................................................N414515 02-425

FUSE 20 AMP — REPLACE................................................N414520 02-250

FUSE 20 AMP — REPLACE................................................N414520 02-425

FUSE 25 AMP — REPLACE................................................N414525 02-250

FUSE 25 AMP — REPLACE................................................N414525 02-425

FUSE 5 AMP — REPLACE..................................................N414505 02-425

FUSE 7.5 AMP — REPLACE...............................................N414575 02-425

FUSE PANEL, MAIN HARNESS — REPLACE.............. ......N413599 02-425

FUSIBLE LINK, (30 AMP BOLT IN) — REPLACE...............N001760 02-250

FUSIBLE LINK, (30 AMP PUSH IN) — REPLACE...............N104520 02-250

FUSIBLE LINK, (40 AMP PUSH IN) — REPLACE...............N001870 02-250

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

FUSIBLE LINK, (60 AMP BOL T IN ) — REPL AC E ...............N10453 0 02-250

FUSIBLE LINK, (60 AMP PUS H IN ) — REPL ACE.......... ... ..N 10 4 51 0 02-250

GASKET, CYLINDER HEAD — REPLACE BOTH...............J310000 00-075

GASKET, CYLINDER HEAD — REPLACE CYLS...............J310200 00-075

GASKET, CYLINDER HEAD — REPLACE CYLS...............J310100 00-075

GASKET, DIFF INSPECTION COVER — REPLACE..........F653100 05-400

GASKET, ENGINE FRONT COVER — REPLACE..............J313550 00-325

GASKET, INLET MANIFOLD — REPLACE......... ................J300500 00-375

GASKET, INLET MANIFOLD UPPER — REPLACE............J301510 00-375

GASKET, OIL FI LTER ADAPTOR — REPLACE........... ......J316100 01-500

GASKET, OIL PAN — REPLACE.........................................J315500 00-275

GASKET, SUPERCHARGER TO MANIFOLD —............. ....J590500 00-375

GASKET, THROTTLE BODY TO ADAPTOR —........... .......J805200 03-300

GASKET, VALVE ROCKER COVER — REPLACE.............J307000 00-025

GASKET, VALVE ROCKER COVER — REPLACE.............J307200 00-025

GASKET, VALVE ROCKER COVER — REPLACE.............J307100 00-025

GASKET/SEAL, OIL PUMP SUCTION PIPE —...................J117300 00-251

GASKET/SEAL, THROTTLE BODY — REPLACE...............J805220 03-300

GASKET/SEAL, WATER PUMP TO COVER —..................J609150 00-325

GASKET/SEALING RING, (ANY) — REPLACE............ .......L501100 03-750

GAUGE ASM, INCLINOMETER — REPLACE.....................N300100 09-125

GAUGE ASM, OIL PRESSURE — REPLACE.....................N303500 09-125

GAUGE ASM, VOLTMETER — REPLACE..........................N307500 09-125

GAUGE, FUEL INSTRUMENT — REPLACE.......................N301500 09-120

GAUGE, TEMPERATURE (DASH UNIT) —........................N306500 09-120

GEAR ASM. (REVERSE) — REPLACE...............................K108280 04-125

GEAR ASM. POWER STEERING — R&R/OVER—............M041010 06-275

GEAR ASM. POWER STEERING — R&R/REPLACE.........M041000 06-275

GEAR SET, TEMPERATURE CONTROL — .......................D107100 08-155A

GEAR, CAMSHAF T (OR THRU ST PLATE) —. ... ... ..............J3 1 45 5 0 0 0- 22 5

GEAR, COUNTER (CLUSTER) — REPLACE.....................K108500 04-125

GEAR, SPEEDOMET ER DRIVE — REPLACE M/T.............K202500 04-125

GEAR/SYNCHRO ASM. (1ST) — REPLACE.......................K108200 04-125

GEAR/SYNCHRO ASM. (2ND) — REPLACE......................K108210 04-125

GEAR/SYNCHRO ASM. (3RD) — REPLACE......................K108220 04-125

GEAR/SYNCHRO ASM. (4TH) — REPLACE ......................K108230 04-125

GEAR/SYNCHRO ASM. (5TH) — REPLACE ......................K108240 04-125

GEAR/SYNCHRO ASM. (6TH) — REPLACE ......................K108250 04-125

GEARS/DRIVE SHAFT/BUSH/PLATE, OIL PUMP —.........J316600 01-500

GLASS ASM. LH FRONT DOOR DROP WINDOW —.........C005200 11-025

GLASS ASM. LH FRONT DOOR DROP WINDOW —.........P008200 11-025

GLASS ASM. LH FRONT DOOR DROP WINDOW —.........P008200 11-020

GLASS ASM. LH FRONT DOOR DROP WINDOW —.........C005200 11-020

GLASS ASM. LH FRONT DOOR DROP WINDOW —.........P008200 11-030

GLASS ASM. LH FRONT DOOR DROP WINDOW —.........C005200 11-030

GLASS ASM. LH REAR DOOR DROP WINDOW —...........C013200 11-030

GLASS ASM. LH REAR DOOR DROP WINDOW —...........P008600 11-020

GLASS ASM. LH REAR DOOR DROP WINDOW —...........C013200 11-020

GLASS ASM. LH REAR DOOR DROP WINDOW —...........P008600 11-030

GLASS ASM. QUARTER WINDOW (C PILLAR) LH —.......C004270 11-030

GLASS ASM. QUARTER WINDOW (C PILLAR) LH —.......C004250 11-030

GLASS ASM. QUARTER WINDOW (C PILLAR) RH —.......C0041 50 11-030

GLASS ASM. QUARTER WINDOW (C PILLAR) RH —.......C0041 70 11-030

GLASS ASM. REAR DOOR FIXED WINDOW LH —...........C017200 11-030

GLASS ASM. REAR DOOR FIXED WINDOW RH —..........C017100 11-030

GLASS ASM. REAR WINDOW — RESEAL............. ............C002500 11-020

GLASS ASM. REAR WINDOW — RESEAL............. ............C002500 11-025

GLASS ASM. REAR WINDOW REPLACE (LONG......... .. ...C002000 11-020

GLASS ASM. REAR WINDOW REPLACE (LONG......... .. ...C002000 11-025

GLASS ASM. REAR WINDOW REPLACE (SHORT............C002100 11-020

GLASS ASM. REAR WINDOW REPLACE (SHORT............C002100 11-025

GLASS ASM. RH FRONT DOOR DROP WINDOW —........P008100 11-025

GLASS ASM. RH FRONT DOOR DROP WINDOW —........P008100 11-020

GLASS ASM. RH FRONT DOOR DROP WINDOW —........C005100 11-020

GLASS ASM. RH FRONT DOOR DROP WINDOW —........C005100 11-030

GLASS ASM. RH FRONT DOOR DROP WINDOW —........P008100 11-030

GLASS ASM. RH FRONT DOOR DROP WINDOW —........C005100 11-025

GLASS ASM. RH REAR DOOR DROP WINDOW —..........C013100 11-020

GLASS ASM. RH REAR DOOR DROP WINDOW —..........C013100 11-030

GLASS ASM. RH REAR DOOR DROP WINDOW —..........P008500 11-020

GLASS ASM. RH REAR DOOR DROP WINDOW —..........P008500 11-030

GLASS ASM. SIDE PA NEL (C PILLAR FIXED) LH —.........C004200 11-020

GLASS ASM. SIDE PA NEL (C PILLAR FIXED) LH —.........C004210 11-020

GLASS ASM. SIDE PA NEL (C PILLAR FIXED) RH —........C004100 11-020

GLASS ASM. SIDE PA NEL (C PILLAR FIXED) RH —........C004110 11-020

GLASS ASM. SIDE PANEL LH — REPLACE......................C0042 00 11-025

GLASS ASM. SIDE PANEL LH — RESEAL.......... ...............C004210 11-025

GLASS ASM. SIDE PANEL RH — REPLACE .....................C0041 00 11-025

GLASS ASM. SIDE PANEL RH — RESEAL.................. ......C0041 10 11-025

GLASS ASM. TAILGATE — REPLACE (AWD.....................C020000 11-030

GLASS ASM. TAILGATE/HATCH — REPLACE..................C020000 11-030

GLASS ASM. TAILGATE/HATCH — REPLACE..................C020010 11-030

GLASS ASM. TAILGATE/HATCH — RESEAL.....................C020500 11-030

GLASS ASM. WINDSHIELD — RESEAL.............................C001200 11-020

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

GLASS ASM. WINDSHIELD — RESEAL.............................C001200 11-025

GLASS ASM. WINDSHIELD — RESEAL.............................C001200 11-030

GLASS ASM. WINDSHIELD REPLACE (LONG..................C001000 11-030

GLASS ASM. WINDSHIELD REPLACE (LONG..................C001000 11-020

GLASS ASM. WINDSHIELD REPLACE (LONG..................C001000 11-025

GLASS ASM. WINDSHIELD REPLACE (SHORT................C001010 11-030

GLASS ASM. WINDSHIELD REPLACE (SHORT................C001010 11-020

GLASS ASM. WINDSHIELD REPLACE (SHORT................C001010 11-025

GLASS, CANOPY QUARTER LEFT HAND (HBD...............C021300 11-025

GLASS, CANOPY QUARTER RIGHT HAND (HBD.............C021250 11-025

GLASS, CANOPY TAILGATE (HBD CANOPY....................C021200 11-025

GLASS/WEATHERSTRIP ASM. DOOR FIXED WIN—........C017100 11-020

GLASS/WEATHERSTRIP ASM. DOOR FIXED WIN—........C017200 11-020

GLOVE BOX ASM. INSTRUMENT PANEL —.....................C459100 09-140

GRID, REAR WINDOW DEMIST — REPAIR.......................D906199 11-020

GRID, REAR WINDOW DEMIST — REPAIR.......................D906199 11-030

GRILL, REAR SHELF SPEAKER LH — REPLACE...... .......C212100 14-460

GRILL, REAR SHELF SPEAKER RH — REPLACE............C212000 14-460

GRILLE ASM. (ONE/BOTH) — REPLACE...........................A550000 07-500

GRILLE ASM. (RADIATOR) — TOP COAT REPAIR...........B078520 99-050

GRILLE ASM. DEMIST NOZZLE LH — REPLACE..............D907320 09-125

GRILLE ASM. DEMIST NOZZLE RH — REPLACE.............D907310 09-125

GRILLE, LOWER RADIATOR, R&R/REPLACE...................A568100 07-500

GUARD, BONNET PROTECTOR — REPLACE..................C896100 AA-000

GUARD, HEAD L A MP STONE — REPLACE BOT H . ... ........C895 000 AA-005

GUARD, HEAD L A MP ST ON E LH — REP L AC E............. ... ..C 89 5 200 AA-005

GUARD, HEADLAMP STONE RH — REPLACE.................C895100 AA-005

GUARD, OIL PAN ASM — REPLACE .................................J315400 06-200

GUIDE RAIL ASM. REAR DROP WINDOW LH —..............C013270 11-750

GUIDE RAIL ASM. REAR DROP WINDOW RH —..............C013170 11-750

GUIDE RAIL, LH FRONT DROP WINDOW —.....................C008240 11-625

GUIDE RAIL, RH FRONT DROP WINDOW —....................C008260 11-625

GUIDE RAILS, BOTH SIDES, SUN ROOF —......................A504200 AA-000

GUIDE, LIFTERS/PUSH RODS — REPLACE CYLS...........J307135 00-050

GUIDE, LIFTERS/PUSH RODS — REPLACE CYLS...........J307235 00-050

HAND SET, SATELLITE NAVIGATION — REPLACE.........R604400 AA-000

HANDLE ASM. DOOR OUTER LH FRONT —.....................C621200 11-360

HANDLE ASM. DOOR OUTER LH REAR —.......................C640200 11-725

HANDLE ASM. DOOR OUTER RH FRONT —....................C621100 11-360

HANDLE ASM. DOOR OUTER RH REAR — ......................C640100 11-725

HANDLE ASM. ENDGATE REMOTE CONTROL —............C613100 12-685

HANDLE ASM. TAILGATE — REPLACE.............................C734500 02-385

HANDLE, ASSIST GRIP (ANY ONE) — REPLACE.............C317000 14-100

HANDLE, DOOR OUTSIDE LHF — TOP COAT..................B081250 99-050

HANDLE, DOOR OUTSIDE LHR — TOP COAT.................B081350 99-050

HANDLE, DOOR OUTSIDE RHF — TOP COAT.................B081200 99-050

HANDLE, DOOR OUTSIDE RHR — TOP COAT.................B081300 99-050

HANDLE. FRONT WINDOW REGULATOR (1 OR 2)..........C332100 11-675

HANDLE. REAR WINDOW REGULATOR (1 OR 2) —........C332200 11-810

HANDLE/ARMREST, LH FRONT DOOR (INTE—...............C406250 14-220

HANDLE/ARMREST, LH REAR DOOR (INTERIOR)...........C414250 14-270

HANDLE/ARMREST, RH FRONT DOOR (INTE—..............C406150 14-220

HANDLE/ARMREST, RH REAR DOOR (INTERIOR)..........C414150 14-270

HANGER/BRACKET {EXHAUST} — REPLACE..................L512220 03-750

HARNESS ASM. TRANS EXTERNAL — REPLACE...........N482699 04-170

HARNESS ASM. TRANS. EXTERNAL — REPLACE..........N482699 04-075

HARNESS ASM. VACUUM HOSES — REPAIR/.................D118000 08-150

HARNESS, LEVEL RIDE POWER — REPAIR/...................F400800 AA-225

HARNESS , RE SIS T OR BL OWE R & C ON T R OL —.............N40859 9 08-150

HARNESS, TRAILER WIRING — REPAIR/REPLACE........R603600 AA-020

HEAD ASM. CYLINDER (COMPLETE) — REPLACE .........J310550 00-075

HEAD ASM. CYLINDER (COMPLETE) — REPLACE .........J310600 00-075

HEAD ASM. CYLINDER (COMPLETE) — REPLACE .........J310450 00-075

HEAD ASM. CYLINDER (LESS VALVES) —.......................J310400 00-075

HEAD ASM. CYLINDER (LESS VALVES) —.......................J310500 00-075

HEAD ASM. CYLINDER (LESS VALVES) —.......................J310300 00-075

HEAD ASM. CYLINDER — OVERHAUL BOTH SIDES.......J310050 00-075

HEAD ASM. CYLIN DER — OVERHAUL CYLS 1,3,5,.........J310150 00-075

HEAD ASM. CYLIN DER — OVERHAUL CYLS 2,4,6,.........J310250 00-075

HEADLAMP ASM. LH — REPLACE ....................................N104200 02-300

HEADLAMP ASM. RH — REPLACE....................................N104100 02-300

HEADLINING, ROOF — REPLACE.....................................C400100 14-150

HEADPHONE ASM — REPLACE........................................R213399 09-515

HEATER EVAPORATOR ASM. — REPLACE.....................D318100 08-150

HEATING MAT, LH FRONT SEAT BACK —........................D130710 14-295

HEATING MAT, LH FRONT SEAT CUSHION —.................D130610 14-295

HEATING MAT, LH FRONT SEAT EXTENSION —.............D130410 14-295

HEATING MAT, RH FRONT SEAT BACK —.......................D130700 14-295

HEATING MAT, RH FRONT SEAT CUSHION —................D130600 14-295

HEATING MAT, RH FRONT SEAT EXTENSION —............D130400 14-295

HEATSHIELD, INTERMEDIATE MUFFLER (RH) — ...........L509500 03-750

HEATSHIELD, INTERMEDIATE MUFFLER —....................L509600 03-750

HEATSHIELD, REAR MUFFLER — REPLACE...................L509700 03-750

HEATSHIELD, REAR MUFFLER — REPLACE R/H............L509710 03-750

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

HEIGHT ADJUSTER, LH FRONT SEAT BELT — ...............C455750 14-400

HEIGHT ADJUSTER, RH FRONT SEAT BELT —...............C455700 14-400

HEIGHT SENSOR ASM — REPLACE.................................F400200 AA-225

HINGE ASM. DECK LID LH — REPLACE...........................C701400 12-660

HINGE ASM. DECK LID RH — REPLACE...........................C701300 12-660

HINGE ASM. ENDGATE LH — REPLACE..........................C613750 12-685

HINGE ASM. ENDGATE RH — REPLACE..........................C613700 12-685

HINGE ASM. ENGINE HOOD LH — REPLACE..................A501200 12-050

HINGE ASM. ENGINE HOOD RH — REPLACE..................A501100 12-050

HINGE ASM. SEAT HATCH LH — REPLACE.....................C572400 14-350

HINGE ASM. SEAT HATCH RH — REPLACE....................C572300 14-350

HINGE, CEN T RE PI LL A R (B ) LOWE R RH /LH —..... ... ... .....C644250 11-730

HINGE, CEN T RE PI LL A R (B ) UPPER RH/LH —.................C644150 11-730

HINGE, FRONT DOOR LOWER RH/LH — REPLACE........C625200 11-370

HINGE, FRONT DOOR UPPER RH/LH — REPLACE.........C625100 11-370

HINGE, FRONT PILLAR (A) LOWER RH/LH — . ............... ..C 62 5 250 11-370

HINGE, FRONT PILLAR (A) UPPER RH/LH —...................C625150 11-370

HINGE, REAR DOOR LOWER RH/LH — RE PLACE ..........C644200 11-730

HINGE, REAR DOOR UPPER RH/LH — REPLACE...........C644100 11-730

HINGE, TAILGATE/HATCH LH — REPLACE......................C701200 12-500

HINGE, TAILGATE/HATCH RH — REPLACE.....................C701100 12-500

HOIST, SPARE WHEEL (UTE) — REPLACE......................R426500 05-825

HOLDER, GARAGE DOOR/SUNGLASS —.........................C402300 14-050

HOLDER, MOBILE PHONE — REPLACE...........................R300400 09-525

HOOD LOCK SECO ND A R Y C AT C H — RE PL A C E..... ........A51950 0 12- 050

HORN & BRACKET ASM. (L/H) — REPLACE.....................N200550 02-400

HORN & BRACKET ASM. (R/H 1 OR 2) — REPLACE....... .N200500 02-400

HORN & BRACKET ASM. ANTI THEFT — REPLACE........N200600 09-552

HORN & BRACKET ASM. ANTI THEFT — REPLACE........N200600 09-540

HOSE ASM, HEATER — REPL ACE (GEN III, GEN IV)...... .D111110 08-075

HOSE ASM. A/C EVAPORATOR FRONT —................. ......D307050 08-200

HOSE ASM. COMPRESSOR SUCTION & DIS—................D307000 08-200

HOSE LPG SERVICE — REPLACE....................................L702200 AA-650R

HOSE VAPOUR FEED LINE LPG — REPLACE.................L700900 AA-650R

HOSE, (ENGINE TO HEATER VALVE) OUTLET —............D111500 08-075

HOSE, (HEATER VALVE TO ENGINE) INLET —................D111400 08-075

HOSE, BY PASS — REPLACE............................................D111300 08-075

HOSE, CHECK VALVE VACUUM — REPLACE..................H503100 04-725

HOSE, CLUTCH M/CYL TO RESERVOIR —....... ...............K062550 00-430

HOSE, CONNECTING TUBE TO ENGINE (S/C,.................J601210 01-160

HOSE, COOLANT AIR BLEED (GEN III, GEN IV) —...........J326500 01-160

HOSE, CRANKC A SE VE N T — REPL A C E ............ ... ...........J95 01 1 0 00-249

HOSE, ENGINE FUEL RETURN TO FUEL RETURN..........J9012 00 03-375

HOSE, ENGINE TO RADIATOR INLET PIPE (S/C..............J602300 01-160

HOSE, FILLER PIPE TO FUEL TANK — REPLACE...........L002300 03-055

HOSE, FRONT BRAKE — REPLACE BOTH SIDES...........H402000 04-750

HOSE, FRONT BRAKE LH — REPLAC E... ... ............ ... .......H40 2 20 0 04-750

HOSE, FRONT BRAKE RH — REPL A CE... ... ... ............ ... ....H402 100 04-750

HOSE, FUEL FEED PIPE TO ENGINE FUEL FEED —.......J901100 03-375

HOSE, LPG FILLER — REPLACE.......................................L702100 AA-650R

HOSE, LPG INJECTOR — REPLACE.................................L701040 AA-650Q

HOSE, OIL C OOLE R (IN L E T) — REPL A C E........... ... ..........K 60 5 20 0 04-1 50

HOSE, P1 SENSOR — REPLACE.......................................L701020 AA-650Q

HOSE, POWER STEERING COOLER — REPLACE..........M044400 06-400

HOSE, PRESSURE CLUTCH — REPLACE........................K062500 00-430

HOSE, RADIATOR TO OVERFLOW RESERVOIR —.........J601600 01-140

HOSE, RESERVOIR TO TAILGATE/HATCH —.......... ........N357200 10-500

HOSE, RETUR N — REPLACE................ ... ............ ... ..........M048000 06-400

HOSE, RR BRAKE — REPLACE BOTH SIDES..................H412000 04-750

HOSE, RR BRA KE LH — REP L AC E .......... ... ............ ... .......H 41 2 20 0 04-750

HOSE, RR BRA KE RH — REP L AC E............. ... ............ ... ....H41 2 10 0 04-750

HOSE, TAILGATE/HATCH WINDOW WASHER —.............N758500 10-500

HOSE, VACU UM ANY ONE — REPL A C E..... ... ... ... .............D907100 08-025

HOSE, VALVE TO HEATER CORE (LOWER) —................D111200 08-075

HOSE, VALVE TO HEATER CORE (UPPER) —.................D111100 08-075

HOSE, WINDSHIE L D WAS H E R ENGIN E BAY ...... ... ... .......N357 10 0 10-500

HOSE/GROMMET EVAPORATOR DRAIN —.....................D323100 08-150

HOSE/PIPE ASM. OIL COOLER TO TRANS.......................K603100 04-150

HOSE/PIPE ASM. TRANS TO OIL COOLER (OUT—.........K603200 04-150

HOSE/PIPE, RESERVOIR TO PUMP — REPLACE............M048500 06-400

HOSES, AIR DUCT , SECONDARY AIR PUMP, —..............J980710 03-300A

HOSES, RADIAT OR BOTH — REPLACE................ ...........J601000 01-160

HOSES, RADIAT OR LOWER/OUTLET — REPLACE.........J6012 00 01-160

HOSES, RADIAT OR UPPER/INLET — REPLACE..............J601100 01-160

HOUSING ASM. — REPLACE.............................................M041100 06-310

HOUSING ASM. CEN TRE AIR OUTLET — REPLACE.......D358300 08-175

HOUSING ASM. M/T EXTENSION — REPLACE (V6 .........K201500 04-100

HOUSING, CONSOLE ASM — REPLACE ..........................C474000 14-900

HOUSING, COOLANT INLET — REPLACE........................J608200 00-350

HOUSING, FUSIBLE LINK — REPLACE.............................N002300 02-250

HOUSING, REAR AXLE — REPLACE.................................F651100 05-400

HOUSING, RELAY & FUSE — REPLA C E........... ... ............ .N002200 02-250

HUB/BEARING, FRONT WHEEL BOTH SIDES —..............E115000 06-212

HUB/BEARING, FRONT WHEEL LH — REPLACE.............E115200 04-805

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

HUB/BEARING, FRONT WHEEL LH — REPLACE.............E115200 06-212

HUB/BEARING, FRONT WHEEL RH — REPLACE............E115100 06-212

HUB/OR BEARING, FRONT WHEEL BOTH SIDES —.......E115000 04-805

HUB/OR BEARI NG, FR ONT WHE E L RH —....... ............... ..E 115 10 0 04-80 5

HYDRAULIC MODULATOR (ABS) — REPLACE................H901100 04-730

HYDRAULIC TENSIONER — PRIMARY TIMING................J314000 00-225

HYDRAULIC TENSIONER — SECONDARY TIMING.........J313900 00-225

HYDRAULIC TENSIONER — SECONDARY TIMING.........J314100 00-225

IDLER GEAR, L/H SIDE — REPLACE.................................J214150 00-225

IDLER GEAR, R/H SIDE — REPLACE................................J214200 00-225

IDLER PULLEY, AIR CONDITIONING — REPLACE...........D312050 01-020

IDLER PULLEY, MAIN BELT — REPLACE.........................J606800 01-020

IDLER PULLEY, MAIN DRIVE BELT (WITH A/C) —...........J607550 01-030

IDLER PULLEY, MAIN DRIVE BELT — REPLACE.............J607350 01-030

INDICATOR ASM. AUTO OIL LEVEL — REPLACE...... ......K604300 04-010

INDICATOR, OIL LEVEL — REPLACE................................J317500 00-580

INJECTOR ASM, LPG — REPLACE ...................................L701050 AA-650Q

INJECTOR ASM. FUEL — REPLACE (ONE/ALL)...............J900000 03-375

INSERT, BUMPER FASCIA ALUMINIUM LH —..................A567600 07-525

INSERT, BUMPER FASCIA ALUMINIUM REPLACE..........A567800 07-525

INSERT, BUMPER FASCIA ALUMINIUM RH —.................A567500 07-525

INSERT, FOG LAMPS (ONE/BOTH) — REPLACE.............A506000 07-500

INSERT, FRONT DOOR TRIM LH — REPLACE.................C407200 14-220

INSERT, FRONT DOOR TRI M RH — REPLA CE................C407 100 14-220

INSERT, INNER ROCKER PANEL LH FRONT —...............C621900 14-100

INSERT, INNER ROCKER PANEL LH REAR —.................C621950 14-100

INSERT, INNER ROCKER PANEL RH FRONT —..............C621800 14-100

INSERT, INNER ROCKER PANEL RH REAR —.................C621850 14-100

INSERT, REAR BUMPER FASCIA CHROME LH OR .........A567900 07-525

INSERT, REAR DOOR TRIM LH — REPLACE...................C407800 14-270

INSERT, REAR DOOR TRIM RH — REPLACE...................C407700 14-270

INSERT, ROCKER PANEL ALUMINIUM MOULD—............A506300 10-300

INSERT, ROCKER PANEL ALUMINIUM MOULD—............A506400 10-300

INSERT, TRAILER HITCH ALUMINIUM CENTRE —..........A567700 07-525

INSTRUMENT CLUSTER — REPLACE..............................N312600 09-100

INSTRUMENT CLUSTER — REPROGRAM.......................N312700 09-100

INSULATION HEADLINING, ROOF — REPLACE...............C400200 14-150

INSULATOR ASM. POWER PLANT REAR —.....................J338000 04-020

INSULATOR, EN GIN E HOOD — REPLA CE .......................A 505 50 0 12-05 0

INSULATOR , EX H A US T TAI L P IP E SU P P O RT — ... ... ........L51 2 23 0 03- 75 0

INSULATOR, FRONT PIPE SUPPORT — REPLACE.........L512240 03-750

INSULATOR, INTERMEDIATE EXHAUST PIPE.................L512210 03-750

INSULATOR, SPRING UPPER FRONT COIL LH —...........E105220 06-210

INSULATOR, SPRING UPPER FRONT COIL RH —...........E105120 06-210

INSULATOR/ SEAT, REAR COIL SPRING LOWER.............F203150 07-150

INSULATOR/ SEAT, REAR COIL SPRING LOWER.............F202150 07-150

INSULATOR/ SEAT, REAR COIL SPRING UPPER.............F203100 07-150

INSULATOR/ SEAT, REAR COIL SPRING UPPER.............F202100 07-150

INTERFACE MODULE, SATELLITE NAVIGATION —........R604300 AA-000

JACK ASM. LIFTING — REPLACE......................................E001500 05-825

KNOB, BACK REST ADJUSTER SWITCH LH —................N264600 14-275

KNOB, BACK REST ADJUSTER SWITCH RH — ...............N264500 14-275

KNOB, GEAR SELECT O R LEVER — REPLACE (V6.........K101100 04-060

KNOB, HEATER A/C CONTROL (ANY) — REPLACE........D333250 08-155A

KNOB, REAR SEAT BACK OR HATCH LOCK LH/.............C584200 14-350

KNOB, REAR SEAT BACK OR HATCH LOCK RH —.........C584100 14-350

KNOB, SEAT ADJUSTER SWITCH LH — REPLACE....... ..N264400 14-275

KNOB, SEAT ADJUSTER SWITCH RH — REPLACE.........N264300 14-275

KNOB/SPRING, PARK BRAKE LEVER — REPLACE.........H325500 04-675

KNUCKLE/ARM ASM. STEERING LH — REPLACE...........E111200 06-212

KNUCKLE/ARM ASM. STEERING RH — REPLACE..........E111100 06-212

LAMP & LENS, REAR LH — REPLACE..............................N122200 02-350

LAMP & LENS, REAR RH — REPLACE..............................N122100 02-350

LAMP ASM, HIGH MOUNT STOP (UTE WITH....................R902400 02-350

LAMP ASM, HIGH MOUNT STOP (UTE WITH....................R902400 AA-020

LAMP ASM. DOME — REPLACE........................................N112500 02-780

LAMP ASM. GLOVE BOX — REPLACE..............................N214500 02-780

LAMP ASM. HIGH MOUNTED STOP — REPLACE............R902400 02-350

LAMP ASM. LH REAR — REPLACE ...................................N112700 02-780

LAMP ASM. REAR COMPARTMENT — REPLACE............N112510 02-780

LAMP ASM. REAR LICENCE — REPLACE ........................N126500 02-375

LAMP ASM. REAR LICENCE — REPLACE ........................N126500 02-385

LAMP ASM. RH REAR — REPLACE...................................N112600 02-780

LAMP ASM. SIDE T/S LH — REPLACE..............................N118400 02-300

LAMP ASM. SIDE T/S RH — REPLACE..............................N118300 02-300

LAMP, DOOR COURTESY LH FRONT — REPLACE.........N319100 02-780

LAMP, DOOR COURTESY LH REAR — REPLACE ...........N319300 02-780

LAMP, DOOR COURTES Y RH FRONT — REPLACE........N319000 02-780

LAMP, DOOR COURTESY RH REAR — REPLACE...........N319200 02-780

LAMP/GLOBE ASM, PUDDLE — REPLACE L/H................R005610 10-400

LAMP/GLOBE ASM, PUDDLE — REPLACE R/H................R005510 10-400

LATCH ASM. DE C K LID/TAILGAT E/ H AT C H — ..... ... ... .......C75 2 00 0 12-680

LATCH ASM. ENDGATE LOCK LH — REPLACE........ .......C613250 12-685

LATCH ASM. ENDGATE LOCK RH — REPLACE...............C613200 12-685

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

LATCH/AC T UA T OR A SM. FI LL E R DOOR .......... ... ... ...........L00 6 22 0 03- 02 8

LEAD ASM. ANTENNA — REPLACE..................................R200150 09-400

LEAD ASM. SPARK PLUG (1 OR ALL) — REPLACE.........J730100 02-030

LEAD CABLE, DVD PLAYER — R&R/REPLACE...... ..........N780110 09-515

LEAD, MOBILE PHONE ANTENNA — REPLACE...............R300300 09-525

LEAD/CABLE, COMPACT DISC PLAYER/........... ...............R205655 09-515

LENS ASM. REFLEX LH — REPLACE................................A571575 02-350

LENS ASM. REFLEX RH — REPLACE...............................A571550 02-350

LENS/CAP ASM. REFLEX LH — REPLACE.......................A571575 07-525

LENS/CAP ASM. REFLEX RH — REPLACE.......................A571550 07-525

LENS/MASK, INSTRUMENT CL USTER — REPLACE.... ....N300600 09-120

LENS/MASK, INSTRUMENT CL USTER — REPLACE.... ....N300600 09-100

LEVER ASM, TILT STEERING — REPLACE......................M015300 06-253

LEVER ASM. ACCELERATOR CONTROL —.....................J815500 03-650

LEVER ASM. DECK LID & FILLER DOOR..........................C459810 03-028

LEVER ASM. FILLER DOOR RELEASE —.............. ...........C459800 03-028

LEVER ASM. PARK BRAKE — REPLACE..........................H325100 04-675

LEVER ASM. SELECTOR (AUTO FLOOR SHIFT) —.........K500100 04-190

LEVER, GEAR SHIFT CONTROL — REPLACE (M/T)........K104100 04-060

LH MIRROR, OUTSIDE REAR VIEW — TOP COAT...........B081630 99-050

LIFTER, HY DR A U LI C VA L V E (A LL) — REPLACE... ... ........J31 11 0 0 00-050

LINE, PRESSURE CLUTCH — REPLACE.......... ................K063500 00-430

LINE, PRESSURE HOSE TO SLAVE CYL —.... ..................K063550 00-430

LINER ASM. (ONE OR ALL) — REPLACE..........................C474300 14-900

LINER ASM. — REPLACE...................................................C474300 09-300

LINER, CARGO BED — REPLACE .....................................R407100 AA-025

LINER, FRONT FENDER LH — REPLACE.........................A531200 12-100

LINER, FRONT FENDER RH — REPLACE.........................A531100 12-100

LINER, REAR WHEELHOUSE, LH — REPLACE................A531400 12-100

LINER, REAR WHEELHOUSE, RH — REPLACE...............A531300 12-100

LINER, TAIL GA TE — REPLACE ............ ... ............ ... ...........R40 7 35 0 AA-025

LINK ASM. REAR SUSPENSION ADJUSTMENT...............F104000 07-150A

LINK ASM. REAR SUSPENSION ADJUSTMENT LH..........F104200 07-1 50A

LINK ASM. REAR SUSPENSION ADJUSTMENT RH.........F104100 07-150A

LINK, HEIGHT SENSOR OR BALL PIVOT —......................F400100 AA-225

LINKAGE ASM. WI NDSHIELD WIPER BOTH SIDES.........N351000 10-506

LINKAGE ASM. WINDSHIELD WIPER LH —......................N351200 10-506

LINKAGE ASM. WINDSHIELD WIPER RH —.....................N351100 10-506

LOCK ASM. LH FRONT DOOR — REPLACE.....................C623000 11-360

LOCK ASM. LH REAR DOOR — REPLACE........................C641000 11-725

LOCK ASM. RH FRONT DOOR — REPLACE.....................C622000 11-360

LOCK ASM. RH REAR DOOR — REPLACE.......................C642000 11-725

LONG MOTOR — REPLACE (GEN III, GEN IV ONLY).......J340300 00-248

LOUVRE REAR WINDOW (EXT) — REPLACE...................R601900 AA-020

LPG BODY HARNESS — REPLACE...................................L790100 AA-650Q

LPG CYLINDER — REPLACE.............................................L701300 AA-650Q

LPG ENGINE HARNESS — REPLACE...............................L790000 AA-650Q

LUGGAGE RACK, RAILS/CROSS OVERS (ROOF) —.......R100100 AA-005

LUMBAR SUPPORT LH — REPLACE.................................C506800 14-275

LUMBAR SUPPORT RH — REPLACE................................C502750 14-275

MANIFOLD ASM. EX H A US T — REPL AC E CY LS........... ... .J303100 0 0 -4 50

MANIFOLD ASM. EX H A US T — REPL AC E CY LS........... ... .J303200 0 0 -4 50

MANIFOLD COVER, INLET — REPLACE...........................J300650 00-375

MANIFOLD UPPER, INLET — REPLACE ...........................J300700 00-375

MANIFOLD, INLET (COMPLETE) — REPLACE..................J300600 00-375

MANUAL TRANS. ASM — R&R/REPLACE.........................K205100 04-090

MANUAL TRANS. ASM. — R&R/OVERHAUL.....................K205110 04-125

MAP POCKET, LH FRT SEAT BACK — REPLACE............C504300 14-322

MAP POCKET, RH FRT SEAT BACK — REPLACE............C504200 14-322

MAT ASM. REAR COMPARTMENT FLOOR —..................C432650 14-490

MAT ASM. REAR COMPARTMENT FLOOR —..................C432650 14-480

MAT, CARGO BED/BOOT — REPLACE.............................R407300 AA-025

MAT, TAILGATE — REPLACE.............................................R407400 AA-025

MATS, FLOOR — REPLACE...............................................R100200 AA-005

MEMCAL ASM (LPG) — REPLA CE............... ... ... ... .............L701550 AA-6 50Q

MEMCAL ASM. (ECM/PCM) — REPLACE (EXCL..............J987700 02-245

MEMCAL ASM. (ECM/P CM) LP G — REPL AC E.............. ... .L701550 02-245

MICROPHONE, BLUETOOTH — REPLACE.......................N780060 09-515

MIRROR ASM. COMPLETE (INTERIOR REAR..................C315500 09-540

MIRROR ASM. COMPLETE (INTERIOR REAR..................C315500 14-025

MIRROR ASM. EXTERIOR REAR VISION LH —................R005600 10-400

MIRROR ASM. EXTERIOR REAR VISION RH —...............R005500 10-400

MIRROR FACE, LH EXT REAR VISION — REPLACE........R006220 10-400

MIRROR FACE, RH EXT REAR VISION — REP LACE.......R006120 10-400

MIRROR RETAINING PLATE (INTERIOR REAR................C315510 14-025

MIRROR, VANITY LH REAR — REPLACE .........................R005800 14-025

MIRROR, VANITY RH REAR — REPLACE.........................R005700 14-025

MIXER — REPLACE................................... .........................L700400 AA-6 50Q

MODULAR PUMP & SENDER UNIT ASM. —.....................L006330 03-074

MODULATOR, DVD FM — REPLACE.................................N780120 09-515

MODULE (BCM), BOD Y C ONT R OL —............................... .N50665 0 02-275

MODULE (BCM), BODY CONTROL — REPLACE..............N506600 02-275

MODULE (BCM), BODY CONTROL — REPROGRAM.......N506590 02-275

MODULE (ECM), ENGINE CONTROL — REPLACE..........J987510 02-245

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

MODULE (PCM), POWERTRAIN CONTROL —..................J987610 02-245

MODULE (PIM), POWER TRAIN INTERFACE —...............J730000 02-245

MODULE (TCM), AUTO TRANSMISSION CON—..............K509600 02-245

MODULE ASM, A/C CLIMATE CON T R OL —........... ... ........D333 100 08-155 A

MODULE ASM. (D FI) ELECTR ON I C IGN ITI ON —..............J7 2 45 2 0 02-225

MODULE ASM. (LEVEL RIDE) RELAY ISOLATING —.......F400700 AA-225

MODULE, BLUETOOTH — REPLACE................................N780055 09-515

MODULE, DVD INTERFACE — REPLACE.........................N780400 09-515

MODULE, DVD SPLITTER — REPLACE............................N780500 09-515

MODULE, EZY ENTRY LH — REPLACE............................N264900 14-275

MODULE, EZY ENTRY RH — REPLACE............................N264800 14-275

MODULE, HEADLIGHTS ON WITH IGNITION — ...............N104150 02-510

MODULE, INTERIOR LAMP CONTROL — REPLACE........N506450 02-275

MODULE, REAR WIPER MOTOR — REPLACE.................N752050 10-525

MODULE, RH FRON T SE A T /MIR ROR POSIT ION..............N 264 70 0 14-275

MODULE, SRS AI R BA G — REPL AC E........ ... ............ ... .....N506800 06-225

MODULE, THROTTLE CONTROL — REPLACE.................J987520 02-245

MODULE, TRIP COMPUTER — REPLACE ........................N833000 09-120

MODULE/CONTROL UNIT, REVERSE PARKING..............N770100 07-525

MOTOR & CABLE ASM. CRUISE CONTROL —.................R403100 03-400

MOTOR & FAN, BLOWER WITH A/C — REPLACE............D327100 08-150

MOTOR ASM, RADIATOR COOLING FAN —.....................J606150 01-105

MOTOR ASM. TAILGATE/HATCH WINDOW WIPER.........N752000 10-525

MOTOR ASM. WINDSHIELD WIPER — REPLACE............N351500 10-506

MOTOR, CRUISE CONTROL — REPLACE........................R400100 03-400

MOTOR, SEAT BACK LH — REPLACE.......................... ....C502860 14-275

MOTOR, SEAT BACK RH — REPLACE..............................C502850 14-275

MOTOR, SEAT HEIGHT ADJUSTER CENTRE —....... .......C502970 14-275

MOTOR, SEAT HEIGHT ADJUSTER LH —....................... .C502960 14-275

MOTOR, SEAT HEIGHT ADJUSTER RH —........................C502950 14-275

MOTOR, SUN ROOF — REPLACE.....................................A504250 AA-000

MOTOR, WINDOW REGULATOR FRONT LH —................N227250 11-675

MOTOR, WINDOW REGULATOR FRONT RH —...............N227150 11-675

MOTOR, WINDOW REGULATOR REAR LH —..................N229200 11-810

MOTOR, WINDOW REGULATOR REAR RH —..................N229100 11-810

MOTOR/SERV O, AI R MIX TU R E SIN GLE /L H —...... ... ... .....D02150 0 08-150

MOTOR/VALVE ASM. (IAC) IDLE AIR — REPLACE..........J971800 03-300

MOULDING ASM. DOOR FRAME INNER LH —.................C127400 11-650

MOULDING ASM. DOOR FRAME INNER RH —....... .........C127300 11-650

MOULDING ASM. IN N ER CHA NN E L LH —.......... ... ... ... .....C127200 11-650

MOULDING ASM. IN N ER CHA NN E L RH — . ............... ........C12710 0 11-650

MOULDING ASM. LH FR ON T DOOR SIDE —...... ... ...........C 830 20 0 10-250

MOULDING ASM. LH FRONT FENDER SIDE —................C883200 10-250

MOULDING ASM. LH FRT DOOR BELT REVEAL..............C832200 11-650

MOULDING ASM. LH GLASS QUARTER WINDOW...........C842200 10-25 0

MOULDING ASM. LH REAR DOOR SIDE — ......................C838200 10-250

MOULDING ASM. LH REAR OUTER WINDOW..................C836100 11-775

MOULDING ASM. LH ROOF FINISHER — REPLACE........C825200 10-265

MOULDING ASM. LH WINDOW CHANNEL INNER —.......C118700 11-775

MOULDING ASM. REAR DOOR FRAME INNER LH...........C127800 11-775

MOULDING ASM. REAR DOOR FRAME INNER RH..........C127700 11-775

MOULDING ASM. REAR WINDOW COMPLETE —....... .....C868100 11-020

MOULDING ASM. REAR WINDOW LOWER —..................C860500 11-025

MOULDING ASM. REAR WINDOW LOWER —..................C860500 11-020

MOULDING ASM. REAR WINDOW UPPER —...................C860600 11-020

MOULDING ASM. RH FRONT DOOR SIDE — ...................C830100 10-250

MOULDING ASM. RH FRONT FENDER SIDE — ...............C883100 10-250

MOULDING ASM. RH FRT DOOR BELT REVEAL..............C832100 11-650

MOULDING ASM. RH GLASS QUARTER WINDOW..........C842100 10-250

MOULDING ASM. RH REAR DOOR SIDE —......................C838100 10-250

MOULDING ASM. RH REAR OUTER WINDOW.................C836200 11-775

MOULDING ASM. RH ROOF FINISHER — REPLACE.......C825100 10-265

MOULDING ASM. RH WINDOW CHANNEL INNER —.......C1188 00 11-77 5

MOULDING ASM. ROOF FINISHER LH — REPLACE........C825200 10-250

MOULDING ASM. ROOF FINISHER RH — REPLACE.......C825100 10-250

MOULDING ASM. ROOF RACK RUNNER BOTH...............C828500 10-250

MOULDING ASM. ROOF RACK RUNNER LH.................. ..C829000 10-250

MOULDING ASM. ROOF RACK RUNNER RH....................C828000 10-250

MOULDING ASM. WINDOW CHANNEL INNER LH............C119000 11-775

MOULDING ASM. WINDOW CHANNEL INNER RH...........C118900 11-775

MOULDING CAP, ROOF REAR CENTRE — TOP..............B077830 99-050

MOULDING CAP, ROOF REAR LH — TOP COAT.............B077820 99-050

MOULDING CAP, ROOF REAR RH — TOP COAT.............B077810 99-050

MOULDING CAP, TAILLAMP LH — TOP COAT.................B077740 99-050

MOULDING CAP, TAILLAMP RH — TOP COAT.................B077730 99-050

MOULDING LOCATOR KIT, REAR WINDOW.....................C860400 11-020

MOULDING LOCATOR KIT, REAR WINDOW.....................C860300 11-020

MOULDING, CENTRE PILLAR LH — REPLACE................C896800 10-250

MOULDING, CENTRE PILLAR RH — REPLACE................C896700 10-250

MOULDING, FRONT BUMPER BAR — REPLACE.............A568000 07-500

MOULDING, FRT/RR DOOR FRAME OPENING LH...........C827000 10-250

MOULDING, FRT/RR DOOR FRAME OPENING RH..........C826000 10-250

MOULDING, LH CENTRE PILLAR — REPLACE ................C896800 10-265

MOULDING, LH FRONT DOOR — TOP COAT...................B001299 99-050

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

MOULDING, LH FRONT DOOR FRAME OPENING —.......C896600 10-265

MOULDING, LH REAR DOOR — TOP COAT REPAIR.......B001499 99-050

MOULDING, LH UPPER QUARTER PANEL —...................C897200 10-265

MOULDING, REAR QUARTER PANEL LH — (UTE)..........B100230 99-050

MOULDING, REAR QUARTER PANEL RH — (UTE)..........B100130 99-050

MOULDING, RH CENTRE PILLAR — REPLACE............. ...C896700 10-265

MOULDING, RH FRONT DOOR — TOP COAT..................B001199 99-050

MOULDING, RH FRONT DOOR FRAME OPENING...........C896500 10-265

MOULDING, RH REAR DOOR — TOP COAT.....................B001399 99-050

MOULDING, RH UPPER QUARTER PANEL —..................C897100 10-265

MOULDING, TAILGATE/HATCH GLASS —........................C868000 11-030

MOULDING, WINDSHIELD COMPLETE/UPPER —...........C820500 11-020

MOULDING, WINDSHIELD COMPLETE/UPPER —...........C820500 11-025

MOULDING, WINDSHIELD, COMPLETE/UPPER —..........C820500 11-030

MOULDING. LH DOOR/QUARTER TO WHEEL..................C838300 10-250

MOULDING. REAR COMPARTMENT LID COVER.............C847500 10-250

MOULDING. REAR PILLAR LH — REPLACE.....................C896400 10-250

MOULDING. REAR PILLAR RH — REPLACE.....................C896300 10-250

MOULDING. RH DOOR/QUARTER TO WHEEL.................C838400 10-250

MOULDING/FL A R E ASM. LH FRONT WHE E L .. ... ... ...........C884 200 10-265

MOULDING/FL A R E ASM. LH FRONT WHE E L .. ... ... ...........C884 200 10-250

MOULDING/ FL A R E ASM. LH RE A R WHEE L ARCH...........C84720 0 10-250

MOULDING/ FL A R E ASM. LH RE A R WHEE L ARCH...........C84720 0 10-265

MOULDING/FL A R E ASM. RH FR ONT WHEE L..... ..............C 884 10 0 10-250

MOULDING/FL A R E ASM. RH FR ONT WHEE L..... ..............C 884 10 0 10-265

MOULDING/FLARE ASM. RH REAR WHEEL ARCH..........C847100 10-250

MOULDING/FLARE ASM. RH REAR WHEEL ARCH..........C847100 10-265

MOULDING/FL A R E ASM. WHE E L ARCH —......... ... ... ... .....C847000 10-250

MOULDING/FL A R E ASM. WHE E L ARCH —......... ... ... ... .....C847000 10-265

MOUNT, SILICON — REPLACE..........................................F400300 AA-225

MOUNT/BRA C K ET , EN GIN E — REPLA C E BOTH..............J23 70 0 0 0 0- 47 5

MOUNT/BRACKET, ENGINE LH FRONT —.......................J337200 00-475

MOUNT/BRACKET, ENGINE RH FRONT —.......................J337100 00-475

MUDFLAP, FRONT — REPLACE........................................R506000 AA-000

MUDFLAP, REAR — REPLACE..........................................R506200 AA-000

MUFFLER/TAIL PIPE ASM. EXHAUST — REPLACE.........L503500 03-750

MUFFLER/TAIL PIPE ASM. EXHAUST — REPLACE.........L503510 03-750

MULTI FUNCTION/INFORMATION DISPLAY —.................N326500 09-100

NAMEPLATE, INSTRUMENT PAD LH — REPLACE..........C461700 09-125

NET, LUGGAGE RETENTION — REPLACE.......................C754400 14-480

NOZZLE ASM. WINDSHIELD WASHER (1 OR 2) —..........N357000 10-500

NOZZLE, HEADLAMP — REPLACE L/H.............................N705010 02-300

NOZZLE, HEAD LA MP — REPLA C E R/H ...... ... ... ... ... ..........N 705 00 0 02-300

NOZZLE, TAILGATE/HATCH WINDOW WIPER —.............N755000 10-500

NUT, SPARE WHE E L RETA IN IN G — REPLAC E...... ... .......E 00 140 0 05-8 25

NUT/STUD, WHEEL ATTACHING (ONE/ALL) —................E006300 05-800

OIL COOLER, TRANSMISSION — REPLACE....................K902300 04-150

OIL PUMP ASM. — R&R/REPLACE....................................K703100 04-200

ORNAMENT ASM, HOOD — REPLACE .............................C896200 10-150

OUTLET ASM. WATER — REPLACE..................................J608110 00-350

OWNER HAND BOOK — REPLACE (PD ONLY)................A000000 AA-020

PAD ASM. FRONT SEAT BACK DRIVERí S —........ ............C552200 14-295

PAD ASM. FRONT SEAT BACK PASSENGER —..............C553200 14-295

PAD ASM. FRONT SEAT CUSHION DRIV ERíS —.............C552000 14-295

PAD ASM. FRONT SEAT CUSHION PASSENGER —.......C553000 14-295

PAD ASM. INSTRUMENT PANEL — REPLACE.................C461100 09-125

PAD ASM. REAR SEAT BAC K (COMPLETE/BOTH............C572100 14-350

PAD ASM. REAR SEAT CU SHION — REPLACE...............C570300 14-330

PAD, BRAKE PEDAL — REPLACE.....................................H301100 04-600

PAD, CLUTCH PEDAL — REPLACE...................................K001200 04-600

PAD, FOOT REST — REPLACE..........................................C001100 14-475

PAD/PEDAL, A CCELERATOR PEDAL — REPLACE..........J815600 03-650

PADS, BOTH FR ON T WHE E L S DISC BRAK E —..... ..........H 10 5 00 0 04-750

PADS/SHOES, REAR BRAKES BOTH SIDES —................H125000 04-825

PAN ASM. OIL — REPLACE................................................J315600 00-275

PAN, REAR COMPARTMENT FLOOR — RESEAL............A205199 12-000

PAN/GASKET, A UTO TRANS OIL — R&R/REPLACE........K611100 04-220

PANEL ASM, INSTRUMENT PANEL CENTRE —...............C461810 09-125

PANEL ASM, INSTRUMENT PANEL UPPER CEN— .........C461800 09-125

PANEL ASM. BACK LOWER — SPOT REPAIR..................B047100 99-050

PANEL ASM. BACK LOWER — STRIP & REPAINT...........B047110 99-050

PANEL ASM. BACK LOWER — TOP COAT REPAI R.........B047120 99-050

PANEL ASM. BACK UPPER — RESEAL............................A202400 12-000

PANEL ASM. COCKPIT/COWL — RESEAL........................A206098 12-000

PANEL ASM. ENGINE HOOD — R & R...............................A500110 12-425

PANEL ASM. ENGIN E HOOD — SPOT REPAIR..... .. .........B003330 99-050

PANEL ASM. ENGINE HOOD — STRIP & REPAINT..........B003300 99-050

PANEL ASM. ENGINE HOOD — TOP COAT REPAIR.......B003305 99-050

PANEL ASM. FRONT DOOR OUTER LH — SPOT.............B001219 99-050

PANEL ASM. FRONT DOOR OUTER LH — STRIP &........B001210 99-050

PANEL ASM. FRONT DOOR OUTER LH — TOP...............B001220 99-050

PANEL ASM. FRONT DOOR OUTER RH — SPOT............B001119 99-050

PANEL ASM. FRONT DOOR OUTER RH — STRIP &........B001110 99-050

PANEL ASM. FRONT DOOR OUTER RH — TOP ..............B001120 99-050

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

PANEL ASM. LOAD AREA TUB (UTE) — SPOT.................B001100 99-050

PANEL ASM. LOAD AREA TUB (UTE) — STRIP &............B001300 99-050

PANEL ASM. LOAD AREA TUB (UTE) — TOP COAT........B001200 99-050

PANEL ASM. RE A R DOOR OUT E R LH — SPOT. ............ ..B00 1 41 9 99-05 0

PANEL ASM. RE A R DOOR OU T E R LH — STR IP &......... ..B00141 0 99-05 0

PANEL ASM. RE A R DOOR OUT E R LH — TOP............... ..B001420 99-05 0

PANEL ASM. RE A R DOOR OUT E R RH — SPOT... ... ... .....B00131 9 99- 050

PANEL ASM. RE A R DOOR OU T E R RH — STRIP &..........B 00 1 310 99- 05 0

PANEL ASM. RE A R DOOR OU T E R RH — TOP.................B 00 1 32 0 99- 050

PANEL ASM. SHROUD SIDE LH — RESEAL.....................A202200 12-000

PANEL ASM. SHROUD SIDE RH — RESEAL....................A202100 12-000

PANEL ASM. SPARE WHEEL WELL — RESEAL...............A202900 12-000

PANEL ASM. TA IL GA TE/HATCH — R&R/R E P LAC E..........C436100 14-500

PANEL, LOWER DECKLID LAMP — REPLACE.................C896950 02-375

PANEL, REAR QUARTER INNER LH — RESEAL..............A202500 12-000

PANEL, REAR QUARTER INNER RH — RESEAL.............A202600 12-000

PANEL, REAR QUARTER OUTER LH (UTE ONLY)...........B001610 99-050

PANEL, REAR QUARTER OUTER LH (UTE ONLY)...........B001630 99-050

PANEL, REAR QUARTER OUTER LH — SPOT.................B001619 99-050

PANEL, REAR QUARTER OUTER LH — STRIP &.............B001610 99-050

PANEL, REAR QUARTER OUTER LH — TOP COAT........B001630 99-050

PANEL, REAR QUARTER OUTER RH (UTE ONLY)..........B001510 99-050

PANEL, REAR QUARTER OUTER RH (UTE ONLY)..........B001530 99-050

PANEL, REAR QUARTER OUTER RH — SPOT................B001519 99-050

PANEL, REAR QUARTER OUTER RH — STRIP &............B001510 99-050

PANEL, REAR QUARTER OUTER RH — TOP COAT........B001530 99-050

PANEL, REAR SEAT BACK SUPPORT — REPLACE........C572900 14-350

PANEL, REAR WHEELHOUSE INNER LH —.....................A202700 12-000

PANEL, REAR WHEELHOUSE INNER RH —.....................A202800 12-000

PANEL, ROOF — SPOT REPAIR........................................B004500 99-050

PANEL, ROOF — STRIP & REPAINT — (UTE ONLY)........B004530 99-050

PANEL, ROOF — STRIP & REPAINT SEDAN OR..............B004530 99-050

PANEL, ROOF — STRIP & REPAINT STATION.................B004530 99-050

PANEL, ROOF — TOP COAT REPAIR — (UTE ONLY ).....B004540 99-050

PANEL, ROOF — TOP COAT REPAIR SEDAN OR............B004540 99-050

PANEL, ROOF — TOP COAT REPAIR STATION...............B004540 99-050

PANEL, ROOF — TOP COAT REPAIR UTE WITH.............B004550 99-050

PANEL, SILL OUT E R LH — SPOT REP AI R....... .................B012600 99-05 0

PANEL, SILL OUTER LH — STRIP & REPAINT............ .....B012610 99-050

PANEL, SIL L OUT ER LH — TOP COA T REP AIR....... ........B01262 0 99- 050

PANEL, SIL L OUT ER R H — SPOT RE PAI R......... ............ ..B01 2 50 0 99- 050

PANEL, SILL OUTER RH — STRIP & REPAINT.................B012510 99-050

PANEL, SILL OUTER RH — TOP COAT REPAIR...............B012520 99-050

PANEL, TAILGATE (UTE ONLY) — STRIP &......................B001810 99-050

PANEL, TAILGATE (UTE ONLY) — TOP COAT .................B001820 99-050

PANEL, TAILGATE OR HATCH — SPOT REPAIR.............B001819 99-050

PANEL, TAILGATE OR HATCH — STRIP & REPAINT.......B001810 99-050

PANEL, TAILGATE OR HATCH — TOP COAT...................B001820 99-050

PANEL, VALAN C E OR AI R DA M — SPOT RE PAIR. ... .......B062 60 0 99-0 50

PANEL, VALAN C E OR AI R DA M — STRIP & .....................B062610 99-0 50

PANEL, VALAN C E OR AI R DA M — TOP COA T............. ... .B062620 99-0 50

PCB, DVD SCREEN LH — REPLACE.................................N780350 09-515

PCB, DVD SCREEN RH — REPLACE................................N780250 09-515

PCM, ECM — REPROGRAM...............................................J987710 02-245

PEDAL ASM, CLUTCH — REPLACE ..................................K001100 04-600

PEDAL ASM. BRAKE — REPLACE.....................................H301000 04-600

PILLAR, FRON T BODY LH — STRIP & REPAINT..............B002910 99-050

PILLAR, FRONT BODY LH — TOP COAT REPAIR.......... ..B002920 99-050

PILLAR, FRONT BODY RH — STRIP & REPAINT..............B002810 99-050

PILLAR, FRON T BODY RH — TOP COAT REPAIR...........B002820 99-050

PILLAR, REAR BODY LH — STRIP & REPAINT.................B100220 99-050

PILLAR, REAR BODY LH — TOP COAT REPAIR ..............B100200 99-050

PILLAR, REAR BODY RH — STRIP & REPAINT................B100120 99-050

PILLAR, REAR BODY RH — TOP COAT REPAIR..............B100100 99-050

PIN/SPRING, H OOD LOC K PILOT — REP L ACE................A513 50 0 12-0 50

PINION & BEARING ASM. STEERING — REPLACE.........M130150 06-310

PIPE & HOSE, PRESSURE — REPLACE...........................M048200 06-400

PIPE & HOSE, STE E RI NG RA C K TO RETU RN........... .......M0 4840 0 06-400

PIPE ASM, TRANSMISSION COOLER — REPLACE.........K603150 04-150

PIPE ASM. AIR BLEED — REPLACE..................................J601610 01-140

PIPE ASM. BRAKE HOSE TO LH RR CALIPER —........ .....H406200 04-750

PIPE ASM. BRAKE HOSE TO RH RR CALIPER —............H406100 04-750

PIPE ASM. HEATER INLET — REPLACE...........................J601350 08-125

PIPE ASM. HEATER OUTLE T — REPLA C E. ... ............... ....J60130 0 0 8 -125

PIPE ASM. LIQUI D LI NE — REPL A CE....... ... ... ............ ... ... .D307 060 08-200

PIPE ASM. MASTE R CYL IN D ER (FRO N T) TO............ ... ... .H402300 04-755

PIPE ASM. MASTER CYLINDER (REAR) TO MOD—........H402600 04-755

PIPE ASM. MASTER CYLINDER TO FRONT CALI—........ .H404200 04-750

PIPE ASM. MASTER CYLINDER TO FRONT CALI—........ .H404100 04-750

PIPE ASM. MASTER CYLINDER TO RR BRAKE RH...... ...H406110 04-750

PIPE ASM. MODUL AT OR TO L/H FR ON T B RAK E... ..........H402500 04-755

PIPE ASM. MODULATOR TO R/H FRONT BRAK E..... ... ....H402400 04-755

PIPE ASM. MODUL AT OR TO R R BRA K E LH — ............ ....H40 6 22 0 04-755

PIPE ASM. MODUL AT OR TO R R BRA K E RH —... ... ..........H406120 04-755

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

PIPE ASM. RAD IA T OR IN LE T (S/C ONL Y) —...... ............ ..J602200 01-160

PIPE ASM. RR BRAKE CROSSOVER — REPLACE..........H404300 04-750

PIPE, COOL A N T AIR BLEED (GE N III , GEN IV) —........ .....J327000 0 1-160

PIPE, COOLANT INLET — REPLACE ( HFV6 ONLY).........J601150 01-160

PIPE, FEED HYDRAULIC ANY ONE — REPLACE.............M144000 06-310

PIPE, FUEL RETURN — REPLACE....................................J904100 03-075

PIPE, FUEL TANK TO ENGINE — REPLACE.....................L010100 03-075

PIPE, FUEL TANK TO VAPOUR CANISTER —..................L011100 03-075

PIPE, HEATER INLET OUTLET — REPLACE (HFV6...... ...D111150 08-075

PIPE, OIL COOLER (OUTLET) — REPLACE......................K605100 04-150

PIPE, RADIATOR CROSSOVER — REPLACE...................K605400 04-150

PIPE, RADIATOR TO TRANS HOSE (INLET) —.................K605300 04-150

PIPE/HOSE, BREATHER/OIL COLLECTION —..................K204110 04-090

PIPE/HOSE, BREATHER/OIL COLLECTION —..................K204110 04-150

PIPE/MUFFLER ASM. EXHAUST INTERIM —....................L503100 03-750

PIPE/SCREEN ASM. OIL SUCTION — REPLACE..............J117350 00-251

PIPES, SECONDARY AIR — REPLACE.............................J980600 03-300A

PISTON & PIN ASM. (ONE) — REPLACE BOTH................J330000 00-550

PISTON & PIN ASM. (ONE) — REPLACE CYLS................J330200 00-550

PISTON & PIN ASM. (ONE) — REPLACE CYLS................J330100 00-550

PIVOT OR PEDESTAL, VALVE ROCKER (1 OR 2) —........J307140 00-050

PIVOT OR PEDESTAL, VALVE ROCKER (1 OR 2) —........J307040 00-050

PIVOT OR PEDESTAL, VALVE ROCKER (1 OR 2) —........J307240 00-050

PLATE ASM. ENDGATE LH — REPLACE..........................C613650 12-685

PLATE ASM. ENDGATE LOCK BASE — REPLACE... ........C613000 12-685

PLATE ASM. ENDGATE RH — REPLACE..........................C613600 12-685

PLATE, CLUTCH DRIVEN — REPLACE (M/T)...................K013120 00-400

PLATE, COIL/MODULE MOUNTING — REPLACE.............J712400 02-225

PLATE, FRONT BUMPE R S KI D PL A T E AL U M IN —.... ........A568 200 07- 50 0

PLATE, LH SI DE FR ON T FE N DE R /D OOR NA ME —..........C882200 10-150

PLATE, REAR MAIN OIL SEAL — R&R/REPLACE.............J320250 00-200

PLATE, RH SID E FR ON T FEN DE R /D OOR NAME —. ... ... ..C88 2 100 10-150

PLATE/BEARING ASM. LH FRONT — REPLACE..............E130020 06-210

PLATE/BEARING ASM. RH FRONT — REPLACE..............E130010 06-210

PLUG, CYLINDER BLOCK DRAIN — REPLACE................J233500 00-248

PLUNGER & KNOB, CIGAR LIGHTER — REPLACE......... .N311600 14-900

PLUNGER/KNOB, CIGAR LIGHTER — REPLACE.............N311600 09-300

POCKET, MAP FRONT DOOR TRIM LH —........................C407400 14-220

POCKET, MAP FRONT DOOR TRIM RH —........................C407300 14-220

PRINTED CIRCUIT BOARD, INSTRUMENT —...................N309500 09-120

PROCESSOR, DIGITAL ADAPTIVE — REPLACE..............L790200 AA-650Q

PROTECTO R/ S WITC H , COMP R ESS O R TH ER —...... ... .....D33210 0 08-200

PULLEY ASM. MAIN BELT TENSIONER —........................J607200 01-030

PULLEY ASM. SUPERCHARGER DRIVE BELT.................J607450 01-030

PULLEY, POWER STEERING PUMP — REPLACE...........M043100 06-400

PULLEY, WATER PUMP — REPLACE ...............................J606600 01-020

PULLEY, WATER PUMP — REPLACE ...............................J606600 01-030

PULSE RING, ABS SENSOR — REPLACE BOTH.............F506300 05-400

PULSE RIN G, ABS SEN S OR LH — REPL AC E............ .......F50 6 50 0 0 5 -4 00

PULSE RIN G, ABS SEN S OR RH — REPL A CE.. ... ... ..........F 50 6 40 0 0 5 -4 00

PUMP ASM, SECONDARY AIR — REPLACE.....................J980800 03-300A

PUMP ASM. POWER STEERING — R&R/OVER—............M1475 00 06-400

PUMP ASM. WATER — REPLACE.....................................J609100 00-325

PUMP ASM. WINDSHIELD WASHER — REPLACE...........N354500 10-500

PUMP ASM/SUPPLY UNIT, POWER STEERING —...........M147000 06-400

PUMP, FUEL (INTERNAL) — REPLACE.............................L006350 03-074

PUMP/GASKET, ENGINE OIL — R&R/REPLACE..............J316500 01-500

RACK PAD, STEERING GEAR — CHECK & ADJUST.......M036200 06-275

RADIATOR — REPA IR ............ ... ............................ .............J605 599 01-105

RADIATOR AS M. — R&R/ RE P L AC E....... ............ ... ............ .J600500 01-105

RADIO CD PLAYER — DUAL H AND LI NG ....... ...................R205 51 0 09-440

RADIO CD PLAYER — REPAIR (BY DEALER)...................R2055 40 09-440

RADIO CD PLAYER — REPLACE.......................................R205500 09-440

RADIO CONTROL ASM. REAR SEAT REMOTE —............R205600 09-500

RADIO CONTROLS, HORN BAR — R&R/REPLACE..........R205520 09-440

RADIO CONTROLS, HORN BAR — REPLACE..................R205520 06-225

RADIO REMOTE CONT ROL MODULE — REPLACE.........R205530 09-440

RAIL ASM, BELT OUTER LH — TOP COAT REPAIR.........B077720 99-050

RAIL ASM, BELT OUTER RH — TOP COAT REPAIR........B077710 99-050

RAIL ASM, ENDGATE UPPER — TOP COAT....................B077750 99-050

RAIL ASM, LPG INJECTOR — REPLACE RH OR LH........L701060 AA-650Q

RAIL ASM. ENDGATE UPPER — REPLACE......................C614200 12-480

RAIL ASM. FUEL — RE PL A C E......... ............. ... ... ............ ... .J90100 0 0 3 -375

RAIL ASM. LH BE L T OU T E R — REPL A CE... ............ ... .......C61 4 10 0 12-480

RAIL ASM. RH BE L T OU T E R — RE PL A CE.................... ... .C614000 12-480

RAIL, CARGO LUGGAGE — REPLACE BOTH...................C432660 14-490

RAIL, CARGO LUGGAGE LH — REPLACE........................C432680 14-490

RAIL, CARGO LUGGAGE RH — REPLACE .......................C432670 14-490

RAIL, ROOF SIDE. LH SIDE — RESEAL............................A210298 12-000

RAIL, ROOF SIDE. RH SIDE — RESEAL........ ................. ...A210198 12-000

REAR AXLE/DIFFERENTIAL ASM. COMPLETE —............F650100 05-400

RECEIVER DEHYDRATOR AND/OR O RINGS —..............D316100 08-200

RECEIVER, REMOTE KEY SIGNAL — REPLACE .............N317700 06-255

RECEIVER, REMOTE KEY SIGNAL — REPLACE .............N317700 09-125

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

RECEIVER/MONITOR, TYRE PRESSURE —.....................N764300 02-275

REGULATOR, FUEL RAIL/PRESSURE — REPLACE........J903000 03-375

RELAXER, ACCELERATOR CABLE CONTROL —............J816800 03-325

RELAY ASM. HE A T ED REA R WIN D OW —............. ... ........N00190 0 02-425

RELAY ASM. LP G — REPL AC E................... ... ............ ... ... ..N002450 02-425

RELAY ASM. RE A R WINDS CR E E N WIP ER — . ............ ... ..N 00 2 40 0 02-425

RELAY ASM. REVERSE LIGHT — REPLACE....................N002455 02-425

RELAY, A/C — REPLACE....................................................N001810 02-250

RELAY, ANTI TH E FT SYSTEM — REP L AC E....... ... ... ........N001 860 02-250

RELAY, AUTO LEVEL CONTROL — REPLACE.................N002120 02-250

RELAY, BLOWER MOTOR — REPLACE............................N001960 02-425

RELAY, BLOWER MOTOR — REPLACE............................N001960 02-250

RELAY, BLOWER MOTOR INHIBITOR — REPLACE.........N002350 02-425

RELAY, DRIVER WINDOW — REPLACE ...........................N002000 02-425

RELAY, ENGINE CONTROL — REPLACE.........................N002100 02-250

RELAY, ENGINE COOLING FAN (HIGH) —........................N001840 02-250

RELAY, ENGINE COOLING FAN (LOW) —........................N001980 02-250

RELAY, FOG LAMP (FRONT) — REPLACE .......................N104600 02-250

RELAY, FRONT WINDSCREEN WIPER — REPLACE.......N002150 02-250

RELAY, FUEL PUMP — REPLACE.....................................N001830 02-250

RELAY, HEADLAMP HIGH BEAM — REPLACE.................N002110 02-250

RELAY, HEADLAMP LOW BEAM — REPLACE..................N001880 02-250

RELAY, HORN — REPLACE...............................................N001820 02-250

RELAY, IGNITION — REPLACE..........................................N359700 02-425

RELAY, INTERIOR LAMP — REPLACE..............................N414535 02-425

RELAY, PARK LAMPS — REPLACE...................................N001990 02-425

RELAY, POWER WINDOW — REPLACE ...........................N001930 02-425

RELAY, STARTER — REPLACE.........................................N001890 02-250

REMOTE CONTROL ASM. FRONT DOOR — ....................C620700 11-360

REMOTE CONTROL ASM. LH FRONT DOOR —...............C620900 11-360

REMOTE CONTROL ASM. RH FRONT DOOR —..............C620800 11-360

REMOTE CONTROL, DVD PLAYER — REPLACE.............N780600 09-515

REMOTE CONTROL. BOT H REAR DOOR —.....................C 334 000 11-725

REMOTE CONTROL. LH REAR DOOR — REPLACE........C334100 11-725

REMOTE CONTROL. RH REAR DOOR — REPLACE........C334200 11-725

REMOTE KEY HEAD — REPLACE ONE/BOTH.................N501600 06-255

RESERVOIR ASM. POWER STEERING — R&R/...............M050500 06-400

RESERVOIR ASM. WINDSHIELD/HEADLAMP...... .............N358500 10-500

RESERVOIR, BRAKE MASTER CYLINDER —...................H400200 04-725

RESERVOIR/BRACKET, CLUTCH MASTER CYLIN—.......K013850 00-430

RESERVOIR/SURGE TANK, RADIATOR OVER—.............J602100 01-140

RESISTOR, A/C BLOWER MOTOR — REPLACE..............D330100 08-150

RESTRAINT ASM. LH FRT SEAT BACK HEAD —........ .....C505200 14-295

RESTRAINT ASM. REAR SEAT BACK HEAD CEN—........C576300 14-350

RESTRAINT ASM. REAR SEAT BACK HEAD LH —..........C576200 14-350

RESTRAINT ASM. REAR SEAT BACK HEAD RH —..........C576100 14-350

RESTRAINT ASM. RH FRT SEAT BACK HEAD —....... ......C505100 14-295

RETAINER, MODULAR ASM TO FUEL TANK —................L006340 03-074

RH MIRROR, OUTSIDE REAR VIEW — TOP COAT..........B081530 99-050

RINGS, PISTON (ONE SET ) — REPLACE OPPO—........ ..J330020 00-550

RINGS, PISTON (ONE SET) — REPLACE CYLS...............J330120 00-550

RINGS, PISTON (ONE SET) — REPLACE CYLS...............J330220 00-550

ROD ASM. PANHARD — REPLACE...................................F114100 07-150

ROD, ADJUSTER ASM LH SEAT — REPLACE............ ......C502150 14-275

ROD, ADJUSTER ASM RH SEAT — REPLACE......... .. ......C502100 14-275

ROD, CONNECTING (ONE) — REPLACE CYLS................J330250 00-550

ROD, CONNECTING (ONE) — REPLACE CYLS................J330150 00-550

ROD, CONNECTING. (ONE) — REPLACE BOTH..............J330050 00-550

ROD, DOOR LOCK CONNECTING LH REAR.....................C624800 11-725

ROD, DOOR LOCK CONNECTING RH REAR....................C624700 11-725

ROD, DOOR LOCK CYLINDER TO DOOR LOCK...............C622350 11-360

ROD, DOOR LOCKING REAR LH — REPLACE.................C623200 11-725

ROD, DOOR LOCKING REAR RH — REPLACE................C623300 11-725

ROD, FRONT DOOR LOCKING (INSIDE) LH —.................C622300 11-360

ROD, FRONT DOOR LOCKING (INSIDE) RH —................C622330 11-360

ROD, HANDLE OUTER DOOR LH FRONT — ....................C622500 11-360

ROD, HANDLE OUTER DOOR RH FRONT —....................C622600 11-360

ROD, HANDLE OUTER LH REAR DOOR —.......................C641200 11-725

ROD, HANDLE OU T E R RH RE AR DOOR —............... ... ....C641 300 11-725

ROD, LH FRONT CONTROL ARM — REPLACE................E106100 06-200

ROD, REMOTE CO NTROL ASM LH REAR DOOR —........C624600 11-725

ROD, REMOTE CO NTROL ASM RH REAR DOOR —........C624500 11-725

ROD, REMOTE CO NTROL LH FRONT — REPLACE.........C622700 11-360

ROD, REMOTE CO NTROL RH FRONT — REPLACE........C622800 11-360

ROD, RH FRONT CONTROL ARM — REPLACE ...............E106200 06-200

ROD, SELECTOR CONTROL (AUTO) — REPLACE..........K506100 04-170

ROD, STEERING TIE — REPLACE BOTH SIDES..............M035000 06-310

ROD, STEERI N G TIE LH — REPLACE..................... ... .......M0 3521 0 06-310

ROD, STEERI N G TIE RH — REPLACE ........ ............ ... .......M0 3511 0 06-310

ROD, VALVE PUSH, (1 OR 2) — REPLACE BOTH............J307020 00-050

ROD, VALVE PUSH, (1 OR 2) — REPLACE CYLS.............J307220 00-050

ROD, VALVE PUSH, (1 OR 2) — REPLACE CYLS.............J307120 00-050

ROD/CABLE, TEMPERATURE CONTROL —.....................D112100 08-150

ROO BAR — REPLACE....................................... ................R90644 0 AA-005

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

S/C BOOST CONT R O L SOL E NOI D VA L V E —.. ............ ... ..J5 8 94 0 0 0 3- 30 0

S/C BYPASS SOLENOID — REPLACE............. .................J589200 03-300

S/C BYPASS VALVE ACTUATOR — REPLACE.................J589100 03-300

SAFETY TRIANGLE — REPLACE ......................................R700200 AA-000

SCALE TRANSMISSION CONTROL — REPLACE.............K508100 04-190

SCOOP ASM, HOOD AIR BOTH — REPLACE...................A015200 12-050

SCOOP ASM, HOOD AIR LH — REPLACE ........................A015100 12-050

SCOOP ASM, HOOD AI R RH — REPL A CE.... ............ ... .....A015000 12-05 0

SCREEN, DVD LH — REPLACE .........................................N780300 09-515

SCREEN, DVD RH — REPLACE.........................................N780200 09-515

SCREEN, SATELLITE NAVIGATION — REPLACE............R604100 AA-000

SCREWS, REMOTE KEY HEAD TO SHAFT —..................N501675 06-255

SEAL ASM. EXTENSION/ADAPTOR HOUSING —............K608200 04-200

SEAL EXTENSION HOUSING OIL — REPLACE M/T.........K202100 04-100

SEAL, AXLE SHAFT LH OIL — REPLACE..........................F505200 05-400

SEAL, AXLE SHAFT OIL — REPLACE BOTH SIDES.........F505000 05-400

SEAL, AXLE SHAFT RH OIL — REPLACE.........................F505100 05-400

SEAL, CONVERTER OIL — REPLACE...............................K702100 04-200

SEAL, CRANKSHAFT FRONT OIL — REPLACE................J312600 00-325

SEAL, DRIVE SHAFT OIL — REPLACE BOTH SIDES.......E302010 06-200

SEAL, DRIVE SHAFT OIL — REPLACE BOTH SIDES.......E302010 05-250

SEAL, EXTENSION HOUSING/REAR COVER —...............K608150 04-200

SEAL, FRONT DIFFERENTIAL PINION OIL —...................E200500 05-250

SEAL, FRONT OUTPUT SHAFT OIL — REPLACE.............K400140 04-050

SEAL, GEARSHIFT CONTROL LOWER — REPLACE.......K200200 04-100

SEAL, GEARSHIFT TO FLOOR — REPLACE (M/T)...........K200100 04-060

SEAL, INJECTOR FUEL UPPER/LOWER —......................J901010 03-375

SEAL, INPUT S HA F T — REPLACE........... ............ ... ...........K10 8 60 0 04-12 5

SEAL, INTERMEDIATE DRIVE SHAFT OIL —....................E303500 05-250

SEAL, INTERMEDIATE DRIVE SHAFT OIL —....................E303500 06-200

SEAL, INTERMEDIATE DRIVE SHAFT OIL —....................E303600 05-250

SEAL, INTERMEDIATE DRIVE SHAFT OIL —....................E303400 06-200

SEAL, LH DRIVE SHAFT OUTPUT OIL — REPLACE........E302120 05-250

SEAL, LH DRIVE SHAFT OUTPUT OIL — REPLACE........E302120 06-200

SEAL, MODULAR ASM. TO FUEL TANK —........................L006310 03-074

SEAL, PINION SHAFT OIL — REPLACE ............................F502100 05-400

SEAL, PINION SHAFT OIL — REPLACE ............................F502100 05-290

SEAL, PUMP ASM POWER STEERING — REPLACE.......M147100 06-400

SEAL, REAR AXLE DRIVE SHAFT INNER —.....................F505500 05-290

SEAL, REAR AXLE DRIVE SHAFT INNER LH —...............F505300 05-290

SEAL, REAR AXLE DRIVE SHAFT INNER RH —...............F505400 05-290

SEAL, REAR MAIN OIL — REPLACE (EXCLUDING..........J320725 00-200

SEAL, REAR OUTPU T SHAFT OIL — REPLACE...............K400150 04-050

SEAL, RH DRIVE SHAFT OUTPUT OIL — REPLACE........E302110 06-200

SEAL, RH DRIVE SHAFT OUTPUT OIL — REPLACE........E302110 05-250

SEAL, VEHICLE SPEED SENDER — REPLA CE........... .....K607250 04-200

SEAL/BOLT, VALVE ROCKER COVER — REPLACE........J109100 00-025

SEAL/CAP, RESERVOIR — REPLACE...............................H400250 04-725

SEAL/FLANGE , TRANSFER CASE ASSY —.............. .. ......K400150 04-050

SEAL/GASKET, OIL PUMP — REPLACE............................K703170 04-200

SEAL/GASKET, WATER OUTLET — REPLACE.................J608100 00-350

SEAT ASM. FRONT BUCKET DRIVERíS — R&R/..............C551000 14-295

SEAT ASM. FRONT BUCKET PASSENGER — R&R/........C550000 14-295

SEAT BELT STALK & TENSIONER LH — REPLACE.........C451240 14-400

SEAT BELT STALK & TENSIONER RH — REPLACE........C451140 14-400

SECONDARY MODULAR PUMP & SENDER UNIT.... ........L006360 03-074

SENDER ASM. VEHICLE SPEED — REPLACE.................N316650 04-200

SENDER ASM. VEHICLE SPEED — REPLACE.................N316650 04-075

SENDER UNIT LPG — REPLACE.......................................L701500 AA-650R

SENDER UN IT , FU E L LEV E L — R&R/REPLAC E.. ... ... .......L00 6 30 0 03 - 0 74

SENSOR ASM KNOCK — REPLACE BOTH SIDES...........J724050 02-000

SENSOR ASM KNOCK — REPLACE CYLS 1,3,5 ..............J724150 02-000

SENSOR ASM KNOCK — REPLACE CYLS 2,4,6 ..............J724100 02-000

SENSOR ASM, AMBIEN T TEMP — REPL AC E... ... .............N317600 08-200

SENSOR ASM, INSIDE AIR TEMP — R&R/REPLACE.......N317650 08-200

SENSOR ASM, SUN — REP L AC E................ ... ... ... .............N31770 0 08-155A

SENSOR ASM. COOLANT TEMP ECM — REPLACE........N317510 02-000

SENSOR ASM. COOLANT TEMP GAU G E —................. ....N317500 02-000

SENSOR ASM. FUEL PU MP SWITCH & OIL PRES—........J724300 02-000

SENSOR ASM. KNOCK (ONE OR BOTH) —......................J724000 02-000

SENSOR ASM. LOW ENGINE OIL LEVEL — .....................J221950 00-275

SENSOR ASM. MANIFOLD AIR TEMP. (M.A.T) —.............J740200 02-000

SENSOR ASM. MASS AIR FLOW — RE PLA C E............. ....N308800 03-250

SENSOR ASM. OIL PRESSURE — REPLACE...................N318500 01-500

SENSOR ASM. OIL TEMPERATURE — REPLACE............J794900 02-000

SENSOR ASM. OIL TEMPERATURE — REPLACE............J794900 00-275

SENSOR ASM. OXYGE N , EX HAU S T LH — .......................J98760 0 0 0 -450

SENSOR ASM. OXYGE N , EX HAU S T RH —. ... ...................J98 7 650 00-450

SENSOR ASM/OIL SE A L , CRAN K S HAF T —............ ..........J 74 0 250 0 2 -0 00

SENSOR, ABS WHEEL SPEED BOTH FRONT —..............H901300 04-730

SENSOR, ABS WHEEL SPEED BOTH REAR —................H901400 04-730

SENSOR, ABS WHEEL SPEED LH FRONT —...................H901340 04-730

SENSOR, ABS WHEEL SPEED LH REAR — .....................H901440 04-730

SENSOR, ABS WHEEL SPEED RH FRONT — ..................H901320 04-730

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

SENSOR, ABS WHE E L S PEE D RH REA R —....... ............ ..H90 1 42 0 04-730

SENSOR, ACCELERATOR PEDAL POSITION —..............J496030 03-650

SENSOR, ACCELEROMETER BRAKE CONTROL......... ....N221330 04-730

SENSOR, CAMSHAFT — REPLACE...................................J795200 02-000

SENSOR, FRONT PARKING AID — REPLACE (ONE/.......N770150 07-500

SENSOR, INTAKE AIR TEMP. — REPLACE......................J724200 03-250

SENSOR, MANIFOLD ABSOLUTE PRESSURE.................J740100 02-000

SENSOR, P1/MAP — REPLACE.........................................L701010 AA-650Q

SENSOR, PERIPHERAL ACCELERATION LH —...............N506950 06-225

SENSOR, PERIPHERAL ACCELERATION RH —..............N506900 06-225

SENSOR, RAIN — REPLACE..............................................N221925 10-505

SENSOR, REVERSE PARKING AID — REPLACE.............N770000 07-525

SENSOR, YAW RAT E /A CC E L ER A T ION (E S P) —......... ... ..N221320 04-730

SERVICE HOSE VENT TUBE — REPLACE .......................L702500 AA-650Q

SERVICE LINE ENGINE BAY — REPLACE........................L700800 AA-650Q

SERVICE LIN E FRON T — RE PL A CE .... ... ............ ... ...........L 70 1 90 0 AA-6 50 Q

SERVICE LINE REAR — REPLACE....................................L701800 AA-650Q

SERVO PISTON ASM. 2ND APPLY — REPLACE..............K600100 04-210

SERVO PISTON ASM. 4TH APPLY — REPLACE..............K600150 04-210

SHACKLE & BUSH, RR STABILIZER BAR LH —...............F125250 07-150A

SHACKLE & BUSH, RR STABILIZER BAR RH —...............F125150 07-150A

SHACKLE ASM. DECK LID/TAILGATE/HATCH — .............C753100 12-680

SHACKLE/BUSH, LEAF SPRING BOTH — REPLACE.......F105000 07-150

SHACKLE/BUSH, LEAF SPRING LH — REPLACE ............F105200 07-150

SHACKLE/BUSH, LEAF SPRING RH — REPLACE............F105100 07-150

SHADE, VENETIAN, REAR WINDOW (EXT) —..................R601500 AA-015

SHAFT & BEARING ASM. BALANCE — REPLACE............J314900 00-150

SHAFT ASM. M/ T MAIN — REPLACE................... ... ...........K 10 8 40 0 04-12 5

SHAFT ASM. REAR PROPELLER — R&R/REPLACE........F907100 05-050

SHAFT, COUPLING ASM STEERING INTERMEDI—.........M013500 06-275

SHAFT, FRONT DIFFERENTIAL PROPELLER —..............F905100 05-250

SHAFT, M/T SHIFT — REPLACE........................................K108000 04-125

SHAFT, MODE CONTROL — REPLACE ............................D333400 08-155A

SHAFT, REAR AXLE — REPLACE BOTH SIDES...............F504000 05-400

SHAFT, REAR AXLE LH — REPLACE................................F504200 05-400

SHAFT, REAR AXLE RH — REPLACE...............................F504100 05-400

SHAFT, REMOTE KEY — REPLACE..................................N501650 06-255

SHAFT/GEAR, INPUT — REPLACE....................................K108800 04-125

SHELF ASM. BACK PANEL UPPER — REPLACE.............C427100 14-460

SHIELD ASM. REAR DISC/DRUM BRAKE LH —...............H128200 04-825

SHIELD ASM. REAR DISC/DRUM BRAKE RH —...............H128100 04-825

SHIELD, DISC BRAKE SPLASH BOTH SIDES —...............H108000 04-805

SHIELD, DISC BRAKE SPLASH LH — REPLACE......... .....H108200 04-805

SHIELD, DISC BRAKE SPLASH RH — REPLACE.............H108100 04-805

SHIFT CONTROL MECHANISM — R&R/REPLACE...........K103100 04-100

SHIFT CONTROL MECHANISM — R&R/REPLACE...........K103100 04-060

SHOCK ABSORBER SUPERLIFT REAR BOTH —.............F121300 AA-225

SHOCK ABSORBER SUPERLIFT REAR BOTH —.............F121300 07-150

SHOCK ABSORBER SUPERLIFT REAR LH —..................F121200 AA-225

SHOCK ABSORBER SUPERLIFT REAR LH —..................F121200 07-150

SHOCK ABSORBER SUPERLIFT REAR RH —..................F121100 AA-225

SHOCK ABSORBER SUPERLIFT REAR RH —..................F121100 07-150

SHOCK ABSORBER, REAR BOTH — REPLACE...............F120000 07-150

SHOCK ABSORBER, REAR LH — REPLACE....................F120200 07-150

SHOCK ABSORBER, REAR RH — REPLACE....................F120100 07-150

SHOES/LINING ASM. REAR PARK BRAKE BOTH —........H327000 04-825

SHOES/LINING ASM. REAR PARK BRAKE LH —.............H327200 04-825

SHOES/LINING ASM. REAR PARK BRAKE RH —..... ........H327100 04-825

SHORT MOTOR — REPLACE (EXCL. GEN III, GEN.........J340000 00-248

SHROUD, RADIATOR COOLING FANS — REPLACE.......J603500 01-105

SHROUD, RADIATOR UPPER — REPLACE......................J603550 01-105

SKIRT/PLATE, ROCKER/SILL PANEL LH (ONE.................C888600 10-300

SKIRT/PLATE, ROCKER/SILL PANEL RH (ONE................C888000 10-300

SKIRT/SILL PLATE, FRONT BUMPER BAR —...................A506100 10-300

SKIRT/SILL PLATE, FRONT BUMPER BAR —...................A506100 07-500

SLIP RING, KEY RE A D ER — REP L AC E.... ... ............ ... .......N31 3 60 0 06-255

SMART UNIT AS M. — REPL A CE........................ ... ............ .L 790300 AA-650 R

SOCKET ASM. TI E ROD LH — REPLA C E. ............ ... ..........M 0 35 010 06-310

SOCKET ASM. TI E ROD RH — REPL AC E... ............ ... .......M0 3502 0 06-310

SOCKET, ACCESSORY POWER SUPPLY —....................N311700 14-900

SOCKET, ACCESSORY POWER SUPPLY —....................N311700 09-300

SOCKET, ACCESSORY POWER SUPPLY —....................N311800 14-480

SOLENOID ASM, REVERSE LOCK OUT —.......................K500400 04-090

SOLENOID VA LVE, CAMSHAFT POSITION ACTU—........J794100 02-000

SOLENOID VA LVE, CAMSHAFT POSITION ACTU—........J794200 02-000

SOLENOID, TAILGATE WINDOW RELEASE (AWD)..........C020200 11-03 0

SOLENOID, VACUUM MASTER — REPLACE...................D021400 08-150

SOLENOID/VALVE, CANISTER PURGE —........................L013100 03-165

SPARK PLUG — REPLACE/CLEAN OR ADJUST..............J735100 02-030

SPEAKER & GRILLE ASM. LH ROOF MOUNTED —.........R211500 09-500

SPEAKER & GRILLE ASM. RH ROOF MOUNTED —....... ..R211400 09-500

SPEAKER & LEAD ASM. REAR LH — REPLACE..............R213350 09-500

SPEAKER & LEAD ASM. REAR RH — REPLACE..............R213300 09-500

SPEAKER ASM. FRONT DASH CENTRE.................. .........R211160 09-500

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

SPEAKER ASM. FRONT DASH/DOOR HANDLE...............R211100 09-500

SPEAKER ASM. FRONT DASH/DOOR HANDLE...............R211150 09-500

SPEAKER ASM. LH FRONT DOOR MOUNTED —.............R211700 09-500

SPEAKER ASM. REAR LH DOOR 1/4 PANEL....................R211750 09-500

SPEAKER ASM. REAR RH DOOR 1/4 PANEL............. ......R211650 09-500

SPEAKER ASM. RH FRONT DOOR MOUNTED —........... .R211600 09-500

SPEAKER, REVERSE PARKING AID — REPLACE...........N770200 07-525

SPEAKER, TELEMATICS — REPLACE........ ......................N446200 09-540

SPEEDOMETER ASM — R&R/REPLACE...........................N300500 09-120

SPOILER ASM. (HSV UTE) — REPLACE...........................A506450 10-350

SPOILER ASM. DECK LID — REPLACE ............................A506500 10-350

SPOILER, REAR — TOP COAT REPAIR............................B201060 99-050

SPORTS/CARRY BAR (UTE ONLY) — REPLACE .............R603800 AA-020

SPRING, ACTUATING LEVER RETURN LH —..................H025600 04-825

SPRING, AC T UAT ING LEVER RETUR N R H —.... ... ... ........H025 500 04-825

SPRING, BR A K E PE D A L RE TURN — REPLAC E. ... ...........H30 2 10 0 04-600

SPRING, CAP AND/OR SEAL — VALVE (ONE CYL.)........J307230 00-075

SPRING, CAP AND/OR SEAL — VALVE (ONE CYL.)........J307130 00-075

SPRING, CAP AND/OR SEAL, VALVE (TWO CYL) —........J307030 00-075

SPRING, CLUT CH PEDAL RETURN — REPLACE............K006100 04-600

SPRING, FRONT COIL BOTH — R&R/REPLACE..............E105000 06-210

SPRING, FRONT COIL LH — R&R/REPLACE....................E105200 06-210

SPRING, FRONT COIL RH — R&R/REPLACE...................E105100 06-210

SPRING, HOOD LOC K RELEASE — REPLACE.................A517600 12-050

SPRING, RE A R COIL B OTH — REP LAC E ........... ... ... ........F10000 0 07-150

SPRING, RE A R COIL LH — REPL A CE..... ............ ... ...........F10 02 0 0 0 7- 15 0

SPRING, RE A R COIL R H — REPL A CE.......... ............ ... .....F100100 0 7- 15 0

SPRING, REAR LEAF BOTH — REPLACE.........................F101000 07-150

SPRING, REAR LEAF LH — REPLACE..............................F101200 07-150

SPRING, REAR LEAF RH — REPLACE..............................F101100 07-150

SPRING, TH R O TT LE RE T UR N — REP L AC E............. ... .....J814500 03-650

SPROCKET, CAMSHAFT TIMING — LEFT BANK..............J314450 00-225

SPROCKET, CAMSHAFT TIMING — LEFT BANK..............J314400 00-225

SPROCKET , CA MSH A F T TI MI NG — RIGH T BA N K......... ..J314300 0 0- 22 5

SPROCKET , CA MSH A F T TI MI NG — RIGH T BA N K......... ..J314350 0 0- 22 5

SPROCKET, TIMING CHAIN/BELT CRANKSHAFT —.......J114100 00-225

SPROCKET, TIMING CHAIN/BELT, CAMSHAFT —...........J314560 00-225

SQUIRTERS, CRANKSHAFT OIL — REPLACE .................J320150 00-200

STABILIZER SHAFT, RR — REPLACE...............................F122100 07-150A

STABILIZER SHAFT, RR — REPLACE...............................F122100 07-125

STARTER MOTOR ASM. — REPLACE...............................J594000 02-070

STEERING COLU MN ASM. COMP LE T E — R&R/..............M019100 06-253

STONE GUARD/DEFLECTOR ASM. FUEL TANK —..........R606500 03-074

STOP/NUT/CAP, SUSPENSION REBOUND LH —.............E130040 06-210

STOP/NUT/CAP, SUSPENSION REBOUND RH —............E130030 06-210

STRAINER, FUEL PICKUP — REPLACE............................L006320 03-074

STRAP ASM. EAR T H C OC KP IT TO BOD Y —................ ... .N001720 02-180

STRAP ASM. EARTH ENGINE TO BODY — REPAIR/.......N001700 02-180

STRAP ASM. FUEL TANK SUPPORT — REPLACE...........L004100 03-055

STRAP ASM. HOOD TO BODY — REPAIR/.......................N001710 02-180

STRIKER ASM. ENDGATE LH — REPLACE......................C613550 12-685

STRIKER ASM. ENDGATE RH — REPLACE......................C613500 12-685

STRIKER PLATE ASM. LH FRONT DOOR —.....................C624200 11-360

STRIKER PLATE ASM. LH REAR DOOR —.......................C643200 11-725

STRIKER PLAT E A SM. RH FR ON T DOOR —....... ... ..........C62 4 10 0 11-360

STRIKER PLA T E A SM. RH RE A R DO OR —.... ... ............ ... .C643100 11-725

STRIP & REPAINT — UTE...................................................B000910 99-050

STRIP & REPAINT SEDAN..................................................B000910 99-050

STRIP & REPAINT STATION WAGON................................B000910 99-050

STRIP ASM. REAR BUMPER — REPLACE........................A580000 07-525

STRIPES (PAINT) OR TRANSFER/DECALS —..................B069099 99-050

STRIPES (PAINT) OR TRANSFER/DECALS —..................B069099 10-250

STRUT ASM, BOTH FRONT — REPLACE .........................E108000 06-212

STRUT ASM, LH FRONT — REPLACE...............................E108200 06-212

STRUT ASM, RH FRONT — REPLACE..............................E108100 06-212

STRUT ASM. DEC K LID BOTH — REPLACE... ... ............ ... .C756000 12-660

STRUT ASM. DE C K LID LH — REPLA CE... ... ............ ... .......C75 6 20 0 12-660

STRUT ASM. DECKLID RH — REPL A CE.................... ... ....C756 100 12-660

STRUT ASM. TAILGATE/HATCH BOTH — REPLACE.......C756000 12-500

STRUT ASM. TAILGATE/HATCH LH — REPLACE ............C756200 12-500

STRUT ASM. TAILGATE/HATCH RH — REPLACE............C756100 12-500

STRUT TOWER, BOT H — REPAIR /RE P LAC E............... ....A500600 12-4 25

STRUT TOWER, LH — REPAIR/REPLACE........................A500500 12-425

STRUT TOWER, RH — REPAIR/REPLACE........................A500400 12-425

STRUT, ENGINE HOOD SUPPORT LH — REPLACE...... ..A502400 12-050

STRUT, ENGINE HOOD SUPPORT RH — RE PLACE .......A5025 00 12-050

STRUT, RIGID TONNEAU COVER — REPLACE...............C756000 AA-025

STRUT, RIGI D TONNEAU COVER LH — REPLACE..........C756200 AA-025

STRUT, RIGID TONNEAU COVER RH — REPLACE.........C756100 AA-025

STRUT/BUSHES, RR STABILIZER BAR LH —...................F125250 07-125

STRUT/BUSHES, RR STABILIZER BAR RH —..................F125150 07-125

STUD/BOLT, FRONT WHEEL LH — REPLACE (ONE........E006200 04-805

STUD/BOLT, FRONT WHEEL RH — REPLACE (ONE.......E006100 04-805

STUD/BOLT, REAR WHEEL LH — REPLACE (ONE/.........E006600 05-290

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

STUD/BOLT, REAR WHEEL LH — REPLACE (ONE/.........E006600 05-400

STUD/BOLT, REAR WHEEL RH — REPLACE (ONE/........E006500 05-400

STUD/BOLT, REAR WHEEL RH — REPLACE (ONE/........E006500 05-290

STUD/BUSH/WASHER, STABILIZER BAR TO...................E109200 06-205

SUN BLIND/VENETIAN, REAR WINDOW (INT) —.............R601700 AA-015

SUN ROOF — R & R............................................................A504100 AA-000

SUNSHADE ASM, SUNROOF — REPLACE.......................A504400 AA-000

SUNSHADE, FRONT WINDSHIELD (EXT) —.....................R602000 AA-015

SUNSHADE , RE A R WINDOW (E XT ) — REPL A CE .......... ..R 602 100 AA-015

SUNVISOR & PIVOT ASM. LH — REPLACE......................C402200 14-050

SUNVISOR & PIVOT ASM. RH — REPLACE......................C402100 14-050

SUPERCHARGER ASM. — REPLACE ...............................J590800 00-375

SUPPORT ASM. PEDAL LEVER — REPLACE...................J816500 03-650

SUPPORT ASM. REAR — REPLACE.................................J338010 04-020

SUPPORT ASM. TRANSMISSION CONTROL INDI—........C474210 04-190

SUPPORT, IDLER PULLEY, AIR CONDITIONING —.........J607300 01-030

SUPPORT, IDLER PULLEY, DRIVE BELT —......................J607500 01-030

SUPPORT , RE A R ALT E RN A T OR MOUNTING.............. ... ..J7 1 22 0 0 0 2- 14 0

SWITCH — LPG/ULP CHANGE OVER — REPLACE.........N220950 04-190

SWITCH — POWER/ECONOMY/OVER DRI V E —..............K500120 04-190

SWITCH ASM. (CONSOLE) WINDOW LIFTER ALL —.......N226000 02-775

SWITCH ASM. SUNROOF OPENING — REPAIR/....... ......N526010 02-775

SWITCH ASM. VEHICLE STABILITY/PITCH CON—..........N526050 02-775

SWITCH HOUSING/BEARING SUPPORT ASM. —............M012510 06-255

SWITCH, A/ C CON T ROL — REPL AC E.............. ... ............ ..D 110 10 0 08-155A

SWITCH, ANT I TH EF T HOOD AC T UATOR —....................N21 6 550 09-552

SWITCH, BLUETOOTH — REPLACE.................................N780050 09-515

SWITCH, BRAK E PR E S SUR E WARNIN G —..... ... ..............H 401 10 0 04-725

SWITCH, CRUISE CONTROL (CLUTCH) —.......................N207550 04-600

SWITCH, CRUISE CONTROL ACTUATOR —....................R401100 03-400

SWITCH, DOME LAMP/DOOR AJAR LH FRT —................N212510 02-780

SWITCH, DOME LAMP/DOOR AJAR LH REAR —.............N212530 02-780

SWITCH, DOME LAMP/DOOR AJAR RH FRT —...............N212500 02-780

SWITCH, DOME LAMP/DOOR AJAR RH REAR —............N212520 02-780

SWITCH, ELECTRIC FRONT DOOR LOCK RH —.............N240150 11-360

SWITCH, ELECTRIC SEAT LH — REPLACE......................N264100 14-275

SWITCH, ELECTRIC SEAT RH — REPLACE.....................N264200 14-275

SWITCH, FAN A/C BLOWER MOTOR SPEED —...............D329100 08-155A

SWITCH, FRONT FOG LAMPS — REPLACE.....................N761700 02-800

SWITCH, FRONT PA R K A SSIS T — REPLA C E . ... ..............N 770 16 0 07-500

SWITCH, GLOVE BOX LA MP — REPL A C E . ... ... ... ..............N 214 60 0 02-780

SWITCH, HAZAR D WARNI NG — REPLA CE........ ... ... ........N220600 02-800

SWITCH, HEADLAMP — REPLACE....................................N218500 02-800

SWITCH, IGNITION — REPLACE ........... ............... .............N313500 06-255

SWITCH, PARK BRAKE WARNING LAMP —.... .................N2085 00 04-675

SWITCH, RE A R COMP A R TME N T LA MP —....... ............ ... .N216500 02-780

SWITCH, RE A R CO MP A R TME N T LOC K REL E A SE...... ....N25 3 30 0 12-680

SWITCH, RE A R CO MP A R TME N T LOC K REL E A SE...... ....N25 3 30 0 02-775

SWITCH, REAR WINDOW DEMIST — REPLACE..............D200100 08-155A

SWITCH, REVERSE LIGHT — REPLACE...........................N209500 04-075

SWITCH, STOP LIGHT/CRUISE CONTROL —...................N207500 04-600

SWITCH, TRACTION CONTROL — REPLACE ..................N220900 04-190

SWITCH, TR A N SMIS S ION SHIF T ST E E RI NG. ... ............ ... .R201600 06-225

SWITCH, TRIP COMPUTER/OVER SPEED —...................N833100 02-800

SWITCH, VA C U UM A/ C — REPL A C E.............. ............ ... ....D200 500 08-155 A

SWITCH, VAC U UM PL U NGER — REPLA C E .................... .D021600 08-150

SWITCH, VAC U UM PL U NGER — REPLA C E .................... .D333500 08-155A

SWITCH, VA L V E BOD Y FLU ID TE MP ER A TU R E —. ..........K 60 0320 04-220

SWITCH, WINDOW LI FT E R BOT H REAR DOORS —........N23 0 000 02-775

SWITCH, WINDOW LI FT E R LH REA R DOOR —......... .......N 23 0 200 02-775

SWITCH, WINDOW LI FT E R RH REA R D OOR —........... ... .N230100 02-775

SWITCH/HARN ESS ASM. NEUTRAL START —................N206500 04-170

SWITCH/HARNESS, MIRROR ADJUSTMENT —...............N240200 02-775

SWITCH/LE VE R , TU R N SIGN AL & HEADL A MP.... ... ... ... ....N20260 0 06-250

SWITCH/LEVER, WINDSHIELD WIPER WASHER —........N203000 06-250

SWITCH/MODULE ASM. ELECTRIC SEAT MEM— ...........N264000 14-275

SWITCH/S E N SOR , TH R OTTLE POSITION —.......... ... ... ....N308 700 03-300

TABLETS/PELLETS, COOLING SYSTEM — ADD..............J600520 01-105

TACHOME T E R — REPL A CE ..... ... ............. ... ............ ... .......N31 0 500 09-120

TAILGATE OR HATCH ASM. — ALIGN...............................P002100 12-685

TAILGATE OR HATCH ASM. — ALIGN...............................P002100 12-500

TAILGATE OR HATCH ASM. — R & R................................A321400 12-500

TAILGATE OR HATCH ASM. — R & R................................A321400 12-685

TAILGATE/HATCH OPENING — SPOT REPAIR................B100360 99-050

TANK & SEAL, RADIATOR SIDE LH — REPLACE.............J600510 01-105

TANK & SEAL, RADI ATOR SIDE RH — REPLA CE............J600530 01-105

TANK/RESERVOIR ASM. VACUUM — REPLACE.............D9070 00 08-02 5

TENSIONER ASM. A/C DRIVE BELT (GEN III, GEN ..........D312000 01-020

TENSIONER ASM. MAIN BELT — REPLACE.....................J607250 01-020

TENSIONER ASM. MAIN DRIVE BELT — REPLACE.........J607250 01-030

TENSIONER ASM. SUPERCHARGER DRIVE BELT..........J607400 01-030

TENSíR, GEAR/PULLEY GUIDE/DAMPER TIMING...........J112700 00-225

THERMOST A T ASM. — REPL A CE............ ... ... ...................J60 8 130 00-350

THERMOST A T/SENSOR, E VA P O RA T O R — ................. ... .D332700 08-150

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

THIRD SEAT, STATION WAGON REAR —........................R902200 AA-020

TONGUE, TOW BAR — REPLACE.....................................R603520 AA-025

TONNEAU COVER, (R IGID ) — TO P COAT REPAIR..........B077770 99-050

TOP COAT REPAIR — UTE................................................B000920 99-050

TOP COAT REPAIR SEDAN................................................B000920 99-050

TOP COAT REPAIR STATION WAGON............................. .B000920 99-050

TOW BALL, TOW BAR — REPLACE ..................................R603510 AA-025

TOWBAR — REPLACE.................... ............................ ........R603500 AA-025

TRACK/HEIGHT ADJUSTER ASM. LH FRT SEAT —.........C521210 14-275

TRACK/HEIGHT ADJUSTER ASM. RH FRT SEAT —........C521220 14-275

TRAILING ARM/LINK LH REAR — REPLACE....................F110250 07-150A

TRAILING ARM/LINK RH REAR — REPLACE....................F110150 07-150A

TRANSDUCER/PRESSURE SENSOR — REPLACE..........D308100 08-200

TRANSFER CASE ASSY. — OVERHAUL...........................K400110 04-050

TRANSFER CASE ASSY. — REPLACE..............................K400100 04-050

TRANSMISSION COOLER FLUSH/FLOW CHECK.............K600600 04-200

TRAY OR SUPPORT, BATTERY — REPLACE...................N003500 02-200

TRIM ASM. INST PANEL LOWER LH — REPL AC E......... ..C456800 09-140

TRIM ASM. INST PANEL LOWER RH — REPLACE...........C464100 09-140

TRIM ASM. LH FRONT DOOR — R&R/ R EP L AC E..............C406200 14-220

TRIM ASM. LH REAR DOOR — R&R /R E PLA C E................C 414 200 14-270

TRIM ASM. REAR HEADREST MOUNT — REPLACE.......C427350 14-460

TRIM ASM. REAR SEAT BACK (COMPLETE/BOTH..........C572210 14-350

TRIM ASM. REAR SEAT BACK (COMPLETE/BOTH..........C572210 14-325

TRIM ASM. REAR SEAT BACK LH — REPL AC E....... ........C58220 0 14-325

TRIM ASM. REAR SEAT BACK RH — REPL AC E...............C58 2 10 0 14-325

TRIM ASM. REAR SEAT CUSHION — REPLACE..............C570100 14-330

TRIM ASM. RH FRONT DOOR — R&R/REPLACE.............C406100 14-220

TRIM ASM. RH REAR DOOR — R&R /R E PLA C E ............. ..C 414 10 0 14-270

TRIM ASM. SEAT BACK DRIV E Rí S — REPL ACE...... ........C555 10 0 14-295

TRIM ASM. SEAT BACK PANEL — REPLACE (UTE/.........C427300 14-460

TRIM ASM. SEAT BACK PASSENGER — REPLACE........C555200 14-295

TRIM ASM. STOP LAMP — REPL AC E .. ... ... ............... ........C436350 14-500

TRIM ASM. TAILGATE LO WER — R& R/ RE P LAC E.... ........C436300 14-500

TRIM ASM. UPPER TAILGATE (ONE PIECE/ALL) —.........C436150 14-500

TRIM ASM. UPPER TAILGATE LH — R&R/REPLACE.......C436250 14-500

TRIM ASM. UPPER TAILGATE RH — R&R/.......................C436200 14-500

TRIM, "A" PILLAR ONE PIECE/UPPER LH —.....................C623450 14-100

TRIM, "A" PILLAR ONE PIECE/UPPER RH —....................C623400 14-100

TRIM, "B" PILLAR CENTRE LH — REPLACE.....................C411250 14-100

TRIM, "B" PILLAR CENTRE RH — REPLACE....................C411150 14-100

TRIM, "B" PILLAR LOWER LH — REPLACE.......................C623550 14-100

TRIM, "B" PILLAR LOWER RH — REPLACE......................C623500 14-100

TRIM, "B" PILLAR UPPER LH — REPLACE.......................C622250 14-100

TRIM, "B" PILLAR UPPER RH — REPLACE............. ..........C622200 14-100

TRIM, "C" PILLAR LH — REPLACE.....................................C410410 14-120

TRIM, "C" PILLAR LOWER LH — REPLACE ......................C410420 14-130

TRIM, "C" PILLAR LOWER LH — REPLACE ......................C410420 14-120

TRIM, "C" PILLAR LOWER RH — REPLACE......................C410320 14-120

TRIM, "C" PILLAR LOWER RH — REPLACE......................C410320 14-130

TRIM, "C" PILLA R RH — REPL A CE........ ... .........................C410310 14-120

TRIM, "C" PILLAR UPPER LH — REPLACE.......................C410410 14-130

TRIM, "C" PILLAR UPPER RH — REPLACE.......................C410310 14-130

TRIM, "D" PILLAR LH — REPLACE.....................................C624350 14-130

TRIM, "D" PILLA R RH — REPL A CE........ ... .........................C624300 14-130

TRIM, ARMR E S T ASM. — RE PL A CE ................. ... ............ .C572800 14-350

TRIM, COWL SIDE LOWER LH — R&R/REPLACE............C456200 14-100

TRIM, COWL SIDE LOWER RH — R&R/REPLACE............C456100 14-100

TRIM, FRONT REAR QUARTER LH — REPLACE.............C421200 14-120

TRIM, FRONT REAR QUARTER LH — REPLACE.............C421200 14-130

TRIM, FRONT REAR QUARTER LH — REPLACE.............C421200 14-270

TRIM, FRONT REAR QUARTER RH — REPLACE.............C421100 14-130

TRIM, FRONT REAR QUARTER RH — REPLACE.............C421100 14-120

TRIM, FRONT REAR QUARTER RH — REPLACE.............C421100 14-270

TRIM, FRONT SEAT CUSHION DRIVERíS —....................C552100 14-295

TRIM, FRONT SEAT CUSHION PASSENGER —...... .........C553100 14-295

TRIM, FRONT SEAT HEAD RESTRAINT LH —..................C505250 14-295

TRIM, FRONT SEAT HEAD RESTRAINT RH —.................C505150 14-295

TRIM, REAR SEAT BACK ARMREST — REPLACE...........C572500 14-325

TRIM, REAR SIDE PANEL LH — REPLACE.......................C624450 14-130

TRIM, REAR SIDE PANEL RH — REPLACE ......................C624400 14-130

TRIM/CARPET ASM. REAR COMPARTMENT....................C434100 14-480

TRIM/CARPET ASM. REAR COMPARTMENT....................C434200 14-480

TRIM/CARPET ASM. REAR COMPARTMENT....................C434200 14-490

TRIM/CARPET ASM. REAR COMPARTMENT....................C434100 14-490

TRUNION/ST UB AXLE, LH REAR — REPLACE.................F201400 05-290

TRUNION/ST UB AXLE, RH REAR — REPLACE................F201300 05-290

TUB, REAR LOAD AREA — R&R/REPLACE......................A590500 12-685

TUBE & BRACKET ASM. OIL LEVEL GAUGE —....... .........J217700 00-580

TUBE ASM. RECEIVER DEHYDRATOR TO TX .................D307100 08-200

TUBE, CONNECTING — REPLACE....................................J601510 01-160

TUBE, RESERVOIR OVERFLOW — REPLACE.................J602500 01-140

TUBE, TRANS. OIL FILLER — REPLACE...........................K604200 04-010

U BOLT, LEAF SPRING LH — REPLACE...........................F108200 07-150

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

U BOLT, LEAF SPRING RH — REPLACE...........................F108100 07-150

UNION/PIPE ASM, ONE/BOTH TRANS TO OIL..................K603000 04-200

UNION/PIPE ASM, ONE/BOTH TRANS TO OIL..................K603000 04-150

UNIVERSAL JOINT, PROPELLER SHAFT CENTRE..........F911100 05-050

UNIVERSAL JOINT/RUBBER MOUNT, FRONT —.............F908100 05-050

UNIVERSAL JOINT/RUBBER MOUNT, REAR — ...............F910100 05-050

VACUUM HOSE (ANY ONE) — REPAIR/REPLACE...........J589300 03-300

VALVE ASM. HE A T ER WATE R — RE PL A CE .......... ... ........D111 700 08-075

VALVE ASM. NON RET UR N WIND S HI EL D............. ... ........N355 500 10-500

VALVE ASM. POWER STEERING — REPLACE................M147200 06-310

VALVE ASM/GROMMET, CHECK POWER BRAKE —.......H504100 04-725

VALVE ASSEMBLY, ANTI THEFT — REPLACE................ .L701400 AA-650R

VALVE EGR &/OR GASKET — REPLACE.......... ................J980500 03-300A

VALVE STEM/TYRE PR E SS U R E INDICATOR........ ...........E00 0 90 0 05- 80 0

VALVE, (PCV) CRANKCASE VENT CONTROL —.............J950100 00-249

VALVE, COMPRESSOR CONTROL — REPLACE.............D333700 08-200

VALVE, CYL. HEAD (ONE) — REPLACE CYLS 1,3,5,.......J310010 00-075

VALVE, CYL. HEAD (ONE) — REPLACE CYLS 2,4,6,.......J310020 00-075

VALVE, FRONT GAS LOCK OFF — REPLACE..................L701030 AA-650Q

VALVE, FUEL CONTROL — REPLACE..............................L701250 AA-650Q

VALVE, NON RETURN, SECONDARY AIR —....................J980700 03-300A

VALVE, OIL PRESSURE RELIEF/REGULATING —...........J316510 01-500

VALVE, PROPORTIONING OR LOAD SENSING —...........H408500 04-725

VALVE, SWITCH OVER, SECONDARY AIR —...................J980910 03-300A

VALVE, TX/EXPANSION AND OR O RINGS —..................D319000 08-200

VALVE, VACUUM CONTROL — REPLACE........................D907150 08-025

VENETIAN, REAR QUARTER WINDOW (INT) —...............R601800 AA-015

VENT, CABIN VENTILATION, BOTH/ALL —.......................D016000 08-700

VENT, CABIN VENTILATION, LH — REPLACE..................D016200 08-700

VENT, CABIN VENTILATION, RH/CENTRE —...................D016100 08-700

VENT, REAR SIDE PANEL LH — REPLACE......................C435600 14-490

VENT, REAR SIDE PANEL RH — REPLACE......................C435500 14-490

VENT/AIR BOX HOUSING, CONSOLE REAR —................D358400 14-900

VENT/AIR BOX HOUSING, CONSOLE REAR —................D358400 08-175

VENT/AIR BOX HOUSING, LH FRONT — REPLACE.........D358500 08-175

VENT/AIR BOX HOUSING, RH FRONT — REPLACE........D358600 08-175

VOLTAGE REGULATOR — REPLACE...............................J592800 02-140

WEATHERSHIELD, DOOR MOUNTED LH —.....................R603100 AA-015

WEATHERSHIELD, DOOR MOUNTED RH —....................R603000 AA-015

WEATHERSTR I P ASM. DR OP WIND OW LH..... ... ... ...........C013 110 11-650

WEATHERSTR I P ASM. DR OP WIND OW RH.......... ... ........C013210 11-650

WEATHERS TR IP ASM. GLASS SIDE PANEL (C..... ... ... .....C117200 11-020

WEATHERSTRIP ASM. GLASS SIDE PANEL (C................C117100 11-020

WEATHERSTRIP ASM. LH FRONT DOOR —....................C105200 11-600

WEATHERSTRIP ASM. LH FRT DOOR FRAME —............C118400 11-650

WEATHERST RI P AS M. LH REA R DOOR —.......................C110 20 0 11-600

WEATHERSTRIP ASM. LH REAR DO OR FRAME —.........C118600 11-775

WEATHERSTRIP ASM. LH REAR DROP WINDOW. ..........C127600 11-775

WEATHERST RI P ASM. RH FR ON T DOOR —.... ... .............C105100 11-600

WEATHERSTRIP ASM. RH FRT DO OR FRAME — ...........C118300 11-650

WEATHERST RI P AS M. RH RE AR DOOR —............ ... .......C110 10 0 11-600

WEATHERSTRIP ASM. RH REAR DO OR FRAME — ........C118500 11-775

WEATHERSTRIP ASM. RH REAR DROP WINDOW..........C127500 11-775

WEATHERS T RI P ASM. ROC K E R PA N E L LH —................C106800 11-600

WEATHERS T RI P ASM. ROC K E R PA N E L RH —...... ... .......C 10 6 70 0 11-600

WEATHERSTRIP, DECK LID — REPLACE ........................C125500 11-600

WEATHERSTRIP, HOOD — REPLACE..............................C107700 12-050

WEATHERSTRIP, SUN ROOF — REPLACE......................A504350 AA-000

WEATHERSTRIP, TAILGATE/HATCH — REPLACE.... ......C126000 11-600

WELSH PLUG ALL — REPLACE (V6 ONLY)......................J332000 00-248

WELSH PLUG, CYL HEAD FRONT — REPLACE...............J314750 00-075

WELSH PLUG, CYL HEAD FRONT — REPLACE...............J314740 00-075

WELSH PLUG, CYL HEAD REAR — REPLACE CYLS..... ..J314760 00-075

WELSH PLUG, CYL HEAD REAR — REPLACE CYLS..... ..J314770 00-075

WELSH PLUG, ENGINE BLOCK VALLEY —......................J314800 00-075

WELSH PLUG, FRONT OIL GALLERY — REPLACE.........J214700 00-248

WELSH PLUG, LH SIDE — REPLACE ONE/BOTH............J332200 00-248

WELSH PLUG, RH SIDE — REPLACE ONE/BOTH............J332100 00-248

WHEEL ALIGNMENT — CHECK & ADJUST.......................P201120 06-212

WHEEL ALIGNMENT — CHECK & ADJUST.......................P201120 06-275

WHEEL ALIGNMENT — CHECK & ADJUST.......................P201120 06-200

WHEEL ASM. (ONE) — REPLACE......................................E000100 05-800

WHEEL ASM. STEERING — REPLACE..............................M001500 06-225

WHEEL BALANCE, ALL WHEELS.......................................P207000 05-800

WHEEL BALANCE, FRONT WHEELS.................................P207100 05-800

WHEEL BALANCE, REAR WHEELS...................................P207200 05-800

WHEEL, ROAD — PAINT.....................................................B092510 99-050

WHEEL/LEVER, LUMBAR SUPPORT — REPLACE...........C502920 14-275

WINDOW REGULAT OR A SM. LH RE AR DOOR/...... ... .......C 01 3 230 11-810

WINDOW REGULAT O R A SM. RH RE A R DO OR /........... ... .C013130 11-810

WINDOW REGULATOR MOTOR/CABLE ASM. LH............N227200 11-675

WINDOW REGULATOR MOTOR/CABLE ASM. RH............N227100 11-675

WINDOW REGULATOR , LH FRONT — REPLACE ......... ...C006200 11-675

WINDOW REGULATOR , RH FRONT — REPLACE............C0061 00 11-675

ALPHABETICAL INDEX

No.Description Sect. No. No.Description Sect. No.

WARRANTY

PROCESSING

WINDOW REGULATOR/MOTOR ASM. LH REAR..............N229250 11-810

WINDOW REGULATOR/MOTOR ASM. RH REAR .............N229150 11-810

WRENCH, WHEEL NUT — REPLACE................................E001600 05-825

YOKE, PROPELLER SHAFT SLIP, FRONT —....................F908200 05-050

No. Description Sect. No.

NUMERICAL INDEX

No. Description Sect. No.

WARRANTY

PROCESSING

A000000 OWNER HAND BOOK — REPLACE (PD ONLY)................AA-020

A015000 SCOOP ASM, HOOD AIR RH — REPLACE .......................12-050

A015100 SCOOP ASM, HOOD AIR LH — REPLACE........................12-050

A015200 SCOOP ASM, HOOD AIR BOTH — REPLACE...................12-050

A201598 FLOOR ASM. FRONT — RESEAL......................................12-000

A202000 CROSSMEMBER ASM. REAR — RESEAL ........................12-000

A202100 PANEL ASM. SHROUD SIDE RH — RESEAL....................12-000

A202200 PANEL ASM. SHROUD SIDE LH — RESEAL.....................12-000

A202300 EXTENSION ASM. FLOOR PANEL FRONT —...................12-000

A202400 PANEL ASM. BACK UPPER — RESEAL............................12-000

A202500 PANEL, REAR QUARTER INNER LH — RESEAL..............12-000

A202600 PANEL, REAR QUARTER INNER RH — RESEAL.............12-000

A202700 PANEL, REAR WHEELHOUSE INNER LH —.....................12-000

A202800 PANEL, REAR WHEELHOUSE INNER RH —....................12-000

A202900 PANEL ASM. SPARE WHEEL WELL — RESEAL ..............12-000

A203098 FLOOR AS M. RE A R — RESEA L.............. ... ... ................ .....12-0 00

A205199 PAN, REAR COMPARTMENT FLOOR — RESEAL............12-000

A206098 PANEL ASM. COCKPIT/COWL — RESEAL .......................12-000

A210198 RAIL, ROOF SIDE. RH SIDE — RESEAL ...........................12-000

A210298 RAIL, ROOF SIDE. LH SIDE — RESEAL............................12-000

A313500 DOOR ASM. RH FRONT — R & R......................................12-460

A313600 DOOR ASM. LH FRONT — R & R.......................................12-460

A314500 DOOR ASM. REAR RH — R & R.........................................12-460

A314600 DOOR ASM. REAR LH — R & R.........................................12-460

A319900 DECK LID ASM. REAR COMPARTMENT — R & R............12-660

A319910 DECK LID ASM. REAR COMPARTMENT — ......................12-660

A321400 TAILGATE OR HATCH ASM. — R & R ...............................12-500

A321400 TAILGATE OR HATCH ASM. — R & R ...............................12-685

A500000 BRACE, FRONT LONGí BOTH — TIGHTEN/.....................12-425

A500100 BRACE, FRONT LONGí RH — TIGHTEN/REPLACE.........12-425

A500110 PANEL ASM. ENGINE HOOD — R & R..............................12-425

A500200 BRACE, FRONT LONGí LH — TIGHTEN/REPLACE..........12-425

A500300 COCK PIT MODULE PA N E L — RE PA IR /R E P LA C E............12-425

A500400 STRUT TOWER, RH — REPAIR/REPLACE.......................12-425

A500500 STRUT TOWER, LH — REPAIR/REPLACE........................12-425

A500600 STRUT TOWER, BOTH — REPAIR/REPLACE ..................12-425

A501100 HINGE ASM. ENGINE HOOD RH — REPLACE.................12-050

A501200 HINGE ASM. ENGINE HOOD LH — REPLACE..................12-050

A502400 STRUT, ENGINE HOOD SUPPORT LH — REPLACE....... .12-050

A502500 STRUT, ENGINE HOOD SUPPORT RH — REPLACE.......12-050

A504100 SUN ROOF — R & R ...........................................................AA-000

A504150 DEFLECTOR PANEL, SUN ROOF — REPLACE................AA-000

A504200 GUIDE RAILS, BOTH SIDES, SUN ROOF —......................AA-000

A504250 MOTOR, SUN ROOF — REPLACE.....................................AA-000

A504300 CABLE, SUN ROOF — REPLACE ......................................AA-000

A504350 WEATHERSTRIP, SUN ROOF — REPLACE......................AA-000

A504400 SUNSHADE ASM, SUNROOF — REPLACE.......................AA-000

A505500 INSULATOR , EN GIN E HOOD — REPL ACE............ ...........12-050

A506000 INSERT, FOG LAMPS (ONE/BOTH) — REPLACE.............07-500

A506100 SKIRT/SILL PLATE, FRONT BUMPER BAR —...................07-500

A506100 SKIRT/SILL PLATE, FRONT BUMPER BAR —...................10-300

A506300 INSERT, ROCKER PANEL ALUMINIUM MOULD—............10-300

A506400 INSERT, ROCKER PANEL ALUMINIUM MOULD—............10-300

A506450 SPOILER ASM. (HSV UTE) — REPLACE...........................10-350

A506500 SPOILER ASM. DECK LID — REPLACE ............................10-350

A506600 AIR DEFL EC T O R, TAILGATE — REPLA C E............ ... ........10-350

A513500 PIN/SPRING, HOOD LOCK PILOT — REPLACE................12-050

A517500 CABLE AS M. EN GIN E HOOD — REPL A C E............... ........12-050

A517600 SPRING, HOOD LOCK RELEASE — REPLACE................12-050

A519500 HOOD LOCK SE C O ND A R Y CA T C H — RE PL A CE..... ........12-050

A530100 FENDER, PANEL RH — R & R............................................12-425

A530200 FENDER, PANEL LH — R & R............................................12-425

A531100 LINER, FRONT FENDER RH — REPLACE........................12-100

A531200 LINER, FRONT FENDER LH — REPLACE.........................12-100

A531300 LINER, REAR WHEELHOUSE, RH — REPLACE...............12-100

A531400 LINER, REAR WHEELHOUSE, LH — REPLACE................12-100

A550000 GRILLE ASM. (ONE/BOTH) — REPLACE...........................07-500

A560500 FASCIA ASM. FRONT BUMPER BAR LOWER —..............07-500

A561520 COVER, TOWING EYE — REPLACE .................................07-500

A567500 INSERT, BUMPER FASCIA ALUMINIUM RH —.................07-525

A567600 INSERT, BUMPER FASCIA ALUMINIUM LH —..................07-525

A567700 INSERT, TRAILER HITCH ALUMINIUM CENTRE —..........07-525

A567800 INSERT, BUMPER FASCIA ALUMINIUM REPLACE..........07-525

A567900 INSERT, REAR BUMPER FASCIA CHROME LH OR.........07-525

A568000 MOULDING, FRONT BUMPER BAR — REPLACE.............07-500

A568100 GRILLE, LO WE R RADIATOR, R&R /R E P LA C E .................. .07-500

A568200 PLATE, FRONT B UMP E R SKI D PL A TE ALUMIN— ........... .07-500

A569500 BUMPERETTE BAR ASM, REAR RH — REPLACE...........07-525

A569600 BUMPERETTE BAR ASM, REAR LH — REPLACE............07-525

A570500 FASCIA ASM. REAR BUMPER BAR COMPLETE —..........07-525

A571520 COVER, TOW BAR/TOWING EYE — REPLACE................07-525

A571550 LENS/CAP ASM. REFLEX RH — REPLACE.......................07-525

A571550 LENS ASM. REFLEX RH — REPLACE...............................02-350

A571575 LENS/CAP ASM. REFLEX LH — REPLACE.......................07-525

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

A571575 LEN S ASM. R EF L EX LH — REP LAC E . ... ............ ... ............0 2 -350

A571600 APPLIQUE/INSERT, REAR BUMPER — R&R/...................07-525

A580000 STRIP ASM. REAR BUMPER — REPLACE .......................07-525

A590500 TUB, REAR LOAD AREA — R&R/REPLACE......................12-685

B000910 STRIP & REPAINT SEDAN..................................................99-050

B000910 STRIP & REPAINT STATION WAGON ...............................99-050

B000910 STRIP & REPAINT — UTE..................................................99-050

B000920 TOP COAT REPAIR — UTE................................................99-050

B000920 TOP COAT REPAIR STATION WAGON.............................99-050

B000920 TOP COAT REPAIR SEDAN ...............................................99-050

B001100 PAN E L AS M. LOAD AREA TU B (U TE ) — SPO T....... .... ... ..99-050

B001110 PANEL ASM. FRONT DOOR OUTER RH — STRIP & .......99-050

B001119 PANEL ASM. FRONT DOOR OUTER RH — SPOT............99-050

B001120 PANEL ASM. FRONT DOOR OUTER RH — TOP..............99-050

B001199 MOULDI NG, RH FRON T DOOR — TOP COAT......... .... ... ..99-050

B001200 PANEL ASM. LOAD AREA TUB (UTE) — TOP COAT........99-050

B001210 PANEL ASM. FRONT DOOR OUTER LH — STRIP &.. ......99-050

B001219 PANEL ASM. FRONT DOOR OUTER LH — SPOT............99-050

B001220 PANEL ASM. FRONT DOOR OUTER LH — TOP...............99-050

B001299 MOULDI NG, LH FRON T DOOR — TOP COAT ... ... ... .........9 9 -0 50

B001300 PAN E L AS M. LOA D ARE A TUB (UTE) — STRIP &............99 -0 50

B001310 PANEL ASM. REAR DOOR OUTER RH — STRIP &..........99-050

B001319 PANEL ASM. REAR DOOR OUTER RH — SPOT..............99-050

B001320 PANEL ASM. REAR DOOR OUTER RH — TOP ................99-050

B001399 MOULDING, RH REAR DOOR — TOP COAT....................99-050

B001410 PANEL ASM. REAR DOOR OUTER LH — STRIP & ..........99-050

B001419 PANEL ASM. REAR DOOR OUTER LH — SPOT...............99-050

B001420 PANEL ASM. REAR DOOR OUTER LH — TOP.................99-050

B001499 MOULDING, LH REAR DOOR — TOP COAT REPAIR......99-050

B001510 PAN E L, REAR QUA RT E R OUT E R R H — STRIP &.......... ..99-050

B001510 PAN E L, REAR QUA RT ER OUTER RH (UTE ONL Y)..........99 -0 50

B001519 PAN E L, REAR QUA RT ER OUTER RH — SPOT....... .........99 -0 50

B001530 PANEL, REAR QUARTER OUTER RH — TOP COAT .......99-050

B001530 PAN E L, REAR QUA RT ER OUTER RH (UTE ONL Y)..........99 -0 50

B001610 PAN E L, REAR QUA RT E R OUT E R LH (U TE ONLY)......... ..99-050

B001610 PANEL, REAR QUARTER OUTER LH — STRIP & ............99-050

B001619 PANE L, REAR QUART E R OUT E R LH — SPOT............... ..99-050

B001630 PANEL, REAR QUARTER OUTER LH — TOP COAT........99-050

B001630 PAN E L, REAR QUA RT ER OUT E R LH (U TE ONL Y)......... ..99-050

B001710 DECK LID ASM. RR COMPARTMENT — STRIP &............99-050

B001719 DECK LID ASM. RR COMPARTMENT — SPOT ................99-050

B001720 DECK LID ASM. RR COMPARTMENT — TOP COAT........99-050

B001810 PANEL, TAILGATE (UTE ONLY) — STRIP &......................99-050

B001810 PANEL, TAILGATE OR HATCH — STRIP & REPAINT.......99-050

B001819 PANEL, TAILGATE OR HATCH — SPOT REPAIR.............99-050

B001820 PANEL, TAILGATE (UTE ONLY) — TOP COAT.................99-050

B001820 PANEL, TAI LGAT E OR HA T C H — TOP COA T..... ... ...........99-050

B002810 PILLAR, FRONT BODY RH — STRIP & REPAINT.............99-050

B002820 PILLAR, FRONT BODY RH — TOP COAT REPAIR...........99-050

B002910 PILLAR, FRONT BODY LH — STRIP & REPAINT..............99-050

B002920 PILLAR, FRONT BODY LH — TOP COAT REPAIR............99-050

B003300 PANEL ASM. ENGINE HOOD — STRIP & REPAINT.........99-050

B003305 PANEL ASM. ENGINE HOOD — TOP COAT REPAIR.......99-050

B003330 PANEL ASM. EN GIN E HOOD — SPOT REP AI R..... ... ........99-050

B004500 PANEL, ROOF — SPOT REPAIR........................................99-050

B004530 PANEL, ROOF — STRIP & REPAINT STATION.................99-050

B004530 PANEL, ROOF — STRIP & REPAINT SEDAN OR..............99-050

B004530 PANEL, ROOF — STRIP & REPAINT — (UTE ONLY).......99-050

B004540 PANEL, ROOF — TOP COAT REPAIR SEDAN OR...........99-050

B004540 PANEL, ROOF — TOP COAT REPAIR — (UTE ONLY).....99-050

B004540 PANEL, ROOF — TOP COAT REPAIR STATION...............99-050

B004550 PANEL, ROOF — TOP COAT REPAIR UTE WITH.............99-050

B012500 PANEL, SIL L OUTE R R H — SPOT REP AI R.......................99-050

B012510 PANEL, SILL OUTER RH — STRIP & REPAINT.................99-050

B012520 PANEL, SIL L OUT ER RH — TOP COAT REPAIR... ... .... ... .99-050

B012600 PANEL, SILL OUTER LH — SPOT REPAIR .......................99-050

B012610 PANEL, SILL OUTER LH — STRIP & REPAINT.................99-050

B012620 PANEL, SILL OUTER LH — TOP COAT REPAIR...............99-050

B014510 FRAME, FRONT DOOR WINDOW RH — STRIP & ............99-050

B014520 FRAME, FRONT DOOR WINDOW RH — TOP COAT........99-050

B014610 FRAME, FRONT DOOR WINDOW LH — STRIP &.............99-050

B014620 FRAME, FRONT DOOR WINDOW LH — TOP COAT.........99-050

B020510 FRAME, REAR DOOR WINDOW RH — STRIP &...............99-050

B020520 FRAME, REAR DOOR WINDOW RH — TOP COAT ..........99-050

B020610 FRAME, REAR DOOR WINDOW LH — STRIP & ...............99-050

B020620 FRAME, REAR DOOR WINDOW LH — TOP COAT...........99-050

B047100 PANEL ASM. BACK LOWER — SPOT REPAIR.................99-050

B047110 PANEL ASM. BACK LOWER — STRIP & REPAINT...........99-050

B047120 PANEL ASM. BACK LOWER — TOP COAT REPAIR.........99-050

B062200 FENDER, PANEL RH — SPOT REPAIR.............................99-050

B062210 FENDER, PANEL RH — STRIP & REPAINT.......................99-050

B062220 FENDER, PANEL RH — TOP COAT REPAIR.....................99-050

B062300 FENDER , PA N E L LH — SPOT REPA IR. ... ... ............ ... ........99-050

B062310 FENDER, PANEL LH — STRIP & REPAINT.......................99-050

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

B062320 FENDER, PANEL LH — TOP COAT REPAIR.....................99-050

B062600 PANEL, VALANCE OR AIR DAM — SPOT REPAIR...........99-050

B062610 PANEL, VALANCE OR AIR DAM — STRIP &.....................99-050

B062620 PANEL, VALANCE OR AIR DAM — TOP COAT.................99-050

B069099 STRIPES (PAI NT ) OR TR A N SF ER/DECA LS — ............ ... ..99-050

B069099 STRIPES (PAI NT ) OR TR A N SF ER/DECA LS — ............ ... ..10-250

B076520 BUMPER BAR, FRONT OR CENTRE OR ENDS —...........99-050

B077520 BUMPER BAR, REAR — TOP COAT REPAIR ...................99-050

B077600 BUMP ER E T TE , RE AR RH — TOP COA T RE PA IR ............99-050

B077620 BUMP ER E T TE , REA R LH — TOP COA T REPA IR.............9 9 -050

B077710 RAIL ASM, BELT OUTER RH — TOP COAT REPAIR........99-050

B077720 RAIL ASM, BELT OUTER LH — TOP COAT REPAIR........99-050

B077730 MOULDING CAP, TAILLAMP RH — TOP COAT................99-050

B077740 MOULDING CAP, TAILLAMP LH — TOP COAT.................99-050

B077750 RAIL ASM, ENDGATE UPPER — TOP COAT....................99-050

B077770 TONNEAU COVE R , (R IGID ) — TOP COA T REPAIR .........9 9 -0 50

B077810 MOULDING CAP, ROOF REAR RH — TOP COAT............99-050

B077820 MOULDING CAP, ROOF REAR LH — TOP COAT.............99-050

B077830 MOULDING CAP, ROOF REAR CENTRE — TOP..............99-050

B078520 GRILLE ASM. (RADIATOR) — TOP COAT REPAIR...........99-050

B081199 DOOR, FUEL TANK FILLER — TOP COAT REPAIR .........99-050

B081200 HANDLE, DOOR OUTSIDE RHF — TOP COAT.................99-050

B081250 HANDLE, DOOR OUTSIDE LHF — TOP COAT .................99-050

B081300 HANDLE, DOOR OUTSIDE RHR — TOP COAT ................99-050

B081350 HANDLE, DOOR OUTSIDE LHR — TOP COAT.................99-050

B081530 RH MIRROR, OUTSIDE REAR VIEW — TOP COAT..........99-050

B081630 LH MIRROR, OUTSIDE REAR VIEW — TOP COAT..........99-050

B092510 WHEEL, ROAD — PAINT....................................................99-050

B100100 PILLAR, REAR BODY RH — TOP COAT REPAIR .............99-050

B100120 PILLAR, REAR BODY RH — STRIP & REPAINT................99-050

B100130 MOULDING, REAR QUARTER PANEL RH — (UTE) .........99-050

B100200 PILLAR, REAR BODY LH — TOP COAT REPAIR..............99-050

B100220 PILLAR, REAR BODY LH — STRIP & REPAINT................99-050

B100230 MOULDING, REAR QUARTER PANEL LH — (UTE)..........99-050

B100300 DOOR OPENING RH FRONT — SPOT REPAIR................99-050

B100310 DOOR OPENING LH FRONT — SPOT REPAIR ................99-050

B100320 DOOR OPENING RH REAR — SPOT REPAIR..................99-050

B100330 DOOR OPENING LH REAR — SPOT REPAIR...................99-050

B100340 ENGINE HOOD OPENING — SPOT REPAIR.....................99-050

B100350 BOOT LID OPENING — SPOT REPAIR .............................99-050

B100360 TAILGATE/HATCH OPENING — SPOT REPAIR ...............99-050

B201060 SPOILER, REAR — TOP COAT REPAIR. ............ ...............99-050

C001000 GLASS ASM. WINDSHIELD REPLACE (LONG..................11-030

C001000 GLASS ASM. WINDSHIELD REPLACE (LONG..................11-025

C001000 GLASS ASM. WINDSHIELD REPLACE (LONG..................11-020

C001010 GLASS ASM. WINDSHIELD REPLACE (SHORT................11-020

C001010 GLASS ASM. WINDSHIELD REPLACE (SHORT................11-025

C001010 GLASS ASM. WINDSHIELD REPLACE (SHORT................11-030

C001100 PAD, FOOT REST — REPLACE.........................................14-475

C001200 GLASS ASM. WINDSHIELD — RESEAL ............................11-030

C001200 GLASS ASM. WINDSHIELD — RESEAL ............................11-025

C001200 GLASS ASM. WINDSHIELD — RESEAL ............................11-020

C002000 GLASS ASM. REAR WINDOW REPLACE (LONG..............11-025

C002000 GLASS ASM. REAR WINDOW REPLACE (LONG..............11-020

C002100 GLASS ASM. REAR WINDOW REPLACE (SHORT............11-025

C002100 GLASS ASM. REAR WINDOW REPLACE (SHORT............11-020

C002500 GLASS ASM. REAR WINDOW — RESEAL ........................11-020

C002500 GLASS ASM. REAR WINDOW — RESEAL ........................11-025

C004100 GLASS ASM. SIDE PA N E L RH — REPL A CE....... ... ...........11-025

C004100 GLASS ASM. SIDE PANEL (C PILLAR FIXED) RH —........11-020

C004110 GLASS ASM. SIDE PANEL RH — RESEAL........................11-025

C004110 GLASS ASM. SIDE PANEL (C PILLAR FIXED) RH —........11-020

C004150 GLASS ASM. QUARTER WINDOW (C PILLAR) RH —......11-030

C004170 GLASS ASM. QUARTER WINDOW (C PILLAR) RH —......11-030

C004200 GLASS ASM. SIDE PANEL (C PILLAR FIXED) LH —.........11-020

C004200 GLASS ASM. SIDE PAN E L LH — REP L AC E..... ............. ... .11-025

C004210 GLASS ASM. SIDE PANEL LH — RESEAL........................11-025

C004210 GLASS ASM. SIDE PANEL (C PILLAR FIXED) LH —.........11-020

C004250 GLASS ASM. QUARTER WINDOW (C PILLAR) LH —.......11-030

C004270 GLASS ASM. QUARTER WINDOW (C PILLAR) LH —.......11-030

C005100 GLAS S ASM. R H FRON T DOOR DROP WI N DOW —........11-020

C005100 GLAS S ASM. R H FRON T DOOR DROP WI N DOW —........11-025

C005100 GLAS S ASM. R H FRON T DOOR DROP WI N DOW —........11-030

C005200 GLASS ASM. LH FRONT DOOR DROP WINDOW — ........11-025

C005200 GLASS ASM. LH FRONT DOOR DROP WINDOW — ........11-030

C005200 GLASS ASM. LH FRONT DOOR DROP WINDOW — ........11-020

C006100 WIN DOW REGU LA T O R, RH FRON T — REPL A C E........ ... .11-675

C006200 WIN DOW REGU LA T O R, LH FRON T — REPL A CE........ ... .11-675

C008240 GUIDE RAIL, LH FRONT DROP WINDOW —.....................11-625

C008260 GUIDE RAIL, RH FRONT DROP WINDOW —....................11-625

C013100 GLASS ASM. RH REAR DOOR DROP WINDOW —..........11-030

C013100 GLASS ASM. RH REAR DOOR DROP WINDOW —..........11-020

C013110 WEA T H ERS TR IP AS M. DROP WIND OW LH........ ... ... .... ....11-6 50

C013130 WIN DOW REGU LA T O R ASM. RH RE A R DOOR/. ... ... .... ... .11-810

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

C013170 GUIDE RAIL ASM. REAR DROP WINDOW RH — .............11-750

C013200 GLASS ASM. LH REA R DOOR DRO P WIN DOW —...........11 -0 20

C013200 GLASS ASM. LH REA R DOOR DRO P WIN DOW —...........11 -0 30

C013210 WEATHERSTRIP ASM. DROP WINDOW RH.....................11-650

C013230 WINDOW REGULA T OR AS M. LH REA R DOOR /............. ..11-810

C013270 GUIDE RAIL ASM. REAR DROP WINDOW LH —..............11-750

C017100 GLASS/WEATHERSTRIP ASM. DOOR FIXED WIN—.......11-020

C017100 GLAS S ASM. RE A R DOOR FIXED WINDO W RH —........ ..11-030

C017200 GLAS S ASM. RE A R DOOR FIXED WINDO W LH — . .... .....11-0 30

C017200 GLASS/WEATHERSTRIP ASM. DOOR FIXED WIN—.......11-020

C020000 GLASS ASM. TA IL GA TE — REPL ACE (AWD ............... ... ..11-030

C020000 GLAS S ASM. TA IL GA TE /H A T CH — REPL AC E............. ... ..11-030

C020010 GLAS S ASM. TA IL GA TE /H A T CH — REPL AC E............. ... ..11-030

C020100 CATCH, TAILGATE WINDOW (AWD) — REPLACE...........11-030

C020200 SOLENOID, TAILGATE WINDOW RELEASE (AWD).........11-030

C020500 GLASS ASM. TAILGATE/HATCH — RESEAL....................11-030

C021200 GLASS, CANOPY TAILGATE (HBD CANOPY....................11-025

C021250 GLASS, CANOPY QUARTER RIGHT HAND (HBD.............11-025

C021300 GLASS, CANOPY QUARTER LEFT HAND (HBD...............11-025

C105100 WEATHERSTRIP ASM. RH FRONT DOOR —...................11-600

C105200 WEATHERSTRIP ASM. LH FRONT DOOR —....................11-600

C106700 WEATHERSTRIP ASM. ROCKER PANEL RH —...............11-600

C106800 WEATHERSTRIP ASM. ROCKER PANEL LH —................11-600

C107700 WEAT HERSTRIP, HOOD — REPL AC E......... ... ............. ... ..12-050

C110100 WEATHERSTRIP ASM. RH REAR DOOR —......................11-600

C110200 WEATHERSTRIP ASM. LH REAR DOOR —......................11-600

C117100 WEATHERSTRIP ASM. GLASS SIDE PANEL (C...............11-020

C117200 WEATHERSTRIP ASM. GLASS SIDE PANEL (C...............11-020

C118300 WEATHERSTRIP ASM. RH FRT DOOR FRAME —...........11-650

C118400 WEATHERSTRIP ASM. LH FRT DOOR FRAME —............11-650

C118500 WEATHERSTRIP ASM. RH REAR DOOR FRAME —........11-775

C118600 WEATHERSTRIP ASM. LH REAR DOOR FRAME —.........11-775

C118700 MOULDING ASM. LH WINDOW CHANNEL INNER —.......11-775

C118800 MOULDING ASM. RH WINDOW CHANNEL INNER — ......11-775

C118900 MOULDI NG AS M. WIN DOW CH A N NE L INNE R RH...........11-775

C119000 MOULDI NG AS M. WIN DOW CH A N NE L INNE R LH.......... ..11-775

C125500 WEATHERSTRIP, DECK LID — REPLACE........................11-600

C126000 WEAT HE R S TR IP , TA IL GA TE /H A TCH — REPLACE..... ... ..11-600

C127100 MOULDI NG AS M. IN NE R CH A NN E L RH —........ ............. ..11-650

C127200 MOULDI NG AS M. IN NE R CH A NN E L LH —...................... ..11-650

C127300 MOULDING ASM. DOOR FRAME INNER RH —................11-650

C127400 MOULDING ASM. DOOR FRAME INNER LH —.................11-650

C127500 WEA T H ERS TR IP AS M. RH REA R DROP WIND OW..........11-775

C127600 WEA T H ERS TR IP AS M. LH REA R DROP WIND OW.......... .11-775

C127700 MOU L D ING A SM. REA R DOOR FR A ME IN N ER RH..........11-775

C127800 MOU L D ING A SM. REA R DOOR FR A ME IN N ER LH ..........11-775

C212000 GRILL, REAR SHELF SPEAKER RH — REPLACE............14-460

C212100 GRILL, REAR SHELF SPEAKER LH — REPLACE.............14-460

C248500 DRAIN HOSE, SUN ROOF FRONT — REPLACE...............AA-000

C249100 DRAIN HOSE, SUN ROOF REAR — REPLACE.................AA-000

C315500 MIRROR ASM. COMPLETE (INTERIOR REAR..................09-540

C315500 MIRROR ASM. COMPLETE (INTERIOR REAR..................14-025

C315510 MIRROR RETAINING PLATE (INTERIOR REAR................14-025

C317000 HANDLE, ASSIST GRIP (ANY ONE) — REPLACE.............14-100

C332100 HA N D LE. FR ON T WIN DOW REGU LA T O R (1 OR 2)...... ... .11-675

C332200 HANDLE. REAR WINDOW REGULATOR (1 OR 2) —........11-810

C334000 REMOT E CON T ROL. BOT H R EAR DOOR —................... .11-725

C334100 REMOTE CONTROL. LH REAR DOOR — REPLACE........11-725

C334200 REMOTE CONTROL. RH REAR DOOR — REPLACE .......11-725

C400100 HEADLINING, ROOF — REPLACE.....................................14-150

C400200 INSULATION HEADLINING, ROOF — REPLACE..............14-150

C402100 SUNVISOR & PIVOT ASM. RH — REPLACE .....................14-050

C402200 SUNVISOR & PIVOT ASM. LH — REPLACE......................14-050

C402300 HOL D ER , GARA GE DOOR/S U NG LA S S —................ ........14-050

C406100 TRIM ASM. RH FRONT DOOR — R&R/REPLACE.............14-220

C406150 HANDLE/ARMREST, RH FRONT DOOR (INTE—..............14-220

C406200 TR IM AS M. LH FRONT DOOR — R&R/ RE P L AC E ............ .14-220

C406250 HANDLE/ARMREST, LH FRONT DOOR (INTE—...............14-220

C406700 DEFLECTOR, WATER RH FRONT DOOR —.....................14-220

C406800 DEFLECTOR, WATER LH FRONT DOOR —......................14-220

C407100 INSERT, FRONT DOOR TRIM RH — REPLACE................14-220

C407200 INSERT, FRONT DOOR TRIM LH — REPLACE.................14-220

C407300 POCKET, MAP FRONT DOOR TRIM RH —.......................14-220

C407400 POCKET, MAP FRONT DOOR TRIM LH —........................14-220

C407700 INSERT, REAR DOOR TRIM RH — REPLACE..................14-270

C407800 INSERT, REAR DOOR TRIM LH — REPLACE...................14-270

C410310 TRIM, "C" PILLAR RH — REPLACE....................................14-120

C410310 TRIM, "C" PILLAR UPPER RH — REPLACE......................14-130

C410320 TRIM, "C" PILLAR LOWER RH — REPLACE......................14-120

C410320 TRIM, "C" PILLAR LOWER RH — REPLACE......................14-130

C410350 ARMREST, "C" PILLAR LOWER RH — R&R/.....................14-120

C410400 ARMREST, "C" PILLAR LOWER LH — R&R/......................14-120

C410410 TRIM, "C" PILLAR UPPER LH — REPLACE......... ..............14-130

C410410 TRIM, "C" PILLAR LH — REPLACE....................................14-120

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

C410420 TRIM, "C" PILLAR LOWER LH — REPLACE......................14-120

C410420 TRIM, "C" PILLAR LOWER LH — REPLACE......................14-130

C411150 TRIM, "B" PILLAR CENTRE RH — REPLACE....................14-100

C411250 TRIM, "B" PILLAR CENTRE LH — REPLACE.....................14-100

C414100 TRIM ASM. RH REAR DOOR — R&R/REPLACE...............14-270

C414150 HANDLE/ARMREST, RH REAR DOOR (INTERIOR)..........14-270

C414200 TRIM ASM. LH REAR DOOR — R&R/REPLACE................14-270

C414250 HANDLE/ARMREST, LH REAR DOOR (INTERIOR) ..........14-270

C417100 DEFLEC TOR , WAT E R RH REA R DOOR —........ ... ... .... ... ..14-270

C417200 DEFLECTOR, WATER LH REAR DOOR —........................14-270

C421100 TRIM, FRON T RE A R QUART E R RH — REP L AC E.......... ..14-270

C421100 TRIM, FRON T RE A R QUART E R RH — REP L AC E.......... ..14-120

C421100 TRIM, FRON T RE A R QUART E R RH — REP L AC E.......... ..14-130

C421200 TRIM, FRON T RE A R QUART E R LH — REP L AC E.............14 -2 70

C421200 TRIM, FRON T RE A R QUART E R LH — REP L AC E.............14 -1 20

C421200 TRIM, FRON T RE A R QUART E R LH — REP L AC E.............14 -1 30

C427100 SHELF ASM. BACK PANEL UPPER — REPLACE.............14-460

C427300 TRIM ASM. SEAT BACK PANEL — REPLACE (UTE/........14-460

C427350 TRIM ASM. REAR HEADREST MOUNT — REPL ACE.......14-460

C431300 CARPET, REAR SEAT BACK — REPLACE .......................14-480

C431600 CARPET/TRIM ASM. REAR END PANEL — ......................14-480

C432600 CARPET & INSULATOR ASM. REAR COMPART—...........14-490

C432600 CARP ET /I NS U LATOR ASM. REAR COMPA R T—............ ..14-480

C432650 MAT ASM. REAR COMPARTMENT FLOOR —..................14-490

C432650 MAT ASM. REAR COMPARTMENT FLOOR —..................14-480

C432660 RAIL, CARGO LUGGAGE — RE PL AC E BOT H............. ... ..14-490

C432670 RAIL, CARGO LUGGAGE R H — REPLA CE..... ... ... ... .........14-4 90

C432680 RAIL, CARGO LUGGAGE LH — REPL A CE........................1 4 -4 90

C432700 CARPET, DECK LID LINER — REPLACE ..........................14-480

C434100 TRIM/CARPET ASM. REAR COMPARTMENT...................14-490

C434100 TRIM/CARPET ASM. REAR COMPARTMENT...................14-480

C434200 TRIM/CARPET ASM. REAR COMPARTMENT...................14-480

C434200 TRIM/CARPET ASM. REAR COMPARTMENT...................14-490

C435300 DOOR, SIDE STOWAGE, REAR COMPARTMENT............14-490

C435300 DOOR, SIDE STOWAGE REAR COMPARTMENT.............14-480

C435400 DOOR, SIDE STOWAGE, REAR COMPARTMENT............14-490

C435500 VENT, REAR SIDE PANEL RH — REPLACE.....................14-490

C435600 VENT, REAR SIDE PANEL LH — REPLACE......................14-490

C436100 PANE L ASM. TA IL GA TE /H A TC H — R&R /R EPLACE.........14 -5 00

C436150 TRIM ASM. UPPER TAILGATE (ONE PIECE/ALL) —........14-500

C436200 TRIM ASM. UPPER TAILGATE RH — R&R/.......................14-500

C436250 TRIM ASM. UPPER TAILGATE LH — R&R/REPLACE.......14-500

C436300 TR IM AS M. TA ILGA TE LOWER — R&R/ RE P LA C E............14-5 00

C436350 TR IM AS M. ST OP LAMP — REPL AC E........... ... ................ .14-500

C440100 FINISH STRIP, HEADLINING FRONT — REPLACE...........14-150

C449100 CARPET ASM. FRONT FLOOR — REPLACE....................14-475

C449200 CARPET/INSULATOR ASM. FLOOR — REPLACE 1.........14-475

C451100 BELT ASM. RET R AC T O R RH FR ON T SE A T —............. ... .14-400

C451140 SEAT BELT STALK & TENSIONER RH — REPLACE........14-400

C451200 BELT ASM. RETRACTOR LH FRONT SEAT —..................14-400

C451240 SEAT BELT STALK & TENSIONER LH — REPLACE.........14-400

C452100 BELT ASM. RET R AC T O R RH RE A R SEA T — .. ... ............. .14-425

C452200 BELT ASM. RET R AC T O R LH REAR SEAT —...... ... ... ........14-425

C452400 BUCKLE ASM. RH REAR SEAT BELT — REPLACE..........14-425

C452500 BELT ASM. CEN T RE RE T RA C T OR/B U C KL E —..... ...........14-425

C452600 BUCKLE ASM. LH REAR SEAT BELT — REPLACE..........14-425

C452700 ESCUTCHEON, REAR SIDE SEAT BELT —......................14-425

C453400 DETECTION PAD, SEAT OCCUPANCY DRIVERS —........14-295

C453500 DETECTION PAD, SEAT OCCUPANCY PASSEN—..........14-295

C454700 AIRBAG UNIT, CURTAIN — REPLACE BOTH...................06-225

C454710 AIRBAG UNIT, CURTAIN — REPLACE LEFT HAND.........06-225

C454720 AIRBAG UNIT, CURTAI N — REPLACE RIGHT HAND.......06-225

C455100 BOLT, SEAT BELT ANCHOR — REPLACE........................14-425

C455100 BOLT, SEAT BELT ANCHOR — REPLACE........................14-400

C455700 HEIGHT ADJUSTER, RH FRONT SEAT BELT —...............14-400

C455750 HEIGHT ADJUSTER, LH FRONT SEAT BELT —...............14-400

C456000 CABLE, DECK LID RELEASE — REPLACE.......................12-680

C456100 TRIM, COWL SIDE LOWER RH — R&R/REPLACE...........14-100

C456200 TRIM, COWL SIDE LOWER LH — R&R/REPLACE............14-100

C456700 COVER ASM. INSTRUMENT LOWER RH —......................09-200

C456800 TRIM ASM. INST PAN EL LOWER LH — REPLAC E... .... ....09-140

C457100 COMP A RTM E NT /A S HTR A Y A SM. FRON T —...... ... ... .... ....09-300

C457100 COMP A RTM E NT /A S HTR A Y A SM. FRON T —...... ... ... .... ....14-900

C457200 COMP A RTM E NT /A S HTR A Y A SM. REAR —........... ... ........14-900

C457300 CUP HOLDER — REPLACE................................................14-900

C457400 CUP HOLDER, CENTRE FASCIA (ONE/BOTH)—..............09-125

C457500 COMPARTMENT ASSEMBLY FRONT FLOOR..................14-900

C459100 GLOVE BOX ASM. INSTRUMENT PANEL —.....................09-140

C459700 CYLINDER ASM. GLOVE BOX — REPLACE .....................09-140

C459800 LEVER ASM. FILLER DOOR RELEASE —.........................03-028

C459810 LEVER ASM. DECK LID & FILLER DOOR..........................03-028

C459900 CABLE, FILLER DOOR RELEASE — REPLACE................03-028

C461100 PAD ASM. INSTRUMENT PANEL — REPLACE.................09-125

C461120 FASCIA ASM. RADIO/HEATER CONTROL SUR—............09-300

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

C461200 COVER INSTRUMENT PANEL END RH —........................09-135

C461300 COVER INSTRUMENT PANEL END LH — REPLACE.......09-135

C461400 EXTENS ION , IN ST R UME N T P ANE L E ND —... ............. ... ..09-135

C461500 FASCIA ASM. LOWER INSTRUMENT PAD CEN— ...........09-300

C461520 FASCIA ASM. LOWER INSTRUMENT PAD CEN— ...........09-300

C461540 FASCIA ASM. LOWER INSTRUMENT PAD CEN— ...........09-300

C461600 DOOR ASM, PASSENGER AIR BAG — REPLACE............09-125

C461700 NAMEPLATE, INSTRUMENT PAD LH — REPLACE..........09-125

C461800 PANE L AS M, IN ST R UME N T P ANEL UPPER CEN —....... ..09-125

C461810 PANE L AS M, IN ST R UME N T P ANEL CENTRE —..............09 -1 25

C462100 FASCIA, INSTRUMENT CLUSTER SURROUND —...........09-100

C464100 TRIM ASM. INST PANEL LOWER RH — REPLACE..........09-140

C474000 HOUSING, CONSOLE ASM — REPLACE..........................14-900

C474100 CAP, CONSOLE — REPLACE (M/T)...................................14-900

C474200 CAP, CONSOLE — REPLACE (AUTO)...............................14-900

C474210 SUPPORT ASM. TRANSMISSION CONTROL INDI—........04-190

C474300 LINER ASM. (ONE OR ALL) — REPLACE..........................14-900

C474300 LINER ASM. — REPLACE...................................................09-300

C474400 ARMREST ASM. TRANSMISSION CONSOLE —...............14-900

C474500 EXTENSION, CONSOLE SIDE (RH) — REPLACE.............14-900

C474600 EXTENSION, CONSOLE SIDE (LH) — REPLACE .............14-900

C474700 COVER ASM. COMPL ETE PARK BRA KE LEV ER —.........04-675

C500500 FASCIA, DVD PLAYER — REPLACE .................................09-515

C500700 FASCI A , DV D SC R E EN RH — REPL AC E ........... ............. ..09-515

C500800 FASCI A , DV D SC R E EN LH — REP L AC E.................. .... .....09 -5 15

C502100 ROD, ADJUSTER ASM RH SEAT — REPLACE.................14-275

C502150 ROD, ADJUSTER ASM LH SEAT — REPLACE .................14-275

C502600 FRAM E ASM. FR ONT SEAT CUSH ION RH —................. ..14-275

C502610 FRAM E ASM. FR ON T SE A T B ACK LH — REPLACE.........14-275

C502700 FRAM E ASM. FR ONT SEAT CUSH ION LH —....................14 -2 75

C502710 FRAME ASM. FRONT SEAT BACK RH — REPLACE........14-275

C502750 LUMBAR SUPPORT RH — REPLACE................................14-275

C502800 CUSHION, FRONT SEAT EXTENSION RH —....................14-295

C502810 FRAM E AS M. FR ON T SE A T B AC K LH ELE C —....... .........14 -2 75

C502850 MOTOR, SEAT BACK RH — REPLACE .............................14-275

C502860 MOTOR, SEAT BACK LH — REPLACE..............................14-275

C502900 CUSHION, FRONT SEAT EXTENSION LH —....................14-295

C502910 FRAM E AS M. FR ON T SE A T B AC K RH ELE C — ...............14-275

C502920 WHEEL/LEVER, LUMBAR SUPPORT — REPLACE..........14-275

C502950 MOTOR, SEAT HE IGH T ADJ U ST E R R H — .. ... ............. ... ..14-275

C502960 MOTOR, SEAT HEIGHT ADJUSTER LH —........................14-275

C502970 MOTOR, SEAT HEIGHT ADJUSTER CENTRE —..............14-275

C503400 COVER, RH FRT SEAT INNER RAIL REAR —...................14-322

C503450 COVER, RH FRT SEAT INNER RAIL FRONT —................14-322

C503500 COVER, LH FRT SEAT INNER RAIL REAR —...................14-322

C503550 COVER, LH FRT SEAT INNER RAIL FRONT —.................14-322

C503600 COVER, RH FRT SEAT OUTER RAIL REAR —.................14-322

C503650 COVER, RH FRT SEAT OUTER RAIL FRONT —...............14-322

C503700 COVER, LH FRT SEAT OUTER RAIL REAR —..................14-322

C503750 COVER, LH FRT SEAT OUTER RAIL FRONT —...............14-322

C503800 COVER, RH FRT SEAT SIDE OUTER — REPLACE..........14-322

C503900 COVER, LH FRT SEAT SIDE OUTER — REPLACE...........14-322

C504000 COVER, RH FRONT SEAT BACK — REPLACE.................14-322

C504100 COVER, LH FRONT SEAT BACK — REPLACE .................14-322

C504200 MAP POCKET, RH FRT SEAT BACK — REPLACE...........14-322

C504300 MAP POCKET, LH FRT SEAT BACK — REPLACE............14-322

C505100 RESTRAINT ASM. RH FRT SEAT BACK HEAD —.............14-295

C505150 TRIM, FRONT SEAT HEAD RESTRAINT RH —.................14-295

C505200 RESTRAINT ASM. LH FRT SEAT BACK HEAD —.............14-295

C505210 CLIP/GUIDE SLEEVE, HEAD RESTRAINT FRT.................14-275

C505230 CLIP/GUIDE SLEEVE, HEAD RESTRAINT REAR..............14-350

C505250 TRIM, FRONT SEAT HEAD RESTRAINT LH —..................14-295

C506800 LUMBAR SUPPORT LH — REPLACE................................14-275

C520140 COVER, SEAT BELT TENSIONER RH — REPLACE.........14-322

C520240 COVER, SEAT BELT TENSIONER LH — REPLACE..........14-322

C521210 TRACK/HEIGHT ADJUSTER ASM. LH FRT SEAT —.........14-275

C521220 TRACK/HEIGHT ADJUSTER ASM. RH FRT SEAT —........14-275

C534500 ADJUST E R WHE E L , FR T SE A T RE C L IN ER —.............. ... .14-275

C550000 SEAT ASM. FRONT BUCKET PASSENGER — R&R/........14-295

C551000 SEAT ASM. FRONT BUCKET DRIVERíS — R&R/.............14-295

C552000 PAD ASM. FRONT SEAT CUSHION DRIVERíS —.............14-295

C552100 TRIM, FRONT SEAT CUSHION DRIVERíS —....................14-295

C552200 PAD ASM. FRONT SEAT BACK DRIVERíS — ...................14-295

C553000 PAD ASM. FRONT SEAT CUSHION PASSENGER —.......14-295

C553100 TRIM, FRONT SEAT CUSHION PASSENGER —...............14-295

C553200 PAD ASM. FRONT SEAT BACK PASSENGER —..............14-295

C555100 TRIM ASM. SEAT BAC K DR IV ERíS — REPLACE ............. .14-295

C555200 TR IM AS M. SE A T BAC K PASS E N GER — REP L AC E........14-295

C559720 FRAME, FRONT SEAT EXTENSION RH —........................14-295

C559820 FRAME, FRONT SEAT EXTENSION LH — REPLACE.......14-295

C570100 TRIM ASM. REAR SEAT CUSHION — REPLACE..............14-330

C570300 PAD ASM. REAR SEAT CUSHION — REPLACE...............14-330

C572100 PAD ASM. REAR SEAT BACK (COMPLETE/BOTH...........14-350

C572210 TRIM ASM. REAR SEAT BACK (COMPLETE/BOTH..........14-350

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

C572210 TRIM ASM. REAR SEAT BACK (COMPLETE/BOTH..........14-325

C572300 HINGE ASM. SEAT HATCH RH — REPLACE....................14-350

C572400 HINGE ASM. SEAT HATCH LH — REPLACE.....................14-350

C572500 TRIM, REAR SEAT BACK ARMREST — REPLACE...........14-325

C572600 ARMREST/HATCH ASM. REAR SEAT CENTRE —...........14-350

C572800 TRIM, ARMREST ASM. — REPLACE.................................14-350

C572900 PANEL, REAR SEAT BACK SUPPORT — REPLACE........14-350

C573020 FRAM E AS M. RE A R SEAT BA CK (C OMP L ET E /.... ... .........14 -350

C576100 RESTRAINT ASM. REAR SEAT BACK HEAD RH — .........14-350

C576200 RESTRAINT ASM. REAR SEAT BACK HEAD LH —..........14-350

C576300 RESTRAINT ASM. REAR SEAT BACK HEAD CEN—........14-350

C582100 TRIM ASM. REAR SEAT BACK RH — REPLACE..............14-325

C582200 TRIM ASM. REAR SEAT BACK LH — REPLACE...............14-325

C584100 KNOB, REAR SEAT BACK OR HATCH LOCK RH —.........14-350

C584200 KNOB, REAR SEAT BACK OR HATCH LOCK LH/.............14-350

C613000 PLATE ASM. ENDGATE LOCK BASE — REPLACE..........12-685

C613100 HANDLE ASM. ENDGATE REMOTE CONTROL —...........12-685

C613200 LATCH ASM. ENDGATE LOCK RH — REPLACE..............12-685

C613250 LATCH ASM. ENDGATE LOCK LH — REPLACE...............12-685

C613300 BRACKET & GUIDE ASM. ENDGATE LOCK......................12-685

C613350 BRACKET & GUIDE ASM. ENDGATE LOCK......................12-685

C613400 CABLE & LINK ASM. ENDGATE — REPLACE BOTH........12-685

C613425 CABLE & LINK ASM. ENDGATE RH — REPLACE.............12-685

C613450 CABLE & LINK ASM. ENDGATE LH — REPLACE.............12-685

C613500 STRIKER ASM. ENDGATE RH — REPLACE.....................12-685

C613550 STRIKER ASM. ENDGATE LH — REPLACE......................12-685

C613600 PLATE ASM. ENDGATE RH — REPLACE .........................12-685

C613650 PLATE ASM. ENDGATE LH — REPLACE..........................12-685

C613700 HINGE ASM. ENDGATE RH — REPLACE .........................12-685

C613750 HINGE ASM. ENDGATE LH — REPLACE..........................12-685

C614000 RAIL ASM. RH BELT OUTER — REPLACE........................12-480

C614100 RAIL ASM. LH BELT OUTER — REPLACE........................12-480

C614200 RAIL ASM. ENDGATE UPPER — REPLACE......................12-480

C614300 CAP, RH TAIL LAMP — REPLACE.....................................12-480

C614400 CAP, LH TAIL LAMP — REPLACE......................................12-480

C620700 REMOTE CONTROL ASM. FRONT DOOR —....................11-360

C620800 REMOTE CONTROL ASM. RH FRONT DOOR —..............11-360

C620900 REMOTE CONTROL ASM. LH FRONT DOOR — ..............11-360

C621100 HANDLE ASM. DOOR OUTER RH FRONT —....................11-360

C621200 HANDLE ASM. DOOR OUTER LH FRONT —....................11-360

C621300 BRACKET, OUTER DOOR HANDLE RH FRONT — ..........11-360

C621400 BRACKET, OUTER DOOR HANDLE LH FRONT —...........11-360

C621600 COVER, INNE R R OC K E R PA N E L RH — REPL A CE..........14-100

C621700 COVER, INNER ROCKER PANEL LH — REPLACE...........14-100

C621800 INSERT, INNER ROCKER PANEL RH FRONT —..............14-100

C621850 INSERT, INNER ROCKER PANEL RH REAR — ................14-100

C621900 INSERT, INNER ROCKER PANEL LH FRONT —...............14-100

C621950 INSERT, INNER ROCKER PANEL LH REAR —.................14-100

C622000 LOCK ASM. RH FRONT DOOR — REPLACE ....................11-360

C622100 CYLINDER ASM. DOOR LOCKING RH — REPLACE........11-360

C622200 TRIM, "B" PILLAR UPPER RH — REPLACE.......................14-100

C622250 TRIM, "B" PILLAR UPPER LH — REPLACE.......................14-100

C622300 ROD, FRONT DOOR LOCKING (INSIDE) LH —.................11-360

C622330 ROD, FRONT DOOR LOCKING (INSIDE) RH —................11-360

C622350 ROD, DOOR LOCK CYLINDER TO DOOR LOCK ..............11-360

C622400 ES C U TCH E ON , D OOR LOC KI NG BU T TON (1 OR........ ....11-7 25

C622400 ES C U TCH E ON , D OOR LOC KI NG BUT TON (1/AL L )..........11-360

C622500 ROD, HANDLE OUTER DOOR LH FRONT —....................11-360

C622600 ROD, HANDLE OUTER DOOR RH FRONT —....................11-360

C622700 ROD, REMOTE CONTROL LH FRONT — REPLACE........11-360

C622800 ROD, REMOTE CONTROL RH FRONT — REPLACE........11-360

C622900 BUTTON ASM. LOCKING DOOR (1/ALL) —.......................11-360

C622900 BUTTON ASM. LOCKING DOOR (1 OR ALL) —................11-725

C623000 LOCK ASM. LH FRONT DOOR — REPLACE.....................11-360

C623200 ROD, DOOR LOCKING REAR LH — REPLACE.................11-725

C623300 ROD, DOOR LOCKING REAR RH — REPLACE................11-725

C623400 TRIM, "A" PILLAR ONE PIECE/UPPER RH —....................14-100

C623450 TRIM, "A" PILLAR ONE PIECE/UPPER LH — ....................14-100

C623500 TRIM, "B" PILLAR LOWER RH — REPLACE......................14-100

C623550 TRIM, "B" PILLAR LOWER LH — REPLACE......................14-100

C623600 COVER, REAR CROSSOVER — REPLACE.......................14-130

C623600 COVER, REAR CROSSOVER — REPLACE.......................14-120

C623800 FINISH STRIP, HEADLINING REAR — REPLACE.............14-130

C623800 FINISH STRIP, HEADLINING REAR — REPLACE.............14-120

C624100 STRIKER PLATE ASM. RH FRONT DOOR —....................11-360

C624200 STRIKER PL A T E AS M. LH FRONT DOOR —....... ............. .11-360

C624300 TRIM, "D" PILLAR RH — REPLACE....................................14-130

C624350 TRIM, "D" PILLAR LH — REPLACE....................................14-130

C624400 TRIM, REAR SIDE PANEL RH — REPLACE......................14-130

C624450 TRIM, REAR SIDE PANEL LH — REPLACE.......................14-130

C624500 ROD, REMOTE CONTROL ASM RH REAR DOOR —.......11-725

C624600 ROD, REMOTE CONTROL ASM LH REAR DOOR —........11-725

C624700 ROD, DOOR LOCK CONNECTING RH REAR....................11-725

C624800 ROD, DOOR LOCK CONNECTING LH REAR....................11-725

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

C625100 HINGE, FRONT DOOR UPPER RH/LH — REPLACE........11-370

C625150 HINGE, FRONT PILLAR (A) UPPER RH/LH —...................11-370

C625200 HINGE, FRONT DOOR LOWER RH/LH — REPLACE........11-370

C625250 HINGE, FR ON T PILLAR (A) LOWER R H/ LH —..................11-370

C634000 BOLT/PIN CHECK ASM. ALL FOUR DOORS — ................11-370

C634000 BOLT/PIN CHECK ASM. ALL FOUR DOORS — ................11-730

C634050 BOLT/PIN CHECK ASM. BOTH FRONT DOORS —...........11-370

C634100 CHECK ASM. RH FRONT DOOR — REPLACE .................11-370

C634150 BOLT/PIN CHECK ASM. RH FRONT DOOR —..................11-370

C634200 CHECK ASM. LH FRONT DOOR — REPLACE..................11-370

C634250 BOLT/PIN CHECK ASM. LH FRONT DOOR — ..................11-370

C636050 BOLT/PIN CHECK ASM. BOTH REAR DOORS —.............11-730

C636100 CHECK LINK/SPRING, RH REAR DOOR —.......................11-730

C636150 BOLT/PIN CHECK ASM. RH REAR DOOR —....................11-730

C636200 CHECK LINK/SPRING, LH REAR DOOR —.......................11-730

C636250 BOLT/PIN CHECK ASM. LH REAR DOOR —.....................11-730

C640100 HANDLE ASM. DOOR OUTER RH REAR —......................11-725

C640200 HANDLE ASM. DOOR OUTER LH REAR —.......................11-725

C641000 LOCK ASM. LH REAR DOOR — REPLACE.......................11-725

C641200 ROD, HANDLE OUTER LH REAR DOOR — ......................11-725

C641300 ROD, HANDLE OUTER RH REAR DOOR —......................11-725

C642000 LOCK ASM. RH REAR DOOR — REPLACE.......................11-725

C643100 STRIKER PLATE ASM. RH REAR DOOR —......................11-725

C643200 STRIKER PLATE ASM. LH REAR DOOR —.......................11-725

C644100 HINGE, REAR DOOR UPPER RH/LH — REPLACE...........11-730

C644150 HINGE, CENTRE PILLAR (B) UPPER RH/LH — ................11-730

C644200 HINGE, REAR DOOR LOWER RH/LH — REPLACE..........11-730

C644250 HINGE, CE N T RE PIL L AR (B ) LOWER RH/LH —.............. ..11-730

C701100 HINGE, TAILGATE/HATCH RH — REPLACE.....................12-500

C701200 HINGE, TAILGATE/HATCH LH — REPLACE .....................12-500

C701300 HINGE ASM. DECK LID RH — REPLACE..........................12-660

C701400 HINGE ASM. DECK LID LH — REPLACE...........................12-660

C733500 CYLINDER ASM. DECK LID/TAILGATE/HATCH................12-680

C734500 HANDLE ASM. TAILGATE — REPLACE ............................02-385

C752000 LATCH ASM. DECK LID/TAILGATE/HATCH —..................12-680

C753100 SHACKLE ASM. DECK LID/TAILGATE/HATCH —.............12-680

C754400 NET, LUGGAGE RETENTION — REPLACE ......................14-480

C756000 STRUT ASM. TAILGATE/HATCH BOTH — REPLACE.......12-500

C756000 STRUT ASM. DECKLID BOTH — REPLACE......................12-660

C756000 STRUT , RI GID TO NN EA U COV E R — REPL A C E.......... ... ..AA-025

C756100 STRUT ASM. TAILGATE/HATCH RH — REPLACE ...........12-500

C756100 STRUT ASM. DECKLID RH — REPLACE...........................12-660

C756100 STRUT, RIGID TONNEAU COVER RH — REPLACE.........AA-025

C756200 STRUT ASM. DE C K LID LH — REPLACE . ... ............ ... ........12-660

C756200 STRUT, RIGID TONNEAU COVER LH — REPLACE .........AA-025

C756200 STRUT ASM. TAILGATE/HATCH LH — REPLACE............12-500

C820500 MOULDING, WINDSHIELD, COMPLETE/UPPER —..........11-030

C820500 MOULDING, WINDSHIELD COMPLETE/UPPER —...........11-025

C820500 MOULDING, WINDSHIELD COMPLETE/UPPER —...........11-020

C825100 MOULDING ASM. RH ROOF FINISHER — REPLACE.......10-265

C825100 MOULDING ASM. ROOF FINISHER RH — REPLACE.......10-250

C825200 MOULDING ASM. ROOF FINISHER LH — REPLACE.......10-250

C825200 MOULDING ASM. LH ROOF FINISHER — REPLACE.......10-265

C826000 MOULDING, FRT/RR DOOR FRAME OPENING RH..........10-250

C827000 MOULDING, FRT/RR DOOR FRAME OPENING LH...........10-250

C828000 MOULDING ASM. ROOF RACK RUNNER RH ....................10-250

C828500 MOULDING ASM. ROOF RACK RUNNER BOTH...............10-250

C829000 MOULDING ASM. ROOF RACK RUNNER LH....................10-250

C830100 MOUL D IN G ASM. RH FR ON T DOOR SIDE —........... .... ... .10-250

C830200 MOULDING ASM. LH FRONT DOOR SIDE —....................10-250

C832100 MOULDING ASM. RH FRT DOOR BELT REVEAL.............11-650

C832200 MOULDING ASM. LH FRT DOOR BELT REVEAL..............11-650

C836100 MOU L D ING A SM. LH REA R OUT E R WINDO W..................11-775

C836200 MOU L D ING ASM. R H REA R OUTER WIND OW.................11-775

C838100 MOULDING ASM. RH REAR DOOR SIDE —......................10-250

C838200 MOULDING ASM. LH REAR DOOR SIDE —......................10-250

C838300 MOULDING. LH DOOR/QUARTER TO WHEEL..................10-250

C838400 MOULDING. RH DOOR/QUARTER TO WHEEL.................10-250

C842100 MOU L D ING ASM. R H GLA S S QUA RTE R WIND OW..........10-250

C842200 MOU L D ING A SM. LH GLA SS QU A R TER WIND OW.......... .10-250

C847000 MOU L D ING/ FL A R E ASM. WHE E L ARCH —......................10-250

C847000 MOU L D ING/ FL A R E ASM. WHE E L ARCH —......................10-265

C847005 FLARE ASM. WHEEL ARCH — REPLACE ALL (AWD.......10-250

C847100 MOULDING/ FL A R E ASM. RH RE A R WHEE L ARCH..........10-250

C847100 MOULDING/ FL A R E ASM. RH RE A R WHEE L ARCH..........10-265

C847105 FLARE ASM. RH REA R WHEE L ARCH — REP LAC E....... .10-250

C847200 MOULDING/ FL A R E ASM. LH RE A R WHEE L ARCH ......... .10-250

C847200 MOULDING/ FL A R E ASM. LH RE A R WHEE L ARCH ......... .10-265

C847205 FL A RE AS M. LH REA R WHE E L ARC H — REPLAC E .... ... .10-250

C847300 APPLIQUE, QUARTER WINDOW REAR (R/H)...................10-250

C847400 APPLIQUE, QUARTER WINDOW REAR (L/H)...................10-250

C847500 MOULDING. REAR COMPARTMENT LID COVER.............10-250

C860300 MOULDING LOCATOR KIT, REAR WINDOW.....................11-020

C860400 MOULDING LOCATOR KIT, REAR WINDOW.....................11-020

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

C860500 MOULDING ASM. REAR WINDOW LOWER —..................11-020

C860500 MOULDING ASM. REAR WINDOW LOWER —..................11-025

C860600 MOULDING ASM. REAR WINDOW UPPER —...................11-020

C868000 MOULDI NG, TAILGATE/HA T C H GLA S S —...................... ..11-030

C868100 MOULDING ASM. REAR WINDOW COMPLETE —...........11-020

C870900 EMBLEM/N A M EPL A TE , R EAR PA NEL /B OOT LID/............10-150

C881500 EMBLEM ASM. HOOD — REPLACE ..................................10-150

C882100 PLATE, RH SIDE FRONT FENDER/DOOR NAME —.........10-150

C882200 PLATE, LH SIDE FRONT FENDER/DOOR NAME —.........10-150

C883100 MOULDING ASM. RH FRONT FENDER SIDE —...............10-250

C883200 MOULDING ASM. LH FRONT FENDER SIDE —................10-250

C884100 MOULDI NG/ FL A RE ASM. RH FR ONT WHEEL ................ ..10-250

C884100 MOULDI NG/ FL A RE ASM. RH FR ONT WHEEL ................ ..10-265

C884105 FLARE ASM. RH FRONT WHEEL ARCH —.......................10-250

C884200 MOULDI NG/FLARE ASM. LH FR ON T WHEEL. ... ... ............10-250

C884200 MOULDI NG/FLARE ASM. LH FR ON T WHEEL. ... ... ............10-265

C884205 FLARE ASM. LH FRONT WHEEL ARCH —........................10-250

C885500 AIR BAG UNIT, RH FRONT SEAT LATERAL —.................06-225

C885600 AIR BAG UNIT, LH FRONT SEAT LATERAL —..................06-225

C888000 SKIRT/PLATE, ROCKER/SILL PANEL RH (ONE................10-300

C888600 SKIRT/PLATE, ROCKER/SILL PANEL LH (ONE ................10-300

C891500 EMBLEM ASM. GRILLE — REPLACE ................................10-150

C895000 GUARD, HEADLAMP STONE — REPLACE BOTH............AA-005

C895100 GUARD, HEADLAMP STONE RH — REPLACE.................AA-005

C895200 GUARD, HEADLAMP STONE LH — REPLACE .................AA-005

C896100 GUARD, BONNET PROTECTOR — REPLACE..................AA-000

C896200 ORNAMENT ASM, HOOD — REPLACE.............................10-150

C896300 MOULDING. REAR PILLAR RH — REPLACE....................10-250

C896400 MOULDING. REAR PILLAR LH — REPLACE.....................10-250

C896500 MOULDING, RH FRONT DOOR FRAME OPENING...........10-265

C896600 MOULDING, LH FRONT DOOR FRAME OPENING —.......10-265

C896700 MOULDING, CENTRE PILLAR RH — REPLACE ...............10-250

C896700 MOULDING, RH CENTRE PILLAR — REPLACE ...............10-265

C896800 MOULDING, CENTRE PILLAR LH — REPLACE................10-250

C896800 MOULDING, LH CENTRE PILLAR — REPLACE................10-265

C896950 PANEL, LOWER DECKLID LAMP — REPLACE.................02-375

C897100 MOULDING, RH UPPER QUARTER PANEL —..................10-265

C897200 MOULDING, LH UPPER QUARTER PANEL —..................10-265

C897300 CAPPING/MOULDING, REAR ROOF CENTRE —.............10-265

C897400 CAPPING, RH REAR ROOF — REPLACE .........................10-265

C897500 CAPPING, LH REAR ROOF — REPLACE..........................10-265

D013100 DUCT ASM. A IR DISTR IB UT ION TO RH VEN T................ ..08-175

D013200 DUCT ASM. AIR DISTRIBUTION TO LH VENT —..............08-175

D013300 DUCT ASM. AIR DISTRIBUTION TO RH VENT..................08-175

D013500 DUCT ASM. REAR COMPARTMENT AIR —......................08-175

D013600 DUCT ASM. AIR DISTRIBUTION TO RH FLOOR...............08-175

D016000 VENT, CABIN VENTILATION, BOTH/ALL —.......................08-700

D016100 VENT, CABIN VENTILATION, RH/CENTRE —...................08-700

D016200 VENT, CABIN VENTILATION, LH — REPLACE..................08-700

D021120 ACTUATOR, RECIRCULATION (VACUUM) —...................08-150

D021300 DUCT, BLOWER TRANSFER — REPLACE .......................08-150

D021320 ACTUATOR, VACUUM CENTRE VENT — REPLACE........08-150

D021400 SOLENOID, VACUUM MASTER — REPLACE...................08-150

D021420 AC T U AT OR , DE MIS T & FLOOR (V A CU UM ) —..................08-150

D021500 MOTOR/SER V O, AIR MIXTURE SIN GL E/LH —.................08-150

D021600 SWITCH, VACUUM PLUNGER — REPLACE.....................08-150

D107100 GEAR SET, TEMPERATURE CONTROL —.......................08-155A

D110100 SWITCH, A/C CONTROL — REPLACE...............................08-155A

D111100 HOSE, VALVE TO HEATER CORE (UPPER) —.................08-075

D111110 HOSE ASM, HEATER — REPLACE (GEN III, GEN IV)......08-075

D111150 PIPE, HEATER INLET OUTLET — REPLACE (HFV6.........08-075

D111200 HOSE, VALVE TO HEATER CORE (LOWER) —................08-075

D111300 HOSE, BY PASS — REPLACE............................................08-075

D111400 HOSE, (HEATER VALVE TO ENGINE) INLET —...............08-075

D111500 HOSE, (ENGINE TO HEATER VALVE) OUTLET —...........08-075

D111700 VALVE ASM. HE A T ER WATE R — REPL A CE ... ............. ....08-075

D112100 ROD/CABLE , TEMP ER A T UR E CO NT R O L —....... ... ...........08-150

D118000 HARNESS ASM. VACUUM HOSES — REPAIR/................08-150

D130400 HEATING MAT, RH FRONT SEAT EXTENSION —............14-295

D130410 HEATING MAT, LH FRONT SEAT EXTENSION —............14-295

D130600 HEATING MAT, RH FRONT SEAT CUSHION —................14-295

D130610 HEATING MAT, LH FRONT SEAT CUSHION —.................14-295

D130700 HEATING MAT, RH FRONT SEAT BACK —.......................14-295

D130710 HEATING MAT, LH FRONT SEAT BACK —.......................14-295

D200100 SWITCH, REAR WINDOW DEMIST — REPLACE..............08-155A

D200500 SWITCH, VACUUM A/C — REPLACE.................................08-155A

D301100 A/C COMPRESSOR & CLUTCH ASM. — REPLACE..........08-200

D301120 "O" RINGS, COMPRESSOR — REPLACE..........................08-200

D307000 HOSE ASM. COMPRESSOR SUCTION & DIS—................08-200

D307050 HOSE ASM. A/C EVAPORATOR FRONT —.......................08-200

D307060 PIPE ASM. LI QUID LINE — REP L AC E .. ............ ... ............. .08-200

D307100 TUBE ASM. RECEIVER DEHYDRATOR TO TX.................08-200

D308100 TRANSDUCER/PRESSURE SENSOR — REPLACE.........08-200

D308200 "O" RING , CON D ENS E R — REPL A C E.............. ... ... ... ........08-200

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

D308210 "O" RING, CONDENSER (UPPER) — REPLACE...............08-200

D308220 "O" RING, CONDENSER (LOWER) — REPLACE..............08-200

D311100 BRACKET, ENGINE MOUNTING & COMPRESSOR..........08-200

D312000 TENSIONER ASM. A/C DRIVE BELT (GEN III, GEN..........01-020

D312050 IDLER PULLEY, AIR CONDITIONING — REPLACE..........01-020

D312100 BELT, A/C COMPRESSOR — REPLACE...........................01-003

D314100 CONDENSER ASM, PIPE & BRACKET — REPLACE........08-200

D316100 RECEIVER DEHYDRATOR AND/OR O RINGS —.............08-200

D318100 HEATER EVAPORATOR ASM. — REPLACE.....................08-150

D318150 CASE, HEATER & A/C — REPLACE ..................................08-150

D319000 VALVE, TX/EXPANSION AND OR O RINGS —..................08-200

D323100 HOSE/GROMMET EVAPORATOR DRAIN —.....................08-150

D327100 MOTOR & FAN, BL OWER WIT H A/ C — REPLAC E ...........08 -1 50

D329100 SWITCH, FAN A/C BLOWER MOTOR SPEED — ..............08-155A

D330100 RESISTOR, A/C BLOWER MOTOR — REPLACE..............08-150

D330200 EVAPORATOR COIL ASM, A/C — REPLACE....................08-150

D332100 PROTECTOR/SWITCH, COMPRESSOR THER— .............08-200

D332700 THERMOSTAT/SENSOR, EVAPORATOR —.....................08-150

D333100 CONTROL ASM, HEATER A/C — REPLACE.....................08-155A

D333100 MODULE ASM, A/C CLIMATE CONTROL —......................08-155A

D333150 FASCIA, HEATER A/C CONTROL — REPLACE................08-155A

D333200 DECA L, HEA T ER A/ C CON T ROL — REP L AC E.. ... ... .........08 -155A

D333250 KNOB, HEATER A/C CONTROL (ANY) — REPLACE........08-155A

D333300 CIRCUIT BOARD, HEATER A/C CONTROL — ..................08-155A

D333400 SHAFT, MODE CONTROL — REPLACE............................08-155A

D333500 SWITCH, VACUUM PLUNGER — REPLACE.....................08-155A

D333700 VALVE, COMPRESSOR CONTROL — REPLACE.............08-200

D337100 CORE ASM. HEATER WITH A/C — REPLACE..................08-150

D352300 DUCT ASM. AIR DISTRIB U T ION TO CONSOLE....... .........08-1 75

D358300 HOUSING ASM. CENTRE AIR OUTLET — REPLACE.......08-175

D358400 VENT/AIR BOX HOUSING, CONSOLE REAR — ...............14-900

D358400 VENT/AIR BOX HOUSING, CONSOLE REAR — ...............08-175

D358500 VENT/AIR BOX HOUSING, LH FRONT — REPLACE........08-175

D358600 VENT/AIR BOX HOUSING, RH FRONT — REPLACE........08-175

D904100 A/C SYSTEM PURGE, LEAK TEST & CHARGE.................08-200

D906199 GRID, REAR WINDOW DEMIST — REPAIR......................11-020

D906199 GRID, REAR WINDOW DEMIST — REPAIR......................11-030

D907000 TANK/ R ES E R VOIR AS M. VAC UUM — REPLACE.............08 -0 25

D907100 HOSE, VACUUM ANY ONE — REPLACE..........................08-025

D907150 VALVE, VACUUM CONTROL — REPLACE .......................08-025

D907200 DEFLECTOR ASM. WATER — REPLACE..........................10-510

D907310 GRILLE ASM. DEMIST NOZZLE RH — REPLACE.............09-125

D907320 GRILLE ASM. DEMIST NOZZLE LH — REPLACE .............09-125

D907400 COVER, PLENUM CHAMBER RH — REPLACE................10-510

D907500 COVER, PLENUM CHAMBER LH — REPLACE.................10-510

E000100 WHEEL ASM. (ONE) — REPLACE .....................................05-800

E000500 CAP ASM. WHEEL CENTRE (ONE OR ALL) —.................05-800

E000510 COVER ASM. WHEEL TRIM (ONE OR ALL) —..................05-800

E000900 VAL V E ST E M /T YR E PRESSURE IN DICATOR............... ... .05-800

E001000 CONTAI NE R , JACK ASM — REPLACE.......... ............ .... ... .05-825

E001300 BOLT/PLATE, SPARE WHEEL RETAINING —...................05-825

E001400 NUT, SPARE WHEEL RETAINING — REPLACE...............05-825

E001500 JACK ASM. LIFT IN G — REP L AC E ........ ... ... ............... ........05-825

E001600 WRENCH, WHEEL NUT — REPLACE................................05-825

E006100 STUD/BOLT, FRONT WHEEL RH — REPLACE (ONE.......04-805

E006200 STUD/BOLT, FRONT WHEEL LH — REPLACE (ONE.......04-805

E006300 NUT/STUD, WHEEL ATTACHING (ONE/ALL) —................05-800

E006400 CAP (PLASTIC), WHEEL NUTS — REPLACE (ONE/.........05-800

E006500 STUD/BOLT, REAR WHEEL RH — REPLACE (ONE/........05-290

E006500 STUD/BOLT, REAR WHEEL RH — REPLACE (ONE/........05-400

E006600 STUD/BOLT, REAR WHEEL LH — REPLACE (ONE/.........05-290

E006600 STUD/BOLT, REAR WHEEL LH — REPLACE (ONE/.........05-400

E100010 BUSH ASM. FRONT LOWER CONTROL ARM —..............06-200

E100100 ARM ASM. RH FRONT LOWER CONTROL —...................06-200

E100110 BUSH ASM. RH FRONT LOWER CONTROL ARM —........06-200

E100200 ARM ASM. LH FRONT LOWER CONTROL —....................06-200

E100210 BUSH ASM. LH FRONT LOWER CONTROL ARM —.........06-200

E103000 BALL JOINT, LOWE R FRONT — REPL A C E BOT H........ ... .06-200

E103300 BALL JOINT, LOWER RH FRON T — REPL A CE ............ ....06-2 00

E103400 BALL JOINT, LOWER LH FRON T — REPL A CE... ... ...........06-200

E105000 SPRING, FRONT COIL BOTH — R&R/REPLACE..............06-210

E105100 SPRING, FRONT COIL RH — R&R/REPLACE...................06-210

E105120 INSULATOR, SPRING UPPER FRONT COIL RH —..........06-210

E105200 SPRING, FRONT COIL LH — R&R/REPLACE....................06-210

E105220 INSULATOR, SPRING UPPER FRONT COIL LH —...........06-210

E106100 ROD, LH FRONT CONTROL ARM — REPLACE................06-200

E106200 ROD, RH FRONT CONTROL ARM — REPLACE...............06-200

E108000 STRUT ASM, BOTH FRONT — REPLAC E........... ..............06-212

E108100 STRUT ASM, RH FRONT — REPLACE..............................06-212

E108200 STRUT ASM, LH FRONT — REPLACE...............................06-212

E109100 BAR, FRON T ST A BI LI ZE R — REPL AC E.............. ............. .06-205

E109150 BUSH/PLATE, STABILIZER BAR TO CROSSMEM—.........06-205

E109200 STUD/BUSH/WASHE R , ST A BI LI ZE R BA R TO.................. .06-205

E109200 ADD TO: REPLACE BOTH SIDES ......................................06-205

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

E111100 KNUCKLE/ARM ASM. STEERING RH — REPLACE..........06-212

E111200 KNUCKLE/ARM ASM. STEERING LH — REPLACE..........06-212

E112000 BUSH ASM. FRONT CONTROL ARM ROD —...................06-200

E112100 BUSH ASM. RH FRONT CONTROL ARM ROD —.............06-200

E112200 BUSH ASM. LH FRONT CONTROL ARM ROD —..............06-200

E115000 HUB/OR BEARING, FRONT WHEEL BOTH SIDES —.......04-805

E115000 HUB/BEARING, FRONT WHEEL BOTH SIDES —.............06-212

E115100 HUB/OR BEAR IN G, FR ON T WHE E L RH — .............. .........04-8 05

E115100 HUB /B EAR IN G , FRON T WHE E L RH — REPL ACE............0 6 -2 12

E115200 HUB /B EAR IN G , FRON T WHE E L LH — REPL ACE........... ..06-212

E115200 HUB /B EAR IN G , FRON T WHE E L LH — REPL ACE........... ..04-805

E130010 PLATE/BEARING ASM. RH FRONT — REPLACE.............06-210

E130020 PLATE/BEARING ASM. LH FRONT — REPLACE..............06-210

E130030 STOP/NUT/CAP, SUSPENSION REBOUND RH —............06-210

E130040 STOP/NUT/CAP, SUSPENSION REBOUND LH —............06-210

E130210 BOOT/BUMPER, PISTON ROD RH — REPLACE..............06-210

E130220 BOOT/BUMPER, PISTON ROD LH — REPLACE...............06-210

E200130 DIFF E RE NTIAL ASM. FRONT (A WD) — REPLAC E...........05-250

E200500 SEAL, FRONT DIFFERENTIAL PINION OIL —...................05-250

E302010 SEAL, DRIVE SHAFT OIL — REPLACE BOTH SIDES.......06-200

E302010 SEAL, DRIVE SHAFT OIL — REPLACE BOTH SIDES.......05-250

E302110 SEAL, RH DRIVE SHAFT OUTPUT OIL — REPLACE .......05-250

E302110 SEAL, RH DRIVE SHAFT OUTPUT OIL — REPLACE .......06-200

E302120 SEAL, LH DRIVE SHAFT OUTPUT OIL — REPLACE........05-250

E302120 SEAL, LH DRIVE SHAFT OUTPUT OIL — REPLACE........06-200

E303100 DRIVE SHAFT ASM. RH FRONT — R&R/REPLACE .........06-200

E303110 CV JOINT/BOOT, RH FRONT DRIVE SHAFT —................06-200

E303200 DRIVE SHAFT ASM. LH FRONT — R&R/REPLACE..........06-200

E303210 CV JOINT/BOOT, LH FRONT DRIVE SHAFT —.................06-200

E303300 DRIVE SHAFT ASM. INTERMEDIATE — R&R/..................06-200

E303400 SEAL, INTERMEDIATE DRIVE SHAFT OIL — ...................06-200

E303500 SEAL, INTERMEDIATE DRIVE SHAFT OIL — ...................05-250

E303500 SEAL, INTERMEDIATE DRIVE SHAFT OIL — ...................06-200

E303600 SEAL, INTERMEDIATE DRIVE SHAFT OIL — ...................05-250

E400400 CROSSMEMBER ASM. FRONT SUSPENSION —.............06-200

F100000 SPRING, REAR COIL BOTH — REPLACE.........................07-150

F100100 SPRING , REA R COI L RH — REPL AC E......... ... ............. ... ..07-150

F100200 SPRING , REA R COI L LH — REPL AC E ... ............ ... ............07-150

F101000 SPRING, REAR LEAF BOTH — REPLACE ........................07-150

F101100 SPRING, REAR LEAF RH — REPLACE.............................07-150

F101200 SPRING, REAR LEAF LH — REPLACE..............................07-150

F102100 CENTRE BOLT, LEAF SPRING RH — REPLACE..............07-150

F102200 CENTRE BOLT, LEAF SPRING LH — REPLACE...............07-150

F102300 BRACKET, LEAF SPRING/SHOCKER MOUNTING............07-150

F102400 BRACKET, LEAF SPRING/SHOCKER MOUNTING............07-150

F104000 LINK ASM. REAR SUSPENSION ADJUSTMENT...............07-150A

F104100 LINK ASM. REAR SUSPENSION ADJUSTMENT RH.........07-150A

F104200 LINK ASM. REAR SUSPENSION ADJUSTMENT LH..........07-150A

F105000 SHACKLE/BUSH, LEAF SPRING BOTH — REPLACE.......07-150

F105100 SHACKLE/BUSH, LEAF SPRING RH — REPLACE............07-150

F105200 SHACKLE/BUSH, LEAF SPRING LH — REPLACE............07-150

F106000 BUSH, LEAF SPRING FRONT EYE BOTH —.....................07-150

F106100 BUSH, LEAF SPRING FRONT EYE RH — REPLACE........07-150

F106200 BUSH, LEAF SPRING FRONT EYE LH — REPLACE ........07-150

F108100 U BOLT, LEAF SPRING RH — REPLACE..........................07-150

F108200 U BOLT, LEAF SPRING LH — REPLACE...........................07-150

F109100 BUMPER, REAR AXLE RH — REPLACE............................07-150

F109200 BUMPER, REAR AXLE LH — REPLACE............................07-150

F109300 BU MP E R AS M. PI NI ON NOS E — REP LAC E......................07-150

F110000 ARM ASM. LOWER CONTROL BOTH — REPLACE..........07-150

F110100 ARM ASM. LOWER CONTROL RH — REPLACE...............07-150A

F110150 TRAILING ARM/LINK RH REAR — REPLACE....................07-150A

F110200 ARM ASM. LOWER CONTROL LH — REPLACE...............07-150A

F110250 TRAILING ARM/LINK LH REAR — REPLACE....................07-150A

F110300 CR OS S ME MB ER / AX L E — R& R/ R EP L AC E.......... ... ...........07-150A

F110500 FRAME, REAR HALF (CAB CHASSIS/CREWMAN) ...........07-150

F111000 BUSHES, LOWER CONTROL ARM — REPLACE..............07-150

F111300 BUSH, TRAILING ARM RR RH — REPLACE.....................07-150A

F111400 BUSH, TRAILING ARM RR LH — REPLACE......................07-150A

F112000 ARM ASM. UPPER CONTROL BOTH — REPLACE...........07-150

F112000 ARM ASM. UPPER CONTROL BOTH — REPLACE...........07-150A

F112100 ARM ASM. UPPER CONTROL RH — REPLACE...............07-150A

F112200 ARM ASM. UPPER CONTROL LH — REPLACE................07-150A

F114100 ROD ASM. PANHARD — REPLACE...................................07-150

F120000 SHOCK ABSORBER, REAR BOTH — REPLACE...............07-150

F120100 SHOCK ABSORBER, REAR RH — REPLACE...................07-150

F120200 SHOCK ABSORBER, REAR LH — REPLACE....................07-150

F121100 SHOCK ABSORBER SUPERLIFT REAR RH — .................AA-225

F121100 SHOCK ABSORBER SUPERLIFT REAR RH — .................07-150

F121200 SHOCK ABSORBER SUPERLIFT REAR LH —..................AA-225

F121200 SHOCK ABSORBER SUPERLIFT REAR LH —..................07-150

F121300 SHOCK ABSORBER SUPERLIFT REAR BOTH —.............AA-225

F121300 SHOCK ABSORBER SUPERLIFT REAR BOTH —.............07-150

F122100 STABILIZER SHAFT, RR — REPLACE...............................07-150A

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

F122100 STABILIZER SHAFT, RR — REPLACE...............................07-125

F125100 BUSH/PLATE, RR STABILIZER BAR RH —.......................07-125

F125100 BUSH/PLATE, RR STABILIZER BAR RH —.......................07-150A

F125150 SHACKLE & BUSH, RR STABILIZER BAR RH — ..............07-150A

F125150 STRUT/BUSHES, RR STABILIZER BAR RH —..................07-125

F125200 BUSH/PLATE, RR STABILIZER BAR LH —........................07-150A

F125200 BUSH/PLATE, RR STABILIZER BAR LH —........................07-125

F125250 SHACKLE & BUSH, RR STABILIZER BAR LH —...............07-150A

F125250 STRUT/BUSHES, RR STABILIZER BAR LH — ..................07-125

F201300 TRUNION/STUB AXLE, RH REAR — REPLACE................05-290

F201350 FLANGE ASM. TRUNION RH RR AXLE — REPLA CE.......05-290

F201400 TRUNION/STUB AXLE, LH REAR — REPLACE ................05-290

F201450 FLANGE ASM. TRUNION LH RR AXLE — REPLA CE........05-290

F202100 INSULATOR/SEAT, REAR COIL SPRING UPPER.............07-150

F202150 INSULATOR/SEAT, REAR COIL SPRING LOWER............07-150

F203100 INSULATOR/SEAT, REAR COIL SPRING UPPER.............07-150

F203150 INSULATOR/SEAT, REAR COIL SPRING LOWER............07-150

F209900 CROSSMEMBER/AXLE REAR — ALIGNMENT.................07-150A

F400100 LINK, HEIGHT SENSOR OR BALL PIVOT —.....................AA-225

F400200 HEIGHT SENSOR ASM — REPLACE.................................AA-225

F400300 MOUNT, SILICON — REPLACE..........................................AA-225

F400500 COMPRESSOR ASM. (LEVEL RIDE) — REPLACE...........AA-225

F400600 AIR LINE ASM LH. S/LIFT SHOCK ABSORBER —............AA-225

F400600 AIR LINE ASM LH. S/LIFT SHOCK ABSORBER —............07-150

F400650 AIR LINE ASM RH. S/LIFT SHOCK ABSORBER — ...........AA-225

F400650 AIR LINE ASM RH. S/LIFT SHOCK ABSORBER — ...........07-150

F400700 MODULE ASM. (LEVEL RIDE ) RELAY ISOLATING —.......AA-225

F400800 HARNESS, LEVEL RIDE POWER — REPAIR/...................AA-225

F501100 FLANGE ASM. DIFFERENTIAL PINION — REPLACE.......05-290

F501100 FLANGE ASM. DIFFERENTIAL PINION — REPLACE.......05-400

F502100 SEAL, PINION SHAFT OIL — REPLACE............................05-290

F502100 SEAL, PINION SHAFT OIL — REPLACE............................05-400

F504000 SHAFT, REAR AXLE — REPLACE BOTH SIDES ..............05-400

F504000 DRIVE SHAFT, RR AXLE — REPLACE BOTH SIDES.......05-290

F504100 SHAFT, REAR AXLE RH — REPLACE...............................05-400

F504100 DRIVE SHAFT, RR AXLE RH — REPLACE (RR)...............05-290

F504150 DAMPER BLOCK AS M. DI FFERENTIA L —......... ... ............05-290

F504200 DRIVE SHAFT, RR AXLE LH — REPLACE (RR)................05-290

F504200 SHAFT, REAR AXLE LH — REPLACE................................05-400

F505000 SEAL, AXLE SHAFT OIL — REPLACE BOTH SIDES........05-400

F505100 SEAL, AXLE SHAFT RH OIL — REPLACE.........................05-400

F505200 SEAL, AXLE SHAFT LH OIL — REPLACE..........................05-400

F505300 SEAL, REAR AXLE DRIVE SHAFT INNER LH —...............05-290

F505400 SEAL, REAR AXLE DRIVE SHAFT INNER RH —...............05-290

F505500 SEAL, REAR AXLE DRIVE SHAFT INNER —.....................05-290

F506000 BEARING, AXLE SHAFT — REPLACE BOTH SIDES ........05-400

F506100 BEARING, AXLE SHAFT RH — REPLACE.........................05-400

F506200 BEARING, AXLE SHAFT LH — REPLACE .........................05-400

F506300 PULSE RING, ABS SE N S OR — REPL A CE BO T H......... ... .05-400

F506400 PULSE RING, ABS SENSOR RH — REP L AC E.............. ....05 -4 00

F506500 PULSE RING, ABS SENSOR LH — REP L AC E.................. .05-400

F650100 REAR AXLE/DIFFERENTIAL ASM. COMPLETE —............05-400

F650100 DIFFEREN T IA L AS M. (C OMP L E TE ) — RE PL A CE.. ...........05-290

F650200 DIFFEREN T IA L ASM. (R E CON D IT ION ) — R & R . ............. .05-290

F650200 DIFFEREN T IA L ASM. (R E CON D IT ION ) — R & R . ............. .05-400

F650500 BU S H , RE A R CROS SME M B ER / AX L E BOT H — .. ............. .07-150A

F650510 BU S H , RE A R CROS SME M B ER / AX L E R H —.......... ...........07-150A

F650520 BU S H , RE A R CROS SME M B ER / AX L E LH —..... ... ............. .07-150A

F651100 HOUSING, REAR AXLE — REPLACE................................05-400

F653100 COVER/GASKET, REAR AXLE HOUSING INSPEC— .......05-290

F653100 COVER, DIFFERENTIAL INSPECTION — REPLACE........05-400

F653100 GASKET, DIFF INSPECTION COVER — REPLACE..........05-400

F701000 BEARING/HUB, REAR WHEEL — REPLACE BOTH..........05-290

F701100 BEARING/HUB, REAR WHEEL RH — REPLACE...............05-290

F701200 BEARING/HUB, REAR WHEEL LH — REPLACE...............05-290

F905100 SHAFT, FRONT DIFFERENTIAL PROPELLER —..............05-250

F905200 BEARING, FRONT PROPELLER SHAFT —.......................05-250

F907100 SHAFT ASM. REAR PROPELLER — R&R/REPLACE........05-050

F908100 UNIVERSAL JOINT/RUBBER MOUNT, FRONT —.............05-050

F908200 YOKE, PROPELLER SHAFT SLIP, FRONT —....................05-050

F908300 FL A NGE , PR OP E LLE R SH A F T, REAR — REPLACE.........05 -0 50

F910100 UNIVERSAL JOINT/RUBBER MOUNT, REAR —...............05-050

F911100 UNIVERSAL JOINT, PROPELLER SHAFT CENTRE..........05-050

F911100 BEARING, CONSTANT VELOCITY JOINT — R&R/...........05-050

F912100 BEARING, PROPELLER SHAFT CENTRE —.....................05-050

F913800 BRIDGE, CROSSMEMBER CENTRE — REPLACE...........04-020

H025500 SPRING, ACTUATING LEVER RETURN RH —..................04-825

H025600 SPRING, ACTUATING LEVER RETURN LH —..................04-825

H105000 PADS, BOT H FR ON T WHE E LS DI SC BR A KE —. ............. .04-750

H106000 DISC ASM. FR ON T BR A KE BOT H SID E S — R&R.............04-805

H106100 DISC ASM. FR ON T BR A KE RH — R&R ... ... ............ ... ........04-805

H106200 DISC ASM. FR ON T BR A KE LH — R&R.......... ... ............. ... .04-805

H107000 CA L IP E R AS M. BOT H FRONT — REPL A CE...... ... ... ... ........04-750

H107100 CALIPER ASM. RH FRONT — REPLACE....... ............ .... ....04 -7 50

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

H107200 CALIP ER AS M. LH FR ONT — REPL AC E...... ... ............. ... ..04-750

H108000 SHIELD, DISC BRAKE SPLASH BOTH SIDES —..............04-805

H108100 SHIELD, DISC BRAKE SPLASH RH — REPLACE.............04-805

H108200 SHIELD, DISC BRAKE SPLASH LH — REPLACE..............04-805

H125000 PADS/SHOES, REAR BRAKES BOTH SIDES —...............04-825

H126000 DISC ASM. REAR BRAKE BOTH SIDES — R&R...............04-825

H126100 DISC ASM. REAR BRAKE RH — R&R................................04-825

H126200 DISC ASM. REAR BRAKE LH — R&R................................04-825

H127000 CALIP ER AS M. RE A R BOTH — REP L AC E................... ... ..04-825

H127100 CALIP ER AS M. RE A R RH — REPL A C E.................... .... .....04-8 25

H127200 CALIP ER AS M. RE A R LH — REPL A CE .. ............ ... ............0 4-825

H128100 SHIELD ASM. REAR DISC/DRUM BRAKE RH — ..............04-825

H128200 SHIELD ASM. REAR DISC/DRUM BRAKE LH —...............04-825

H301000 PEDA L ASM. BRAKE — REPLACE ... ... ............ ... ............. ..04-600

H301100 PAD, BRA KE PE D AL — REP L A CE.......... ............ ... ............04-600

H302100 SPRING, BRAKE PEDAL RETURN — REPLACE ..............04-600

H321000 CABLE ASM. PARK BRAKE REAR BOTH SIDES —..........04-675

H321100 CABLE ASM. PARK BRAKE RH REAR — REPLACE........04-675

H321200 CABLE ASM. PARK BRAKE LH REAR — REPLACE.........04-675

H325100 LEVER ASM. PARK BRAKE — REPLACE..........................04-675

H325500 KNOB/SPRING, PARK BRAKE LEVER — REPLACE........04-675

H327000 SHOES/LINING ASM. REAR PAR K BRAKE BOTH —........04-825

H327100 SHOES/LINING ASM. REAR PARK BRAKE RH — ............04-825

H327200 SHOES/LINING ASM. REAR PARK BRAKE LH —.............04-825

H327300 CABLE ASM. PARK BRAKE FRONT/CENTRE —..............04-675

H400100 CYLIN D ER , BR AK E MAS T E R — REPL A CE........ ............. ..04-725

H400200 RESERVOIR, BRAKE MASTER CYLINDER —..................04-725

H400250 SEAL/CAP, RESERVOIR — REPLACE ..............................04-725

H401100 SWITCH, BRAKE PRESSURE WARNING — .....................04-725

H402000 HOSE, FRONT BRAKE — REPLACE BOTH SIDES...........04-750

H402100 HOSE, FRONT BRAKE RH — REPLACE...........................04-750

H402200 HOSE, FRONT BRAKE LH — REPLACE............................04-750

H402300 PIPE ASM. MASTER CYLINDER (FRONT) TO...................04-755

H402400 PIPE ASM. MODULATOR TO R/H FRONT BRAKE............04-755

H402500 PIPE ASM. MODULATOR TO L/H FRONT BRAKE ............04-755

H402600 PIPE ASM. MASTER CYLINDER (REAR) TO MOD—........04-755

H404100 PIPE ASM. MASTER CYLINDER TO FRONT CALI— ........04-750

H404200 PIPE ASM. MASTER CYLINDER TO FRONT CALI— ........04-750

H404300 PIPE ASM. RR BRAKE CROSSOVER — REPLACE..........04-750

H406100 PIPE ASM. BRAKE HOSE TO RH RR CALIPER —............04-750

H406110 PIPE ASM. MASTER CYLINDER TO RR BRAKE RH.........04-750

H406120 PIPE ASM. MODULATOR TO RR BRAKE RH — ...............04-755

H406200 PIPE ASM. BR A K E HOS E TO LH RR CA L IP ER —......... ... .04-750

H406220 PIPE ASM. MOD U LA T OR TO RR BRA KE LH —........ .... ....04- 7 55

H408500 VALVE, PROPORTIONING OR LOAD SENSING —...........04-725

H412000 HOSE, RR BRAKE — REPLACE BOTH SIDES..................04-750

H412100 HOSE, RR BRAKE RH — REPLACE ..................................04-750

H412200 HOSE, RR BRAKE LH — REPLACE...................................04-750

H502500 BOOSTER ASM. POWER BRAKE — R&R/REPLACE........04-725

H503100 HOSE, CHECK VALVE VACUUM — REPLACE.................04-725

H504100 VALVE ASM/GROMMET, CHECK POWER BRAKE —.......04-725

H901100 HYDRAULIC MODULATOR (ABS) — REPLACE................04-730

H901300 SENSOR, ABS WHEEL SPEED BOTH FRONT —.............04-730

H901320 SENSOR, ABS WHEEL SPEED RH FRONT —. ...... ...........04-730

H901340 SENSOR, ABS WHEEL SPEED LH FRONT —...................04-730

H901400 SENSOR, ABS WHEEL SPEED BOTH REAR —................04-730

H901420 SENSOR, ABS WHEEL SPEED RH REAR —.......... ...........04-730

H901440 SENSOR, ABS WHEEL SPEED LH REAR —.....................04-730

H902500 BR A K E S YST EM — BLEE D.... ............... ............................ .04-725

J109100 SEAL/BOLT, VALVE ROCKER COVER — REPLACE........00-025

J112700 TENSíR, GEAR/PULLEY GUIDE/DAMPER TIMING...........00-225

J114100 SPROCKET, TIMING CHAIN/BELT CRANKSHAFT —.......00-225

J117300 GASKET/SEAL, OIL PUMP SUCTION PIPE —...................00-251

J117350 PIPE/SCREEN ASM. OIL SUCTION — REPLACE.............00-251

J213510 CHA IN /B E LT , TI MIN G — REPL A C E (E X HFV6).................00-225

J213550 CHAIN, PRIMARY TIMING — R&R/REPLACE....................00-225

J213600 CHAIN, R/H SIDE SECONDARY TIMING — R&R/.............00-225

J213700 CHAIN, L/H SI DE SE C O ND A R Y TI MING — R&R/..............00-225

J213800 CHAINS, TIMING — R&R/REPLACE ALL PRIMARY..........00-225

J214150 IDLER GEAR, L/H SIDE — REPLACE ................................00-225

J214200 IDLER GEAR, R/H SIDE — REPLACE................................00-225

J214700 WELSH PLUG, FRONT OIL GALLERY — REPLACE.........00-248

J217700 TUBE & BRACKET ASM. OIL LEVEL GAUGE —...............00-580

J221950 SENSOR ASM. LOW ENGINE OIL LEVEL —.....................00-275

J233500 PLUG, CYLINDER BLOCK DRAIN — REPLACE................00-248

J237000 MOUNT/BRACKET, ENGINE — REPLACE BOTH .............00-475

J300500 GASKET, INLET MANIFOLD — REPLACE.........................00-375

J300600 MANIFOLD, INLET (COMPLETE) — REPLACE .................00-375

J300620 COVER, ENGINE BLOCK VALLEY — REPLACE...............00-375

J300650 MANIF O LD COVE R, INL ET — REPLACE.......... ... ... ... ........00-375

J300700 MANIFOLD UPPER, INLET — REPLACE...........................00-375

J301510 GASKET, INLET MANIFOLD UPPER — REPLACE............00-375

J303100 MANIFOLD ASM. EXHAUST — REPLACE CYLS...............00-450

J303200 MANIFOLD ASM. EXHAUST — REPLACE CYLS...............00-450

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

J307000 GASKET, VALVE ROCKER COVER — REPLACE.............00-025

J307010 ARM, VALVE ROCK ER (1 OR AL L ) — REPL AC E..............0 0-050

J307020 ROD, VALVE PUSH, (1 OR 2) — REPLACE BOTH............00-050

J307030 SPRING, CAP AND/OR SEAL, VALVE (TWO CYL) —.......00-075

J307040 PIVOT OR PEDESTAL, VALVE ROCKER (1 OR 2 ) —.......00-050

J307050 COV E R AS M. VA L V E ROC K ER — RE PL ACE BOT H.........0 0 -0 25

J307100 GASKET, VALVE ROCKER COVER — REPLACE.............00-025

J307110 ARM, VALVE ROCK ER (1 OR AL L ) — REPL AC E..............0 0-050

J307120 ROD, VALVE PUSH, (1 OR 2) — REPLACE CYLS ............00-050

J307130 SPRING, CAP AND/OR SEAL — VALVE (ONE CYL.)........00-075

J307135 GUIDE, LI FT E RS /P U S H R OD S — REP L AC E CYLS..... ... ..00-050

J307140 PIVOT OR PEDESTAL, VALVE ROCKER (1 OR 2 ) —.......00-050

J307150 COV E R AS M. VA L V E ROC K ER — RE PL ACE CY L S.........0 0-025

J307200 GASKET, VALVE ROCKER COVER — REPLACE.............00-025

J307210 ARM, VALVE ROCK ER (1 OR AL L ) — REPL AC E..............0 0-050

J307220 ROD, VALVE PUSH, (1 OR 2) — REPLACE CYLS ............00-050

J307230 SPRING, CAP AND/OR SEAL — VALVE (ONE CYL.)........00-075

J307235 GUIDE, LI FT E RS /P U S H R OD S — REP L AC E CYLS..... ... ..00-050

J307240 PIVOT OR PEDESTAL, VALVE ROCKER (1 OR 2 ) —.......00-050

J307250 COV E R AS M. VA L V E ROC K ER — RE PL ACE CY L S.........0 0-025

J310000 GASKET, CYLINDER HEAD — REPLACE BOTH ..............00-075

J310010 VALVE, CYL. HEAD ( ONE) — REPLACE CYLS 1,3,5,.......00-075

J310020 VALVE, CYL. HEAD ( ONE) — REPLACE CYLS 2,4,6,.......00-075

J310050 HEAD ASM. CYLINDER — OVERHAUL BOTH SIDES ......00-075

J310100 GASKET, CYLINDER HEAD — REPLACE CYLS...............00-075

J310150 HEAD ASM. CYLINDER — OVERHAUL CYLS 1,3,5,.........00-075

J310200 GASKET, CYLINDER HEAD — REPLACE CYLS...............00-075

J310250 HEAD ASM. CYLINDER — OVERHAUL CYLS 2,4,6,.........00-075

J310300 HEAD ASM. CYLINDER (LESS VALVES) — ......................00-075

J310400 HEAD ASM. CYLINDER (LESS VALVES) — ......................00-075

J310450 HEAD ASM. CYLINDER (COMPLETE) — REPLACE.........00-075

J310500 HEAD ASM. CYLINDER (LESS VALVES) — ......................00-075

J310550 HEAD ASM. CYLINDER (COMPLETE) — REPLACE.........00-075

J310600 HEAD ASM. CYLINDER (COMPLETE) — REPLACE.........00-075

J311100 LIFTER, HYDRAULIC VALVE (ALL) — REPLACE..............00-050

J312500 DAMPER ASM. TORSIONAL — REPLACE........................00-540

J312600 SEAL, CRANKSHAFT FRONT OIL — REPLACE ...............00-325

J313100 COVER, ENGINE SIDE RH — REPLACE...........................00-508

J313200 COVER, ENGINE SIDE LH — REPLACE............................00-508

J313250 COV E R, EN GI NE FR ON T — REPL A CE................. ... .........00 -5 08

J313300 COVER, ENGINE UPPER — REPLACE ONE/BOTH .........00-508

J313500 COVER/HOUSING, ENGINE FRONT — REPLACE ...........00-325

J313550 GASKET, ENGINE FRONT COVER — REPLACE..............00-325

J313900 HYDRAULIC TENSIONER — SECONDARY TIMING.........00-225

J314000 HYDRAULIC TENSIONER — PRIMARY TIMING ...............00-225

J314100 HYDRAULIC TENSIONER — SECONDARY TIMING.........00-225

J314300 SPROCKET, CAMSHAFT TIMING — RIGHT BANK...........00-225

J314350 SPROCKET, CAMSHAFT TIMING — RIGHT BANK...........00-225

J314400 SPROCKET, CAMSHAFT TIMING — LEFT BANK .............00-225

J314450 SPROCKET, CAMSHAFT TIMING — LEFT BANK .............00-225

J314500 CAMSHAFT ASM. — REPL ACE (EXCLUDING HFV6).......00-175

J314550 GEAR, CAMSHAFT (OR THRUST PLATE) —....................00-225

J314560 SPROCKET, TIMING CHAIN/BELT, CAMSHAFT —...........00-225

J314570 CAMS H AF T ASM CYL S 1, 3, 5 EX H A US T —... ............ .... ....00-175

J314580 CAMSHAFT ASM. CYLS 2,4,6 EXHAUST —......................00-175

J314590 CAMSHAFT ASM CYLS 1,3,5 INTAKE — REPLACE.........00-175

J314610 CAMSHAFT ASM. CYLS 2,4,6 INTAKE — REPLACE........00-175

J314740 WELSH PLUG, CYL HEAD FRONT — REPLACE..............00-075

J314750 WELSH PLUG, CYL HEAD FRONT — REPLACE..............00-075

J314760 WELSH PLUG, CYL HEAD REAR — REPLACE CYLS......00-075

J314770 WELSH PLUG, CYL HEAD REAR — REPLACE CYLS......00-075

J314800 WELSH PLUG, ENGINE BLOCK VALLEY —......................00-075

J314900 SHAFT & BEARING ASM. BALANCE — REPLACE...........00-150

J314910 BEA R IN G, BALAN C E S HAF T (R EA R ) — REPL A CE......... .00-150

J315400 GUARD, OIL PAN ASM — REPLACE.................................06-200

J315500 GASKET, OIL PAN — REPLACE ........................................00-275

J315600 PAN ASM. OIL — REPLACE ...............................................00-275

J315700 COVER, OIL TRANSFER — REPLACE (GEN III, GEN.......00-275

J316100 GASKET, OIL FILTER ADAPTOR — REPLACE.................01-500

J316200 FILTER/CARTRIDGE ASM. OIL — REPLACE....................01-500

J316300 ADA P TOR /H OU SI NG AS M. OIL FILTER —............. ... ........01-500

J316500 PUMP/GASKET, ENGINE OIL — R&R/REPLACE..............01-500

J316510 VALVE, OIL PRESSURE RELIEF/REGULATING —...........01-500

J316600 GEARS/DRIVE SHAFT/BUSH/PLATE, OIL PUMP —.........01-500

J317500 INDICATOR, OIL LEVEL — REPLACE ...............................00-580

J318500 CAP, OIL FILLER — REPLACE...........................................00-025

J320000 CRANKSHAFT — R&R/REPLACE......................................00-200

J320100 CAP, CRANKSHAFT MAIN BEARING — REPLACE ..........00-200

J320150 SQUIRTERS, CRANKSHAFT OIL — REPLACE.................00-200

J320250 PLATE, REAR MAIN OIL SEAL — R&R/REPLACE............00-200

J320510 BEARING, CONNECTING ROD (ONE/ALL) —...................00-550

J320700 BEARING, CRANKSHAFT MAIN (ONE) — REPLACE........00-200

J32072 5 SEA L, REAR MAIN OI L — RE PLACE (EXC L UDING..........00-200

J326500 HOSE, COOLANT AIR BLEED (GEN III, GEN IV) —..........01-160

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

J327000 PIPE, COOLANT AIR BL E ED (GEN III, GEN IV) —............01-160

J330000 PISTON & PIN ASM. (ONE) — REPLACE BOTH ...............00-550

J330020 RINGS, PISTON (ONE SET ) — REPLACE OPPO—.........00-550

J330050 ROD , CON NEC T IN G. (ONE ) — RE PL ACE BOT H......... .....00-550

J330100 PISTON & PIN ASM. (ONE) — REPLACE CYLS................00-550

J330120 RINGS, PISTON (ONE SET) — REPLACE CYLS...............00-550

J330150 ROD, CONNECTING (ONE) — REPLACE CYLS ...............00-550

J330200 PISTON & PIN ASM. (ONE) — REPLACE CYLS................00-550

J330220 RINGS, PISTON (ONE SET) — REPLACE CYLS...............00-550

J330250 ROD, CONNECTING (ONE) — REPLACE CYLS ...............00-550

J332000 WELSH PLUG ALL — REPLACE (V6 ONLY)......................00-248

J332100 WELSH PLUG, RH SIDE — REPLACE ONE/BOTH...........00-248

J332200 WELSH PLUG, LH SIDE — REPLACE ONE/BOTH............00-248

J335500 FLYWHEEL & RING GEAR ASM. — REPLACE .................00-400

J335550 FLEXPLATE & RING GEAR ASM. — REPLACE ................00-400

J337100 MOUNT/BRACKET, ENGINE RH FRONT — ......................00-475

J337200 MOU N T/ BR A CKE T , EN GIN E LH FRON T —..... ... ... ............0 0 -4 75

J338000 INSULATOR ASM. POWER PLANT REAR — ....................04-020

J338010 SUPPORT ASM. REAR — REPLACE.................................04-020

J340000 SHORT MOTOR — REPLACE (EXCL. GEN III, GEN.........00-248

J340010 ENGINE ASM. AS SHIPPED — REPLACE (EXCL. ............00-500

J340020 ENGINE ASM. AS SHIPPED — REPLACE (GEN III,..........00-500

J340100 ENGINE & TRANS. ASM. — R & R (EXCL. GEN III,...........00-500

J340200 ENGINE & TRANS. ASM. — R & R (GEN III, GEN IV)........00-500

J340300 LONG MOTOR — REPLACE (GEN III , GEN IV ONLY)......00-248

J340500 BLOCK, CYLINDER CASE — REPLACE............................00-248

J351000 CA MS HA F T A SM. — REPL A C E AL L HFV6...... ... ... ............00-175

J496030 SENSOR, ACCELERATOR PEDAL POSITION —..............03-650

J546500 CON T ROL LER , FU E L PUMP SPEE D — REPL AC E......... ..03-074

J589100 S/C BYPASS VALVE ACTUATOR — REPLACE................03-300

J589200 S/C BYPASS SOLENOID — REPLACE..............................03-300

J589300 VACUUM HOSE (ANY ONE) — REPAIR/REPLACE ..........03-300

J589400 S/C BOOST CONTROL SOLENOID VALVE —...................03-300

J590500 GASKET, SUPERCHARGER TO MANIFOLD — ................00-375

J590800 SUPERCHARGER ASM. — REPLACE...............................00-375

J591200 ALTERNATOR ASM. — REPLACE.....................................02-140

J592800 VOLTAGE REGULATOR — REPLACE...............................02-140

J594000 STARTER MOTOR ASM. — REPLACE..............................02-070

J600100 CAP, RADIATOR FILLER — REPLACE..............................01-105

J600150 CAP, OVERFLOW RESERVOIR/SURGE TANK.................01-140

J600500 RADIATOR ASM. — R&R/REPLACE..................................01-105

J600510 TANK & SEAL, RADIATOR SIDE LH — REPLACE ............01-105

J600520 TABLETS/PELLETS, COOLING SYSTEM — ADD.............01-105

J600530 TANK & SEAL, RADIATOR SIDE RH — REPLACE............01-105

J601000 HOSES, RADIATOR BOTH — REPLACE...........................01-160

J601100 HOSES, RADIATOR UPPER/INLET — REPLACE..............01-160

J601150 PIPE, COOLANT INLET — REPLACE (HFV6 ONLY).........01-160

J601200 HOSES, RADIATOR LOWER/OUTLET — REPLACE.........01-160

J601210 HOSE, CONNECTING TUBE TO ENGINE (S/C,.................01-160

J601300 PIPE ASM. HEATER OUTLET — REPLACE.......................08-125

J601350 PI PE AS M. HE A TE R INL E T — REPL ACE ... ............ ... ........08-125

J601400 CLAMP, RADIATOR HOSE — REPLACE (ANY)................01-160

J601450 CLAMP, RADIATOR OVERFLOW HOSES —.....................01-140

J601510 TUBE, CONNECTING — REPLACE....................................01-160

J601600 HOSE, RADIATOR TO OVERFLOW RESERVOIR —.........01-140

J601610 PI PE AS M. AI R B LE E D — REPLACE .......... ... ............ .... ....01- 1 40

J602100 RESERVOIR/SURGE TANK, RADIATOR OVER—.............01-140

J602200 PIPE ASM. RADIATOR INLET (S/C ONLY) —....................01-160

J602300 HOSE, ENGINE TO RADIATOR INLET PIPE (S/C..............01-160

J602500 TUBE, RESERVOIR OVERFLOW — REPLACE.................01-140

J603500 SHROUD, RADI ATOR COOLING FANS — REPLACE.......01-105

J603550 SHROUD, RADIATOR UPPER — REPLACE......................01-105

J605599 RAD IA T OR — REPA IR......... ... ............ ... ............ ... ............. .01-105

J606100 FAN BLADE, RADIATOR COOLING — REPLACE.............01-105

J606150 MOTOR ASM, RADIATOR COOLING FAN —.....................01-105

J606600 PUL LE Y, WATER PUMP — REPLAC E........... ....................01-020

J606600 PUL LE Y, WATER PUMP — REPLAC E........... ....................01-030

J606800 IDLER PULLEY, MAIN BELT — REPLACE.........................01-020

J607050 BELT, SUPERCHARGER....................................................01-003

J607100 BELT, MAIN DRIVE — REPLACE.......................................01-003

J607150 BELT, WATER PUMP & ALTERNATOR — REPLACE.......01-003

J607200 PULLEY ASM. MAIN BELT TENSIONER —........................01-030

J607250 TENSIONER ASM. MAIN BELT — REPLACE.....................01-020

J607250 TENSIONER ASM. MAIN DRIVE BELT — REPLACE.........01-030

J607300 SUPPORT, IDLER PULLEY, AIR CONDITIONING —.........01-030

J607350 IDLER PULLEY, MAIN DRIVE BELT — REPLACE.............01-030

J607400 TENSIONER ASM. SUPERCHARGER DRIVE BELT..........01-030

J607450 PULLEY ASM. SUPERCHARGER DRIVE BELT.................01-030

J607500 SUPPORT, IDLER PULLEY, DRIVE BELT —.....................01-030

J607550 IDLER PULLEY, MAIN DRIVE BELT (WITH A/C) —...........01-030

J608100 SEAL/GASKET, WATER OUTLET — REPLACE................00-350

J608110 OUTLET ASM. WATER — REPLACE.................................00-350

J608130 THERMOSTAT ASM. — REPLACE.....................................00-350

J608200 HOUSING, COOLANT INLET — REPLACE........................00-350

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

J609100 PUMP ASM. WATER — REPLACE.....................................00-325

J609150 GASKET/SEAL, WATER PUMP TO COVER —..................00-325

J712100 BRACKET, ALTERNA TOR MOUNTING — REPLACE .......02-140

J712200 SUPPORT, REAR ALTERNATOR MOUNTING ..................02-140

J712300 BRACE/ADJUSTER, ALTERNATOR MOUNTING ..............02-140

J712400 PLATE, COIL/M OD U L E MOU NTI NG — REPL A CE ............02-225

J715100 COIL, IGNITION — REPLACE (GEN III, GEN IV) ...............02-235

J724000 SE N S OR ASM . KN OCK (ON E OR BOT H ) —......................02 -0 00

J724050 SENSOR ASM KNOCK — REPLACE BOTH SIDES...........02-000

J724100 SENSOR ASM KNOCK — REPLACE CYLS 2,4,6..............02-000

J724150 SENSOR ASM KNOCK — REPLACE CYLS 1,3,5..............02-000

J724200 SENSOR, INTAKE AIR TEMP. — REPLACE......................03-250

J724300 SENSOR AS M . FU E L PU MP SWITCH & OIL PRE S —.......02-000

J724510 COIL ASM. (DFI) ELECTRONIC IGNITION — ....................02-225

J724520 MODULE ASM. (DFI) ELECTRONIC IGNITION — .............02-225

J730000 MODULE (PIM), POWER TRAIN INTERFACE —...............02-245

J730100 LEAD ASM. SPARK PLUG (1 OR ALL) — REPLACE.........02-030

J735100 SPARK PLUG — REPLACE/CLEAN OR ADJUST..............02-030

J740100 SENSOR, MANIFOLD ABSOLUTE PRESSURE.................02-000

J740200 SENSOR ASM. MANIFOLD AIR TEMP. (M.A.T) — ............02-000

J740250 SENSOR ASM/OIL SEAL, CRANKSHAFT —......................02-000

J794100 SOLENOID VALVE, CAMSHAFT POSITION ACTU—........02-000

J794200 SOLENOID VALVE, CAMSHAFT POSITION ACTU—........02-000

J794900 SENSOR ASM. OIL TEMPERATURE — REPLACE...........00-275

J794900 SENSOR ASM. OIL TEMPERATURE — REPLACE...........02-000

J795200 SENSOR, CAMSHAFT — REPLACE..................................02-000

J805170 BODY ASM. THROTTLE — REPLACE...............................03-300

J805200 GASKET, THROTTLE BODY TO ADAPTOR —..................03-300

J805210 ADAPTOR ASM. THROTTLE BODY (S/C ONLY) — ..........03-300

J805220 GASKET/SEAL, THROTTLE BODY — REPLACE..............03-300

J814500 SPRING, THROTTLE RETURN — REPLACE ....................03-650

J815500 LEVER ASM. AC C E LE R AT O R CONT R O L —......... ... .........0 3 - 6 50

J815600 PAD/PEDAL, ACCELERATOR PEDAL — REPLACE.........03-650

J816500 SUPPORT ASM. PEDAL LEVER — REPLACE ..................03-650

J816800 RELAXER, ACCELERATOR CABLE CONTROL —............03-325

J816900 CABLE ASM. AC C E LE R AT O R CONT R O L —......... ... .........03-325

J816910 CAM/BRACKET — THROTTLE & CRUISE CABLE............03-325

J817500 BODY, AIR CLEANER UPPER — REPLACE......................03-250

J817600 BODY, AIR CLEANER LOWER — REPLACE.....................03-250

J817900 ELEMENT ASM. AIR CLEANER — REPLACE ...................03-250

J818510 BOOT, AIR FLOW METER TO THROTTLE BODY —.........03-250

J818520 BOOT, AIR CLEANER TO MASS AIR FLOW SEN—..........03-250

J818530 DUCT ASM. AIR INTAKE TO AIR CLEANER —.................03-250

J900000 INJECTOR ASM. FUEL — REPLACE (ONE/ALL)...............03-375

J901000 RAIL ASM. FUEL — REPLACE...........................................03-375

J901010 SEAL, INJECTOR FUEL UPPER/LOWER —......................03-375

J901100 HOSE, FUEL FEED PIPE TO ENGINE FU EL FEED — ......03-375

J901200 HOSE, ENGINE FUEL RETURN TO FUEL RETURN .........03-375

J903000 REGULATOR, FUEL RAIL/PRESSURE — REPLACE........03-375

J904100 PIPE, FUEL RETURN — REPLACE....................................03-075

J950100 VALVE, (PCV) CRANKCASE VENT CONTROL —.............00-249

J950110 HOSE, CRANKCASE VENT — REPLACE..........................00-249

J971800 MOTOR/VALVE ASM. (IAC) IDLE AIR — REPLACE..........03-300

J980500 VALVE EGR &/OR GASKET — REPLACE .........................03-300A

J980600 PIPES, SECONDARY AIR — REPLACE.............................03-300A

J980700 VALVE, NON RETURN, SECONDARY AIR —....................03-300A

J980710 HOSES, AIR DUCT, SECONDARY AIR PUMP, —.............03-300A

J980800 PUMP ASM, SECONDARY AIR — REPLACE....................03-300A

J980910 VALVE, SWITCH OVER, SECONDARY AIR —..................03-300A

J980930 COMBINATION VALVE/SEAL, SECONDARY AIR —.........03-300A

J987510 MODUL E (E CM) , EN GINE CON T ROL — REPL AC E......... .02-245

J987520 MODULE, THROTTLE CONTROL — REPLACE................02-245

J987600 SENSOR ASM. OXYGEN, EXHAUST LH —.......................00-450

J987610 MODUL E (P CM) , POWE RT R AIN C ONT R OL — ... ... ...........02-245

J987650 SENSOR ASM. OXYGEN, EXHAUST RH —.......................00-450

J987700 MEMCAL ASM. (E CM/ PC M) — REPL A CE (E XC L ..............02-2 45

J987710 PCM, ECM — REPR OGR A M ........ ........................... ...........02-245

K000225 AUTO TRANS ASM. — SRTA CHANGEOVER PRO—.......04-200

K001100 PEDAL AS M, CL U TC H — REPL AC E........ ............ ... ...........04-600

K001200 PAD, CLUTCH PEDAL — REPLACE ..................................04-600

K006100 SPRING, CLUTCH PEDAL RETURN — REPLACE............04-600

K009710 FORK, M/T SHIFT, ANY ONE — REPLACE........................04-090

K009820 BEARING, DIFFERENTIAL SIDE — REPLACE..................05-250

K012100 BEARING ASM. CLUTCH THROWOUT — REPLACE........00-400

K012150 FORK, PIN & DAMPER ASM CLUTCH — REPLACE.........00-400

K013100 COVER/PRESSURE PLATE ASM. — REPLACE (M/.........00-400

K013120 PLATE, CLUTCH DRIVEN — REPLACE (M/T)...................00-400

K013500 BEARING ASM. CLUTCH PILOT — REPLACE (M/T).........00-400

K013600 CYLINDER, CLUTCH SLAVE — REPLACE........................00-430

K013700 CYLINDER, CLUTCH SLAVE — OVERHAUL.....................00-430

K013750 CAP/SEAL, RESERVOIR CLUTCH MASTER CYL—..........00-430

K013800 CYLINDER, CLUTCH MASTER — REPLACE.....................00-430

K013850 RESERVOIR/BRACKET, CLUTCH MASTER CYLIN—.......00-430

K013900 CYLINDER, CLUTCH MASTER — OVERHAUL..................00-430

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

K062500 HOSE, PRESSURE CLUTCH — REPLACE........................00-430

K062550 HOSE, CLUTCH M/CYL TO RESERVOIR —......................00-430

K063500 LINE , PR E S SU R E CLUT C H — REPL A CE........ ............. ... ..00-430

K063550 LINE, PRESSURE HOSE TO SLAVE CYL — .....................00-430

K101100 KNOB, GEAR SELECTOR LEVER — REPLACE (V6.........04-060

K103100 SHIFT CONTROL MECHANISM — R&R/REPLACE...........04-060

K103100 SHIFT CONTROL MECHANISM — R&R/REPLACE...........04-100

K104100 LEVER, GEAR SHIFT CO NTROL — REPLACE (M/T)........04-060

K107500 CABLE, GEARSHIFT CONTROL (ONE/BOTH) —..............04-100

K108000 SHAFT, M/T SHIFT — REPLACE........................................04-125

K108100 FORK, M/T SHIFT, ANY ONE — REPLACE .......................04-125

K108200 GEAR/SYNCHRO ASM. (1ST) — REPLACE......................04-125

K108210 GEAR/SYNCHRO ASM. (2ND) — REPLACE......................04-125

K108220 GEAR/SYNCHRO ASM. (3RD) — REPLACE......................04-125

K108230 GEAR/SYNCHRO ASM. (4TH) — REPLACE......................04-125

K108240 GEAR/SYNCHRO ASM. (5TH) — REPLACE......................04-125

K108250 GEAR/SYNCHRO ASM. (6TH) — REPLACE......................04-125

K108280 GEAR ASM. (REVERSE) — REPLACE...............................04-125

K108300 BEA R IN G A SM. M/T INT ER N A L AN Y ONE —........ ... .... .....04-1 25

K108400 SHAFT ASM. M/T MAIN — REPLACE ................................04-125

K108500 GEAR, COUNTER (CLUSTER) — REPLACE.....................04-125

K108600 SEA L, INPU T SH A F T — REPL A CE ... ... ............ ... ... ............04-125

K108700 BEA R IN G A SM. INP UT SHA FT — REPL AC E............ .... .....04 -1 25

K108800 SHAFT/GEAR, INPUT — REPLACE ...................................04-125

K200100 SEAL, GEARSHIFT TO FLOOR — REPLACE (M/T) ..........04-060

K200200 SEAL, GEARSHIFT CONTROL LOWER — REPLACE.......04-100

K201500 HOUSING ASM. M/T EXTENSION — REPLACE (V6.........04-100

K202100 SEAL EXTENSION HOUSING OIL — REPLACE M/T........04-100

K202500 GEAR, SPEEDOMETER DRIVE — REPLACE M/T............04-125

K203200 COVER/GASKET, GEARSHIFT MECHANISM —...............04-100

K204110 PIPE/HOSE, BREATHER/OIL COLLECTION —.................04-150

K204110 PIPE/HOSE, BREATHER/OIL COLLECTION —.................04-090

K205100 MANUAL TRANS. ASM — R&R/REPLACE.........................04-090

K205110 MAN U AL TRANS. ASM. — R&R/OV E R HAUL................ ... ..04-125

K205170 COVER, MANUAL TRANS CASE — REPLACE .................04-090

K205200 CASE ASM. MANUAL TRANS — REPLACE ......................04-090

K400100 TRANSFER CASE ASSY. — REPLACE .............................04-050

K400110 TRANSFER CASE ASSY. — OVERHAUL ........ ..................04-050

K400140 SEA L, FRONT OUTP U T SHA F T OI L — RE PL A C E............04-050

K400150 SEAL, REAR OUTPUT SHAFT OIL — REPLACE...............04-050

K400150 SEAL/FLANGE, TRANSFER CASE ASSY —......................04-050

K500100 LEV ER AS M. SE L EC T OR (A U TO FLOOR SH IF T ) —.........04-190

K500110 BUTTON, LEVER ASM FLR SHIFT CONTROL...................04-190

K500120 SWITCH — POWER/ECONOMY/OVERDRI V E —... ... .... ... .04-190

K500400 SOLENOID ASM, REVERSE LOCK OUT —.......................04-090

K503100 CABLE, FLOOR SHIFT CONTROL — REPLACE...............04-170

K506100 ROD, SELECTOR CONTROL (AUTO) — REPLACE..........04-170

K508100 SCALE TR A N SMIS S ION CON TR O L — REPL A C E......... ....04 -1 90

K508220 COVER, TRANSMISSION SELECTION CONTROL —.......04-190

K509600 CONTROL UNIT, AUTO TRANSMISSION —......................04-170

K509600 MODULE (TCM), AUTO TRANSMISSION CON—..............02-245

K600100 SERVO PISTON ASM. 2ND APPLY — REPLACE..............04-210

K600150 SERVO PISTON ASM. 4TH APPLY — REPLACE..............04-210

K600320 SWITCH, VALVE BODY FLUID TEMPERATURE —...........04-220

K600500 AUTO TRANS. OIL PRESSURE — CHECK........................04-200

K600550 BOOT, AUTO TRANSMISSION SELECTOR — R&R/.........04-190

K600600 TRANSMISSION COOLER FLUSH/FLOW CHECK ............04-200

K603000 UNION/PIPE ASM, ONE/BOTH TRANS TO OIL.................04-150

K603000 UNION/PIPE ASM, ONE/BOTH TRANS TO OIL.................04-200

K603100 HOSE/PIPE ASM. OIL COOLER TO TRANS ......................04-150

K603150 PIPE ASM, TRA NS MIS S ION COOLER — REP LAC E..... ....04-1 50

K603200 HOSE/PIPE ASM. TRANS TO OIL COOLER (OUT—.........04-150

K604200 TUBE, TRANS. OIL FILLER — REPLACE ..........................04-010

K604300 INDICATOR ASM. AUTO OIL LEVEL — REPLACE............04-010

K604400 COVER, CONVERTER/CLUTCH — REPLACE..................04-010

K604500 BOLT, CONVERTER TO DRIVEPLATE — REPLACE........04-010

K605100 PIPE, OIL COOLER (OUTLET) — REPLACE......................04-150

K605200 HOSE, OIL COOLER (IN L ET ) — REPL A CE.......... ..............04-150

K605300 PIPE, RADIATOR TO TRANS HOSE (INLET) — ................04-150

K605400 PIPE, RADIATOR CROSSOVER — REPLACE...................04-150

K607250 SEAL, VEHICLE SPEED SENDER — REPLACE................04-200

K608100 EXTENSION/ADAPTOR HOUSING/REAR COVER —.......04-200

K608120 BUSH, EXTENSION HOUSING — REPLACE.....................04-200

K608150 SEAL, EXTENSION HOUSING/REAR COVER —...............04-200

K608200 SEAL ASM. EXTENSION/ADAPTOR HOUSING —............04-200

K611100 PAN/GASKET, AUTO TRANS OIL — R&R/REPLACE........04-220

K611200 FILTER/SEAL ASM. AUTO OIL — REPLACE.....................04-220

K700100 AUTO TRANS ASM. — AC DELCO (POLICY .....................04-200

K700500 AUTO TRANS ASM. — R&R ...............................................04-200

K701100 CONVERT E R ASM. — RE PL A C E. ... ... ............ ... ............. ... .04-200

K702100 SEAL, CONVERTER OIL — REPLACE...............................04-200

K703100 OIL PUMP ASM. — R&R/REPLACE....................................04-200

K703156 DIFFERENTIAL ASM. (FWD) — REPLACE ........................05-250

K703170 SEAL/GASKET, OIL PUMP — REPLACE...........................04-200

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

K902300 OIL COOL E R, TRANSMISSI ON — REPL A CE........ ............0 4-150

L001100 FUEL TANK ASM. — R&R/REPLACE.................................03-055

L002100 FILLE R PI PE AS M. FU E L TA N K — REPLA C E...................0 3 - 0 55

L002300 HOSE, FILLER PIPE TO FUEL TANK — REPLACE...........03-055

L004100 STRAP ASM. FUEL TAN K SUPP O RT — REPL A CE..... ... ..03-055

L006200 DOOR ASM. FUEL TANK FILLER — REPLACE.................03-028

L006220 LATCH/A C T UATOR ASM. FILLE R DOOR........ ... ............. ..03-028

L006300 SENDER UNIT, FUEL LEVEL — R&R/REPLACE...............03-074

L006310 SEAL, MODULA R A SM. TO FUE L TA N K —.. ... ... ...............03-074

L006320 STRAINER, FUEL PIC KU P — REPLA C E ............... ... .........0 3-074

L006330 MODULAR PU MP & SE N D ER UN IT AS M . —......... ............03-074

L006340 RETAINER, MODULAR ASM TO FUEL TANK —...............03-074

L006350 PUMP, FUEL (INTERNAL) — REPLACE ............................03-074

L006360 SECONDARY MODULAR PUMP & SENDER UNIT............03-074

L006400 CAP ASM. FUEL TANK FILLER — REPLACE....................03-055

L008100 FUEL HOSE (TANK AREA) ANY — REPLACE...................03-165

L010100 PIPE, FUEL TANK TO ENGINE — REPLACE ....................03-075

L010500 FUEL FILT E R — REPL A C E.......... ... ............ ... ... ............. ... ..03-075

L011100 PIPE, FUEL TANK TO VAPOUR CANISTER —..................03-075

L013100 SOLENOID/VALVE, CANISTER PURGE —........................03-165

L014100 CANISTER, CHARCOAL — REPLACE...............................03-165

L501100 GASKET/SEALING RING, (ANY) — REPLACE..................03-750

L503100 PIPE/MUFFL E R A SM. EXH A U ST INT E R IM —. ... ... ............0 3 -750

L503500 MUFFL E R /T AI L PI PE ASM. EXHA US T — REPLA C E.........0 3 - 7 50

L503510 MUFFL E R /T AI L PI PE ASM. EXHA US T — REPLA C E.........0 3 - 7 50

L504100 ENGINE PIPE/CATALYTIC CONVERTER (LH) —..............03-750

L504150 ENGINE PIPE/CATALYTIC CONVERTER, (ONE...............03-750

L504200 ENGINE PIPE/CATALYTIC CONVERTER (RH) —.............03-750

L509500 HEATSHIELD, INTERMEDIATE MUFFLER (RH) —...........03-750

L509600 HEATSHIELD, INTERMEDIATE MUFFLER —....................03-750

L509700 HEATSHIELD, REAR MUFFLER — REPLACE...................03-750

L509710 HEATSHIELD, REAR MUFFLER — REPLACE R/H ...........03-750

L512210 INSULATOR, INTERMEDIATE EXHAUST PIPE.................03-750

L512220 HANGER/BRACKET {EXHAUST} — REPLACE .................03-750

L512230 INSULATOR, EXHAUST TAIL PIPE SUPPORT —.............03-750

L512240 INSULATOR, FRONT PIPE SUPPORT — REPLACE.........03-750

L700300 ELBOW INLET NO. 8—5 — REPLACE...............................AA-650R

L700400 MIXER — REPLACE............................................................AA-650Q

L700500 CONTROL VALVE LPG — REPLACE.................................AA-650R

L700600 CONVERT E R — REPL A CE............. ... ... ... ............... ............A A -6 5 0Q

L700800 SERVIC E LINE ENGINE BA Y — REPL A CE ........... ... .........AA -6 5 0Q

L700900 HOSE VAPOUR FEED LINE LPG — REPLACE.................AA-650R

L701010 SENSOR, P1/MAP — REPLACE.........................................AA-650Q

L701020 HOSE, P1 SENSOR — REPLACE ......................................AA-650Q

L701030 VALVE, FRONT GAS LOCK OFF — REPLACE..................AA-650Q

L701040 HOSE, LPG INJECTOR — REPLACE.................................AA-650Q

L701050 INJECTOR ASM, LPG — REPLACE...................................AA-650Q

L701060 RAIL ASM, LPG INJECTOR — REPLACE RH OR LH........AA-650Q

L701070 FILTER ASM, LPG VAPOUR — REPLACE.........................AA-650Q

L701100 CONVERTER COOLANT PIPES — REPLACE...................AA-650Q

L701200 FLOOR FLANGE — REPLACE ...........................................AA-650Q

L701250 VALVE, FUEL CONTROL — REPLACE..............................AA-650Q

L701300 LPG CYLINDER — REPLACE.............................................AA-650Q

L701400 VALVE ASSEMBLY, ANTI THEFT — REPLACE.................AA-650R

L701450 AUTO FILL LIMITER VALVE — REPLACE .........................AA-650Q

L701500 SENDER UNIT LPG — REPLACE.......................................AA-650R

L701550 MEMCAL ASM. (ECM/PCM) LP G — REPLA C E..................02-245

L701550 MEMCAL ASM (LPG) — REPLACE ....................................AA-650Q

L701600 CONTENTS GAUGE LPG — REPLACE.............................AA-650R

L701700 FUEL GAUGE INTERFACE OR RELAY — REPLACE........AA-650Q

L701800 SERVICE LINE REAR — REPLACE ...................................AA-650Q

L701900 SERVICE LI N E FRON T — REPL A CE.......... ... ................ ....AA-6 5 0Q

L702000 FILLER BOX/V A L VE , LP G — REPL AC E.................. ... ........AA-650R

L702100 HOSE, LPG FILLER — REPLACE.......................................AA-650R

L702200 HOSE LPG SERVICE — REPLACE....................................AA-650R

L702300 ELBOW NO. 8 LPG — REPLACE........................................AA-650R

L702400 FILLER HOSE VENT TUBE — REPLACE...........................AA-650Q

L702500 SERVICE HOSE VENT TUBE — REPLACE.......................AA-650Q

L790000 LPG ENGINE HARNESS — REPLACE...............................AA-650Q

L790100 LPG BODY HARNESS — REPLACE ..................................AA-650Q

L790200 PROCESSOR, DIGITAL ADAPTIVE — REPLACE..............AA-650Q

L790300 SMART UNIT AS M. — REPL A CE ................ ... ... ............. ... .AA-650R

L790500 FUEL CHANGE OVER SWIT C H — REPL A CE ........... .... ... .AA-650Q

M001500 WHEEL ASM. STEERING — REPLACE.............................06-225

M012510 SWITCH HOUSING/BEARING SUPPORT ASM. —............06-255

M013500 SHAFT, COUPLING ASM STEERING INTERMEDI—.........06-275

M015300 LEVER ASM, TILT STEERING — REPLACE......................06-253

M018100 COVER, STEERING COLUMN UPPER — REPLACE........06-250

M018150 COVER, STEERING COLUMN LOWER — REPLACE.......06-250

M018200 BOOT /S EAL , ST EE RI NG COLU MN TO FL OOR — . ... ........06-253

M019100 STEERING COLUMN ASM. COMPLETE — R&R/..............06-253

M035000 ROD , ST E E RI NG TI E — REPL A CE BOT H SID ES............. .06-310

M035010 SOCKET ASM. TIE ROD LH — REPLACE..........................06-310

M035020 SOCKET ASM. TIE ROD RH — REPLACE.........................06-310

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

M035110 ROD, STEERING TIE RH — REPLACE..............................06-310

M035210 ROD, STEERING TIE LH — REPLACE...............................06-310

M036200 RACK PAD, STEERING GEAR — CHECK & ADJUST.......06-275

M037000 BELLOW, TIE ROD END — REPLACE BOTH SIDES........06-310

M037100 BELLOW, TIE ROD END RH — REPLACE.........................06-310

M037200 BELLOW, TIE ROD END LH — REPLACE .........................06-310

M041000 GEAR ASM. POWER STEERING — R&R/REPLACE.........06-275

M041010 GEAR ASM. POWER STEERING — R&R/OVER—............06-275

M041100 HOUSING ASM. — REPLACE.............................................06-310

M042500 BELT, P/S PUMP — REPLACE...........................................01-003

M043100 PULLEY, POWER STEE R IN G P UMP — REP L ACE...........06-4 00

M044300 COOLER, POWER STEERING — REPLACE.....................06-400

M044400 HOSE, POWER STEERING COOLER — REPL ACE........ ..06-400

M048000 HOSE, RETURN — REPLACE............................................06-400

M048100 BRACKET/BUSHING, POWER STEERING PUMP.............06-400

M048200 PIPE & HOSE, PRESSURE — REPLACE...........................06-400

M048300 CAP, POWER STEERING PUMP RESERVOIR —.............06-400

M048400 PIPE & HOSE, STEERING RACK TO RETURN .................06-400

M048500 HOSE/PIPE, RESERVOIR TO PUMP — REPLACE...........06-400

M048600 "O" RING, ANY/ALL — REPLACE.......................................06-400

M048700 CLAMP, POWER STEERING HOSE ANY/ALL —...............06-400

M050500 RESERVOIR ASM. POWER STEERING — R&R/ ..............06-400

M130150 PINION & BEARING ASM. STEERING — REPLACE.........06-310

M144000 PIPE, FEED HY DR A ULIC ANY ONE — REPLA C E ... .... ... ..06-310

M147000 PUMP ASM/SUPPLY UNIT, POWER STEERING —..........06-400

M147100 SEAL, PUMP ASM POWER STEERING — REPLACE.......06-400

M147200 VALVE ASM. POWER STEERING — REPLACE................06-310

M147500 PUMP ASM. POWER STEERING — R&R/OVER— ...........06-400

M200100 AIR BAG UNIT, DRIVER SRS — REPLACE.......................06-225

M200200 COIL, SRS AIR BAG — REPLAC E........... ...........................06-225

M200300 AIR BAG UNIT, PASSENGER SRS — REPLACE ..............06-225

N000333 BATTERY REPLACEMENT — CENTURY YUASA.............02-200

N000500 BATTERY ASM. — REPLACE.............................................02-200

N000550 BATTERY ASM. — TEST & RECHARGE............................02-200

N001700 STRAP ASM. EARTH ENGINE TO BODY — REPAIR/.......02-180

N001710 STRAP ASM. HOOD TO BODY — REPAIR/.......................02-180

N001720 STRAP AS M. EA R TH COC K PIT TO BODY —........... .... .....02-1 80

N001760 FUSIBLE LINK, (30 AMP BOLT IN) — REPLACE...............02-250

N001790 CIRCUIT BREAKER, MAIN WIRING HARNESS.................02-425

N001810 RELAY, A/C — REPLACE ...................................................02-250

N001820 RELAY, HORN — REPLACE...............................................02-250

N001830 RELAY, FUEL PUMP — REPLACE.....................................02-250

N001840 RELAY, ENGINE COOLING FAN (HIGH) — .......................02-250

N001860 RELAY, ANTI TH E F T SY S TE M — REP L AC E............. .... ....02 -2 50

N001870 FUSIBLE LINK, (40 AMP PU S H IN) — REP L AC E....... ........02-250

N001880 RELAY, HEADLAMP LOW BEAM — REPLACE.................02-250

N001890 RELAY, STARTER — REPLACE.........................................02-250

N001900 RELAY ASM. HE ATED REAR WINDOW —.......... ..............02-425

N001930 RELAY, POWER WINDOW — REPLACE...........................02-425

N001960 RELAY, BLOWER MOTOR — REPLACE............................02-250

N001960 RELAY, BLOWER MOTOR — REPLACE............................02-425

N001980 RELAY, ENGINE COOLING FAN (LOW) —........................02-250

N001990 RELAY, PARK LAMPS — REPLACE ..................................02-425

N002000 RELAY, DRIVER WINDOW — REPLACE...........................02-425

N002100 RELAY, ENGINE CONTROL — REPLACE.........................02-250

N002110 RELAY, HEADLAMP HIGH BEAM — REPLACE.................02-250

N002120 RELAY, AUTO LEVEL CONTROL — REPLACE.................02-250

N002150 RELAY, FRONT WINDSCREEN WIPER — REPLACE.......02-250

N002200 HOUSING, RELAY & FUSE — REPLACE...........................02-250

N002250 COVER, RELAY & FUSE HOUSING — REPLACE.............02-250

N002300 HOUSING, FUSIBLE LINK — REPLACE ............................02-250

N002350 RELAY, BLOWER MOTOR INHIBITOR — REPLACE........02-425

N002400 RELAY ASM. RE A R WINDS CR E E N WIP ER —....... ... ........02-425

N002450 RELAY ASM. LP G — REPL AC E ..................... ... ... ............. .02-425

N002455 RELAY ASM. REVERSE LIGHT — REPLACE....................02-425

N002500 CLAMP, BATTERY — REPLACE........................................02-200

N003500 TRAY OR SUPPORT, BATTERY — REPLACE ..................02-200

N008000 FOG LAMP, BOTH FRONT — REPLACE...........................02-325

N008010 FOG LAMP, RH FRONT — REPLACE................................02-325

N008020 FOG LAMP, LH FRONT — REPLACE.................................02-325

N104100 HEADLAMP ASM. RH — REPLACE ...................................02-300

N104150 MODULE, HEADLIGHTS ON WITH IGNITION —...............02-510

N104200 HEADLAMP ASM. LH — REPLACE....................................02-300

N104230 BULB HOLDER, TURN SIGNAL LAMP RH —.....................02-300

N104240 BULB HOLDER, TURN SIGNAL LAMP LH —.....................02-300

N104270 BULB, PARK LAMP LH — REPLACE..................................02-300

N104280 BULB, HIGH MOUNTED STOP LAMP — REPLACE..........02-350

N104290 BULB, REAR LICENCE PLATE LAMP— REPLACE...........02-375

N104290 BULB, REAR LICENCE PLATE LAMP— REPLACE...........02-385

N104300 BULB, PARK LAMP RH — REPLACE.................................02-300

N104310 BULB, 12V 55W DRIVING LAMP RH — REPLACE............02-300

N104320 BULB, 12V 55W DRIVING LAMP LH — REPLACE.............02-300

N104330 BULB, TURN SIGNAL LAMP LH — REPLACE...................02-300

N104340 BULB, 12V 55/60W HEADLAMP RH — REPLACE.............02-300

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

N104350 BULB, TURN SIGNAL LAMP RH — REPLACE...................02-300

N104360 BULB/HOLDER, FRONT SIDE T/S LAMP RH —................02-300

N104370 BULB, DECKLID TAIL LAMP — REPLACE.........................02-375

N104380 BULB, BACK UP LAMP — REPLACE.................................02-375

N104400 BULB, LH STOP/TAIL/TURN/REV — REPLACE ANY/.......02-350

N104410 BULB, FRONT FOG LAMP — REPLACE............................02-325

N104420 BULB, VEHICLE INTERIOR — REPLACE..........................02-780

N104440 BULB, 12V 55/60W HEADLAMP LH — REPLACE..............02-300

N104450 BULB/HOLDER, FRONT SIDE T/S LAMP LH —.................02-300

N104460 DUST CAP/O RING, HEADLAMP BULB RH —...................02-300

N104470 DUST CAP/O RING, HEADLAMP BULB LH —...................02-300

N104480 DUST CAP/O RING, DRIVING LIGHT BULB RH —............02-300

N104490 DUST CAP/O RING, DRIVING LIGHT BULB LH — ............02-300

N104500 BULB, RH STOP/TAIL/TURN/REV — REPLACE ANY/......02-350

N104510 FUSIB LE LIN K , (6 0 AMP PUS H IN ) — REPL AC E ............ ..02-250

N104520 FUSIB LE LIN K , (3 0 AMP PUS H IN ) — REPL AC E ............ ..02-250

N104530 FUSIBLE LINK, (60 AMP BOLT IN) — REPLACE...............02-250

N104600 RELAY, FOG LAMP (FRONT) — REPLACE.......................02-250

N112400 COVER, DOME LAMP — REPLACE...................................02-780

N112500 LAMP ASM. DOME — REPLACE........................................02-780

N112510 LAMP ASM. REAR COMPARTMENT — REPLACE ...........02-780

N112600 LAMP ASM. RH REAR — REPLACE ..................................02-780

N112700 LAMP ASM. LH REAR — REPLACE...................................02-780

N117500 FLASHER/RELAY ASM. TURN SIGNAL/HAZARD .............02-425

N118300 LAMP ASM. SIDE T/S RH — REPLACE .............................02-300

N118400 LAMP ASM. SIDE T/S LH — REPLACE..............................02-300

N122100 LAMP & LENS, REAR RH — REPLACE .............................02-350

N122200 LAMP & LENS, REAR LH — REPLACE..............................02-350

N124000 DECKLID PANEL/LAMP ASM. (ONE PIECE) —.................02-375

N126500 LAMP ASM. REAR LICENCE — REPLACE........................02-385

N126500 LAMP ASM. REAR LICENCE — REPLACE........................02-375

N200500 HORN & BRACKET ASM. (R/H 1 OR 2) — REPLACE .......02-400

N200550 HORN & BRACKET ASM. (L/H) — REPLACE ....................02-400

N200600 HORN & BRACKET ASM. ANTI THE FT — REPLACE........09-540

N200600 HORN & BRACKET ASM. ANTI THE FT — REPLACE........09-552

N202600 SWITCH/LEVER, TURN SIGNAL & HEADLAMP................06-250

N203000 SWITCH/LEVER, WIN DSHIELD WIPER WASHER —........06-250

N206500 SWITCH /H A RN E S S AS M. NE U T RA L STA R T —................0 4 - 1 70

N207500 SWITCH, ST OP LI GHT /C R UI S E CON T ROL —... ... ............04-600

N207550 SWITCH, CRUISE CONTROL (CLUTCH) —.......................04-600

N208500 SWITCH , PA R K BR A K E WAR N IN G LAMP —............ .... ... ..04-675

N209500 SWITCH, REVERSE LIGHT — REPLACE..........................04-075

N212500 SWITCH, DOME LAMP/DOOR AJAR RH FRT —...............02-780

N212510 SWITCH, DOME LAMP/DOOR AJAR LH FRT —................02-780

N212520 SWITCH, DOME LAMP/DOOR AJAR RH REAR —............02-780

N212530 SWITCH, DOME LAMP/DOOR AJAR LH REAR —.............02-780

N214500 LAMP ASM. GLOVE BOX — REPLACE..............................02-780

N214600 SWITCH, GLOVE BOX LAMP — REPLACE.......................02-780

N216500 SWITCH, REAR COMPARTMENT LAMP —.......................02-780

N216550 SWITCH, ANTI THEFT HOOD ACTUATOR —....................09-552

N218500 SWITCH, HEADLAMP — REPLACE...................................02-800

N220600 SWITCH, HAZARD WARNING — REPLACE......................02-800

N220900 SWITCH, TRACTION CONTROL — REPLACE..................04-190

N220950 SWITCH — LPG/UL P CH A N GE OV E R — REPLA C E..... ... .04-190

N221000 BULB, SHIFT CONTROL — REPLACE...............................04-190

N221320 SENSOR, YAW RAT E /A CC E L ER ATION (ES P) —............. .04-730

N221330 SENSOR, ACCELEROMETER BRAKE CONTROL............04-730

N221925 SENSOR, RAIN — REPLACE .............................................10-505

N221970 BULB, INSTRUMENT CLUSTER — REPLACE ONE/.........09-100

N221970 BULB, INSTRUMENT CLUSTER — REPLACE ONE/.........09-120

N221990 BULB, HEATER CONTROL — REPLACE ONE/ALL...........08-155A

N226000 SWITCH ASM. (CONSO LE) WINDOW LIFTER ALL —.......02-775

N227100 WINDOW RE GU LAT O R MOT OR /C ABL E ASM. RH...........11-675

N227150 MOTOR, WINDOW REGULATOR FRONT RH —...............11-675

N227200 WINDOW RE GU LAT O R MOT OR /C ABL E ASM. LH. ... .... ... .11-675

N227250 MOTOR, WINDOW REGULATOR FRONT LH —................11-675

N229100 MOTOR, WINDOW REGULATOR REAR RH —.................11-810

N229150 WINDOW REGULATOR/MOTOR ASM. RH REAR.............11-810

N229200 MOTOR, WINDOW REGULATOR REAR LH —..................11-810

N229250 WINDOW REGULATOR/MOTOR ASM. LH REAR..............11-810

N230000 SWITCH, WINDOW LIFTER BOTH REAR DOORS —........02-775

N230100 SWITCH, WINDOW LIFTER RH REAR DOOR —...............02-775

N230200 SWITCH, WINDOW LIFTER LH REAR DOOR — ...............02-775

N240150 SWITCH, ELECTRIC FRONT DOOR LOCK RH —.............11-360

N240200 SWITCH/HARNESS, MIRROR ADJUSTMENT —...............02-775

N242100 ACTUATOR ASM. DOOR CENTRAL LOCKING RH...........11-360

N242200 ACTUATOR ASM. DOOR CENTRAL LOCKING LH............11-360

N243100 ACTUATOR ASM. DOOR CENTRAL LOCKING RH...........11-725

N243200 ACTUATOR ASM. DOOR CENTRAL LOCKING LH............11-725

N253300 SWITCH, REAR COMPARTMENT LOCK RELEASE..........02-775

N253300 SWITCH, REAR COMPARTMENT LOCK RELEASE..........12-680

N253400 ACTUATOR ASM, DECK LID/TAILGATE/HATCH...............12-680

N264000 SWITCH/MODULE ASM. ELECTRIC SEAT MEM—...........14-275

N264100 SWITCH, ELECTRIC SEAT LH — REPLACE.....................14-275

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

N264200 SWITCH, ELECTRIC SEAT RH — REPLACE.....................14-275

N264300 KNOB, SEAT ADJUSTER SWITCH RH — REPLACE........14-275

N264400 KNOB, SEAT ADJUSTER SWITCH LH — REPLACE.........14-275

N264500 KNOB, BACK REST ADJUSTER SWITCH RH —...............14-275

N264600 KNOB, BACK REST ADJUSTER SWITCH LH —................14-275

N264700 MODULE, RH FR ON T SEA T/ M IR ROR POS IT ION .............14-275

N264800 MODULE, EZY ENTRY RH — REPLACE ...........................14-275

N264900 MODULE, EZY ENTRY LH — REPLACE............................14-275

N300100 GAUGE ASM, INCLINOMETER — REPLACE....................09-125

N300500 SPEEDOMETER ASM — R&R/REPLACE..........................09-120

N300600 LENS/MASK, INSTRUMENT CLUSTER — REPLACE.......09-100

N300600 LENS/MASK, INSTRUMENT CLUSTER — REPLACE.......09-120

N301500 GAUGE, FUEL INSTRUMENT — REPLACE ......................09-120

N303500 GAUGE ASM, OIL PRESSURE — REPLACE.....................09-125

N306500 GAUGE, TEMPERATURE (DASH UNIT) —........................09-120

N307500 GAUGE ASM, VOLTMETER — REPLACE .........................09-125

N308500 CLOCK (DIGIT A L/AN A LOGU E) — REP L AC E .. ................ ..09-120

N308700 SWITCH/SENSOR, THROTTLE POSITION — ...................03-300

N308800 SENSOR ASM. MASS AIR FLOW — REPLACE.................03-250

N309500 PRINT E D CIRCUIT BOA RD , IN S TR U ME N T —............. ... ..09-120

N310500 TACHOMETER — REPLACE..............................................09-120

N311600 PLUNGER & KNOB, CIGAR LIGHTER — REPLACE.........14-900

N311600 PLUNGER/KNOB, CIGAR LIGHTER — REPLACE.............09-300

N311650 CIGAR LIGHTER & WIRING ASM. (COMPLETE) —..........09-300

N311650 CIGAR LIGHTER & WIRING ASM. (COMPLETE) —..........14-900

N311700 SOCKET, ACCESSORY POWER SUPPLY —....................09-300

N311700 SOCKET, ACCESSORY POWER SUPPLY —....................14-900

N311800 SOCKET, ACCESSORY POWER SUPPLY —....................14-480

N312500 CYLINDER ASM. IGNITION LOCK — REPLACE ...............06-255

N312600 INSTR UMEN T CLU S TE R — REPLA CE......... ... ... ... ............09-100

N312700 INSTRUMEN T C LUS TE R — REPR OGR A M..... ................ ..09-100

N313500 SWITCH, IGNITION — REPLACE.......................................06-255

N313600 SLIP RING, KEY READER — REPLACE............................06-255

N316650 SENDER ASM. VEHICLE SPEED — REPLACE.................04-075

N316650 SENDER ASM. VEHICLE SPEED — REPLACE.................04-200

N317500 SENSOR ASM. COOLANT TEMP GAUGE —.....................02-000

N317510 SENSOR ASM. COOLANT TEMP ECM — REPLACE........02-000

N317600 SENSOR ASM, AMBIENT TEMP — REPLACE..................08-200

N317650 SENSOR ASM, INSIDE AIR TEMP — R&R/REPLAC E.......08-200

N317700 RECEIV ER, R EMOT E KEY SIGNA L — REPL A C E........ .....09-125

N317700 SENSOR ASM, SUN — REPLACE......................................08-155A

N317700 RECEIV ER, R EMOT E KEY SIGNA L — REPL A C E........ .....06-255

N318500 SENSOR ASM. OIL PRESSURE — REPLACE...................01-500

N319000 LAMP, DOOR COURTESY RH FRONT — REPLACE........02-780

N319100 LAMP, DOOR COURTESY LH FRONT — REPLACE.........02-780

N319200 LAMP, DOOR COURTESY RH REAR — REPLACE...........02-780

N319300 LAMP, DOOR COURTESY LH REAR — REPLACE...........02-780

N326500 MULTI FUNCTION/INFORMATION DISPLAY —................09-100

N351000 LINKAGE ASM. WINDSHIELD WIPER BOTH SIDES.........10-506

N351100 LINKAGE ASM. WINDSHIELD WIPER RH —.....................10-506

N351200 LINKAGE ASM. WINDSHIELD WIPER LH —......................10-506

N351500 MOTOR ASM. WINDSHIELD WIPER — REPLACE............10-506

N354500 PUMP ASM. WINDSHIELD WASHER — REPLACE...........10-500

N355500 VALVE ASM. NON RETURN WINDSHIELD........................10-500

N356000 BLADE ASM. WIN DSHIELD WIPER (1 OR 2) —.. ... ... ........10-505

N356100 ARM ASM. WINDSHIELD WIPER (1 OR 2) —....................10-505

N357000 NOZZLE ASM. WINDSHIELD WASHER (1 OR 2) —..........10-500

N357100 HOSE, WINDSHIELD WASHER ENGINE BAY...................10-500

N357200 HOSE, RESERVOIR TO TAILGATE/HATCH —..................10-500

N358500 RESERVOIR ASM. WINDSHIELD/HEADLAMP..................10-500

N358600 CAP, WINDSHIELD WASHER RESERVOIR —..................10-500

N359700 RELAY, IGNITION — REPLACE .........................................02-425

N401900 CURTAI N AIRBAG HARN E S S — REPLACE BOTH ... ........06-225

N408599 HARNESS , RE S IS T OR BL OWER & CON T ROL —.............08-150

N413599 FUSE PANEL, MAIN HARNESS — REPLACE....................02-425

N414505 FUSE 5 AMP — REPLACE..................................................02-425

N414510 FUSE 10 AMP — REPLACE................................................02-250

N414510 FUSE 10 AMP — REPLACE................................................02-425

N414515 FUSE 15 AMP — REPLACE................................................02-250

N414515 FUSE 15 AMP — REPLACE................................................02-425

N414520 FUSE 20 AMP — REPLACE................................................02-250

N414520 FUSE 20 AMP — REPLACE................................................02-425

N414525 FUSE 25 AMP — REPLACE................................................02-250

N414525 FUSE 25 AMP — REPLACE................................................02-425

N414535 RELAY, INTERIOR LAMP — REPLACE .............................02-425

N414575 FUSE 7.5 AMP — REPLACE...............................................02-425

N414600 CIRCUIT BREAKER, MAIN WIRING HARNESS.................02-425

N446000 CONTROL UNIT, TELEMATICS — REPLACE....................09-540

N446100 BATTERY, TELEMATICS CONTROL UNIT —....................09-540

N446200 SPEAKER, TELEMATICS — REPLACE....... .......................09-540

N446300 ANTENNA, TELEMATICS — REPLACE..............................09-540

N482699 HARNESS ASM. TRANS. EXTERNAL — REPLACE..........04-075

N482699 HARNESS ASM. TRANS EXTERNAL — REPLACE...........04-170

N501600 REMOTE KEY HEAD — REPLACE ONE/BOTH.................06-255

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

N501650 SHAFT, RE MOT E KE Y — REPL AC E....... ... ............ ... .........06 -2 55

N501675 SCREWS, REMOTE KEY HEAD TO SHAFT —..................06-255

N506450 MODULE, INTERIOR LAMP CONTROL — REPLACE.......02-275

N506590 MODULE (BCM), BODY CONTROL — REPROGRAM.......02-275

N506600 MODULE (BCM), BODY CONTROL — REPLACE..............02-275

N506650 MODULE (BCM), BODY CONTROL — ...............................02-275

N506700 CONTROL UNIT/MODULE, (ABS) — REPLACE................04-730

N506800 MODULE, S RS AIR BA G — REPL AC E.......... .....................06 -2 25

N506900 SENSOR, PERIPHERAL ACCELERATION RH —..............06-225

N506950 SENSOR, PERIPHERAL ACCELERATION LH — ..............06-225

N526010 SWITCH ASM. SUNROOF OPENING — REPAIR/.............02-775

N526050 SWITCH ASM. VEHICLE STABILITY/PITCH CON—..........02-775

N705000 NOZZLE, HEADLAMP — REPLACE R/H............................02-300

N705010 NOZZLE, HEADLAMP — REPLACE L/H.............................02-300

N752000 MOTOR ASM. TAILGATE/HATCH WINDOW WIPER.........10-525

N752050 MODULE, REAR WIPER MOTOR — REPLACE.................10-525

N752100 ARM ASM. TAILGATE/HATCH WIPER — REPLACE.........10-525

N752200 BLADE AS M. TA IL GA TE /H A TCH WIPE R —..................... ..10-525

N755000 NOZZLE, TAILGATE/HATCH WINDOW WIPER — ............10-500

N758500 HOSE, TAILGATE/HATCH WINDOW WASHER — ............10-500

N761700 SWITCH, FRONT FOG LAMPS — REPLACE.....................02-800

N764300 RECEIVER/MONITOR, TYRE PRESSURE —....................02-275

N770000 SENSOR, REVERSE PARKING AID — REPLACE.............07-525

N770100 MODULE/CONTROL UNIT, REVERSE PARKING..............07-525

N770150 SENSOR, FRONT PARKING AID — REPLACE (ONE/......07-500

N770160 SWITCH, FRONT PARK ASSIST — REPLACE..................07-500

N770200 SPEAKER, REVERSE PARKING AID — REPLACE...........07-525

N780050 SWITCH, BLUETOOTH — REPLACE.................................09-515

N780055 MODULE, BLU E TOOT H — REPL A C E........... ... ... ...............09-515

N780060 MICROPH ONE , BL U ET OOTH — REPLA CE ............. .........09-5 15

N780100 DVD PLAYER — R&R/REPLACE........................................09-515

N780110 LEAD C ABL E, DVD PLAY ER — R&R /R E P LACE.... ... .... .....09-5 15

N780120 MODULATOR, DVD FM — REPLACE ................................09-515

N780150 DVD PLAYER — REPROGRAM..........................................09-515

N780200 SCREEN, DVD RH — REPLACE ........................................09-515

N780250 PCB, DVD SCREEN RH — REPLACE................................09-515

N780300 SCREEN, DVD LH — REPLACE.........................................09-515

N780350 PCB, DVD SCREEN LH — REPLACE.................................09-515

N780400 MODULE, D VD INT E R FAC E — RE PL A C E....... ... ... ............0 9 -515

N780500 MODULE, DVD SPLITTER — REPLACE............................09-515

N780600 REMOTE CONTROL, DVD PLAYER — REPLACE ............09-515

N780650 BATTERY , DV D REMOT E CON T ROL — REPL AC E..... ... ..09-515

N833000 MODULE, TRIP COMPUTER — REPLACE........................09-120

N833100 SWITCH, TRIP COMPUTER/OVER SPEED —...................02-800

P001120 DOOR ASM. RH FRONT — ALIGN.....................................12-460

P001220 DOOR ASM. LH FRONT — ALIGN......................................12-460

P001320 DOOR ASM. REAR RH — ALIGN .......................................12-460

P001420 DOOR ASM. REAR LH — ALIGN........................................12-460

P002100 TAILGATE OR HATCH ASM. — ALIGN..............................12-685

P002100 TAILGATE OR HATCH ASM. — ALIGN..............................12-500

P003100 ENGINE HOOD — ALIGN....................................................12-425

P003900 DECK LID ASM. — ALIGN...................................................12-660

P006100 BUMPER BAR ASM FRONT — ADJUST............................07-500

P006900 BUMPER BAR ASM. REAR — ADJUST..............................07-525

P008100 GLASS ASM. RH FRONT DOOR DROP WINDOW —........11-020

P008100 GLASS ASM. RH FRONT DOOR DROP WINDOW —........11-030

P008100 GLASS ASM. RH FRONT DOOR DROP WINDOW —........11-025

P008200 GLASS ASM. LH FRONT DOOR DROP WINDOW —........11-030

P008200 GLASS ASM. LH FRONT DOOR DROP WINDOW —........11-025

P008200 GLASS ASM. LH FRONT DOOR DROP WINDOW —........11-020

P008500 GLASS ASM. RH REAR DOOR DROP WINDOW —..........11-020

P008500 GLASS ASM. RH REAR DOOR DROP WINDOW —..........11-030

P008600 GLASS ASM. LH REAR DOOR DRO P WIN D OW —.......... .11-020

P008600 GLASS ASM. LH REAR DOOR DRO P WIN D OW —.......... .11-030

P101100 CONTROL CABLES, TEMP & DIRECTIONAL —................08-150

P201120 WHEEL ALIGNMENT — CHECK & ADJUST ......................06-200

P201120 WHEEL ALIGNMENT — CHECK & ADJUST ......................06-212

P201120 WHEEL ALIGNMENT — CHECK & ADJUST ......................06-275

P207000 WHEEL BALANCE, ALL WHEELS ......................................05-800

P207100 WHEEL BALAN CE, FR ON T WHE E LS.................................05-800

P207200 WHEEL BALANCE, REAR WHEELS...................................05-800

R005300 COVER ASM. INNER WINDOW FRAME RH —..................10-400

R005400 COVER ASM. INNER WINDOW FRAME LH —..................10-400

R005500 MIRROR ASM. EXTERIOR REAR VISION RH —...............10-400

R005510 LAMP/GLOBE ASM, PUDDLE — REPLACE R/H................10-400

R005600 MIRROR ASM. EXTERIOR REAR VISION LH —................10-400

R005610 LAMP/GLOBE ASM, PUDDLE — REPLACE L/H................10-400

R005700 MIRROR, VANITY RH REAR — REPLACE.........................14-025

R005800 MIRROR, VANITY LH REAR — REPLACE.........................14-025

R006120 MIRROR FACE, RH EXT REA R VISION — REPLACE.......10-400

R006220 MIRROR FACE, LH EXT REAR VISION — REPLACE.......10-400

R100100 LUGGAGE RACK, RAILS/CROSS OVERS (ROOF) —.......AA-005

R100200 MATS, FLOOR — REPLACE...............................................AA-005

R100500 DEFLECTOR/SPOILER, ROOF — REPLACE.....................AA-005

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

R200100 ANTENNA & LEAD ASM. (MANUAL) — REPLACE............09-400

R200150 LEAD ASM. A NTE NN A — REPL ACE. ... ............ ... ............. ..09-400

R200200 ANTEN N A ROD (MA ST) — RE PL A CE........... ............ .... .....09-4 00

R200300 ANTENNA & LEAD ASM. (ELECTRIC) — R&R/ .................09-400

R201000 AMPLIF IE R & LE A D , DIV E R SI TY /S C REEN... ............ .... .....09 -4 00

R201600 SWITCH, TRANSMISSION SHIFT STEERING...................06-225

R205500 RADIO CD PLAYER — REPLACE ......................................09-440

R205510 RADIO CD PLAYER — DUAL HANDLING..........................09-440

R205520 RADIO CONTROLS, HORN BAR — R&R/REPLACE.........09-440

R205520 RADIO CONTROLS, HORN BAR — REPLACE..................06-225

R205530 RADIO REMOTE CONTROL MODULE — REPLACE........09-440

R205540 RADIO CD PLAYER — REPAIR (BY DEALER)..................09-440

R205560 CONTROL ASM, RADIO & HEATER — REPLACE ............09-440

R205600 RADIO CONTROL ASM. REAR SEAT REMOTE — ...........09-500

R205650 COMPACT DISC PLAYER/CHANGER — REPLACE .........09-515

R205655 LEAD/ C AB L E, CO MPA C T D IS C PL A Y ER/........... ............. ..09-515

R205700 AMPLIF IE R, AUDIO SYSTEM — R&R/ RE P LAC E ............ ..09-515

R211100 SPEAKER ASM. FRONT DASH/DOOR HANDLE...............09-500

R211150 SPEAKER ASM. FRONT DASH/DOOR HANDLE...............09-500

R211160 SPEAKER ASM. FRONT DASH CENTRE...........................09-500

R211200 COVER, SPEAKER FRONT DOOR TRIM RH —................14-220

R211300 COVER, SPEAKER FRONT DOOR TRIM LH — .................14-220

R211400 SPEAKER & GRILLE ASM. RH ROOF MOUNTE D —........09-500

R211500 SPEAKER & GRILLE ASM. LH ROOF MOUNTED —.........09-500

R211600 SPEAKER ASM. RH FRONT DOOR MOUNTED —............09-500

R211650 SPEAKER ASM. REAR RH DOOR 1/4 PANEL...................09-500

R211700 SPEAKER ASM. LH FRONT DOOR MOUNTED —............09-500

R211750 SPEAKER ASM. REAR LH DOOR 1/4 PANEL....................09-500

R211800 COVER SPEAKER, RH REAR DOOR TRIM 1/4.................14-270

R211900 COVER SPEAKER, LH REAR DOOR TRIM 1/4..................14-270

R213300 SPEAKER & LEAD ASM. REAR RH — REPLACE .............09-500

R213350 SPEAKER & LEAD ASM. REAR LH — REPLACE..............09-500

R213399 HEADPH ON E AS M — REPL AC E............. ... ... ................ .....09-515

R300100 ANTENNA, MOBILE PHONE — REPLACE.........................09-525

R300200 BASE, MOBILE PHONE ANTENNA (OUTER) —................09-525

R300250 BASE, MOBILE PHONE ANTENNA (INNER) —.................09-525

R300300 LEAD, MOBIL E PHON E A NT E NN A — REPL AC E......... ... ..09-525

R300400 HOLDER, MOBILE PHONE — REPLACE...........................09-525

R400100 MOTOR, CRUISE CONTROL — REPLACE........................03-400

R401100 SWITCH, CRUISE CONTROL ACTUATOR —....................03-400

R401200 CABLE, CRUISE CONTROL MOTOR — REPLACE...........03-400

R403100 MOTOR & CABLE ASM. CRUISE CONTROL — ................03-400

R407100 LINER, CA R G O B ED — REP L AC E........ ... ............ ... ...........AA-025

R407200 COVER, SOFT TONNEAU — REPLACE............................AA-025

R407250 COVER, RIGID TONNEAU — REPLACE............................AA-025

R407300 MAT, CARGO BED/BOOT — REPLACE.............................AA-025

R407350 LINER, TAIL GA TE — REP L AC E...... ............ ... ............ .... ....AA-025

R407400 MAT, TAILGATE — REP L ACE ............ ... ... ............... ...........AA-025

R426500 HOIST, SPARE WHEEL (UTE) — REPLACE......................05-825

R506000 MUDFLAP, FRONT — REPLACE........................................AA-000

R506200 MUDFLAP, REAR — REPLACE..........................................AA-000

R600100 CHILD RESTRAINT FITTING — REPLACE........................AA-020

R601250 CARGO BARRIER — REPLACE.........................................AA-015

R601500 SHADE, VENETIAN, REAR WINDOW (EXT) —..................AA-015

R601700 SUN BLIND/VENETIAN, REAR WINDOW (INT) —.............AA-015

R601800 VE N E TI AN , R EAR QUART E R WIN DOW (IN T ) —...............AA-015

R601900 LOUVRE REAR WINDOW (EXT) — REPLACE..................AA-020

R602000 SUNSHADE, FRONT WINDSHIELD (EXT) —.....................AA-015

R602100 SU N S HAD E , RE A R WINDOW (E XT ) — REPL A CE........ ... .AA-015

R602400 COVER/INSERT, FRONT SEATS — REPLACE.................AA-000

R603000 WEATHERSHIELD, DOOR MOUNTED RH —....................AA-015

R603100 WEATHERSHIELD, DOOR MOUNTED LH —.....................AA-015

R603500 TOWB A R — REPL ACE ........ ........................... ....................AA-025

R603510 TOW BALL, TOW BAR — REPLACE..................................AA-025

R603520 TONGUE, TOW BAR — REPLACE.....................................AA-025

R603600 HARNES S , TR A IL ER WI R I N G — REPA I R/REPLAC E........AA-020

R603700 BRACE, REAR QUARTER (TOW BAR ACC) —.................AA-025

R603800 SPORTS/CARRY BAR (UTE ONLY) — REPLACE.............AA-020

R604100 SCREEN, SATELLITE NAVIGATION — REPLACE............AA-000

R604200 CD PLAYER, SATELLITE NAVIGATION — REPLACE.......AA-000

R604300 INTERFACE MODULE, SATELLITE NAVIGATION —........AA-000

R604400 HAND SET, SATELLITE NAVIGATION — REPLACE.........AA-000

R606000 CAP ASM. FUEL TANK FILLER, LOCKING —....................03-055

R606500 STONE GUARD /D EF L EC T O R A SM. FU E L TANK — . .... ....03 -0 74

R607500 EXTENSION, TAIL PIPE — REPLACE................................03-750

R608000 FRAME, LICENCE PLATE — REPLACE.............................AA-005

R609100 CARGO COVER (WAGON) — REPLACE...........................14-130

R609100 CARGO COVER (WAGON) — REPLACE...........................AA-000

R700100 FIRST AID KIT — REPLACE...............................................AA-000

R700200 SAFETY TRIANGLE — REPLACE......................................AA-000

R700300 FIRE EXTINGUISHER — REPLACE...................................AA-000

R902100 CRUISE CONTROL — ADJUST..........................................03-400

R902200 TH IR D SEAT , ST A T ION WAGON REA R —.......... ... ...........AA-020

R902210 CABLE, THIRD SEAT BACK RELEASE — REPLACE........AA-020

NUMERICAL INDEX

No. Description Sect. No. No. Description Sect. No.

WARRANTY

PROCESSING

R902400 LAMP ASM, HIGH MOUNT STOP (UTE WITH ...................AA-020

R902400 LAMP ASM, HIGH MOUNT STOP (UTE WITH ...................02-350

R902400 LAMP ASM. HIGH MOUNTED STOP — REPLACE............02-350

R906440 ROO BAR — REPLACE.......................................................AA-005

LTG GI_AA

AA-000 AA-000

AA-000

AA-000 AA-000

AA-005 AA-005 AA-005

AA-005 AA-005

AA-005

AA-025

AA-020

AA-025 AA-025 AA-225

AA-650Q

AA-650R

AA-020 AA-020 AA-020

AA-025

AA-015 AA-015

SATELLITE

NAVIGATION

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ACCESSORIES

AA-000 ACCESSORIES

R700300 FIRE EXTINGUISHER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

A504100 SUN ROOF — R & R ST ST ST ST ST ST ST ST

A504400 SUNSHADE ASM, SUNROOF — REPLACE — .5 .5 .5 — .5 .5 —

A504350 WEATHERSTRIP, SUN ROOF — REPLACE ST ST ST ST ST ST ST ST

A504300 CABLE, SUN ROOF — REPLACE ST ST ST ST ST ST ST ST

ADD FOR: WAGON ————————

A504150 DEFLECTOR PANEL, SUN ROOF — REPLACE ST ST ST ST ST ST ST ST

A504200 GUIDE RAILS, BOTH SIDES, SUN ROOF —

REPLACE STSTSTSTSTSTSTST

ADD FOR: WAGON ————————

A504250 MOTOR, SUN ROOF — REPLACE ST ST ST ST ST ST ST ST

C248500 DRAIN HOSE, SUN ROOF FRONT — REPLACE — — — — — — — —

ADD FOR: HATCH ————————

C249100 DRAIN HOSE, SUN ROOF REAR — REPLACE — — — — — — — —

1 R609100 CARGO COVER (WAGON) — REPLACE — .2 .2 .2 — — — —

2 C896100 GUARD, BONNET PROTECTOR — REPLACE — .2 .2 .2 — .2 .2 .2

3 R506000 MUDFLAP, FRONT — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

R506200 MUDFLAP, REAR — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

4 R700200 SAFETY TRIANGLE — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

5 R700100 FIRST AID KIT — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

6 R602400 COVER/INSERT, FRONT SEATS — REPLACE — .4 .4 .4 — .4 .4 .4

7 R604100 SCREEN, SATELLITE NAVIGATION — REPLACE — .5 .5 .5 — .5 .5 .5

R604200 CD PLAYER, SATELLITE NAVIGATION — REPLACE — .3 .3 .3 — .3 .3 .3

— 1

ACCESSORIES

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

AA-000 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

R604300 INTERFACE MODULE, SATELLITE NAVIGATION —

REPLACE — .4 .4 .4 — .4 .4 .4

R604400 HAND SET, SATELLITE NAVIGATION — REPLACE — .3 .3 .3 — .3 .3 .3

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ACCESSORIES

AA-005 ACCESSORIES

1 R100500 DEFLECTOR/SPOILER, ROOF — REPLACE — .3 .3 .3 — — — —

2 R906440 ROO BAR — REPLACE — .4 .4 .4 — .4 .4 .4

3 R608000 FRAME, LICENCE PLATE — REPLACE — .2 .2 .2 — .2 .2 .2

4 R100100 LUGGAGE RACK, RAILS/CROSS OVERS (ROOF) —

R&R/REPLACE — .2 .2 .2 — .2 .2 .2

5 C895000 GUARD, HEADLAMP STONE — REPLACE BOTH

SIDES — .3 .3 .3 — .3 .3 .3

C895100 GUARD, HEADLAMP STONE RH — REPLACE — .2 .2 .2 — .2 .2 .2

C895200 GUARD, HEADLAMP STONE LH — REPLACE — .2 .2 .2 — .2 .2 .2

6 R100200 MATS, FLOOR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ACCESSORIES

AA-015 ACCESSORIES

1 R601500 SHADE, VENETIAN, REAR WINDOW (EXT) —

REPLACE ————————

2 R601250 CARGO BARRIER — REPLACE — .3 .3 .3 — — — —

3 R601700 SUN BLIND/VENETIAN, REAR WINDOW (INT) —

REPLACE — .2 .2 .2 — — — —

R601800 VENETIAN, REAR QUARTER WINDOW (INT) —

REPLACE (WAGON) — — — — — — — —

4 R602000 SUNSHADE, FRONT WINDSHIELD (EXT) —

REPLACE — .3 .3 .3 — .3 .3 .3

5 R602100 SUNSHADE, REAR WINDOW (EXT) — REPLACE — .3 .3 .3 — .3 .3 .3

6 R603000 WEATHERSHIELD, DOOR MOUNTED RH —

REPLACE — .3 .3 .3 — .3 .3 .3

R603100 WEATHERSHIELD, DOOR MOUNTED LH —

REPLACE — .3 .3 .3 — .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ACCESSORIES

AA-020 ACCESSORIES

1 R601900 LOUVRE REAR WINDOW (EXT) — REPLACE — — — — — — — —

2 R600100 CHILD RESTRAINT FITTING — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 R902200 THIRD SEAT, STATION WAGON REAR —

REPLACE — .6 .6 .6 — — — —

R902210 CABLE, THIRD SEAT BACK RELEASE — REPLACE — 1.0 1.0 1.0 — — — —

4 R603800 SPORTS/CARRY BAR (UTE ONLY) — REPLACE — .3 .3 .3 — — — —

R902400 LAMP ASM, HIGH MOUNT STOP (UTE WITH

SPORTS BAR ONLY) — .5 .5 .5 — — — —

5 R603600 HARNESS, TRAILER WIRING — REPAIR/REPLACE .3 .3 .3 .3 .3 .3 .3 .3

6 A000000 OWNER HAND BOOK — REPLACE (PD ONLY) .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ACCESSORIES

AA-025 TOWING

1 R603500 TOWBAR — REPLACE — .5 .5 .5 — .5 .5 .5

2 R603520 TONGUE, TOW BAR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 R603510 TOW BALL, TOW BAR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

4 R603700 BRACE, REAR QUARTER (TOW BAR ACC) —

REPLACE — .3 .3 .3 — .3 .3 .3

5 R407200 COVER, SOFT TONNEAU — REPLACE — .3 .3 .3 — — — —

6 R407250 COVER, RIGID TONNEAU — REPLACE — .4 .4 .4 — — — —

7 C756000 STRUT, RIGID TONNEAU COVER — REPLACE

BOTH —.3 .3.3————

C756100 STRUT, RIGID TONNEAU COVER RH — REPLACE — .2 .2 .2 — — — —

C756200 STRUT, RIGID TONNEAU COVER LH — REPLACE — .2 .2 .2 — — — —

8 R407100 LINER, CARGO BED — REPLACE — .4 .4 .4 — — — —

R407300 MAT, CARGO BED/BOOT — REPLACE — .2 .2 .2 — .2 .2 .2

9 R407350 LINER, TAILGATE — REPLACE — .2 .2 .2 — — — —

R407400 MAT, TAILGATE — REPLACE — .2 .2 .2 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ACCESSORIES

AA-225 AUTOMATIC LEVEL RIDE

1 F400100 LINK, HEIGHT SENSOR OR BALL PIVOT —

REPLACE — .3 .3 .3 — .3 .3 .3

2 F400200 HEIGHT SENSOR ASM — REPLACE — .4 .4 .4 — .4 .4 .4

3 F400300 MOUNT, SILICON — REPLACE — .3 .3 .3 — .3 .3 —

4 F400500 COMPRE SSOR ASM. (LEVEL RIDE) — REPLACE — .5 .5 .5 — .5 .5 .5

5 F400600 AIR LINE A SM LH. S/LIFT SHOCK ABSORBER —

REPLACE — .3 .3 .3 — .3 .3 .3

6 F400650 AIR LINE ASM RH. S/LIFT SHOCK ABSORBER —

REPLACE — .3 .3 .3 — .3 .3 .3

7 F400700 MODULE ASM. (LEVEL RIDE) RELAY ISOLATING —

REPLACE — .3 .3 .3 — .3 .3 .3

8 F121100 SHOCK ABSORBER SUPERLIFT REAR RH —

REPLACE — .4 .4 .4 — .4 .4 .4

F121200 SHOCK ABSORBER SUPERLIFT REAR LH —

REPLACE — .4 .4 .4 — .4 .4 .4

9 F121300 SHOCK ABSORBER SUPERLIFT REAR BOTH —

REPLACE — .6 .6 .6 — .6 .6 .6

10 F400800 HARNESS, LEVEL RIDE POWER — REPAIR/

REPLACE — ST ST ST — ST ST ST

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ACCESSORIES

AA-650Q L.P.G

L701010 SENSOR, P1/MAP — REPLACE — .5 — — — — — —

L701020 HOSE, P1 SENSOR — REPLACE — .5 — — — — — —

L701030 VALVE, FRONT GAS LOCK OFF — REPLACE — 1.2 — — — — — —

L701040 HOSE, LPG INJECTOR — REPLACE — .9 — — — — — —

L701050 INJECTOR ASM, LPG — REPLACE — .5 — — — — — —

ADD FOR: ALL INJECTORS —.8——————

L701060 RAIL ASM, LPG INJECTOR — REPLACE RH OR LH — .5 — — — — — —

ADD FOR: BOTH SIDES — .3 — — — — — —

L701070 FILTER ASM, LPG VAPOUR — REPLACE — .5 — — — — — —

L701100 CONVERTER COOLANT PIPES — REPLACE — .9 .9 .9 — — — —

L701250 VALVE, FUEL CONTROL — REPLACE — — .4 .4 — — — —

ADD TO: INSTALL FUEL SYSTEM ANALYSER &

PERFORM DIAGNOSIS — — .5 .5 — — — —

L700400 MIXER — REPLACE — — 1.1 1.1 — — — —

L790000 LPG ENGINE HARNESS — REPLACE — 2.5 — — — — — —

L790500 FUEL CHANGE OVER SWITCH — REPLACE — .5 .4 .4 — — — —

L790100 LPG BODY HARNESS — REPLACE — — — — — — — —

L701550 MEMCAL ASM (LPG) — REPLACE — — .4 .4 — — — —

L701700 FUEL GAUGE INTERFACE OR RELAY — REPLACE — — .5 .5 — — — —

L702500 SERVICE HOSE VENT TUBE — REPLACE — — .4 .4 — — — —

1 L701300 LPG CYLINDER — REPLACE — .7 .7 .7 — — — —

2 L701450 AUTO FILL LIMITER VALVE — REPLACE — 1.0 1.0 1.0 — — — —

L702400 FILLER HOSE VENT TUBE — REPLACE — .4 .4 .4 — — — —

— 1

L.P.G

ACCESSORIES

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

AA-650Q — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

L701200 FLOOR FLANGE — REPLACE — .6 .6 .6 — — — —

3 L701800 SERVICE LINE REAR — REPLACE — .9 .9 .9 — — — —

4 L701900 SERVICE LINE FRONT — REPLACE — .9 .9 .9 — — — —

L790200 PROCESSOR, DIGITAL ADAPTIVE — REPLACE — 1.0 1.0 1.0 — — — —

ADD TO: INSTALL FUEL SYSTEM ANALYSER &

PERFORM DIAGNOSIS — — .5 .5 — — — —

5 L700800 SERVICE LINE ENGINE BAY — REPLACE — — .5 .5 — — — —

6 L700600 CONVERTER — REPLACE — 1.5 1.0 1.0 — — — —

ADD TO: PRESSURE TEST — — .9 .9 — — — —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ACCESSORIES

AA-650R L.P.G

L700500 CONTROL VALVE LPG — REPLACE — .7 .7 .7 — — — —

L700900 HOSE VAPOUR FEED LINE LPG — REPLACE — .5 .6 .6 — — — —

1 L790300 SMART UNIT ASM. — REPLACE — .4 .4 .4 — — — —

L701400 VALVE ASSEMBLY, ANTI THEFT — REPLACE — 1.0 1.0 1.0 — — — —

2 L702200 HOSE LPG SERVICE — REPLACE — .6 .6 .6 — — — —

3 L702000 FILLER BOX/VALVE, LPG — REPLACE — .8 .8 .8 — — — —

4 L702100 HOSE, LPG FILLER — REPLACE — .6 .6 .6 — — — —

5 L700300 ELBOW INLET NO. 8—5 — REPLACE — .4 .4 .4 — — — —

L702300 ELBOW NO. 8 LPG — REPLACE — .4 .4 .4 — — — —

6 L701600 CONTENTS GAUGE LPG — REPLACE — .6 .6 .6 — — — —

L701500 SENDER UNIT LPG — REPLACE — .4 .4 .4 — — — —

— 1

LTG GI_00

00-249

00-999

00-350

00-150

00-500

00-025

00-375

00-050

00-075

00-450

00-248

00-200

00-175

00-225

00-325

00-540

REFER

04-600

00-251

00-475

00-550

00-430

00-275 00-580 00-400

00-508

DIAGNOSTIC

TROUBLE CODES

ENGINE

00-248

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-025 CYLINDER HEAD COVER

J109100 SEAL/BOLT, VALVE ROCKER COVER — REPLACE — .2 .2 .2 — .2 .2 .2

1 J307050 COVER ASM. VALVE ROCKER — REPLACE BOTH

SIDES .7.5.5.5.7.5.5.5

ADD FOR: SUPERCHARGED — — .1 .1 — — .1 .1

ADD FOR: HFV6 .6 .4 — — .6 .4 — —

J307150 COVER ASM. VALVE ROCKER — REPLACE CYLS

1,3,5, (7) .6.3.3.3.6.3.3.3

ADD FOR: HFV6 .4 .4 — — .4 .4 — —

J307250 COVER ASM. VALVE ROCKER — REPLACE CYLS

2,4,6, (8) .6.3.3.3.6.3.3.3

ADD FOR: HFV6 .4 .4 — — .4 .4 — —

2 J318500 CAP, OIL FILLER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 J307000 GASKET, VALVE ROCKER COVER — REPLACE

BOTH SIDES .7.5.5.5.7.5.5.5

ADD FOR: SUPERCHARGED — — .1 .1 — — .1 .1

ADD FOR: HFV6 .6 .4 — — .6 .4 — —

J307100 GASKET, VALVE ROCKER COVER — REPLACE

CYLS 1,3,5, (7) .6.3.3.3.6.3.3.3

ADD FOR: HFV6 .4 .4 — — .4 .4 — —

J307200 GASKET, VALVE ROCKER COVER — REPLACE

CYLS 2,4,6, (8) .6.3.3.3.6.3.3.3

ADD FOR: HFV6 .4 .4 — — .4 .4 — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-050 VALVE LIFTERS

1 J307040 PIVOT OR PEDESTAL, VALVE ROCKER (1 OR 2) —

REPLACE BOTH SIDES 1.1 1.2 1.0 1.0 1.1 1.2 1.0 1.0

ADD FOR: GEN III, GEN IV — — .2 .2 — — .2 .2

J307140 PIVOT OR PEDESTAL, VALVE ROCKER (1 OR 2) —

REPLACE CYLS 1,3,5, (7) .7.9.7.7.7.9.7.7

ADD FOR: GEN III, GEN IV — — .2 .2 — — .2 .2

J307240 PIVOT OR PEDESTAL, VALVE ROCKER (1 OR 2) —

REPLACE CYLS 2,4,6, (8) .7.9.7.7.7.9.7.7

ADD FOR: GEN III, GEN IV — — .2 .2 — — .2 .2

2 J307020 ROD, VALVE PUSH, (1 OR 2) — REPLACE BOTH

SIDES 1.1 .7 .7 .7 1.1 .7 .7 .7

ADD FOR: EACH ADDITIONAL CYLINDER — .2 .2 .2 — .2 .2 .2

J307120 ROD, VALVE PUSH, (1 OR 2) — REPLACE CYLS

1,3,5, (7) .7.5.5.5.7.5.5.5

ADD FOR: EACH ADDITIONAL CYLINDER — .2 .2 .2 — .2 .2 .2

J307220 ROD, VALVE PUSH, (1 OR 2) — REPLACE CYLS

2,4,6, (8) .7.5.5.5.7.5.5.5

ADD FOR: EACH ADDITIONAL CYLINDER — .2 .2 .2 — .2 .2 .2

3 J311100 LIFTER, HYDRAULIC VALVE (ALL) — REPLACE 2.4 2.7 3.5 3.5 2.4 2.7 3.5 3.5

ADD FOR: GEN III, GEN IV — 2.3 1.5 1.5 — 2.3 1.5 1.5

4 J307010 ARM, VALVE ROCKER (1 OR ALL) — REPLACE

BOTH SIDES 1.1 .8 .7 .7 1.1 .8 .7 .7

ADD FOR: GEN III, GEN IV — — .1 .1 — — .1 .1

ADD FOR: HFV6 — 1.1 — — — 1.1 — —

ADD FOR: EACH ADDITIONAL CYLINDER — — .2 .2 — — .2 .2

— 1

VALVE LIFTERS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-050 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

J307110 ARM, VALVE ROCKER (1 OR ALL) — REPLACE

CYLS 1,3,5, (7) .7.5.5.5.7.5.5.5

ADD FOR: GEN III, GEN IV — — .1 .1 — — .1 .1

ADD FOR: HFV6 —.7———.7——

ADD FOR: EACH ADDITIONAL CYLINDER — — .2 .2 — — .2 .2

J307210 ARM, VALVE ROCKER (1 OR ALL) — REPLACE

CYLS 2,4,6, (8) .7.6.5.5.7.6.5.5

ADD FOR: GEN III, GEN IV — — .1 .1 — — .1 .1

ADD FOR: HFV6 —.6———.6——

ADD FOR: EACH ADDITIONAL CYLINDER — — .2 .2 — — .2 .2

5 J307135 GUIDE, LIFTERS/PUSH RODS — REPLACE CYLS

1,3,5, (7) — 3.4 2.5 2.5 — 3.4 2.5 2.5

ADD FOR: GEN III, GEN IV — — .9 .9 — — .9 .9

J307235 GUIDE, LIFTERS/PUSH RODS — REPLACE CYLS

2,4,6, (8) — 3.3 2.6 2.6 — 3.3 2.6 2.6

ADD FOR: GEN III, GEN IV — — .7 .7 — — .7 .7

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-075 CYLINDER HEAD, VALVES & WELSH

PLUGS

J314800 WELSH PLUG, ENGINE BLOCK VALLEY —

REPLACE ONE OR BOTH (HFV6 ONLY) — 5.3 — — — 5.3 — —

1 J310600 HEAD ASM. CYLINDER (COMPLETE) — REPLACE

BOTH SIDES 4.0 4.8 4.6 4.6 4.0 4.8 4.6 4.6

ADD FOR: GEN III, GEN IV — — .2 .2 — — .2 .2

ADD FOR: HFV6 1.7 .2 — — 1.7 .2 — —

*** PRIOR ZONE APPROVAL REQUIRED ***

J310450 HEAD ASM. CYLINDER (COMPLETE) — REPLACE

CYLS 1,3,5, (7) 2.9 3.3 3.3 3.3 2.9 3.3 3.3 3.3

ADD FOR: HFV6 2.3 1.0 — — 2.3 1.0 — —

ADD FOR: V6 — — .3 .3 — — .3 .3

*** PRIOR ZONE APPROVAL REQUIRED ***

J310550 HEAD ASM. CYLINDER (COMPLETE) — REPLACE

CYLS 2,4,6, (8) 2.8 3.2 3.2 3.2 2.8 3.2 3.2 3.2

ADD FOR: HFV6 2.4 1.3 — — 2.4 1.3 — —

*** PRIOR ZONE APPROVAL REQUIRED ***

J310300 HEAD ASM. CYLINDER (LESS VALVES) —

REPLACE BOTH SIDES — 7.2 6.6 6.6 — 7.2 6.6 6.6

ADD FOR: GEN III, GEN IV — .2 .8 .8 — .2 .8 .8

J310400 HEAD ASM. CYLINDER (LESS VALVES) —

REPLACE CYLS 1,3,5, (7) — 4.9 4.5 4.5 — 4.9 4.5 4.5

ADD FOR: GEN III, GEN IV — — .4 .4 — — .4 .4

ADD FOR: HFV6 —.4———.4——

— 1

CYLINDER HEAD, VALVES & WELSH

PLUGS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-075 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

J310500 HEAD ASM. CYLINDER (LESS VALVES) —

REPLACE CYLS 2,4,6, (8) — 4.4 4.1 4.1 — 4.4 4.1 4.1

ADD FOR: GEN III, GEN IV — — .3 .3 — — .3 .3

ADD FOR: HFV6 — 1.4 — — — 1.4 — —

J310050 HEAD ASM. CYLINDER — OVERHA UL BOTH SIDES — 8.8 7.6 7.6 — 8.8 7.6 7.6

ADD FOR: GEN III, GEN IV — — 1.2 1.2 — — 1.2 1.2

ADD FOR: HFV6 — 2.7 — — — 2.7 — —

J310150 HEAD ASM. CYLINDER — OVERHA UL CYLS 1,3,5,

(7) — 5.8 5.1 5.1 — 5.8 5.1 5.1

ADD FOR: GEN III, GEN IV — — .7 .7 — — .7 .7

ADD FOR: HFV6 — 1.6 — — — 1.6 — —

J310250 HEAD ASM. CYLINDER — OVERHA UL CYLS 2,4,6,

(8) — 5.2 4.7 4.7 — 5.2 4.7 4.7

ADD FOR: GEN III, GEN IV — — .5 .5 — — .5 .5

ADD FOR: HFV6 — 2.5 — — — 2.5 — —

2 J307030 SPRING, CAP AND/OR SEAL, VALVE (TWO CYL) —

REPLACE BOTH SIDES — 1.6 1.6 1.6 — 1.6 1.6 1.6

ADD FOR: HFV6 — 1.3 — — — 1.3 — —

ADD FOR: EACH ADDITIONAL CYLINDER — .3 .3 .3 — .3 .3 .3

ADD FOR: EACH ADDITIONAL CYLINDER HFV6 —.4———.4——

CYLINDER HEAD, VALVES & WELSH

PLUGS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-075 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

J307130 SPRING, CAP AND/OR SEAL — VALVE (ONE CYL.)

— REPLACE CYLS 1,3,5, (7) — 1.3 1.3 1.3 — 1.3 1.3 1.3

ADD FOR: HFV6 —.3———.3——

ADD FOR: EACH ADDITIONAL CYLINDER — .3 .3 .3 — .3 .3 .3

ADD FOR: EACH ADDITIONAL CYLINDER HFV6 —.4———.4——

J307230 SPRING, CAP AND/OR SEAL — VALVE (ONE CYL.)

— REPLACE CYLS 2,4,6, (8) — 1.3 1.3 1.3 — 1.3 1.3 1.3

ADD FOR: HFV6 —.3———.3——

ADD FOR: EACH ADDITIONAL CYLINDER — .3 .3 .3 — .3 .3 .3

ADD FOR: EACH ADDITIONAL CYLINDER HFV6 —.4———.4——

3 J310010 VALVE, CYL. HEAD (ONE) — REPLACE CYLS 1,3,5,

(7) — 3.9 3.9 3.9 — 3.9 3.9 3.9

ADD FOR: HFV6 —.5———.5——

ADD FOR: V6 — — .2 .2 — — .2 .2

ADD FOR: EACH ADDITIONAL VALVE — .2 .2 .2 — .2 .2 .2

J310020 VALVE, CYL. HEAD (ONE) — REPLACE CYLS 2,4,6,

(8) — 3.7 3.7 3.7 — 3.7 3.7 3.7

ADD FOR: HFV6 — 1.0 — — — 1.0 — —

ADD FOR: EACH ADDITIONAL VALVE — .2 .2 .2 — .2 .2 .2

4 J310000 GASKET, CYLINDER HEAD — REPLACE BOTH

SIDES 4.0 4.9 4.6 4.6 4.0 4.9 4.6 4.6

ADD FOR: GEN III, GEN IV — — .3 .3 — — .3 .3

ADD FOR: HFV6 —.1———.1——

CYLINDER HEAD, VALVES & WELSH

PLUGS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-075 — 4

VX/

U, 2

VY/

V2II WL WKVZVE WM

J310100 GASKET, CYLINDER HEAD — REPLACE CYLS

1,3,5, (7) 2.9 3.3 3.3 3.3 2.9 3.3 3.3 3.3

ADD FOR: HFV6 2.3 1.0 — — 2.3 1.0 — —

ADD FOR: V6 — — .3 .3 — — .3 .3

J310200 GASKET, CYLINDER HEAD — REPLACE CYLS

2,4,6, (8) 2.8 3.2 3.2 3.2 2.8 3.2 3.2 3.2

ADD FOR: HFV6 2.4 1.3 — — 2.4 1.3 — —

5 J314740 WELSH PLUG, CYL HEAD FRONT — REPLACE

CYLS 1,3,5,(7) — .6 .5 .5 — .6 .5 .5

ADD FOR: GEN III, GEN IV — — .1 .1 — — .1 .1

J314750 WELSH PLUG, CYL HEAD FRONT — REPLACE

CYLS 2,4,6,(8) — 1.4 .7 .7 — 1.4 .7 .7

ADD FOR: GEN III, GEN IV — — .7 .7 — — .7 .7

J314760 WELSH PLUG, CYL HEAD REAR — RE PLACE CYLS

1,3,5,(7) ONE/BOTH SIDES — 6.8 6.5 6.5 — 7.3 7.0 7.0

REMOVE ENGINE & TRANS FOR V6 & GEN III,

GEN IV

ADD FOR: GEN III, GEN IV — — .3 .3 — — .3 .3

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: A/C — .5 .5 .5 — — — —

CYLINDER HEAD, VALVES & WELSH

PLUGS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-075 — 5

VX/

U, 2

VY/

V2II WL WKVZVE WM

J314770 WELSH PLUG, CYL HEAD REAR — RE PLACE CYLS

2,4,6,(8) ONE/BOTH SIDES — 6.8 6.5 6.5 — 7.3 7.0 7.0

REMOVE ENGINE & TRANS FOR V6 & GEN III,

GEN IV

ADD FOR: GEN III, GEN IV — — .3 .3 — — .3 .3

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: A/C — .5 .5 .5 — — — —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-150 BALANCE SHAFT

1 J314910 BEARING, BALANCE SHAFT (REAR) — REPLACE — 7.9 7.9 7.9 — 7.9 7.9 7.9

2 J314900 SHAFT & BEARING ASM. BALANCE — REPLACE — 7.9 7.9 7.9 — 7.9 7.9 7.9

ADD FOR: A/C ————————

ADD FOR: M/T ————————

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-175 CAMSHAFT & HOUSING

1 J314500 CAMSHAFT ASM. — REPLACE (EXCLUDING HFV6) — 11.6 6.5 6.5 — 11.6 6.5 6.5

ADD FOR: GEN III, GEN IV — — 5.1 5.1 — — 5.1 5.1

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

J351000 CAMSHAFT ASM. — REPLACE ALL HFV6 — 1.6 — — — 1.6 — —

J314570 CAMSHAFT ASM CYLS 1,3,5 EXHAUST —

REPLACE HFV6 — 1.4 — — — 1.4 — —

ADD TO REPLACE CAMSHAFT CYLS 1,3,5

INTAKE —.1———.1——

J314590 CAMSHAFT ASM CYLS 1,3,5 INTAKE — REPLACE

HFV6 —1.4———1.4——

ADD TO REPLACE CAMSHAFT CYLS 1,3,5

EXHAUST — .1 — — — .1 — —

J314580 CAMSHAFT ASM. CYLS 2,4,6 EXHAUST —

REPLACE HFV6 — 1.4 — — — 1.4 — —

ADD TO REPLACE CAMSHAFT CYLS 2,4,6

INTAKE —.1———.1——

J314610 CAMSHAFT ASM. CYLS 2,4,6 INTAKE — REPLACE

HFV6 —1.4———1.4——

ADD TO REPLACE CAMSHAFT CYLS 2,4,6

EXHAUST — .1 — — — .1 — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-200 CRANKSHAFT, BEARINGS & REAR MAIN

J320150 SQUIRTERS, CRANKSHAFT OIL — REPLACE

(HFV6) 1.8 5.8 — — 1.8 5.8 — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

1 J320000 CRANKSHAFT — R&R/REPLACE — 8.4 12.3 12.3 — 8.7 12.3 12.3

ADD FOR: GEN III, GEN IV — 4.4 .5 .5 — 4.1 .5 .5

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

2 J320100 CAP, CRANKSHAFT MAIN BEARING — REPLACE — 7.3 3.9 3.9 — 7.6 3.9 3.9

ADD FOR: GEN III, GEN IV — 2.4 5.8 5.8 — 2.1 5.8 5.8

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

3 J320725 SEAL, REAR MAIN OIL — REPLACE (EXCLUDING

HFV6) — 3.3 3.3 3.3 — 3.5 3.5 3.5

ADD FOR: GEN III, GEN IV WITH M/T — .3 .3 .3 — — — —

ADD FOR: AWD (GEN III, GEN IV ONLY) — .2 .2 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.2——————

ADD FOR: AUTO — — .2 .2 — — — —

4 J320700 BEARING, CRANKSHAFT MAIN (ONE) — REPLACE — 7.5 3.9 3.9 — 7.5 3.9 3.9

ADD FOR: GEN III, GEN IV — 2.4 6.0 6.0 — 2.4 6.0 6.0

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD TO: REPLACE ALL BEARINGS — .3 .3 .3 — .3 .3 .3

— 1

CRANKSHAFT, BEARINGS & REAR MAIN

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-200 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

5 J320250 PLATE, REAR MAIN OIL SEAL — R&R/REPLACE — 6.4 5.6 5.6 — 6.6 5.6 5.6

ADD FOR: GEN III, GEN IV — 2.6 4.4 4.4 — 2.4 4.4 4.4

ADD FOR: AWD (GEN III, GEN IV ONLY) — .3 .2 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.2——————

ADD FOR: AUTO — — .2 .2 — — .2 .2

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-225 TIMING CHAIN & SPROCKETS

1 J213510 CHAIN/BELT, TIMING — REPLACE (EX HFV6) 9.8 10.1 2.7 2.7 9.8 10.1 2.7 2.7

ADD FOR: GEN III, GEN IV — — 7.4 7.4 — — 7.4 7.4

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

J213550 CHAIN, PRIMARY TIMING — R&R/REPLACE 5.0 3.8 — — 5.0 3.8 — —

ADD TO REPLACE L/H SECONDARY TIMING

CHAIN —.2———.2——

J213600 CHAIN, R/H SIDE SECONDARY TIMING — R&R/

REPLACE 4.8 3.6 — — 4.8 3.6 — —

ADD TO REPLACE L/H SECONDARY TIMING

CHAIN —.4———.4——

J213700 CHAIN, L/H SIDE SE CONDARY TIMING — R&R/

REPLACE 5.0 4.0 — — 5.0 4.0 — —

J213800 CHAINS, TIMING — R&R/REPLACE ALL PRIMARY

& SECONDARY 5.0 4.0 — — 5.0 4.0 — —

2 J114100 SPROCKET, TIMING CHAIN/BELT CRANKSHAFT —

REPLACE 5.0 3.5 2.8 2.8 5.0 3.5 2.8 2.8

ADD FOR: GEN III, GEN IV 4.8 6.7 7.4 7.4 4.8 6.7 7.4 7.4

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

3 J314560 SPROCKET, TIMING CHAIN/BELT, CAMSHAFT —

REPLACE (EX HFV6) — 10.1 2.8 2.8 — 10.1 2.8 2.8

ADD FOR: GEN III, GEN IV — — 7.3 7.3 — — 7.3 7.3

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

J314300 SPROCKET, CAMSHAFT TIMING — RIGHT BANK

INTAKE REPLACE (HFV6) — 1.2 — — — 1.2 — —

ADD TO: REPLACE ADDITIONAL SPROCKET — .1 — — — .1 — —

— 1

TIMING CHAIN & SPROCKETS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-225 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

J314350 SPROCKET, CAMSHAFT TIMING — RIGHT BANK

EXHAUST REPLACE (HFV6) — 1.2 — — — 1.2 — —

ADD TO: REPLACE ADDITIONAL SPROCKET — .1 — — — .1 — —

J314400 SPROCKET, CAMSHAFT TIMING — LEFT BANK

INTAKE REPLACE (HFV6) — 1.2 — — — 1.2 — —

ADD TO: REPLACE ADDITIONAL SPROCKET — .1 — — — .1 — —

J314450 SPROCKET, CAMSHAFT TIMING — LEFT BANK

EXHAUST REPLACE (HFV6) — 1.2 — — — 1.2 — —

ADD TO: REPLACE ADDITIONAL SPROCKET — .1 — — — .1 — —

4 J112700 TENSíR, GEAR/PULLEY GUIDE/DAMPER TIMING

CHAIN/BELT — REPLACE — 2.7 2.7 2.7 — 2.7 2.7 2.7

J314000 HYDRAULIC TENSIONE R — PRIMARY TIMING

CHAIN — REPLACE — 3.5 — — — 3.5 — —

ADD TO REPLACE ALL OTHER TENSIONERS — .1 — — — .1 — —

J313900 HYDRAULIC TENSIONE R — SECONDARY TIMING

CHAIN R/H — REPLACE — 3.5 — — — 3.5 — —

ADD TO REPLACE ALL OTHER TENSIONERS — .1 — — — .1 — —

J314100 HYDRAULIC TENSIONE R — SECONDARY TIMING

CHAIN L/H — REPLACE — 3.5 — — — 3.5 — —

ADD TO REPLACE ALL OTHER TENSIONERS — .1 — — — .1 — —

J214150 IDLER GEAR, L/H SIDE — REPLACE — 3.8 — — — 3.8 — —

ADD TO REPLACE OTHER SI DE — .2 — — — .2 — —

J214200 IDLER GEAR, R/H SIDE — REPLACE — 3.8 — — — 3.8 — —

ADD TO REPLACE OTHER SI DE — .2 — — — .2 — —

TIMING CHAIN & SPROCKETS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-225 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

5 J314550 GEAR, CAMSHAFT (OR THRUST PLATE) —

REPLACE — — 2.8 2.8 — — 2.8 2.8

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-248 CYLINDER BLOCK & WELSH PLUGS

J332000 WELSH PLUG ALL — REPLACE (V6 ONLY) — — 2.5 2.5 — — 2.5 2.5

J233500 PLUG, CYLINDER BLOCK DRAIN — REPLACE — — .4 .4 — — .4 .4

1 J214700 WELSH PLUG, FRONT OIL GALLERY — REPLACE — 3.8 3.8 3.8 — 3.8 3.8 3.8

2 J332100 WELSH PLUG, RH SIDE — REPLACE ONE/BOTH — .9 .7 .7 — .9 .7 .7

ADD FOR: GEN III, GEN IV — — .2 .2 — — .2 .2

ADD FOR: HFV6 —.6———.6——

3 J332200 WELSH PLUG, LH SIDE — REPLACE ONE/BOTH — .9 .7 .7 — .9 .7 .7

ADD FOR: GEN III, GEN IV — — .2 .2 — — .2 .2

ADD FOR: HFV6 —.1———.1——

4 J340500 BLOCK, CYLINDER CASE — REPLACE — 9.8 13.4 13.4 — 10.1 13.4 13.4

ADD FOR: GEN III, GEN IV — 6.9 3.3 3.3 — 6.6 3.3 3.3

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

J340300 LONG MOTOR — REPLACE (GEN III, GEN IV ONLY) 6.2 10.6 10.6 10.6 6.2 10.6 10.6 10.6

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

J340000 SHORT MOTOR — REPLACE (EXCL. GEN III, GEN

IV) — 9.0 11.5 11.5 — 9.3 11.5 11.5

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-249 CRANKCASE VENTILATION

1 J950100 VALVE, (PCV) CRANKCASE VENT CONTROL —

REPLACE .4.5.5.5.4.5.5.5

2 J950110 HOSE, CRANKCASE VENT — REPLACE .3 .4 .2 .2 .3 .4 .2 .2

ADD FOR: GEN III, GEN IV — — .2 .2 — — .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-251 OIL SUCTION PIPE & SCREEN

1 J117350 PIPE/SCREEN ASM. OIL SUCTION — REPLACE 1.7 5.5 3.5 3.5 1.7 5.8 3.5 3.5

ADD FOR: GEN III, GEN IV — 4.1 6.1 6.1 — 3.7 6.1 6.1

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

2 J117300 GASKET/SEAL, OIL PUMP SUCTION PIPE —

REPLACE 1.7 5.5 3.5 3.5 1.7 5.8 3.5 3.5

ADD FOR: GEN III, GEN IV — 4.1 6.1 6.1 — 3.7 6.1 6.1

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-275 OIL PAN

J315700 COVER, OIL TRANSFER — REPLACE (GEN III, GEN

IV) — .4 .4 .4 — .4 .4 .4

J794900 SENSOR ASM. OIL TEMPERATURE — REPLACE .2 .3 — — .2 .3 — —

J221950 SENSOR ASM. LOW ENGINE OIL LEVEL —

REPLACE .2 .3 — — .2 .3 — —

1 J315500 GASKET, OIL PAN — REPLACE 1.6 8.5 3.6 3.6 1.6 8.8 3.6 3.6

ADD FOR: GEN III, GEN IV — 1.0 5.9 5.9 — .7 5.9 5.9

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

2 J315600 PAN ASM. OIL — REPLACE 1.6 8.5 3.6 3.6 1.6 8.8 3.6 3.6

ADD FOR: GEN III, GEN IV — 1.0 5.9 5.9 — .7 5.9 5.9

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-325 WATER PUMP & FRONT COVER

1 J609100 PUMP ASM. WATER — REPLACE .5 .7 .8 .8 .5 .7 .8 .8

ADD FOR: GEN III, GEN IV .6 .6 .5 .5 .6 .6 .5 .5

2 J609150 GASKET/SEAL, WATER PUMP TO COVER —

REPLACE .5.7.8.8.5.7.8.8

ADD FOR: GEN III, GEN IV .6 .6 .5 .5 .6 .6 .5 .5

3 J313550 GASKET, ENGINE FRONT COVER — REPLACE 4.0 3.5 2.2 2.2 4.0 3.5 2.2 2.2

ADD FOR: GEN III, GEN IV 5.5 6.3 7.6 7.6 5.5 6.3 7.6 7.6

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

4 J313500 COVER/HOUSING, ENGINE FRONT — REPLACE 4.0 3.5 2.2 2.2 4.0 3.5 2.2 2.2

ADD FOR: GEN III, GEN IV 5.5 6.3 7.6 7.6 5.5 6.3 7.6 7.6

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

5 J312600 SEAL, CRANKSHAFT FRONT OIL — REPLACE .6 .6 .7 .7 .6 .6 .7 .7

ADD FOR: GEN III, GEN IV 1.0 1.1 1.0 1.0 1.0 1.1 1.0 1.0

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-350 WATER OUTLET & THERMOSTAT

J608200 HOUSING, COOLANT INLET — REPLACE 1.0 .4 — — 1.0 .4 — —

ADD FOR: HFV6 —.9———.9——

1 J608110 OUTLET ASM. WATER — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

ADD FOR: V6 — — .2 .2 — — .2 .2

2 J608100 SEAL/GASKET, WATER OUTLET — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

ADD FOR: V6 — — .2 .2 — — .2 .2

3 J608130 THERMOSTAT ASM. — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

ADD FOR: V6 — — .3 .3 — — .3 .3

ADD FOR: HFV6 1.4 .9 — — 1.4 .9 — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-375 INLET MANIFOLD

J590800 SUPERCHARGER ASM. — REPLACE — — 2.0 2.0 — — 2.0 2.0

J590500 GASKET, SUPERCHARGER TO MANIFOLD —

REPLACE — — 1.6 1.6 — — 1.6 1.6

J300620 COVER, ENGINE BLOCK VALLEY — REPLACE .9 1.5 1.5 1.5 .9 1.5 1.5 1.5

1 J300600 MANIFOLD, INLET (COMPLETE) — REPLACE .6 .6 1.4 1.4 .6 .6 1.4 1.4

ADD FOR: GEN III, GEN IV — .8 — — — .8 — —

ADD FOR: HFV6 .1 — — — .1 — — —

ADD FOR: V6 — — 1.7 1.7 — — 1.7 1.7

ADD FOR: V6 SUPERCHARGED — — 1.9 1.9 — — 1.9 1.9

2 J300500 GASKET, INLET MANIFOLD — REPLACE .6 .6 1.2 1.2 .6 .6 1.2 1.2

ADD FOR: GEN III, GEN IV — .6 — — — .6 — —

ADD FOR: HFV6 .1 — — — .1 — — —

ADD FOR: V6 — — .9 .9 — — .9 .9

ADD FOR: V6 SUPERCHARGED — — 1.1 1.1 — — 1.1 1.1

3 J300650 MANIFOLD COVER, INLET — REPLACE — — .3 .3 — — .3 .3

4 J300700 MANIFOLD UPPER, INLET — REPLACE .6 .4 .4 .4 .6 .4 .4 .4

5 J301510 GASKET, INLET MANIFOLD UPPER — REPLACE .6 .4 .4 .4 .6 .4 .4 .4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-400 FLYWHEEL & FLEXPLATE

K013500 BEARING ASM. CLUTCH PILOT — REPLACE (M/T) — — 2.7 2.7 — — — —

ADD FOR: GEN III, GEN IV — 3.5 .8 .8 — — — —

K012150 FORK, PIN & DAMPER ASM CLUTCH — REPLACE

(M/T) — — 2.4 2.4 — — — —

1 J335500 FLYWHEEL & RING GEAR ASM. — REPLACE — 3.0 2.8 2.8 — — — —

ADD FOR: GEN III, GEN IV — .6 .8 .8 — — — —

2 J335550 FLEXPLATE & RING GEAR ASM. — REPLACE — 2.7 2.7 2.7 — 3.0 2.7 2.7

ADD FOR: GEN III, GEN IV — .6 .6 .6 — .3 .6 .6

ADD FOR: AWD (GEN III, GEN IV ONLY) — .8 .8 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.6——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

3 K013100 COVER/PRESSURE PLATE ASM. — REPLACE (M/

T) — 2.8 2.6 2.6 — — — —

ADD FOR: GEN III, GEN IV — .6 .8 .8 — — — —

ADD TO: R & R FLYWHEEL — .2 .2 .2 — — — —

4 K013120 PLATE, CLUTCH DRIVEN — REPLACE (M/T) — 2.8 2.6 2.6 — — — —

ADD FOR: GEN III, GEN IV — .6 .8 .8 — — — —

ADD TO: R & R FLYWHEEL — .2 .2 .2 — — — —

5 K012100 BEARING ASM. CLUTCH THROWOUT — REPLACE

(M/T) — 2.6 2.4 2.4 — — — —

ADD FOR: GEN III, GEN IV — 1.0 .8 .8 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-430 CLUTCH CONTROLS

1 K013800 CYLINDER, CLUTCH MASTER — REPLACE — .7 .7 .7 — — — —

K013900 CYLINDER, CLUTCH MASTER — OVERHAUL — .9 .9 .9 — — — —

2 K013600 CYLINDER, CLUTCH SLAVE — REPLACE — 1.9 .4 .4 — — — —

ADD FOR: GEN III, GEN IV — 1.4 2.9 2.9 — — — —

K013700 CYLINDER, CLUTCH SLAVE — OVERHAUL — — .6 .6 — — — —

3 K013750 CAP/SEAL, RESERVOIR CLUTCH MASTER CYL—

INDER — REPLACE — .2 .2 .2 — — — —

4 K013850 RESERVOIR/BRACKET, CLUTCH MASTER CYLIN—

DER — REPLACE — .4 .4 .4 — — — —

5 K062550 HOSE, CLUTCH M/CYL TO RESERVOIR —

REPLACE — .3 .3 .3 — — — —

6 K063500 LINE, PRESSURE CLUTCH — REPLACE — .7 .7 .7 — — — —

7 K062500 HOSE, PRESSURE CLUTCH — REPLACE — .5 .5 .5 — — — —

8 K063550 LINE, PRESSURE HOSE TO SLAVE CYL —

REPLACE — .5 .5 .5 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-450 EXHAUST MANIFOLDS

1 J303100 MANIFOLD ASM. EXHAUST — REPLACE CYLS

1,3,5, (7) — .7 .7 .7 — .7 .7 .7

ADD FOR: HFV6 —.6———.6——

ADD FOR: AWD (HFV6 ONLY) —1.0——————

2 J303200 MANIFOLD ASM. EXHAUST — REPLACE CYLS

2,4,6, (8) — .7 .7 .7 — .7 .7 .7

ADD FOR: HFV6 —.1———.1——

ADD FOR: AWD (HFV6 ONLY) —.2——————

3 J987650 SENSOR ASM. OXYGEN, EXHAUST RH —

REPLACE OR REAR .3 .3 .3 .3 .3 .3 .3 .3

ADD TO REPLACE ADDITIONAL/ALL OXYGEN

SENSORS .1 .1 .1 .1 .1 .1 .1 .1

J987600 SENSOR ASM. OXYGEN, EXHAUST LH —

REPLACE OR FRONT .3.3.3.3.3.3.3.3

ADD TO REPLACE ADDITIONAL/ALL OXYGEN

SENSORS .1 .1 .1 .1 .1 .1 .1 .1

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-475 ENGINE MOUNTING

J237000 MOUNT/BRACKET, ENGINE — REPLACE BOTH

SIDES .8.8.8.8.8.8.8.8

ADD FOR: HFV6 —.2———.2——

1 J337100 MOUNT/BRACKET, ENGINE RH FRONT —

REPLACE .5.5.5.5.5.5.5.5

ADD FOR: HFV6 —.1———.1——

2 J337200 MOUNT/BRACKET, ENGINE LH FRONT —

REPLACE .5.5.5.5.5.5.5.5

ADD FOR: HFV6 —.2———.2——

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-500 ENGINE ASSEMBLY

J340200 ENGINE & TRANS. ASM. — R & R (GEN III, GEN IV) 3.8 6.6 6.6 6.6 3.8 6.6 6.6 6.6

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

J340100 ENGINE & TRANS. ASM. — R & R (EXCL. GEN III,

GEN IV) 4.3 5.3 6.4 6.4 4.5 5.6 6.9 6.9

ADD FOR: AWD (HFV6 ONLY) —.7——————

ADD FOR: 5 SPEED AUTO .2 .3 — — — — — —

ADD FOR: A/C — — .5 .5 — — — —

J340020 ENGINE ASM. AS SHIPPED — REPLACE (GEN III,

GEN IV) 6.2 9.3 9.3 9.3 6.2 9.3 9.3 9.3

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

J340010 ENGINE ASM. AS SHIPPED — REPLACE (EXCL.

GEN III, GEN IV) 6.7 6.2 9.1 9.1 6.9 6.7 9.6 9.6

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO .2 .3 — — — — — —

ADD FOR: A/C — — .5 .5 — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-508 ENGINE COVERS

1 J313100 COVER, ENGINE SIDE RH — REPLACE .2 .2 — — .2 .2 — —

2 J313200 COVER, ENGINE SIDE LH — REPLACE .2 .2 — — .2 .2 — —

3 J313250 COVER, ENGINE FRONT — REPLACE — — — — — — — —

4 J313300 COVER, ENGINE UPPER — REPLACE ONE/BOTH

(GEN III, GEN IV) .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-540 CRANKSHAFT BALANCER

1 J312500 DAMPER ASM. TORSIONAL — REPLACE .7 .8 .4 .4 .7 .8 .4 .4

ADD FOR: GEN III, GEN IV .5 .8 1.2 1.2 .5 .8 1.2 1.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-550 PISTON & PIN, RINGS & BEARINGS

*** PRIOR ZONE APPROVAL REQUIRED FOR ALL

PISTON, ROD, RING REPAIRS ***

1 J330020 RINGS, PISTON (ONE SET ) — REPLACE OPPO—

SITE SIDES — 8.9 9.7 9.7 — 9.2 9.7 9.7

ADD FOR: GEN III, GEN IV — 4.5 3.7 3.7 — 4.2 3.7 3.7

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD TO: REPLACE ALL PISTON RINGS — .5 .5 .5 — .5 .5 .5

J330120 RINGS, PISTON (ONE SET) — REPLACE CYLS

1,3,5, (7) — 7.9 7.8 7.8 — 8.2 7.8 7.8

ADD FOR: GEN III, GEN IV — 4.0 4.1 4.1 — 3.7 4.1 4.1

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD TO: REPLACE ALL PISTON RINGS — .3 .3 .3 — .3 .3 .3

J330220 RINGS, PISTON (ONE SET) — REPLACE CYLS

2,4,6, (8) — 8.2 7.8 7.8 — 8.5 7.8 7.8

ADD FOR: GEN III, GEN IV — 3.7 4.1 4.1 — 3.4 4.1 4.1

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD TO: REPLACE ALL PISTON RINGS — .3 .3 .3 — .3 .3 .3

— 1

PISTON & PIN, RINGS & BEARINGS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-550 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

2 J330000 PISTON & PIN ASM. (ONE) — REPLACE BOTH

SIDES — 8.7 9.7 9.7 — 9.0 9.7 9.7

ADD FOR: GEN III, GEN IV — 4.9 3.9 3.9 — 4.6 3.9 3.9

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD FOR: EACH ADDITIONAL PISTON & PIN — .2 .2 .2 — .2 .2 .2

J330100 PISTON & PIN ASM. (ONE) — REPLACE CYLS

1,3,5, (7) — 7.7 7.8 7.8 — 8.0 7.8 7.8

ADD FOR: GEN III, GEN IV — 4.3 4.2 4.2 — 4.0 4.2 4.2

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD FOR: EACH ADDITIONAL PISTON & PIN — .2 .2 .2 — .2 .2 .2

J330200 PISTON & PIN ASM. (ONE) — REPLACE CYLS

2,4,6, (8) — 8.2 7.8 7.8 — 8.5 7.8 7.8

ADD FOR: GEN III, GEN IV — 3.8 4.2 4.2 — 3.5 4.2 4.2

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD FOR: EACH ADDITIONAL PISTON & PIN — .2 .2 .2 — .2 .2 .2

PISTON & PIN, RINGS & BEARINGS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-550 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

3 J330050 ROD, CONNECTING. (ONE) — REPLACE BOTH

SIDES — 8.2 9.7 9.7 — 8.5 9.7 9.7

ADD FOR: GEN III, GEN IV — 5.4 3.9 3.9 — 5.1 3.9 3.9

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD FOR: EACH ADDITIONAL CONNECTING

ROD — .2 .2 .2 — .2 .2 .2

J330150 ROD, CONNECTING (ONE) — REPLACE CYLS

1,3,5, (7) — 7.9 7.8 7.8 — 8.2 7.8 7.8

ADD FOR: GEN III, GEN IV — 4.1 4.2 4.2 — 3.8 4.2 4.2

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD FOR: EACH ADDITIONAL CONNECTING

ROD — .2 .2 .2 — .2 .2 .2

J330250 ROD, CONNECTING (ONE) — REPLACE CYLS

2,4,6, (8) — 8.1 7.8 7.8 — 8.4 7.8 7.8

ADD FOR: GEN III, GEN IV — 3.9 4.2 4.2 — 3.6 4.2 4.2

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD FOR: EACH ADDITIONAL CONNECTING

ROD — .2 .2 .2 — .2 .2 .2

PISTON & PIN, RINGS & BEARINGS

ENGINE & CLUTCH

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

00-550 — 4

VX/

U, 2

VY/

V2II WL WKVZVE WM

4 J320510 BEARING, CONNECTING ROD (ONE/ALL) —

REPLACE — 7.7 3.9 3.9 — 8.0 3.9 3.9

ADD FOR: GEN III, GEN IV — 2.3 6.1 6.1 — 2.0 6.1 6.1

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

ADD FOR: AWD (HFV6 ONLY) —1.2——————

ADD FOR: 5 SPEED AUTO — .3 — — — — — —

ADD TO: REPLACE ALL CONNECTING ROD

BEARINGS — .5 .5 .5 — .5 .5 .5

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE & CLUTCH

00-580 OIL LEVEL TUBE

1 J317500 INDICATOR, OIL LEVEL — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

2 J217700 TUBE & BRACKET ASM. OIL LEVEL GAUGE —

REPLACE .3.3.3.3.3.3.3.3

— 1

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

00- 999 —

DIAGNOSTIC TROUBLE CODES

ENGINE

J900001 ENGINE DIAGNOSTIC CODE U0001, P2A01 0.3 ST — — 0.3 ST — —

J900004 ENGINE DIAGNOSTIC CODE P2A04 0.3 — — — 0.3 — — —

J900008 ENGINE DIAGNOSTIC CODE P0008 0.3 ST — — 0.3 ST — —

J900009 ENGINE DIAGNOSTIC CODE P0009 0.3 ST — — 0.3 ST — —

J900010 ENGINE DIAGNOSTIC CODE P0010 0.3 ST — — 0.3 ST — —

J900011 ENGINE DIAGNOSTIC CODE P0011 0.3 ST — — 0.3 ST — —

J900012 ENGINE DIAGNOSTIC CODE 12, P0012 — — — ST — — — ST

J900013 ENGINE DIAGNOSTIC CODE 13, P0013 0.3 ST ST ST 0.3 ST ST ST

J900014 ENGINE DIAGNOSTIC CODE 14, P0014 0.3 ST ST ST 0.3 ST ST ST

J900015 ENGINE DIAGNOSTIC CODE 15, P0015 — — ST ST — — ST ST

J900016 ENGINE DIAGNOSTIC CODE 16, P0016 0.3 ST ST ST 0.3 ST ST ST

J900017 ENGINE DIAGNOSTIC CODE 17, P0017 0.3 ST ST ST 0.3 ST ST ST

J900018 ENGINE DIAGNOSTIC CODE 18, P0018 0.3 ST — ST 0.3 ST — ST

J900019 ENGINE DIAGNOSTIC CODE 19, P0019 0.3 ST ST ST 0.3 ST ST ST

J900020 ENGINE DIAGNOSTIC CODE P0020 0.3 ST — — 0.3 ST — —

J900021 ENGINE DIAGNOSTIC CODE 21, P0021 0.3 ST ST ST 0.3 ST ST ST

J900022 ENGINE DIAGNOSTIC CODE 22, P0022 — — ST ST — — ST ST

J900023 ENGINE DIAGNOSTIC CODE 23, P0023 0.3 ST ST ST 0.3 ST ST ST

J900024 ENGINE DIAGNOSTIC CODE 24, P0024 0.3 ST ST ST 0.3 ST ST ST

J900025 ENGINE DIAGNOSTIC CODE 25, P0025 — — ST ST — — ST ST

J900026 ENGINE DIAGNOSTIC CODE 26, P0026 — — ST ST — — ST ST

J900028 ENGINE DIAGNOSTIC CODE 28, P0028 — — ST — — — ST —

J900029 ENGINE DIAGNOSTIC CODE 29, P0029 — — —————ST

J900030 ENGINE DIAGNOSTIC CODE 30, P0030 0.3 ST — — 0.3 ST — —

J900031 ENGINE DIAGNOSTIC CODE 31, P0031 0.3 ST ST — 0.3 ST ST ST

J900032 ENGINE DIAGNOSTIC CODE 32, P0032 0.3 ST ST ST 0.3 ST ST ST

J900033 ENGINE DIAGNOSTIC CODE 33, P0033 — — ——————

J900034 ENGINE DIAGNOSTIC CODE 34, P0034 — — ——————

J900035 ENGINE DIAGNOSTIC CODE 35, P0035 — ST ST ST — ST ST ST

J900036 ENGINE DIAGNOSTIC CODE 36, P0036 0.3 ST ST ST 0.3 ST ST ST

J900037 ENGINE DIAGNOSTIC CODE P0037 0.3 ST — — 0.3 ST — —

J900038 ENGINE DIAGNOSTIC CODE P0038 0.3 ST — — 0.3 ST — —

J900040 ENGINE DIAGNOSTIC CODE P0040 — ST — — — ST — —

J900041 ENGINE DIAGNOSTIC CODE P0041 — ST — — — ST — —

J900042 ENGINE DIAGNOSTIC CODE 42, P0042 — — ST ST — — ST ST

J900043 ENGINE DIAGNOSTIC CODE 43, P0043 — — ST ST — — ST ST

J900044 ENGINE DIAGNOSTIC CODE 44, P0044 — — ST ST — — ST ST

J900045 ENGINE DIAGNOSTIC CODE 45, P0045 — — ST ST — — ST ST

J900046 ENGINE DIAGNOSTIC CODE 46, P0046 — — ST ST — — ST ST

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J900047 ENGINE DIAGNOSTIC CODE 47, P0047 — — ST ST — — ST ST

J900048 ENGINE DIAGNOSTIC CODE 48, P0048 — — ST ST — — ST ST

J900049 ENGINE DIAGNOSTIC CODE 49, P0049 — — ST ST — — ST ST

J900050 ENGINE DIAGNOSTIC CODE P0050 0.3 ST — — 0.3 ST — —

J900051 ENGINE DIAGNOSTIC CODE 51, P0051 0.3 ST ST ST 0.3 ST ST ST

J900052 ENGINE DIAGNOSTIC CODE 52, P0052 0.3 ST ST ST 0.3 ST ST —

J900053 ENGINE DIAGNOSTIC CODE 53, P0053 0.3 ST ST ST 0.3 ST ST —

J900054 ENGINE DIAGNOSTIC CODE 54, P0054 0.3 — ST — 0.3 — ST ST

J900055 ENGINE DIAGNOSTIC CODE 55, P0055 — — ST ST — — ST ST

J900056 ENGINE DIAGNOSTIC CODE 56, P0056 0.3 ST ST ST 0.3 ST ST ST

J900057 ENGINE DIAGNOSTIC CODE 57, P0057 0.3 ST ST ST 0.3 ST ST ST

J900058 ENGINE DIAGNOSTIC CODE 58, P0058 0.3 ST ST — 0.3 ST ST —

J900059 ENGINE DIAGNOSTIC CODE 59, P0059 0.3 ST ST — 0.3 ST ST —

J900060 ENGINE DIAGNOSTIC CODE 59, P0060, P060D 0.3 — — — 0.3 — — —

J900062 ENGINE DIAGNOSTIC CODE P062F 0.3 — — — 0.3 — — —

J900063 ENGINE DIAGNOSTIC CODE 63, P0063 — — ST ST — — ST ST

J900064 ENGINE DIAGNOSTIC CODE 64, P0064 — — ST ST — — ST ST

J900065 ENGINE DIAGNOSTIC CODE 65, P0065 — — ST ST — — ST ST

J900066 ENGINE DIAGNOSTIC CODE 66, P0066 — — ST — — — ST —

J900067 ENGINE DIAGNOSTIC CODE 67, P0067 — — ST — — — ST —

J900068 ENGINE DIAGNOSTIC CODE 67, P0068 0.3 ST — — 0.3 ST — —

J900069 ENGINE DIAGNOSTIC CODE 69, P0069 — — ——————

J900071 ENGINE DIAGNOSTIC CODE 71, P0071 — — ——————

J900072 ENGINE DIAGNOSTIC CODE 72, P0072, U0073 0.3 — ST — 0.3 — ST —

J900073 ENGINE DIAGNOSTIC CODE 73, P0073 — — ST — — — ST —

J900075 ENGINE DIAGNOSTIC CODE 75, P0075 — — ST ST — — ST —

J900076 ENGINE DIAGNOSTIC CODE 76, P0076 — — ST ST — — ST ST

J900078 ENGINE DIAGNOSTIC CODE 78, P0078 — — ST ST — — ST ST

J900079 ENGINE DIAGNOSTIC CODE 79, P0079 — — ST — — — ST —

J900081 ENGINE DIAGNOSTIC CODE 81, P0081 — — ST — — — ST —

J900082 ENGINE DIAGNOSTIC CODE 82, P0082 — — ST — — — ST —

J900083 ENGINE DIAGNOSTIC CODE 83, P0083 — — ST — — — ST —

J900084 ENGINE DIAGNOSTIC CODE 84, P0084 — — ——————

J900085 ENGINE DIAGNOSTIC CODE 85, P0085 — — ST — — — ST —

J900091 ENGINE DIAGNOSTIC CODE 91, P0091 — — ST ST — — ST ST

J900092 ENGINE DIAGNOSTIC CODE 92, P0092 — — ST ST — — ST ST

J900093 ENGINE DIAGNOSTIC CODE 93, P0093 — — ST ST — — ST ST

J900094 ENGINE DIAGNOSTIC CODE 94, P0094 — — ST ST — — ST ST

J900095 ENGINE DIAGNOSTIC CODE 95, P0095 — — ST ST — — ST ST

J900096 ENGINE DIAGNOSTIC CODE 96, P0096 — — ST ST — — ST ST

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J900097 ENGINE DIAGNOSTIC CODE 97, P0097 — — ST ST — — ST ST

J900100 ENGINE DIAGNOSTIC CODE P0100 0.3 — — — 0.3 — — —

J900101 ENGINE DIAGNOSTIC CODE P0101, U0101 0.3 ST ST ST 0.3 ST ST ST

J900102 ENGINE DIAGNOSTIC CODE P0102 0.3 ST ST ST 0.3 ST ST ST

J900103 ENGINE DIAGNOSTIC CODE P0103 0.3 ST ST ST 0.3 ST ST ST

J900105 ENGINE DIAGNOSTIC CODE P0105, U0105 — ST — — — ST — —

J900106 ENGINE DIAGNOSTIC CODE P0106 0.3 ST — — 0.3 ST — ST

J900107 ENGINE DIAGNOSTIC CODE P0107, U0107 0.3 ST ST ST 0.3 ST ST ST

J900108 ENGINE DIAGNOSTIC CODE P0108 0.3 ST ST ST 0.3 ST ST ST

J900110 ENGINE DIAGNOSTIC CODE 110, P0110 — — ——————

J900111 ENGINE DIAGNOSTIC CODE P0111 0.3 — ST ST 0.3 — ST ST

J900112 ENGINE DIAGNOSTIC CODE 112, P0112 0.3 ST ST ST 0.3 ST ST ST

J900113 ENGINE DIAGNOSTIC CODE 113, P0113 0.3 ST ST ST 0.3 ST ST ST

J900115 ENGINE DIAGNOSTIC CODE P0115 — ST — — — ST — —

J900116 ENGINE DIAGNOSTIC CODE P0116 0.3 ST — ST 0.3 ST — —

J900117 ENGINE DIAGNOSTIC CODE P0117 0.3 ST ST ST 0.3 ST ST ST

J900118 ENGINE DIAGNOSTIC CODE P0118 0.3 ST ST ST 0.3 ST ST ST

J900120 ENGINE DIAGNOSTIC CODE 120, P0120 0.3 ST — — 0.3 ST — —

J900121 ENGINE DIAGNOSTIC CODE P0121, U0121 0.3 ST ST ST 0.3 ST ST ST

J900122 ENGINE DIAGNOSTIC CODE 122, P0122 0.3 ST ST ST 0.3 ST ST ST

J900123 ENGINE DIAGNOSTIC CODE 123, P0123 0.3 ST ST ST 0.3 ST ST ST

J900125 ENGINE DIAGNOSTIC CODE P0125, U0125 0.3 ST ST ST 0.3 ST ST ST

J900128 ENGINE DIAGNOSTIC CODE P0128 0.3 ST — — 0.3 ST — —

J900130 ENGINE DIAGNOSTIC CODE 130, P0130 0.3 ST — — 0.3 ST — —

J900131 ENGINE DIAGNOSTIC CODE 131, P0131 0.3 ST ST ST 0.3 ST ST ST

J900132 ENGINE DIAGNOSTIC CODE 132, P0132 0.3 ST ST ST 0.3 ST ST ST

J900133 ENGINE DIAGNOSTIC CODE P0133 0.3 ST ST ST 0.3 ST ST ST

J900134 ENGINE DIAGNOSTIC CODE 134, P0134 0.3 ST ST ST 0.3 ST ST ST

J900135 ENGINE DIAGNOSTIC CODE 135, P0135 0.3 ST ST ST 0.3 ST ST ST

J900136 ENGINE DIAGNOSTIC CODE P0136 — — ——————

J900137 ENGINE DIAGNOSTIC CODE P0137 0.3 ST — — 0.3 ST — ST

J900138 ENGINE DIAGNOSTIC CODE P0138 0.3 ST — — 0.3 ST — ST

J900139 ENGINE DIAGNOSTIC CODE P0139 0.3 — — — 0.3 — — —

J900140 ENGINE DIAGNOSTIC CODE P0140, U0140 0.3 ST — — 0.3 ST — ST

J900141 ENGINE DIAGNOSTIC CODE P0141 0.3 ST — — 0.3 ST — ST

J900147 ENGINE DIAGNOSTIC CODE P0147 — — —————ST

J900150 ENGINE DIAGNOSTIC CODE P0150 0.3 ST — — 0.3 ST — —

J900151 ENGINE DIAGNOSTIC CODE P0151 0.3 ST ST ST 0.3 ST ST ST

J900152 ENGINE DIAGNOSTIC CODE P0152 0.3 ST ST ST 0.3 ST ST ST

J900153 ENGINE DIAGNOSTIC CODE P0153 0.3 ST ST ST 0.3 ST ST ST

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 4

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J900154 ENGINE DIAGNOSTIC CODE P0154 0.3 ST ST ST 0.3 ST ST ST

J900155 ENGINE DIAGNOSTIC CODE P0155, U0155 0.3 ST ST ST 0.3 ST ST ST

J900156 ENGINE DIAGNOSTIC CODE P0156 — — ——————

J900157 ENGINE DIAGNOSTIC CODE P0157 0.3 ST — — 0.3 ST — ST

J900158 ENGINE DIAGNOSTIC CODE P0158 0.3 ST — — 0.3 ST — ST

J900159 ENGINE DIAGNOSTIC CODE P0159 0.3 — — — 0.3 — — —

J900160 ENGINE DIAGNOSTIC CODE P0160 0.3 ST — — 0.3 ST — ST

J900161 ENGINE DIAGNOSTIC CODE P0161 0.3 ST — — 0.3 ST — ST

J900167 ENGINE DIAGNOSTIC CODE P0167 — — —————ST

J900170 ENGINE DIAGNOSTIC CODE P0170 — — ST ST — — ST ST

J900171 ENGINE DIAGNOSTIC CODE P0171 0.3 ST ST ST 0.3 ST ST ST

J900172 ENGINE DIAGNOSTIC CODE P0172 0.3 ST ST ST 0.3 ST ST ST

J900173 ENGINE DIAGNOSTIC CODE P0173 — — ST ST — — ST ST

J900174 ENGINE DIAGNOSTIC CODE P0174 0.3 ST ST ST 0.3 ST ST ST

J900175 ENGINE DIAGNOSTIC CODE P0175 0.3 ST ST ST 0.3 ST ST ST

J900196 ENGINE DIAGNOSTIC CODE P0196 — ST — — — ST — —

J900197 ENGINE DIAGNOSTIC CODE P0197 — ST — — — ST — —

J900198 ENGINE DIAGNOSTIC CODE P0198 0.3 ST — — 0.3 ST — —

J900200 ENGINE DIAGNOSTIC CODE P0200 — ST ST ST — ST ST ST

J900201 ENGINE DIAGNOSTIC CODE 201, P0201 0.3 ST — — 0.3 ST — —

J900202 ENGINE DIAGNOSTIC CODE 202, P0202 0.3 ST — — 0.3 ST — —

J900203 ENGINE DIAGNOSTIC CODE 203, P0203 0.3 ST — — 0.3 ST — —

J900204 ENGINE DIAGNOSTIC CODE 204, P0204 0.3 ST — — 0.3 ST — —

J900205 ENGINE DIAGNOSTIC CODE P0205 0.3 ST — — 0.3 ST — —

J900206 ENGINE DIAGNOSTIC CODE P0206 0.3 ST — — 0.3 ST — —

J900207 ENGINE DIAGNOSTIC CODE P0207 0.3 — — — 0.3 — — —

J900208 ENGINE DIAGNOSTIC CODE P0208 0.3 — — — 0.3 — — —

J900217 ENGINE DIAGNOSTIC CODE P0217 — — ——————

J900218 ENGINE DIAGNOSTIC CODE P0218 — ST ST ST — ST ST ST

J900219 ENGINE DIAGNOSTIC CODE P0219 — ST — — — ST — —

J900220 ENGINE DIAGNOSTIC CODE P0220 0.3 ST — — 0.3 ST — —

J900221 ENGINE DIAGNOSTIC CODE P0221 0.3 ST — — 0.3 ST — —

J900222 ENGINE DIAGNOSTIC CODE P0222 0.3 ST — — 0.3 ST — —

J900223 ENGINE DIAGNOSTIC CODE P0223 0.3 ST — — 0.3 ST — —

J900228 ENGINE DIAGNOSTIC CODE P0228 — ST — — — ST — —

J900229 ENGINE DIAGNOSTIC CODE P0229 — ST — — — ST — —

J900230 ENGINE DIAGNOSTIC CODE P0230 0.3 ST ST ST 0.3 ST ST ST

J900235 ENGINE DIAGNOSTIC CODE P0235 — — ——————

J900243 ENGINE DIAGNOSTIC CODE P0243 — — ——————

J900261 ENGINE DIAGNOSTIC CODE P0261 0.3 ST — — 0.3 ST — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 5

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J900262 ENGINE DIAGNOSTIC CODE P0262 0.3 ST — — 0.3 ST — —

J900264 ENGINE DIAGNOSTIC CODE P0264 0.3 ST — — 0.3 ST — —

J900265 ENGINE DIAGNOSTIC CODE P0265 0.3 ST — — 0.3 ST — —

J900267 ENGINE DIAGNOSTIC CODE P0267 0.3 ST — — 0.3 ST — —

J900268 ENGINE DIAGNOSTIC CODE P0268 0.3 ST — — 0.3 ST — —

J900270 ENGINE DIAGNOSTIC CODE P0270 0.3 ST — — 0.3 ST — —

J900271 ENGINE DIAGNOSTIC CODE P0271 0.3 ST — — 0.3 ST — —

J900273 ENGINE DIAGNOSTIC CODE P0273 0.3 ST — — 0.3 ST — —

J900274 ENGINE DIAGNOSTIC CODE P0274 0.3 ST — — 0.3 ST — —

J900276 ENGINE DIAGNOSTIC CODE P0276 0.3 ST — — 0.3 ST — —

J900277 ENGINE DIAGNOSTIC CODE P0277 0.3 ST — — 0.3 ST — —

J900300 ENGINE DIAGNOSTIC CODE P0300 0.3 ST — — 0.3 ST — —

J900301 ENGINE DIAGNOSTIC CODE P0301 0.3 — — — 0.3 — — —

J900302 ENGINE DIAGNOSTIC CODE P0302 0.3 — — — 0.3 — — —

J900303 ENGINE DIAGNOSTIC CODE P0303 0.3 — — — 0.3 — — —

J900304 ENGINE DIAGNOSTIC CODE P0304 0.3 — — — 0.3 — — —

J900305 ENGINE DIAGNOSTIC CODE P0305 0.3 — — — 0.3 — — —

J900306 ENGINE DIAGNOSTIC CODE P0306 0.3 — — — 0.3 — — —

J900313 ENGINE DIAGNOSTIC CODE P0313 — — ——————

J900315 ENGINE DIAGNOSTIC CODE P0315 0.3 — — — 0.3 — — —

J900318 ENGINE DIAGNOSTIC CODE P0318 — ST — — — ST — —

J900324 ENGINE DIAGNOSTIC CODE P0324 0.3 ST — — 0.3 ST — —

J900325 ENGINE DIAGNOSTIC CODE 325, P0325 0.3 ST ST ST 0.3 ST ST ST

J900326 ENGINE DIAGNOSTIC CODE P0326 0.3 — — — 0.3 — — —

J900327 ENGINE DIAGNOSTIC CODE P0327 0.3 ST ST ST 0.3 ST ST ST

J900328 ENGINE DIAGNOSTIC CODE P0328 0.3 ST — — 0.3 ST — —

J900330 ENGINE DIAGNOSTIC CODE P0330 0.3 — — — 0.3 — — —

J900332 ENGINE DIAGNOSTIC CODE P0332 0.3 ST ST ST 0.3 ST ST ST

J900333 ENGINE DIAGNOSTIC CODE P0333 0.3 ST — — 0.3 ST — —

J900335 ENGINE DIAGNOSTIC CODE P0335 0.3 ST ST ST 0.3 ST ST ST

J900336 ENGINE DIAGNOSTIC CODE 336, P0336 0.3 ST ST ST 0.3 ST ST ST

J900337 ENGINE DIAGNOSTIC CODE P0337 — ST — — — ST — —

J900338 ENGINE DIAGNOSTIC CODE P0338 0.3 ST — — 0.3 ST — —

J900340 ENGINE DIAGNOSTIC CODE 340, P0340 0.3 — — — 0.3 — — —

J900341 ENGINE DIAGNOSTIC CODE 341, P0341 0.3 ST ST ST 0.3 ST ST ST

J900342 ENGINE DIAGNOSTIC CODE P0342 0.3 ST ST ST 0.3 ST ST ST

J900343 ENGINE DIAGNOSTIC CODE P0343 0.3 ST ST ST 0.3 ST ST ST

J900346 ENGINE DIAGNOSTIC CODE P0346 0.3 ST — — 0.3 ST — —

J900347 ENGINE DIAGNOSTIC CODE P0347 0.3 ST — — 0.3 ST — —

J900348 ENGINE DIAGNOSTIC CODE P0348 0.3 ST — — 0.3 ST — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 6

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J900351 ENGINE DIAGNOSTIC CODE 351, P0351 0.3 ST ST ST 0.3 ST ST ST

J900352 ENGINE DIAGNOSTIC CODE 352, P0352 0.3 ST ST ST 0.3 ST ST ST

J900353 ENGINE DIAGNOSTIC CODE P0353 0.3 ST ST ST 0.3 ST ST ST

J900354 ENGINE DIAGNOSTIC CODE P0354 0.3 ST ST ST 0.3 ST ST ST

J900355 ENGINE DIAGNOSTIC CODE P0355 0.3 ST ST ST 0.3 ST ST ST

J900356 ENGINE DIAGNOSTIC CODE P0356 0.3 ST ST ST 0.3 ST ST ST

J900357 ENGINE DIAGNOSTIC CODE P0357 0.3 ST ST ST 0.3 ST ST ST

J900358 ENGINE DIAGNOSTIC CODE P0358 0.3 ST ST ST 0.3 ST ST ST

J900366 ENGINE DIAGNOSTIC CODE P0366 0.3 ST — — 0.3 ST — —

J900367 ENGINE DIAGNOSTIC CODE P0367 0.3 ST — — 0.3 ST — —

J900368 ENGINE DIAGNOSTIC CODE P0368 0.3 ST — — 0.3 ST — —

J900374 ENGINE DIAGNOSTIC CODE P0374 — — ST ST — — ST —

J900391 ENGINE DIAGNOSTIC CODE P0391 0.3 ST — — 0.3 ST — —

J900392 ENGINE DIAGNOSTIC CODE P0392 0.3 ST — — 0.3 ST — —

J900393 ENGINE DIAGNOSTIC CODE P0393 0.3 ST — — 0.3 ST — —

J900400 ENGINE DIAGNOSTIC CODE P0400 — — —————ST

J900401 ENGINE DIAGNOSTIC CODE P0401 — — —————ST

J900402 ENGINE DIAGNOSTIC CODE P0402, U0402 — ST — — — ST — ST

J900403 ENGINE DIAGNOSTIC CODE P0403 — — ——————

J900404 ENGINE DIAGNOSTIC CODE P0404 — — —————ST

J900405 ENGINE DIAGNOSTIC CODE P0405 — — ST ST — — ST ST

J900410 ENGINE DIAGNOSTIC CODE P0410 — — —————ST

J900412 ENGINE DIAGNOSTIC CODE P0412 — — —————ST

J900415 ENGINE DIAGNOSTIC CODE U0415 — ST — — — ST — —

J900418 ENGINE DIAGNOSTIC CODE P0418 — — —————ST

J900420 ENGINE DIAGNOSTIC CODE P0420 0.3 — — — 0.3 — — ST

J900422 ENGINE DIAGNOSTIC CODE P0422 — — ——————

J900423 ENGINE DIAGNOSTIC CODE U0423 — ST — — — ST — —

J900430 ENGINE DIAGNOSTIC CODE P0430 0.3 — — — 0.3 — — ST

J900432 ENGINE DIAGNOSTIC CODE P0432 — — ——————

J900440 ENGINE DIAGNOSTIC CODE P0440 — — —————ST

J900441 ENGINE DIAGNOSTIC CODE P0441 — — —————ST

J900442 ENGINE DIAGNOSTIC CODE P0442 — ST — — — ST — ST

J900443 ENGINE DIAGNOSTIC CODE 443, P0443 0.3 ST ST ST 0.3 ST ST ST

J900446 ENGINE DIAGNOSTIC CODE P0446 — — ST ST — — ST ST

J900449 ENGINE DIAGNOSTIC CODE P0449 — — —————ST

J900451 ENGINE DIAGNOSTIC CODE P0451 0.3 — — — 0.3 — — —

J900452 ENGINE DIAGNOSTIC CODE P0452 0.3 — — — 0.3 — — ST

J900453 ENGINE DIAGNOSTIC CODE P0453 0.3 — — — 0.3 — — ST

J900458 ENGINE DIAGNOSTIC CODE P0458 0.3 ST — — 0.3 ST — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 7

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J900459 ENGINE DIAGNOSTIC CODE P0459 0.3 ST — — 0.3 ST — —

J900460 ENGINE DIAGNOSTIC CODE P0460 — — ——————

J900461 ENGINE DIAGNOSTIC CODE P0461 0.3 ST — — 0.3 ST — ST

J900462 ENGINE DIAGNOSTIC CODE 462, P0462 0.3 ST — — 0.3 ST — ST

J900463 ENGINE DIAGNOSTIC CODE 463, P0463 0.3 ST — — 0.3 ST — ST

J900480 ENGINE DIAGNOSTIC CODE P0480 0.3 ST — — 0.3 ST — ST

J900481 ENGINE DIAGNOSTIC CODE P0481 0.3 ST ST ST 0.3 ST ST ST

J900500 ENGINE DIAGNOSTIC CODE 500, P0500 — ST ST — — ST ST ST

J900501 ENGINE DIAGNOSTIC CODE P0501 — — ——————

J900502 ENGINE DIAGNOSTIC CODE 502, P0502 — ST ST — — ST ST ST

J900503 ENGINE DIAGNOSTIC CODE P0503 — ST ST ST — ST ST ST

J900504 ENGINE DIAGNOSTIC CODE P0504 — ST — — — ST — —

J900505 ENGINE DIAGNOSTIC CODE 505, P0505 — — ——————

J900506 ENGINE DIAGNOSTIC CODE P0506 0.3 ST ST ST 0.3 ST ST ST

J900507 ENGINE DIAGNOSTIC CODE P0507 0.3 ST ST ST 0.3 ST ST ST

J900513 ENGINE DIAGNOSTIC CODE P0513 0.3 ST — — 0.3 ST — —

J900520 ENGINE DIAGNOSTIC CODE P0520 — — ——————

J900521 ENGINE DIAGNOSTIC CODE P0521 0.3 ST — — 0.3 ST — —

J900522 ENGINE DIAGNOSTIC CODE P0522 0.3 ST ST ST 0.3 ST ST ST

J900523 ENGINE DIAGNOSTIC CODE P0523 0.3 ST ST ST 0.3 ST ST ST

J900530 ENGINE DIAGNOSTIC CODE P0530 — ST ST ST — ST ST ST

J900531 ENGINE DIAGNOSTIC CODE P0531 — — —————ST

J900532 ENGINE DIAGNOSTIC CODE P0532 0.3 ST — — 0.3 ST — —

J900533 ENGINE DIAGNOSTIC CODE P0533 0.3 ST — — 0.3 ST — —

J900550 ENGINE DIAGNOSTIC CODE P0550 — — ——————

J900560 ENGINE DIAGNOSTIC CODE 560, P0560 0.3 ST ST ST 0.3 ST ST ST

J900561 ENGINE DIAGNOSTIC CODE P0561 — — ST — — — ST —

J900562 ENGINE DIAGNOSTIC CODE P0562 0.3 ST ST ST 0.3 ST ST ST

J900563 ENGINE DIAGNOSTIC CODE P0563 0.3 ST ST ST 0.3 ST ST ST

J900565 ENGINE DIAGNOSTIC CODE P0565 — ST — — — ST — —

J900566 ENGINE DIAGNOSTIC CODE P0566 — — ——————

J900567 ENGINE DIAGNOSTIC CODE P0567 — ST — — — ST — ST

J900568 ENGINE DIAGNOSTIC CODE P0568 — ST — — — ST — ST

J900571 ENGINE DIAGNOSTIC CODE P0571 — ST — — — ST — ST

J900572 ENGINE DIAGNOSTIC CODE P0572 0.3 ST — — 0.3 ST — —

J900573 ENGINE DIAGNOSTIC CODE P0573 0.3 ST — — 0.3 ST — —

J900575 ENGINE DIAGNOSTIC CODE P0575 0.3 — — — 0.3 — — —

J900601 ENGINE DIAGNOSTIC CODE 601, P0601 0.3 ST ST ST 0.3 ST ST ST

J900602 ENGINE DIAGNOSTIC CODE P0602 0.3 ST ST ST 0.3 ST ST ST

J900603 ENGINE DIAGNOSTIC CODE P0603 0.3 ST — — 0.3 ST — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 8

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J900604 ENGINE DIAGNOSTIC CODE P0604 0.3 ST — — 0.3 ST — ST

J900606 ENGINE DIAGNOSTIC CODE P0606 0.3 ST — — 0.3 ST — ST

J900607 ENGINE DIAGNOSTIC CODE P0607 0.3 — — — 0.3 — — —

J900608 ENGINE DIAGNOSTIC CODE P0608 — ST ST ST — ST ST ST

J900615 ENGINE DIAGNOSTIC CODE P0615 0.3 ST — — 0.3 ST — ST

J900616 ENGINE DIAGNOSTIC CODE P0616 0.3 ST — — 0.3 ST — —

J900617 ENGINE DIAGNOSTIC CODE P0617 0.3 ST — — 0.3 ST — —

J900621 ENGINE DIAGNOSTIC CODE P0621 0.3 ST — — 0.3 ST — —

J900622 ENGINE DIAGNOSTIC CODE P0622 0.3 ST — — 0.3 ST — —

J900625 ENGINE DIAGNOSTIC CODE P0625 0.3 — — — 0.3 — — —

J900626 ENGINE DIAGNOSTIC CODE P0626 0.3 ST — — 0.3 ST — —

J900627 ENGINE DIAGNOSTIC CODE P0627 0.3 ST — — 0.3 ST — —

J900628 ENGINE DIAGNOSTIC CODE P0628 0.3 ST — — 0.3 ST — —

J900629 ENGINE DIAGNOSTIC CODE P0629 0.3 ST — — 0.3 ST — —

J900633 ENGINE DIAGNOSTIC CODE P0633 0.3 ST — — 0.3 ST — —

J900638 ENGINE DIAGNOSTIC CODE P0638 0.3 ST — — 0.3 ST — —

J900641 ENGINE DIAGNOSTIC CODE P0641 0.3 ST — — 0.3 ST — —

J900645 ENGINE DIAGNOSTIC CODE P0645 0.3 ST — — 0.3 ST — ST

J900646 ENGINE DIAGNOSTIC CODE P0646 0.3 ST — — 0.3 ST — —

J900647 ENGINE DIAGNOSTIC CODE P0647 0.3 ST — — 0.3 ST — —

J900650 ENGINE DIAGNOSTIC CODE P0650 0.3 — — — 0.3 — — —

J900651 ENGINE DIAGNOSTIC CODE P0651 0.3 ST — — 0.3 ST — —

J900654 ENGINE DIAGNOSTIC CODE P0654 0.3 ST ST ST 0.3 ST ST ST

J900685 ENGINE DIAGNOSTIC CODE P0685 0.3 ST — — 0.3 ST — —

J900686 ENGINE DIAGNOSTIC CODE P0686 0.3 ST — — 0.3 ST — —

J900687 ENGINE DIAGNOSTIC CODE P0687 0.3 ST — — 0.3 ST — —

J900689 ENGINE DIAGNOSTIC CODE P0689 0.3 — — — 0.3 — — —

J900690 ENGINE DIAGNOSTIC CODE P0690 0.3 — — — 0.3 — — —

J900691 ENGINE DIAGNOSTIC CODE P0691 0.3 ST — — 0.3 ST — —

J900692 ENGINE DIAGNOSTIC CODE P0692 0.3 ST — — 0.3 ST — —

J900693 ENGINE DIAGNOSTIC CODE P0693 0.3 ST — — 0.3 ST — —

J900694 ENGINE DIAGNOSTIC CODE P0694 0.3 ST — — 0.3 ST — —

J900700 ENGINE DIAGNOSTIC CODE P0700 0.3 ST — — 0.3 ST — —

J900703 ENGINE DIAGNOSTIC CODE P0703 — — ——————

J900704 ENGINE DIAGNOSTIC CODE P0704 — ST —————ST

J900705 ENGINE DIAGNOSTIC CODE P0705 — ST ST — — ST ST ST

J900706 ENGINE DIAGNOSTIC CODE P0706 — ST ST — — ST ST ST

J900711 ENGINE DIAGNOSTIC CODE P0711 — ST ST — — ST ST ST

J900712 ENGINE DIAGNOSTIC CODE P0712 — ST ST — — ST ST ST

J900713 ENGINE DIAGNOSTIC CODE P0713 — ST ST — — ST ST ST

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 9

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J900716 ENGINE DIAGNOSTIC CODE P0716 — ST — — — ST — ST

J900717 ENGINE DIAGNOSTIC CODE P0717 — ST — — — ST — ST

J900719 ENGINE DIAGNOSTIC CODE P0719 — ST ST — — ST ST ST

J900722 ENGINE DIAGNOSTIC CODE P0722 — ST — — — ST — —

J900724 ENGINE DIAGNOSTIC CODE P0724 — ST ST — — ST ST ST

J900725 ENGINE DIAGNOSTIC CODE P0725 — — ——————

J900727 ENGINE DIAGNOSTIC CODE P0727 — ST — — — ST — —

J900730 ENGINE DIAGNOSTIC CODE P0730 — — ST — — — ST ST

J900740 ENGINE DIAGNOSTIC CODE P0740 — ST ST — — ST ST ST

J900741 ENGINE DIAGNOSTIC CODE P0741 — ST ST — — ST ST ST

J900742 ENGINE DIAGNOSTIC CODE P0742 — ST ST — — ST ST ST

J900748 ENGINE DIAGNOSTIC CODE P0748 — ST ST — — ST ST ST

J900751 ENGINE DIAGNOSTIC CODE P0751 — ST ST — — ST ST ST

J900752 ENGINE DIAGNOSTIC CODE P0752 — ST — — — ST — —

J900753 ENGINE DIAGNOSTIC CODE P0753 — ST ST — — ST ST ST

J900756 ENGINE DIAGNOSTIC CODE P0756 — ST ST — — ST ST ST

J900757 ENGINE DIAGNOSTIC CODE P0757 — — ST — — — ST —

J900758 ENGINE DIAGNOSTIC CODE P0758 — ST ST — — ST ST ST

J900785 ENGINE DIAGNOSTIC CODE P0785 — ST ST — — ST ST ST

J900801 ENGINE DIAGNOSTIC CODE P0801 — ST ST — — ST ST ST

J900803 ENGINE DIAGNOSTIC CODE P0803 — — —————ST

J900804 ENGINE DIAGNOSTIC CODE P0804 — — —————ST

J900850 ENGINE DIAGNOSTIC CODE P0850 0.3 ST — — 0.3 ST — —

J900851 ENGINE DIAGNOSTIC CODE P0851 0.3 — — — 0.3 — — ST

J900852 ENGINE DIAGNOSTIC CODE P0852 0.3 — — — 0.3 — — —

J900856 ENGINE DIAGNOSTIC CODE P0856 0.3 — — — 0.3 — — —

J900864 ENGINE DIAGNOSTIC CODE P0864 — ST — — — ST — —

J901009 ENGINE DIAGNOSTIC CODE B1009 — ST — — — ST — —

J901011 ENGINE DIAGNOSTIC CODE B1011 0.3 ST — — 0.3 ST — —

J901012 ENGINE DIAGNOSTIC CODE B1012 0.3 ST — — 0.3 ST — —

J901013 ENGINE DIAGNOSTIC CODE B1013 0.3 ST — — 0.3 ST — —

J901014 ENGINE DIAGNOSTIC CODE B1014 0.3 ST — — 0.3 ST — —

J901019 ENGINE DIAGNOSTIC CODE B1019 — ST — — — ST — —

J901026 ENGINE DIAGNOSTIC CODE U1026 — — —————ST

J901040 ENGINE DIAGNOSTIC CODE U1040 — — —————ST

J901041 ENGINE DIAGNOSTIC CODE U1041 — — —————ST

J901056 ENGINE DIAGNOSTIC CODE U1056 — — —————ST

J901064 ENGINE DIAGNOSTIC CODE U1064, P1064 — — ST ST — — ST ST

J901096 ENGINE DIAGNOSTIC CODE U1096 — — —————ST

J901101 ENGINE DIAGNOSTIC CODE P1101 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 10

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J901105 ENGINE DIAGNOSTIC CODE P1105 ————————

J901106 ENGINE DIAGNOSTIC CODE 1106, P1106 — ST — — — ST — ST

J901107 ENGINE DIAGNOSTIC CODE P1107 — ST — — — ST — ST

J901110 ENGINE DIAGNOSTIC CODE 1110, P1110 ———————ST

J901111 ENGINE DIAGNOSTIC CODE P1111 — ST ST ST — ST ST ST

J901112 ENGINE DIAGNOSTIC CODE P1112 — ST ST ST — ST ST ST

J901113 ENGINE DIAGNOSTIC CODE P1113 ————————

J901114 ENGINE DIAGNOSTIC CODE P1114 — ST ST ST — ST ST ST

J901115 ENGINE DIAGNOSTIC CODE P1115 — ST ST ST — ST ST ST

J901116 ENGINE DIAGNOSTIC CODE P1116 — — ST — — — ST —

J901120 ENGINE DIAGNOSTIC CODE P1120 ———————ST

J901121 ENGINE DIAGNOSTIC CODE P1121 — ST ST ST — ST ST ST

J901122 ENGINE DIAGNOSTIC CODE 1122, P1122 — ST ST — — ST ST ST

J901125 ENGINE DIAGNOSTIC CODE P1125 — ST ST — — ST ST ST

J901130 ENGINE DIAGNOSTIC CODE P1130 ————————

J901133 ENGINE DIAGNOSTIC CODE P1133 0.3 ST ST ST 0.3 ST ST ST

J901134 ENGINE DIAGNOSTIC CODE P1134 — ST ST ST — ST ST ST

J901135 ENGINE DIAGNOSTIC CODE P1135 ———————ST

J901136 ENGINE DIAGNOSTIC CODE P1136 ———————ST

J901137 ENGINE DIAGNOSTIC CODE P1137 ————————

J901138 ENGINE DIAGNOSTIC CODE P1138 ————————

J901153 ENGINE DIAGNOSTIC CODE P1153 0.3 ST ST ST 0.3 ST ST ST

J901154 ENGINE DIAGNOSTIC CODE P1154 — ST ST ST — ST ST ST

J901155 ENGINE DIAGNOSTIC CODE P1155 ———————ST

J901156 ENGINE DIAGNOSTIC CODE P1156 ———————ST

J901170 ENGINE DIAGNOSTIC CODE P1170 ————————

J901171 ENGINE DIAGNOSTIC CODE P1171 ————————

J901172 ENGINE DIAGNOSTIC CODE P1172 ———————ST

J901191 ENGINE DIAGNOSTIC CODE P1191 ———————ST

J901209 ENGINE DIAGNOSTIC CODE C1209 0.3 — — — 0.3 — — —

J901210 ENGINE DIAGNOSTIC CODE C1210 0.3 — — — 0.3 — — —

J901220 ENGINE DIAGNOSTIC CODE P1220 — — —————ST

J901221 ENGINE DIAGNOSTIC CODE P1221 — — —————ST

J901222 ENGINE DIAGNOSTIC CODE P1222 — — —————ST

J901223 ENGINE DIAGNOSTIC CODE C1223 0.3 — — — 0.3 — — —

J901224 ENGINE DIAGNOSTIC CODE C1224 0.3 — — — 0.3 — — —

J901227 ENGINE DIAGNOSTIC CODE C1227 0.3 — — — 0.3 — — —

J901228 ENGINE DIAGNOSTIC CODE C1228 0.3 — — — 0.3 — — —

J901229 ENGINE DIAGNOSTIC CODE P1229 — — ——————

J901230 ENGINE DIAGNOSTIC CODE P1230 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 11

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J901234 ENGINE DIAGNOSTIC CODE C1234 0.3 — — — 0.3 — — —

J901235 ENGINE DIAGNOSTIC CODE C1235 0.3 — — — 0.3 — — —

J901243 ENGINE DIAGNOSTIC CODE P1243 — — ——————

J901255 ENGINE DIAGNOSTIC CODE P1255 — — ST ST — — ST —

J901257 ENGINE DIAGNOSTIC CODE P1257 — — —————ST

J901258 ENGINE DIAGNOSTIC CODE P1258 0.3 ST ST ST 0.3 ST ST ST

J901271 ENGINE DIAGNOSTIC CODE P1271 — — ——————

J901274 ENGINE DIAGNOSTIC CODE P1274 — — —————ST

J901275 ENGINE DIAGNOSTIC CODE P1275 — — —————ST

J901276 ENGINE DIAGNOSTIC CODE P1276 — — —————ST

J901280 ENGINE DIAGNOSTIC CODE P1280 — — —————ST

J901281 ENGINE DIAGNOSTIC CODE P1281 — — —————ST

J901285 ENGINE DIAGNOSTIC CODE P1285 — — —————ST

J901286 ENGINE DIAGNOSTIC CODE P1286 — — —————ST

J901300 ENGINE DIAGNOSTIC CODE U1300 — — —————ST

J901301 ENGINE DIAGNOSTIC CODE U1301 — — —————ST

J901326 ENGINE DIAGNOSTIC CODE P1326 — — ——————

J901327 ENGINE DIAGNOSTIC CODE P1327 — — ——————

J901328 ENGINE DIAGNOSTIC CODE P1328 — — ——————

J901329 ENGINE DIAGNOSTIC CODE P1329 — — ——————

J901336 ENGINE DIAGNOSTIC CODE P1336 — — —————ST

J901345 ENGINE DIAGNOSTIC CODE P1345 — — ——————

J901351 ENGINE DIAGNOSTIC CODE P1351 — — ST ST — — ST —

J901361 ENGINE DIAGNOSTIC CODE P1361 — — ST ST — — ST —

J901372 ENGINE DIAGNOSTIC CODE P1372 — — ST ST — — ST —

J901380 ENGINE DIAGNOSTIC CODE P1380 0.3 — — — 0.3 — — ST

J901381 ENGINE DIAGNOSTIC CODE P1381 0.3 — — — 0.3 — — ST

J901404 ENGINE DIAGNOSTIC CODE P1404 — — —————ST

J901405 ENGINE DIAGNOSTIC CODE P1405 — — ——————

J901406 ENGINE DIAGNOSTIC CODE P1406 — — —————ST

J901409 ENGINE DIAGNOSTIC CODE P1409 — — —————ST

J901410 ENGINE DIAGNOSTIC CODE P1410 — — —————ST

J901415 ENGINE DIAGNOSTIC CODE P1415 — — —————ST

J901416 ENGINE DIAGNOSTIC CODE P1416 — — —————ST

J901431 ENGINE DIAGNOSTIC CODE P1431 — — —————ST

J901432 ENGINE DIAGNOSTIC CODE P1432 — — —————ST

J901433 ENGINE DIAGNOSTIC CODE P1433 — — —————ST

J901441 ENGINE DIAGNOSTIC CODE P1441 — — —————ST

J901442 ENGINE DIAGNOSTIC CODE P1442 — — —————ST

J901450 ENGINE DIAGNOSTIC CODE P1450 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 12

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J901481 ENGINE DIAGNOSTIC CODE P1481 — — ——————

J901482 ENGINE DIAGNOSTIC CODE P1482 — — ——————

J901483 ENGINE DIAGNOSTIC CODE P1483 — — ——————

J901484 ENGINE DIAGNOSTIC CODE P1484 — — ——————

J901490 ENGINE DIAGNOSTIC CODE P1490 — — ——————

J901500 ENGINE DIAGNOSTIC CODE P1500 — — ——————

J901501 ENGINE DIAGNOSTIC CODE P1501 — — ——————

J901502 ENGINE DIAGNOSTIC CODE P1502 — — ——————

J901503 ENGINE DIAGNOSTIC CODE P1503 — — ——————

J901504 ENGINE DIAGNOSTIC CODE P1504 — — —————ST

J901508 ENGINE DIAGNOSTIC CODE P1508 — — —————ST

J901509 ENGINE DIAGNOSTIC CODE P1509 — — —————ST

J901510 ENGINE DIAGNOSTIC CODE P1510 — — ——————

J901512 ENGINE DIAGNOSTIC CODE P1512 — — ——————

J901513 ENGINE DIAGNOSTIC CODE P1513 — — —————ST

J901514 ENGINE DIAGNOSTIC CODE P1514 — — —————ST

J901515 ENGINE DIAGNOSTIC CODE P1515 — — —————ST

J901516 ENGINE DIAGNOSTIC CODE P1516 0.3 ST — — 0.3 ST — ST

J901517 ENGINE DIAGNOSTIC CODE P1517 — — —————ST

J901518 ENGINE DIAGNOSTIC CODE P1518 — — —————ST

J901520 ENGINE DIAGNOSTIC CODE P1520 — — —————ST

J901523 ENGINE DIAGNOSTIC CODE P1523 — — —————ST

J901525 ENGINE DIAGNOSTIC CODE P1525 — — ——————

J901526 ENGINE DIAGNOSTIC CODE P1526 — — ——————

J901530 ENGINE DIAGNOSTIC CODE P1530 — — ——————

J901535 ENGINE DIAGNOSTIC CODE P1535 — — ——————

J901539 ENGINE DIAGNOSTIC CODE P1539 — ST ST ST — ST ST ST

J901540 ENGINE DIAGNOSTIC CODE P1540 — — ——————

J901545 ENGINE DIAGNOSTIC CODE P1545 — — —————ST

J901546 ENGINE DIAGNOSTIC CODE P1546 — ST ST ST — ST ST ST

J901550 ENGINE DIAGNOSTIC CODE P1550 — — ——————

J901551 ENGINE DIAGNOSTIC CODE P1551 0.3 ST — — 0.3 ST — —

J901554 ENGINE DIAGNOSTIC CODE P1554 — ST — — — ST — —

J901555 ENGINE DIAGNOSTIC CODE P1555 — — ——————

J901565 ENGINE DIAGNOSTIC CODE P1565 — — ——————

J901571 ENGINE DIAGNOSTIC CODE P1571 — — ST ST — — ST ST

J901572 ENGINE DIAGNOSTIC CODE P1572 — ST — — — ST — ST

J901574 ENGINE DIAGNOSTIC CODE P1574 — ST — — — ST — ST

J901575 ENGINE DIAGNOSTIC CODE P1575 — ST — — — ST — ST

J901585 ENGINE DIAGNOSTIC CODE P1585 — ST — — — ST — ST

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 13

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J901599 ENGINE DIAGNOSTIC CODE P1599 — — ——————

J901600 ENGINE DIAGNOSTIC CODE 1600, P1600 — — ——————

J901601 ENGINE DIAGNOSTIC CODE P1601 — — ——————

J901602 ENGINE DIAGNOSTIC CODE P1602 — — ——————

J901606 ENGINE DIAGNOSTIC CODE P1606 — — ——————

J901610 ENGINE DIAGNOSTIC CODE P1610 — — ——————

J901611 ENGINE DIAGNOSTIC CODE P1611 — ST — — — ST — —

J901612 ENGINE DIAGNOSTIC CODE P1612 — — ST —————

J901613 ENGINE DIAGNOSTIC CODE P1613 — — ST —————

J901614 ENGINE DIAGNOSTIC CODE P1614 — — ——————

J901615 ENGINE DIAGNOSTIC CODE P1615 — — ——————

J901616 ENGINE DIAGNOSTIC CODE P1616 — — ——————

J901620 ENGINE DIAGNOSTIC CODE P1620 — — ——————

J901621 ENGINE DIAGNOSTIC CODE P1621 — ST — — — ST — —

J901626 ENGINE DIAGNOSTIC CODE P1626 — ST ST ST — ST ST ST

J901627 ENGINE DIAGNOSTIC CODE P1627 — — ST ST — — ST —

J901628 ENGINE DIAGNOSTIC CODE P1628 — — ST ST — — ST —

J901629 ENGINE DIAGNOSTIC CODE P1629 0.3 ST — — 0.3 ST — —

J901630 ENGINE DIAGNOSTIC CODE P1630 — ST ST ST — ST ST ST

J901631 ENGINE DIAGNOSTIC CODE P1631 0.3 ST ST ST 0.3 ST ST ST

J901632 ENGINE DIAGNOSTIC CODE P1632 0.3 ST — — 0.3 ST — —

J901633 ENGINE DIAGNOSTIC CODE P1633 — — ——————

J901635 ENGINE DIAGNOSTIC CODE P1635 — ST ST ST — ST ST ST

J901637 ENGINE DIAGNOSTIC CODE P1637 — ST — — — ST — —

J901639 ENGINE DIAGNOSTIC CODE P1639 — ST ST ST — ST ST ST

J901640 ENGINE DIAGNOSTIC CODE P1640 — — ——————

J901642 ENGINE DIAGNOSTIC CODE P1642 — — ST ST — — ST —

J901643 ENGINE DIAGNOSTIC CODE P1643 — — ST ST — — ST —

J901648 ENGINE DIAGNOSTIC CODE P1648 0.3 ST — — 0.3 ST — —

J901649 ENGINE DIAGNOSTIC CODE P1649 0.3 — — — 0.3 — — —

J901650 ENGINE DIAGNOSTIC CODE 1650, P1650 — — ——————

J901652 ENGINE DIAGNOSTIC CODE P1652 — — —————ST

J901654 ENGINE DIAGNOSTIC CODE P1654 — — —————ST

J901659 ENGINE DIAGNOSTIC CODE P1659 — — —————ST

J901660 ENGINE DIAGNOSTIC CODE P1660 — — —————ST

J901661 ENGINE DIAGNOSTIC CODE P1661 — — —————ST

J901663 ENGINE DIAGNOSTIC CODE P1663 — — —————ST

J901665 ENGINE DIAGNOSTIC CODE P1665 — — —————ST

J901666 ENGINE DIAGNOSTIC CODE P1666 — — —————ST

J901668 ENGINE DIAGNOSTIC CODE P1668 — ST — — — ST — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 14

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J901677 ENGINE DIAGNOSTIC CODE P1677 — ST — — — ST — —

J901678 ENGINE DIAGNOSTIC CODE P1678 — ST — — — ST — —

J901679 ENGINE DIAGNOSTIC CODE P1679 — ST — — — ST — —

J901680 ENGINE DIAGNOSTIC CODE P1680 — — ——————

J901681 ENGINE DIAGNOSTIC CODE P1681 — — ——————

J901682 ENGINE DIAGNOSTIC CODE P1682 0.3 — — — 0.3 — — —

J901683 ENGINE DIAGNOSTIC CODE P1683 — — ——————

J901689 ENGINE DIAGNOSTIC CODE P1689 — — —————ST

J901690 ENGINE DIAGNOSTIC CODE P1690 — — ——————

J901700 ENGINE DIAGNOSTIC CODE P1700 — — ——————

J901740 ENGINE DIAGNOSTIC CODE P1740 — — ——————

J901810 ENGINE DIAGNOSTIC CODE P1810 — ST ST ST — ST ST ST

J901811 ENGINE DIAGNOSTIC CODE P1811 — — —————ST

J901812 ENGINE DIAGNOSTIC CODE P1812 — — ——————

J901813 ENGINE DIAGNOSTIC CODE P1813 — — ——————

J901814 ENGINE DIAGNOSTIC CODE P1814 — — ——————

J901835 ENGINE DIAGNOSTIC CODE P1835 — — ——————

J901845 ENGINE DIAGNOSTIC CODE P1845 — ST — — — ST — —

J901860 ENGINE DIAGNOSTIC CODE P1860 — ST ST — — ST ST ST

J901870 ENGINE DIAGNOSTIC CODE P1870 — ST ST — — ST ST ST

J901875 ENGINE DIAGNOSTIC CODE P1675 — — —————ST

J901900 ENGINE DIAGNOSTIC CODE P1900 — — —————ST

J901999 ENGINE DIAGNOSTIC CODE U1999 — — —————ST

J902002 ENGINE DIAGNOSTIC CODE B2002 — — ST ST — — ST ST

J902006 ENGINE DIAGNOSTIC CODE B2006 — — ST ST — — ST ST

J902007 ENGINE DIAGNOSTIC CODE B2007 — — ST ST — — ST ST

J902008 ENGINE DIAGNOSTIC CODE P2008 0.3 — — — 0.3 — — —

J902009 ENGINE DIAGNOSTIC CODE P2009 0.3 — — — 0.3 — — —

J902009 ENGINE DIAGNOSTIC CODE B2009 — — ST ST — — ST ST

J902010 ENGINE DIAGNOSTIC CODE P2010 0.3 — — — 0.3 — — —

J902066 ENGINE DIAGNOSTIC CODE P2066 0.3 ST — — 0.3 ST — —

J902067 ENGINE DIAGNOSTIC CODE P2067 0.3 ST — — 0.3 ST — —

J902068 ENGINE DIAGNOSTIC CODE P2068 0.3 ST — — 0.3 ST — —

J902088 ENGINE DIAGNOSTIC CODE P2088 0.3 ST — — 0.3 ST — —

J902089 ENGINE DIAGNOSTIC CODE P2089 0.3 ST — — 0.3 ST — —

J902090 ENGINE DIAGNOSTIC CODE P2090 0.3 ST — — 0.3 ST — —

J902091 ENGINE DIAGNOSTIC CODE P2091 0.3 ST — — 0.3 ST — —

J902092 ENGINE DIAGNOSTIC CODE P2092 0.3 ST — — 0.3 ST — —

J902093 ENGINE DIAGNOSTIC CODE P2093 0.3 ST — — 0.3 ST — —

J902094 ENGINE DIAGNOSTIC CODE P2094 0.3 ST — — 0.3 ST — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 15

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J902095 ENGINE DIAGNOSTIC CODE P2095 0.3 ST — — 0.3 ST — —

J902096 ENGINE DIAGNOSTIC CODE P2096 0.3 — — — 0.3 — — —

J902097 ENGINE DIAGNOSTIC CODE P2097 0.3 — — — 0.3 — — —

J902098 ENGINE DIAGNOSTIC CODE P2098 0.3 — — — 0.3 — — —

J902099 ENGINE DIAGNOSTIC CODE P2099 0.3 — — — 0.3 — — —

J902100 ENGINE DIAGNOSTIC CODE P2100 0.3 ST — — 0.3 ST — —

J902100 ENGINE DIAGNOSTIC CODE U2100 — — ——————

J902101 ENGINE DIAGNOSTIC CODE P2101 0.3 ST — — 0.3 ST — —

J902101 ENGINE DIAGNOSTIC CODE U2101, P2101 — ST — — — ST — —

J902103 ENGINE DIAGNOSTIC CODE U2103 — — ——————

J902104 ENGINE DIAGNOSTIC CODE U2104 — — ——————

J902105 ENGINE DIAGNOSTIC CODE P2105 0.3 ST — — 0.3 ST — —

J902105 ENGINE DIAGNOSTIC CODE U2105 — ST — — — ST — —

J902106 ENGINE DIAGNOSTIC CODE U2106 — — ——————

J902107 ENGINE DIAGNOSTIC CODE P2107 0.3 ST — — 0.3 ST — —

J902107 ENGINE DIAGNOSTIC CODE U2107, P2107 — ST — — — ST — —

J902108 ENGINE DIAGNOSTIC CODE P2108 — ST — — — ST — —

J902108 ENGINE DIAGNOSTIC CODE U2108 — — ——————

J902119 ENGINE DIAGNOSTIC CODE P2119 0.3 ST — — 0.3 ST — —

J902119 ENGINE DIAGNOSTIC CODE B2119 — ST — — — ST — —

J902120 ENGINE DIAGNOSTIC CODE P2120 0.3 ST — — 0.3 ST — —

J902122 ENGINE DIAGNOSTIC CODE P2122 0.3 ST — — 0.3 ST — —

J902123 ENGINE DIAGNOSTIC CODE P2123 0.3 ST — — 0.3 ST — —

J902125 ENGINE DIAGNOSTIC CODE P2125 0.3 ST — — 0.3 ST — —

J902127 ENGINE DIAGNOSTIC CODE P2127 0.3 ST — — 0.3 ST — —

J902128 ENGINE DIAGNOSTIC CODE P2128 0.3 ST — — 0.3 ST — —

J902135 ENGINE DIAGNOSTIC CODE P2135 0.3 ST — — 0.3 ST — —

J902138 ENGINE DIAGNOSTIC CODE P2138 0.3 ST — — 0.3 ST — —

J902176 ENGINE DIAGNOSTIC CODE P2176 0.3 ST — — 0.3 ST — —

J902177 ENGINE DIAGNOSTIC CODE P2177 0.3 — — — 0.3 — — —

J902178 ENGINE DIAGNOSTIC CODE P2178 0.3 — — — 0.3 — — —

J902179 ENGINE DIAGNOSTIC CODE P2179 0.3 — — — 0.3 — — —

J902180 ENGINE DIAGNOSTIC CODE P2180 0.3 — — — 0.3 — — —

J902187 ENGINE DIAGNOSTIC CODE P2187 0.3 — — — 0.3 — — —

J902188 ENGINE DIAGNOSTIC CODE P2188 0.3 — — — 0.3 — — —

J902189 ENGINE DIAGNOSTIC CODE P2189 0.3 — — — 0.3 — — —

J902190 ENGINE DIAGNOSTIC CODE P2190 0.3 — — — 0.3 — — —

J902227 ENGINE DIAGNOSTIC CODE P2227 0.3 ST — — 0.3 ST — —

J902228 ENGINE DIAGNOSTIC CODE P2228 0.3 ST — — 0.3 ST — —

J902229 ENGINE DIAGNOSTIC CODE P2229 0.3 ST — — 0.3 ST — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 16

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J902231 ENGINE DIAGNOSTIC CODE P2231 0.3 ST — — 0.3 ST — —

J902232 ENGINE DIAGNOSTIC CODE P2232 0.3 ST — — 0.3 ST — —

J902234 ENGINE DIAGNOSTIC CODE P2234 0.3 ST — — 0.3 ST — —

J902235 ENGINE DIAGNOSTIC CODE P2235 0.3 ST — — 0.3 ST — —

J902237 ENGINE DIAGNOSTIC CODE P2237 — ST — — — ST — —

J902238 ENGINE DIAGNOSTIC CODE P2238 — ST — — — ST — —

J902239 ENGINE DIAGNOSTIC CODE P2239 — ST — — — ST — —

J902240 ENGINE DIAGNOSTIC CODE P2240 — ST — — — ST — —

J902241 ENGINE DIAGNOSTIC CODE P2241 — ST — — — ST — —

J902242 ENGINE DIAGNOSTIC CODE P2242 — ST — — — ST — —

J902243 ENGINE DIAGNOSTIC CODE P2243 — ST — — — ST — —

J902247 ENGINE DIAGNOSTIC CODE P2247 — ST — — — ST — —

J902251 ENGINE DIAGNOSTIC CODE P2251 — ST — — — ST — —

J902254 ENGINE DIAGNOSTIC CODE P2254 — ST — — — ST — —

J902270 ENGINE DIAGNOSTIC CODE P2270 0.3 ST — — 0.3 ST — —

J902271 ENGINE DIAGNOSTIC CODE P2271 0.3 ST — — 0.3 ST — —

J902272 ENGINE DIAGNOSTIC CODE P2272 0.3 ST — — 0.3 ST — —

J902273 ENGINE DIAGNOSTIC CODE P2273 0.3 ST — — 0.3 ST — —

J902297 ENGINE DIAGNOSTIC CODE P2297 — ST — — — ST — —

J902298 ENGINE DIAGNOSTIC CODE P2298 — ST — — — ST — —

J902300 ENGINE DIAGNOSTIC CODE P2300 0.3 ST — — 0.3 ST — —

J902301 ENGINE DIAGNOSTIC CODE P2301 0.3 ST — — 0.3 ST — —

J902303 ENGINE DIAGNOSTIC CODE P2303 0.3 ST — — 0.3 ST — —

J902304 ENGINE DIAGNOSTIC CODE P2304 0.3 ST — — 0.3 ST — —

J902306 ENGINE DIAGNOSTIC CODE P2306 0.3 ST — — 0.3 ST — —

J902307 ENGINE DIAGNOSTIC CODE P2307 0.3 ST — — 0.3 ST — —

J902309 ENGINE DIAGNOSTIC CODE P2309 0.3 ST — — 0.3 ST — —

J902310 ENGINE DIAGNOSTIC CODE P2310 0.3 ST — — 0.3 ST — —

J902312 ENGINE DIAGNOSTIC CODE P2312 0.3 ST — — 0.3 ST — —

J902313 ENGINE DIAGNOSTIC CODE P2313 0.3 ST — — 0.3 ST — —

J902315 ENGINE DIAGNOSTIC CODE P2315 0.3 ST — — 0.3 ST — —

J902316 ENGINE DIAGNOSTIC CODE P2316 0.3 ST — — 0.3 ST — —

J902500 ENGINE DIAGNOSTIC CODE P2500 — ST — — — ST — —

J902501 ENGINE DIAGNOSTIC CODE P2501 — ST — — — ST — —

J902544 ENGINE DIAGNOSTIC CODE P2544 0.3 — — — 0.3 — — —

J902610 ENGINE DIAGNOSTIC CODE P2610 0.3 ST — — 0.3 ST — —

J902626 ENGINE DIAGNOSTIC CODE P2626 — ST — — — ST — —

J902629 ENGINE DIAGNOSTIC CODE P2629 — ST — — — ST — —

J902636 ENGINE DIAGNOSTIC CODE P2636 — ST — — — ST — —

J902745 ENGINE DIAGNOSTIC CODE B2745 — ST — — — ST — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ENGINE

DIAGNOSTIC TROUBLE CODES

00- 999 — 17

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

J903027 ENGINE DIAGNOSTIC CODE B3027 — ST — — — ST — —

J903657 ENGINE DIAGNOSTIC CODE B3657 — ST — — — ST — —

J903924 ENGINE DIAGNOSTIC CODE B3924 — ST — — — ST — —

LTG GI_01

01-140

01-003

01-020

01-030

REFER

00-325

01-105

01-160

01-105

01-500

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE COOLING & OILING

01-003 DRIVE BELTS

J607050 BELT, SUPERCHARGER — — .2 .2 — — .2 .2

1 J607100 BELT, MAIN DRIVE — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

2 J607150 BELT, WATER PUMP & ALTERNATOR — REPLACE — — — — — — — —

3 M042500 BELT, P/S PUMP — REPLACE — — — — — — — —

4 D312100 BELT, A/C COMPRESSOR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE COOLING & OILING

01-020 BELT TENSIONER, PULLEY & FAN

(V8s ONLY)'

1 D312000 TENSIONER ASM. A/C DRIVE BELT (GEN III, GEN

IV)— REPLACE .2.3.3.3.2.3.3.3

2 D312050 IDLER PULLEY, AIR CONDITIONING — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 J607250 TENSIONER ASM. MAIN BELT — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

4 J606800 IDLER PULLEY, MAIN BELT — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

5 J606600 PULLEY, WATER PUMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE COOLING & OILING

01-030 BELT TENSIONER & PULLEY (V6 ONLY)

1 J607250 TENSIONER ASM. MAIN DRIVE BELT — REPLACE .2 .3 .6 .6 .2 .3 .6 .6

J607400 TENSIONER ASM. SUPERCHARGER DRIVE BELT

— REPLACE ——.6.6——.6.6

2 J607200 PULLEY ASM. MAIN BELT TENSIONER —

REPLACE .2.3.3.3.2.3.3.3

J607450 PULLEY ASM. SUPERCHARGER DRIVE BELT

TENSIONER — REPLAC E — — .3 .3 — — .3 .3

3 J607300 SUPPORT, IDLER PULLEY, AIR CONDITIONING —

REPLACE — .3 .4 .4 — .3 .4 .4

4 J607500 SUPPORT, IDLER PULLEY, DRIVE BELT —

REPLACE .2.3.4.4.2.3.4.4

5 J607350 IDLER PULLEY, MAIN DRIVE BELT — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

6 J607550 IDLER PULLEY, MAIN DRIVE BELT (WITH A/C) —

REPLACE — .3 .3 .3 — .3 .3 .3

7 J606600 PULLEY, WATER PUMP — REPLACE .2 .3 .2 .2 .2 .3 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE COOLING & OILING

01-105 RADIATOR & COOLING FANS

J603550 SHROUD, RADIATOR UPPER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

J600100 CAP, RADIATOR FILLER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

J600520 TABLETS/PELLETS, COOLING SYSTEM — ADD .2 .2 .2 .2 .2 .2 .2 .2

1 J606150 MOTOR ASM, RADIATOR COOLING FAN —

REPLACE .4.5.5.5.4.5.5.5

2 J603500 SHROUD, RADIATOR COOLING FANS — REPLACE .3 .5 .5 .5 .3 .5 .5 .5

3 J606100 FAN BLADE, RADIATOR COOLING — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

4 J600500 RADIATOR ASM. — R&R/REPLACE .6 .7 .7 .7 .6 .8 .8 .8

ADD FOR: AUTO — .1 .1 .1 — — — —

J605599 RADIATOR — REPAIR — ST ST ST — ST ST ST

J600510 TANK & SEAL, RADIATOR SIDE LH — REPLACE — ST ST ST — ST ST ST

J600530 TANK & SEAL, RADIATOR SIDE RH — REPLACE — ST ST ST — ST ST ST

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE COOLING & OILING

01-140 RADIATOR OVERFLOW RESERVOIR &

HOSES

J601450 CLAMP, RADIATOR OVERFLOW HOSES —

REPLACE (ANY) .2.2.2.2.2.2.2.2

J601610 PIPE ASM. AIR BLEED — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

1 J602100 RESERVOIR/SURGE TANK, RADIATOR OVER—

FLOW — REPLACE .3.3.3.3.3.3.3.3

2 J600150 CAP, OVERFLOW RESERVOIR/SURGE TANK

ASM. — REPLACE .2.2.2.2.2.2.2.2

3 J601600 HOSE, RADIATOR TO OVERFLOW RESERVOIR —

REPLACE .2.2.2.2.2.2.2.2

4 J602500 TUBE, RESERVOIR OVERFLOW — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE COOLING & OILING

01-160 HOSES & PIPES, ENGINE COOLING

J326500 HOSE, COOLANT AIR BLEED (GEN III, GEN IV) —

REPLACE — .4 .4 .4 — .4 .4 .4

J327000 PIPE, COOLANT AIR BLEED (GEN III, GEN IV) —

REPLACE — .9 .9 .9 — .9 .9 .9

J601000 HOSES, RADIATOR BOTH — REPLACE .3 .5 .5 .5 .3 .5 .5 .5

J601150 PIPE, COOLANT INLET — REPLACE (HFV6 ONLY) 1.1 1.0 — — 1.1 1.0 — —

1 J601100 HOSES, RADIATOR UPPER/INLET — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

J602200 PIPE ASM. RADIATOR INLET (S/C ONLY) —

REPLACE — — .7 .7 — — .7 .7

J602300 HOSE, ENGINE TO RADIATOR INLET PIPE (S/C

ONLY) — REPLACE — — .6 .6 — — .6 .6

2 J601200 HOSES, RADIATOR LOWER/OUTLET — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

3 J601210 HOSE, CONNECTING TUBE TO ENGINE (S/C,

GEN III, GEN IV ONLY) — REPLACE — .3 .3 .3 — .3 .3 .3

4 J601510 TUBE, CONNECTING — REPLACE — .5 .5 .5 — .5 .5 .5

5 J601400 CLAMP, RADIATOR HOSE — REPLACE (ANY) .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ENGINE COOLING & OILING

01-500 OIL PUMP, GEARS, FILTER & COOLER

1 J316500 PUMP/GASKET, ENGINE OIL — R&R/REPLACE 9.6 9.9 9.9 9.9 9.6 9.9 9.9 9.9

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

2 J316510 VALVE, OIL PRESSURE RELIEF/REGULATING —

REPLACE 5.13.9.8.85.13.9.8.8

ADD FOR: GEN III, GEN IV 4.9 6.3 9.4 9.4 4.9 6.3 9.4 9.4

ADD FOR: AWD (GEN III, GEN IV ONLY) — 1.0 1.0 — — — — —

3 J316100 GASKET, OIL FILTER ADAPTOR — REPLACE .6 .6 .7 .7 .6 .6 .7 .7

4 J316200 FILTER/CARTRIDGE ASM. OIL — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

5 N318500 SENSOR ASM. OIL PRESSURE — REPLACE .2 .3 .4 .4 .2 .3 .4 .4

ADD FOR: GEN III, GEN IV — .1 — — — .1 — —

6 J316300 ADAPTOR/HOUSING ASM. OIL FILTER —

REPLACE .6.6.7.7.6.6.7.7

ADD FOR: GEN III, GEN IV — .1 — — — .1 — —

7 J316600 GEARS/DRIVE SHAFT/BUSH/PLATE, OIL PUMP —

R&R/REPLACE (V6) 5.1 3.9 2.9 2.9 5.1 3.9 2.9 2.9

— 1

LTG GI_02

02-775

02-250

02-425

02-510

02-200

02-140

02-225 (V6)

02-235 (V8)

02-030

02-800

REFER

04-600

02-000

02-350

02-780

02-000

02-070

02-000

02-300

02-245

02-325

02-400

02-300

REFER

06-255

08-155A

02-235

02-375

02-385 02-350

02-780

REFER

09-300

02-275

02-180

02-000

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-000 SENSORS, ENGINE

J740200 SENSOR ASM. MANIFOLD AIR TEMP. (M.A.T) —

REPLACE .2.4.4.4.2.4.4.4

J794100 SOLENOID VALVE, CAMSHAFT POSITION ACTU—

ATOR — REPLACE ONE/BOTH LEFT BANK .2 .3 — — .2 .3 — —

ADD TO REPLACE OIL SEAL ONE OR BOTH .1 .1 — — .1 .1 — —

J794200 SOLENOID VALVE, CAMSHAFT POSITION ACTU—

ATOR — REPLACE ONE/BOTH RIGHT BANK .2 .3 — — .2 .3 — —

ADD TO REPLACE OIL SEAL ONE OR BOTH .1 .1 — — .1 .1 — —

J794900 SENSOR ASM. OIL TEMPERATURE — REPLACE .2 .3 — — .2 .3 — —

1 N317500 SENSOR ASM. COOLANT TEMP GAUGE —

REPLACE — — .2 .2 — — .2 .2

2 N317510 SENSOR ASM. COOLANT TEMP ECM — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

3 J740100 SENSOR, MANIFOLD ABSOLUTE PRESSURE

(MAP) — REPLACE .2.3.3.3.2.3.3.3

4 J724300 SENSOR ASM. FUEL PUMP SWITCH & OIL PRES—

SURE — REPLACE — .3 .3 .3 — .3 .3 .3

5 J724000 SENSOR ASM. KNOCK (ONE OR BOTH) —

REPLACE (GEN III, GEN IV) .2 1.3 1.3 1.3 .2 1.3 1.3 1.3

J724050 SENSOR ASM KNOCK — REPLACE BOTH SIDES

(HFV6 ONLY) .3 .7 — — .3 .7 — —

J724150 SENSOR ASM KNOCK — REPLACE CYLS 1,3,5 .2 .5 .4 .4 .2 .5 .4 .4

J724100 SENSOR ASM KNOCK — REPLACE CYLS 2,4,6 .2 .4 .4 .4 .2 .4 .4 .4

6 J740250 SENSOR ASM/OIL SEAL, CRANKSHAFT —

REPLACE .2.5.5.5.2.5.5.5

ADD FOR: GEN III, GEN IV .1 .4 .4 .4 .1 .4 .4 .4

— 1

SENSORS, ENGINE

ELECTRICAL

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

02-000 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

7 J795200 SENSOR, CAMSHAFT — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

ADD FOR: GEN III, GEN IV — .7 .7 .7 — .7 .7 .7

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-030 SPARK PLUGS & LEADS

1 J730100 LEAD ASM. SPARK PLUG (1 OR ALL) — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

ADD FOR: V6 (CYLS 2,4,6) — — .3 .3 — — .3 .3

2 J735100 SPARK PLUG — REPLACE/CLEAN OR ADJUST .4 .4 .4 .4 .4 .4 .4 .4

ADD FOR: HFV6 .6 .2 — — .6 .2 — —

ADD TO: REPLACE 2 OR MORE PLUGS — .2 .2 .2 — .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-070 STARTER MOTOR

1 J594000 STARTER MOTOR ASM. — REPLACE .3 .5 .4 .4 .3 .5 .4 .4

ADD FOR: GEN III, GEN IV .1 .3 .4 .4 .1 .3 .4 .4

ADD FOR: AWD (HFV6 ONLY) —.1——————

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-140 ALTERNATOR & MOUNTING

J592800 VOLTAGE REGULATOR — REPLACE — — .4 .4 — — .4 .4

ADD FOR: GEN III, GEN IV — .7 .3 .3 — .7 .3 .3

1 J591200 ALTERNATOR ASM. — REPLACE .5 .5 .3 .3 .5 .5 .3 .3

ADD FOR: GEN III, GEN IV .1 .1 .3 .3 .1 .1 .3 .3

2 J712100 BRACKET, ALTERNATOR MOUNTING — REPLACE .7 .6 .6 .6 .7 .6 .6 .6

ADD FOR: HFV6 .1 .2 — — .1 .2 — —

3 J712200 SUPPORT, REAR ALTERNATOR MOUNTING

(GEN III, GEN IV) — REPLACE — .6 .6 .6 — .6 .6 .6

J712300 BRACE/ADJUSTER, ALTERNATOR MOUNTING

(V6, V8) — REPLACE — — .3 .3 — — .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-180 ENGINE & BODY EARTH STRAPS

1 N001700 STRAP ASM. EARTH ENGINE TO BODY — REPAIR/

REPLACE .2.2.2.2.2.2.2.2

2 N001710 STRAP ASM. HOOD TO BODY — REPAIR/

REPLACE .2.2.2.2.2.2.2.2

3 N001720 STRAP ASM. EARTH COCKPIT TO BODY —

REPAIR/REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-200 BATTERY

N003500 TRAY OR SUPPORT, BATTERY — REPLACE .4 .4 .4 .4 .4 .4 .4 .4

1 N000500 BATTERY ASM. — REPLACE .3 .3 .3 .3 .3 .3 .3 .3

N000333 BATTERY REPLACEMENT — CENTURY YUASA

(POLICE) .3 .3 .3 .3 — .3 .3 .3

BATTERIES ARE ONLY COVERED BY 12

MONTHS WARRANTY

*****************************************

N000550 BATTERY ASM. — TEST & RECHARGE .3 .3 .3 .3 .3 .3 .3 .3

*** PRIOR ZONE APPROVAL REQUIRED AFTER

PD***

FOR W & V SERIES VEHICLES, REFER TO RDL

82/00

*****************************************

2 N002500 CLAMP, BATTERY — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-225 IGNITION COIL (V6)

1 J724510 COIL ASM. (DFI) ELECTRONIC IGNITION —

REPLACE (V6) .8 .6 .3 .3 .8 .6 .3 .3

ADD TO: REPLACE ADDITIONAL OR ALL OTHER

COILS .1 .2 — — .1 .2 — —

ADD TO: REPLACE EACH ADDITIONAL COIL — — .1 .1 — — .1 .1

2 J712400 PLATE, COIL/MODULE MOUNTING — REPLACE — — 1.0 1.0 — — 1.0 1.0

3 J724520 MODULE ASM. (DFI) ELECTRONIC IGNITION —

REPLACE (V6 BOTH) — — .4 .4 — — .4 .4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-235 IGNITION COIL (V8)

1 J715100 COIL, IGNITION — REPLACE (GEN III, GEN IV) .4 .3 .3 .3 .4 .3 .3 .3

ADD TO: REPLACE ADDITIONAL COILS OTHER

SIDE .1 .1 .1 .1 .1 .1 .1 .1

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-245 POWERTRAIN/ENGINE CONTROL

MODULES

J987520 MODULE, THROTTLE CONTROL — REPLACE

(GEN III, GEN IV) — .4 .4 .4 — .4 .4 .4

J730000 MODULE (PIM), POWER TRAIN INTERFACE —

REPLACE (GEN III, GEN IV, HFV6) — .4 .4 .4 — .4 .4 .4

K509600 MODULE (TCM), AUTO TRANSMISSION CON—

TROL — REPLACE .4 .4 — — .4 .4 — —

1 J987610 MODULE (PCM), POWERTRAIN CONTROL —

REPLACE .3.4.4.4.3.4.4.4

ADD FOR: RE—PROGRAMMING .2 .2 .2 .2 .2 .2 .2 .2

J987510 MODULE (ECM), ENGINE CONTROL — REPLACE .3 .4 — — .3 .4 — —

2 J987710 PCM, ECM — REPROGRAM .3 .4 .4 .4 .3 .4 .4 .4

J987700 MEMCAL ASM. (ECM/PCM) — RE PLACE (EXCL.

GEN III, GEN IV) — — .4 .4 — — .4 .4

L701550 MEMCAL ASM. (ECM/PCM) LPG — REPLACE

(EXCL. GEN III, GEN IV) — — .4 .4 — — .4 .4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-250 RELAYS

N001960 RELAY, BLOWER MOTOR — REPLACE — .2 .2 — — .2 .2 —

1 N002200 HOUSING, RELAY & FUSE — REPLACE — ST ST ST — ST ST ST

2 N002250 COVER, RELAY & FUSE HOUSING — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 N414510 FUSE 10 AMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N414515 FUSE 15 AMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N414520 FUSE 20 AMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N414525 FUSE 25 AMP — REPLACE .2 .2 .2 — .2 .2 .2 —

4 N104510 FUSIBLE LINK, (60 AMP PUSH IN) — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

5 N104530 FUSIBLE LINK, (60 AMP BOLT IN) — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

6 N001870 FUSIBLE LINK, (40 AMP PUSH IN) — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

7 N001760 FUSIBLE LINK, (30 AMP BOLT IN) — REPLACE — — — .2 — .2 .2 .2

N104520 FUSIBLE LINK, (30 AMP PUSH IN) — REPLACE .2 .2 .2 — .2 .2 .2 —

8 N002300 HOUSING, FUSIBLE LINK — REPLACE — — — .2 — — — .2

9 N001980 RELAY, ENGINE COOLING FAN (LOW) —

REPLACE .2.2.2.2.2.2.2.2

10 N002100 RELAY, ENGINE CONTROL — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

11 N001820 RELAY, HORN — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

12 N001810 RELAY, A/C — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

13 N001880 RELAY, HEADLAMP LOW BEAM — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

14 N001860 RELAY, ANTI THEFT SYSTEM — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

15 N104600 RELAY, FOG LAMP (FRONT) — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

16 N002150 RELAY, FRONT WINDSCREEN WIPER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

17 N001830 RELAY, FUEL PUMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

RELAYS

ELECTRICAL

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

02-250 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

18 N001840 RELAY, ENGINE COOLING FAN (HIGH) —

REPLACE .2.2.2.2.2.2.2.2

19 N001890 RELAY, STARTER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

20 N002110 RELAY, HEADLAMP HIGH BEAM — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

21 N002120 RELAY, AUTO LEVEL CONTROL — REPLACE .2 .2 .2 .2 .2 .2 .2 —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-275 BODY CONTROL MODULE, CONTROL

UNITS

N764300 RECEIVER/MONITOR, TYRE PRESSURE —

REPLACE — — — — — .5 — —

N506450 MODULE, INTERIOR LAMP CONTROL — REPLACE — — — — — .2 — —

1 N506650 MODULE (BCM), BODY CONTROL —

(CHANGEOVER UNIT) REMOVE & REFIT .4 .3 .3 .3 .4 .3 .3 .3

N506600 MODULE (BCM), BODY CONTROL — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

*** PRIOR ZONE APPROVAL REQUIRED ***

N506590 MODULE (BCM), BODY CONTROL — REPROGRAM .3 .3 .3 .3 .3 .3 .3 .3

NOT TO BE USED WITH BCM CHANGEOVER

PROGRAMME

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-300 HEADLAMP & TURN SIGNAL LAMPS

1 N104100 HEADLAMP ASM. RH — REPLACE .6 .4 .4 .4 .6 .4 .4 .4

N104200 HEADLAMP ASM. LH — REPLACE .6 .4 .4 .4 .6 .4 .4 .4

N705000 NOZZLE, HEADLAMP — REPLACE R/H — — — — .7 — — —

N705010 NOZZLE, HEADLAMP — REPLACE L/H — — — — .7 — — —

2 N104340 BULB, 12V 55/60W HEADLAMP RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD TO REPLACE: BULB HEADLAMP OPPOSITE

SIDE .1 .1 .1 .1 .1 .1 .1 .1

N104440 BULB, 12V 55/60W HEADLAMP LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD TO REPLACE: BULB HEADLAMP OPPOSITE

SIDE .1 .1 .1 .1 .1 .1 .1 .1

3 N104310 BULB, 12V 55W DRIVING LAMP RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD TO REPLACE: BULB DRIVING LAMP OPPO—

SITE SIDE .1 .1 .1 .1 .1 .1 .1 .1

N104320 BULB, 12V 55W DRIVING LAMP LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD TO REPLACE: BULB DRIVING LAMP OPPO—

SITE SIDE .1 .1 .1 .1 .1 .1 .1 .1

4 N104350 BULB, TURN SIGNAL LAMP RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD TO REPLACE: BULB TURN SIGNAL OPPO—

SITE SIDE .1 .1 .1 .1 .1 .1 .1 .1

N104330 BULB, TURN SIGNAL LAMP LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD TO REPLACE: BULB TURN SIGNAL OPPO—

SITE SIDE .1 .1 .1 .1 .1 .1 .1 .1

5 N104300 BULB, PARK LAMP RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD TO REPLACE: BULB PARK LAMP OPPOSITE

SIDE .1 .1 .1 .1 .1 .1 .1 .1

— 1

HEADLAMP & TURN SIGNAL LAMPS

ELECTRICAL

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

02-300 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

N104270 BULB, PARK LAMP LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD TO REPLACE: BULB PARK LAMP OPPOSITE

SIDE .1 .1 .1 .1. .1 .1 .1 .1

6 N104230 BULB HOLDER, TURN SIGNAL LAMP RH —

REPLACE — .2 .2 .2 — .2 .2 .2

N104240 BULB HOLDER, TURN SIGNAL LAMP LH —

REPLACE — .2 .2 .2 — .2 .2 .2

7 N104460 DUST CAP/O RING, HEADLAMP BULB RH —

REPLACE — .2 .2 .2 — .2 .2 .2

N104470 DUST CAP/O RING, HEADLAMP BULB LH —

REPLACE — .2 .2 .2 — .2 .2 .2

8 N104480 DUST CAP/O RING, DRIVING LIGHT BULB RH —

REPLACE — .2 .2 .2 — .2 .2 .2

N104490 DUST CAP/O RING, DRIVING LIGHT BULB LH —

REPLACE — .2 .2 .2 — .2 .2 .2

9 N118300 LAMP ASM. SIDE T/S RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N118400 LAMP ASM. SIDE T/S LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

10 N104360 BULB/HOLDER, FRONT SIDE T/S LAMP RH —

REPLACE .2.2.2.2.2.2.2.2

N104450 BULB/HOLDER, FRONT SIDE T/S LAMP LH —

REPLACE .2.2.2.2.2.2.2.2

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-325 FOG LAMP

1 N104410 BULB, FRONT FOG LAMP — REPLACE .3 .2 .2 .2 .3 .2 .2 .2

ADD TO REPLACE: BULB FOG LAMP OPPOSITE

SIDE — .1 .1 .1 — .1 .1 .1

2 N008000 FOG LAMP, BOTH FRONT — REPLACE .4 .4 .4 .4 .4 .4 .4 .4

N008010 FOG LAMP, RH FRONT — REPLACE .3 .3 .3 .3 .3 .3 .3 .3

N008020 FOG LAMP, LH FRONT — REPLACE .3 .3 .3 .3 .3 .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-350 REAR LAMPS

R902400 LAMP ASM. HIGH MOUNTED STOP — REPLACE 1.3 .3 .3 .3 1.3 .5 .5 .5

ADD FOR: SEDAN — .2 .2 .2 — — — —

R902400 LAMP ASM, HIGH MOUNT STOP (UTE WITH

SPORTS BAR ONLY) — .5 .5 .5 — — — —

N104280 BULB, HIGH MOUNTED STOP LAMP — REPLACE — .2 .2 .2 — .2 .2 .2

1 N104500 BULB, RH STOP/TAIL/TURN/REV — REPLACE ANY/

ALL .2 .2 .2 .2 — .2 .2 .2

ADD TO REPLACE: ANY BULB ONE OR MORE .1 .1 .1 .1 — .1 .1 .1

N104400 BULB, LH STOP/TAIL/TURN/REV — REPLACE ANY/

ALL .2.2.2.2.2.2.2.2

ADD TO REPLACE: ANY BULB ONE OR MORE .1 .1 .1 .1 .1 .1 .1 .1

2 N122100 LAMP & LENS, REAR RH — REPLACE .3 .3 .3 .3 .3 .3 .3 .3

N122200 LAMP & LENS, REAR LH — REPLACE .3 .3 .3 .3 .3 .3 .3 .3

3 A571550 LENS ASM. REFLEX RH — REPLACE .5 .2 .2 .2 — — — —

ADD FOR: SEDAN — .3 .3 .3 — — — —

A571575 LENS ASM. RE FLEX LH — REPLACE .5 .2 .2 .2 — — — —

ADD FOR: SEDAN — .3 .3 .3 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-375 DECK LID LAMP

1 N124000 DECKLID PANEL/LAMP ASM. (ONE PIECE) —

REPLACE — .3 .3 .3 — .3 .3 .3

2 C896950 PANEL, LOWER DECKLID LAMP — REPLACE — .3 .3 .3 — .3 .3 .3

3 N126500 LAMP ASM. REAR LICENCE — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

4 N104380 BULB, BACK UP LAMP — REPLACE — — — .2 — — — —

5 N104370 BULB, DECKLID TAIL LAMP — REPLACE — — — — — — — —

6 N104290 BULB, REAR LICENCE PLATE LAMP— REPLACE

ONE/ALL .2.2.2.2.2.2.2.2

ADD: TO REPLACE ANY ADDITIONAL REAR BULB — .1 .1 .1 — .1 .1 .1

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-385 TAILGATE LAMPS & HANDLE

1 C734500 HANDLE ASM. TAILGATE — REPLACE — .3 .3 .3 — — — —

2 N126500 LAMP ASM. REAR LICENCE — REPLACE — .2 .2 .2 — — — —

3 N104290 BULB, REAR LICENCE PLATE LAMP— REPLACE

ONE/ALL — .2 .2 .2 — .2 .2 .2

ADD: TO REPLACE ANY ADDITIONAL BULB — .1 .1 .1 — .1 .1 .1

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-400 HORN

1 N200500 HORN & BRACKET ASM. (R/H 1 OR 2) — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

2 N200550 HORN & BRACKET ASM. (L/H) — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-425 FUSE PANEL

1 N413599 FUSE PANEL, MAIN HARNESS — REPLACE 1.2 ST ST ST 1.2 ST ST ST

2 N117500 FLASHER/RELAY ASM. TURN SIGNAL/HAZARD

WARNING — REPLACE — .2 .2 .2 — .2 .2 .2

3 N001960 RELAY, BLOWER MOTOR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

4 N359700 RELAY, IGNITION — REPLACE .2 .2 .2 — .2 .2 .2 —

N001900 RELAY ASM. HEATED REAR WINDOW —

REPLACE .2.2.2.2.2.2.2.2

5 N001930 RELAY, POWER WINDOW — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

6 N002350 RELAY, BLOWER MOTOR INHIBITOR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

7 N002000 RELAY, DRIVER WINDOW — REPLACE — .2 .2 .2 — — — —

8 N001990 RELAY, PARK LAMPS — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

9 N002400 RELAY ASM. REAR WINDSCREEN WIPER —

REPLACE .2.2.2.2.2.2.2.2

10 N414600 CIRCUIT BREAKER, MAIN WIRING HARNESS

POWER WINDOWS — REPLACE .2.2.2.2.2.2.2.2

11 N001790 CIRCUIT BREAKER, MAIN WIRING HARNESS

SEATS — REPLACE .2.2.2.2.2.2.2.2

12 N002450 RELAY ASM. LPG — REPLACE — — .2 .2 .2 .2 .2 .2

N002455 RELAY ASM. REVERSE LIGHT — REPLACE .2 .2 .2 — — — — —

13 N414505 FUSE 5 AMP — REPLACE — — — — — — — —

N414575 FUSE 7.5 AMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N414510 FUSE 10 AMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N414515 FUSE 15 AMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N414520 FUSE 20 AMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

FUSE PANEL

ELECTRICAL

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

02-425 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

N414525 FUSE 25 AMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

14 N414535 RELAY, INTERIOR LAMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-510 HEADLIGHT ON MODULE

1 N104150 MODULE, HEADLIGHTS ON WITH IGNITION —

REPLACE — .5 .5 .5 — .5 .5 .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-775 SWITCH & HARNESS - ELECTRIC

WINDOWS & MIRRORS

N526050 SWITCH ASM. VEHICLE STABILITY/PITCH CON—

TROL — REPLACE — .2 — — — .2 — —

N526010 SWITCH ASM. SUNROOF OPENING — REPAIR/

REPLACE .2.2.2.2.2.2.2.2

1 N226000 SWITCH ASM. (CONSOLE) WINDOW LIFTER ALL —

REPLACE .2.2.2.2.2.2.2.2

2 N240200 SWITCH/HARNESS, MIRROR ADJUSTMENT —

REPLACE .2.4.4.4.2.4.4.4

3 N253300 SWITCH, REAR COMPARTMENT LOCK RELEASE

— REPLACE .2.2.2.2.2.2.2.2

4 N230000 SWITCH, WINDOW LIFTER BOTH REAR DOORS —

REPLACE .5.2.2.2.5.2.2.2

N230100 SWITCH, WINDOW LIFTER RH REAR DOOR —

REPLACE .3.2.2.2.3.2.2.2

N230200 SWITCH, WINDOW LIFTER LH REAR DOOR —

REPLACE .3.2.2.2.3.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-780 INTERIOR LAMPS & SWITCHES

N216500 SWITCH, REAR COMPARTMENT LAMP —

REPLACE .2.2.2.2.2.2.2.2

N112510 LAMP ASM. REAR COMPARTMENT — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

1 N112500 LAMP ASM. DOME — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

2 N112400 COVER, DOME LAMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 N214500 LAMP ASM. GLOVE BOX — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

4 N214600 SWITCH, GLOVE BOX LAMP — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

5 N319000 LAMP, DOOR COURTESY RH FRONT — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N319100 LAMP, DOOR COURTESY LH FRONT — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N319200 LAMP, DOOR COURTESY RH REAR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N319300 LAMP, DOOR COURTESY LH REAR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

6 N212500 SWITCH, DOME LAMP/DOOR AJAR RH FRT —

REPLACE .2.2.2.2.2.2.2.2

N212510 SWITCH, DOME LAMP/DOOR AJAR LH FRT —

REPLACE .2.2.2.2.2.2.2.2

N212520 SWITCH, DOME LAMP/DOOR AJAR RH REAR —

REPLACE .2.2.2.2.2.2.2.2

N212530 SWITCH, DOME LAMP/DOOR AJAR LH REAR —

REPLACE .2.2.2.2.2.2.2.2

7 N112600 LAMP ASM. RH REAR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N112700 LAMP ASM. LH REAR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

INTERIOR LAMPS & SWITCHES

ELECTRICAL

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

02-780 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

8 N104420 BULB, VEHICLE INTERIOR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

(FOR DOME, READING, GLOVE COMPíT, FOOT—

WELL, INSTRUMENT, ETC.

NOT EXTERIOR LAMPS.)

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ELECTRICAL

02-800 SWITCHES, INSTRUMENT FASCIA

1 N220600 SWITCH, HAZARD WARNING — REPLACE — .4 .4 .4 — .4 .4 .4

2 N218500 SWITCH, HEADLAMP — REPLACE — .2 .2 .3 — .2 .2 .3

3 N833100 SWITCH, TRIP COMPUTER/OVER SPEED —

REPLACE — .2 .2 .3 — .2 .2 .3

4 N761700 SWITCH, FRONT FOG LAMPS — REPLACE — — — .4 — — — .4

— 1

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

02- 999 —

DIAGNOSTIC TROUBLE CODES

BCM, CRUISE CONTROL, CENTRAL LOCKING,

LIGHTING, SEATS, PARK ASSIST

N900001 ELECTRICAL DIAGNOSTIC CODE 01 — ST ST ST — ST ST ST

N900002 ELECTRICAL DIAGNOSTIC CODE 02 — ST ST ST — ST ST ST

N900003 ELECTRICAL DIAGNOSTIC CODE 03 — ST ST ST — ST ST ST

N900004 ELECTRICAL DIAGNOSTIC CODE 04 — ST ST ST — ST ST ST

N900005 ELECTRICAL DIAGNOSTIC CODE 05 — ST ST ST — ST ST ST

N900006 ELECTRICAL DIAGNOSTIC CODE 06 — ST ST ST — ST ST ST

N900007 ELECTRICAL DIAGNOSTIC CODE 07 — ST — ST — ST — ST

N900008 ELECTRICAL DIAGNOSTIC CODE 08 — — — ST — — — ST

N900009 ELECTRICAL DIAGNOSTIC CODE 09 — ST ST — — ST ST —

N900010 ELECTRICAL DIAGNOSTIC CODE 10 — ST ST — — ST ST —

N900011 ELECTRICAL DIAGNOSTIC CODE 11, B0011 — ST ST — — ST ST —

N900012 ELECTRICAL DIAGNOSTIC CODE 12 — ST ST — — ST ST —

N900013 ELECTRICAL DIAGNOSTIC CODE 13 — ST ST — — ST ST —

N900014 ELECTRICAL DIAGNOSTIC CODE 14 — — ——————

N900016 ELECTRICAL DIAGNOSTIC CODE 16 — — ——————

N900017 ELECTRICAL DIAGNOSTIC CODE 17 — ST — ST — ST — ST

N900018 ELECTRICAL DIAGNOSTIC CODE 18 — ST ST — — ST ST —

N900019 ELECTRICAL DIAGNOSTIC CODE 19 — ST ST — — ST ST —

N900020 ELECTRICAL DIAGNOSTIC CODE 20, U0020 0.3 ST ST — 0.3 ST ST —

N900021 ELECTRICAL DIAGNOSTIC CODE 21 — ST ST — — ST ST —

N900022 ELECTRICAL DIAGNOSTIC CODE 22 — ST ST — — ST ST —

N900023 ELECTRICAL DIAGNOSTIC CODE 23 — ST ST — — ST ST —

N900024 ELECTRICAL DIAGNOSTIC CODE 24 — ST ST — — ST ST —

N900025 ELECTRICAL DIAGNOSTIC CODE 25 — ST ST — — ST — —

N900026 ELECTRICAL DIAGNOSTIC CODE 26 — ST ST — — ST — —

N900027 ELECTRICAL DIAGNOSTIC CODE 27 — ST — — — ST — —

N900028 ELECTRICAL DIAGNOSTIC CODE 28 — ST — — — ST — —

N900032 ELECTRICAL DIAGNOSTIC CODE 32 — — ——————

N900036 ELECTRICAL DIAGNOSTIC CODE 36 — — ——————

N900041 ELECTRICAL DIAGNOSTIC CODE 41 — — ——————

N900073 ELECTRICAL DIAGNOSTIC CODE U0073 0.3 — — — 0.3 — — —

N900100 ELECTRICAL DIAGNOSTIC CODE U0100 0.3 — — — 0.3 — — —

N900101 ELECTRICAL DIAGNOSTIC CODE U0101 0.3 — — — 0.3 — — —

N900121 ELECTRICAL DIAGNOSTIC CODE U0121 0.3 — — — 0.3 — — —

N900138 ELECTRICAL DIAGNOSTIC CODE B0138A 0.3 — — — 0.3 — — —

N900140 ELECTRICAL DIAGNOSTIC CODE U0140 0.3 — — — 0.3 — — —

N900155 ELECTRICAL DIAGNOSTIC CODE U0155 0.3 — — — 0.3 — — —

N900160 ELECTRICAL DIAGNOSTIC CODE U0160 0.3 — — — 0.3 — — —

N900164 ELECTRICAL DIAGNOSTIC CODE U0164 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

BCM, CRUISE CONTROL, CENTRAL LOCKING,

LIGHTING, SEATS, PARK ASSIST

DIAGNOSTIC TROUBLE CODES

02- 999 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

N900184 ELECTRICAL DIAGNOSTIC CODE U0184 0.3 — — — 0.3 — — —

N900186 ELECTRICAL DIAGNOSTIC CODE U0186 0.3 — — — 0.3 — — —

N900198 ELECTRICAL DIAGNOSTIC CODE U0198 0.3 — — — 0.3 — — —

N900214 ELECTRICAL DIAGNOSTIC CODE U0214 0.3 — — — 0.3 — — —

N900257 ELECTRICAL DIAGNOSTIC CODE B257A 0.3 — — — 0.3 — — —

N900277 ELECTRICAL DIAGNOSTIC CODE C0277 0.3 — — — 0.3 — — —

N900297 ELECTRICAL DIAGNOSTIC CODE C0297 0.3 — — — 0.3 — — —

N900370 ELECTRICAL DIAGNOSTIC CODE B370D 0.3 — — — 0.3 — — —

N900569 ELECTRICAL DIAGNOSTIC CODE C0569 0.3 — — — 0.3 — — —

N900575 ELECTRICAL DIAGNOSTIC CODE B0575 — ST — — — ST — —

N900750 ELECTRICAL DIAGNOSTIC CODE C0750 0.3 — — — 0.3 — — —

N900755 ELECTRICAL DIAGNOSTIC CODE C0755 0.3 — — — 0.3 — — —

N900760 ELECTRICAL DIAGNOSTIC CODE C0760 0.3 — — — 0.3 — — —

N900765 ELECTRICAL DIAGNOSTIC CODE C0765 0.3 — — — 0.3 — — —

N900775 ELECTRICAL DIAGNOSTIC CODE C0775 0.3 — — — 0.3 — — —

N900785 ELECTRICAL DIAGNOSTIC CODE C0785 0.3 — — — 0.3 — — —

N900826 ELECTRICAL DIAGNOSTIC CODE P0826 0.3 — — — 0.3 — — —

N900890 ELECTRICAL DIAGNOSTIC CODE C0890 0.3 — — — 0.3 — — —

N900953 ELECTRICAL DIAGNOSTIC CODE B0953 0.3 — — — 0.3 — — —

N900954 ELECTRICAL DIAGNOSTIC CODE B0954 0.3 — — — 0.3 — — —

N900955 ELECTRICAL DIAGNOSTIC CODE B0955 0.3 — — — 0.3 — — —

N900956 ELECTRICAL DIAGNOSTIC CODE B0956 0.3 — — — 0.3 — — —

N900957 ELECTRICAL DIAGNOSTIC CODE B0957 0.3 — — — 0.3 — — —

N900958 ELECTRICAL DIAGNOSTIC CODE B0958 0.3 — — — 0.3 — — —

N900959 ELECTRICAL DIAGNOSTIC CODE B0959 0.3 — — — 0.3 — — —

N900960 ELECTRICAL DIAGNOSTIC CODE B0960 0.3 — — — 0.3 — — —

N900961 ELECTRICAL DIAGNOSTIC CODE B0961 0.3 — — — 0.3 — — —

N900967 ELECTRICAL DIAGNOSTIC CODE B0967 0.3 — — — 0.3 — — —

N900968 ELECTRICAL DIAGNOSTIC CODE B0968 0.3 — — — 0.3 — — —

N900976 ELECTRICAL DIAGNOSTIC CODE B0976 — ST — — — ST — —

N900980 ELECTRICAL DIAGNOSTIC CODE B0980 0.3 ST — — 0.3 ST — —

N900983 ELECTRICAL DIAGNOSTIC CODE B0983 0.3 — — — 0.3 — — —

N900986 ELECTRICAL DIAGNOSTIC CODE B0986 0.3 — — — 0.3 — — —

N901000 ELECTRICAL DIAGNOSTIC CODE U1000, B1000 0.3 ST — — 0.3 ST — —

N901001 ELECTRICAL DIAGNOSTIC CODE U1001, B1001 0.3 ST — — 0.3 ST — —

N901002 ELECTRICAL DIAGNOSTIC CODE U1002, B1002 — ST — — — ST — —

N901008 ELECTRICAL DIAGNOSTIC CODE B1008 0.3 — — — 0.3 — — —

N901015 ELECTRICAL DIAGNOSTIC CODE B1015 0.3 — — — 0.3 — — —

N901016 ELECTRICAL DIAGNOSTIC CODE B1016 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

BCM, CRUISE CONTROL, CENTRAL LOCKING,

LIGHTING, SEATS, PARK ASSIST

DIAGNOSTIC TROUBLE CODES

02- 999 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

N901128 ELECTRICAL DIAGNOSTIC CODE U1128 — — — — — ST — —

N901304 ELECTRICAL DIAGNOSTIC CODE U1304 0.3 — — — 0.3 — — —

N901325 ELECTRICAL DIAGNOSTIC CODE B1325 0.3 — — — 0.3 — — —

N901370 ELECTRICAL DIAGNOSTIC CODE B1370 0.3 — — — 0.3 — — —

N901380 ELECTRICAL DIAGNOSTIC CODE B1380 0.3 — — — 0.3 — — —

N901390 ELECTRICAL DIAGNOSTIC CODE B1390 0.3 — — — 0.3 — — —

N901400 ELECTRICAL DIAGNOSTIC CODE U1400 0.3 — — — 0.3 — — —

N901401 ELECTRICAL DIAGNOSTIC CODE U1401 0.3 — — — 0.3 — — —

N901410 ELECTRICAL DIAGNOSTIC CODE B1410 0.3 — — — 0.3 — — —

N901420 ELECTRICAL DIAGNOSTIC CODE B1420 0.3 — — — 0.3 — — —

N901428 ELECTRICAL DIAGNOSTIC CODE B1428 0.3 — — — 0.3 — — —

N901433 ELECTRICAL DIAGNOSTIC CODE B1433 0.3 — — — 0.3 — — —

N901440 ELECTRICAL DIAGNOSTIC CODE B1440 0.3 — — — 0.3 — — —

N901441 ELECTRICAL DIAGNOSTIC CODE B1441 0.3 — — — 0.3 — — —

N901448 ELECTRICAL DIAGNOSTIC CODE B1448 0.3 — — — 0.3 — — —

N901516 ELECTRICAL DIAGNOSTIC CODE B1516 0.3 — — — 0.3 — — —

N901517 ELECTRICAL DIAGNOSTIC CODE B1517 0.3 — — — 0.3 — — —

N901527 ELECTRICAL DIAGNOSTIC CODE B1527 0.3 — — — 0.3 — — —

N901529 ELECTRICAL DIAGNOSTIC CODE B1529 0.3 — — — 0.3 — — —

N901735 ELECTRICAL DIAGNOSTIC CODE B1735 0.3 — — — 0.3 — — —

N901740 ELECTRICAL DIAGNOSTIC CODE B1740 0.3 — — — 0.3 — — —

N901750 ELECTRICAL DIAGNOSTIC CODE B1750 0.3 — — — 0.3 — — —

N901755 ELECTRICAL DIAGNOSTIC CODE B1755 0.3 — — — 0.3 — — —

N901760 ELECTRICAL DIAGNOSTIC CODE B1760 0.3 — — — 0.3 — — —

N901814 ELECTRICAL DIAGNOSTIC CODE U1814 0.3 — — — 0.3 — — —

N901815 ELECTRICAL DIAGNOSTIC CODE B1815 0.3 — — — 0.3 — — —

N901820 ELECTRICAL DIAGNOSTIC CODE B1820 0.3 — — — 0.3 — — —

N901825 ELECTRICAL DIAGNOSTIC CODE B1825 0.3 — — — 0.3 — — —

N902099 ELECTRICAL DIAGNOSTIC CODE U2099 0.3 — — — 0.3 — — —

N902136 ELECTRICAL DIAGNOSTIC CODE U2136 0.3 — — — 0.3 — — —

N902355 ELECTRICAL DIAGNOSTIC CODE B2355 0.3 — — — 0.3 — — —

N902375 ELECTRICAL DIAGNOSTIC CODE B2375 0.3 — — — 0.3 — — —

N902530 ELECTRICAL DIAGNOSTIC CODE B2530 0.3 — — — 0.3 — — —

N902540 ELECTRICAL DIAGNOSTIC CODE B2540 0.3 — — — 0.3 — — —

N902545 ELECTRICAL DIAGNOSTIC CODE B2545 0.3 — — — 0.3 — — —

N902555 ELECTRICAL DIAGNOSTIC CODE B2555 0.3 — — — 0.3 — — —

N902565 ELECTRICAL DIAGNOSTIC CODE B2565 0.3 — — — 0.3 — — —

N902575 ELECTRICAL DIAGNOSTIC CODE B2575 0.3 — — — 0.3 — — —

N902580 ELECTRICAL DIAGNOSTIC CODE B2580 0.3 — — — 0.3 — — —

N902585 ELECTRICAL DIAGNOSTIC CODE B2585 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

BCM, CRUISE CONTROL, CENTRAL LOCKING,

LIGHTING, SEATS, PARK ASSIST

DIAGNOSTIC TROUBLE CODES

02- 999 — 4

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

N902590 ELECTRICAL DIAGNOSTIC CODE B2590 0.3 — — — 0.3 — — —

N902595 ELECTRICAL DIAGNOSTIC CODE B2595 0.3 — — — 0.3 — — —

N902600 ELECTRICAL DIAGNOSTIC CODE B2600 0.3 — — — 0.3 — — —

N902610 ELECTRICAL DIAGNOSTIC CODE B2610 0.3 — — — 0.3 — — —

N902615 ELECTRICAL DIAGNOSTIC CODE B2615 0.3 — — — 0.3 — — —

N902625 ELECTRICAL DIAGNOSTIC CODE B2625 0.3 — — — 0.3 — — —

N902645 ELECTRICAL DIAGNOSTIC CODE B2645 0.3 — — — 0.3 — — —

N902652 ELECTRICAL DIAGNOSTIC CODE B2652 0.3 — — — 0.3 — — —

N902705 ELECTRICAL DIAGNOSTIC CODE B2705 0.3 — — — 0.3 — — —

N902730 ELECTRICAL DIAGNOSTIC CODE B2730 0.3 — — — 0.3 — — —

N902745 ELECTRICAL DIAGNOSTIC CODE B2745 0.3 — — — 0.3 — — —

N902750 ELECTRICAL DIAGNOSTIC CODE B2750 0.3 — — — 0.3 — — —

N902765 ELECTRICAL DIAGNOSTIC CODE B2765 0.3 — — — 0.3 — — —

N902976 ELECTRICAL DIAGNOSTIC CODE B2976 0.3 — — — 0.3 — — —

N903006 ELECTRICAL DIAGNOSTIC CODE B3006 0.3 — — — 0.3 — — —

N903105 ELECTRICAL DIAGNOSTIC CODE B3105 0.3 — — — 0.3 — — —

N903109 ELECTRICAL DIAGNOSTIC CODE B3109 0.3 — — — 0.3 — — —

N903110 ELECTRICAL DIAGNOSTIC CODE B3110 0.3 — — — 0.3 — — —

N903111 ELECTRICAL DIAGNOSTIC CODE B3111 0.3 — — — 0.3 — — —

N903112 ELECTRICAL DIAGNOSTIC CODE B3112 0.3 — — — 0.3 — — —

N903125 ELECTRICAL DIAGNOSTIC CODE B3125 0.3 — — — 0.3 — — —

N903130 ELECTRICAL DIAGNOSTIC CODE B3130 0.3 — — — 0.3 — — —

N903135 ELECTRICAL DIAGNOSTIC CODE B3135 0.3 — — — 0.3 — — —

N903140 ELECTRICAL DIAGNOSTIC CODE B3140 0.3 — — — 0.3 — — —

N903265 ELECTRICAL DIAGNOSTIC CODE B3265 0.3 — — — 0.3 — — —

N903410 ELECTRICAL DIAGNOSTIC CODE B3410 0.3 — — — 0.3 — — —

N903415 ELECTRICAL DIAGNOSTIC CODE B3415 0.3 — — — 0.3 — — —

N903420 ELECTRICAL DIAGNOSTIC CODE B3420 0.3 — — — 0.3 — — —

N903435 ELECTRICAL DIAGNOSTIC CODE B3435 0.3 — — — 0.3 — — —

N903440 ELECTRICAL DIAGNOSTIC CODE B3440 0.3 — — — 0.3 — — —

N903445 ELECTRICAL DIAGNOSTIC CODE B3445 0.3 — — — 0.3 — — —

N903622 ELECTRICAL DIAGNOSTIC CODE B3622 0.3 — — — 0.3 — — —

N903715 ELECTRICAL DIAGNOSTIC CODE B3715 0.3 — — — 0.3 — — —

N903794 ELECTRICAL DIAGNOSTIC CODE B3794 0.3 — — — 0.3 — — —

N903867 ELECTRICAL DIAGNOSTIC CODE B3867 0.3 — — — 0.3 — — —

N903873 ELECTRICAL DIAGNOSTIC CODE B3873 0.3 — — — 0.3 — — —

N903875 ELECTRICAL DIAGNOSTIC CODE B3875 0.3 — — — 0.3 — — —

N903907 ELECTRICAL DIAGNOSTIC CODE B3907 0.3 — — — 0.3 — — —

N903913 ELECTRICAL DIAGNOSTIC CODE B3913 — — ——————

N903914 ELECTRICAL DIAGNOSTIC CODE B3914 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

BCM, CRUISE CONTROL, CENTRAL LOCKING,

LIGHTING, SEATS, PARK ASSIST

DIAGNOSTIC TROUBLE CODES

02- 999 — 5

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

N903915 ELECTRICAL DIAGNOSTIC CODE B3915 — — ——————

N903922 ELECTRICAL DIAGNOSTIC CODE B3922 0.3 — — — 0.3 — — —

N903933 ELECTRICAL DIAGNOSTIC CODE B3933 0.3 — — — 0.3 — — —

N903936 ELECTRICAL DIAGNOSTIC CODE B3936 — — ——————

N903974 ELECTRICAL DIAGNOSTIC CODE B3974 — — ——————

LTG GI_03

03-300

REFER

AA-650Q

03-325

03-075

03-650

03-400

03-165

REFER

AA-650Q

REFER

00-450

03-250

03-375 03-028 03-165

03-074

03-165

03-300A

03-165

03-750

03-074

03-055

03-300A

REFER

AA-650Q

REFER

AA-650Q

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-028 LATCH, CABLE - DOOR FUEL TANK

FILLER

1 L006220 LATCH/ACTUATOR ASM. FILLER DOOR

RELEASE — REPLACE .3 .2 .2 .2 .3 .2 .2 .2

2 L006200 DOOR ASM. FUEL TANK FILLER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 C459900 CABLE, FILLER DOOR RELEASE — REPLACE — .4 .4 .4 — .4 .4 .4

4 C459800 LEVER ASM. FILLER DOOR RELEASE —

REPLACE. — .2 .2 .2 — .2 .2 .2

5 C459810 LEVER ASM. DECK LID & FILLER DOOR

RELEASE.—REPLACE — — — — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-055 FUEL TANK

L002100 FILLER PIPE ASM. FUEL TANK — REPLACE

(SEDAN/WAGON N/A) .4 .6 .6 — .4 — — —

ADD FOR: COUPE — .4 — — — — — —

ADD FOR: REGULAR CAB/CREWMAN — .1 .1 — — — — —

L002300 HOSE, FILLER PIPE TO FUEL TANK — REPLACE

(SEDAN/WAGON N/A) .5 .6 .6 — .5 — — —

ADD FOR: COUPE — .4 — — — — — —

ADD FOR: REGULAR CAB/CREWMAN — .1 .1 — — — — —

1 L001100 FUEL TANK ASM. — R&R/REPLACE 1.3 .4 .4 .8 1.3 .8 .8 .8

ADD FOR: SEDAN/WAGON — .4 .4 — — — — —

ADD FOR: UTE — .7 .7 .3 — — — —

ADD FOR: COUPE — .6 .4 — — — — —

ADD FOR: CREWMAN — .6 .6 — — — — —

ADD FOR: ALUMINIUM TRAY (REGULAR CAB) — .4 .4 — — — — —

2 L004100 STRAP ASM. FUEL TANK SUPPORT — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

ADD FOR: UTE — .3 .3 .3 — — — —

3 L006400 CAP ASM. FUEL TANK FILLER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

R606000 CAP ASM. FUEL TANK FILLER, LOCKING —

REPLACE .2 — — — .2 — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-074 FUEL PUMP & SENDER - FUEL TANK

R606500 STONE GUARD/DEFLECTOR ASM. FUEL TANK —

REPLACE .6 .3 — — .6 — — —

J546500 CONTROLLER, FUEL PUMP SPEED — REPLACE — .4 .4 .4 — .4 .4 .4

1 L006330 MODULAR PUMP & SENDER UNIT ASM. —

REPLACE .5.4.4.8.5.8.8.8

ADD FOR: SEDAN/WAGON — .4 .4 — — — — —

ADD FOR: UTE — .7 .7 .3 — — — —

ADD FOR: COUPE — .7 .4 — — — — —

ADD FOR: CREWMAN — .6 .6 — — — — —

ADD FOR: ALUMINIUM TRAY (REGULAR CAB) — .4 .4 — — — — —

L006360 SECONDARY MODULAR PUMP & SENDER UNIT

ASM. — REPLACE 1.4 — — — 1.4 — — —

2 L006310 SEAL, MODULAR ASM. TO FUEL TANK —

REPLACE .5.4.4.8.5.8.8.8

ADD FOR: SEDAN/WAGON — .4 .4 — — — — —

ADD FOR: UTE — .7 .7 .3 — — — —

ADD FOR: COUPE — .6 .4 — — — — —

ADD FOR: CREWMAN — .6 .6 — — — — —

ADD FOR: ALUMINIUM TRAY (REGULAR CAB) — .4 .4 — — — — —

— 1

FUEL PUMP & SENDER - FUEL TANK

FUEL & EXHAUST

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

03-074 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

3 L006350 PUMP, FUEL (INTERNAL) — REPLACE .6 .4 .4 .8 .6 .8 .8 .8

ADD FOR: SEDAN/WAGON — .4 .4 — — — — —

ADD FOR: UTE — .7 .7 .3 — — — —

ADD FOR: COUPE — .6 .4 — — — — —

ADD FOR: CREWMAN — .6 .6 — — — — —

ADD FOR: ALUMINIUM TRAY (REGULAR CAB) — .4 .4 — — — — —

4 L006300 SENDER UNIT, FUEL LEVEL — R&R/REPLACE — .4 .4 .8 — .8 .8 .8

ADD FOR: SEDAN/WAGON — .4 .4 — — — — —

ADD FOR: UTE — .7 .7 .3 — — — —

ADD FOR: COUPE — .6 .4 — — — — —

ADD FOR: CREWMAN — .6 .6 — — — — —

ADD FOR: ALUMINIUM TRAY (REGULAR CAB) — .4 .4 — — — — —

5 L006340 RETAINER, MODULAR ASM TO FUEL TANK —

REPLACE — .3 .3 .8 — .8 .8 .8

ADD FOR: SEDAN/WAGON — .5 .5 — — — — —

ADD FOR: UTE — .7 .7 .3 — — — —

ADD FOR: COUPE — .7 .5 — — — — —

ADD FOR: CREWMAN — .6 .6 — — — — —

ADD FOR: ALUMINIUM TRAY (REGULAR CAB) — .4 .4 — — — — —

FUEL PUMP & SENDER - FUEL TANK

FUEL & EXHAUST

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

03-074 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

6 L006320 STRAINER, FUEL PICKUP — REPLACE — .4 .4 .8 — .8 .8 .8

ADD FOR: SEDAN/WAGON/5 DOOR HATCH — .4 .4 — — — — —

ADD FOR: UTE — .7 .7 .3 — — — —

ADD FOR: COUPE — .6 .4 — — — — —

ADD FOR: CREWMAN — .6 .6 — — — — —

ADD FOR: ALUMINIUM TRAY (REGULAR CAB) — .4 .4 — — — — —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-075 FUEL PIPES

1 L011100 PIPE, FUEL TANK TO VAPOUR CANISTER —

REPLACE — .3 .3 .3 — .3 .3 .3

2 L010100 PIPE, FUEL TANK TO ENGINE — REPLACE 4.1 .8 .8 .8 4.1 .8 .8 .8

3 J904100 PIPE, FUEL RETURN — REPLACE — .3 .3 .3 — .3 .3 .3

4 L010500 FUEL FILTER — REPLACE — .3 .3 .3 — .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-165 VAPOUR CANISTER

L008100 FUEL HOSE (TANK AREA) ANY — REPLACE — .5 .5 .5 — .5 .5 .5

L013100 SOLENOID/VALVE, CANISTER PURGE —

REPLACE .3.3.3.3.3.3.3.3

1 L014100 CANISTER, CHARCOAL — REPLACE 1.4 .3 .3 .3 1.4 .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-250 AIR CLEANER & AIR INTAKE

1 J818510 BOOT, AIR FLOW METER TO THROTTLE BODY —

REPLACE .2.2.2.2.2.2.2.2

2 N308800 SENSOR ASM. MASS AIR FLOW — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 J818520 BOOT, AIR CLEANER TO MASS AIR FLOW SEN—

SOR — REPLACE .2.2.2.2.2.2.2.2

4 J817500 BODY, AIR CLEANER UPPER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

5 J817900 ELEMENT ASM. AIR CLEANER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

6 J817600 BODY, AIR CLEANER LOWER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

7 J724200 SENSOR, INTAKE AIR TEMP. — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

8 J818530 DUCT ASM. AIR INTAKE TO AIR CLEANER —

REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-300 THROTTLE BODY & ADAPTOR

J589300 VACUUM HOSE (ANY ONE) — REPAIR/REPLACE .3 .3 .3 .3 .3 .3 .3 .3

J589100 S/C BYPASS VALVE ACTUATOR — REPLACE — — .4 .4 — — .4 .4

J589400 S/C BOOST CONTROL SOLENOID VALVE —

REPLACE — — .3 .3 — — .3 .3

J589200 S/C BYPASS SOLENOID — REPLACE — — .3 .3 — — .3 .3

1 J805170 BODY ASM. THROTTLE — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

ADD FOR: V6 SUPERCHARGED — — .1 .1 — — .1 .1

J805200 GASKET, THROTTLE BODY TO ADAPTOR —

REPLACE — — .3 .3 — — .3 .3

J805210 ADAPTOR ASM. THROTTLE BODY (S/C ONLY) —

REPLACE — — .4 .4 — — .4 .4

2 J805220 GASKET/SEAL, THROTTLE B ODY — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

ADD FOR: V6 SUPERCHARGED — — .1 .1 — — .1 .1

3 N308700 SWITCH/SENSOR, THROTTLE POSITION —

REPLACE — .4 .4 .4 — .4 .4 .4

4 J971800 MOTOR/VALVE ASM. (IAC) IDLE AIR — REPLACE — .4 .4 .4 — .4 .4 .4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-300A EGR VALVE & SECONDARY AIR

INJECTION

J980500 VALVE EGR &/OR GASKET — REPLACE — — .3 .3 — — .3 .3

1 J980800 PUMP ASM, SECONDARY AIR — REPLACE — — — — — — — —

2 J980910 VALVE, SWITCH OVER, SECONDARY AIR —

REPLACE ————————

3 J980930 COMBINATION VALVE/SEAL, SECONDARY AIR —

REPLACE ————————

4 J980700 VALVE, NON RETURN, SECONDARY AIR —

REPLACE ————————

5 J980710 HOSES, AIR DUCT, SECONDARY AIR PUMP, —

REPLACE ————————

6 J980600 PIPES, SECONDARY AIR — REPLACE — — — — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-325 THROTTLE CABLE

J816800 RELAXER, ACCELERATOR CABLE CONTROL —

REPLACE — — .3 .3 — — .3 .3

1 J816900 CABLE ASM. ACCELERATOR CONTROL —

REPLACE — — .3 .3 — — .3 .3

2 J816910 CAM/BRACKET — THROTTLE & CRUISE CABLE

SUPPORT — REPLACE — — .2 .2 — — .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-375 FUEL INJECTION RAIL & HOSES

1 J901000 RAIL ASM. FUEL — REPLACE .5 .5 .7 .7 .5 .5 .7 .7

ADD FOR: GEN III, GEN IV — .2 — — — .2 — —

ADD FOR: HFV6 .3 — — — .3 — — —

ADD FOR: V6 SUPERCHARGED — — .2 .2 — — .2 .2

2 J900000 INJECTOR ASM. FUEL — REPLACE (ONE/ALL) .6 .4 .4 .4 .6 .4 .4 .4

ADD FOR: HFV6 .3 .2 — — .3 .2 — —

ADD FOR: V6 SUPERCHARGED — — .2 .2 — — .2 .2

ADD TO: REPLACE EACH ADDITIONAL INJEC—

TOR ——.1.1——.1.1

ADD TO: REPLACE ALL INJECTORS — .1 .3 .3 — .1 .3 .3

3 J901010 SEAL, INJECTOR FUEL UPPER/LOWER —

REPLACE .6.4.4.4.6.4.4.4

ADD FOR: HFV6 .3 .2 — — .3 — — —

ADD FOR: V6 SUPERCHARGED — — .2 .2 — — .2 .2

ADD TO: REPLACE EACH ADDITIONAL INJEC—

TOR SEAL — — .1 .1 — — .1 .1

ADD TO: REPLACE ALL INJECTOR SEALS — .1 .3 .3 — .1 .3 .3

4 J903000 REGULATOR, FUEL RAIL/PRESSURE — REPLACE — .3 .3 .3 — .3 .3 .3

5 J901200 HOSE, ENGINE FUEL RETURN TO FUEL RETURN

PIPE — REPLACE — .3 .3 .3 — .3 .3 .3

6 J901100 HOSE, FUEL FEED PIPE TO ENGINE FUEL FEED —

REPLACE — .3 .3 .3 — .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-400 CRUISE CONTROL

R902100 CRUISE CONTROL — ADJUST — — .2 .2 — — .2 .2

R403100 MOTOR & CABLE ASM. CRUISE CONTROL —

REPLACE — — .3 .3 — — .3 .3

R401100 SWITCH, CRUISE CONTROL ACTUATOR —

REPLACE — .3 .3 .3 — .3 .3 .3

1 R400100 MOTOR, CRUISE CONTROL — REPLACE — — .3 .3 — — .3 .3

2 R401200 CABLE, CRUISE CONTROL MOTOR — REPLACE — — .2 .2 — — .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-650 ACCELERATOR PEDAL

J496030 SENSOR, ACCELERATOR PEDAL POSITION —

REPLACE .4 .4 — — .4 .4 — —

1 J816500 SUPPORT ASM. PEDAL LEVER — REPLACE — — .3 .3 — — .3 .3

2 J815500 LEVER ASM. ACCELERATOR CONTROL —

REPLACE .4 — .3 .3 .4 — .3 .3

3 J814500 SPRING, THROTTLE RETURN — REPLACE — — .2 .2 — — .2 .2

4 J815600 PAD/PEDAL, ACCELERATOR PEDAL — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FUEL & EXHAUST

03-750 EXHAUST PIPE & MUFFLER

1 L504150 ENGINE PIPE/CATALYTIC CONVERTER, (ONE

PIECE/BOTH) — REPLACE .4 .6 .6 .6 .4 .6 .6 .6

ADD FOR: HFV6 .1 — — — .1 — — —

L504200 ENGINE PIPE/CATALYTIC CONVERTER (RH) —

REPLACE — .5 .5 .5 — .5 .5 .5

ADD FOR: HFV6 .1 — — — .1 — — —

L504100 ENGINE PIPE/CATALYTIC CONVERTER (LH) —

REPLACE — .5 .5 .5 — .5 .5 .5

ADD FOR: HFV6 .1 — — — .1 — — —

2 L503100 PIPE/MUFFLER ASM. EXHAUST INTERIM —

REPLACE .4.6.6.6.4.6.6.6

3 L503500 MUFFLER/TAIL PIPE ASM. EXHAUS T — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

L503510 MUFFLER/TAIL PIPE ASM. EXHAUST — REPLACE

R/H .3———.3———

4 L501100 GASKET/SEALING RING, (ANY) — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

5 L512210 INSULATOR, INTERMEDIATE EXHAUST PIPE

SUPPORT — REPLACE .2.2.2.2.2.2.2.2

6 L512230 INSULATOR, EXHAUST TAIL PIPE SUPPORT —

REPLACE .2.2.2.2.2.2.2.2

7 L512240 INSULATOR, FRONT PIPE SUPPORT — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

8 L512220 HANGER/BRACKET {EXHAUST} — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

9 R607500 EXTENSION, TAIL PIPE — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

10 L509500 HEATSHIELD, INTERMEDIATE MUFFLER (RH) —

REPLACE .3.3.3.3.3.3.3.3

— 1

EXHAUST PIPE & MUFFLER

FUEL & EXHAUST

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

03-750 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

L509600 HEATSHIELD, INTERMEDIATE MUFFLER —

REPLACE .3.3.3.3.3.3.3.3

11 L509700 HEATSHIELD, REAR MUFFLER — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

L509710 HEATSHIELD, REAR MUFFLER — REPLACE R/H .3 — — — .3 — — —

LTG GI_04A

04-150 04-999

04-210

04-150

04-200

04-010

04-170

04-190

04-200

04-010

04-22004-020

DIAGNOSTIC

TROUBLE CODES

AUTO TRANS

LTG GI_04B

04-730

04-999A 04-825

04-750

04-755

04-825

04-725

04-600

04-675

04-825

04-730

04-750

04-805

04-750

04-755

04-725

DIAGNOSTIC

TROUBLE CODES

ABS

LTG GI_04M

04-060

04-010 04-090

04-125

04-020

04-075

04-100

LTG GI_04T

04T-050

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-010 MOUNTING - TRANSMISSION TO ENGINE

1 K604200 TUBE, TRANS. OIL FILLER — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

2 K604400 COVER, CONVERTER/CLUTCH — REPLACE .2 .4 .4 .4 .2 .4 .4 .4

3 K604300 INDICATOR ASM. AUTO OIL LEVEL — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

4 K604500 BOLT, CONVERTER TO DRIVEPLATE — REPLACE .4 .6 .6 .6 .4 .6 .6 .6

ADD FOR: GEN III, GEN IV — .3 .3 .3 — .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-020 MOUNTING - TRANSMISSION REAR

1 J338000 INSULATOR ASM. POWER PLANT REAR —

REPLACE .3.4.4.4.3.4.4.4

2 J338010 SUPPORT ASM. REAR — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

3 F913800 BRIDGE, CROSSMEMBER CENTRE — REPLACE — — — — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-050 TRANSFER CASE

K400140 SEAL, FRONT OUTPUT SHAFT OIL — REPLACE — .6 .6 — — — — —

K400150 SEAL, REAR OUTPUT SHAFT OIL — REPLACE — 1.0 1.0 — — — — —

1 K400100 TRANSFER CASE ASSY. — REPLACE — 1.3 1.3 — — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

2 K400110 TRANSFER CASE ASSY. — OVERHAUL — — — — — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

3 K400150 SEAL/FLANGE, TRANSFER CASE ASSY —

REPLACE ————————

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-060 GEAR LEVER - M/T

K103100 SHIFT CONTROL MECHANISM — R&R/REPLACE

(M/T) — .4 .4 .4 — — — —

ADD FOR: HFV6 —.4——————

1 K101100 KNOB, GEAR SELECTOR LEVER — REPLACE (V6

ONLY) — .3 .3 .2 — — — —

2 K200100 SEAL, GEARSHIFT TO FLOOR — REPLACE (M/T) — .3 .3 .3 — — — —

3 K104100 LEVER, GEAR SHIFT CONTROL — REPLACE (M/T) — .5 .5 .5 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-075 TRANSMISSION HARNESS

1 N482699 HARNESS ASM. TRANS. EXTERNAL — REPLACE — — — — — — — —

2 N209500 SWITCH, REVERSE LIGHT — REPLACE .3 .5 .5 .5 — .5 .5 .5

3 N316650 SENDER ASM. VEHICLE SPEED — REPLACE .3 .4 .4 .4 — .4 .4 .4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-090 TRANSMISSION - M/T

K205100 MANUAL TRANS. ASM — R&R/REPLACE 1.8 1.8 2.3 2.3 — — — —

ADD FOR: GEN III, GEN IV .8 .8 .3 .3 — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

K204110 PIPE/HOSE, BREATHER/OIL COLLECTION —

REPLACE .4 .4 .4 .4 — .4 .4 .4

K500400 SOLENOID ASM, REVERSE LOCK OUT —

REPLACE .4 .4 .4 .4 — — — —

1 K009710 FORK, M/T SHIFT, ANY ONE — REPLACE — — — — — — — —

2 K205170 COVER, MANUAL TRANS CASE — REPLACE — — — — — — — —

3 K205200 CASE ASM. MANUAL TRANS — REPLACE — — — — — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-100 EXTENSION HOUSING, SEAL &

GEARSHIFT MECHANISM - M/T

K107500 CABLE, GEARSHIFT CONTROL (ONE/BOTH) —

REPLACE ————————

K103100 SHIFT CONTROL MECHANISM — R&R/REPLACE

(M/T) — .4 .4 .4 — — — —

ADD FOR: HFV6 —.6——————

1 K200200 SEAL, GEARSHIFT CONTROL LOWER — REPLACE

(M/T) — .3 .3 .3 — — — —

2 K203200 COVER/GASKET, GEARSHIFT MECHANISM —

REPLACE (GENIII) ONLY — 2.7 2.7 2.7 — — — —

3 K202100 SEAL EXTENSION HOUSING OIL — REPLACE M/T — .6 .6 .6 — — — —

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — — — —

4 K201500 HOUSING ASM. M/T EXTENSION — REPLACE (V6

ONLY) —1.2——————

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-125 TRANSMISSION - INTERNAL M/T

*** PRIOR ZONE APPROVAL REQUIRED FOR ALL

INTERNAL TRANSMISSION REPAIRS ***

K205110 MANUAL TRANS. ASM. — R&R/OVERHAUL — 1.8 2.3 2.3 — — — —

ADD FOR: GEN III, GEN IV — .8 .3 .3 — — — —

ADD FOR: OVERHAUL HFV6 — 2.6 — — — — — —

ADD FOR: OVERHAUL GEN III, GEN IV — 5.5 5.5 5.5 — — — —

1 K108000 SHAFT, M/T SHIFT — REPLACE — — — — — — — —

2 K108100 FORK, M/T SHIFT, ANY ONE — REPLACE — 3.0 3.5 3.5 — — — —

ADD FOR: GEN III, GEN IV — .5 — — — — — —

3 K202500 GEAR, SPEEDOMETER DRIVE — REPLACE M/T — — — — — — — —

4 K108200 GEAR/SYNCHRO ASM. (1ST) — REPLACE — 2.8 4.9 4.9 — — — —

ADD FOR: GEN III, GEN IV — 2.1 — — — — — —

K108210 GEA R/SYNCHRO ASM. (2ND) — REPLACE — 3.0 5.0 5.0 — — — —

ADD FOR: GEN III, GEN IV — 2.0 — — — — — —

K108220 GEA R/SYNCHRO ASM. (3RD) — REPLACE — 2.8 4.6 4.6 — — — —

ADD FOR: GEN III, GEN IV — 1.8 — — — — — —

K108230 GEAR/SYNCHRO ASM. (4TH) — REPLACE — 2.9 4.1 4.1 — — — —

ADD FOR: GEN III, GEN IV — 1.2 — — — — — —

K108240 GEAR/SYNCHRO ASM. (5TH) — REPLACE — 3.0 3.8 3.8 — — — —

ADD FOR: GEN III, GEN IV — .8 — — — — — —

K108250 GEAR/SYNCHRO ASM. (6TH) — REPLACE — 2.8 3.8 3.8 — — — —

ADD FOR: GEN III, GEN IV — 1.0 — — — — — —

— 1

TRANSMISSION - INTERNAL M/T

TRANSMISSION, ESP & BRAKES

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

04-125 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

K108280 GEA R ASM. (REVERSE) — REPLACE — 2.8 3.7 3.7 — — — —

ADD FOR: GEN III, GEN IV — .9 — — — — — —

5 K108300 BEARING ASM. M/T INTERNAL ANY ONE —

REPLACE — 3.2 5.0 5.0 — — — —

ADD FOR: GEN III, GEN IV — 1.8 — — — — — —

ADD TO REPLACE ALL BEARINGS GEN III, GEN

IV —.8——————

ADD TO REPLACE ALL BEARINGS HFV6 — 1.2 — — — — — —

6 K108400 SHAFT ASM. M/T MAIN — REPLACE — 2.2 5.3 5.3 — — — —

ADD FOR: GEN III, GEN IV — 3.1 — — — — — —

7 K108500 GEAR, COUNTER (CLUSTER) — REPLACE — — — — — — — —

8 K108600 SEAL, INPUT SHAFT — REPLACE — 2.0 5.3 5.3 — — — —

ADD FOR: GEN III, GEN IV — 3.3 — — — — — —

9 K108700 BEARING ASM. INPUT SHAFT — REPLACE — 2.0 5.3 5.3 — — — —

ADD FOR: GEN III, GEN IV — 3.3 — — — — — —

10 K108800 SHAFT/GEAR, INPUT — REPLACE — 2.0 5.3 5.3 — — — —

ADD FOR: GEN III, GEN IV — 3.3 — — — — — —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-150 TRANSMISSION OIL COOLER & PIPES -

AUTO

K603000 UNION/PIPE A SM, ONE/BOTH TRANS TO OIL

COOLER HOSE — REPLACE .4.5.5.5.4.5.5.5

K204110 PIPE/HOSE, BREATHER/OIL COLLECTION —

REPLACE — .4 .4 .4 — .4 .4 .4

1 K603100 HOSE/PIPE ASM. OIL COOLER TO TRANS

(INLET) — REPLACE — .5 .5 .5 — .5 .5 .5

ADD FOR: 5 SPEED AUTO — .1 — — — .1 — —

K603150 PIPE ASM, TRANSMISSION COOLER — REPLACE .4 — — — .4 — — —

ADD FOR 4 SPEED AUTO .2 — — — — — — —

2 K603200 HOSE/PIPE ASM. TRANS TO OIL COOLER (OUT—

LET) — REPLACE — .5 .5 .5 — .5 .5 .5

ADD FOR: 5 SPEED AUTO — .1 — — — .1 — —

3 K605300 PIPE, RADIATOR TO TRANS HOSE (INLET) —

REPLACE — .4 .4 .4 — .4 .4 .4

4 K605100 PIPE, OIL COOLER (OUTLET) — REPLACE — .4 .4 .4 — .4 .4 .4

5 K605200 HOSE, OIL COOLER (INLET) — REPLACE — .4 .4 .4 — .4 .4 .4

6 K605400 PIPE, RADIATOR CROSSOVER — REPLACE — .4 .4 .4 — .4 .4 .4

7 K902300 OIL COOLER, TRANSMISSION — REPLACE — .5 .5 .5 — .5 .5 .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-170 TRANSMISSION SHIFT CONTROL - AUTO

K509600 CONTROL UNIT, AUTO TRANSMISSION —

REPLACE .4 .4 — — .4 .4 — —

1 K506100 ROD, SELECTOR CONTROL (AUTO) — REPLACE .2 .4 .4 .4 .2 .4 .4 .4

K503100 CABLE, FLOOR SHIFT CONTROL — REPLACE — .6 .6 — — — — —

2 N206500 SWITCH/HARNESS ASM. NEUTRAL START —

REPLACE .3 .4 .4 .4 — .4 .4 .4

3 N482699 HARNESS ASM. TRANS EXTERNAL — REPLACE — — — — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-190 TRANSMISSION SELECTOR CONTROL -

AUTO

K600550 BOOT, AUTO TRANSMISSION SELECTOR — R&R/

REPLACE — .4 .4 — — .4 .4 —

1 K500100 LEVER ASM. SELECTOR (AUTO FLOOR SHIFT) —

REPLACE .9.8.8.8.9.8.8.8

2 K500110 BUTTON, LEVER ASM FLR SHIFT CONTROL

(AUTO) — REPLACE .3.4.4.8.3.4.4.8

3 K508220 COVER, TRANSMISSION SELECTION CONTROL —

REPLACE (AUTO) .4 .4 .4 .8 .4 .4 .4 .8

4 K508100 SCALE TRANSMISSION CONTROL — REPLACE .4 .4 .4 .8 .4 .4 .4 .8

5 C474210 SUPPORT ASM. TRANSMISSION CONTROL INDI—

CATOR — REPLACE — .4 .4 .8 — .4 .4 .8

6 K500120 SWITCH — POWER/ECONOMY/OVERDRIVE —

REPLACE — .4 .4 .8 — .4 .4 .8

7 N220900 SWITCH, TRACTION CONTROL — REPLACE .2 .4 .4 .8 .2 .4 .4 .8

N220950 SWITCH — LPG/ULP CHANGE OVER — REPLACE — — .4 .8 — — .4 .8

8 N221000 BULB, SHIFT CONTROL — REPLACE .4 .4 .4 .8 .4 .4 .4 .8

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-200 TRANSMISSION - AUTO

K000225 AUTO TRANS ASM. — SRTA CHANGEOVER PRO—

GRAM 2.5 2.6 2.6 2.6 2.6 2.9 2.6 2.6

ADD FOR: AWD (GEN III, GEN IV ONLY) — .4 .4 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.3——————

ADD FOR: GEN III, GEN IV — .5 .5 .5 — .2 .5 .5

ADD FOR: 5 SPEED AUTO .1 .3 — — — — — —

ADD FOR: 6 SPEED AUTO .1 — — — .1 — — —

ADD TO: FLUSH COOLER & CHECK FLOW — .4 .4 .4 — .4 .4 .4

K700100 AUTO TRANS ASM. — AC DELCO (POLICY

REPAIRS ONLY) 2.5 2.6 2.6 2.6 2.6 2.9 2.6 2.6

ADD FOR: AWD (GEN III, GEN IV ONLY) — .4 .4 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.3——————

ADD FOR: GEN III, GEN IV — .5 .5 .5 — .2 .5 .5

ADD FOR: 5 SPEED AUTO .1 .3 — — — — — —

ADD FOR: 6 SPEED AUTO .1 — — — .1 — — —

ADD TO: FLUSH COOLER & CHECK FLOW — .4 .4 .4 — .4 .4 .4

*** PRIOR ZONE APPROVAL REQUIRED ***

K700500 AUTO TRANS ASM. — R&R 2.5 2.6 2.6 2.6 2.6 2.9 2.6 2.6

ADD FOR: AWD (GEN III, GEN IV ONLY) — .4 .4 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.3——————

ADD FOR: GEN III, GEN IV — .5 .5 .5 — .2 .5 .5

ADD FOR: 5 SPEED AUTO .1 .3 — — — — — —

ADD FOR: 6 SPEED AUTO .1 — — — .1 — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

— 1

TRANSMISSION - AUTO

TRANSMISSION, ESP & BRAKES

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

04-200 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

K600500 AUTO TRANS. OIL PRESSURE — CHECK — .7 .7 .7 — .7 .7 .7

K600600 TRANSMISSION COOLER FLUSH/FLOW CHECK — .4 .4 .4 — .4 .4 .4

*** PRIOR ZONE APPROVAL REQUIRED ***

1 K701100 CONVERTER ASM. — REPLACE 2.6 2.6 2.6 2.6 2.7 2.9 2.6 2.6

ADD FOR: GEN III, GEN IV — .5 .5 .5 — .2 .5 .5

ADD FOR: AWD (GEN III, GEN IV ONLY) — .2 .2 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.3——————

ADD FOR: 5 SPEED AUTO .1 .3 — — — — — —

ADD FOR: 6 SPEED AUTO .1 — — — .1 — — —

K702100 SEAL, CONVERTER OIL — REPLACE 2.6 2.8 2.8 2.8 2.7 2.8 2.8 2.8

ADD FOR: GEN III, GEN IV — .5 .5 .5 — .2 .5 .5

ADD FOR: AWD (GEN III, GEN IV ONLY) — .2 .2 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.3——————

ADD FOR: 5 SPEED AUTO .1 .3 — — — — — —

ADD FOR: 6 SPEED AUTO .1 — — — .1 — — —

2 K703100 OIL PUMP ASM. — R&R/REPLACE — 3.2 3.2 3.2 — 3.5 3.2 3.2

ADD FOR: GEN III, GEN IV — .5 .5 .5 — .2 .5 .5

ADD FOR: AWD (GEN III, GEN IV ONLY) — .2 .2 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.3——————

ADD TO: OVERHAUL — .9 .9 .9 — .9 .9 .9

TRANSMISSION - AUTO

TRANSMISSION, ESP & BRAKES

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

04-200 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

3 K703170 SEAL/GASKET, OIL PUMP — REPLACE 2.9 3.2 3.2 3.2 — 3.5 3.2 3.2

ADD FOR: GEN III, GEN IV — .5 .5 .5 — .2 .5 .5

ADD FOR: AWD (GEN III, GEN IV ONLY) — .2 .2 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.3——————

4 K603000 UNION/PIPE ASM, ONE/B OTH TRANS TO OIL

COOLER HOSE — REPLACE — .5 .5 .5 — .5 .5 .5

5 K608150 SEAL, EXTENSION HOUSING/REAR COVER —

REPLACE .7 .9 .9 .9 — .9 .9 .9

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

6 K608100 EXTENSION/ADAPTOR HOUSING/REAR COVER —

R&R/REPLACE .7 .9 .9 .9 — .9 .9 .9

ADD FOR: AWD (GEN III, GEN IV ONLY) — .2 .2 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.2——————

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

7 K608120 BUSH, EXTENSION HOUS ING — REPLACE .8 1.0 1.0 1.0 — 1.0 1.0 1.0

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

8 K608200 SEAL ASM. EXTENSION/ADAPTOR HOUSING —

REPLACE .6.5.5.5.6.5.5.5

ADD FOR: AWD (GEN III, GEN IV ONLY) — .2 .2 — — — — —

ADD FOR: AWD (HFV6 ONLY) —.2——————

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

9 K607250 SEAL, VEHICLE SPEED SENDER — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

10 N316650 SENDER ASM. VEHICLE SPEED — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-210 SERVOS-AUTO TRANSMISSION'

1 K600100 SERVO PISTON ASM. 2ND APPLY — REPLACE — .9 .9 .9 — .9 .9 .9

2 K600150 SERVO PISTON ASM. 4TH APPLY — REPLACE — .9 .9 .9 — .9 .9 .9

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-220 OIL PAN, GASKET & FILTER - AUTO

TRANSMISSION

K600320 SWITCH, VALVE BODY FLUID TEMPERATURE —

REPLACE ————————

1 K611100 PAN/GASKET, AUTO TRANS OIL — R&R/REPLACE .4 .5 .5 .5 .5 .5 .5 .5

ADD FOR: 5 SPEED 6 SPEED AUTO .1 — — — — — — —

2 K611200 FILTER/SEAL ASM. AUTO OIL — REPLACE .4 .5 .5 .5 .5 .5 .5 .5

ADD FOR: 5 SPEED 6 SPEED AUTO .1 — — — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-600 BRAKE & CLUTCH PEDAL CONTROL

1 N207500 SWITCH, STOP LIGHT/CRUISE CONTROL —

REPLACE .2.4.4.4.2.4.4.4

N207550 SWITCH, CRUISE CONTROL (CLUTCH) —

REPLACE — .4 .4 .4 — — — —

2 H301100 PAD, BRAKE PEDAL — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 H301000 PEDAL ASM. BRAKE — REPLACE .4 2.5 2.5 2.5 .4 2.5 2.5 2.5

4 H302100 SPRING, BRAKE PEDAL RETURN — REPLACE — 2.5 2.5 2.5 — 2.5 2.5 2.5

5 K001200 PAD, CLUTCH PEDAL — REPLACE .2 .2 .2 .2 .2 — — —

6 K001100 PEDAL ASM, CLUTCH — REPLACE .5 .6 .6 .6 .5 — — —

7 K006100 SPRING, CLUTCH PEDAL RETURN — REPLACE — .6 .6 .6 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-675 PARK BRAKE

1 H325100 LEVER ASM. PARK BRAKE — REPLACE 1.2 .6 .6 .6 1.2 .6 .6 .6

2 C474700 COVER ASM. COMPLETE PARK BRAKE LEVER —

REPLACE — .2 .2 .2 — .2 .2 .2

3 N208500 SWITCH, PARK BRAKE WARNING LAMP —

REPLACE .4.6.6.6.4.6.6.6

4 H327300 CABLE ASM. PARK BRAKE FRONT/CENTRE —

REPLACE 1.6 1.2 1.2 1.2 1.6 1.2 1.2 1.2

H321000 CABLE ASM. PARK BRAKE REAR BOTH SIDES —

REPLACE .8.4.4.4.8.4.4.4

H321100 CABLE ASM. PARK BRAKE RH REAR — REPLACE .7 .3 .3 .3 .7 .3 .3 .3

H321200 CABLE ASM. PARK BRAKE LH REAR — REPLACE .7 .3 .3 .3 .7 .3 .3 .3

5 H325500 KNOB/SPRING, PARK BRAKE LEVER — REPLACE — .2 .2 .2 — .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-725 BRAKE MAIN CYLINDER

H902500 BRAKE SYSTEM — BLEED .2 .4 .4 .4 .2 .4 .4 .4

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

H401100 SWITCH, BRAKE PRESSURE WARNING —

REPLACE .2.2.2.2.2.2.2.2

H408500 VALVE, PROPORTIONING OR LOAD SENSING —

REPLACE — .8 .8 .8 — — — —

1 H400100 CYLINDER, BRAKE MASTER — REPLACE .5 .8 .8 .8 .5 .8 .8 .8

2 H502500 BOOSTER ASM. POWER BRAKE — R&R/REPLACE 1.2 1.4 1.4 1.4 1.2 1.4 1.4 1.4

3 H504100 VALVE A SM/GROMMET, CHECK POWER BRAKE —

REPLACE .2.2.2.2.2.2.2.2

H503100 HOSE, CHECK VALVE VACUUM — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

4 H400200 RESERVOIR, BRAKE MASTER CYLINDER —

REPLACE .3.4.4.4.3.4.4.4

5 H400250 SEAL/CAP, RESERVOIR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-730 ESP & ABS BRAKING SYSTEM

N221320 SENSOR, YAW RATE/ACCELERATION (ESP) —

REPLACE 1.3 .4 — — 1.3 .4 — —

N221330 SENSOR, ACCELEROMETER BRAKE CONTROL

(AWD) — REPLACE —.4——————

1 H901100 HYDRAULIC MODULATOR (ABS) — REPLACE .7 1.0 1.0 1.0 .7 1.0 1.0 1.0

2 N506700 CONTROL UNIT/MODULE, (ABS) — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

3 H901300 SENSOR, ABS WHEEL SPEED BOTH FRONT —

REPLACE .8.8.8.8.8.8.8.8

H901320 SENSOR, ABS WHEEL SPEED RH FRONT —

REPLACE .5.5.5.5.5.5.5.5

H901340 SENSOR, ABS WHEEL SPEED LH FRONT —

REPLACE .5.5.5.5.5.5.5.5

H901400 SENSOR, ABS WHEEL SPEED BOTH REAR —

REPLACE .4.5.5.5.4.5.5.5

H901420 SENSOR, ABS WHEEL SPEED RH REAR —

REPLACE .2.4.4.4.2.4.4.4

H901440 SENSOR, ABS WHEEL SPEED LH REAR —

REPLACE .2.4.4.4.2.4.4.4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-750 BRAKE PIPES AND HOSES

1 H404100 PIPE ASM. MASTER CYLINDER TO FRONT CALI—

PER HOSE RH — REPLACE — .6 .6 .6 — — — —

2 H404200 PIPE ASM. MASTER CYLINDER TO FRONT CALI—

PER HOSE LH — REPLACE — .6 .6 .6 — — — —

3 H402000 HOSE, FRONT BRAKE — REPLACE BOTH SIDES .5 .6 .6 .6 .5 .6 .6 .6

H402100 HOSE, FRONT BRAKE RH — REPLACE .3 .5 .5 .5 .3 .5 .5 .5

H402200 HOSE, FRONT BRAKE LH — REPLACE .3 .5 .5 .5 .3 .5 .5 .5

4 H107000 CALIPER ASM. BOTH FRONT— REPLACE .6 .7 .7 .7 .6 .7 .7 .7

H107100 CALIPER ASM. RH FRONT — REPLACE .5 .5 .5 .5 .5 .5 .5 .5

H107200 CALIPER ASM. LH FRONT — REPLACE .5 .5 .5 .5 .5 .5 .5 .5

H105000 PADS, BOTH FRONT WHEELS DISC BRAKE —

REPLACE .4.5.5.5.4.5.5.5

5 H406110 PIPE ASM. MASTER CYLINDER TO RR BRAKE RH

— REPLACE — — 1.0 1.0 — — — —

6 H412000 HOSE, RR BRAKE — REPLACE BOTH SIDES .5 .6 .6 .6 .5 .6 .6 .6

H412100 HOSE, RR BRAKE RH — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

H412200 HOSE, RR BRAKE LH — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

7 H406100 PIPE ASM. BRAKE HOSE TO RH RR CALIPER —

REPLACE — .5 .5 .5 — .5 .5 .5

H406200 PIPE ASM. BRAKE HOSE TO LH RR CALIPER —

REPLACE — .5 .5 .5 — .5 .5 .5

8 H404300 PIPE ASM. RR BRAKE CROSSOVER — REPLACE — .5 .5 .5 — .5 .5 .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-755 BRAKE PIPES ABS

H406120 PIPE ASM. MODULATOR TO RR BRAKE RH —

REPLACE 4.1 1.0 1.0 1.0 4.1 1.0 1.0 1.0

H406220 PIPE ASM. MODULATOR TO RR BRAKE LH —

REPLACE 4.1 1.0 1.0 1.0 4.1 1.0 1.0 1.0

1 H402600 PIPE ASM. MASTER CYLINDER (REAR) TO MOD—

ULATOR — REPLACE 4.1 .5 .5 .5 4.1 .5 .5 .5

2 H402400 PIPE ASM. MODULATOR TO R/H FRONT BRAKE

HOSE — REPLACE .4.5.5.5.4.5.5.5

3 H402500 PIPE ASM. MODULATOR TO L/H FRONT BRAKE

HOSE — REPLACE 4.0 .5 .5 .5 4.0 .5 .5 .5

4 H402300 PIPE ASM. MASTER CYLINDER (FRONT) TO

MODULATOR — REPLACE .4.5.5.5.4.5.5.5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-805 HUB & DISC FRONT WHEEL

1 E115000 HUB/OR BEARING, FRONT WHEEL BOTH SIDES —

REPLACE .8.8.8.8.8.8.8.8

E115100 HUB/OR BEARING, FRONT WHEEL RH —

REPLACE .5.5.5.5.5.5.5.5

E115200 HUB/BEARING, FRONT WHEEL LH — REPLACE .5 .5 .5 .5 .5 .5 .5 .5

2 E006100 STUD/BOLT, FRONT WHEEL RH — REPLACE (ONE

OR ALL) .4 .5 .5 .5 .4 .5 .5 .5

E006200 STUD/BOLT, FRONT WHEEL LH — REPLACE (ONE

OR ALL) .4 .5 .5 .5 .4 .5 .5 .5

3 FOR V & W SERIES BRAKE SHUDDER COM—

PLAINTS.

REFER TO SPECIAL OPERATIONS, SECTION 99—

150

OR DEALER LETTER 18/05

H106000 DISC ASM. FRONT BRAKE BOTH SIDES — R&R .4 .4 .4 .4 .4 .4 .4 .4

H106100 DISC ASM. FRONT BRAKE RH — R&R .3 .3 .3 .3 .3 .3 .3 .3

H106200 DISC ASM. FRONT BRAKE LH — R&R .3 .3 .3 .3 .3 .3 .3 .3

4 H108000 SHIELD, DISC BRAKE SPLASH BOTH SIDES —

REPLACE .7.8.8.8.7.8.8.8

H108100 SHIELD, DISC BRAKE SPLASH RH — REPLACE .4 .5 .5 .3 .4 .5 .5 .5

H108200 SHIELD, DISC BRAKE SPLASH LH — REPLACE .4 .5 .5 .3 .4 .5 .5 .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

TRANSMISSION, ESP & BRAKES

04-825 REAR BRAKES

1 FOR V & W SERIES BRAKE SHUDDER COM—

PLAINTS.

REFER TO SPECIAL OPERATIONS, SECTION 99—

150

OR DEALER LETTER 18/05

H126000 DISC ASM. REAR BRAKE BOTH SIDES — R&R .4 .5 .5 .5 .4 .5 .5 .5

H126100 DISC ASM. REAR BRAKE RH — R&R .3 .4 .4 .4 .3 .4 .4 .4

H126200 DISC ASM. REAR BRAKE LH — R&R .3 .4 .4 .4 .3 .4 .4 .4

2 H327000 SHOES/LINING ASM. REAR PARK BRAKE BOTH —

REPLACE .8 1.0 1.0 1.0 .8 1.0 1.0 1.0

H327100 SHOES/LINING ASM. REAR PARK BRAKE RH —

REPLACE .5.7.7.7.5.7.7.7

H327200 SHOES/LINING ASM. REAR PARK BRAKE LH —

REPLACE .5.7.7.7.5.7.7.7

3 H128100 SHIELD ASM. REAR DISC/DRUM BRAKE RH —

R&R/REPLACE .6 1.0 1.0 1.0 .6 1.0 1.0 1.0

H128200 SHIELD ASM. REAR DISC/DRUM BRAKE LH —

R&R/REPLACE .6 1.0 1.0 1.0 .6 1.0 1.0 1.0

4 H025500 SPRING, ACTUATING LEVER RETURN RH —

REPLACE — .3 .3 .3 — .3 .3 .3

H025600 SPRING, ACTUATING LEVER RETURN LH —

REPLACE — .3 .3 .3 — .3 .3 .3

5 H127000 CALIPER ASM. REAR BOTH — REPLACE .6 1.0 1.0 1.0 .6 1.0 1.0 1.0

H127100 CALIPER ASM. REAR RH — REPLACE .4 .7 .7 .7 .4 .7 .7 .7

H127200 CALIPER ASM. REAR LH — REPLACE .4 .7 .7 .7 .4 .7 .7 .7

— 1

REAR BRAKES

TRANSMISSION, ESP & BRAKES

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

04-825 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

H125000 PADS/SHOES, REAR BRAKES BOTH SIDES —

REPLACE (UP TO 5,000KM) .4 .5 .5 .5 .4 .5 .5 .5

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

04- 999 —

DIAGNOSTIC TROUBLE CODES

TRANSMISSION

K900014 TRANSMISSION DIAGNOSTIC CODE 14 — — —————ST

K900015 TRANSMISSION DIAGNOSTIC CODE 15 — — —————ST

K900017 TRANSMISSION DIAGNOSTIC CODE 17 — — ——————

K900021 TRANSMISSION DIAGNOSTIC CODE 21 — — —————ST

K900022 TRANSMISSION DIAGNOSTIC CODE 22 — — —————ST

K900024 TRANSMISSION DIAGNOSTIC CODE 24 — — —————ST

K900025 TRANSMISSION DIAGNOSTIC CODE 25 — — ——————

K900026 TRANSMISSION DIAGNOSTIC CODE 26 — — ——————

K900028 TRANSMISSION DIAGNOSTIC CODE 28 — — — ST — — — ST

K900029 TRANSMISSION DIAGNOSTIC CODE 29 — — ——————

K900031 TRANSMISSION DIAGNOSTIC CODE 31 — — ——————

K900032 TRANSMISSION DIAGNOSTIC CODE 32 — — ——————

K900033 TRANSMISSION DIAGNOSTIC CODE 33 — — ——————

K900036 TRANSMISSION DIAGNOSTIC CODE 36 — — ——————

K900038 TRANSMISSION DIAGNOSTIC CODE 38 — — ——————

K900039 TRANSMISSION DIAGNOSTIC CODE 39 — — ——————

K900041 TRANSMISSION DIAGNOSTIC CODE 41 — — ——————

K900042 TRANSMISSION DIAGNOSTIC CODE 42 — — ——————

K900047 TRANSMISSION DIAGNOSTIC CODE 47 — — ——————

K900048 TRANSMISSION DIAGNOSTIC CODE 48 — — ——————

K900049 TRANSMISSION DIAGNOSTIC CODE 49 — — ——————

K900052 TRANSMISSION DIAGNOSTIC CODE 52 — — —————ST

K900053 TRANSMISSION DIAGNOSTIC CODE 53 — — —————ST

K900055 TRANSMISSION DIAGNOSTIC CODE 55 — — —————ST

K900056 TRANSMISSION DIAGNOSTIC CODE 56 — — ——————

K900057 TRANSMISSION DIAGNOSTIC CODE 57 — — ——————

K900058 TRANSMISSION DIAGNOSTIC CODE 58 — — — ST — — — ST

K900059 TRANSMISSION DIAGNOSTIC CODE 59 — — — ST — — — ST

K900061 TRANSMISSION DIAGNOSTIC CODE 61 — — ——————

K900062 TRANSMISSION DIAGNOSTIC CODE 62 — — ——————

K900066 TRANSMISSION DIAGNOSTIC CODE 66 — — — ST — — — ST

K900067 TRANSMISSION DIAGNOSTIC CODE 67 — — — ST — — — ST

K900068 TRANSMISSION DIAGNOSTIC CODE 68 — — ——————

K900069 TRANSMISSION DIAGNOSTIC CODE 69 — — — ST — — — ST

K900072 TRANSMISSION DIAGNOSTIC CODE 72 — — — ST — — — ST

K900073 TRANSMISSION DIAGNOSTIC CODE 73 — — — ST — — — ST

K900074 TRANSMISSION DIAGNOSTIC CODE 74 — — ——————

K900075 TRANSMISSION DIAGNOSTIC CODE 75 — — —————ST

K900076 TRANSMISSION DIAGNOSTIC CODE 76 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

TRANSMISSION

DIAGNOSTIC TROUBLE CODES

04- 999 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

K900077 TRANSMISSION DIAGNOSTIC CODE 77 — — ——————

K900078 TRANSMISSION DIAGNOSTIC CODE 78 — — ——————

K900079 TRANSMISSION DIAGNOSTIC CODE 79 — — — ST — — — ST

K900081 TRANSMISSION DIAGNOSTIC CODE 81 — — — ST — — — ST

K900082 TRANSMISSION DIAGNOSTIC CODE 82 — — — ST — — — ST

K900083 TRANSMISSION DIAGNOSTIC CODE 83 — — — ST — — — ST

K900084 TRANSMISSION DIAGNOSTIC CODE 84 — — ——————

K900085 TRANSMISSION DIAGNOSTIC CODE 85 — — — ST — — — ST

K900100 TRANSMISSION DIAGNOSTIC CODE U0100 — ST — — — ST — —

K900115 TRANSMISSION DIAGNOSTIC CODE P0115 — ST — — — ST — —

K900120 TRANSMISSION DIAGNOSTIC CODE P0120 — ST — — — ST — —

K900218 TRANSMISSION DIAGNOSTIC CODE P0218 0.3 ST ST ST 0.3 ST ST ST

K900502 TRANSMISSION DIAGNOSTIC CODE P0502 — ST ST ST — ST ST ST

K900503 TRANSMISSION DIAGNOSTIC CODE P0503 — ST ST ST — ST ST ST

K900560 TRANSMISSION DIAGNOSTIC CODE P0560 — — ——————

K900561 TRANSMISSION DIAGNOSTIC CODE P0561 — — ——————

K900562 TRANSMISSION DIAGNOSTIC CODE P0562 0.3 ST — — 0.3 ST — —

K900563 TRANSMISSION DIAGNOSTIC CODE P0563 0.3 ST — — 0.3 ST — —

K900572 TRANSMISSION DIAGNOSTIC CODE P0572 0.3 ST — — 0.3 ST — —

K900573 TRANSMISSION DIAGNOSTIC CODE P0573 0.3 ST — — 0.3 ST — —

K900601 TRANSMISSION DIAGNOSTIC CODE P0601 0.3 ST — — 0.3 ST — —

K900602 TRANSMISSION DIAGNOSTIC CODE P0602 0.3 ST — — 0.3 ST — —

K900603 TRANSMISSION DIAGNOSTIC CODE P0603 0.3 ST — — 0.3 ST — —

K900604 TRANSMISSION DIAGNOSTIC CODE P0604 0.3 ST — — 0.3 ST — —

K900606 TRANSMISSION DIAGNOSTIC CODE P0606 0.3 — — — 0.3 — — —

K900634 TRANSMISSION DIAGNOSTIC CODE P0634 0.3 — — — 0.3 — — —

K900667 TRANSMISSION DIAGNOSTIC CODE P0667 0.3 — — — 0.3 — — —

K900668 TRANSMISSION DIAGNOSTIC CODE P0668 0.3 — — — 0.3 — — —

K900669 TRANSMISSION DIAGNOSTIC CODE P0669 0.3 — — — 0.3 — — —

K900700 TRANSMISSION DIAGNOSTIC CODE P0700 — — ——————

K900703 TRANSMISSION DIAGNOSTIC CODE P0703 0.3 — — — 0.3 — — —

K900705 TRANSMISSION DIAGNOSTIC CODE P0705 0.3 ST ST ST 0.3 ST ST ST

K900706 TRANSMISSION DIAGNOSTIC CODE P0706 — ST ST — — ST ST —

K900710 TRANSMISSION DIAGNOSTIC CODE P0710 — — ——————

K900711 TRANSMISSION DIAGNOSTIC CODE P0711 0.3 ST ST ST 0.3 ST ST ST

K900712 TRANSMISSION DIAGNOSTIC CODE P0712 0.3 ST ST ST 0.3 ST ST ST

K900713 TRANSMISSION DIAGNOSTIC CODE P0713 0.3 ST ST ST 0.3 ST ST ST

K900715 TRANSMISSION DIAGNOSTIC CODE P0715 — — ——————

K900716 TRANSMISSION DIAGNOSTIC CODE P0716 0.3 ST — — 0.3 ST — —

K900717 TRANSMISSION DIAGNOSTIC CODE P0717 0.3 ST — — 0.3 ST — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

TRANSMISSION

DIAGNOSTIC TROUBLE CODES

04- 999 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

K900719 TRANSMISSION DIAGNOSTIC CODE P0719 0.3 ST ST ST 0.3 ST ST ST

K900720 TRANSMISSION DIAGNOSTIC CODE P0720 — — ——————

K900722 TRANSMISSION DIAGNOSTIC CODE P0722 0.3 ST — — 0.3 ST — —

K900723 TRANSMISSION DIAGNOSTIC CODE P0723 0.3 ST — — 0.3 ST — —

K900724 TRANSMISSION DIAGNOSTIC CODE P0724 0.3 ST ST ST 0.3 ST ST ST

K900725 TRANSMISSION DIAGNOSTIC CODE P0725 — — ——————

K900727 TRANSMISSION DIAGNOSTIC CODE P0727 — ST — — — ST — —

K900730 TRANSMISSION DIAGNOSTIC CODE P0730 — ST ST ST — ST ST —

K900731 TRANSMISSION DIAGNOSTIC CODE P0731 0.3 ST — — 0.3 ST — —

K900732 TRANSMISSION DIAGNOSTIC CODE P0732 0.3 ST — — 0.3 ST — —

K900733 TRANSMISSION DIAGNOSTIC CODE P0733 0.3 ST ST ST 0.3 ST ST —

K900734 TRANSMISSION DIAGNOSTIC CODE P0734 0.3 ST — — 0.3 ST — —

K900735 TRANSMISSION DIAGNOSTIC CODE P0735 0.3 ST — — 0.3 ST — —

K900736 TRANSMISSION DIAGNOSTIC CODE P0736 — — ——————

K900740 TRANSMISSION DIAGNOSTIC CODE P0740 — ST ST ST — ST ST ST

K900741 TRANSMISSION DIAGNOSTIC CODE P0741 0.3 ST — ST 0.3 ST — —

K900742 TRANSMISSION DIAGNOSTIC CODE P0742 0.3 ST ST ST 0.3 ST ST —

K900743 TRANSMISSION DIAGNOSTIC CODE P0743 — — ——————

K900748 TRANSMISSION DIAGNOSTIC CODE P0748 — ST ST ST — ST ST ST

K900751 TRANSMISSION DIAGNOSTIC CODE P0751 0.3 ST ST ST 0.3 ST ST ST

K900752 TRANSMISSION DIAGNOSTIC CODE P0752 0.3 ST — — 0.3 ST — —

K900753 TRANSMISSION DIAGNOSTIC CODE P0753 — ST ST ST — ST ST ST

K900756 TRANSMISSION DIAGNOSTIC CODE P0756 0.3 ST ST ST 0.3 ST ST ST

K900757 TRANSMISSION DIAGNOSTIC CODE P0757 0.3 ST — ST 0.3 ST — —

K900758 TRANSMISSION DIAGNOSTIC CODE P0758 — ST ST ST — ST ST ST

K900761 TRANSMISSION DIAGNOSTIC CODE P0761 0.3 ST — — 0.3 ST — —

K900762 TRANSMISSION DIAGNOSTIC CODE P0762 0.3 ST — — 0.3 ST — —

K900763 TRANSMISSION DIAGNOSTIC CODE P0763 — — ——————

K900768 TRANSMISSION DIAGNOSTIC CODE P0768 — — ——————

K900773 TRANSMISSION DIAGNOSTIC CODE P0773 — — ——————

K900780 TRANSMISSION DIAGNOSTIC CODE P0780 — — ——————

K900785 TRANSMISSION DIAGNOSTIC CODE P0785 — ST ST ST — ST ST ST

K900787 TRANSMISSION DIAGNOSTIC CODE P0787 0.3 ST — — 0.3 ST — —

K900788 TRANSMISSION DIAGNOSTIC CODE P0788 0.3 ST — — 0.3 ST — —

K900801 TRANSMISSION DIAGNOSTIC CODE P0801 — ST — — — ST — —

K900815 TRANSMISSION DIAGNOSTIC CODE P0815 0.3 ST — — 0.3 ST — —

K900816 TRANSMISSION DIAGNOSTIC CODE P0816 0.3 ST — — 0.3 ST — —

K900826 TRANSMISSION DIAGNOSTIC CODE P0826 0.3 ST — — 0.3 ST — —

K900842 TRANSMISSION DIAGNOSTIC CODE P0842 0.3 — — — 0.3 — — —

K900843 TRANSMISSION DIAGNOSTIC CODE P0843 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

TRANSMISSION

DIAGNOSTIC TROUBLE CODES

04- 999 — 4

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

K900847 TRANSMISSION DIAGNOSTIC CODE P0847 0.3 — — — 0.3 — — —

K900848 TRANSMISSION DIAGNOSTIC CODE P0848 0.3 — — — 0.3 — — —

K900850 TRANSMISSION DIAGNOSTIC CODE P0850 — ST — — — ST — —

K900864 TRANSMISSION DIAGNOSTIC CODE P0864 — ST — — — ST — —

K900872 TRANSMISSION DIAGNOSTIC CODE P0872 0.3 — — — 0.3 — — —

K900873 TRANSMISSION DIAGNOSTIC CODE P0873 0.3 — — — 0.3 — — —

K900877 TRANSMISSION DIAGNOSTIC CODE P0877 0.3 — — — 0.3 — — —

K900878 TRANSMISSION DIAGNOSTIC CODE P0878 0.3 — — — 0.3 — — —

K900894 TRANSMISSION DIAGNOSTIC CODE P0894 0.3 ST — — 0.3 ST — —

K900897 TRANSMISSION DIAGNOSTIC CODE P0897 0.3 ST — — 0.3 ST — —

K900960 TRANSMISSION DIAGNOSTIC CODE P0960 0.3 — — — 0.3 — — —

K900961 TRANSMISSION DIAGNOSTIC CODE P0961 0.3 ST — — 0.3 ST — —

K900962 TRANSMISSION DIAGNOSTIC CODE P0962 0.3 — — — 0.3 — — —

K900963 TRANSMISSION DIAGNOSTIC CODE P0963 0.3 — — — 0.3 — — —

K900965 TRANSMISSION DIAGNOSTIC CODE P0965 0.3 — — — 0.3 — — —

K900966 TRANSMISSION DIAGNOSTIC CODE P0966 0.3 — — — 0.3 — — —

K900967 TRANSMISSION DIAGNOSTIC CODE P0967 0.3 — — — 0.3 — — —

K900969 TRANSMISSION DIAGNOSTIC CODE P0969 0.3 — — — 0.3 — — —

K900970 TRANSMISSION DIAGNOSTIC CODE P0970 0.3 — — — 0.3 — — —

K900971 TRANSMISSION DIAGNOSTIC CODE P0971 0.3 — — — 0.3 — — —

K900973 TRANSMISSION DIAGNOSTIC CODE P0973 0.3 ST — — 0.3 ST — —

K900974 TRANSMISSION DIAGNOSTIC CODE P0974 0.3 ST — — 0.3 ST — —

K900976 TRANSMISSION DIAGNOSTIC CODE P0976 0.3 ST — — 0.3 ST — —

K900977 TRANSMISSION DIAGNOSTIC CODE P0977 0.3 ST — — 0.3 ST — —

K900979 TRANSMISSION DIAGNOSTIC CODE P0979 0.3 ST — — 0.3 ST — —

K900980 TRANSMISSION DIAGNOSTIC CODE P0980 0.3 ST — — 0.3 ST — —

K900989 TRANSMISSION DIAGNOSTIC CODE P0989 0.3 — — — 0.3 — — —

K900990 TRANSMISSION DIAGNOSTIC CODE P0990 0.3 — — — 0.3 — — —

K901040 TRANSMISSION DIAGNOSTIC CODE U1040 0.3 — — — 0.3 — — —

K901064 TRANSMISSION DIAGNOSTIC CODE U1064 0.3 — — — 0.3 — — —

K901065 TRANSMISSION DIAGNOSTIC CODE U1065 0.3 — — — 0.3 — — —

K901066 TRANSMISSION DIAGNOSTIC CODE U1066 0.3 — — — 0.3 — — —

K901120TRANSMISSION DIAGNOSTIC CODE P1120 ————————

K901130TRANSMISSION DIAGNOSTIC CODE P1130 ————————

K901192 TRANSMISSION DIAGNOSTIC CODE U1192 0.3 — — — 0.3 — — —

K901300 TRANSMISSION DIAGNOSTIC CODE U1300 0.3 — — — 0.3 — — —

K901301 TRANSMISSION DIAGNOSTIC CODE U1301 0.3 — — — 0.3 — — —

K901621 TRANSMISSION DIAGNOSTIC CODE P1621 0.3 ST — — 0.3 ST — —

K901668 TRANSMISSION DIAGNOSTIC CODE P1668 — ST — — — ST — —

K901683 TRANSMISSION DIAGNOSTIC CODE P1683 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

TRANSMISSION

DIAGNOSTIC TROUBLE CODES

04- 999 — 5

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

K901700 TRANSMISSION DIAGNOSTIC CODE P1700 — — ——————

K901702 TRANSMISSION DIAGNOSTIC CODE P1702 — — ——————

K901704 TRANSMISSION DIAGNOSTIC CODE P1704 — — ——————

K901705 TRANSMISSION DIAGNOSTIC CODE P1705 — — ——————

K901728 TRANSMISSION DIAGNOSTIC CODE P1728 0.3 — — — 0.3 — — —

K901729 TRANSMISSION DIAGNOSTIC CODE P1729 0.3 — — — 0.3 — — —

K901730 TRANSMISSION DIAGNOSTIC CODE P1730 — — ——————

K901740 TRANSMISSION DIAGNOSTIC CODE P1740 0.3 — — — 0.3 — — —

K901743 TRANSMISSION DIAGNOSTIC CODE P1743 — — ——————

K901750 TRANSMISSION DIAGNOSTIC CODE P1750 0.3 — — — 0.3 — — —

K901751 TRANSMISSION DIAGNOSTIC CODE P1751 0.3 — — — 0.3 — — —

K901780 TRANSMISSION DIAGNOSTIC CODE P1780 — — ——————

K901793 TRANSMISSION DIAGNOSTIC CODE P1793 — ST — — — ST — —

K901796 TRANSMISSION DIAGNOSTIC CODE P1796 0.3 — — — 0.3 — — —

K901801 TRANSMISSION DIAGNOSTIC CODE P1801 — — ——————

K901802 TRANSMISSION DIAGNOSTIC CODE P1802 — — ——————

K901810 TRANSMISSION DIAGNOSTIC CODE P1810 0.3 ST ST ST 0.3 ST ST ST

K901811 TRANSMISSION DIAGNOSTIC CODE P1811 0.3 — — — 0.3 — — —

K901813 TRANSMISSION DIAGNOSTIC CODE P1813 — — ——————

K901814 TRANSMISSION DIAGNOSTIC CODE P1814 0.3 — — — 0.3 — — —

K901815 TRANSMISSION DIAGNOSTIC CODE P1815 0.3 ST — — 0.3 ST — —

K901816 TRANSMISSION DIAGNOSTIC CODE P1816 0.3 ST — — 0.3 ST — —

K901817 TRANSMISSION DIAGNOSTIC CODE P1817 0.3 — — — 0.3 — — —

K901818 TRANSMISSION DIAGNOSTIC CODE P1818 0.3 — — — 0.3 — — —

K901819 TRANSMISSION DIAGNOSTIC CODE P1819 0.3 — — — 0.3 — — —

K901820 TRANSMISSION DIAGNOSTIC CODE P1820 0.3 ST — — 0.3 ST — —

K901822 TRANSMISSION DIAGNOSTIC CODE P1822 0.3 ST — — 0.3 ST — —

K901823 TRANSMISSION DIAGNOSTIC CODE P1823 0.3 ST — — 0.3 ST — —

K901825 TRANSMISSION DIAGNOSTIC CODE P1825 0.3 ST — — 0.3 ST — —

K901826 TRANSMISSION DIAGNOSTIC CODE P1826 0.3 ST — — 0.3 ST — —

K901831 TRANSMISSION DIAGNOSTIC CODE P1831 0.3 ST — — 0.3 ST — —

K901832 TRANSMISSION DIAGNOSTIC CODE P1832 0.3 ST — — 0.3 ST — —

K901833 TRANSMISSION DIAGNOSTIC CODE P1833 0.3 ST — — 0.3 ST — —

K901834 TRANSMISSION DIAGNOSTIC CODE P1834 0.3 ST — — 0.3 ST — —

K901835 TRANSMISSION DIAGNOSTIC CODE P1835 — — ——————

K901847 TRANSMISSION DIAGNOSTIC CODE P1847 — — ——————

K901860 TRANSMISSION DIAGNOSTIC CODE P1860 — ST ST ST — ST ST ST

K901870 TRANSMISSION DIAGNOSTIC CODE P1870 — ST ST ST — ST ST ST

K901876 TRANSMISSION DIAGNOSTIC CODE P1876 0.3 ST — — 0.3 ST — —

K901877 TRANSMISSION DIAGNOSTIC CODE P1877 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

TRANSMISSION

DIAGNOSTIC TROUBLE CODES

04- 999 — 6

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

K901890 TRANSMISSION DIAGNOSTIC CODE P1890 — — ——————

K901895 TRANSMISSION DIAGNOSTIC CODE P1895 — — ——————

K901896 TRANSMISSION DIAGNOSTIC CODE P1896 — — ——————

K901915 TRANSMISSION DIAGNOSTIC CODE P1915 — — ——————

K902101 TRANSMISSION DIAGNOSTIC CODE U2101 0.3 — — — 0.3 — — —

K902102 TRANSMISSION DIAGNOSTIC CODE U2102 0.3 — — — 0.3 — — —

K902103 TRANSMISSION DIAGNOSTIC CODE U2103 0.3 — — — 0.3 — — —

K902104 TRANSMISSION DIAGNOSTIC CODE U2104 0.3 — — — 0.3 — — —

K902105 TRANSMISSION DIAGNOSTIC CODE U2105 0.3 ST — — 0.3 ST — —

K902107 TRANSMISSION DIAGNOSTIC CODE U2107 0.3 — — — 0.3 — — —

K902108 TRANSMISSION DIAGNOSTIC CODE U2108 0.3 — — — 0.3 — — —

K902139 TRANSMISSION DIAGNOSTIC CODE U2139 0.3 — — — 0.3 — — —

K902144 TRANSMISSION DIAGNOSTIC CODE U2144 0.3 — — — 0.3 — — —

K902544 TRANSMISSION DIAGNOSTIC CODE P2544 — ST — — — ST — —

K902637 TRANSMISSION DIAGNOSTIC CODE P2637 — ST — — — ST — —

K902661 TRANSMISSION DIAGNOSTIC CODE P2661 — ST — — — ST — —

K902715 TRANSMISSION DIAGNOSTIC CODE P2715 0.3 — — — 0.3 — — —

K902719 TRANSMISSION DIAGNOSTIC CODE P2719 0.3 — — — 0.3 — — —

K902720 TRANSMISSION DIAGNOSTIC CODE P2720 0.3 — — — 0.3 — — —

K902721 TRANSMISSION DIAGNOSTIC CODE P2721 0.3 — — — 0.3 — — —

K902728 TRANSMISSION DIAGNOSTIC CODE P2728 0.3 — — — 0.3 — — —

K902729 TRANSMISSION DIAGNOSTIC CODE P2729 0.3 — — — 0.3 — — —

K902730 TRANSMISSION DIAGNOSTIC CODE P2730 0.3 — — — 0.3 — — —

K902737 TRANSMISSION DIAGNOSTIC CODE P2737 0.3 — — — 0.3 — — —

K902738 TRANSMISSION DIAGNOSTIC CODE P2738 0.3 — — — 0.3 — — —

K902739 TRANSMISSION DIAGNOSTIC CODE P2739 0.3 — — — 0.3 — — —

K902762 TRANSMISSION DIAGNOSTIC CODE P2762 0.3 — — — 0.3 — — —

K902763 TRANSMISSION DIAGNOSTIC CODE P2763 0.3 ST — — 0.3 ST — —

K902764 TRANSMISSION DIAGNOSTIC CODE P2764 0.3 ST — — 0.3 ST — —

K902769 TRANSMISSION DIAGNOSTIC CODE P2769 0.3 ST — — 0.3 ST — —

K902770 TRANSMISSION DIAGNOSTIC CODE P2770 0.3 ST — — 0.3 ST — —

K902771 TRANSMISSION DIAGNOSTIC CODE P2771 0.3 — — — 0.3 — — —

K903601 TRANSMISSION DIAGNOSTIC CODE B3601 — — ——————

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

04- 999A —

DIAGNOSTIC TROUBLE CODES

ABS, ESP, TCS

H900012 ABS/ESP/TCS DIAGNOSTIC CODE 12 — — — ST — — — ST

H900013 ABS/ESP/TCS DIAGNOSTIC CODE B013B 0.3 — — — 0.3 — — —

H900016 ABS/ESP/TCS DIAGNOSTIC CODE 16 — — ——————

H900017 ABS/ESP/TCS DIAGNOSTIC CODE 17 — — ——————

H900018 ABS/ESP/TCS DIAGNOSTIC CODE 18 — — ——————

H900019 ABS/ESP/TCS DIAGNOSTIC CODE 19 — — ——————

H900021 ABS/ESP/TCS DIAGNOSTIC CODE 21 — ST ST ST — ST ST ST

H900023 ABS/ESP/TCS DIAGNOSTIC CODE 23 — ST ST ST — ST ST ST

H900025 ABS/ESP/TCS DIAGNOSTIC CODE 25 — ST ST ST — ST ST ST

H900027 ABS/ESP/TCS DIAGNOSTIC CODE 27 — ST ST ST — ST ST ST

H900028 ABS/ESP/TCS DIAGNOSTIC CODE 28 — ST ST ST — ST ST ST

H900029 ABS/ESP/TCS DIAGNOSTIC CODE 29 — — ——————

H900031 ABS/ESP/TCS DIAGNOSTIC CODE 31 — ST ST ST — ST ST ST

H900033 ABS/ESP/TCS DIAGNOSTIC CODE 33 — ST ST ST — ST ST ST

H900035 ABS/ESP/TCS DIAGNOSTIC CODE 35, C0035 0.3 ST ST ST 0.3 ST ST ST

H900036 ABS/ESP/TCS DIAGNOSTIC CODE 36, C0036 — ST ST —————

H900037 ABS/ESP/TCS DIAGNOSTIC CODE 37 — ST ST ST — ST ST ST

H900039 ABS/ESP/TCS DIAGNOSTIC CODE 39 — — ——————

H900040 ABS/ESP/TCS DIAGNOSTIC CODE 40, C0040 0.3 ST ST — 0.3 ST — —

H900041 ABS/ESP/TCS DIAGNOSTIC CODE 41, C0041 — ST ST ST — ST ST ST

H900042 ABS/ESP/TCS DIAGNOSTIC CODE 42 — ST ST ST — ST ST ST

H900043 ABS/ESP/TCS DIAGNOSTIC CODE 43 — — ——————

H900044 ABS/ESP/TCS DIAGNOSTIC CODE 44 — — ——————

H900045 ABS/ESP/TCS DIAGNOSTIC CODE 45, C0045 0.3 ST ST ST 0.3 ST ST ST

H900046 ABS/ESP/TCS DIAGNOSTIC CODE 46, C0046 — ST ST ST — ST ST ST

H900047 ABS/ESP/TCS DIAGNOSTIC CODE 47 — ST ST ST — ST ST ST

H900048 ABS/ESP/TCS DIAGNOSTIC CODE 48 — ST ST ST — ST ST ST

H900049 ABS/ESP/TCS DIAGNOSTIC CODE 49 — — ——————

H900050 ABS/ESP/TCS DIAGNOSTIC CODE 50, C0050 0.3 ST ST — 0.3 ST — —

H900051 ABS/ESP/TCS DIAGNOSTIC CODE 51, C0051 — ST ST ST — ST ST ST

H900052 ABS/ESP/TCS DIAGNOSTIC CODE 52 — ST ST ST — ST ST ST

H900055 ABS/ESP/TCS DIAGNOSTIC CODE 55 — ST ST ST — ST ST ST

H900056 ABS/ESP/TCS DIAGNOSTIC CODE 56 — ST ST ST — ST ST ST

H900058 ABS/ESP/TCS DIAGNOSTIC CODE 58 — — — ST — — — ST

H900059 ABS/ESP/TCS DIAGNOSTIC CODE 59 — — ——————

H900060 ABS/ESP/TCS DIAGNOSTIC CODE 60, C0060 0.3 ST — — 0.3 ST — —

H900061 ABS/ESP/TCS DIAGNOSTIC CODE 61 — ST ST ST — ST ST ST

H900062 ABS/ESP/TCS DIAGNOSTIC CODE 62 — ST ST ST — ST ST ST

H900063 ABS/ESP/TCS DIAGNOSTIC CODE 63 — ST ST ST — ST ST ST

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ABS, ESP, TCS

DIAGNOSTIC TROUBLE CODES

04- 999A — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

H900064 ABS/ESP/TCS DIAGNOSTIC CODE 64 — ST ST ST — ST ST —

H900065 ABS/ESP/TCS DIAGNOSTIC CODE 65, C0065 0.3 ST ST ST 0.3 ST ST —

H900066 ABS/ESP/TCS DIAGNOSTIC CODE 66 — ST ST ST — ST ST —

H900067 ABS/ESP/TCS DIAGNOSTIC CODE 67 — ST ST ST — ST ST ST

H900068 ABS/ESP/TCS DIAGNOSTIC CODE 68 — ST ST ST — ST ST —

H900070 ABS/ESP/TCS DIAGNOSTIC CODE 70, C0070 0.3 ST — — 0.3 ST — —

H900071 ABS/ESP/TCS DIAGNOSTIC CODE 71 — ST ST ST — ST ST ST

H900072 ABS/ESP/TCS DIAGNOSTIC CODE 72 — ST ST ST — ST ST ST

H900073 ABS/ESP/TCS DIAGNOSTIC CODE 73, U0073 0.3 ST ST ST 0.3 ST ST ST

H900074 ABS/ESP/TCS DIAGNOSTIC CODE 74, C0074 — ST ST ST — ST ST ST

H900075 ABS/ESP/TCS DIAGNOSTIC CODE 75, C0075 0.3 ST — — 0.3 ST — —

H900078 ABS/ESP/TCS DIAGNOSTIC CODE 78, C0078 — ST ST ST — ST ST ST

H900080 ABS/ESP/TCS DIAGNOSTIC CODE 80, C0080 0.3 ST — — 0.3 ST — —

H900085 ABS/ESP/TCS DIAGNOSTIC CODE 85, C0085 0.3 ST ST ST 0.3 ST ST ST

H900090 ABS/ESP/TCS DIAGNOSTIC CODE 90, C0090 0.3 ST — — 0.3 ST — —

H900095 ABS/ESP/TCS DIAGNOSTIC CODE 95, C0095 0.3 ST — — 0.3 ST — —

H900100 ABS/ESP/TCS DIAGNOSTIC CODE 110, C0100, U0100 0.3 — — — 0.3 — — —

H900101 ABS/ESP/TCS DIAGNOSTIC CODE B101E, U0101 0.3 — — — 0.3 — — —

H900105 ABS/ESP/TCS DIAGNOSTIC CODE 121, C0105 0.3 — — — 0.3 — — —

H900110 ABS/ESP/TCS DIAGNOSTIC CODE 110, C0110 0.3 ST ST — 0.3 ST — —

H900121 ABS/ESP/TCS DIAGNOSTIC CODE 121, C0121 0.3 ST ST — 0.3 ST — —

H900131 ABS/ESP/TCS DIAGNOSTIC CODE 131, C0131 0.3 ST — — 0.3 ST — —

H900140 ABS/ESP/TCS DIAGNOSTIC CODE U0140 0.3 — — — 0.3 — — —

H900141 ABS/ESP/TCS DIAGNOSTIC CODE 141, C0141 0.3 ST — — 0.3 ST — —

H900143 ABS/ESP/TCS DIAGNOSTIC CODE U0143 0.3 — — — 0.3 — — —

H900146 ABS/ESP/TCS DIAGNOSTIC CODE 146, C0146 0.3 ST — — 0.3 ST — —

H900151 ABS/ESP/TCS DIAGNOSTIC CODE 151, C0151 0.3 ST — — 0.3 ST — —

H900155 ABS/ESP/TCS DIAGNOSTIC CODE U0155 0.3 — — — 0.3 — — —

H900156 ABS/ESP/TCS DIAGNOSTIC CODE 156, C0156 0.3 ST — — 0.3 ST — —

H900161 ABS/ESP/TCS DIAGNOSTIC CODE 161, C0161 0.3 ST ST — 0.3 ST — —

H900166 ABS/ESP/TCS DIAGNOSTIC CODE 166, C0166 — — ——————

H900186 ABS/ESP/TCS DIAGNOSTIC CODE 186, C0186 0.3 ST — — 0.3 ST — —

H900189 ABS/ESP/TCS DIAGNOSTIC CODE 189, C0189 — — ——————

H900191 ABS/ESP/TCS DIAGNOSTIC CODE C0191 — ST ST — — ST — —

H900192 ABS/ESP/TCS DIAGNOSTIC CODE C0192 — ST ST — — ST — —

H900196 ABS/ESP/TCS DIAGNOSTIC CODE 196, C0196 0.3 ST — — 0.3 ST — —

H900236 ABS/ESP/TCS DIAGNOSTIC CODE 236, C0236 — — ——————

H900237 ABS/ESP/TCS DIAGNOSTIC CODE C0237 — — ——————

H900240 ABS/ESP/TCS DIAGNOSTIC CODE C0240 — — ——————

H900241 ABS/ESP/TCS DIAGNOSTIC CODE 241, C0241 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ABS, ESP, TCS

DIAGNOSTIC TROUBLE CODES

04- 999A — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

H900242 ABS/ESP/TCS DIAGNOSTIC CODE 242, C0242 — — ——————

H900244 ABS/ESP/TCS DIAGNOSTIC CODE 244, C0244 — — ——————

H900245 ABS/ESP/TCS DIAGNOSTIC CODE 245, C0245 0.3 ST ST — 0.3 ST — —

H900252 ABS/ESP/TCS DIAGNOSTIC CODE 252, C0252 0.3 ST — — 0.3 ST — —

H900253 ABS/ESP/TCS DIAGNOSTIC CODE C0253 — ST — — — ST — —

H900256 ABS/ESP/TCS DIAGNOSTIC CODE C0256 — — ——————

H900260 ABS/ESP/TCS DIAGNOSTIC CODE C0260 — — ——————

H900273 ABS/ESP/TCS DIAGNOSTIC CODE C0273 — ST ——————

H900274 ABS/ESP/TCS DIAGNOSTIC CODE C0274 — — ——————

H900275 ABS/ESP/TCS DIAGNOSTIC CODE C0275 — — ——————

H900280 ABS/ESP/TCS DIAGNOSTIC CODE C0280 — — ——————

H900292 ABS/ESP/TCS DIAGNOSTIC CODE C0292 — — ——————

H900460 ABS/ESP/TCS DIAGNOSTIC CODE C0460 0.3 ST — — 0.3 ST — —

H900500 ABS/ESP/TCS DIAGNOSTIC CODE P0500 — — ——————

H900501 ABS/ESP/TCS DIAGNOSTIC CODE P0501 — — ——————

H900550 ABS/ESP/TCS DIAGNOSTIC CODE C0550 — ST ST ST — ST — —

H900551 ABS/ESP/TCS DIAGNOSTIC CODE C0551 — ST — — — ST — —

H900558 ABS/ESP/TCS DIAGNOSTIC CODE C0558 0.3 ST — — 0.3 ST — —

H900561 ABS/ESP/TCS DIAGNOSTIC CODE C0561 0.3 — — — 0.3 — — —

H900565 ABS/ESP/TCS DIAGNOSTIC CODE C0565 0.3 — — — 0.3 — — —

H900569 ABS/ESP/TCS DIAGNOSTIC CODE C0569 0.3 ST — — 0.3 ST — —

H900710 ABS/ESP/TCS DIAGNOSTIC CODE C0710 — — ——————

H900750 ABS/ESP/TCS DIAGNOSTIC CODE C0750 — ST — — — ST — —

H900755 ABS/ESP/TCS DIAGNOSTIC CODE C0755 — ST — — — ST — —

H900760 ABS/ESP/TCS DIAGNOSTIC CODE C0760 — ST — — — ST — —

H900800 ABS/ESP/TCS DIAGNOSTIC CODE 800, C0800 — ST — — — ST — —

H900895 ABS/ESP/TCS DIAGNOSTIC CODE C0895 — ST ——————

H900896 ABS/ESP/TCS DIAGNOSTIC CODE C0896 — ST ——————

H900899 ABS/ESP/TCS DIAGNOSTIC CODE C0899 0.3 — — — 0.3 — — —

H900900 ABS/ESP/TCS DIAGNOSTIC CODE C0900 0.3 — — — 0.3 — — —

H900946 ABS/ESP/TCS DIAGNOSTIC CODE C0946 — — ——————

H901012 ABS/ESP/TCS DIAGNOSTIC CODE B1012 — — ——————

H901020 ABS/ESP/TCS DIAGNOSTIC CODE B1020 — — ——————

H901035 ABS/ESP/TCS DIAGNOSTIC CODE B1035 — — ——————

H901041 ABS/ESP/TCS DIAGNOSTIC CODE C1041 — — ——————

H901042 ABS/ESP/TCS DIAGNOSTIC CODE C1042 — — ——————

H901045 ABS/ESP/TCS DIAGNOSTIC CODE C1045 — — ——————

H901046 ABS/ESP/TCS DIAGNOSTIC CODE C1046 — — ——————

H901051 ABS/ESP/TCS DIAGNOSTIC CODE C1051 — — ——————

H901052 ABS/ESP/TCS DIAGNOSTIC CODE C1052 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

ABS, ESP, TCS

DIAGNOSTIC TROUBLE CODES

04- 999A — 4

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

H901055 ABS/ESP/TCS DIAGNOSTIC CODE C1055 — — ——————

H901056 ABS/ESP/TCS DIAGNOSTIC CODE C1056 — — ——————

H901057 ABS/ESP/TCS DIAGNOSTIC CODE C1057 — — ——————

H901061 ABS/ESP/TCS DIAGNOSTIC CODE C1061 — — ——————

H901063 ABS/ESP/TCS DIAGNOSTIC CODE C1063 — — ——————

H901071 ABS/ESP/TCS DIAGNOSTIC CODE C1071 — — ——————

H901390 ABS/ESP/TCS DIAGNOSTIC CODE P1390 — — ——————

H901395 ABS/ESP/TCS DIAGNOSTIC CODE P1395 — — ——————

H901500 ABS/ESP/TCS DIAGNOSTIC CODE P1500 — — ——————

H901571 ABS/ESP/TCS DIAGNOSTIC CODE P1571 — — ——————

H901650 ABS/ESP/TCS DIAGNOSTIC CODE U1650 — — ——————

H901711 ABS/ESP/TCS DIAGNOSTIC CODE P1711 — — ——————

H901712 ABS/ESP/TCS DIAGNOSTIC CODE P1712 — — ——————

H902100 ABS/ESP/TCS DIAGNOSTIC CODE U2100 — — ——————

H902103 ABS/ESP/TCS DIAGNOSTIC CODE U2103 — — ——————

H902104 ABS/ESP/TCS DIAGNOSTIC CODE U2104 — — ——————

H902105 ABS/ESP/TCS DIAGNOSTIC CODE U2105 — — ——————

H902106 ABS/ESP/TCS DIAGNOSTIC CODE U2106 — — ——————

H902108 ABS/ESP/TCS DIAGNOSTIC CODE U2108 — — ——————

H902139 ABS/ESP/TCS DIAGNOSTIC CODE U2139 — — ——————

H902142 ABS/ESP/TCS DIAGNOSTIC CODE U2142 — — ——————

H902143 ABS/ESP/TCS DIAGNOSTIC CODE U2143 — — ——————

H902160 ABS/ESP/TCS DIAGNOSTIC CODE U2160 — — ——————

H902795 ABS/ESP/TCS DIAGNOSTIC CODE B2795 — — ——————

LTG GI_05

05-050

05-290

05-400 05-290

05-400

05-250 (FWD)

05-290 (RWD+IRS)

05-400 (RWD)

05-290

05-400

05-800

05-825

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT/REAR DIFFERENTIAL, REAR AXLE,

WHEELS

05-050 PROPELLER SHAFT

1 F907100 SHAFT ASM. REAR PROPELLER — R&R/REPLACE .6 .4 .4 .4 .6 .4 .4 .4

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

2 F911100 UNIVERSAL JOINT, PROPELLER SHAFT CENTRE

— REPLACE — .8 .8 .8 — .8 .8 .8

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

F911100 BEARING, CONSTANT VELOCITY JOINT — R&R/

REPLACE — — — — — — — .8

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — — — — — — — .5

3 F912100 BEARING, PROPELLER SHAFT CENTRE —

REPLACE — 1.0 1.0 1.0 — 1.0 1.0 1.0

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

4 F908100 UNIVERSAL JOINT/RUBBER MOUNT, FRONT —

REPLACE — .6 .6 .6 — .6 .6 .8

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

5 F908200 YOKE, PROPELLER SHAFT SLIP, FRONT —

REPLACE — .6 .6 .6 — .6 .6 .8

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

6 F910100 UNIVERSAL JOINT/RUBBER MOUNT, REAR —

REPLACE .7.6.6.6.7.6.6.8

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

7 F908300 FLA NGE, PROPELLER SHAFT, REAR — REPLACE — — — — — — — .8

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — — — — — — — .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT/REAR DIFFERENTIAL, REAR AXLE,

WHEELS

05-250 DIFFERENTIAL, ALL WHEEL DRIVE

E200500 SEAL, FRONT DIFFERENTIAL PINION OIL —

REPLACE — .9 .9 — — — — —

E303600 SEAL, INTERMEDIATE DRIVE SHAFT OIL —

REPLACE OUTER — .5 .5 — — — — —

E303500 SEAL, INTERMEDIATE DRIVE SHAFT OIL —

REPLACE INNER — 1.4 1.4 — — — — —

1 E200130 DIFFERENTIAL ASM. FRONT (AWD) — REPLACE — 2.4 2.4 — — — — —

2 K009820 BEARING, DIFFERENTIAL SIDE — REPLACE — — — — — — — —

3 F905100 SHAFT, FRONT DIFFERENTIAL PROPELLER —

REPLACE — .5 .5 — — — — —

4 K703156 DIFFERENTIAL ASM. (FWD) — REPLACE — — — — — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

5 F905200 BEARING, FRONT PROPELLER SHAFT —

REPLACE — .6 .6 — — — — —

6 E302010 SEAL, DRIVE SHAFT OIL — REPLACE BOTH SIDES — 2.5 2.5 — — — — —

E302110 SEAL, RH DRIVE SHAFT OUTPUT OIL — REPLACE — 2.4 2.4 — — — — —

E302120 SEAL, LH DRIVE SHAFT OUTPUT OIL — REPLACE — .5 .5 — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT/REAR DIFFERENTIAL, REAR AXLE,

WHEELS

05-290 DIFFERENTIAL, REAR DRIVE SHAFTS

(IRS)

F653100 COVER/GASKET, REAR AXLE HOUSING INSPEC—

TION — REPLACE — .4 .4 .4 — .4 .4 .4

F501100 FLANGE ASM. DIFFERENTIAL PINION — REPLACE — .7 .7 .7 — .7 .7 .7

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

F502100 SEAL, PINION SHAFT OIL — REPLACE — .8 .8 .8 — .8 .8 .8

ADD FOR: DUAL INTERMEDIATE EXHAUST PIPE — .5 .5 .5 — .5 .5 .5

F505500 SEAL, REAR AXLE DRIVE SHAFT INNER —

REPLACE BOTH 1.7 .8 .8 .8 1.7 .8 .8 .8

F505400 SEAL, REAR AXLE DRIVE SHAFT INNER RH —

REPLACE 1.7 .5 .5 .5 1.7 .5 .5 .5

F505300 SEAL, REAR AXLE DRIVE SHAFT INNER LH —

REPLACE 1.7 .5 .5 .5 1.7 .5 .5 .5

1 F650100 DIFFERENTIAL ASM. (COMPLETE) — REPLACE 1.7 2.2 2.2 2.2 1.7 2.2 2.2 2.2

F650200 DIFFERENTIAL ASM. (RECONDITION) — R & R — 2.2 2.2 2.2 — 2.2 2.2 2.2

*** PRIOR ZONE APPROVAL REQUIRED ***

2 F504000 DRIVE S HAFT, RR AXLE — REPLACE BOTH SIDES

(RR) 1.2 1.0 1.0 1.0 1.2 1.0 1.0 1.0

F504100 DRIVE SHAFT, RR AXLE RH — REPLACE (RR) .6 .5 .5 .5 .6 .5 .5 .5

F504200 DRIVE SHAFT, RR AXLE LH — REPLACE (RR) .6 .5 .5 .5 .6 .5 .5 .5

3 F504150 DAMPER BLOCK A SM. DIFFERENTIAL —

REPLACE — .4 .4 .4 — .4 .4 .4

4 F201350 FLANGE ASM. TRUNION RH RR AXLE — REPLACE — 1.3 1.3 1.3 — 1.3 1.3 1.3

F201450 FLANGE ASM. TRUNION LH RR AXLE — REPLACE — 1.3 1.3 1.3 — 1.3 1.3 1.3

5 F701000 BEARING/HUB, REAR WHEEL — REPLACE BOTH 1.2 — — — 1.2 — — —

— 1

DIFFERENTIAL, REAR DRIVE SHAFTS

(IRS)

FRONT/REAR DIFFERENTIAL, REAR AXLE,

WHEELS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

05-290 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

F701100 BEARING/HUB, REAR WHEEL RH — REPLACE .6 2.8 2.8 2.8 .6 2.8 2.8 2.8

F701200 BEARING/HUB, REAR WHEEL LH — REPLACE .6 2.8 2.8 2.8 .6 2.8 2.8 2.8

6 F201300 TRUNION/STUB AXLE, RH REAR — REPLACE — 1.3 1.3 1.3 — 1.3 1.3 1.3

F201400 TRUNION/STUB AXLE, LH REAR — REPLACE — 1.3 1.3 1.3 — 1.3 1.3 1.3

E006500 STUD/BOLT, REAR WHEEL RH — REPLACE (ONE/

ALL) — .7 .7 .7 — .7 .7 .7

E006600 STUD/BOLT, REAR WHEEL LH — REPLACE (ONE/

ALL) — .7 .7 .7 — .7 .7 .7

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT/REAR DIFFERENTIAL, REAR AXLE,

WHEELS

05-400 DIFFERENTIAL, REAR AXLE ASM (NON

IRS)

F506300 PULSE RING, ABS SENSOR — REPLACE BOTH

SIDES —1.01.0—————

F506400 PULSE RING, ABS SENSOR RH — REPLACE — .6 .6 — — — — —

F506500 PULSE RING, ABS SENSOR LH — REPLACE — .6 .6 — — — — —

1 F650100 REAR A XLE/DIFFERENTIAL ASM. COMPLETE —

REPLACE — 1.9 1.9 — — — — —

F650200 DIFFERENTIAL ASM. (RECONDITION) — R & R — 1.9 1.9 — — — — —

*** PRIOR ZONE APPROVAL REQUIRED ***

2 F501100 FLANGE ASM. DIFFERENTIAL PINION — REPLACE — .7 .7 — — — — —

3 F502100 SEAL, PINION SHAFT OIL — REPLACE — .8 .8 — — — — —

4 F653100 COVER, DIFFERENTIAL INSPECTION — REPLACE — .4 .4 — — — — —

5 F653100 GASKET, DIFF INSPECTION COVER — REPLACE — .4 .4 — — — — —

6 F504000 SHAFT, REAR AXLE — REPLACE BOTH SIDES — 1.0 1.0 — — — — —

F504100 SHAFT, REAR AXLE RH — REPLACE — .6 .6 — — — — —

F504200 SHAFT, REAR AXLE LH — REPLACE — .6 .6 — — — — —

7 F505000 SEAL, AXLE SHAFT OIL — REPLACE BOTH SIDES — 1.0 1.0 — — — — —

F505100 SEAL, AXLE SHAFT RH OIL — REPLACE — .6 .6 — — — — —

F505200 SEAL, AXLE SHAFT LH OIL — REPLACE — .6 .6 — — — — —

8 F506000 BEARING, AXLE SHAFT — REPLACE BOTH SIDES — 1.0 1.0 — — — — —

F506100 BEARING, AXLE SHAFT RH — REPLACE — .6 .6 — — — — —

F506200 BEARING, AXLE SHAFT LH — REPLACE — .6 .6 — — — — —

9 E006500 STUD/BOLT, REAR WHEEL RH — REPLACE (ONE/

ALL) — .7 .7 — — — — —

— 1

DIFFERENTIAL, REAR AXLE ASM (NON

IRS)

FRONT/REAR DIFFERENTIAL, REAR AXLE,

WHEELS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

05-400 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

E006600 STUD/BOLT, REAR WHEEL LH — REPLACE (ONE/

ALL) — .7 .7 — — — — —

10 F651100 HOUSING, REAR AXLE — REPLACE — — — — — — — —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT/REAR DIFFERENTIAL, REAR AXLE,

WHEELS

05-800 ROAD WHEEL

P207000 WHEEL BALANCE, A LL WHEELS .7 1.0 1.0 1.0 .7 1.0 1.0 1.0

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

P207100 WHEEL BALANCE, FRONT WHEE LS .4 .6 .6 .6 .4 .6 .6 .6

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

P207200 WHEEL BALANCE, REAR WHE ELS .4 .6 .6 .6 .4 .6 .6 .6

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

1 E000500 CAP ASM. WHEEL CENTRE (ONE OR ALL) —

REPLACE .2.3.3.3.2.3.3.3

*** PRIOR ZONE APPROVAL REQUIRED ***

2 E000510 COVER ASM. WHEEL TRIM (ONE OR ALL) —

REPLACE .2.3.3.3.2.3.3.3

*** PRIOR ZONE APPROVAL REQUIRED ***

3 E006300 NUT/STUD, WHEEL ATTACHING (ONE/ALL) —

REPLACE .2.2.2.2.2.2.2.2

E006400 CAP (PLA STIC), WHEEL NUTS — REPLACE (ONE/

ALL) .2 .2 .2 .2 .2 .2 .2 .2

4 E000100 WHEEL ASM. (ONE) — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

ADD TO: REPLACE EACH ADDITIONAL WHEEL/

TYRE .2 .3 .3 .3 .2 .3 .3 .3

— 1

ROAD WHEEL

FRONT/REAR DIFFERENTIAL, REAR AXLE,

WHEELS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

05-800 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

5 E000900 VALVE STEM/TYRE PRESSURE INDICATOR

(ONE) ROADWHEEL — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

ADD TO: REPLACE EACH ADDITIONAL VALVE

STEM .2 .3 .3 .3 .2 .3 .3 .3

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT/REAR DIFFERENTIAL, REAR AXLE,

WHEELS

05-825 JACK & SPARE WHEEL

R426500 HOIST, SPARE WHEEL (UTE) — REPLACE — .3 .3 .3 — — — —

1 E001000 CONTAINER, JACK ASM — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

2 E001600 WRENCH, WHEEL NUT — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

3 E001500 JACK ASM. LIFTING — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

*** PRIOR ZONE APPROVAL REQUIRED AFTER

PD***

4 E001300 BOLT/PLATE, SPARE WHEEL RETAINING —

REPLACE .2.2.2.2.2.2.2.2

5 E001400 NUT, SPARE WHEEL RETAINING — REPLACE — .2 .2 .2 — .2 .2 .2

— 1

LTG GI_06

06-200

06-275

06-310

06-200

06-205

06-210

06-400

06-212

06-400

06-250

06-253

06-225

06-255

06-400

DIAGNOSTIC

TROUBLE CODES

SRS

DIAGNOSTIC

TROUBLE CODES

STEERING

06-999 06-999A

06-400

06-225

SRS

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-200 FRONT CROSSMEMBER, DRIVE SHAFTS

P201120 WHEEL ALIGNMENT — CHECK & ADJUST .5 .3 .3 .3 .5 .3 .3 .3

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT — .6 .6 .6 — .6 .6 .6

*** PRIOR ZONE APPROVAL REQUIRED ***

J315400 GUARD, OIL PAN ASM — REPLACE .2 .4 .4 .4 .2 .4 .4 .4

E303400 SEAL, INTERMEDIATE DRIVE SHAFT OIL —

REPLACE OUTER — .5 .5 — — — — —

E303500 SEAL, INTERMEDIATE DRIVE SHAFT OIL —

REPLACE INNER — 1.4 1.4 — — — — —

E302010 SEAL, DRIVE SHA FT OIL — REPLACE BOTH SIDES — 2.5 2.5 — — — — —

E302110 SEAL, RH DRIVE SHAFT OUTPUT OIL — REPLACE — 2.4 2.4 — — — — —

E302120 SEAL, LH DRIVE SHAFT OUTPUT OIL — REPLACE — .5 .5 — — — — —

1 E400400 CROSSMEMBER ASM. FRONT SUSPENSION —

R&R/REPLACE — 2.3 2.3 2.3 — 2.3 2.3 2.3

2 E100100 ARM ASM. RH FRONT LOWER CONTROL —

REPLACE .4 1.0 1.0 1.0 .4 1.0 1.0 1.0

E100200 ARM ASM. LH FRONT LOWER CONTROL —

REPLACE .4 1.0 1.0 1.0 .4 1.0 1.0 1.0

3 E103000 BALL JOINT, LOWER FRONT — REPLACE BOTH

SIDES — .9 .9 .9 — .9 .9 .9

E103300 BALL JOINT, LOWER RH FRONT — REPLACE — .6 .6 .6 — .6 .6 .6

E103400 BALL JOINT, LOWER LH FRONT — REPLACE — .6 .6 .6 — .6 .6 .6

4 E106100 ROD, LH FRONT CONTROL ARM — REPLACE .4 .7 .7 .7 .4 .7 .7 .7

E106200 ROD, RH FRONT CONTROL ARM — REPLACE .4 .7 .7 .7 .4 .7 .7 .7

— 1

FRONT CROSSMEMBER, DRIVE SHAFTS

FRONT SUSPENSION, STEERING & SRS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

06-200 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

5 E112000 BUSH ASM. FRONT CONTROL ARM ROD —

REPLACE BOTH SIDES — 1.0 1.0 1.0 — 1.0 1.0 1.0

E112100 BUSH ASM. RH FRONT CONTROL ARM ROD —

REPLACE — .6 .6 .6 — .6 .6 .6

E112200 BUSH ASM. LH FRONT CONTROL ARM ROD —

REPLACE — .6 .6 .6 — .6 .6 .6

6 E100010 BUSH ASM. FRONT LOWER CONTROL ARM —

REPLACE BOTH SIDES — 1.0 1.0 1.0 — 1.0 1.0 1.0

E100110 BUSH ASM. RH FRONT LOWER CONTROL ARM —

REPLACE — .6 .6 .6 — .6 .6 .6

E100210 BUSH A SM. LH FRONT LOWER CONTROL ARM —

REPLACE — .6 .6 .6 — .6 .6 .6

7 E303110 CV JOINT/BOOT, RH FRONT DRIVE SHAFT —

REPLACE — .7 .7 — — — — —

E303210 CV JOINT/BOOT, LH FRONT DRIVE SHAFT —

REPLACE — .6 .6 — — — — —

E303100 DRIVE S HAFT ASM. RH FRONT — R&R/REPLACE — .5 .5 — — — — —

E303200 DRIVE S HAFT ASM. LH FRONT — R&R/REPLACE — .5 .5 — — — — —

E303300 DRIVE S HAFT ASM. INTERMEDIATE — R&R/

REPLACE — 1.4 1.4 — — — — —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-205 FRONT STABILIZER BAR

1 E109100 BAR, FRONT STABILIZER — REPLACE .6 2.4 2.4 2.4 .6 2.4 2.4 2.4

2 E109150 BUSH/PLATE, STABILIZER BAR TO CROSSMEM—

BER — REPLACE .2.3.3.3.2.3.3.3

3 E109200 STUD/BUSH/WASHER, STABILIZER BAR TO

STRUT — REPLACE .2.3.4.4.2.3.4.4

E109200 ADD TO: REPLACE BOTH SIDES — .1 .2 .2 .1 .1 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-210 SPRING, BOOT, BEARING & STRUT

MOUNTING

1 E105000 SPRING, FRONT COIL BOTH — R&R/REPLACE 1.7 1.7 1.7 1.7 1.7 1.7 1.7 1.7

E105100 SPRING, FRONT COIL RH — R&R/REPLACE .9 1.0 1.0 1.0 .9 1.0 1.0 1.0

E105200 SPRING, FRONT COIL LH — R&R/REPLACE .9 1.0 1.0 1.0 .9 1.0 1.0 1.0

2 E105120 INSULATOR, SPRING UPPER FRONT COIL RH —

REPLACE .8.8.8.8.8.8.8.8

E105220 INSULATOR, SPRING UPPER FRONT COIL LH —

REPLACE .8.8.8.8.8.8.8.8

3 E130210 BOOT/BUMPER, PISTON ROD RH — REPLACE .8 .8 .8 .8 .8 .8 .8 .8

E130220 BOOT/BUMPER, PISTON ROD LH — REPLACE .8 .8 .8 .8 .8 .8 .8 .8

4 E130010 PLATE/BEARING ASM. RH FRONT — REPLACE .8 .8 .8 .8 .8 .8 .8 .8

ADD: TO REPLACE OPPOSITE SIDE .5 .5 .5 .5 .5 .5 .5 .5

E130020 PLATE/BEARING ASM. LH FRONT — REPLACE .8 .8 .8 .8 .8 .8 .8 .8

ADD: TO REPLACE OPPOSITE SIDE .5 .5 .5 .5 .5 .5 .5 .5

5 E130030 STOP/NUT/CAP, SUSPENSION REBOUND RH —

REPLACE .2.3.3.3.2.3.3.3

E130040 STOP/NUT/CAP, SUSPENSION REBOUND LH —

REPLACE .2.3.3.3.2.3.3.3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-212 STEERING KNUCKLE, STRUT & HUB

P201120 WHEEL ALIGNMENT — CHECK & ADJUST .5 .3 .3 .3 .5 .3 .3 .3

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT — .6 .6 .6 — .6 .6 .6

*** PRIOR ZONE APPROVAL REQUIRED ***

1 E108000 STRUT ASM, BOTH FRONT — REPLACE 1.7 2.0 2.0 2.0 1.7 2.0 2.0 2.0

E108100 STRUT AS M, RH FRONT — REPLACE .9 1.4 1.4 1.4 .9 1.4 1.4 1.4

E108200 STRUT AS M, LH FRONT — REPLACE .9 1.4 1.4 1.4 .9 1.4 1.4 1.4

2 E111100 KNUCKLE/ARM ASM. STEERING RH — REPLACE .6 .8 .8 .8 .6 .8 .8 .8

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

E111200 KNUCKLE/ARM ASM. STEERING LH — REPLACE .6 .8 .8 .8 .6 .8 .8 .8

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

3 E115000 HUB/BEARING, FRONT WHEEL BOTH SIDES —

REPLACE .8.8.8.8.8.8.8.8

E115100 HUB/BEARING, FRONT WHEEL RH — REPLACE .5 .5 .5 .5 .5 .5 .5 .5

E115200 HUB/BEARING, FRONT WHEEL LH — REPLACE .5 .5 .5 .5 .5 .5 .5 .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-225 STEERING WHEEL, HORN BAR & SRS

R201600 SWITCH, TRANSMISSION SHIFT STEERING

WHEEL CONTROLS — REPLACE — .4 — — — .4 — —

R205520 RADIO CONTROLS, HORN BAR — REPLACE .5 .3 .3 .4 .5 .3 .3 .4

1 M200100 AIR BAG UNIT, DRIVER SRS — REPLACE .3 .3 .3 .3 .3 .3 .3 .3

2 M001500 WHEEL ASM. STEERING — REPLACE .5 .4 .4 .4 .5 .4 .4 .4

3 M200200 COIL, SRS AIR BAG — REPLACE .6 .5 .5 .6 .6 .5 .5 .6

4 M200300 AIR BAG UNIT, PASSENGER SRS — REPLACE 3.6 2.0 2.0 2.0 3.6 2.0 2.0 2.0

5 N506800 MODULE, SRS AIR BAG — REPLACE 1.3 .5 .5 .5 1.3 .5 .5 .5

6 N506900 SENSOR, PERIPHERAL ACCELERATION RH —

REPLACE .3.4.4.4.3.4.4.4

N506950 SENSOR, PERIPHERAL ACCELERATION LH —

REPLACE .3.4.4.4.3.4.4.4

7 C454700 AIRBAG UNIT, CURTAIN — REPLACE BOTH 1.8 — — — 1.8 — — —

C454710 AIRBAG UNIT, CURTAIN — REPLACE LEFT HAND

SIDE 1.5———1.5———

C454720 AIRBAG UNIT, CURTAIN — REPLACE RIGHT HAND

SIDE 1.5———1.5———

8 N401900 CURTAIN AIRBAG HARNESS — REPLACE BOTH

SIDES ————————

9 C885500 AIR BAG UNIT, RH FRONT SEAT LATERAL —

REPLACE .8.8.8.8.8.8.8.8

ADD FOR: COUPE — .1 .1 .1 — — — —

C885600 AIR BAG UNIT, LH FRONT SEAT LATERAL —

REPLACE .8.8.8.8.8.8.8.8

ADD FOR: COUPE — .1 .1 .1 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-250 STEERING COLUMN COVERS &

SWITCHES

1 M018100 COVER, STEERING COLUMN UPPER — REPLACE .4 .3 .3 .3 .4 .3 .3 .3

2 N203000 SWITCH/LEVER, WINDSHIELD WIPER WASHER —

REPLACE .5.3.3.3.5.3.3.3

3 M018150 COVER, STEERING COLUMN LOWER — REPLACE .4 .2 .2 .2 .4 .2 .2 .2

4 N202600 SWITCH/LEVER, TURN SIGNAL & HEADLAMP

DIMMER — REPLACE .5.3.3.3.5.3.3.3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-253 STEERING COLUMN

1 M019100 STEERING COLUMN ASM. COMPLETE — R&R/

REPLACE 1.2 1.2 1.2 1.2 1.2 1.2 1.2 1.2

2 M015300 LEVER ASM, TILT STEERING — REPLACE — .5 .5 .5 — .5 .5 .5

3 M018200 BOOT/SEAL, STEERING COLUMN TO FLOOR —

REPLACE — 1.0 1.0 1.0 — 1.0 1.0 1.0

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-255 IGNITION LOCK, SWITCH & KEYS

N317700 RECEIVER, REMOTE KEY SIGNAL — REPLACE .5 .4 .4 .4 .5 .4 .4 .4

1 N312500 CYLINDER ASM. IGNITION LOCK — REPLACE .6 .3 .3 .3 .6 .3 .3 .3

ADD FOR: BARREL RECODE — .3 .3 .3 — .3 .3 .3

2 N313500 SWITCH, IGNITION — REPLACE .5 .4 .4 .4 .5 .4 .4 .4

3 M012510 SWITCH HOUSING/BEARING SUPPORT ASM. —

REPLACE ————————

4 N313600 SLIP RING, KEY READER — REPLACE .5 .3 .3 .3 .5 .3 .3 .3

5 N501600 REMOTE KEY HEAD — REPLACE ONE/BOTH — .3 .3 .3 — .3 .3 .3

TIME TO REPROGRAM BOTH REMOTES

INCLUDED

6 N501650 SHAFT, REMOTE KEY — RE PLACE — .3 .3 .3 — .3 .3 .3

7 N501675 SCREWS, REMOTE KEY HEAD TO SHAFT —

REPLACE — .2 .2 .2 — .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-275 STEERING GEAR

P201120 WHEEL ALIGNMENT — CHECK & ADJUST .5 .3 .3 .3 .5 .3 .3 .3

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT — .6 .6 .6 — .6 .6 .6

*** PRIOR ZONE APPROVAL REQUIRED ***

M036200 RACK PAD, STEERING GEAR — CHECK & ADJUST — .4 .4 .4 — .4 .4 .4

1 M013500 SHAFT, COUPLING ASM STEERING INTERMEDI—

ATE — REPLACE — — — — — — — —

2 M041000 GEAR ASM. POWER STEERING — R&R/REPLACE 1.1 1.4 1.4 1.4 1.1 1.4 1.4 1.4

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

M041010 GEAR ASM. POWER STEERING — R&R/OVER—

HAUL — 4.1 4.1 4.1 — 4.1 4.1 4.1

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT — .6 .6 .6 — .6 .6 .6

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-310 STEERING GEAR BREAKDOWN

M130150 PINION & BEARING ASM. STEERING — REPLACE — .8 .8 .8 — .8 .8 .8

M147200 VALVE ASM. POWER STEERING — REPLACE — .8 .8 .8 — .8 .8 .8

1 M144000 PIPE, FEED HYDRAULIC ANY ONE — REPLACE — .5 .5 .5 — .5 .5 .5

2 M035000 ROD, STEERING TIE — REPLACE BOTH SIDES .5 .7 .7 .7 .5 .7 .7 .7

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

M035110 ROD, STEERING TIE RH — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

M035210 ROD, STEERING TIE LH — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

3 M037000 BELLOW, TIE ROD END — REPLACE BOTH SIDES .5 .9 .9 .9 .5 .9 .9 .9

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

M037100 BELLOW, TIE ROD END RH — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

M037200 BELLOW, TIE ROD END LH — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

4 M035010 SOCKET ASM. TIE ROD LH — REPLACE .2 .5 .5 .5 .2 .5 .5 .5

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

— 1

STEERING GEAR BREAKDOWN

FRONT SUSPENSION, STEERING & SRS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

06-310 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

M035020 SOCKET ASM. TIE ROD RH — REPLACE .2 .5 .5 .5 .2 .5 .5 .5

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

5 M041100 HOUSING ASM. — REPLACE — 2.1 2.1 2.1 — 2.1 2.1 2.1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

FRONT SUSPENSION, STEERING & SRS

06-400 POWER STEERING PUMP & IDLER

PULLEY

M048100 BRACKET/BUSHING, POWER STEERING PUMP

MOUNTING — REPLACE .6.7.7.7.6.7.7.7

1 M147000 PUMP ASM/SUPPLY UNIT, POWER STEERING —

R&R/REPLACE (INCLUDES HUB/PULLEY

REMOVAL) .5 .8 .7 .7 .5 .8 .7 .7

ADD FOR: V6 — — .2 .2 — — .2 .2

M147100 SEAL, PUMP ASM POWER STEERING — REPLACE — .9 .9 .9 — .9 .9 .9

ADD FOR: V6 — — .2 .2 — — .2 .2

M147500 PUMP ASM. POWER STEERING — R&R/OVER—

HAUL — 1.2 1.2 1.2 — 1.2 1.2 1.2

M043100 PULLEY, POWER STEERING PUMP — REPLACE .6 .7 .3 .3 .6 .7 .3 .3

ADD FOR: GEN III, GEN IV — — .4 .4 — — .4 .4

ADD FOR: HFV6 —.1———.1——

2 M048400 PIPE & HOSE, STEERING RACK TO RETURN

HOSE — REPLACE .7.4.4.4.7.4.4.4

3 M048200 PIPE & HOSE, PRESSURE — REPLACE .4 .4 .4 .4 .4 .4 .4 .4

ADD FOR: HFV6 —.7———.7——

4 M048000 HOSE, RETURN — REPLACE .6 .3 .3 .3 .6 .3 .3 .3

5 M048500 HOSE/PIPE, RESERVOIR TO PUMP — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

6 M050500 RESERVOIR ASM. POWER STEERING — R&R/

REPLACE .2.3.3.3.2.3.3.3

7 M048300 CAP, POWER STEERING PUMP RESERVOIR —

REPLACE .2.2.2.2.2.2.2.2

8 M048600 "O" RING, ANY/ALL — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

— 1

POWER STEERING PUMP & IDLER

PULLEY

FRONT SUSPENSION, STEERING & SRS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

06-400 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

9 M048700 CLAMP, POWER STEERING HOSE ANY/ALL —

REPLACE .2.3.3.3.2.3.3.3

10 M044300 COOLER, POWER STEERING — REPLACE — .5 .5 .5 — .5 .5 .5

11 M044400 HOSE, POWER STEERING COOLER — REPLACE

ONE/BOTH — .4 .4 .4 — .4 .4 .4

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

06- 999 —

DIAGNOSTIC TROUBLE CODES

SRS

M900004 SRS DIAGNOSTIC CODE 04 — — ——————

M900005 SRS DIAGNOSTIC CODE 05 — — ——————

M900006 SRS DIAGNOSTIC CODE 06 — — ——————

M900007 SRS DIAGNOSTIC CODE 07 — — ——————

M900008 SRS DIAGNOSTIC CODE 08 — — ——————

M900009 SRS DIAGNOSTIC CODE 09 — — ——————

M900012 SRS DIAGNOSTIC CODE 12, B0012 0.3 ST — — 0.3 ST — —

M900013 SRS DIAGNOSTIC CODE 13, B0013 0.3 — — ST 0.3 — — ST

M900014 SRS DIAGNOSTIC CODE 14, B0014 0.3 — — ST 0.3 — — ST

M900015 SRS DIAGNOSTIC CODE 15, B0015 0.3 — — ST 0.3 — — ST

M900016 SRS DIAGNOSTIC CODE 16, B0016 0.3 — — ST 0.3 — — ST

M900017 SRS DIAGNOSTIC CODE 17, B0017 — ST ST ST — ST ST ST

M900018 SRS DIAGNOSTIC CODE 18, B0018 — ST ST ST — ST ST ST

M900019 SRS DIAGNOSTIC CODE 19, B0019 0.3 ST ST ST 0.3 ST ST ST

M900020 SRS DIAGNOSTIC CODE 20, B0020 0.3 ST ST ST 0.3 ST ST ST

M900021 SRS DIAGNOSTIC CODE 21, B0021 0.3 ST ST ST 0.3 ST ST ST

M900022 SRS DIAGNOSTIC CODE 22, B0022 0.3 ST ST ST 0.3 ST ST ST

M900023 SRS DIAGNOSTIC CODE 23, B0023 0.3 — — ST 0.3 — — ST

M900024 SRS DIAGNOSTIC CODE 24, B0024 — — — ST — — — ST

M900025 SRS DIAGNOSTIC CODE 25, B0025 — — — ST — — — ST

M900026 SRS DIAGNOSTIC CODE 26, B0026 — — — ST — — — ST

M900028 SRS DIAGNOSTIC CODE 28, B0028 — — ——————

M900029 SRS DIAGNOSTIC CODE 29, B0029 — — ——————

M900030 SRS DIAGNOSTIC CODE 30, B0030 — — ——————

M900031 SRS DIAGNOSTIC CODE 31, B0031 — — — ST — — — ST

M900032 SRS DIAGNOSTIC CODE 32, B0032 — ST ST ST — ST ST ST

M900033 SRS DIAGNOSTIC CODE 33, B0033 — ST ST ST — ST ST ST

M900034 SRS DIAGNOSTIC CODE 34, B0034 — ST ST ST — ST ST ST

M900035 SRS DIAGNOSTIC CODE 35, B0035 — ST ST ST — ST ST ST

M900036 SRS DIAGNOSTIC CODE 36, B0036 — ST ST ST — ST ST ST

M900037 SRS DIAGNOSTIC CODE 37, B0037 — ST ST ST — ST ST ST

M900038 SRS DIAGNOSTIC CODE 38, B0038 — ST ST ST — ST ST ST

M900040 SRS DIAGNOSTIC CODE 40, B0040 — — ——————

M900041 SRS DIAGNOSTIC CODE 41, B0041 — — ——————

M900043 SRS DIAGNOSTIC CODE 43, B0043 — — ——————

M900044 SRS DIAGNOSTIC CODE 44, B0044 — — ——————

M900045 SRS DIAGNOSTIC CODE 45, B0045 — — ——————

M900046 SRS DIAGNOSTIC CODE 46, B0046 — — ——————

M900048 SRS DIAGNOSTIC CODE 48, B0048 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

SRS

DIAGNOSTIC TROUBLE CODES

06- 999 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

M900049 SRS DIAGNOSTIC CODE 49, B0049 — ST ST ST — ST ST ST

M900050 SRS DIAGNOSTIC CODE 50, B0050 — ST ST ST — ST ST ST

M900051 SRS DIAGNOSTIC CODE 51, B0051 — ST ST ST — ST ST ST

M900052 SRS DIAGNOSTIC CODE 52, B0052 0.3 ST ST ST 0.3 ST ST ST

M900053 SRS DIAGNOSTIC CODE 53, B0053 0.3 ST ST ST 0.3 ST ST ST

M900054 SRS DIAGNOSTIC CODE 54, B0054 — ST ST ST — ST ST ST

M900055 SRS DIAGNOSTIC CODE 55, B0055 0.3 — — ST 0.3 — — ST

M900056 SRS DIAGNOSTIC CODE 56, B0056 — — ——————

M900057 SRS DIAGNOSTIC CODE 57, B0057 — — ——————

M900058 SRS DIAGNOSTIC CODE 58, B0058 — — ——————

M900059 SRS DIAGNOSTIC CODE 59, B0059 — — ——————

M900060 SRS DIAGNOSTIC CODE 60, B0060 — — ——————

M900061 SRS DIAGNOSTIC CODE 61, B0061 — — ——————

M900062 SRS DIAGNOSTIC CODE 62, B0062 — — ——————

M900064 SRS DIAGNOSTIC CODE 64, B0064 — — ——————

M900065 SRS DIAGNOSTIC CODE 65, B0065 — ST ST ST — ST ST ST

M900066 SRS DIAGNOSTIC CODE 66, B0066 — ST ST ST — ST ST ST

M900067 SRS DIAGNOSTIC CODE 67, B0067 — ST ST ST — ST ST ST

M900068 SRS DIAGNOSTIC CODE 68, B0068 — ST ST ST — ST ST ST

M900069 SRS DIAGNOSTIC CODE 69, B0069 — ST ST ST — ST ST ST

M900070 SRS DIAGNOSTIC CODE 70, B0070 — ST ST ST — ST ST ST

M900071 SRS DIAGNOSTIC CODE 71, B0071 — — ——————

M900072 SRS DIAGNOSTIC CODE 72, B0072 0.3 — — — 0.3 — — —

M900073 SRS DIAGNOSTIC CODE 72, B0073, U0073 0.3 — — — 0.3 — — —

M900077 SRS DIAGNOSTIC CODE 77, B0077 — — ——————

M900078 SRS DIAGNOSTIC CODE 78, B0078 — — ——————

M900079 SRS DIAGNOSTIC CODE 79, B0079 0.3 — — — 0.3 — — —

M900080 SRS DIAGNOSTIC CODE 80, B0080 0.3 — — — 0.3 — — —

M900081 SRS DIAGNOSTIC CODE 81, B0081 — ST ST ST — ST ST ST

M900082 SRS DIAGNOSTIC CODE 82, B0082 — ST ST ST — ST ST ST

M900083 SRS DIAGNOSTIC CODE 83, B0083 0.3 ST ST ST 0.3 ST ST ST

M900084 SRS DIAGNOSTIC CODE 84, B0084 0.3 ST ST ST 0.3 ST ST ST

M900085 SRS DIAGNOSTIC CODE 85, B0085 0.3 ST ST ST 0.3 ST ST ST

M900086 SRS DIAGNOSTIC CODE 86, B0086 0.3 ST ST ST 0.3 ST ST ST

M900087 SRS DIAGNOSTIC CODE 87, B0087 — — ——————

M900088 SRS DIAGNOSTIC CODE 88, B0088 — — ——————

M900089 SRS DIAGNOSTIC CODE 89, B0089 — — ——————

M900090 SRS DIAGNOSTIC CODE 90, B0090 — — ——————

M900092 SRS DIAGNOSTIC CODE 92, B0092 — — ——————

M900093 SRS DIAGNOSTIC CODE 93, B0093 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

SRS

DIAGNOSTIC TROUBLE CODES

06- 999 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

M900095 SRS DIAGNOSTIC CODE 95, B0095 — — ——————

M900096 SRS DIAGNOSTIC CODE 96, B0096 — — ——————

M900097 SRS DIAGNOSTIC CODE 97, B0097 — ST ST ST — ST ST ST

M900098 SRS DIAGNOSTIC CODE 98, B0098 — ST ST ST — ST ST ST

M900099 SRS DIAGNOSTIC CODE 99, B0099 — ST ST ST — ST ST ST

M900100 SRS DIAGNOSTIC CODE 100, B0100 — ST ST ST — ST ST ST

M900101 SRS DIAGNOSTIC CODE 101, B0101 — ST ST ST — ST ST ST

M900102 SRS DIAGNOSTIC CODE 102, B0102 — ST ST ST — ST ST ST

M900118SRS DIAGNOSTIC CODE 118, B0118 ————————

M900119SRS DIAGNOSTIC CODE 119, B0119 ————————

M900120 SRS DIAGNOSTIC CODE 120, B0120 — — ——————

M900121 SRS DIAGNOSTIC CODE 121, B0121 — — ——————

M900122 SRS DIAGNOSTIC CODE 122, B0122 — — ——————

M900123 SRS DIAGNOSTIC CODE 123, B0123 — — ——————

M900129 SRS DIAGNOSTIC CODE 129, B0129 — ST ST ST — ST ST ST

M900130 SRS DIAGNOSTIC CODE 130, B0130 — ST ST ST — ST ST ST

M900131 SRS DIAGNOSTIC CODE 131, B0131 — ST ST ST — ST ST ST

M900132 SRS DIAGNOSTIC CODE 132, B0132 — ST ST ST — ST ST ST

M900133 SRS DIAGNOSTIC CODE 133, B0133 — ST ST ST — ST ST ST

M900134 SRS DIAGNOSTIC CODE 134, B0134 — ST ST ST — ST ST ST

M900135 SRS DIAGNOSTIC CODE 135, B0135 — ST ST ST — ST ST ST

M900136 SRS DIAGNOSTIC CODE 136, B0136 — ST ST ST — ST ST ST

M900140 SRS DIAGNOSTIC CODE U0140 0.3 — — — 0.3 — — —

M900155 SRS DIAGNOSTIC CODE U0155 0.3 — — — 0.3 — — —

M900161 SRS DIAGNOSTIC CODE 161, B0161 — ST ST ST — ST ST ST

M900163 SRS DIAGNOSTIC CODE 163, B0163 — ST ST ST — ST ST ST

M900177 SRS DIAGNOSTIC CODE 177, B0177 — ST ST — — ST ST —

M900241 SRS DIAGNOSTIC CODE 241, B0241 — ST ST — — ST ST —

M900242 SRS DIAGNOSTIC CODE 242, B0242 — ST ST — — ST ST —

M900247 SRS DIAGNOSTIC CODE 247, B0247 — ST ST ST — ST ST ST

M900670 SRS DIAGNOSTIC CODE 670, B0670 — — ——————

M900975 SRS DIAGNOSTIC CODE 975, B0975 — — ——————

M900996 SRS DIAGNOSTIC CODE B0996 0.3 — — — 0.3 — — —

M901000 SRS DIAGNOSTIC CODE B1000 0.3 — — — 0.3 — — —

M901001 SRS DIAGNOSTIC CODE B1001 0.3 — — — 0.3 — — —

M901016 SRS DIAGNOSTIC CODE B1016 0.3 — — — 0.3 — — —

M901325 SRS DIAGNOSTIC CODE B1325 0.3 — — — 0.3 — — —

M901370 SRS DIAGNOSTIC CODE B1370 0.3 — — — 0.3 — — —

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

06- 999A —

DIAGNOSTIC TROUBLE CODES

STEERING

M991111 STEERING DIAGNOSTIC CODE C1111 — — ——————

M991113STEERING DIAGNOSTIC CODE C1113 ————————

M991114STEERING DIAGNOSTIC CODE C1114 ————————

M991115STEERING DIAGNOSTIC CODE C1115 ————————

M991116STEERING DIAGNOSTIC CODE C1116 ————————

M991121STEERING DIAGNOSTIC CODE C1121 ————————

M991122STEERING DIAGNOSTIC CODE C1122 ————————

M991123STEERING DIAGNOSTIC CODE C1123 ————————

M991124STEERING DIAGNOSTIC CODE C1124 ————————

M991141STEERING DIAGNOSTIC CODE C1141 ————————

M991142STEERING DIAGNOSTIC CODE C1142 ————————

M991143STEERING DIAGNOSTIC CODE C1143 ————————

M991144STEERING DIAGNOSTIC CODE C1144 ————————

M991145STEERING DIAGNOSTIC CODE C1145 ————————

M991151STEERING DIAGNOSTIC CODE C1151 ————————

M991152STEERING DIAGNOSTIC CODE C1152 ————————

M991153STEERING DIAGNOSTIC CODE C1153 ————————

M991154STEERING DIAGNOSTIC CODE C1154 ————————

M991155STEERING DIAGNOSTIC CODE C1155 ————————

M991500 STEERING DIAGNOSTIC CODE C1500 — — ——————

M991502 STEERING DIAGNOSTIC CODE C1502 — — ——————

M991503 STEERING DIAGNOSTIC CODE C1503 — — ——————

M991504 STEERING DIAGNOSTIC CODE C1504 — — ——————

M991505 STEERING DIAGNOSTIC CODE C1505 — — ——————

M991506 STEERING DIAGNOSTIC CODE C1506 — — ——————

M991507 STEERING DIAGNOSTIC CODE C1507 — — ——————

M991508 STEERING DIAGNOSTIC CODE C1508 — — ——————

M991509 STEERING DIAGNOSTIC CODE C1509 — — ——————

M991510 STEERING DIAGNOSTIC CODE C1510 — — ——————

M991512 STEERING DIAGNOSTIC CODE C1512 — — ——————

M991517 STEERING DIAGNOSTIC CODE C1517 — — ——————

M991523 STEERING DIAGNOSTIC CODE C1523 — — ——————

M991525 STEERING DIAGNOSTIC CODE C1525 — — ——————

M991526 STEERING DIAGNOSTIC CODE C1526 — — ——————

M991527 STEERING DIAGNOSTIC CODE C1527 — — ——————

M991528 STEERING DIAGNOSTIC CODE C1528 — — ——————

M991529 STEERING DIAGNOSTIC CODE C1529 — — ——————

M991530 STEERING DIAGNOSTIC CODE C1530 — — ——————

M991531 STEERING DIAGNOSTIC CODE C1531 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

STEERING

DIAGNOSTIC TROUBLE CODES

06- 999A — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATION OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

M991532 STEERING DIAGNOSTIC CODE C1532 — — ——————

M991533 STEERING DIAGNOSTIC CODE C1533 — — ——————

M991534 STEERING DIAGNOSTIC CODE C1534 — — ——————

M991550 STEERING DIAGNOSTIC CODE C1550 — — ——————

LTG GI_07

07-150

07-150A

07-125

07-150A

07-500

07-525

07-150

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

REAR SUSPENSION & BUMPER BARS

07-125 REAR STABILIZER SHAFT (NON IRS)

1 F122100 STABILIZER SHAFT, RR — REPLACE — .5 .5 — — — — —

2 F125150 STRUT/BUSHES, RR STABILIZER BAR RH —

REPLACE — .3 .3 — — — — —

F125250 STRUT/BUSHES, RR STABILIZER BAR LH —

REPLACE — .3 .3 — — — — —

3 F125100 BUSH/PLATE, RR STABILIZER BAR RH —

REPLACE — .3 .3 — — — — —

F125200 BUSH/PLATE, RR STABILIZER BAR LH —

REPLACE — .3 .3 — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

REAR SUSPENSION & BUMPER BARS

07-150 REAR SUSPENSION, SHOCK ABSORBERS

F110500 FRAME, REAR HALF (CAB CHASSIS/CREWMAN)

ONLY — REPLACE/REPAIR — ST ST — — — — —

F106000 BUSH, LEAF SPRING FRONT EYE BOTH —

REPLACE — 1.6 1.6 — — — — —

F106100 BUSH, LEAF SPRING FRONT EYE RH — REPLACE — .9 .9 — — — — —

F106200 BUSH, LEAF SPRING FRONT EYE LH — REPLACE — .9 .9 — — — — —

F105000 SHACKLE/BUSH, LEAF SPRING BOTH — REPLACE — .8 .8 — — — — —

F105100 SHACKLE/BUSH, LEAF SPRING RH — REPLACE — .5 .5 — — — — —

F105200 SHACKLE/BUSH, LEAF SPRING LH — REPLACE — .5 .5 — — — — —

F108100 U BOLT, LEAF SPRING RH — REPLACE — .4 .4 — — — — —

F108200 U BOLT, LEAF SPRING LH — REPLACE — .4 .4 — — — — —

F102300 BRACKET, LEAF SPRING/SHOCKER MOUNTING

RH — REPLACE — .5 .5 — — — — —

F102400 BRACKET, LEAF SPRING/SHOCKER MOUNTING

LH — REPLACE — .5 .5 — — — — —

F102100 CENTRE BOLT, LEAF SPRING RH — REPLACE — .8 .8 — — — — —

F102200 CENTRE BOLT, LEAF SPRING LH — REPLACE — .8 .8 — — — — —

1 F109300 BUMPER AS M. PINION NOSE — REPLACE — .2 .2 .2 — .2 .2 .2

2 F114100 ROD ASM. PANHARD — REPLACE — — — — — — — —

3 F112000 ARM ASM. UPPER CONTROL BOTH — REPLACE — — — — — — — —

4 F109100 BUMPER, REAR AXLE RH — REPLACE — .2 .2 — — — — —

F109200 BUMPER, REAR AXLE LH — REPLACE — .2 .2 — — — — —

5 F110000 ARM ASM. LOWER CONTROL BOTH — REPLACE — — — — — — — —

— 1

REAR SUSPENSION, SHOCK ABSORBERS

REAR SUSPENSION & BUMPER BARS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

07-150 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

6 F111000 BUSHES, LOWER CONTROL ARM — REPLACE

ALL ————————

7 F100000 SPRING, REAR COIL BOTH — REPLACE 1.3 .6 .6 .6 1.3 .6 .6 .6

F101000 SPRING, REAR LEAF BOTH — REPLACE — 1.0 1.0 — — — — —

F100100 SPRING, REAR COIL RH — REPLACE .7 .4 .4 .4 .7 .4 .4 .4

F101100 SPRING, REAR LEAF RH — REPLACE — .7 .7 — — — — —

F100200 SPRING, REAR COIL LH — REPLACE .7 .4 .4 .4 .7 .4 .4 .4

F101200 SPRING, REAR LEAF LH — REPLACE — .7 .7 — — — — —

8 F202100 INSULATOR/SEAT, REAR COIL SPRING UPPER

RH — REPLACE — .4 .4 .4 — .4 .4 .4

F203100 INSULATOR/SEAT, REAR COIL SPRING UPPER

LH — REPLACE — .4 .4 .4 — .4 .4 .4

F202150 INSULATOR/SEAT, REAR COIL SPRING LOWER

RH — REPLACE — .4 .4 .4 — .4 .4 .4

F203150 INSULATOR/SEAT, REAR COIL SPRING LOWER

LH — REPLACE — .4 .4 .4 — .4 .4 .4

9 F120000 SHOCK ABSORBER, RE AR BOTH — REPLACE 1.3 .6 .6 .6 1.3 .6 .6 .6

F120100 SHOCK ABSORBER, REAR RH — REPLACE .7 .4 .4 .4 .7 .4 .4 .4

F120200 SHOCK ABSORBER, REAR LH — REPLACE .7 .4 .4 .4 .7 .4 .4 .4

F121300 SHOCK ABSORBER SUPERLIFT REAR BOTH —

REPLACE — .6 .6 .6 — .6 .6 .6

F121100 SHOCK ABSORBER SUPERLIFT REAR RH —

REPLACE — .4 .4 .4 — .4 .4 .4

F121200 SHOCK ABSORBER SUPERLIFT REAR LH —

REPLACE — .4 .4 .4 — .4 .4 .4

REAR SUSPENSION, SHOCK ABSORBERS

REAR SUSPENSION & BUMPER BARS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

07-150 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

F400600 AIR LINE ASM LH. S/LIFT SHOCK ABSORBER —

REPLACE — .3 .3 .3 — .3 .3 .3

F400650 AIR LINE ASM RH. S/LIFT SHOCK ABSORBER —

REPLACE — .3 .3 .3 — .3 .3 .3

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

REAR SUSPENSION & BUMPER BARS

07-150A REAR SUSPENSION, (IRS)

F104000 LINK ASM. REAR SUSPENSION ADJUSTMENT

BOTH — REPLACE .4.5.5.5.4.5.5.5

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

F104100 LINK ASM. REAR SUSPENSION ADJUSTMENT RH

— REPLACE .3.4.4.4.3.4.4.4

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

F104200 LINK ASM. REAR SUSPENSION ADJUSTMENT LH

— REPLACE .3.4.4.4.3.4.4.4

ADD FOR: ELECTRONIC/OPTICAL/LASER WHEEL

ALIGNMENT .5.6.6.6.5.6.6.6

F112000 ARM ASM. UPPER CONTROL BOTH — REPLACE 1.4 — — — 1.4 — — —

F112100 ARM ASM. UPPER CONTROL RH — REPLACE 1.3 — — — 1.3 — — —

F112200 ARM ASM. UPPER CONTROL LH — REPLACE 1.3 — — — 1.3 — — —

F110100 ARM ASM. LOWER CONTROL RH — REPLACE .5 — — — .5 — — —

F110200 ARM ASM. LOWER CONTROL LH — REPLACE .5 — — — .5 — — —

1 F110300 CROSSMEMBER/AXLE — R&R/REPLACE 2.6 3.6 3.6 3.6 2.6 3.6 3.6 3.6

F209900 CROSSMEMBER/AXLE REAR — ALIGNMENT

CHECK .5 1.0 1.0 1.0 .5 1.0 1.0 1.0

2 F110150 TRAILING ARM/LINK RH REAR — REPLACE — 2.8 2.8 2.8 — 2.8 2.8 2.8

F110250 TRAILING ARM/LINK LH REAR — REPLACE — 2.8 2.8 2.8 — 2.8 2.8 2.8

3 F122100 STABILIZER SHAFT, RR — REPLACE .5 1.6 1.6 1.6 .5 1.6 1.6 1.6

4 F125100 BUSH/PLATE, RR STABILIZER BAR RH —

REPLACE .2 1.4 1.4 1.4 .2 1.4 1.4 1.4

— 1

REAR SUSPENSION, (IRS)

REAR SUSPENSION & BUMPER BARS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

07-150A — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

F125200 BUSH/PLATE, RR STABILIZER BAR LH —

REPLACE .2 1.4 1.4 1.4 .2 1.4 1.4 1.4

5 F125150 SHACKLE & BUSH, RR STABILIZER BAR RH —

REPLACE .2.3.3.3.2.3.3.3

F125250 SHACKLE & BUSH, RR STABILIZER BAR LH —

REPLACE .2.3.3.3.2.3.3.3

6 F111300 BUSH, TRAILING ARM RR RH — REPLACE — 1.7 1.7 1.7 — 1.7 1.7 1.7

F111400 BUSH, TRAILING ARM RR LH — REPLACE — 1.7 1.7 1.7 — 1.7 1.7 1.7

7 F650500 BUSH, REAR CROSSMEMBER/AXLE BOTH —

REPLACE — 1.1 1.1 1.1 — 1.1 1.1 1.1

F650510 BUSH, REAR CROSSMEMBER/AXLE RH —

REPLACE — .7 .7 .7 — .7 .7 .7

F650520 BUSH, REAR CROSSMEMBER/AXLE LH —

REPLACE — .7 .7 .7 — .7 .7 .7

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

REAR SUSPENSION & BUMPER BARS

07-500 FRONT BUMPER BARS

P006100 BUMPER BA R ASM FRONT — ADJUST .2 .2 .2 .2 .2 .2 .2 .2

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

A550000 GRILLE ASM. (ONE/BOTH) — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

A506100 SKIRT/SILL PLATE, FRONT BUMPER BAR —

REPLACE — .4 .4 .4 — .4 .4 .4

A561520 COVER, TOWING EYE — REPLACE — .2 .2 — — .2 .2 —

N770150 SENSOR, FRONT PARKING AID — REPLACE (ONE/

ALL) .5 — — — .5 .6 — —

N770160 SWITCH, FRONT PARK ASSIST — REPLACE — — — — — .2 — —

1 A560500 FASCIA ASM. FRONT BUMPER BAR LOWER —

R&R/REPLACE .4.4.4.4.4.4.4.4

2 A506000 INSERT, FOG LAMPS (ONE/BOTH) — REPLACE .3 .2 .2 .2 .3 — — .2

3 A568000 MOULDING, FRONT BUMPER BAR — REPLACE — — — — .4 .3 .3 .3

4 A568100 GRILLE, LOWER RADIATOR, R&R/REPLACE. — .5 .5 .5 — — — —

5 A568200 PLATE, FRONT BUMPER SKID PLATE ALUMIN—

IUM — REPLACE — .4 .4 — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

REAR SUSPENSION & BUMPER BARS

07-525 REAR BUMPER BARS

N770000 SENSOR, REVERSE PARKING AID — REPLACE

(ONE/ALL) .5 .6 .6 .6 .5 .6 .6 —

N770100 MODULE/CONTROL UNIT, REVERSE PARKING

AID — REPLACE .5.3.3.3.5.5.5—

ADD FOR: SEDAN — .2 .2 .2 — — — —

N770200 SPEAKER, REVERSE PARKING AID — REPLACE .5 .3 .3 .3 .5 .5 .5 —

ADD FOR: SEDAN — .2 .2 .2 — — — —

A580000 STRIP AS M. REAR BUMPER — REPLACE — — — — — — — .3

1 A570500 FASCIA ASM. REAR BUMPER BAR COMPLETE —

R & R .4.4.4.4.4.5.5.5

ADD FOR: SEDAN/COUPE/CREWMAN — .1 .1 .1 — — — —

P006900 BUMPER BA R ASM. REAR — ADJUST .2 .2 .2 .2 .2 .2 .2 .2

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

A569500 BUMPERE TTE BAR ASM, REAR RH — REPLACE

(UTE ONLY) — .4 .4 .4 — — — —

A569600 BUMPERE TTE BAR ASM, REAR LH — REPLACE

(UTE ONLY) — .4 .4 .4 — — — —

2 A571520 COVER, TOW BAR/TOWING EYE — REPLACE — .2 .2 .2 — .2 .2 .2

3 A571550 LENS/CAP ASM. REFLEX RH — REPLACE .5 .2 .2 .2 — — — —

ADD FOR: SEDAN — — — .3 — — — —

A571575 LENS/CA P ASM. REFLEX LH — REPLACE .5 .2 .2 .2 — — — —

ADD FOR: SEDAN — — — .3 — — — —

4 A571600 APPLIQUE/INSERT, REAR BUMPER — R&R/

REPLACE .5 .5 .5 — .5 — — —

— 1

REAR BUMPER BARS

REAR SUSPENSION & BUMPER BARS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

07-525 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

5 A567500 INSERT, BUMPER FASCIA ALUMINIUM RH —

REPLACE — .4 .4 — — — — —

A567600 INSERT, BUMPER FASCIA ALUMINIUM LH —

REPLACE — .4 .4 — — — — —

A567700 INSERT, TRAILER HITCH ALUMINIUM CENTRE —

REPLACE — .3 .3 — — — — —

A567800 INSERT, BUMPER FASCIA ALUMINIUM REPLACE

ALL —.5 .5—————

6 A567900 INSERT, REAR BUMPER FASCIA CHROME LH OR

RH —REPLACE — — — — .5 .6 .6 —

ADD FOR REPLACING BOTH SIDES — — — — .1 .1 .1 —

LTG GI_08

08-700

08-175

08-999

08-155A

08-025

08-150

08-175

08-125

08-200

08-025

08-075

DIAGNOSTIC

TROUBLE CODES

A/C

08-200

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

HEATING & AIR CONDITIONING

08-025 VACUUM HOSES - HEATER CONTROL

D907000 TANK/RESERVOIR ASM. VACUUM — REPLACE — .2 .2 .2 — .2 .2 .2

1 D907100 HOSE, VACUUM ANY ONE — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

2 D907150 VALVE, VACUUM CONTROL — REPLACE — .2 .2 .2 — .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

HEATING & AIR CONDITIONING

08-075 HEATER HOSES

D111150 PIPE, HEATER INLET OUTLET — REPLACE (HFV6

ONLY) 1.0 1.0 — — 1.0 1.0 — —

D111300 HOSE, BY PASS — REPLACE — .3 .3 .3 — .3 .3 .3

1 D111400 HOSE, (HEATER VALVE TO ENGINE) INLET —

REPLACE — .3 .3 .3 — .3 .3 .3

2 D111500 HOSE, (ENGINE TO HEATER VALVE) OUTLET —

REPLACE — .3 .3 .3 — .3 .3 .3

3 D111100 HOSE, VALVE TO HEATER CORE (UPPER) —

REPLACE — .3 .3 .3 — .3 .3 .3

D111110 HOSE ASM, HEATER — REPLACE (GEN III, GEN IV) .2 .3 .3 .3 .2 .3 .3 .3

4 D111200 HOSE, VALVE TO HEATER CORE (LOWER) —

REPLACE — .3 .3 .3 — .3 .3 .3

5 D111700 VALVE ASM. HEATER WATER — REPLACE — .3 .3 .3 — .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

HEATING & AIR CONDITIONING

08-125 HEATER PIPES - INLET & OUTLET

1 J601300 PIPE ASM. HEATER OUTLET — REPLACE — .5 .5 .5 — .5 .5 .5

2 J601350 PIPE ASM. HEATER INLET — REPLACE — .5 .5 .5 — .5 .5 .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

HEATING & AIR CONDITIONING

08-150 HEATER, BLOWER & A/C - EVAPORATOR

1 D318100 HEATER EVAPORATOR ASM. — REPLACE 5.1 4.2 4.2 4.2 5.1 4.2 4.2 4.2

2 D327100 MOTOR & FAN, BLOWER WITH A/C — REPLACE .4 .3 .3 .3 .4 .3 .3 .3

3 D021300 DUCT, BLOWER TRANSFER — REPLACE 5.2 .2 .2 .2 5.2 .2 .2 .2

4 D330200 EVAPORATOR COIL ASM, A/C — REPLACE 5.4 4.3 4.3 4.3 5.4 4.3 4.3 4.3

ADD FOR: DIAGNOSIS, USING LEAK TEST TOOL — .5 .5 .5 — .5 .5 .5

5 N408599 HARNESS, RESISTOR BLOWER & CONTROL —

REPAIR/REPLACE ————————

6 D330100 RESISTOR, A/C BLOWER MOTOR — REPLACE — .3 .3 .3 — .3 .3 .3

7 D318150 CASE, HEATER & A/C — REPLACE — — — — — — — —

8 D021420 ACTUATOR, DEMIST & FLOOR (VACUUM) —

REPLACE .7.6.6.6.7.6.6.6

9 D118000 HARNESS AS M. VACUUM HOSES — REPAIR/

REPLACE — ST ST ST — ST ST ST

10 D021320 ACTUATOR, VACUUM CENTRE VENT — REPLACE .7 .6 .6 .6 .7 .6 .6 .6

11 D337100 CORE ASM. HEATER WITH A/C — REPLACE 5.2 4.2 4.2 4.2 5.2 4.2 4.2 4.2

12 D323100 HOSE/GROMMET EVAPORATOR DRAIN —

REPLACE — .6 .6 .6 — .6 .6 .6

13 D332700 THERMOSTAT/SENSOR, EVAPORATOR —

REPLACE 5.2 4.3 4.3 4.3 5.2 4.3 4.3 4.3

14 D021120 ACTUATOR, RECIRCULATION (VACUUM) —

REPLACE .7.5.5.5.7.5.5.5

15 D021400 SOLENOID, VACUUM MASTER — REPLACE — .3 .3 .3 — .3 .3 .3

16 D021500 MOTOR/SERVO, AIR MIXTURE SINGLE/LH —

REPLACE — 4.2 4.2 4.2 — 4.2 4.2 4.2

17 D021600 SWITCH, VACUUM PLUNGER — REPLACE — .3 .3 .3 — .3 .3 .3

— 1

HEATER, BLOWER & A/C - EVAPORATOR

HEATING & AIR CONDITIONING

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

08-150 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

18 P101100 CONTROL CABLES, TEMP & DIRECTIONAL —

ADJUST — .2 .2 .2 — — — —

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

D112100 ROD/CABLE, TEMPERATURE CONTROL —

REPLACE — .5 .5 .5 — — — —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

HEATING & AIR CONDITIONING

08-155A HEATER & A/C - CONTROLS

N317700 SENSOR ASM, SUN — REPLACE .5 .4 .4 .4 .5 .4 .4 .4

1 D333100 MODULE ASM, A/C CLIMATE CONTROL —

REPLACE .4.4.4.4.4.4.4.4

D333100 CONTROL ASM, HEATER A/C — REPLACE — .4 .4 .4 — — — —

N221990 BULB, HEATER CONTROL — REPLACE ONE/ALL — — — .4 — .4 .4 .4

2 D333150 FASCIA, HEATER A/C CONTROL — REPLACE — — — .4 — — — —

3 D333250 KNOB, HEATER A/C CONTROL (ANY) — REPLACE — — — .2 — — — —

4 D333200 DECAL, HEATER A/C CONTROL — REPLACE — — — .4 — — — —

5 D110100 SWITCH, A/C CONTROL — REPLACE — — — .4 — — — —

6 D200100 SWITCH, REAR WINDOW DEMIST — REPLACE — — — .4 — — — —

7 D333300 CIRCUIT BOARD, HEATER A/C CONTROL —

REPLACE — .4 .4 .4 — — — —

8 D107100 GEAR SET, TEMPERATURE CONTROL —

REPLACE — — — .4 — — — —

9 D333400 SHAFT, MODE CONTROL — REPL ACE — — — .4 — — — —

10 D329100 SWITCH, FAN A/C BLOWER MOTOR SPEED —

REPLACE — — — .4 — — — —

11 D200500 SWITCH, VACUUM A/C — REPLACE — — — .4 — — — —

12 D333500 SWITCH, VACUUM PLUNGER — REPLACE — — — .4 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

HEATING & AIR CONDITIONING

08-175 DUCTS, VENTS - HEATER & A/C

1 D013600 DUCT ASM. AIR DISTRIBUTION TO RH FLOOR

OUTLET — REPLACE .2.3.3.3.2.3.3.3

2 D013300 DUCT ASM. AIR DISTRIBUTION TO RH VENT

INNER — REPLACE — 2.0 2.0 2.0 — 2.0 2.0 2.0

3 D013100 DUCT ASM. AIR DISTRIBUTION TO RH VENT

OUTER — REPLACE — 2.0 2.0 2.0 — 2.0 2.0 2.0

4 D352300 DUCT ASM. AIR DISTRIBUTION TO CONSOLE

DUCT — REPLACE — .6 .6 .6 — .6 .6 .6

5 D013500 DUCT ASM. REAR COMPARTMENT AIR —

REPLACE — .5 .5 .5 — .5 .5 .5

6 D013200 DUCT ASM. AIR DISTRIBUTION TO LH VENT —

REPLACE — 2.0 2.0 2.0 — 2.0 2.0 2.0

7 D358600 VENT/AIR BOX HOUSING, RH FRONT — REPLACE — .3 .3 .3 — .3 .3 .3

D358500 VENT/AIR BOX HOUSING, LH FRONT — REPLACE — .3 .3 .3 — .3 .3 .3

8 D358400 VENT/AIR BOX HOUSING, CONSOLE REAR —

REPLACE .3.3.3.3.3.3.3.3

9 D358300 HOUSING ASM. CENTRE AIR OUTLET — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

HEATING & AIR CONDITIONING

08-200 AIR CONDITIONING SYSTEM

D904100 A/C SYSTEM PURGE, LEAK TEST & CHARGE .5 .8 .8 .8 .5 .8 .8 .8

*** PRE—DELIVERY ONLY ***

N317600 SENSOR ASM, AMBIENT TEMP — REPLACE .3 .3 .3 .3 .3 .3 .3 .3

N317650 SENSOR ASM, INSIDE AIR TEMP — R&R/REPLACE .4 .3 .3 .5 .4 .3 .3 .5

D311100 BRACKET, ENGINE MOUNTING & COMPRESSOR

SUPPORT LH — REPLACE .8 .8 .8 .8 .8 .8 .8 .8

ADD FOR: GEN III, GEN IV .1 — — — .1 — — —

D332100 PROTECTOR/SWITCH, COMPRESSOR THER—

MAL — REPLACE .4.3.3.3.4.3.3.3

1 D301100 A/C COMPRESSOR & CLUTCH ASM. — REPLACE .7 1.1 1.3 1.3 .7 1.1 1.3 1.3

ADD FOR: GEN III, GEN IV .1 .5 .3 .3 .1 .5 .3 .3

D333700 VALVE, COMPRESSOR CONTROL — REPLACE .4 1.1 1.3 1.3 .4 1.1 1.3 1.3

ADD FOR: GEN III, GEN IV .1 .5 .3 .3 .1 .5 .3 .3

2 D301120 "O" RINGS, COMPRESSOR — REPLACE .6 1.0 1.0 1.0 .6 1.0 1.0 1.0

3 D316100 RECEIVER DEHYDRATOR AND/OR O RINGS —

REPLACE — 1.0 1.0 1.0 — 1.0 1.0 1.0

4 D314100 CONDENSER ASM, PIPE & BRACKET — REPLACE .9 1.3 1.3 1.3 .9 1.3 1.3 1.3

5 D307000 HOSE ASM. COMPRESSOR SUCTION & DIS—

CHARGE — REPLACE .6 1.0 1.0 1.0 .6 1.0 1.0 1.0

ADD FOR: GEN III, GEN IV .4 .2 .2 .2 .4 .2 .2 .2

ADD FOR: AWD (HFV6 ONLY) —.1——————

D307050 HOSE ASM. A/C EVAPORATOR FRONT —

REPLACE .7 — — — .7 — — —

D307060 PIPE ASM. LIQUID LINE — REPLACE 1.0 — — — 1.0 — — —

— 1

AIR CONDITIONING SYSTEM

HEATING & AIR CONDITIONING

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

08-200 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

6 D308200 "O" RING, CONDENSER — REPLACE — .9 .9 .9 — .9 .9 .9

D308210 "O" RING, CONDENSER (UPPER) — REPLACE .4 — — — .4 — — —

D308220 "O" RING, CONDENSER (LOWER) — REPLACE .6 — — — .6 — — —

7 D308100 TRANSDUCER/PRESSURE SENSOR — REPLACE .4 .2 .2 .2 .4 .2 .2 .2

ADD TO: REGAS SYSTEM — .3 .3 .3 — .3 .3 .3

8 D319000 VALVE, TX/EXPANSION AND OR O RINGS —

REPLACE .8 1.2 1.2 1.2 .8 1.2 1.2 1.2

9 D307100 TUBE ASM. RECEIVER DEHYDRATOR TO TX

VALVE — REPLACE — 1.1 1.1 1.1 — 1.1 1.1 1.1

ADD FOR: GEN III, GEN IV — .2 .2 .2 — .2 .2 .2

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

HEATING & AIR CONDITIONING

08-700 CABIN VENTILATION

1 D016000 VENT, CABIN VENTILATION, BOTH/ALL —

REPLACE .3.4.4.4.3.5.5.5

ADD FOR: SEDAN/COUPE — .1 .1 .1 — — — —

D016100 VENT, CABIN VENTILATION, RH/CENTRE —

REPLACE .3.4.4.4.3.5.5.5

ADD FOR: SEDAN/COUPE — .1 .1 .1 — — — —

D016200 VENT, CABIN VENTILATION, LH — REPLACE .3 .4 .4 .4 .3 .5 .5 .5

ADD FOR: SEDAN/COUPE — .1 .1 .1 — — — —

— 1

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

08- 999 —

DIAGNOSTIC TROUBLE CODES

A/C, ECC

D900002 A/C DIAGNOSTIC CODE 02 — — ——————

D900003 A/C DIAGNOSTIC CODE 03 — — ——————

D900004 A/C DIAGNOSTIC CODE 04 — — ——————

D900005 A/C DIAGNOSTIC CODE 05 — — ——————

D900011 A/C DIAGNOSTIC CODE 11 — — ——————

D900012 A/C DIAGNOSTIC CODE 12 — — ——————

D900013 A/C DIAGNOSTIC CODE 13 — ST ST ST — ST ST ST

D900014 A/C DIAGNOSTIC CODE 14 — ST ST ST — ST ST ST

D900015 A/C DIAGNOSTIC CODE 15 — ST ST ST — ST ST ST

D900016 A/C DIAGNOSTIC CODE 16 — ST ST ST — ST ST ST

D900017 A/C DIAGNOSTIC CODE 17 — ST ST ST — ST ST ST

D900018 A/C DIAGNOSTIC CODE 18 — ST ST ST — ST ST ST

D900019 A/C DIAGNOSTIC CODE 19 — ST ST ST — ST ST ST

D900021 A/C DIAGNOSTIC CODE 21 — — — ST — — — ST

D900022 A/C DIAGNOSTIC CODE 22 — — ——————

D900023 A/C DIAGNOSTIC CODE 23 — — ——————

D900024 A/C DIAGNOSTIC CODE 24 — — — ST — — — ST

D900031 A/C DIAGNOSTIC CODE 31 — — ——————

D900035 A/C DIAGNOSTIC CODE 35 — ST ST — — ST ST —

D900036 A/C DIAGNOSTIC CODE 36 — ST ST ST — ST ST ST

D900037 A/C DIAGNOSTIC CODE 37 — ST ST ST — ST ST ST

D900038 A/C DIAGNOSTIC CODE 38 — ST ST ST — ST ST ST

D900039 A/C DIAGNOSTIC CODE 39 — ST ST ST — ST ST ST

D900040 A/C DIAGNOSTIC CODE 40 — ST ST — — ST ST —

D900041 A/C DIAGNOSTIC CODE 41 — ST ST — — ST ST —

D900043 A/C DIAGNOSTIC CODE 43 — ST ST — — ST ST —

D900044 A/C DIAGNOSTIC CODE 44 — ST ST — — ST ST —

D900045 A/C DIAGNOSTIC CODE 45 — ST ST — — ST ST —

D900046 A/C DIAGNOSTIC CODE 46 — ST ST — — ST ST —

D900047 A/C DIAGNOSTIC CODE 47 — ST ST — — ST ST —

D900048 A/C DIAGNOSTIC CODE 48 — ST ST — — ST ST —

D900049 A/C DIAGNOSTIC CODE 49 — ST ST — — ST ST —

D900050 A/C DIAGNOSTIC CODE 50 — ST ST — — ST ST —

D900051 A/C DIAGNOSTIC CODE 51 — — ——————

D900052 A/C DIAGNOSTIC CODE 52 — — ——————

D900057 A/C DIAGNOSTIC CODE 57 — — ——————

D900140 A/C DIAGNOSTIC CODE U0140 0.3 — — — 0.3 — — —

D900155 A/C DIAGNOSTIC CODE U0155 0.3 — — — 0.3 — — —

D900158 A/C DIAGNOSTIC CODE B0158 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

A/C, ECC

DIAGNOSTIC TROUBLE CODES

08- 999 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

D900163 A/C DIAGNOSTIC CODE 163 — — ——————

D900164 A/C DIAGNOSTIC CODE 164 — — ——————

D900168 A/C DIAGNOSTIC CODE B0168 0.3 — — — 0.3 — — —

D900183 A/C DIAGNOSTIC CODE B0183 0.3 — — — 0.3 — — —

D900184 A/C DIAGNOSTIC CODE U0184 0.3 — — — 0.3 — — —

D900188 A/C DIAGNOSTIC CODE B0188 0.3 — — — 0.3 — — —

D900193 A/C DIAGNOSTIC CODE B0193 0.3 — — — 0.3 — — —

D900228 A/C DIAGNOSTIC CODE B0228 0.3 — — — 0.3 — — —

D900238 A/C DIAGNOSTIC CODE B0238 0.3 — — — 0.3 — — —

D900249 A/C DIAGNOSTIC CODE U0249 0.3 — — — 0.3 — — —

D900253 A/C DIAGNOSTIC CODE B0253 0.3 — — — 0.3 — — —

D900408 A/C DIAGNOSTIC CODE B0408 0.3 — — — 0.3 — — —

D900418 A/C DIAGNOSTIC CODE B0418 0.3 — — — 0.3 — — —

D900428 A/C DIAGNOSTIC CODE B0428 0.3 — — — 0.3 — — —

D901325 A/C DIAGNOSTIC CODE B1325 0.3 — — — 0.3 — — —

D903531 A/C DIAGNOSTIC CODE B3531 0.3 — — — 0.3 — — —

D903933 A/C DIAGNOSTIC CODE B3933 0.3 — — — 0.3 — — —

LTG GI_09

REFER

06-225 09-125

09-100

09-120

09-125

09-140

09-200

09-440

09-140

09-135

09-300

09-515

09-100

09-552

09-400

DIAGNOSTIC

TROUBLE CODES

INST/INFO DISPLAY

DIAGNOSTIC

TROUBLE CODES

ALARM/IMMOB

DIAGNOSTIC

TROUBLE CODES

RADIO

TELEMATICS

09-999 09-999A 09-999B 09-540

09-500

09-525

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-100 INSTRUMENT CLUSTER & FASCIA

N326500 MULTI FUNCTION/INFORMATION DISPLAY —

REPLACE .6 — — — — .4 .4 —

1 C462100 FASCIA, INSTRUMENT CLUSTER SURROUND —

R&R/REPLACE — .2 .2 .4 — .2 .2 .4

2 N312700 INSTRUMENT CLUSTER — REPROGRAM .2 .2 .2 .2 .2 .2 .2 .2

N312600 INSTRUMENT CLUSTER — REPLACE .3 .3 .3 .4 .3 .3 .3 .4

ADD TO: RE—PROGRAM — .1 .1 .1 — .1 .1 .1

N300600 LENS/MASK, INSTRUMENT CLUSTER — REPLACE — .3 .3 .4 — .3 .3 .4

N221970 BULB, INSTRUMENT CLUSTER — REPLACE ONE/

ALL — — — .4 — — — .4

ADD TO: RE—PROGRAM — — — .1 — — — .1

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-120 INSTRUMENTATION GAUGES &

SPEEDOMETER

N221970 BULB, INSTRUMENT CLUSTER — REPLACE ONE/

ALL — — — .4 — — — .4

ADD TO: RE—PROGRAM — — — .1 — — — .1

N308500 CLOCK (DIGITAL/ANALOGUE) — REPLACE — — — — — — — .4

1 N300600 LENS/MASK, INSTRUMENT CLUSTER — REPLACE — .3 .3 .4 — .3 .3 .4

2 N301500 GAUGE, FUEL INSTRUMENT — REPLACE — — — — — — — —

3 N310500 TACHOMETER — REPLACE — — — — — — — —

4 N300500 SPEEDOMETER ASM — R&R/REPLACE — — — — — — — —

5 N309500 PRINTED CIRCUIT BOARD, INSTRUMENT —

REPLACE ————————

6 N306500 GAUGE, TEMPERATURE (DASH UNIT) —

REPLACE ————————

7 N833000 MODULE, TRIP COMPUTER — REPLACE — — — — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-125 INSTRUMENT PAD & DEMIST GRILLE

N317700 RECEIVER, REMOTE KEY SIGNAL — REPLACE .5 .4 .4 .4 .5 .4 .4 .4

C457400 CUP HOLDER, CENTRE FASCIA (ONE/BOTH)—

REPLACE .2 .3 .3 — .2 .3 .3 —

C461810 PANEL ASM, INSTRUMENT PANEL CENTRE —

REPLACE .5 .4 .4 — — — — —

1 C461100 PAD ASM. INSTRUMENT PANEL — REPLACE 3.5 2.1 2.1 2.1 3.5 2.1 2.1 2.1

2 D907320 GRILLE ASM. DEMIST NOZZLE LH — REPLACE .3 .2 .2 .2 .3 .2 .2 .2

3 D907310 GRILLE ASM. DEMIST NOZZLE RH — REPLACE .3 .2 .2 .2 .3 .2 .2 .2

4 C461600 DOOR ASM, PASSENGER AIR BAG — REPLACE — 2.1 2.1 2.1 — 2.1 2.1 2.1

5 C461700 NAMEPLATE, INSTRUMENT PAD LH — REPLACE — .2 .2 .2 — .2 .2 .2

6 C461800 PANEL ASM, INSTRUMENT PANEL UPPER CEN—

TRE — REPLACE .5 .2 .2 — — — — —

ADD FOR: ACCESSORY GAUGES — .1 .1 — — — — —

7 N300100 GAUGE ASM, INCLINOMETER — REPLACE — .3 .3 — — — — —

N303500 GAUGE ASM, OIL PRESSURE — REPLACE — .3 .3 — — — — —

N307500 GAUGE ASM, VOLTMETER — REPLACE — .3 .3 — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-135 END COVERS, SIDE AIR VENTS -

INSTRUMENT PANEL

1 C461300 COVER INSTRUMENT PANEL END LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

2 C461400 EXTENSION, INSTRUMENT PANEL END —

REPLACE — — — .2 — — — .2

3 C461200 COVER INSTRUMENT PANEL END RH —

REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-140 GLOVE BOX & LOWER TRIM

1 C459700 CYLINDER ASM. GLOVE BOX — REPLACE — .2 .2 .2 — .2 .2 .2

2 C459100 GLOVE BOX ASM. INSTRUMENT PANEL —

REPLACE .2.2.2.2.2.2.2.2

3 C456800 TRIM ASM. INST PANEL LOWER LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

4 C464100 TRIM ASM. INST PANEL LOWER RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-200 COVER & LOWER TRIM - R/H

1 C456700 COVER ASM. INSTRUMENT LOWER RH —

REPLACE — .2 .2 .2 — .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-300 CENTRE FASCIA

C461120 FASCIA ASM. RADIO/HEATER CONTROL SUR—

ROUND — REPLACE .6 .3 .3 — .6 .3 .3 —

N311700 SOCKET, ACCESSORY POWER SUPPLY —

REPLACE. .5 .4 .4 .4 .5 .4 .4 .4

N311600 PLUNGER/KNOB, CIGAR LIGHTER — REPLACE — .2 .2 .2 — .2 .2 .2

N311650 CIGAR LIGHTER & WIRING ASM. (COMPLETE) —

REPLACE — .4 .4 .4 — .4 .4 .4

1 C461500 FASCIA ASM. LOWER INSTRUMENT PAD CEN—

TRE — REPLACE — — — .5 — — — .5

C461520 FASCIA ASM. LOWER INSTRUMENT PAD CEN—

TRE RH — REPLACE — .5 .5 — — .5 .5 —

C461540 FASCIA ASM. LOWER INSTRUMENT PAD CEN—

TRE LH — REPLACE — .5 .5 — — .5 .5 —

2 C457100 COMPARTMENT/ASHTRAY ASM. FRONT —

REPLACE .2.2.2.2.2.2.2.2

3 C474300 LINER ASM. — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-400 ANTENNA

R201000 AMPLIFIER & LEAD, DIVERSITY/SCREEN

ANTENNA — REPLACE — 1.4 1.4 1.4 — 1.4 1.4 1.4

1 R200100 ANTENNA & LEAD ASM. (MANUAL) — REPLACE 1.4 — — .4 1.4 — — —

R200300 ANTENNA & LEAD ASM. (ELECTRIC) — R&R/

REPLACE — .4 .4 .4 — .4 .4 .4

2 R200200 ANTENNA ROD (MAST) — REPLACE .2 .6 .6 .6 .2 .6 .6 .6

3 R200150 LEAD ASM. ANTENNA — REPLACE 1.2 1.1 1.1 1.1 1.2 1.1 1.1 1.1

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-440 RADIO/CD

1 R205500 RADIO CD PLAYER — REPLACE .8 .2 .2 .2 .8 .2 .2 .2

R205510 RADIO CD PLAYER — DUAL HANDLING .8 .2 .2 .2 .8 .2 .2 .2

*** PRIOR ZONE APPROVAL REQUIRED ***

*** FOR USE WITH EXCHANGE SYSTEM AND

R205500 ONLY ***

R205540 RADIO CD PLAYER — REPAIR (BY DEALER) — .3 .3 .3 — .3 .3 .3

*** INCLUDES R & R ***

R205520 RADIO CONTROLS, HORN BAR — R&R/REPLACE .5 .3 .3 .4 .5 .3 .3 .4

R205530 RADIO REMOTE CONTROL MODULE — REPLACE — — — .4 — .4 .4 .4

R205560 CONTROL ASM, RADIO & HEATER — REPLACE .2 — — — .4 — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-500 RADIO SPEAKERS

R205600 RADIO CONTROL ASM. REAR SEAT REMOTE —

R&R/REPLACE — — — — — .2 .2 .2

R211400 SPEAKER & GRILLE ASM. RH ROOF MOUNTED —

REPLACE — — — — — .2 .2 .2

R211500 SPEAKER & GRILLE ASM. LH ROOF MOUNTED —

REPLACE — — — — — .2 .2 .2

1 R211100 SPEAKER ASM. FRONT DASH/DOOR HANDLE

MOUNTED RH — REPLACE .3.3.3.3.3.3.3.3

R211150 SPEAKER ASM. FRONT DAS H/DOOR HANDLE

MOUNTED LH — REPLACE .3.3.3.3.3.3.3.3

R211160 SPEAKER ASM. FRONT DASH CENTRE

MOUNTED — REPLACE .2 — — — .2 — — —

2 R211600 SPEAKER ASM. RH FRONT DOOR MOUNTED —

REPLACE .3.4.4.4.3.4.4.4

R211700 SPEAKER ASM. LH FRONT DOOR MOUNTED —

REPLACE .3.4.4.4.3.4.4.4

3 R211750 SPEAKER ASM. REAR LH DOOR 1/4 PANEL

MOUNTED — REPLACE .3.4.4.4.3.4.4.4

ADD FOR: COUPE — .2 .2 .2 — — — —

R211650 SPEAKER ASM. REAR RH DOOR 1/4 PANEL

MOUNTED — REPLACE .3.4.4.4.3.4.4.4

ADD FOR: COUPE — .2 .2 .2 — — — —

4 R213300 SPEAKER & LEAD ASM. REAR RH — REPLACE .5 .6 .6 .6 .5 .6 .6 .6

R213350 SPEAKER & LEAD ASM. REAR LH — REPLACE .5 .6 .6 .6 .5 .6 .6 .6

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-515 AUDIO/DVD SYSTEM/BLUE TOOTH

N780050 SWITCH, BLUETOOTH — REPLACE — .3 .3 — — .3 .3 —

N780055 MODULE, BLUETOOTH — REPLACE — .3 .3 — — .3 .3 —

N780060 MICROPHONE, BLUETOOTH — REPLACE — .2 .2 — — .2 .2 —

N780110 LEAD CABLE, DVD PLAYER — R&R/REPLACE — .8 .8 — — .4 .4 —

N780120 MODULATOR, DVD FM — REPLACE — .4 .4 — — — — —

N780100 DVD PLAYER — R&R/REPLACE — .4 .4 — — .4 .4 —

N780150 DVD PLAYER — REPROGRAM — .3 .3 — — .3 .3 —

C500500 FASCIA, DVD PLAYER — REPLACE — — — — — .3 .3 —

N780200 SCREEN, DVD RH — REPLACE — — — — — .3 .3 —

N780300 SCREEN, DVD LH — REPLACE — — — — — .3 .3 —

N780250 PCB, DVD SCREEN RH — REPLACE — — — — — .3 .3 —

N780350 PCB, DVD SCREEN LH — REPLACE — — — — — .3 .3 —

C500700 FASCIA, DVD SCREEN RH — REPLACE — — — — — .2 .2 —

C500800 FASCIA, DVD SCREEN LH — REPLACE — — — — — .2 .2 —

N780400 MODULE, DVD INTERFACE — REPLACE — — — — — .4 .4 —

N780500 MODULE, DVD SPLITTER — REPLACE — — — — — .4 .4 —

N780600 REMOTE CONTROL, DVD PLAYER — REPLACE — — — — — .2 .2 —

N780650 BATTERY, DVD REMOTE CONTROL — REPLACE — — — — — .2 .2 —

1 R205650 COMPACT DISC PLAYER/CHANGER — REPLACE — — — .4 — — — .4

2 R205655 LEAD/CABLE, COMPACT DISC PLAYER/

CHANGER — REPLACE — — — 1.5 — — — 1.5

3 R205700 AMPLIFIER, AUDIO SYSTEM — R&R/REPLACE — .3 .3 .2 — .4 .4 .2

4 R213399 HEADPHONE ASM — REPLACE — .2 — — — .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-525 ANTENNA - MOBILE PHONE

R300400 HOLDER, MOBILE PHONE — REPLACE — .3 .3 .3 — .3 .3 .3

1 R300300 LEAD, MOBILE PHONE ANTENNA — REPLACE — — — — — ST ST ST

2 R300100 ANTENNA, MOBILE PHONE — REPLACE — — — — — .3 .3 .3

3 R300200 BASE, MOBILE PHONE ANTENNA (OUTER) —

REPLACE — — — — — .3 .3 .3

4 R300250 BASE, MOBILE PHONE ANTENNA (INNER) —

REPLACE — — — — — .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-540 TELEMATICS

C315500 MIRROR ASM. COMPLETE (INTERIOR REAR

VIEW) — REPLACE .2.2.2.2.2.2.2.2

N446200 SPEAKER, TELEMATICS — REPLACE — — — .6 — — — .6

N446300 ANTENNA, TELEMATICS — REPLACE — 2.1 2.1 .6 — 2.1 2.1 .6

N200600 HORN & BRACKET ASM. ANTI THEFT — REPLACE — .3 .3 .3 — .3 .3 .3

1 N446000 CONTROL UNIT, TELEMATICS — REPLACE — .5 .5 .5 — .5 .5 .5

N446100 BATTERY, TELEMATICS CONTROL UNIT —

REPLACE — .5 .5 .5 — .5 .5 .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INSTRUMENT, INFO DISPLAY, RADIO,

TELEMATICS, ALARM

09-552 IMMOBILISER, ALARM SYSTEM

1 N200600 HORN & BRACKET ASM. ANTI THEFT — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

2 N216550 SWITCH, ANTI THEFT HOOD ACTUATOR —

REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

09- 999 —

DIAGNOSTIC TROUBLE CODES

INSTRUMENTS, INFO DISPLAYS

N909000 INST/INFO DISPLAY DIAGNOSTIC CODE B1000 0.3 — — — 0.3 — — —

N909001 INST/INFO DISPLAY DIAGNOSTIC CODE 01, B1001 0.3 ST ST ST 0.3 ST ST ST

N909002 INST/INFO DISPLAY DIAGNOSTIC CODE 02 — ST ST ST — ST ST ST

N909003 INST/INFO DISPLAY DIAGNOSTIC CODE 03 — ST ST ST — ST ST ST

N909004 INST/INFO DISPLAY DIAGNOSTIC CODE 04 — ST ST ST — ST ST ST

N909005 INST/INFO DISPLAY DIAGNOSTIC CODE 05 — ST ST ST — ST ST ST

N909006 INST/INFO DISPLAY DIAGNOSTIC CODE 06 — ST ST ST — ST ST ST

N909007 INST/INFO DISPLAY DIAGNOSTIC CODE 07 — ST ST ST — ST ST ST

N909008 INST/INFO DISPLAY DIAGNOSTIC CODE 08 — ST ST ST — ST ST ST

N909009 INST/INFO DISPLAY DIAGNOSTIC CODE 09 — ST ST ST — ST ST ST

N909010 INST/INFO DISPLAY DIAGNOSTIC CODE 10 — ST ST ST — ST ST ST

N909011 INST/INFO DISPLAY DIAGNOSTIC CODE 11 — ST ST ST — ST ST ST

N909012 INST/INFO DISPLAY DIAGNOSTIC CODE 12 — ST ST ST — ST ST ST

N909013 INST/INFO DISPLAY DIAGNOSTIC CODE 13 — ST ST ST — ST ST ST

N909014 INST/INFO DISPLAY DIAGNOSTIC CODE 14 — ST ST ST — ST ST ST

N909015 INST/INFO DISPLAY DIAGNOSTIC CODE 15 — ST ST ST — ST ST ST

N909016 INST/INFO DISPLAY DIAGNOSTIC CODE 16, B1016 0.3 ST ST ST 0.3 ST ST ST

N909017 INST/INFO DISPLAY DIAGNOSTIC CODE 17 — ST ST ST — ST ST ST

N909018 INST/INFO DISPLAY DIAGNOSTIC CODE 18 — — — ST — — — ST

N909019 INST/INFO DISPLAY DIAGNOSTIC CODE 19 — ST ST ST — ST ST ST

N909020 INST/INFO DISPLAY DIAGNOSTIC CODE 20 — — — ST — — — ST

N909021 INST/INFO DISPLAY DIAGNOSTIC CODE 21 — ST ST ST — ST ST ST

N909022 INST/INFO DISPLAY DIAGNOSTIC CODE 22 — ST ST ST — ST ST ST

N909024 INST/INFO DISPLAY DIAGNOSTIC CODE 24, B1024 0.3 ST ST ST 0.3 ST ST ST

N909025 INST/INFO DISPLAY DIAGNOSTIC CODE 25 — — — ST — — — ST

N909026 INST/INFO DISPLAY DIAGNOSTIC CODE 26 — ST — ST — — — ST

N909029 INST/INFO DISPLAY DIAGNOSTIC CODE 29 — ST — — — ST — —

N909030 INST/INFO DISPLAY DIAGNOSTIC CODE 30 — ST — — — ST — —

N909031 INST/INFO DISPLAY DIAGNOSTIC CODE 31 — — ——————

N909039 INST/INFO DISPLAY DIAGNOSTIC CODE 39 — ST — — — ST — —

N909042 INST/INFO DISPLAY DIAGNOSTIC CODE 42 — ST — — — ST — —

N909045 INST/INFO DISPLAY DIAGNOSTIC CODE 45 — ST — — — ST — —

N909046 INST/INFO DISPLAY DIAGNOSTIC CODE 46 — ST — — — ST — —

N909047 INST/INFO DISPLAY DIAGNOSTIC CODE 47 — ST — — — ST — —

N909051 INST/INFO DISPLAY DIAGNOSTIC CODE 51 — — ——————

N909052 INST/INFO DISPLAY DIAGNOSTIC CODE 52 — — ——————

N909055 INST/INFO DISPLAY DIAGNOSTIC CODE 55 — — ——————

N909073 INST/INFO DISPLAY DIAGNOSTIC CODE U0073 0.3 — — — 0.3 — — —

N909100 INST/INFO DISPLAY DIAGNOSTIC CODE U0100 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

INSTRUMENTS, INFO DISPLAYS

DIAGNOSTIC TROUBLE CODES

09- 999 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

N909101 INST/INFO DISPLAY DIAGNOSTIC CODE B101D, B101E 0.3 — — — 0.3 — — —

N909126 INST/INFO DISPLAY DIAGNOSTIC CODE C0126 0.3 — — — 0.3 — — —

N909155 INST/INFO DISPLAY DIAGNOSTIC CODE U0155 0.3 — — — 0.3 — — —

N909184 INST/INFO DISPLAY DIAGNOSTIC CODE U0184 0.3 — — — 0.3 — — —

N909299 INST/INFO DISPLAY DIAGNOSTIC CODE U0299 0.3 — — — 0.3 — — —

N909806 INST/INFO DISPLAY DIAGNOSTIC CODE B2806 0.3 — — — 0.3 — — —

N909809 INST/INFO DISPLAY DIAGNOSTIC CODE B2809 0.3 — — — 0.3 — — —

N909996 INST/INFO DISPLAY DIAGNOSTIC CODE B0996 0.3 — — — 0.3 — — —

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

09- 999A —

DIAGNOSTIC TROUBLE CODES

ALARM, IMMOBILISER

N990001 ALARM/IMMOBILISER DIAGNOSTIC CODE 01 — ST ST ST — ST ST ST

N990002 ALARM/IMMOBILISER DIAGNOSTIC CODE 02 — ST ST ST — ST ST ST

N990003 ALARM/IMMOBILISER DIAGNOSTIC CODE 03 — ST ST ST — ST ST ST

N990004 ALARM/IMMOBILISER DIAGNOSTIC CODE 04 — ST ST ST — ST ST ST

N990005 ALARM/IMMOBILISER DIAGNOSTIC CODE 05 — ST ST ST — ST ST ST

N990011 ALARM/IMMOBILISER DIAGNOSTIC CODE 11 — — ——————

N990012 ALARM/IMMOBILISER DIAGNOSTIC CODE 12 — — ——————

N990013 ALARM/IMMOBILISER DIAGNOSTIC CODE 13 — — ——————

N990014 ALARM/IMMOBILISER DIAGNOSTIC CODE 14 — — ——————

N990015 ALARM/IMMOBILISER DIAGNOSTIC CODE 15 — — ——————

N990016 ALARM/IMMOBILISER DIAGNOSTIC CODE 16 — — ——————

N990017 ALARM/IMMOBILISER DIAGNOSTIC CODE 17 — — ——————

N990018 ALARM/IMMOBILISER DIAGNOSTIC CODE 18 — — ——————

N990019 ALARM/IMMOBILISER DIAGNOSTIC CODE 19 — — ——————

N990020 ALARM/IMMOBILISER DIAGNOSTIC CODE 20, U0020 0.3 — — — 0.3 — — —

N990021 ALARM/IMMOBILISER DIAGNOSTIC CODE 21 — — ——————

N990022 ALARM/IMMOBILISER DIAGNOSTIC CODE 22 — — ——————

N990024 ALARM/IMMOBILISER DIAGNOSTIC CODE 24 — — ——————

N990073 ALARM/IMMOBILISER DIAGNOSTIC CODE U0073 0.3 — — — 0.3 — — —

N990140 ALARM/IMMOBILISER DIAGNOSTIC CODE U0140 0.3 — — — 0.3 — — —

N990155 ALARM/IMMOBILISER DIAGNOSTIC CODE U0155 0.3 — — — 0.3 — — —

N990302 ALARM/IMMOBILISER DIAGNOSTIC CODE B302A 0.3 — — — 0.3 — — —

N990996 ALARM/IMMOBILISER DIAGNOSTIC CODE B0996 0.3 — — — 0.3 — — —

N991000 ALARM/IMMOBILISER DIAGNOSTIC CODE B1000 0.3 — — — 0.3 — — —

N991015 ALARM/IMMOBILISER DIAGNOSTIC CODE B1015 0.3 — — — 0.3 — — —

N991016 ALARM/IMMOBILISER DIAGNOSTIC CODE B1016 0.3 — — — 0.3 — — —

N991424 ALARM/IMMOBILISER DIAGNOSTIC CODE B1424 0.3 — — — 0.3 — — —

N993031 ALARM/IMMOBILISER DIAGNOSTIC CODE B3031 0.3 — — — 0.3 — — —

N993055 ALARM/IMMOBILISER DIAGNOSTIC CODE B3055 0.3 — — — 0.3 — — —

N993060 ALARM/IMMOBILISER DIAGNOSTIC CODE B3060 0.3 — — — 0.3 — — —

N993935 ALARM/IMMOBILISER DIAGNOSTIC CODE B3935 0.3 — — — 0.3 — — —

N993976 ALARM/IMMOBILISER DIAGNOSTIC CODE B3976 0.3 — — — 0.3 — — —

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

DIAGNOSTIC TROUBLE CODES

VX/

U, 2

VY/

V2II WL WKVZVE WM

09- 999B —

DIAGNOSTIC TROUBLE CODES

RADIO, DVD, NAVIGATION

N999009 RADIO/DVD/NAV DIAGNOSTIC CODE B1009 0.3 — — — 0.3 — — —

N999010 RADIO/DVD/NAV DIAGNOSTIC CODE 10,B1010 0.3 ST ST — 0.3 ST ST —

N999011 RADIO/DVD/NAV DIAGNOSTIC CODE 11, B1011 0.3 ST ST — 0.3 ST ST —

N999016 RADIO/DVD/NAV DIAGNOSTIC CODE B1016 0.3 — — — 0.3 — — —

N999019 RADIO/DVD/NAV DIAGNOSTIC CODE B1019 0.3 — — — 0.3 — — —

N999020 RADIO/DVD/NAV DIAGNOSTIC CODE B1020 0.3 — — — 0.3 — — —

N999021 RADIO/DVD/NAV DIAGNOSTIC CODE 21 — ST ST — — ST ST —

N999022 RADIO/DVD/NAV DIAGNOSTIC CODE 22 — ST ST — — ST ST —

N999023 RADIO/DVD/NAV DIAGNOSTIC CODE B1023 0.3 — — — 0.3 — — —

N999024 RADIO/DVD/NAV DIAGNOSTIC CODE 24 — ST ST — — ST ST —

N999025 RADIO/DVD/NAV DIAGNOSTIC CODE 25, B1025 0.3 ST ST — 0.3 ST ST —

N999026 RADIO/DVD/NAV DIAGNOSTIC CODE 26 — ST ST — — ST ST —

N999027 RADIO/DVD/NAV DIAGNOSTIC CODE B1027 0.3 — — — 0.3 — — —

N999028 RADIO/DVD/NAV DIAGNOSTIC CODE B1028 0.3 — — — 0.3 — — —

N999029 RADIO/DVD/NAV DIAGNOSTIC CODE B1029 0.3 — — — 0.3 — — —

N999030 RADIO/DVD/NAV DIAGNOSTIC CODE 30 — ST ST — — ST ST —

N999031 RADIO/DVD/NAV DIAGNOSTIC CODE 31 — — ——————

N999032 RADIO/DVD/NAV DIAGNOSTIC CODE 32 — — ——————

N999033 RADIO/DVD/NAV DIAGNOSTIC CODE 33 — ST ST — — ST ST —

N999034 RADIO/DVD/NAV DIAGNOSTIC CODE 34 — ST ST — — ST ST —

N999035 RADIO/DVD/NAV DIAGNOSTIC CODE 35, B1035 0.3 ST ST — 0.3 ST ST —

N999037 RADIO/DVD/NAV DIAGNOSTIC CODE B1037 0.3 — — — 0.3 — — —

N999038 RADIO/DVD/NAV DIAGNOSTIC CODE B1038 0.3 — — — 0.3 — — —

N999039 RADIO/DVD/NAV DIAGNOSTIC CODE B1039 0.3 — — — 0.3 — — —

N999040 RADIO/DVD/NAV DIAGNOSTIC CODE 40 — ST ST — — ST ST —

N999041 RADIO/DVD/NAV DIAGNOSTIC CODE 41 — — ——————

N999045 RADIO/DVD/NAV DIAGNOSTIC CODE B1045 0.3 — — — 0.3 — — —

N999047 RADIO/DVD/NAV DIAGNOSTIC CODE B1047 0.3 — — — 0.3 — — —

N999048 RADIO/DVD/NAV DIAGNOSTIC CODE B1048 0.3 — — — 0.3 — — —

N999049 RADIO/DVD/NAV DIAGNOSTIC CODE B1049 0.3 — — — 0.3 — — —

N999051 RADIO/DVD/NAV DIAGNOSTIC CODE 51 — — ——————

N999052 RADIO/DVD/NAV DIAGNOSTIC CODE 52 — — ——————

N999054 RADIO/DVD/NAV DIAGNOSTIC CODE 54 — — ——————

N999055 RADIO/DVD/NAV DIAGNOSTIC CODE 55, B1055 0.3 — — — 0.3 — — —

N999057 RADIO/DVD/NAV DIAGNOSTIC CODE B1057 0.3 — — — 0.3 — — —

N999058 RADIO/DVD/NAV DIAGNOSTIC CODE B1058 0.3 — — — 0.3 — — —

N999059 RADIO/DVD/NAV DIAGNOSTIC CODE B1059 0.3 — — — 0.3 — — —

N999061 RADIO/DVD/NAV DIAGNOSTIC CODE 61 — — ——————

N999062 RADIO/DVD/NAV DIAGNOSTIC CODE 62 — — ——————

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

RADIO, DVD, NAVIGATION

DIAGNOSTIC TROUBLE CODES

09- 999B — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

N999063 RADIO/DVD/NAV DIAGNOSTIC CODE 63 — — ——————

N999073 RADIO/DVD/NAV DIAGNOSTIC CODE 73, U0073 0.3 — — — 0.3 — — —

N999081 RADIO/DVD/NAV DIAGNOSTIC CODE 81 — — ——————

N999082 RADIO/DVD/NAV DIAGNOSTIC CODE 82 — — ——————

N999083 RADIO/DVD/NAV DIAGNOSTIC CODE 83 — — ——————

N999084 RADIO/DVD/NAV DIAGNOSTIC CODE 84 — — ——————

N999085 RADIO/DVD/NAV DIAGNOSTIC CODE 85 — — ——————

N999086 RADIO/DVD/NAV DIAGNOSTIC CODE 86 — — ——————

N999087 RADIO/DVD/NAV DIAGNOSTIC CODE 87 — — ——————

N999088 RADIO/DVD/NAV DIAGNOSTIC CODE 88 — — ——————

N999089 RADIO/DVD/NAV DIAGNOSTIC CODE 89 — — ——————

N999095 RADIO/DVD/NAV DIAGNOSTIC CODE 95 — — ——————

N999097 RADIO/DVD/NAV DIAGNOSTIC CODE 97 — — ——————

N999098 RADIO/DVD/NAV DIAGNOSTIC CODE 98 — — ——————

N999099 RADIO/DVD/NAV DIAGNOSTIC CODE 99 — — ————ST—

N999101 RADIO/DVD/NAV DIAGNOSTIC CODE B101D, B101E 0.3 — — — 0.3 — — —

N999102 RADIO/DVD/NAV DIAGNOSTIC CODE 102 — — ——————

N999121 RADIO/DVD/NAV DIAGNOSTIC CODE 121, U2121 0.3 — — — 0.3 — — —

N999140 RADIO/DVD/NAV DIAGNOSTIC CODE U0140 0.3 — — — 0.3 — — —

N999147 RADIO/DVD/NAV DIAGNOSTIC CODE U0147 0.3 — — — 0.3 — — —

N999155 RADIO/DVD/NAV DIAGNOSTIC CODE U0155 0.3 — — — 0.3 — — —

N999164 RADIO/DVD/NAV DIAGNOSTIC CODE U0164 0.3 — — — 0.3 — — —

N999184 RADIO/DVD/NAV DIAGNOSTIC CODE U0184 0.3 — — — 0.3 — — —

N999190 RADIO/DVD/NAV DIAGNOSTIC CODE 190 — — ——————

N999191 RADIO/DVD/NAV DIAGNOSTIC CODE 191 — — ——————

N999192 RADIO/DVD/NAV DIAGNOSTIC CODE 192 — — ——————

N999193 RADIO/DVD/NAV DIAGNOSTIC CODE 193 — — ——————

N999194 RADIO/DVD/NAV DIAGNOSTIC CODE 194 — — ——————

N999198 RADIO/DVD/NAV DIAGNOSTIC CODE U0198 0.3 — — — 0.3 — — —

N999199 RADIO/DVD/NAV DIAGNOSTIC CODE 199 — — ——————

N999201 RADIO/DVD/NAV DIAGNOSTIC CODE 201, U2201 0.3 — — — 0.3 — — —

N999202 RADIO/DVD/NAV DIAGNOSTIC CODE 202, U2202 0.3 — — — 0.3 — — —

N999203 RADIO/DVD/NAV DIAGNOSTIC CODE U2203 0.3 — — — 0.3 — — —

N999204 RADIO/DVD/NAV DIAGNOSTIC CODE 204, U2204 0.3 — — — 0.3 — — —

N999205 RADIO/DVD/NAV DIAGNOSTIC CODE 205 — — ——————

N999206 RADIO/DVD/NAV DIAGNOSTIC CODE 206 — — ——————

N999207 RADIO/DVD/NAV DIAGNOSTIC CODE 207 — — ——————

N999240 RADIO/DVD/NAV DIAGNOSTIC CODE B1240 0.3 — — — 0.3 — — —

N999243 RADIO/DVD/NAV DIAGNOSTIC CODE B1243 0.3 — — — 0.3 — — —

N999244 RADIO/DVD/NAV DIAGNOSTIC CODE B1244 0.3 — — — 0.3 — — —

DIAGNOSTIC TROUBLE CODES

SECTION No.

WARRANTY

PROCESSING

DESCRIPTIONLABOP

RADIO, DVD, NAVIGATION

DIAGNOSTIC TROUBLE CODES

09- 999B — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

NOTE: DTC OPERATION NUMBERS SHOULD ONLY BE USED WHEN THE INVESTIGATIO N OF A DTC DOES NOT REVEAL ANY

FAULTS. (CLAIM THE ACTUAL TIME SPENT TO CARRY OUT THE DIAGNOSE, UP TO A MAXIMUM OF 0.7 (EXCLUDING VE/WM).

WHEN THE CAUSE OF A DTC IS IDENTIFIED, USE THE RELEVANT PART/REPAIR LABOUR OPERATION NUMBER AND

CLAIM THE TIME TAKEN TO DIAGNOSE THE FAULT AS OTHER LABOUR HOURS. (SEEK ZONE APPROVAL AS REQUIRED).

N999245 RADIO/DVD/NAV DIAGNOSTIC CODE B1245 0.3 — — — 0.3 — — —

N999248 RADIO/DVD/NAV DIAGNOSTIC CODE B1248 0.3 — — — 0.3 — — —

N999249 RADIO/DVD/NAV DIAGNOSTIC CODE B1249 0.3 — — — 0.3 — — —

N999271 RADIO/DVD/NAV DIAGNOSTIC CODE B1271 0.3 — — — 0.3 — — —

N999325 RADIO/DVD/NAV DIAGNOSTIC CODE B1325 0.3 — — — 0.3 — — —

N999330 RADIO/DVD/NAV DIAGNOSTIC CODE B1330 0.3 — — — 0.3 — — —

N999335 RADIO/DVD/NAV DIAGNOSTIC CODE B1335 0.3 — — — 0.3 — — —

N999340 RADIO/DVD/NAV DIAGNOSTIC CODE B1340 0.3 — — — 0.3 — — —

N999401 RADIO/DVD/NAV DIAGNOSTIC CODE B1401 0.3 — — — 0.3 — — —

N999423 RADIO/DVD/NAV DIAGNOSTIC CODE B1423 0.3 — — — 0.3 — — —

N999462 RADIO/DVD/NAV DIAGNOSTIC CODE B2462 0.3 — — — 0.3 — — —

N999464 RADIO/DVD/NAV DIAGNOSTIC CODE B1464 0.3 — — — 0.3 — — —

N999484 RADIO/DVD/NAV DIAGNOSTIC CODE B2484 0.3 — — — 0.3 — — —

N999924 RADIO/DVD/NAV DIAGNOSTIC CODE B3924 0.3 — — — 0.3 — — —

N999926 RADIO/DVD/NAV DIAGNOSTIC CODE B3926 0.3 — — — 0.3 — — —

N999927 RADIO/DVD/NAV DIAGNOSTIC CODE B3927 0.3 — — — 0.3 — — —

N999996 RADIO/DVD/NAV DIAGNOSTIC CODE B0996 0.3 — — — 0.3 — — —

N999997 RADIO/DVD/NAV DIAGNOSTIC CODE B0997 0.3 — — — 0.3 — — —

N999998 RADIO/DVD/NAV DIAGNOSTIC CODE B0998 0.3 — — — 0.3 — — —

LTG GI_10

10-510

10-150

10-505

10-250(SED & WAG)

10-265(UTE)

10-350

10-500

10-506

10-400

10-300

10-250

10-400

10-350

10-300

10-525

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-150 EMBLEMS & NAME PLATES

1 C881500 EMBLEM ASM. HOOD — REPLACE — — — .2 — .2 .2 .2

C896200 ORNAMENT ASM, HOOD — REPLACE — — — — — .2 .2 .2

2 C882100 PLATE, RH SIDE FRONT FENDER/DOOR NAME —

REPLACE .2.2.2.2.2.2.2.2

C882200 PLATE, LH SIDE FRONT FENDER/DOOR NAME —

REPLACE .2.2.2.2.2.2.2.2

C891500 EMBLEM ASM. GRILLE — REPLACE .2 .3 .3 .3 .2 — — —

3 C870900 EMBLEM/NAMEPLATE, REAR PANEL/BOOT LID/

TAIL GATE/HATCH — REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-250 BODY MOULDINGS, SEDAN/WAGON/

COUPE

B069099 STRIPES (PAINT) OR TRANSFER/DECALS —

REPAIR/REPLACE — ST ST ST — ST ST ST

C842100 MOULDING ASM. RH GLASS QUARTER WINDOW

— REPLACE — — — — — .2 .2 .2

C842200 MOULDING ASM. LH GLASS QUARTER WINDOW

— REPLACE — — — — — .2 .2 .2

C847000 MOULDING/FLARE ASM. WHEEL ARCH —

REPLACE ALL — 1.1 1.1 — — — — —

C847005 FLARE ASM. WHEEL ARCH — REPLACE ALL (AWD

MONARO ONLY) ——ST—————

C884100 MOULDING/FLARE ASM. RH FRONT WHEEL

ARCH — REPLACE — .4 .4 — — — — —

C884105 FLARE ASM. RH FRONT WHEEL ARCH —

REPLACE (AWD MONARO ONLY) — — ST — — — — —

C884200 MOULDING/FLARE ASM. LH FRONT WHEEL

ARCH — REPLACE — .4 .4 — — — — —

C884205 FLARE ASM. LH FRONT WHEEL ARCH —

REPLACE (AWD MONARO ONLY) — — ST — — — — —

C847100 MOULDING/FLARE ASM. RH REAR WHEEL ARCH

— REPLACE —.3 .3—————

C847105 FLARE ASM. RH REAR WHEEL ARCH — REPLACE

(AWD MONARO ONLY) — — ST — — — — —

C847200 MOULDING/FLARE ASM. LH REAR WHEEL ARCH

— REPLACE —.3 .3—————

C847205 FLARE ASM. LH REAR WHEEL ARCH — REPLACE

(AWD MONARO ONLY) — — ST — — — — —

— 1

BODY MOULDINGS, SEDAN/WAGON/

COUPE

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

10-250 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

C847300 APPLIQUE, QUARTER WINDOW REAR (R/H)

REPLACE — .3 .3 — — — — —

C847400 APPLIQUE, QUARTER WINDOW REAR (L/H)

REPLACE — .3 .3 — — — — —

1 C825100 MOULDING ASM. ROOF FINISHER RH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

C825200 MOULDING ASM. ROOF FINISHER LH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

C828500 MOULDING ASM. ROOF RACK RUNNER BOTH

(WAGON ONLY) — REPLACE — 1.9 1.9 1.9 — — — —

C828000 MOULDING ASM. ROOF RACK RUNNER RH

(WAGON ONLY) — REPLACE — 1.7 1.7 1.7 — — — —

C829000 MOULDING ASM. ROOF RACK RUNNER LH

(WAGON ONLY) — REPLACE — 1.7 1.7 1.7 — — — —

2 C826000 MOULDING, FRT/RR DOOR FRAME OPENING RH

— REPLACE .2.3.3.3.2.3.3.3

C827000 MOULDING, FRT/RR DOOR FRAME OPENING LH

— REPLACE .2.3.3.3.2.3.3.3

3 C896700 MOULDING, CENTRE PILLAR RH — REPLACE — .3 .3 .3 — .3 .3 .3

C896800 MOULDING, CENTRE PILLAR LH — REPLACE — .3 .3 .3 — .3 .3 .3

4 C883100 MOULDING ASM. RH FRONT FENDER SIDE —

REPLACE .2.3.3.3.2.3.3.3

ADD: TO REPLACE ANY ADDITIONAL MOULDING — .3 .3 .3 — .3 .3 .3

C883200 MOULDING ASM. LH FRONT FENDER SIDE —

REPLACE .2.3.3.3.2.3.3.3

ADD: TO REPLACE ANY ADDITIONAL MOULDING — .3 .3 .3 — .3 .3 .3

BODY MOULDINGS, SEDAN/WAGON/

COUPE

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

10-250 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

5 C830100 MOULDING ASM. RH FRONT DOOR SIDE —

REPLACE .4.5.5.5.4.5.5.5

ADD: TO REPLACE ANY ADDITIONAL MOULDING .3 .3 .3 .3 .3 .3 .3 .3

C830200 MOULDING ASM. LH FRONT DOOR SIDE —

REPLACE .4.5.5.5.4.5.5.5

ADD: TO REPLACE ANY ADDITIONAL MOULDING .3 .3 .3 .3 .3 .3 .3 .3

6 C838100 MOULDING ASM. RH REAR DOOR SIDE —

REPLACE .4.5.5.5.4.5.5.5

ADD: TO REPLACE ANY ADDITIONAL MOULDING .3 .3 .3 .3 .3 .3 .3 .3

C838200 MOULDING ASM. LH REAR DOOR SIDE —

REPLACE .4.5.5.5.4.5.5.5

ADD: TO REPLACE ANY ADDITIONAL MOULDING .3 .3 .3 .3 .3 .3 .3 .3

C838300 MOULDING. LH DOOR/QUARTER TO WHEEL

ARCH — REPLACE — .3 .3 .3 .6 .3 .3 .3

C838400 MOULDING. RH DOOR/QUARTER TO WHEEL

ARCH — REPLACE — .3 .3 .3 .6 .3 .3 .3

7 C896300 MOULDING. REAR PILLAR RH — REPLACE — 1.0 1.0 1.0 — 1.0 1.0 1.0

C896400 MOULDING. REAR PILLAR LH — REPLACE — 1.0 1.0 1.0 — 1.0 1.0 1.0

8 C847500 MOULDING. REAR COMPARTMENT LID COVER

LOWER — REPLACE .3 .3 .3 — .3 .3 .3 —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-265 BODY MOULDINGS, UTILITY/CREWMAN

C847000 MOULDING/FLARE ASM. WHEEL ARCH —

REPLACE ALL — 1.1 1.1 — — — — —

C884100 MOULDING/FLARE ASM. RH FRONT WHEEL

ARCH — REPLACE — .4 .4 — — — — —

C884200 MOULDING/FLARE ASM. LH FRONT WHEEL

ARCH — REPLACE — .4 .4 — — — — —

C847100 MOULDING/FLARE ASM. RH REAR WHEEL ARCH

— REPLACE —.3 .3—————

C847200 MOULDING/FLARE ASM. LH REAR WHEEL ARCH

— REPLACE —.3 .3—————

1 C897400 CAPPING, RH REAR ROOF — REPLACE — .3 .3 .3 — — — —

C897500 CAPPING, LH REAR ROOF — REPLACE — .3 .3 .3 — — — —

2 C897100 MOULDING, RH UPPER QUARTER PANEL —

REPLACE — 1.3 1.3 1.3 — — — —

C897200 MOULDING, LH UPPER QUARTER PANEL —

REPLACE — 1.3 1.3 1.3 — — — —

3 C896700 MOULDING, RH CENTRE PILLAR — REPLACE — .3 .3 .3 — — — —

C896800 MOULDING, LH CENTRE PILLAR — REPLACE — .3 .3 .3 — — — —

4 C896500 MOULDING, RH FRONT DOOR FRAME OPENING

— REPLACE — .3 .3 .3 — — — —

C896600 MOULDING, LH FRONT DOOR FRAME OPENING —

REPLACE — .3 .3 .3 — — — —

5 C825100 MOULDING ASM. RH ROOF FINISHER — REPLACE — .3 .3 .3 — — — —

C825200 MOULDING ASM. LH ROOF FINISHER — REPLACE — .3 .3 .3 — — — —

— 1

BODY MOULDINGS, UTILITY/CREWMAN

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

10-265 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

6 C897300 CAPPING/MOULDING, REAR ROOF CENTRE —

REPLACE — .3 .3 .3 — — — —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-300 ROCKER PANEL SKIRTS

1 C888000 SKIRT/PLATE, ROCKER/SILL PANEL RH (ONE

PIECE) — REPLACE .5 .3 .3 .3 .5 .3 .3 .3

C888600 SKIRT/PLATE, ROCKER/SILL PANEL LH (ONE

PIECE) — REPLACE .5 .3 .3 .3 .5 .3 .3 .3

A506100 SKIRT/SILL PLATE, FRONT BUMPER BAR —

REPLACE — .4 .4 .4 — .4 .4 .4

2 A506300 INSERT, ROCKER PANEL ALUMINIUM MOULD—

ING — REPLACE ONE — .4 .4 — — — — —

A506400 INSERT, ROCKER PANEL ALUMINIUM MOULD—

ING — REPLACE BOTH SIDES — .6 .6 — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-350 SPOILER, AIR DEFLECTOR

A506450 SPOILER ASM. (HSV UTE) — REPLACE — .6 .6 — — — — —

1 A506500 SPOILER ASM. DECK LID — REPLACE .4 .6 .6 .6 .4 .6 .6 .6

2 A506600 AIR DEFLECTOR, TAILGATE — REPLACE — .3 .3 .3 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-400 EXTERIOR REAR VISION MIRROR

R005510 LAMP/GLOBE ASM, PUDDLE — REPLACE R/H — — — — .2 — — —

R005610 LAMP/GLOBE ASM, PUDDLE — REPLACE L/H — — — — .2 — — —

1 R005500 MIRROR ASM. EXTERIOR REAR VISION RH —

REPLACE .3.4.4.4.3.4.4.4

R005600 MIRROR ASM. EXTERIOR REAR VISION LH —

REPLACE .3.4.4.4.3.4.4.4

2 R005300 COVER ASM. INNER WINDOW FRAME RH —

REPLACE .2.2.2.2.2.2.2.2

R005400 COVER ASM. INNER WINDOW FRAME LH —

REPLACE .2.2.2.2.2.2.2.2

3 R006120 MIRROR FACE, RH EXT REAR VISION — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

R006220 MIRROR FACE, LH EXT REAR VISION — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-500 WASHERS, WINDSHIELD & TAILGATE

GLASS

1 N358500 RESERVOIR ASM. WINDSHIELD/HEADLAMP

WASHER — REPLACE .8 .6 .6 .6 .8 .6 .6 .6

2 N354500 PUMP ASM. WINDSHIELD WASHER — REPLACE .8 .2 .2 .2 .8 .2 .2 .2

3 N357000 NOZZLE ASM. WINDSHIELD WASHER (1 OR 2) —

REPLACE — .2 .2 .2 — .2 .2 .2

4 N755000 NOZZLE, TAILGATE/HATCH WINDOW WIPER —

REPLACE — .2 .2 .2 — — — —

5 N358600 CAP, WINDSHIELD WASHER RESERVOIR —

REPLACE .2.2.2.2.2.2.2.2

6 N355500 VALVE ASM. NON RETURN WINDSHIELD

WASHER HOSE — REPLACE — .2 .2 .2 — .2 .2 .2

7 N357100 HOSE, WINDSHIELD WASHER ENGINE BAY

(ANY) — REPLACE .2.2.2.2.2.2.2.2

8 N357200 HOSE, RESERVOIR TO TAILGATE/HATCH —

REPLACE — 1.0 1.0 1.0 — — — —

9 N758500 HOSE, TAILGATE/HATCH WINDOW WASHER —

REPLACE — .3 .3 .3 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-505 WINDSHIELD WIPERS

N221925 SENSOR, RAIN — REPLACE .2 — — — .2 — — —

1 N356100 ARM ASM. WINDSHIELD WIPER (1 OR 2) —

REPLACE .2.2.2.2.2.2.2.2

2 N356000 BLADE ASM. WINDSHIELD WIPER (1 OR 2) —

REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-506 WINDSHIELD WIPER UNIT

1 N351000 LINKAGE ASM. WINDSHIELD WIPER BOTH SIDES

— REPLACE .4.6.6.6.4.6.6.6

N351100 LINKAGE ASM. WINDSHIELD WIPER RH —

REPLACE .4 — — — .4 — — —

N351200 LINKAGE ASM. WINDSHIELD WIPER LH —

REPLACE .4 — — — .4 — — —

2 N351500 MOTOR ASM. WINDSHIELD WIPER — REPLACE .5 .6 .6 .6 .5 .6 .6 .6

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-510 WATER DEFLECTOR & PLENUM COVERS

1 D907200 DEFLECTOR ASM. WATER — REPLACE — .4 .4 .4 — .4 .4 .4

2 D907400 COVER, PLENUM CHAMBER RH — REPLACE .3 .2 .2 .2 .3 .2 .2 .2

3 D907500 COVER, PLENUM CHAMBER LH — REPLACE .3 .2 .2 .2 .3 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

10-525 TAILGATE WIPER

N752050 MODULE, REAR WIPER MOTOR — REPLACE — .4 .4 — — — — —

1 N752000 MOTOR ASM. TAILGATE/HATCH WINDOW WIPER

— REPLACE — .5 .5 .5 — — — —

2 N752100 ARM ASM. TAILGATE/HATCH WIPER — REPLACE — .2 .2 .2 — — — —

3 N752200 BLADE ASM. TAILGATE/HATCH WIPER —

REPLACE — .2 .2 .2 — — — —

— 1

LTG GI_11

03/11/2005

11-370

11-730

11-625

11-675

REFER

14-220

14-270

11-810

11-650 11-775

11-725

11-750

11-020

11-025

11-030

11-360

11-600

11-360

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-020 GLASS - SEDAN/COUPE

C004100 GLASS ASM. SIDE PANEL (C PILLAR FIXED) RH —

REPLACE — 1.1 1.1 1.1 .7 1.1 1.1 1.1

C004110 GLASS ASM. SIDE PANEL (C PILLAR FIXED) RH —

RESEAL — 1.0 1.0 1.0 .7 1.0 1.0 1.0

C004200 GLASS ASM. SIDE PANEL (C PILLAR FIXED) LH —

REPLACE — 1.1 1.1 1.1 .7 1.1 1.1 1.1

C004210 GLASS ASM. SIDE PANEL (C PILLAR FIXED) LH —

RESEAL — 1.0 1.0 1.0 .7 1.0 1.0 1.0

C117100 WEATHERSTRIP ASM. GLASS SIDE PANEL (C

PILLAR) RH — REPLACE — — — — — .7 .7 .7

C117200 WEATHERSTRIP ASM. GLASS SIDE PANEL (C

PILLAR) LH — REPLACE — — — — — .7 .7 .7

D906199 GRID, REAR WINDOW DEMIST — REPAIR — ST ST ST — ST ST ST

1 C001000 GLASS ASM. WINDSHIELD REPLACE (LONG

METHOD) — 2.4 2.4 2.4 — 2.4 2.4 2.4

C001010 GLASS ASM. WINDSHIELD REPLACE (SHORT

METHOD) — 1.9 1.9 1.9 — 1.9 1.9 1.9

C001200 GLASS ASM. WINDSHIELD — RESEAL — .5 .5 .5 — .5 .5 .5

2 C820500 MOULDING, WINDSHIELD COMPLETE/UPPER —

REPLACE — .3 .3 .3 — .3 .3 .3

3 C005100 GLASS ASM. RH FRONT DOOR DROP WINDOW —

REPLACE .6 1.0 1.0 1.0 .6 1.0 1.0 1.0

P008100 GLAS S ASM. RH FRONT DOOR DROP WINDOW —

ADJUST .4 .4 .4 .4 .4 .4 .4 .4

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

— 1

GLASS - SEDAN/COUPE

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

11-020 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

C005200 GLASS ASM. LH FRONT DOOR DROP WINDOW —

REPLACE .6 1.0 1.0 1.0 .6 1.0 1.0 1.0

P008200 GLAS S ASM. LH FRONT DOOR DROP WINDOW —

ADJUST .4 .4 .4 .4 .4 .4 .4 .4

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

4 C013100 GLASS ASM. RH REAR DOOR DROP WINDOW —

REPLACE .5.5.5.5.5.5.5.5

P008500 GLAS S ASM. RH REAR DOOR DROP WINDOW —

ADJUST .4 .4 .4 .4 .4 .4 .4 .4

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

C013200 GLASS ASM. LH REAR DOOR DROP WINDOW —

REPLACE .5.5.5.5.5.5.5.5

P008600 GLAS S ASM. LH REAR DOOR DROP WINDOW —

ADJUST .4 .4 .4 .4 .4 .4 .4 .4

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

5 C017100 GLASS/WEATHERSTRIP ASM. DOOR FIXED WIN—

DOW RH — REPLACE — .7 .7 .7 — .7 .7 .7

C017200 GLASS/WEATHERSTRIP ASM. DOOR FIXED WIN—

DOW LH — REPLACE — .7 .7 .7 — .7 .7 .7

6 C002000 GLASS ASM. REAR WINDOW REPLACE (LONG

METHOD) — 2.4 2.4 2.4 — 2.4 2.4 2.4

C002100 GLASS ASM. REAR WINDOW REPLACE (SHORT

METHOD) — 1.9 1.9 1.9 — 1.9 1.9 1.9

GLASS - SEDAN/COUPE

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

11-020 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

C002500 GLASS ASM. REAR WINDOW — RESEAL — .5 .5 .5 — .5 .5 .5

7 C860300 MOULDING LOCATOR KIT, REAR WINDOW

REPLACE (LONG METHOD) — 2.4 2.4 2.4 — — — —

C860400 MOULDING LOCATOR KIT, REAR WINDOW

REPLACE (SHORT METHOD) — 1.9 1.9 1.9 — — — —

C868100 MOULDING ASM. REAR WINDOW COMPLETE —

REPLACE — — — — — .3 .3 .3

C860600 MOULDING ASM. REAR WINDOW UPPER —

REPLACE — 2.4 2.4 2.4 — 2.4 2.4 2.4

C860500 MOULDING ASM. REAR WINDOW LOWER —

REPLACE — 2.4 2.4 2.4 — 2.4 2.4 2.4

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-025 GLASS - UTE/HBD CANOPY

C021200 GLASS, CANOPY TAILGATE (HBD CANOPY

ONLY) — ADJUST/REPLACE — .3 .3 — — — — —

C021250 GLASS, CANOPY QUARTER RIGHT HAND (HBD

CANOPY ONLY) — ADJUST/REPLACE — .3 .3 — — — — —

C021300 GLASS, CANOPY QUARTER LEFT HAND (HBD

CANOPY ONLY) — ADJUST/REPLACE — .3 .3 — — — — —

1 C820500 MOULDING, WINDSHIELD COMPLETE/UPPER —

REPLACE — .3 .3 .3 — — — —

2 C001000 GLASS ASM. WINDSHIELD REPLACE (LONG

METHOD) — 2.4 2.4 2.4 — — — —

C001010 GLASS ASM. WINDSHIELD REPLACE (SHORT

METHOD) — 1.9 1.9 1.9 — — — —

C001200 GLASS ASM. WINDSHIELD — RESEAL — .5 .5 .5 — — — —

3 C860500 MOULDING ASM. REAR WINDOW LOWER —

REPLACE — .4 .4 .4 — — — —

4 C002000 GLASS ASM. REAR WINDOW REPLACE (LONG

METHOD) — 2.4 2.4 2.4 — — — —

C002100 GLASS ASM. REAR WINDOW REPLACE (SHORT

METHOD) — 1.9 1.9 1.9 — — — —

C002500 GLASS ASM. REAR WINDOW — RESEAL — .5 .5 .5 — — — —

5 C004100 GLASS ASM. SIDE PANEL RH — REPLACE — 1.1 1.1 1.1 — — — —

C004110 GLASS ASM. SIDE PANEL RH — RESEAL — 1.0 1.0 1.0 — — — —

C004200 GLASS ASM. SIDE PANEL LH — REPLACE — 1.1 1.1 1.1 — — — —

C004210 GLASS ASM. SIDE PANEL LH — RESEAL — 1.0 1.0 1.0 — — — —

— 1

GLASS - UTE/HBD CANOPY

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

11-025 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

6 C005100 GLASS ASM. RH FRONT DOOR DROP WINDOW —

REPLACE — 1.0 1.0 1.0 — — — —

P008100 GLAS S ASM. RH FRONT DOOR DROP WINDOW —

ADJUST — .4 .4 .4 — — — —

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

C005200 GLASS ASM. LH FRONT DOOR DROP WINDOW —

REPLACE — 1.0 1.0 1.0 — — — —

P008200 GLAS S ASM. LH FRONT DOOR DROP WINDOW —

ADJUST — .4 .4 .4 — — — —

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-030 GLASS - WAGON/HATCH

D906199 GRID, REAR WINDOW DEMIST — REPAIR — ST ST ST — — — —

C020100 CATCH, TAILGATE WINDOW (AWD) — REPLACE — .4 .4 — — — — —

C020200 SOLENOID, TAILGATE WINDOW RELEASE (AWD)

— REPLACE —.5 .5—————

1 C001000 GLASS ASM. WINDSHIELD REPLACE (LONG

METHOD) — 2.4 2.4 2.4 — — — —

C001010 GLASS ASM. WINDSHIELD REPLACE (SHORT

METHOD) — 1.9 1.9 1.9 — — — —

C001200 GLASS ASM. WINDSHIELD — RESEAL — .5 .5 .5 — — — —

2 C820500 MOULDING, WINDSHIELD, COMPLETE/UPPER —

REPLACE — .3 .3 .3 — — — —

3 C005100 GLASS ASM. RH FRONT DOOR DROP WINDOW —

REPLACE — 1.0 1.0 1.0 — — — —

P008100 GLAS S ASM. RH FRONT DOOR DROP WINDOW —

ADJUST — .4 .4 .4 — — — —

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

C005200 GLASS ASM. LH FRONT DOOR DROP WINDOW —

REPLACE — 1.0 1.0 1.0 — — — —

P008200 GLAS S ASM. LH FRONT DOOR DROP WINDOW —

ADJUST — .4 .4 .4 — — — —

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

4 C013100 GLASS ASM. RH REAR DOOR DROP WINDOW —

REPLACE — .5 .5 .5 — — — —

— 1

GLASS - WAGON/HATCH

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

11-030 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

P008500 GLAS S ASM. RH REAR DOOR DROP WINDOW —

ADJUST — .4 .4 .4 — — — —

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

C013200 GLASS ASM. LH REAR DOOR DROP WINDOW —

REPLACE — .5 .5 .5 — — — —

P008600 GLAS S ASM. LH REAR DOOR DROP WINDOW —

ADJUST — .4 .4 .4 — — — —

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

5 C017100 GLASS ASM. REAR DOOR FIXED WINDOW RH —

REPLACE — .7 .7 .7 — — — —

C017200 GLASS ASM. REAR DOOR FIXED WINDOW LH —

REPLACE — .7 .7 .7 — — — —

6 C004150 GLASS ASM. QUARTER WINDOW (C PILLAR) RH —

REPLACE — 1.1 1.1 1.1 — — — —

C004170 GLASS ASM. QUARTER WINDOW (C PILLAR) RH —

RESEAL — 1.0 1.0 1.0 — — — —

C004250 GLASS ASM. QUARTER WINDOW (C PILLAR) LH —

REPLACE — 1.1 1.1 1.1 — — — —

C004270 GLASS ASM. QUARTER WINDOW (C PILLAR) LH —

RESEAL — 1.0 1.0 1.0 — — — —

7 C020000 GLASS ASM. TAILGATE — REPLACE (AWD

WAGON) —.4 .4—————

7 C020000 GLASS ASM. TAILGATE/HATCH — REPLACE

(LONG METHOD) — 2.0 2.0 2.0 — — — —

GLASS - WAGON/HATCH

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

11-030 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

C020010 GLASS ASM. TAILGATE/HATCH — REPLACE

(SHORT METHOD) — 1.5 1.5 1.5 — — — —

C020500 GLASS ASM. TAILGATE/HATCH — RESEAL — .5 .5 .5 — — — —

8 C868000 MOULDING, TAILGATE/HATCH GLASS —

REPLACE — .3 .3 .3 — — — —

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-360 FRONT DOOR LOCK & CONTROL

C622100 CYLINDER ASM. DOOR LOCKING RH — REPLACE .5 .7 .7 .7 .5 .7 .7 .7

N240150 SWITCH, ELECTRIC FRONT DOOR LOCK RH —

REPLACE — .4 .4 .4 — .4 .4 .4

C624100 STRIKER PLATE ASM. RH FRONT DOOR —

REPLACE .2.2.2.2.2.2.2.2

C624200 STRIKER PLATE ASM. LH FRONT DOOR —

REPLACE .2.2.2.2.2.2.2.2

1 C621100 HANDLE ASM. DOOR OUTER RH FRONT —

REPLACE .5.7.7.7.5.7.7.7

C621200 HANDLE ASM. DOOR OUTER LH FRONT —

REPLACE .5.7.7.7.5.7.7.7

2 C621300 BRACKET, OUTER DOOR HANDLE RH FRONT —

REPLACE — .7 .7 .7 — .7 .7 .7

C621400 BRACKET, OUTER DOOR HANDLE LH FRONT —

REPLACE — .7 .7 .7 — .7 .7 .7

3 C622500 ROD, HANDLE OUTER DOOR LH FRONT —

REPLACE .4.5.5.5.4.5.5.5

C622600 ROD, HANDLE OUTER DOOR RH FRONT —

REPLACE .4.5.5.5.4.5.5.5

4 C622350 ROD, DOOR LOCK CYLINDER TO DOOR LOCK

RH FRONT — REPLACE .4.5.5.5.4.5.5.5

5 C622000 LOCK ASM. RH FRONT DOOR — REPLACE .5 .7 .7 .7 .5 .7 .7 .7

C623000 LOCK ASM. LH FRONT DOOR — REPLACE .5 .7 .7 .7 .5 .7 .7 .7

6 N242100 ACTUATOR ASM. DOOR CENTRAL LOCKING RH

FRONT — REPLACE — .7 .7 .7 — .7 .7 .7

— 1

FRONT DOOR LOCK & CONTROL

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

11-360 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

N242200 ACTUATOR ASM. DOOR CENTRAL LOCKING LH

FRONT — REPLACE — .7 .7 .7 — .7 .7 .7

7 C622800 ROD, REMOTE CONTROL RH FRONT — REPLACE .3 .5 .5 .5 .3 .5 .5 .5

C622700 ROD, REMOTE CONTROL LH FRONT — REPLACE .3 .5 .5 .5 .3 .5 .5 .5

8 C620700 REMOTE CONTROL ASM. FRONT DOOR —

REPLACE BOTH SIDES — .4 .4 .4 — .4 .4 .4

C620800 REMOTE CONTROL ASM. RH FRONT DOOR —

REPLACE .3.2.2.2.3.2.2.2

C620900 REMOTE CONTROL ASM. LH FRONT DOOR —

REPLACE .3.2.2.2.3.2.2.2

9 C622300 ROD, FRONT DOOR LOCKING (INSIDE) LH —

REPLACE — .5 .5 .5 — .5 .5 .5

C622330 ROD, FRONT DOOR LOCKING (INSIDE) RH —

REPLACE — .5 .5 .5 — .5 .5 .5

10 C622400 ESCUTCHEON, DOOR LOCKING BUTTON (1/ALL)

— REPLACE — .2 .2 .2 — .2 .2 .2

11 C622900 BUTTON ASM. LOCKING DOOR (1/ALL) —

REPLACE — .2 .2 .2 — .2 .2 .2

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-370 FRONT CHECK LINK & DOOR HINGE

1 C634100 CHECK ASM. RH FRONT DOOR — REPLACE .2 .6 .6 .6 .2 .6 .6 .6

C634200 CHECK ASM. LH FRONT DOOR — REPLACE .2 .6 .6 .6 .2 .6 .6 .6

2 C625150 HINGE, FRONT PILLAR (A) UPPER RH/LH —

REPLACE STSTSTSTSTSTSTST

C625250 HINGE, FRONT PILLAR (A) LOWER RH/LH —

REPLACE STSTSTSTSTSTSTST

3 C625100 HINGE, FRONT DOOR UPPER RH/LH — REPLACE ST ST ST ST ST ST ST ST

C625200 HINGE, FRONT DOOR LOWER RH/LH — REPLACE ST ST ST ST ST ST ST ST

4 C634000 BOLT/PIN CHECK ASM. ALL FOUR DOORS —

REPLACE .3.4.4.4.3.4.4.4

C634050 BOLT/PIN CHECK ASM. BOTH FRONT DOORS —

REPLACE .2.3.3.2.2.3.3.3

C634150 BOLT/PIN CHECK ASM. RH FRONT DOOR —

REPLACE .2.2.2.2.2.2.2.2

C634250 BOLT/PIN CHECK ASM. LH FRONT DOOR —

REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-600 WEATHERSTRIPS

C106700 WEATHERSTRIP ASM. ROCKER PANEL RH —

REPLACE .2.2.2.2.2.2.2.2

C106800 WEATHERSTRIP ASM. ROCKER PANEL LH —

REPLACE .2.2.2.2.2.2.2.2

1 C105100 WEATHERSTRIP ASM. RH FRONT DOOR —

REPLACE .2.5.5.5.2.5.5.5

C105200 WEATHERSTRIP ASM. LH FRONT DOOR —

REPLACE .2.5.5.5.2.5.5.5

2 C110100 WEATHERSTRIP ASM. RH REAR DOOR —

REPLACE .2.5.5.5.2.5.5.5

C110200 WEATHERSTRIP ASM. LH REAR DOOR —

REPLACE .2.5.5.5.2.5.5.5

3 C125500 WEATHERSTRIP, DECK LID — REPLACE .2 .4 .4 .4 .2 .4 .4 .4

C126000 WEATHERSTRIP, TAILGATE/HATCH — REPLACE — .4 .4 .4 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-625 GLASS CHANNEL & GUIDES - FRONT

DOOR

1 C008240 GUIDE RAIL, LH FRONT DROP WINDOW —

REPLACE .7.8.8.8.7.8.8.8

C008260 GUIDE RAIL, RH FRONT DROP WINDOW —

REPLACE .7.8.8.8.7.8.8.8

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-650 FRONT DOOR WEATHERSTRIP

1 C118300 WEATHERSTRIP ASM. RH FRT DOOR FRAME —

REPLACE .2.3.3.3.2.3.3.3

C118400 WEATHERSTRIP ASM. LH FRT DOOR FRAME —

REPLACE .2.3.3.3.2.3.3.3

2 C832100 MOULDING ASM. RH FRT DOOR BELT REVEAL

OUTER — REPLACE .2.3.3.3.2.3.3.3

C832200 MOULDING ASM. LH FRT DOOR BELT REVEAL

OUTER — REPLACE .2.3.3.3.2.3.3.3

3 C013110 WEATHERSTRIP ASM. DROP WINDOW LH

FRONT — REPLACE .5.6.6.6.5.6.6.6

C013210 WEATHERSTRIP ASM. DROP WINDOW RH

FRONT — REPLACE .5.6.6.6.5.6.6.6

4 C127100 MOULDING ASM. INNER CHANNEL RH —

REPLACE .3.4.4.4.3.4.4.4

C127200 MOULDING ASM. INNER CHANNEL LH —

REPLACE .3.4.4.4.3.4.4.4

5 C127300 MOULDING ASM. DOOR FRAME INNER RH —

REPLACE .2.3.3.3.2.3.3.3

C127400 MOULDING ASM. DOOR FRAME INNER LH —

REPLACE .2.3.3.3.2.3.3.3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-675 FRONT DOOR WINDOW REGULATO R

1 C006100 WINDOW REGULATOR, RH FRONT — REPLACE — .8 .8 .8 — — — —

C006200 WINDOW REGULATOR, LH FRONT — REPLACE — .8 .8 .8 — — — —

2 C332100 HANDLE. FRONT WINDOW REGULATOR (1 OR 2)

— REPLACE — .2 .2 .2 — — — —

3 N227100 WINDOW REGULATOR MOTOR/CABLE ASM. RH

FRONT — REPLACE .5.8.8.8.5.8.8.8

N227200 WINDOW REGULATOR MOTOR/CABLE ASM. LH

FRONT — REPLACE .5.8.8.8.5.8.8.8

N227150 MOTOR, WINDOW REGULATOR FRONT RH —

REPLACE .5 — — — .5 — — —

N227250 MOTOR, WINDOW REGULATOR FRONT LH —

REPLACE .5 — — — .5 — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-725 REAR DOOR LOCK & CONTROL

1 C640100 HANDLE ASM. DOOR OUTER RH REAR —

REPLACE .5.5.5.5.5.5.5.5

C640200 HANDLE ASM. DOOR OUTER LH REAR —

REPLACE .5.5.5.5.5.5.5.5

2 C641200 ROD, HANDLE OUTER LH REAR DOOR —

REPLACE .4.3.3.3.4.3.3.3

C641300 ROD, HANDLE OUTER RH REAR DOOR —

REPLACE .4.3.3.3.4.3.3.3

3 C641000 LOCK ASM. LH REAR DOOR — REPLACE .5 .7 .7 .7 .5 .7 .7 .7

C642000 LOCK ASM. RH REAR DOOR — REPLACE .5 .7 .7 .7 .5 .7 .7 .7

4 N243100 ACTUATOR ASM. DOOR CENTRAL LOCKING RH

REAR — REPLACE — .7 .7 .7 — .7 .7 .7

N243200 ACTUATOR ASM. DOOR CENTRAL LOCKING LH

REAR — REPLACE — .7 .7 .7 — .7 .7 .7

5 C334000 REMOTE CONTROL. BOTH REAR DOOR —

REPLACE — .3 .3 .3 — .3 .3 .3

C334100 REMOTE CONTROL. LH REAR DOOR — REPLACE .3 .2 .2 .2 .3 .2 .2 .2

C334200 REMOTE CONTROL. RH REAR DOOR — REPLACE .3 .2 .2 .2 .3 .2 .2 .2

6 C623200 ROD, DOOR LOCKING REAR LH — REPLACE — .3 .3 .3 — .3 .3 .3

C623300 ROD, DOOR LOCKING REAR RH — REPLACE — .3 .3 .3 — .3 .3 .3

7 C622400 ESCUTCHEON, DOOR LOCKING BUTTON (1 OR

ALL) — REPLACE — .2 .2 .2 — .2 .2 .2

8 C622900 BUTTON ASM. LOCKING DOOR (1 OR ALL) —

REPLACE — .2 .2 .2 — .2 .2 .2

— 1

REAR DOOR LOCK & CONTROL

ORNAMENTATION, WIPERS

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

11-725 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

9 C624500 ROD, REMOTE CONTROL ASM RH REAR DOOR —

REPLACE — .3 .3 .3 — .3 .3 .3

C624600 ROD, REMOTE CONTROL ASM LH REAR DOOR —

REPLACE — .3 .3 .3 — .3 .3 .3

10 C624700 ROD, DOOR LOCK CONNECTING RH REAR

DOOR — REPLACE .4.3.3.3.4.3.3.3

C624800 ROD, DOOR LOCK CONNECTING LH REAR

DOOR — REPLACE .4.3.3.3.4.3.3.3

11 C643100 STRIKER PLATE ASM. RH REAR DOOR —

REPLACE .2.2.2.2.2.2.2.2

C643200 STRIKER PLATE ASM. LH REAR DOOR —

REPLACE .2.2.2.2.2.2.2.2

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-730 REAR CHECK LINK & DOOR HINGE

1 C636100 CHECK LINK/SPRING, RH REAR DOOR —

REPLACE .2.4.4.4.2.4.4.4

C636200 CHECK LINK/SPRING, LH REAR DOOR —

REPLACE .2.4.4.4.2.4.4.4

2 C644150 HINGE, CENTRE PILLAR (B) UPPER RH/LH —

REPLACE STSTSTSTSTSTSTST

C644250 HINGE, CENTRE PILLAR (B) LOWER RH/LH —

REPLACE STSTSTSTSTSTSTST

3 C644100 HINGE, REAR DOOR UPPER RH/LH — REPLACE ST ST ST ST ST ST ST ST

C644200 HINGE, REAR DOOR LOWER RH/LH — REPLACE ST ST ST ST ST ST S T ST

4 C634000 BOLT/PIN CHECK ASM. ALL FOUR DOORS —

REPLACE .2.4.4.4.2.4.4.4

C636050 BOLT/PIN CHECK ASM. BOTH REAR DOORS —

REPLACE .2.3.3.3.2.3.3.3

C636150 BOLT/PIN CHECK ASM. RH REAR DOOR —

REPLACE .2.2.2.2.2.2.2.2

C636250 BOLT/PIN CHECK ASM. LH REAR DOOR —

REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-750 GLASS CHANNEL & GUIDES - REAR

DOOR

1 C013170 GUIDE RAIL ASM. REAR DROP WINDOW RH —

REPLACE .7.7.7.7.7.7.7.7

C013270 GUIDE RAIL ASM. REAR DROP WINDOW LH —

REPLACE .7.7.7.7.7.7.7.7

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-775 REAR DOOR WEATHERSTRIP

1 C836100 MOULDING ASM. LH REAR OUTER WINDOW

CHANNEL — REPLACE .2.2.2.2.2.2.2.2

C836200 MOULDING ASM. RH REAR OUTER WINDOW

CHANNEL — REPLACE .2.2.2.2.2.2.2.2

2 C118500 WEATHERSTRIP ASM. RH REAR DOOR FRAME —

REPLACE .2.4.4.4.2.4.4.4

C118600 WEATHERSTRIP ASM. LH REAR DOOR FRAME —

REPLACE .2.4.4.4.2.4.4.4

3 C127500 WEATHERSTRIP ASM. RH REAR DROP WINDOW

— REPLACE .6.6.6.6.6.6.6.6

C127600 WEATHERSTRIP ASM. LH REAR DROP WINDOW

— REPLACE .6.6.6.6.6.6.6.6

4 C118800 MOULDING ASM. RH WINDOW CHANNEL INNER —

REPLACE .3.3.3.3.3.3.3.3

C118700 MOULDING ASM. LH WINDOW CHANNEL INNER —

REPLACE .3.3.3.3.3.3.3.3

5 C118900 MOULDING ASM. WINDOW CHANNEL INNER RH

(SHORT) — REPLACE — .3 .3 .3 — .3 .3 .3

C119000 MOULDING ASM. WINDOW CHANNEL INNER LH

(SHORT) — REPLACE — .3 .3 .3 — .3 .3 .3

6 C127700 MOULDING ASM. REAR DOOR FRAME INNER RH

— REPLACE .2.3.3.3.2.3.3.3

C127800 MOULDING ASM. REAR DOOR FRAME INNER LH

— REPLACE .2.3.3.3.2.3.3.3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

ORNAMENTATION, WIPERS

11-810 REAR DOOR WINDOW REGULAT O R

N229100 MOTOR, WINDOW REGULATOR REAR RH —

REPLACE .5 — — — .5 — — —

N229200 MOTOR, WINDOW REGULATOR REAR LH —

REPLACE .5 — — — .5 — — —

1 N229150 WINDOW REGULATOR/MOTOR ASM. RH REAR

DOOR — REPLACE .5.7.7.7.5.7.7.7

N229250 WINDOW REGULATOR/MOTOR ASM. LH REAR

DOOR — REPLACE .5.7.7.7.5.7.7.7

2 C013130 WINDOW REGULATOR ASM. RH REAR DOOR/

QUARTER — REPLACE — .7 .7 .7 — — — —

C013230 WINDOW REGULATOR ASM. LH REAR DOOR/

QUARTER — REPLACE — .7 .7 .7 — — — —

3 C332200 HANDLE. REAR WINDOW REGULATOR (1 OR 2) —

REPLACE — .2 .2 .2 — — — —

— 1

LTG GI_12

03/11/2005

12-050

12-425 REFER

AA-005 12-660

12-660

12-425

12-500

12-680

12-000 12-480

12-685

12-460

12-425

12-100

FRT & RR

END GATE

HARDWARE

(UTILITY)

BODY

SEALING

OPERATION

SIDE RAILS

(UTILITY)

12-500

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-000 BODY SEALING

1 A201598 FLOOR ASM. FRONT — RESEAL ST ST S T ST ST ST ST ST

A203098 FLOOR ASM. REAR — RESEAL ST ST ST ST ST ST ST ST

A202000 CROSSMEMB ER ASM. REAR — RESEAL S T ST ST ST ST ST ST ST

A202100 PANEL ASM. SHROUD SIDE RH — RESEAL ST ST ST ST ST ST ST ST

A202200 PANEL ASM. SHROUD SIDE LH — RESEAL ST ST ST S T ST ST ST ST

A202400 PANEL ASM. BACK UPPER — RESEAL ST ST ST ST ST ST ST ST

A202500 PANEL, REAR QUARTER INNER LH — RESEAL ST ST ST ST ST ST ST ST

A202600 PANEL, REAR QUARTER INNER RH — RESEAL ST ST ST ST ST ST ST ST

A202700 PANEL, REAR WHEELHOUSE INNER LH —

RESEAL ST ST ST ST ST ST ST ST

A202800 PANEL, REAR WHEELHOUSE INNER RH —

RESEAL ST ST ST ST ST ST ST ST

A202900 PANEL ASM. SPARE WHEEL WELL — RESEAL ST ST ST ST ST ST ST ST

A205199 PAN, REAR COMPARTMENT FLOOR — RESEAL ST ST ST ST ST ST ST ST

A206098 PANEL ASM. COCKPIT/COWL — RESEAL ST ST ST ST ST ST ST ST

A202300 EXTENS ION ASM. FLOOR PANEL FRONT —

RESEAL ST ST ST ST ST ST ST ST

A210198 RAIL, ROOF SIDE. RH SIDE — RES EAL ST ST ST ST ST ST ST ST

A210298 RAIL, ROOF SIDE. LH SIDE — RESEAL ST ST ST ST ST ST ST ST

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-050 ENGINE HOOD HARDWARE

A015000 SCOOP ASM, HOOD AIR RH — REPLACE — .3 — — — — — —

A015100 SCOOP ASM, HOOD AIR LH — REPLACE — .3 — — — — — —

A015200 SCOOP ASM, HOOD AIR BOTH — REPLACE — .4 — — — — — —

A505500 INSULATOR, ENGINE HOOD — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

1 A517500 CABLE ASM. ENGINE HOOD — REPLACE .4 .6 .6 .6 .4 .6 .6 .6

2 A501100 HINGE ASM. ENGINE HOOD RH — REPLACE .5 .5 .5 .5 .5 .5 .5 .5

A501200 HINGE ASM. ENGINE HOOD LH — REPLACE .5 .5 .5 .5 .5 .5 .5 .5

3 A513500 PIN/SPRING, HOOD LOCK PILOT — REPLACE — .2 .2 .2 — .2 .2 .2

4 A519500 HOOD LOCK SECONDARY CATCH — REPLACE — .3 .3 .3 — .3 .3 .3

5 C107700 WEATHERSTRIP, HOOD — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

6 A502400 STRUT, ENGINE HOOD SUPPORT LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

A502500 STRUT, ENGINE HOOD SUPPORT RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

7 A517600 SPRING, HOOD LOCK RELEASE — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-100 FENDER & WHEELHOUSE LINERS

1A531100LINER, FRONT FENDER RH — REPLACE .2.2.2.2.2.2.2.2

ADD FOR : AWD WAGON — .2 .2 — — — — —

A531200 LINER, FRONT FENDER LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD FOR : AWD WAGON — .2 .2 — — — — —

2 A531300 LINER, REAR WHEELHOUSE, RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD FOR : CREWMAN/AWD WAGON — .1 .1 — — — — —

A531400 LINER, REAR WHEE LHOUSE, LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD FOR : CREWMAN/AWD WAGON — .1 .1 — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-425 FRONT END

A500300 COCKPIT MODULE PANEL — REPAIR/REPLACE — ST ST ST — ST ST ST

*** PRIOR ZONE APPROVAL REQUIRED ***

A500000 BRACE , FRONT LONGí BOTH — TIGHTEN/

REPLACE — .4 .4 .4 — .4 .4 .4

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

A500100 BRACE , FRONT LONGRH'— TIGHTEN/REPLACE — .3 .3 .3 — .3 .3 .3

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

A500200 BRACE , FRONT LONGLH'— TIGHTEN/REPLACE — .3 .3 .3 — .3 .3 .3

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

1 A500110 PANEL ASM. ENGINE HOOD — R & R .3 .4 .4 .4 .3 .4 .4 .4

P003100 ENGINE HOOD — ALIGN .2 .3 .3 .3 .2 .3 .3 .3

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

2 A530100 FENDER, PANEL RH — R & R 1.1 1.7 1.7 1.7 1.1 1.7 1.7 1.7

A530200 FE NDER, PANEL LH — R & R 1.1 1.7 1.7 1.7 1.1 1.7 1.7 1.7

3 A500600 STRUT TOWER, BOTH — REPAIR/REPLACE — ST ST ST — ST ST ST

*** PRIOR ZONE APPROVAL REQUIRED ***

A500400 STRUT TOWER, RH — REPAIR/REPLACE — ST ST ST — ST ST ST

*** PRIOR ZONE APPROVAL REQUIRED ***

A500500 STRUT TOWER, LH — REPAIR/REPLACE — S T ST ST — ST ST ST

*** PRIOR ZONE APPROVAL REQUIRED ***

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-460 DOOR ASSEMBLY, FRONT & REAR

1 A313500 DOOR ASM. RH FRONT — R & R .4 1.5 1.5 1.5 .4 1.5 1.5 1.5

P001120DOOR ASM. RH FRONT — ALIGN .2.3.3.3.2.3.3.3

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

A313600 DOOR ASM. LH FRONT — R & R .4 1.5 1.5 1.5 .4 1.5 1.5 1.5

P001220 DOOR ASM. LH FRONT — ALIGN .2 .3 .3 .3 .2 .3 .3 .3

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

2 A314500 DOOR ASM. REAR RH — R & R .4 1.5 1.5 1.5 .4 1.5 1.5 1.5

P001320 DOOR ASM. RE AR RH — ALIGN .2 .3 .3 .3 .2 .3 .3 .3

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

A314600 DOOR ASM. RE AR LH — R & R .4 1.5 1.5 1.5 .4 1.5 1.5 1.5

P001420 DOOR ASM. RE AR LH — ALIGN .2 .3 .3 .3 .2 .3 .3 .3

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-480 RAILS, REAR TONNEAU

1 C614000 RAIL ASM. RH BELT OUTER — REPLACE — .4 .4 .4 — — — —

C614100 RAIL ASM. LH BELT OUTER — REPLACE — .4 .4 .4 — — — —

C614200 RAIL ASM. ENDGATE UPPER — REPLACE — .4 .4 .4 — — — —

2 C614300 CAP, RH TAIL LAMP — REPLACE — .3 .3 .3 — — — —

C614400 CAP, LH TAIL LAMP — REPLACE — .3 .3 .3 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-500 TAILGATE, HINGES & STRUTS

1 P002100 TAILGATE OR HATCH ASM. — ALIGN — .3 .3 .3 — — — —

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

A321400 TAILGATE OR HATCH ASM. — R & R — .7 .7 .7 — — — —

2 C701100 HINGE, TAILGATE/HATCH RH — REPLACE — .5 .5 .5 — — — —

C701200 HINGE, TAILGATE/HATCH LH — REPLACE — .5 .5 .5 — — — —

3 C756000 STRUT ASM. TAILGATE/HATCH BOTH — REPLACE — .4 .4 .4 . — — —

C756100 STRUT ASM. TAILGATE/HATCH RH — REPLACE — .3 .3 .3 — — — —

C756200 STRUT ASM. TAILGATE/HATCH LH — REPLACE — .3 .3 .3 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-660 DECKLID, HINGES & STRUTS

1 A319900 DECK LID ASM. REAR COMPARTMENT — R & R .3 .3 .3 .3 .3 .3 .3 .3

A319910 DECK LID ASM. REAR COMPARTMENT —

REPLACE .5.6.6.6.5.6.6.6

P003900 DECK LID ASM. — ALIGN .2 .3 .3 .3 .2 .3 .3 .3

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

2 C701300 HINGE ASM. DECK LID RH — REPLACE .2 .5 .5 .5 .2 .5 .5 .5

C701400 HINGE ASM. DECK LID LH — REPLACE .2 .5 .5 .5 .2 .5 .5 .5

3 C756000 STRUT ASM. DECKLID BOTH — REPLACE .2 .4 .4 .4 .2 .4 .4 .4

C756100 STRUT ASM. DECKLID RH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

C756200 STRUT ASM. DECKLID LH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-680 DECK LID/TAILGATE LOCKING

N253300 SWITCH, REAR COMPARTMENT LOCK RELEASE

— REPLACE .2.2.2.2.2.2.2.2

C456000 CABLE, DECK LID RELEASE — REPLACE .3 .4 .4 .4 .3 .4 .4 .4

1 N253400 ACTUATOR ASM, DECK LID/TAILGATE/HATCH

RELEASE — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

ADD FOR : WAGON — .1 .1 .1 — — — —

2 C733500 CYLINDER ASM. DECK LID/TAILGATE/HATCH

LOCK — REPLACE — .3 .3 .3 — — — —

3 C752000 LATCH ASM. DECK LID/TAILGATE/HATCH —

REPLACE .2.2.2.2.2.2.2.2

4 C753100 SHACKLE ASM. DECK LID/TAILGATE/HATCH —

REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

SHEET METAL

12-685 ENDGATE HARDWARE & REAR TUB

P002100 TAILGATE OR HATCH ASM. — ALIGN — .3 .3 .3 — — — —

*** PRIOR ZONE APPROVAL REQUIRED AFTER

3000KM ***

A321400 TAILGATE OR HATCH ASM. — R & R — .4 .4 .4 — — — —

A590500 TUB, REAR LOAD AREA — R&R/REPLACE — .8 .8 — — — — —

C613700 HINGE ASM. ENDGATE RH — REPLACE — .5 .5 .5 — — — —

C613750 HINGE ASM. ENDGATE LH — REPLACE — .5 .5 .5 — — — —

1 C613000 PLATE ASM. ENDGATE LOCK BASE — REPLACE — .3 .3 .3 — — — —

2 C613100 HANDLE ASM. ENDGATE REMOTE CONTROL —

REPLACE — .3 .3 .3 — — — —

3 C613200 LATCH ASM. ENDGATE LOCK RH — REPLACE — .3 .3 .3 — — — —

C613250 LATCH ASM. ENDGATE LOCK LH — REPLACE — .3 .3 .3 — — — —

4 C613300 BRACKET & GUIDE ASM. ENDGATE LOCK

PLUNGER RH — REPLACE — .3 .3 .3 — — — —

C613350 BRACKET & GUIDE ASM. ENDGATE LOCK

PLUNGER LH — REPLACE — .3 .3 .3 — — — —

5 C613400 CABLE & LINK ASM. ENDGATE — REPLACE BOTH — .4 .4 .4 — — — —

C613425 CABLE & LINK ASM. ENDGATE RH — REPLACE — .3 .3 .3 — — — —

C613450 CABLE & LINK ASM. ENDGATE LH — REPLACE — .3 .3 .3 — — — —

6 C613500 STRIKER ASM. ENDGATE RH — REPLACE — .3 .3 .3 — — — —

C613550 STRIKER ASM. ENDGATE LH — REPLACE — .3 .3 .3 — — — —

7 C613600 PLATE ASM. ENDGATE RH — REPLACE — .3 .3 .3 — — — —

C613650 PLATE ASM. ENDGATE LH — REPLACE — .3 .3 .3 — — — —

— 1

LTG GI_14

14-100

14-150 14-460

14-480

14-120

14-050

14-100

REFER

AA-020

14-325

14-350

14-275

14-295

14-400

14-425

14-322

14-330

14-220

14-270

14-130 14-500

REFER

AA-000

14-900

14-480

14-490

14-475

14-025

14-490

14-500

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-025 INTERIOR MIRRORS

R005700 MIRROR, VANITY RH REAR — REPLACE — — — — — .2 .2 .2

R005800 MIRROR, VANITY LH REAR — REPLACE — — — — — .2 .2 .2

1 C315500 MIRROR ASM. COMPLETE (INTERIOR REAR

VIEW) — REPLACE .2.2.2.2.2.2.2.2

C315510 MIRROR RETAINING PLATE (INTERIOR REAR

VIEW) — REPLACE — .4 .4 .4 — .4 .4 .4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-050 SUNVISOR TRIM

1 C402100 SUNVISOR & PIVOT ASM. RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

C402200 SUNVISOR & PIVOT ASM. LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

C402300 HOLDER, GARAGE DOOR/SUNGLASS —

REPLACE .2.2.2.2.2.2.2—

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-100 INTERIOR TRIM (SIDE)

C317000 HANDLE, ASSIST GRIP (ANY ONE) — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

1 C621600 COVER, INNER ROCKER PANEL RH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

C621700 COVER, INNER ROCKER PANEL LH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

2 C621800 INSERT, INNER ROCKER PANEL RH FRONT —

REPLACE .2.2.2.2.2.2.2.2

C621900 INSERT, INNER ROCKER PANEL LH FRONT —

REPLACE .2.2.2.2.2.2.2.2

3 C621850 INSERT, INNER ROCKER PANEL RH REAR —

REPLACE .2.2.2.2.2.2.2.2

C621950 INSERT, INNER ROCKER PANEL LH REAR —

REPLACE .2.2.2.2.2.2.2.2

4 C622200 TRIM, "B" PILLAR UPPER RH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

ADD FOR: COUPE — .2 .2 .2 — — — —

C622250 TRIM, "B" PILLAR UPPER LH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

ADD FOR: COUPE — .2 .2 .2 — — — —

C411150 TRIM, "B" PILLAR CENTRE RH — REPLACE .2 — — — .2 — — —

C411250 TRIM, "B" PILLAR CENTRE LH — REPLACE .2 — — — .2 — — —

5 C623500 TRIM, "B" PILLAR LOWER RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

C623550 TRIM, "B" PILLAR LOWER LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

6 C456100 TRIM, COWL SIDE LOWER RH — R&R/REPLACE .2 .2 .2 .2 .2 .2 .2 .2

C456200 TRIM, COWL SIDE LOWER LH — R&R/REPLACE .2 .2 .2 .2 .2 .2 .2 .2

7 C623400 TRIM, "A" PILLAR ONE PIECE/UPPER RH —

REPLACE .2.2.2.2.2.2.2.2

— 1

INTERIOR TRIM (SIDE)

INTERIOR TRIM

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

14-100 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

C623450 TRIM, "A" PILLAR ONE PIECE/UPPER LH —

REPLACE .2.2.2.2.2.2.2.2

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-120 INTERIOR TRIM (REAR QUARTER &

BOOT)

C421100 TRIM, FRONT REAR QUARTER RH — REPLACE — .6 .6 .6 — — — —

C421200 TRIM, FRONT REAR QUARTER LH — REPLACE — .6 .6 .6 — — — —

C623800 FINISH STRIP, HEADLINING REAR — REPLACE — .2 .2 .2 — — — .2

1 C410310 TRIM, "C" PILLAR RH — REPLACE .3 .5 .5 .5 .3 .4 .4 .5

ADD FOR: COUPE — .2 .2 .2 — — — —

ADD FOR: CREWMAN — .1 .1 — — — — —

C410410 TRIM, "C" PILLAR LH — REPLACE .3 .5 .5 .5 .3 .4 .4 .5

ADD FOR: COUPE — .2 .2 .2 — — — —

ADD FOR: CREWMAN — .1 .1 — — — — —

2 C410350 ARMREST, "C" PILLAR LOWER RH — R&R/

REPLACE — — — — — .5 .5 .6

C410400 ARMREST, "C" PILLAR LOWER LH — R&R/

REPLACE — — — — — .5 .5 .6

3 C623600 COVER, REAR CROSSOVER — REPLACE — .2 .2 .2 — .2 .2 .2

4 C410320 TRIM, "C" PILLAR LOWER RH — REPLACE — — — — .2 .4 .4 .5

C410420 TRIM, "C" PILLAR LOWER LH — REPLACE — — — — .2 .4 .4 .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-130 INTERIOR TRIM (REAR QUARTER

WAGON/HATCH)

R609100 CARGO COVER (WAGON) — REPLACE — .2 .2 .2 — — — —

C421100 TRIM, FRONT REAR QUARTER RH — REPLACE — .6 .6 .6 — — — —

C421200 TRIM, FRONT REAR QUARTER LH — REPLACE — .6 .6 .6 — — — —

1 C623600 COVER, REAR CROSSOVER — REPLACE — .2 .2 .2 — — — —

2 C623800 FINISH STRIP, HEADLINING REAR — REPLACE — .2 .2 .2 — — — —

3 C624300 TRIM, "D" PILLAR RH — REPLACE — .3 .3 .3 — — — —

C624350 TRIM, "D" PILLAR LH — REPLACE — .3 .3 .3 — — — —

4 C410310 TRIM, "C" PILLAR UPPER RH — REPLACE — .2 .2 .2 — — — —

C410410 TRIM, "C" PILLAR UPPER LH — REPLACE — .2 .2 .2 — — — —

5 C410320 TRIM, "C" PILLAR LOWER RH — REPLACE — .2 .2 .2 — — — —

C410420 TRIM, "C" PILLAR LOWER LH — REPLACE — .2 .2 .2 — — — —

6 C624400 TRIM, REAR SIDE PANEL RH — REPLACE — .2 .2 .2 — — — —

C624450 TRIM, REAR SIDE PANEL LH — REPLACE — .2 .2 .2 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-150 HEADLINING TRIM

C440100 FINISH STRIP, HEADLINING FRONT — REPLACE — .3 .3 .3 — — — .3

1 C400100 HEADLINING, ROOF — REPLACE 1.3 1.0 1.0 1.0 1.3 1.0 1.0 1.0

ADD FOR: CAPRICE — — — — — .2 .2 .2

ADD FOR: STATION WAGON — .5 .5 .5 — — — —

2 C400200 INSULATION HEADLINING, ROOF — REPLACE — 1.0 1.0 1.0 — 1.0 1.0 1.0

ADD FOR: CAPRICE — — — — — .2 .2 .2

ADD FOR: STATION WAGON — .5 .5 .5 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-220 FRONT DOOR TRIM

C406700 DEFLECTOR, WATER RH FRONT DOOR —

REPLACE .3.3.3.3.3.3.3.3

C406800 DEFLECTOR, WATER LH FRONT DOOR —

REPLACE .3.3.3.3.3.3.3.3

1 C406100 TRIM ASM. RH FRONT DOOR — R&R/REPLACE .3 .3 .3 .3 .3 .3 .3 .3

ADD TO: REPLACE DOOR TRIM — .4 .4 .4 — .4 .4 .4

C406200 TRIM ASM. LH FRONT DOOR — R&R/REPLACE .3 .3 .3 .3 .3 .3 .3 .3

ADD TO: REPLACE DOOR TRIM — .4 .4 .4 — .4 .4 .4

2 C407100 INSERT, FRONT DOOR TRIM RH — REPLACE — .4 .4 .4 — .4 .4 .4

C407200 INSERT, FRONT DOOR TRIM LH — REPLACE — .4 .4 .4 — .4 .4 .4

3 C407300 POCKET, MAP FRONT DOOR TRIM RH —

REPLACE — .4 .4 .4 — .4 .4 .4

C407400 POCKET, MAP FRONT DOOR TRIM LH —

REPLACE — .4 .4 .4 — .4 .4 .4

4 R211200 COVER, SPEAKER FRONT DOOR TRIM RH —

REPLACE — .4 .4 .4 — .4 .4 .4

R211300 COVER, SPEAKER FRONT DOOR TRIM LH —

REPLACE — .4 .4 .4 — .4 .4 .4

5 C406150 HANDLE/ARMREST, RH FRONT DOOR (INTE—

RIOR) — REPLACE .3.4.4.4.3.4.4.4

C406250 HANDLE/ARMREST, LH FRONT DOOR (INTE—

RIOR) — REPLACE .3.4.4.4.3.4.4.4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-270 REAR DOOR TRIM

C417100 DEFLECTOR, WATER RH REAR DOOR —

REPLACE .3.3.3.3.3.3.3.3

C417200 DEFLECTOR, WATER LH REAR DOOR —

REPLACE .3.3.3.3.3.3.3.3

1 C414100 TRIM ASM. RH REAR DOOR — R&R/REPLACE .3 .3 .3 .3 .3 .3 .3 .3

ADD TO: REPLACE DOOR TRIM — .3 .3 .3 — .3 .3 .3

C414200 TRIM ASM. LH REAR DOOR — R&R/REPLACE .3 .3 .3 .3 .3 .3 .3 .3

ADD TO: REPLACE DOOR TRIM — .3 .3 .3 — .3 .3 .3

C421100 TRIM, FRONT REAR QUARTER RH — REPLACE .4 .6 .6 .6 — — — —

C421200 TRIM, FRONT REAR QUARTER LH — REPLACE .4 .6 .6 .6 — — — —

2 C407700 INSERT, REAR DOOR TRIM RH — REPLACE — .4 .4 .4 — .4 .4 .4

C407800 INSERT, REAR DOOR TRIM LH — REPLA CE — .4 .4 .4 — .4 .4 .4

3 R211800 COVER SPEAKER, RH REAR DOOR TRIM 1/4

PANEL RH — REPLACE — .4 .4 .4 — .4 .4 .4

ADD FOR: COUPE — .2 .2 .2 — — — —

R211900 COVER SPEAKER, LH REAR DOOR TRIM 1/4

PANEL RH — REPLACE — .4 .4 .4 — .4 .4 .4

ADD FOR: COUPE — .2 .2 .2 — — — —

4 C414150 HANDLE/ARMREST, RH REAR DOOR (INTERIOR)

— REPLACE .3.4.4.4.3.4.4.4

C414250 HANDLE/ARMREST, LH REAR DOOR (INTERIOR)

— REPLACE .3.4.4.4.3.4.4.4

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-275 FRONT SEAT HARDWARE

N264700 MODULE, RH FRONT SEAT/MIRROR POSITION

MEMORY — .5 .4 — — .5 .4 —

C502950 MOTOR, SEAT HEIGHT ADJUSTER RH —

REPLACE — .7 .7 .7 — .7 .7 .7

C502960 MOTOR, SEAT HEIGHT ADJUSTER LH —

REPLACE — .7 .7 .7 — .7 .7 .7

C502970 MOTOR, SEAT HEIGHT ADJUSTER CENTRE —

REPLACE — .7 .7 .7 — .7 .7 .7

C502850 MOTOR, SEAT BACK RH — REPLACE — .7 .7 .7 — .7 .7 .7

C502860 MOTOR, SEAT BACK LH — REPLACE — .7 .7 .7 — .7 .7 .7

1 C521220 TRACK/HEIGHT ADJUSTER ASM. RH FRT SEAT —

REPLACE .7 1.0 1.0 1.0 .7 1.0 1.0 1.0

C521210 TRACK/HEIGHT ADJUSTER ASM. LH FRT SEAT —

REPLACE .7 1.0 1.0 1.0 .7 1.0 1.0 1.0

2 C502100 ROD, ADJUSTER ASM RH SEAT — REPLACE — — — — — — — —

C502150 ROD, ADJUSTER ASM LH SEAT — REPLACE — — — — — — — —

3 C502600 FRAME ASM. FRONT SEAT CUSHION RH —

REPLACE .7 1.0 1.0 1.0 .7 1.0 1.0 1.0

C502700 FRAME ASM. FRONT SEAT CUSHION LH —

REPLACE .7 1.0 1.0 1.0 .7 1.0 1.0 1.0

4 N264100 SWITCH, ELECTRIC SEAT LH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

N264200 SWITCH, ELECTRIC SEAT RH — REPLACE .2 .3 .3 .3 .2 .3 .3 .3

N264000 SWITCH/MODULE ASM. ELECTRIC SEAT MEM—

ORY — REPLACE .2.3.3.3.2.3.3.3

N264800 MODULE, EZY ENTRY RH — REPLACE — .3 .3 .3 — — — —

— 1

FRONT SEAT HARDWARE

INTERIOR TRIM

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

14-275 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

N264900 MODULE, EZY ENTRY LH — REPLACE — .3 .3 .3 — — — —

5 N264300 KNOB, SEAT ADJUSTER SWITCH RH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N264400 KNOB, SEAT ADJUSTER SWITCH LH — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

N264500 KNOB, BACK REST ADJUSTER SWITCH RH —

REPLACE .2.2.2.2.2.2.2.2

N264600 KNOB, BACK REST ADJUSTER SWITCH LH —

REPLACE .2.2.2.2.2.2.2.2

6 C534500 ADJUSTER WHEEL, FRT SEAT RECLINER —

REPLACE .2.2.2.2.2———

7 C502920 WHEEL/LEVER, LUMBAR SUPPORT — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

8 C505210 CLIP/GUIDE SLEEVE, HEAD RESTRAINT FRT

SEAT — REPLACE .3.3.3.3.3.3.3.3

9 C502810 FRAME ASM. FRONT SEAT BACK LH ELEC —

REPLACE .8 1.0 1.0 1.0 .8 1.0 1.0 1.0

ADD FOR: COUPE — .1 .1 .1 — — — —

C502910 FRAME ASM. FRONT SEAT BACK RH ELEC —

REPLACE .8 1.0 1.0 1.0 .8 1.0 1.0 1.0

ADD FOR: COUPE — .1 .1 .1 — — — —

C502610 FRAME ASM. FRONT SEAT BACK LH — REPLACE .8 1.0 1.0 1.0 .8 — — —

ADD FOR: COUPE — .1 .1 .1 — — — —

ADD FOR: SIDE AIR BAGS — — — — — — — —

C502710 FRAME ASM. FRONT SEAT BACK RH — REPLACE .8 1.0 1.0 1.0 .8 — — —

ADD FOR: COUPE — .1 .1 .1 — — — —

10 C502750 LUMBAR SUPPORT RH — REPLACE — .6 .6 .6 — .6 .6 .6

FRONT SEAT HARDWARE

INTERIOR TRIM

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

14-275 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

C506800 LUMBAR SUPPORT LH — REPLACE — .6 .6 .6 — .6 .6 .6

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-295 FRONT SEAT TRIM & PADS

C550000 SEAT ASM. FRONT BUCKET PASSENGER — R&R/

REPLACE .2.4.4.4.2.4.4.4

C551000 SEAT ASM. FRONT BUCKET DRIVERíS — R&R/

REPLACE .2.4.4.4.2.4.4.4

C453400 DETECTION PAD, SEAT OCCUPANCY DRIVERS —

REPLACE — .9 .9 .9 — — — —

C453500 DETECTION PAD, SEAT OCCUPANCY PASSEN—

GER — REPLACE — .9 .9 .9 — — — —

1 C552000 PAD ASM. FRONT SEAT CUSHION DRIVERíS —

REPLACE .8.9.9.9.8.9.9.9

C553000 PAD ASM. FRONT SEAT CUSHION PASSENGE R —

REPLACE .8.9.9.9.8.9.9.9

C552100 TRIM, FRONT SEAT CUSHION DRIVERíS —

REPLACE .8.9.9.9.8.9.9.9

C553100 TRIM, FRONT SEAT CUSHION PASSENGER —

REPLACE .8.9.9.9.8.9.9.9

2 C552200 PAD ASM. FRONT SEAT BACK DRIVERíS —

REPLACE .8 1.0 1.0 1.0 .8 1.0 1.0 1.0

ADD FOR: COUPE — .1 .1 .1 — — — —

C553200 PAD ASM. FRONT SEAT BACK PASSENGER —

REPLACE .8 1.0 1.0 1.0 .8 1.0 1.0 1.0

ADD FOR: COUPE — .1 .1 .1 — — — —

C555100 TRIM ASM. SEAT BACK DRIVERS'— REPLACE .8 1.0 1.0 1.0 .8 1.0 1.0 1.0

ADD FOR: COUPE — .1 .1 .1 — — — —

— 1

FRONT SEAT TRIM & PADS

INTERIOR TRIM

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

14-295 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

C555200 TRIM ASM. SEAT BACK PASSENGER — REPLACE .8 1.0 1.0 1.0 .8 1.0 1.0 1.0

ADD FOR: COUPE — .1 .1 .1 — — — —

3 C505100 RESTRAINT ASM. RH FRT SEAT BACK HEAD —

REPLACE .2.2.2.2.2.2.2.2

ADD FOR: CAPRICE WITH DVD — — — — — .1 .1 —

C505200 RESTRAINT ASM. LH FRT SEAT BACK HEAD —

REPLACE .2.2.2.2.2.2.2.2

ADD FOR: CAPRICE WITH DVD — — — — — .1 .1 —

C505150 TRIM, FRONT SEAT HEAD RESTRAINT RH —

REPLACE .3.3.3.3.3.3.3.3

ADD FOR: CAPRICE WITH DVD — — — — — .1 .1 —

C505250 TRIM, FRONT SEAT HEAD RESTRAINT LH —

REPLACE .3.3.3.3.3.3.3.3

ADD FOR: CAPRICE WITH DVD — — — — — .1 .1 —

4 C502800 CUSHION, FRONT SEAT EXTENSION RH —

REPLACE ————————

C502900 CUSHION, FRONT SEAT EXTENSION LH —

REPLACE ————————

5 C559720 FRAME, FRONT SEAT EXTENSION RH —

REPLACE ————————

C559820 FRAME, FRONT SEAT EXTENSION LH — REPLACE — — — — — — — —

6 D130400 HEATING MAT, RH FRONT SEAT EXTENSION —

REPLACE ————————

D130410 HEATING MAT, LH FRONT SE AT EXTENSION —

REPLACE ————————

FRONT SEAT TRIM & PADS

INTERIOR TRIM

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

14-295 — 3

VX/

U, 2

VY/

V2II WL WKVZVE WM

7 D130600 HEATING MAT, RH FRONT SEAT CUSHION —

REPLACE ————————

D130610 HEATING MAT, LH FRONT SEAT CUSHION —

REPLACE ————————

8 D130700 HEATING MAT, RH FRONT SEAT BACK —

REPLACE ————————

D130710 HEATING MAT, LH FRONT SEAT BACK —

REPLACE ————————

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-322 FRONT SEAT RAIL COVERS

1 C504000 COVER, RH FRONT SEAT BACK — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

C504100 COVER, LH FRONT SEAT BACK — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

2 C520140 COVER, SEAT BELT TENSIONER RH — REPLACE — .2 .2 .2 — .2 .2 .2

C520240 COVER, SEAT BELT TENSIONER LH — REPLACE — .2 .2 .2 — .2 .2 .2

3 C503400 COVER, RH FRT SEAT INNER RAIL REAR —

REPLACE .2.2.2.2.2.2.2.2

C503500 COVER, LH FRT SEAT INNER RAIL REAR —

REPLACE .2.2.2.2.2.2.2.2

4 C503450 COVER, RH FRT SEAT INNER RA IL FRONT —

REPLACE .2.2.2.2.2.2.2.2

C503550 COVER, LH FRT SEAT INNER RAIL FRONT —

REPLACE .2.2.2.2.2.2.2.2

5 C503600 COVER, RH FRT SEAT OUTER RAIL REA R —

REPLACE .2.2.2.2.2.2.2.2

C503700 COVER, LH FRT SEAT OUTER RAIL REAR —

REPLACE .2.2.2.2.2.2.2.2

6 C503650 COVER, RH FRT SEAT OUTER RAIL FRONT —

REPLACE .2.2.2.2.2.2.2.2

C503750 COVER, LH FRT SEAT OUTER RAIL FRONT —

REPLACE .2.2.2.2.2.2.2.2

7 C503800 COVER, RH FRT SEAT SIDE OUTER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

C503900 COVER, LH FRT SEAT SIDE OUTE R — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

8 C504200 MAP POCKET, RH FRT SEAT BACK — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD: TO REPLACE OTHER SIDE .1 .1 .1 .1 .1 .1 .1 .1

— 1

FRONT SEAT RAIL COVERS

INTERIOR TRIM

SECTION No.

Labour Operation

Key

No. No. Description

WARRANTY

PROCESSING

Model

14-322 — 2

VX/

U, 2

VY/

V2II WL WKVZVE WM

C504300 MAP POCKET, LH FRT SEAT BACK — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

ADD: TO REPLACE OTHER SIDE .1 .1 .1 .1 .1 .1 .1 .1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-325 REAR SEAT BACK TRIM

1 C572210 TRIM ASM. REAR SEAT BACK (COMPLETE/BOTH

SIDES) — REPLACE .6 .5 .5 .5 .6 .5 .5 .5

2 C582100 TRIM ASM. REAR SEAT BACK RH — REPLACE .4 .6 .6 .6 .4 .6 .6 .6

C582200 TRIM ASM. REAR SEAT BACK LH — REPLACE .4 .6 .6 .6 .4 .6 .6 .6

3 C572500 TRIM, REAR SEAT BACK ARMREST — REPLACE .6 .6 .6 .6 .6 .6 .6 .6

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-330 COVER, PAD - REAR SEAT

1 C570100 TRIM ASM. REAR SEAT CUSHION — REPLACE .4 .6 .6 .6 .4 .6 .6 .6

2 C570300 PAD ASM. REAR SEAT CUSHION — REPLACE .4 .6 .6 .6 .4 .6 .6 .6

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-350 REAR SEAT BACK HARDWARE & TRIM

C576100 RESTRAINT ASM. REAR SEAT BACK HEAD RH —

REPLACE .2.2.2.2.2.2.2.2

C576200 RESTRAINT ASM. REAR SEAT BACK HEAD LH —

REPLACE .2.2.2.2.2.2.2.2

C576300 RESTRAINT ASM. REAR SEAT BACK HEAD CEN—

TRE — REPLACE .2.2.2.2.2.2.2.2

C505230 CLIP/GUIDE SLEEVE, HEAD RESTRAINT REAR

SEAT — REPLACE .4.4.4.4.4.4.4.4

1 C584100 KNOB, REAR SEAT BACK OR HATCH LOCK RH —

REPLACE — .8 .8 .8 — .8 .8 .8

C584200 KNOB, REAR SEAT BACK OR HATCH LOCK LH/

CENTRE — REPLACE — .8 .8 .8 — .8 .8 .8

2 C572900 PANEL, REAR SEAT BACK SUPPORT — REPLACE — .4 .4 .4 — .4 .4 .4

3 C572300 HINGE ASM. SEAT HATCH RH — REPLACE .5 .4 .4 .4 .5 .4 .4 .4

C572400 HINGE ASM. SEAT HATCH LH — REPLACE .5 .4 .4 .4 .5 .4 .4 .4

4 C572100 PAD ASM. REAR SEAT BACK (COMPLETE/BOTH

SIDES) — R&R/REPLACE .6 .7 .7 .7 .6 .7 .7 .7

C573020 FRAME ASM. REAR SEAT BACK (COMPLETE/

BOTH SIDES) — R&R/REPLACE .6.4.4.4.6.4.4.4

5 C572210 TRIM ASM. REAR SEAT BACK (COMPLETE/BOTH

SIDES) — REPLACE .6 .7 .7 .7 .6 .7 .7 .7

6 C572600 ARMREST/HATCH ASM. REAR SEAT CENTRE —

REPLACE .5.4.4.4.5.4.4.4

C572800 TRIM, ARMREST ASM. — REPLACE .5 .5 .5 .5 .5 .5 .5 .5

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-400 FRONT SEAT BELTS

1 C451100 BELT ASM. RETRACTOR RH FRONT SEAT —

REPLACE .5.5.5.5.5.5.5.5

ADD FOR: COUPE — .3 .3 .3 — — — —

C451200 BELT ASM. RETRACTOR LH FRONT SEAT —

REPLACE .5.5.5.5.5.5.5.5

ADD FOR: COUPE — .3 .3 .3 — — — —

2 C451140 SEAT BELT STALK & TENSIONER RH — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

C451240 SEAT BELT STALK & TENSIONER LH — REPLACE .4 .5 .5 .5 .4 .5 .5 .5

3 C455700 HEIGHT ADJUSTER, RH FRONT SEAT BELT —

REPLACE .4.5.5.5.4.5.5.5

C455750 HEIGHT ADJUSTER, LH FRONT SEAT BELT —

REPLACE .4.5.5.5.4.5.5.5

4 C455100 BOLT, SEAT BELT ANCHOR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-425 REAR SEAT BELTS

1 C452100 BELT ASM. RETRACTOR RH REAR SEAT —

REPLACE .6.4.4.4.6.4.4.4

ADD FOR: CREWMAN — .7 .7 — — — — —

ADD FOR: COUPE — .4 .4 .4 — — — —

C452200 BELT ASM. RETRACTOR LH REAR SEAT —

REPLACE .6.4.4.4.6.4.4.4

ADD FOR: CREWMAN — .7 .7 — — — — —

ADD FOR: COUPE — .4 .4 .4 — — — —

2 C452500 BELT ASM. CENTRE RETRACTOR/BUCKLE —

REPLACE .6.6.6.6.6.6.6.6

ADD FOR: CREWMAN — .5 .5 — — — — —

3 C452400 BUCKLE ASM. RH REAR SEAT BELT — REPLACE .2 .4 .4 .4 .2 .4 .4 .4

ADD FOR: CREWMAN — .2 .2 — — — — —

4 C452600 BUCKLE ASM. LH REAR SEAT BELT — REPLACE .2 .4 .4 .4 .2 — — —

ADD FOR: CREWMAN — .2 .2 — — — — —

5 C455100 BOLT, SEAT BELT ANCHOR — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

6 C452700 ESCUTCHEON, REAR SIDE SEAT BELT —

REPLACE (ONE/BOTH) .2 .2 .2 .2 .2 .2 .2 .2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-460 PARCEL SHELF

C427350 TRIM ASM. REAR HEADREST MOUNT — REPLACE

(CREWMAN) —.8.8—————

1 C427100 SHELF ASM. BACK PANEL UPPER — REPLACE .5 .4 .4 .4 .5 .4 .4 .4

2 C212000 GRILL, REAR SHELF SPEAKER RH — REPLACE .6 .4 .4 .4 .6 .4 .4 .4

C212100 GRILL, REAR SHELF SPEAKER LH — REPLACE .6 .4 .4 .4 .6 .4 .4 .4

3 C427300 TRIM ASM. SEAT BACK PANEL — REPLACE (UTE/

REGULAR CAB) — .4 .4 .4 — — — —

ADD FOR: REGULAR CAB — .1 .1 — — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-475 FRONT & REAR CARPETS

1 C449200 CARPET/INSULATOR ASM. FLOOR — REPLACE 1

PIECE (EXC. UTE) — 2.6 2.6 2.6 — 2.6 2.6 2.6

C449100 CARPET ASM. FRONT FLOOR — REPLACE

(UTE,REGULAR CAB) — 2.1 2.1 2.1 — — — —

2C001100PAD, FOOT REST — REPLACE .2.2.2.2.2.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-480 REAR COMPARTMENT TRIM (SEDAN)

N311800 SOCKET, ACCESSORY POWER SUPPLY —

REPLACE. .2 — — — .2 .2 .2 —

C432650 MAT ASM. REAR COMPARTMENT FLOOR —

REPLACE .2.2.2.2.2.2.2.2

C432700 CARPET, DECK LID LINER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

C431600 CARPET/TRIM ASM. REAR END PANEL —

REPLACE .2.2.2.2.2.2.2.2

C754400 NET, LUGGAGE RETENTION — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

C435300 DOOR, SIDE STOWAGE REAR COMPARTMENT

RH — REPLACE .2 — — — .2 .2 .2 —

1 C432600 CARPET/INSULATOR ASM. REAR COMPART—

MENT FLOOR — REPLACE .2.2.2.2.2.2.2.2

2 C431300 CARPET, REAR SEAT BACK — REPLACE — .2 .2 .2 — .2 .2 .2

3 C434100 TRIM/CARPET ASM. REAR COMPARTMENT

WHEELHOUSE RH — REPLACE .4.2.2.2.4.2.2.2

4 C434200 TRIM/CARPET ASM. REAR COMPARTMENT

WHEELHOUSE LH — REPLACE .4.2.2.2.4.2.2.2

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-490 REAR COMPARTMENT TRIM - WAGON

C432660 RAIL, CARGO LUGGAGE — REPLACE BOTH — .4 .4 — — — — —

C432670 RAIL, CARGO LUGGAGE RH — REPLACE — .3 .3 — — — — —

C432680 RAIL, CARGO LUGGAGE LH — REPLACE — .3 .3 — — — — —

C432650 MAT ASM. REAR COMPARTMENT FLOOR —

REPLACE — .2 .2 .2 — — — —

C432600 CARPET & INSULATOR ASM. REAR COMPART—

MENT FLOOR — REPLACE — .2 .2 .2 — — — —

1 C434100 TRIM/CARPET ASM. REAR COMPARTMENT

WHEELHOUSE RH — REPLACE — .3 .3 .3 — — — —

ADD FOR: AWD WAGON — .2 .2 — — — — —

C434200 TRIM/CARPET ASM. REAR COMPARTMENT

WHEELHOUSE LH — REPLACE — .3 .3 .3 — — — —

ADD FOR: AWD WAGON — .2 .2 — — — — —

2 C435300 DOOR, SIDE STOWAGE, REAR COMPARTMENT

RH — REPLACE — .2 .2 .2 — — — —

C435400 DOOR, SIDE STOWAGE, REAR COMPARTMENT

LH — REPLACE — .2 .2 .2 — — — —

3 C435500 VENT, REAR SIDE PANEL RH — REPLACE — .2 .2 .2 — — — —

C435600 VENT, REAR SIDE PANEL LH — REPLACE — .2 .2 .2 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-500 TAILGATE TRIM - WAGON

1 C436100 PANEL ASM. TAILGATE/HATCH — R&R/REPLACE — .2 .2 .2 — — — —

2 C436300 TRIM ASM. TAILGATE LOWER — R&R/REPLACE — .2 .2 .2 — — — —

3 C436150 TRIM ASM. UPPER TAILGATE (ONE PIECE/ALL) —

R&R/REPLACE — .3 .3 .3 — — — —

C436200 TRIM ASM. UPPER TAILGATE RH — R&R/

REPLACE — .2 .2 .2 — — — —

C436250 TRIM ASM. UPPER TAILGATE LH — R&R/REPLACE — .2 .2 .2 — — — —

4 C436350 TRIM ASM. STOP LAMP — REPLACE — .2 .2 .2 — — — —

— 1

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

INTERIOR TRIM

14-900 CONSOLE

N311700 SOCKET, ACCESSORY POWER SUPPLY —

REPLACE. .3 .3 .3 .3 .3 .3 .3 .3

N311600 PLUNGER & KNOB, CIGAR LIGHTER — REPL ACE — .2 .2 .2 — .2 .2 .2

N311650 CIGAR LIGHTER & WIRING ASM. (COMPLETE) —

REPLACE — .4 .4 .4 — .4 .4 .4

C457100 COMPARTMENT/ASHTRAY ASM. FRONT —

REPLACE .2.2.2.2.2.2.2.2

C474500 EXTENSION, CONSOLE SIDE (RH) — REPLACE .4 .2 .2 .2 .4 .2 .2 .2

C474600 EXTENSION, CONSOLE SIDE (LH) — REPLACE .4 .2 .2 .2 .4 .2 .2 .2

1 C474000 HOUSING, CONSOLE ASM — REPLACE 1.2 .4 .4 .4 1.2 .4 .4 .4

2 C474100 CAP, CONSOLE — REPLACE (M/T) .2 .3 .3 .3 — — — —

C474200 CAP, CONSOLE — REPLACE (AUTO) .2 .3 .3 .3 .2 .3 .3 .3

3 C474400 ARMREST ASM. TRANSMISSION CONSOLE —

REPLACE .4.2.2.2.4.2.2.2

4 D358400 VENT/AIR BOX HOUSING, CONSOLE REAR —

REPLACE .3.3.3.3.3.3.3.3

5 C457200 COMPARTMENT/ASHTRAY ASM. REAR —

REPLACE .2.2.2.2.2.2.2.2

6 C474300 LINER ASM. (ONE OR ALL) — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

7 C457300 CUP HOLDER — REPLACE .2 .2 .2 .2 .2 .2 .2 .2

8 C457500 COMPARTMENT ASSEMBLY FRONT FLOOR

CONSOLE — REPLACE .2.2.2.2.2.2.2.2

— 1

LTG GI_99

27 28

18 (RH)

19 (LH)

1(RH)

2 (LH)

3 (RH)

4 (LH)

7 (RH)

8 (LH)

5 (RH)

6 (LH)

25 (RH)

26 (LH)

20 (RH)

21 (LH)

22 (RH)

23 (LH)

13 (RH)

14 (LH)

9 (RH)

10 (LH)

33 (RH)

34 (LH)

22 (RH)

23 (LH)

20 (RH)

21 (LH)

1 (RH)

2 (LH)

5 (RH)

6 (LH)

25 (RH)

26 (LH)

18 (RH)

19 (LH) 3 (RH)

4 (LH)

7 (RH)

8 (LH)

9 (RH)

10 (LH)

39 (RH)

40 (LH) 37 (RH)

38 (LH)

35 (RH)

36 (LH)

33 (RH)

34 (LH)

51 (RH)

52 (LH) 57 (RH)

58 (LH) 54 (RH)

55 (LH) 56

9 (RH)

10 (LH)

SECTION No.

WARRANTY

PROCESSING SEALING, PAINT, DIAGNOSIS, SPECIAL

OPERATIONS, CAMPAIGNS

PAINT FINISH OPERATIONS

(THIS INFORMATION IS REPEATED FROM THE INTRODUCTION PAGES, FOR EASY REFERENCE).

PAINT REFINISH TIMES INCLUDED IN THIS MANUAL ARE FOR RECTIFICATION OF BLEMISHES

RESULTING EITHER FROM PAINT AND ASSOCIATED MATERIALS, OR THEIR PROCESSING OPERATION

NOT CONFORMING TO REGULAR HOLDEN’S STANDARDS.

THE TIMES ARE BASED ON THE OPERATION BEING CARRIED OUT DURING THE WARRANTY PERIOD OR

WITHIN A REASONABLE TIME FOLLOWING IT.

NOTE: TIMES DO NOT APPLY TO CRASH REPAIRS, THE REPAIRING OF AGED OR NEGLECTED VEHICLES.

LABOUR TIMES COVER THE COMPLETE AREA AND OPERATION AS DESIGNATED AND INCLUDE

PREPARATION, MASKING UP AND THE CLEANING OF EQUIPMENT. RECTIFICATION OF ONLY A SECTION

OF THE PART INVOLVED IS TO BE APPORTIONED ACCORDINGLY.

SPOT REPAIR: SPOT REPAIR APPLIES TO A REPAIR OR TOUCH-UP FOR THE CORRECTION

OF CHIPPING AT PANEL EDGES OR OTHER ISOLATED MINOR

IMPERFECTIONS, AND WHEN IT IS NOT POSSIBLE TO CORRECT THE MINOR

IMPERFECTIONS WITH A BRUSH TOUCH-UP.

TOP COAT REPAIR: APPLIES TO PAINT REPAIR OPERATIONS THAT DO NOT REQUIRE THE USE

OF PRIMER BUT MERELY INVOLVE REMOVING BY WIPING THE SURFACE

WITH A SOLVENT, SANDING THE ORIGINAL COLOUR COAT, MASKING THE

AREA AS NECESSARY, APPLYING COLOUR COAT AND BUFF POLISH WHEN

DRY. TOP COAT REPAIR SHOULD BE USED WHEN CORRECTING

CONDITIONS SUCH AS THIN PAINT, OFF COLOUR, RUB THROUGHS, OR

SURFACE SCRATCHES.

STRIP AND REPAINT: APPLIED TO PAINT REPAIR OF A PANEL WHEN COLOUR COATS AND

UNDERCOATS ARE AFFECTED. THE PAINT DAMAGE IS OF SUCH A NATURE

THAT UNDERCOAT MUST BE REMOVED DURING THE SANDING

OPERATION, RESULTING IN THE EXPOSURE OF BARE METAL FOR THE

ENTIRE PANEL. REPAIR OPERATIONS REQUIRE SANDING, CLEANING THE

AFFECTED AREA OF CONTAMINANTS (OIL, WAX, SILICONE, PAINT

STRIPPER, ETC.), MASKING THE AREA AS NECESSARY, PRIMING, FILLING

WHEN NECESSARY, SANDING PRIMER, SEALING, APPLYING COLOUR AND

BUFF POLISH WHEN DRY. THE REFINISH OPERATION ALSO INCLUDES

MATERIAL PREPARATION AS WELL AS CLEANING EQUIPMENT. A STRIP

AND REPAINT OPERATION WOULD BE USED WHEN CORRECTING ANY

CONDITIONS EXTENDING INTO OR THROUGH THE PAINT UNDERCOATS

AND FOR OVER THE ENTIRE PANEL.

COMBINATION PANEL

WORK: WHERE MORE THAN ONE PANEL IS INVOLVED, ADD THE PAINT MATERIAL

ALLOWANCES TOGETHER AND REDUCE THE TOTAL BY 10% PER PANEL,

UP TO A MAXIMUM OF 40%.

E.G. TWO PANELS: TOTAL THE MATERIAL ALLOWANCE AND SUBTRACT 20%

THREE PANELS: TOTAL THE MATERIAL ALLOWANCE AND SUBTRACT 30%

FOUR PANELS: TOTAL THE MATERIAL ALLOWANCE AND SUBTRACT 40%

(OR MORE)

NOTE: ALL PAINT OPERATION TIME ALLOWANCES INCLUDE REMOVAL AND REPLACEMENT OF PARTS

TO FACILITATE THE PAINT OPERATION. PAINT MATERIAL ALLOWANCE FOR EACH PASSENGER VEHICLE

IS LISTED DIRECTLY BELOW THE TIME ALLOWANCE.

E.G. VS VR SB JM JP

B001199 MOULDING, FRONT DOOR RH

— TOP COAT REPAIR 1.3 1.3 1.3 1.3 1.3

PAINT FINISH OPERATIONS

99-050 — 1

SECTION No.

WARRANTY

PROCESSING SEALING, PAINT, DIAGNOSIS, SPECIAL

OPERATIONS, CAMPAIGNS

LOW BAKE OVEN ALLOWANCE

APPLIES TO THE TIME ALLOWED FOR THE OVEN BAKING OF ENAMEL PAINTED VEHICLES ONLY, AND IS

APPLICABLE TO THE ACTUAL PAINT REPAIR TIME ONLY.

AN ALLOWANCE OF $20.00 UP TO THE FIRST $100.00 PAINT LABOUR AND AN ADDITIONAL $7.50 FOR

EACH $100.00 PAINT LABOUR OR PART THEREOF FOR THE REMAINDER. IT IS NOT TO INCLUDE PAINT

MATERIAL ALLOWANCE.

CLAMING FOR LOW BAKE OVEN ALLOWANCE:

CLAIMS FOR TOTAL OVEN ALLOWANCE PLUS PAINT MATERIAL ALLOWANCE MUST BE ENTERED IN THE

NET ITEMS EXPENSE COLUMN, USING NET ITEM TYPE ‘M’.

THE OVEN ALLOWANCE IS TO BE CALCULATED BY THE FOLLOWING FORMULA:

SINGLE PANEL PAINT REPAIR — BAKED ENAMEL:

OVEN ALLOWANCE: $20.00 FOR FIRST $100.00 OF LABOUR COST PLUS

$7.50 FOR EACH REMAINING $100.00 OR PART THEREOF

EXAMPLE: FOR A VR STATION WAGON, PAINTED IN METALLIC, BAKED ENAMEL (REF. PAGE 99-050)

LABOUR OP. NO. DESCRIPTION TIME

B004530 PANEL, ROOF - STRIP & REPAINT, STATION WAGON 10.3 HOURS (TOTAL)

IF WARRANTY RATE IS $40.00, 10.3 HOURS X $40.00 = $412.00 (TOTAL LABOUR)

OVEN ALLOWANCE IS: $20.00 FOR FIRST $100.00

$ 7.50 FOR SECOND $100.0 0

$ 7.50 FOR THIRD $10 0. 00

$ 7.50 FOR FOURTH $10 0. 00

$ 7.50 FOR REMAINING $12.00

TOTAL: $50.00 OVEN ALLOWANCE

COMBINATION PANEL PAINT REPAIRS — BAKED ENAMEL:

FOR MULTIPLE P AINT REPAIRS ON ONE VEHICLE, PAINTED IN BAKED ENAME L, THE OVEN ALLOWANCE

MUST BE CALCULATED AS PER THE FORMULA NOTED ABOVE. (I.E. $20.00 FOR FIRST $ 100.00, $7 .50 F OR

EACH ADDITIONAL $100.00 OR PART THEREOF.) THE TOTAL OVEN ALLOWANCE AMOUN T CALCULATED

USING THE ABOVE FORMULA MUST BE CLAIMED ON THE MAJOR PAINT REPAIR FOR THE VEHICLE.

IDENTIFICATION OF BAKED ENAMEL PAINT — VR MODEL:

THE BODY AND OPTION PLATE ATTACHED TO THE DASH PANEL HAS THE VEHICLE’S PAINT CODE

MARKED ON IT.

LACQUER PAINTS HAVE A 5 DIGIT CODE PREFIXED WITH A ‘1’ FOR SOLID COLOUR, OR A ‘2’ FOR A

METALLIC COLOUR. ENAMEL PAINTS HAVE A 4 DIGIT CODE ONLY.

E.G.: ALASKAN WHITE LACQUER CODE — 1J064

ENAMEL CODE — J064

PAINT FINISH OPERATIONS

99-050 — 2

SECTION No.

WARRANTY

PROCESSING SEALING, PAINT, DIAGNOSIS, SPECIAL

OPERATIONS, CAMPAIGNS

PAINT FINISH OPERATIONS

99-050 — 3

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

VX/

U, 2

VY/

V2II WL WKVZVE WM

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

99-050 PAINT

### PRIOR ZONE APPROVAL IS REQUIRED FOR

ALL STRIP & REPAINT REPAIRS ###

*****************************************

B069099 STRIPES (PAINT) OR TRANSFER/DECALS —

REPAIR/REPLACE STSTSTSTSTSTSTST

B000910 STRIP & REPAINT SEDAN 38.9 38.9 38.9 38.9 38.9 38.9 38.9 38.9

ADD FOR: BAKED ENAMEL 11.9 11.9 11.9 11.9 11.9 11.9 11.9 11.9

### PAINT MATERIAL ALLOWANCE $ $424 $424 $424 $424 $424$424 $424 $424

ADD FOR: BAKED ENAMEL $78 $78 $78 $78 $78 $78 $78 $78

B000910 STRIP & REPAINT — UTE — 36.5 36.5 36.5 — — — —

ADD FOR: BAKED ENAMEL — 11.9 11.9 11.9 — — — —

### PAINT MATERIAL ALLOWANCE $ — $424 $424 $424 — — — —

ADD FOR: BAKED ENAMEL — $78 $78 $78 — — — —

B000910 STRIP & REPAINT STATION WAGON — 40.7 40.7 40.7 — — — —

ADD FOR: BAKED ENAMEL — 13.6 13.6 13.6 — — — —

### PAINT MATERIAL ALLOWANCE $ — $424 $424 $424 — — — —

ADD FOR: BAKED ENAMEL — $78 $78 $78 — — — —

B000920 TOP COAT REPAIR SEDAN 26.3 26.3 26.3 26.3 26.3 26.3 26.3 26.3

ADD FOR: BAKED ENAMEL 8.2 8.2 8.2 8.2 8.2 8.2 8.2 8.2

### PAINT MATERIAL ALLOWANCE $ $228 $228 $228 $228 $228$228 $228 $228

ADD FOR: BAKED ENAMEL $57 $57 $57 $57 $57 $57 $57 $57

B000920 TOP COAT REPAIR — UTE — 24.7 24.7 24.7 — — — —

ADD FOR: BAKED ENAMEL — 8.2 8.2 8.2 — — — —

### PAINT MATERIAL ALLOWANCE $ — $228 $228 $228 — — — —

ADD FOR: BAKED ENAMEL — $57 $57 $57 — — — —

B000920 TOP COAT REPAIR STATION WAGON — 27.0 27.0 27.0 — — — —

ADD FOR: BAKED ENAMEL — 9.8 9.8 9.8 — — — —

### PAINT MATERIAL ALLOWANCE $ — $227 $227 $227 — — — —

ADD FOR: BAKED ENAMEL — $58 $58 $58 — — — —

B001100 PANEL ASM. LOAD AREA TUB (UTE) — SPOT

REPAIR — 1.3 1.3 1.3 — — — —

### PAINT MATERIAL ALLOWANCE $ — $39 $39 $39 — — — —

ADD FOR: BAKED ENAMEL — $9 $9 $9 — — — —

B001200 PANEL ASM. LOAD AREA TUB (UTE) — TOP COAT

REPAIR — 1.8 1.8 1.8 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.7 1.7 1.7 — — — —

### PAINT MATERIAL ALLOWANCE $ — $48 $48 $48 — — — —

ADD FOR: BAKED ENAMEL — $11 $11 $11 — — — —

B001300 PANEL ASM. LOAD AREA TUB (UTE) — STRIP &

REPAINT — 2.9 2.9 2.9 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.7 1.7 1.7 — — — —

### PAINT MATERIAL ALLOWANCE $ — $85 $85 $85 — — — —

ADD FOR: BAKED ENAMEL — $24 $24 $24 — — — —

— 4

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 5

VX/

U, 2

VY/

V2II WL WKVZVE WM

B100300 DOOR OPENING RH FRONT — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

B100310 DOOR OPENING LH FRONT — SP OT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

B100320 DOOR OPENING RH REAR — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

B100330 DOOR OPENING LH REAR — S POT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

B100340 ENGINE HOOD OPENING — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

B100350 BOOT LID OPENING — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

B100360 TAILGATE/HATCH OPENING — SPOT REPAIR — 1.0 1.0 1.0 — — — —

### PAINT MATERIAL ALLOWANCE $ — $39 $39 $39 — — — —

ADD FOR: BAKED ENAMEL — $9 $9 $9 — — — —

1 B001119 PANEL ASM. FRONT DOOR OUTER RH — SPOT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

1 B001120 PANEL ASM. FRONT DOOR OUTER RH — TOP

COAT REPAIR 1.8 1.8 1.8 1.8 1.8 1.8 1.8 1.8

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.7 1.7 1.7 1.7 1.7 1.7 1.7 1.7

### PAINT MATERIAL ALLOWANCE $ $48 $48 $48 $48 $48 $48 $48 $48

ADD FOR: BAKED ENAMEL $13 $13 $13 $13 $13 $13 $13 $13

1 B001110 PANEL ASM. FRONT DOOR OUTER RH — STRIP &

REPAINT 2.9 2.9 2.9 2.9 2.9 2.9 2.9 2.9

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.9 1.9 1.9 1.9 1.9 1.9 1.9 1.9

### PAINT MATERIAL ALLOWANCE $ $85 $85 $85 $85 $85 $85 $85 $85

ADD FOR: BAKED ENAMEL $24 $24 $24 $24 $24 $24 $24 $24

2 B001219 PANEL ASM. FRONT DOOR OUTER LH — SPOT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 6

VX/

U, 2

VY/

V2II WL WKVZVE WM

2 B001220 PANEL ASM. FRONT DOOR OUTER LH — TOP

COAT REPAIR 1.8 1.8 1.8 1.8 1.8 1.8 1.8 1.8

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.7 1.7 1.7 1.7 1.7 1.7 1.7 1.7

### PAINT MATERIAL ALLOWANCE $ $48 $48 $48 $48 $48 $48 $48 $48

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

2 B001210 PANEL ASM. FRONT DOOR OUTER LH — STRIP &

REPAINT 2.9 2.9 2.9 2.9 2.9 2.9 2.9 2.9

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.7 1.7 1.7 1.7 1.7 1.7 1.7 1.7

### PAINT MATERIAL ALLOWANCE $ $85 $85 $85 $85 $85 $85 $85 $85

ADD FOR: BAKED ENAMEL $24 $24 $24 $24 $24 $24 $24 $24

3 B001319 PANEL ASM. REAR DOOR OUTER RH — SPOT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

3 B001320 PANEL ASM. REAR DOOR OUTER RH — TOP

COAT REPAIR 1.8 1.8 1.8 1.8 1.8 1.8 1.8 1.8

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.7 1.7 1.7 1.7 1.7 1.7 1.7 1.7

### PAINT MATERIAL ALLOWANCE $ $48 $48 $48 $48 $48 $48 $48 $48

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

3 B001310 PANEL ASM. REAR DOOR OUTER RH — STRIP &

REPAINT 2.9 2.9 2.9 2.9 2.9 2.9 2.9 2.9

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $86 $86 $86 $86 $86 $86 $86 $86

ADD FOR: BAKED ENAMEL $23 $23 $23 $23 $23 $23 $23 $23

4 B001419 PANEL ASM. REAR DOOR OUTER LH — SPOT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

4 B001420 PANEL ASM. REAR DOOR OUTER LH — TOP

COAT REPAIR 1.8 1.8 1.8 1.8 1.8 1.8 1.8 1.8

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.7 1.7 1.7 1.7 1.7 1.7 1.7 1.7

### PAINT MATERIAL ALLOWANCE $ $48 $48 $48 $48 $48 $48 $48 $48

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

4 B001410 PANEL ASM. REAR DOOR OUTER LH — STRIP &

REPAINT 2.9 2.9 2.9 2.9 2.9 2.9 2.9 2.9

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.2 1.2 1.2 1.2 1.2 1.2 1.2 1.2

### PAINT MATERIAL ALLOWANCE $ $86 $86 $86 $86 $86 $86 $86 $86

ADD FOR: BAKED ENAMEL $23 $23 $23 $23 $23 $23 $23 $23

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 7

VX/

U, 2

VY/

V2II WL WKVZVE WM

5 B001199 MOULDING, RH FRONT DOOR — TOP COAT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $33 $33 $33 $33 $33 $33 $33 $33

6 B001299 MOULDING, LH FRONT DOOR — TOP COAT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $33 $33 $33 $33 $33 $33 $33 $33

7 B001399 MOULDING, RH REAR DOOR — TOP COAT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $33 $33 $33 $33 $33 $33 $33 $33

8 B001499 MOULDING, LH REAR DOOR — TOP COAT REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $33 $33 $33 $33 $33 $33 $33 $33

9 B001519 PANEL, REAR QUARTER OUTER RH — SPOT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

9 B001530 PANEL, REAR QUARTER OUTER RH — TOP COAT

REPAIR 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.4 1.4 1.4 1.4 1.4 1.4 1.4 1.4

### PAINT MATERIAL ALLOWANCE $ $50 $50 $50 $50 $50 $50 $50 $50

ADD FOR: BAKED ENAMEL $8 $8 $8 $8 $8 $8 $8 $8

9 B001530 PANEL, REAR QUARTER OUTER RH (UTE ONLY)

— TOP COAT REPAIR — 1.8 1.8 1.8 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.4 1.4 1.4 — — — —

### PAINT MATERIAL ALLOWANCE $ — $50 $50 $50 — — — —

ADD FOR: BAKED ENAMEL — $8 $8 $8 — — — —

9 B001510 PANEL, REAR QUARTER OUTER RH — STRIP &

REPAINT 2.9 2.9 2.9 2.9 2.9 2.9 2.9 2.9

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $98 $98 $98 $98 $98 $98 $98 $98

ADD FOR: BAKED ENAMEL $23 $23 $23 $23 $23 $23 $23 $23

9 B001510 PANEL, REAR QUARTER OUTER RH (UTE ONLY)

— STRIP & REPAINT — 2.7 2.7 2.7 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.3 1.3 1.3 — — — —

### PAINT MATERIAL ALLOWANCE $ — $98 $98 $98 — — — —

ADD FOR: BAKED ENAMEL — $23 $23 $23 — — — —

10 B001619 PANEL, REAR QUARTER OUTER LH — SPOT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 8

VX/

U, 2

VY/

V2II WL WKVZVE WM

10 B001630 PANEL, REAR QUARTER OUTER LH — TOP COAT

REPAIR 2.0 2.0 2.0 2.0 2.0 2.0 2.0 2.0

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.4 1.4 1.4 1.4 1.4 1.4 1.4 1.4

### PAINT MATERIAL ALLOWANCE $ $50 $50 $50 $50 $50 $50 $50 $50

ADD FOR: BAKED ENAMEL $8 $8 $8 $8 $8 $8 $8 $8

10 B001630 PANEL, REAR QUARTER OUTER LH (UTE ONLY)

— TOP COAT REPAIR — 1.8 1.8 1.8 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.4 1.4 1.4 — — — —

### PAINT MATERIAL ALLOWANCE $ — $50 $50 $50 — — — —

ADD FOR: BAKED ENAMEL — $8 $8 $8 — — — —

10 B001610 PANEL, REAR QUARTER OUTER LH — STRIP &

REPAINT 2.9 2.9 2.9 2.9 2.9 2.9 2.9 2.9

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $98 $98 $98 $98 $98 $98 $98 $98

ADD FOR: BAKED ENAMEL $23 $23 $23 $23 $23 $23 $23 $23

10 B001610 PANEL, REAR QUARTER OUTER LH (UTE ONLY)

— STRIP & REPAINT — 2.7 2.7 2.7 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.3 1.3 1.3 — — — —

### PAINT MATERIAL ALLOWANCE $ — $98 $98 $98 — — — —

ADD FOR: BAKED ENAMEL — $23 $23 $23 — — — —

11 B001719 DECK LID ASM. RR COMPARTMENT — SPOT

REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

11 B001720 DECK LID ASM. RR COMPARTMENT — TOP COAT

REPAIR 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $51 $51 $51 $51 $51 $51 $51 $51

ADD FOR: BAKED ENAMEL $10 $10 $10 $10 $10 $10 $10 $10

11 B001710 DECK LID ASM. RR COMPARTMENT — STRIP &

REPAINT 3.2 3.2 3.2 3.2 3.2 3.2 3.2 3.2

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $96 $96 $96 $96 $96 $96 $96 $96

ADD FOR: BAKED ENAMEL $25 $25 $25 $25 $25 $25 $25 $25

12 B001819 PANEL, TAILGATE OR HATCH — SPOT REPAIR — 1.3 1.3 1.3 — — — —

### PAINT MATERIAL ALLOWANCE $ — $39 $39 $39 — — — —

ADD FOR: BAKED ENAMEL — $9 $9 $9 — — — —

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 9

VX/

U, 2

VY/

V2II WL WKVZVE WM

12 B001820 PANEL, TAILGATE OR HATCH — TOP COAT

REPAIR — 2.8 2.8 2.8 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — .8 .8 .8 — — — —

### PAINT MATERIAL ALLOWANCE $ — $51 $51 $51 — — — —

ADD FOR: BAKED ENAMEL — $10 $10 $10 — — — —

12 B001820 PANEL, TAILGATE (UTE ONLY) — TOP COAT

REPAIR — 1.8 1.8 1.8 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — .8 .8 .8 — — — —

### PAINT MATERIAL ALLOWANCE $ — $51 $51 $51 — — — —

ADD FOR: BAKED ENAMEL — $10 $10 $10 — — — —

12 B001810 PANEL, TAILGATE OR HATCH — STRIP & REPAINT — 3.6 3.6 3.6 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — .9 .9 .9 — — — —

### PAINT MATERIAL ALLOWANCE $ — $96 $96 $96 — — — —

ADD FOR: BAKED ENAMEL — $25 $25 $25 — — — —

12 B001810 PANEL, TAILGATE (UTE ONLY) — STRIP &

REPAINT — 2.6 2.6 2.6 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — .9 .9 .9 — — — —

### PAINT MATERIAL ALLOWANCE $ — $96 $96 $96 — — — —

ADD FOR: BAKED ENAMEL — $25 $25 $25 — — — —

13 B002820 PILLAR, FRONT BODY RH — TOP COAT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

13 B002810 PILLAR, FRONT BODY RH — STRIP & REPAINT 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL .3 .3 .3 .3 .3 .3 .3 .3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

14 B002920 PILLAR, FRONT BODY LH — TOP COAT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

14 B002910 PILLAR, FRONT BODY LH — STRIP & REPAINT 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL .3 .3 .3 .3 .3 .3 .3 .3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

15 B003330 PANEL ASM. ENGINE HOOD — SPOT REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 10

VX/

U, 2

VY/

V2II WL WKVZVE WM

15 B003305 PANEL ASM. ENGINE HOOD — TOP COAT REPAIR 2.2 2.2 2.2 2.2 2.2 2.2 2.2 2.2

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL .3 .3 .3 .3 .3 .3 .3 .3

### PAINT MATERIAL ALLOWANCE $ $51 $51 $51 $51 $51 $51 $51 $51

ADD FOR: BAKED ENAMEL $23 $23 $23 $23 $23 $23 $23 $23

15 B003300 PANEL ASM. ENGINE HOOD — STRIP & REPAINT 3.4 3.4 3.4 3.4 3.4 3.4 3.4 3.4

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL .4 .4 .4 .4 .4 .4 .4 .4

### PAINT MATERIAL ALLOWANCE $ $114 $114 $114 $114 $114 $114 $114 $114

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

16 B004500 PANEL, ROOF — SPOT REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

16 B004540 PANEL, ROOF — TOP COAT REPAIR SEDAN OR

HATCHBACK 3.6 3.6 3.6 3.6 3.6 3.6 3.6 3.6

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.7 1.7 1.7 1.7 1.7 1.7 1.7 1.7

### PAINT MATERIAL ALLOWANCE $ $52 $52 $52 $52 $52 $52 $52 $52

ADD FOR: BAKED ENAMEL $23 $23 $23 $23 $23 $23 $23 $23

16 B004540 PANEL, ROOF — TOP COAT REPAIR — (UTE ONLY) — 2.3 2.3 2.3 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.7 1.7 1.7 — — — —

### PAINT MATERIAL ALLOWANCE $ — $52 $52 $52 — — — —

ADD FOR: BAKED ENAMEL — $23 $23 $23 — — — —

16 B004530 PANEL, ROOF — STRIP & REPAINT SEDAN OR

HATCHBACK 5.6 5.6 5.6 5.6 5.6 5.6 5.6 5.6

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.8 1.8 1.8 1.8 1.8 1.8 1.8 1.8

### PAINT MATERIAL ALLOWANCE $ $102 $102 $102 $102 $102$102 $102 $102

ADD FOR: BAKED ENAMEL $22 $22 $22 $22 $22 $22 $22 $22

16 B004530 PANEL, ROOF — STRIP & REPAINT — (UTE ONLY) — 3.3 3.3 3.3 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.8 1.8 1.8 — — — —

### PAINT MATERIAL ALLOWANCE $ — $102 $102 $102 — — — —

ADD FOR: BAKED ENAMEL — $22 $22 $22 — — — —

17 B004540 PANEL, ROOF — TOP COAT REPAIR STATION

WAGON — 5.2 5.2 5.2 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.5 1.5 1.5 — — — —

### PAINT MATERIAL ALLOWANCE $ — $57 $57 $57 — — — —

ADD FOR: BAKED ENAMEL — $24 $24 $24 — — — —

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 11

VX/

U, 2

VY/

V2II WL WKVZVE WM

17 B004530 PANEL, ROOF — STRIP & REPAINT STATION

WAGON — 8.2 8.2 8.2 — — — —

ADD FOR: METALLIC — .3 .3 .3 — — — —

ADD FOR: BAKED ENAMEL — 1.8 1.8 1.8 — — — —

### PAINT MATERIAL ALLOWANCE $ — $121 $121 $121 — — — —

ADD FOR: BAKED ENAMEL — $23 $23 $23 — — — —

17 B004550 PANEL, ROOF — TOP COAT REPAIR UTE WITH

HBD CANOPY ONLY — 2.5 2.5 — — — — —

ADD FOR: METALLIC — .3 .3 — — — — —

ADD FOR: BAKED ENAMEL — 1.5 1.5 — — — — —

### PAINT MATERIAL ALLOWANCE $ — $57 $57 — — — — —

ADD FOR: BAKED ENAMEL — $24 $24 — — — — —

18 B012500 PANEL, SILL OUTER RH — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

18 B012520 PANEL, SILL OUTER RH — TOP COAT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

18 B012510 PANEL, SILL OUTER RH — STRIP & REPAINT 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

19 B012600 PANEL, SILL OUTER LH — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

19 B012620 PANEL, SILL OUTER LH — TOP COAT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

19 B012610 PANEL, SILL OUTER LH — STRIP & REPAINT 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

20 B014520 FRAME, FRONT DOOR WINDOW RH — TOP COAT

REPAIR .5 .5 .5 .5 .5 .5 .5 .5

ADD FOR: BAKED ENAMEL .6 .6 .6 .6 .6 .6 .6 .6

### PAINT MATERIAL ALLOWANCE $ $22 $22 $22 $22 $22 $22 $22 $22

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

20 B014510 FRAME, FRONT DOOR WINDOW RH — STRIP &

REPAINT .5.5.5.5.5.5.5.5

ADD FOR: BAKED ENAMEL .9 .9 .9 .9 .9 .9 .9 .9

### PAINT MATERIAL ALLOWANCE $ $22 $22 $22 $22 $22 $22 $22 $22

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

21 B014620 FRAME, FRONT DOOR WINDOW LH — TOP COAT

REPAIR .5 .5 .5 .5 .5 .5 .5 .5

ADD FOR: BAKED ENAMEL .6 .6 .6 .6 .6 .6 .6 .6

### PAINT MATERIAL ALLOWANCE $ $22 $22 $22 $22 $22 $22 $22 $22

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 12

VX/

U, 2

VY/

V2II WL WKVZVE WM

21 B014610 FRAME, FRONT DOOR WINDOW LH — STRIP &

REPAINT .5.5.5.5.5.5.5.5

ADD FOR: BAKED ENAMEL .9 .9 .9 .9 .9 .9 .9 .9

### PAINT MATERIAL ALLOWANCE $ $22 $22 $22 $22 $22 $22 $22 $22

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

22 B020520 FRAME, REAR DOOR WINDOW RH — TOP COAT

REPAIR .5 .5 .5 .5 .5 .5 .5 .5

ADD FOR: BAKED ENAMEL .6 .6 .6 .6 .6 .6 .6 .6

### PAINT MATERIAL ALLOWANCE $ $22 $22 $22 $22 $22 $22 $22 $22

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

22 B020510 FRAME, REAR DOOR WINDOW RH — STRIP &

REPAINT .5.5.5.5.5.5.5.5

ADD FOR: BAKED ENAMEL .9 .9 .9 .9 .9 .9 .9 .9

### PAINT MATERIAL ALLOWANCE $ $22 $22 $22 $22 $22 $22 $22 $22

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

23 B020620 FRAME, REAR DOOR WINDOW LH — TOP COAT

REPAIR .5 .5 .5 .5 .5 .5 .5 .5

ADD FOR: BAKED ENAMEL .6 .6 .6 .6 .6 .6 .6 .6

### PAINT MATERIAL ALLOWANCE $ $22 $22 $22 $22 $22 $22 $22 $22

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

23 B020610 FRAME, REAR DOOR WINDOW LH — STRIP &

REPAINT .5.5.5.5.5.5.5.5

ADD FOR: BAKED ENAMEL .9 .9 .9 .9 .9 .9 .9 .9

### PAINT MATERIAL ALLOWANCE $ $22 $22 $22 $22 $22 $22 $22 $22

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

24 B047100 PANEL ASM. BACK LOWER — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

24 B047120 PANEL ASM. BACK LOWER — TOP COAT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

### PAINT MATERIAL ALLOWANCE $ $45 $45 $45 $45 $45 $45 $45 $45

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

24 B047110 PANEL ASM. BACK LOWER — STRIP & REPAINT 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

### PAINT MATERIAL ALLOWANCE $ $75 $75 $75 $75 $75 $75 $75 $75

ADD FOR: BAKED ENAMEL $35 $35 $35 $35 $35 $35 $35 $35

25 B062200 FENDER, PANEL RH — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

25 B062220 FENDER, PANEL RH — TOP COAT REPAIR 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $48 $48 $48 $48 $48 $48 $48 $48

ADD FOR: BAKED ENAMEL $26 $26 $26 $26 $26 $26 $26 $26

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 13

VX/

U, 2

VY/

V2II WL WKVZVE WM

25 B062210 FENDER, PANEL RH — STRIP & REPAINT 3.5 3.5 3.5 3.5 3.5 3.5 3.5 3.5

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.6 1.6 1.6 1.6 1.6 1.6 1.6 1.6

### PAINT MATERIAL ALLOWANCE $ $83 $83 $83 $83 $83 $83 $83 $83

ADD FOR: BAKED ENAMEL $23 $23 $23 $23 $23 $23 $23 $23

26 B062300 FENDER, PANEL LH — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

26 B062320 FENDER, PANEL LH — TOP COAT REPAIR 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $48 $48 $48 $48 $48 $48 $48 $48

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

26 B062310 FENDER, PANEL LH — STRIP & REPAINT 3.5 3.5 3.5 3.5 3.5 3.5 3.5 3.5

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

ADD FOR: BAKED ENAMEL 1.6 1.6 1.6 1.6 1.6 1.6 1.6 1.6

### PAINT MATERIAL ALLOWANCE $ $83 $83 $83 $83 $83 $83 $83 $83

ADD FOR: BAKED ENAMEL $23 $23 $23 $23 $23 $23 $23 $23

27 B062600 PANEL, VALANCE OR AIR DAM — SPOT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

27 B062620 PANEL, VALANCE OR AIR DAM — TOP COAT

REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $45 $45 $45 $45 $45 $45 $45 $45

ADD FOR: BAKED ENAMEL $11 $11 $11 $11 $11 $11 $11 $11

27 B062610 PANEL, VALANCE OR AIR DAM — STRIP &

REPAINT 1.5 1.5 1.5 1.5 1.5 1.5 1.5 1.5

### PAINT MATERIAL ALLOWANCE $ $79 $79 $79 $79 $79 $79 $79 $79

ADD FOR: BAKED ENAMEL $27 $27 $27 $27 $27 $27 $27 $27

28 B076520 BUMPER BAR, FRONT OR CENTRE OR ENDS —

TOP COAT REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $67 $67 $67 $67 $67 $67 $67 $67

29 B077520 BUMPER BAR, REAR — TOP COAT REPAIR 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

### PAINT MATERIAL ALLOWANCE $ $67 $67 $67 $67 $67 $67 $67 $67

29 B077600 BUMPERETTE, REAR RH — TOP COAT REPAIR — 1.0 1.0 1.0 — — — —

### PAINT MATERIAL ALLOWANCE $ — $45 $45 $45 — — — —

29 B077620 BUMPERETTE, REAR LH — TOP COAT REPAIR — 1.0 1.0 1.0 — — — —

### PAINT MATERIAL ALLOWANCE $ — $45 $45 $45 — — — —

30 B078520 GRILLE ASM. (RADIATOR) — TOP COAT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $41 $41 $41 $41 $41 $41 $41 $41

31 B081199 DOOR, FUEL TANK FILLER — TOP COAT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

### PAINT MATERIAL ALLOWANCE $ $33 $33 $33 $33 $33 $33 $33 $33

32 B201060 SPOILER, REAR — TOP COAT REPAIR 1.5 1.5 1.5 1.5 1.5 1.5 1.5 1.5

### PAINT MATERIAL ALLOWANCE $ $33 $33 $33 $33 $33 $33 $33 $33

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 14

VX/

U, 2

VY/

V2II WL WKVZVE WM

33 B100100 PILLAR, REAR BODY RH — TOP COAT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

33 B100120 PILLAR, REAR BODY RH — STRIP & REPAINT 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

### PAINT MATERIAL ALLOWANCE $ $75 $75 $75 $75 $75 $75 $75 $75

ADD FOR: BAKED ENAMEL $35 $35 $35 $35 $35 $35 $35 $35

33 B100130 MOULDING, REAR QUARTER PANEL RH — (UTE) — 1.3 1.3 1.3 — — — —

### PAINT MATERIAL ALLOWANCE $ — $33 $33 $33 — — — —

34 B100200 PILLAR, REAR BODY LH — TOP COAT REPAIR 1.0 1.0 1.0 1.0 1.0 1.0 1.0 1.0

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

### PAINT MATERIAL ALLOWANCE $ $39 $39 $39 $39 $39 $39 $39 $39

ADD FOR: BAKED ENAMEL $9 $9 $9 $9 $9 $9 $9 $9

34 B100220 PILLAR, REAR BODY LH — STRIP & REPAINT 1.3 1.3 1.3 1.3 1.3 1.3 1.3 1.3

ADD FOR: METALLIC .3.3.3.3.3.3.3.3

### PAINT MATERIAL ALLOWANCE $ $75 $75 $75 $75 $75 $75 $75 $75

ADD FOR: BAKED ENAMEL $35 $35 $35 $35 $35 $35 $35 $35

34 B100230 MOULDING, REAR QUARTER PANEL LH — (UTE) — 1.3 1.3 1.3 — — — —

### PAINT MATERIAL ALLOWANCE $ — $33 $33 $33 — — — —

35 B081530 RH MIRROR, OUTSIDE REAR VIEW — TOP COAT

REPAIR .7 .7 .7 .7 .7 .7 .7 .7

### PAINT MATERIAL ALLOWANCE $ $25 $25 $25 $25 $25 $25 $25 $25

36 B081630 LH MIRROR, OUTSIDE REAR VIEW — TOP COAT

REPAIR .7 .7 .7 .7 .7 .7 .7 .7

### PAINT MATERIAL ALLOWANCE $ $25 $25 $25 $25 $25 $25 $25 $25

37 B081200 HANDLE, DOOR OUTSIDE RHF — TOP COAT

REPAIR .7 .7 .7 .7 .7 .7 .7 .7

### PAINT MATERIAL ALLOWANCE $ $25 $25 $25 $25 $25 $25 $25 $25

38 B081250 HANDLE, DOOR OUTSIDE LHF — TOP COAT

REPAIR .7 .7 .7 .7 .7 .7 .7 .7

### PAINT MATERIAL ALLOWANCE $ $25 $25 $25 $25 $25 $25 $25 $25

39 B081300 HANDLE, DOOR OUTSIDE RHR — TOP COAT

REPAIR .7 .7 .7 .7 .7 .7 .7 .7

### PAINT MATERIAL ALLOWANCE $ $25 $25 $25 $25 $25 $25 $25 $25

40 B081350 HANDLE, DOOR OUTSIDE LHR — TOP COAT

REPAIR .7 .7 .7 .7 .7 .7 .7 .7

### PAINT MATERIAL ALLOWANCE $ $25 $25 $25 $25 $25 $25 $25 $25

50 B092510 WHEEL, ROAD — PAINT .5 .5 .5 .5 .5 .5 .5 .5

ADD FOR: EACH ADDITIONAL WHEEL .2.2.2.2.2.2.2.2

### PAINT MATERIAL ALLOWANCE $ $25 $25 $25 $25 $25 $25 $25 $25

51 B077810 MOULDING CAP, ROOF REAR RH — TOP COAT

REPAIR —.7 .7.7————

### PAINT MATERIAL ALLOWANCE $ — $25 $25 $25 — — — —

PAINT

PAINT, SPECIAL OPERATIONS, CAMPAIGNS

ISSUE — 00/00/00 # DENOTES 36/100 POWER TRAIN WARRANTY REVISION — 00/00/00

SECTION No.

Labour Operation Model

Key

No. No. Description

WARRANTY

PROCESSING

99-050 — 15

VX/

U, 2

VY/

V2II WL WKVZVE WM

52 B077820 MOULDING CAP, ROOF REAR LH — TOP COAT

REPAIR —.7 .7.7————

### PAINT MATERIAL ALLOWANCE $ — $25 $25 $25 — — — —

53 B077830 MOULDING CAP, ROOF REAR CENTRE — TOP

COAT REPAIR — .7 .7 .7 — — — —

### PAINT MATERIAL ALLOWANCE $ — $25 $25 $25 — — — —

54 B077710 RAIL ASM, BELT OUTER RH — TOP COAT REPAIR — 1.0 1.0 1.0 — — — —

### PAINT MATERIAL ALLOWANCE $ — $33 $33 $33 — — — —

55 B077720 RAIL ASM, BELT OUTER LH — TOP COAT REPAIR — 1.0 1.0 1.0 — — — —

### PAINT MATERIAL ALLOWANCE $ — $33 $33 $33 — — — —

56 B077750 RAIL ASM, ENDGATE UPPER — TOP COAT

REPAIR — 1.0 1.0 1.0 — — — —

### PAINT MATERIAL ALLOWANCE $ — $33 $33 $33 — — — —

57 B077730 MOULDING CAP, TAILLAMP RH — TOP COAT

REPAIR —.7 .7.7————

### PAINT MATERIAL ALLOWANCE $ — $25 $25 $25 — — — —

58 B077740 MOULDING CAP, TAILLAMP LH — TOP COAT

REPAIR —.7 .7.7————

### PAINT MATERIAL ALLOWANCE $ — $25 $25 $25 — — — —

B077770 TONNEAU COVER, (RIGID) — TOP COAT REPAIR — 3.6 3.6 3.6 — — — —

### PAINT MATERIAL ALLOWANCE $ — $55 $55 $55 — — — —

SECTION No.

WARRANTY

PROCESSING

OPERATION SPECIAL TASK OPERATION NUMBERS

LAB. OP. MODEL &/OR STD. LETTER GROUP ISSUE

NUMBER OPERATION DESCRIPTION SERIES TIME TYPE /NO. /DATE

99-150 —

SEALING, PAINT, DIAGNOSIS, SPECIAL OPERATIONS,

CAMPAIGNS

SPECIAL OPERATIONS

A000225 REPL. BODY/OPT. PLATE (SILVER ICE PAINT) VS 0.5 ADL 28/95 06/95

A000228 INSPECT UPPER BODY FOR CORROSION SB 0.4 ADL 45/95 08/95

A000231 ELIMINATE WIND NOISE/W-SCREEN MOULDING VS 0.4 TIB GRP 01 02/97

A000246 RECTIFY CREAK — RH LOWER CORNER,

WINDSCREEN AREA VT 0.5 TIB G RP 01 02/99

A000249 RECTIFY CREAK — LH LOWER DASH AREA VT 0.5 TIB GRP 01 02/99

A000252 RESEAL ROOF PANEL SEAM — RH SIDE VT 0.5 TIB GRP 01 03/99

A000255 RESEAL ROOF PANEL SEAM — LH SIDE VT 0.5 TIB GRP 01 03/99

A000258 SEPARATE DASH PANEL (SHEETMETAL) VT, WH 0.7 T IB GRP 01 09/99

A000276 INSTRUMENT PANEL RETAINING SCREWS

— REPLACE VT, WH 0.4 TIB GRP 01 09/00

A000279 MODIFY COCKPIT MODULE VX , VU, WH 0.3 TIB GRP 01 04/01

A000291 RH ROCKER PANEL WATER LEAK REWORK V2 0.6 TIB GRP 01 05/03

A000294 LH ROCKER PANEL WATER LEAK REWORK V2 0.6 TIB GRP 01 05/03

A000297 CABIN DUST ENTRY VU,VY (UTE) 1.5 TIB GRP 01 08/03

C000054 CRACKS IN FLOOR PANEL (FRONT SEAT

MOUNTING HOLE) V CAR 1.3 SL GRP 01 03/83

C000277 INSTALL SEAT RECLINER BRAKE RING KIT VR 0.3 TIB GRP 01 02/95

C000286 THIRD SEAT STOWABILITY VR/VP 1.2 TIB GRP 01 06/95

C000289 HOLLANDIA SUNROOF REWORK VS 0.4 ADL 72/95 12/95

C000295 INSTRUMENT PANEL PAD REWORK JM/JP 3.0 TIB GRP 01 05/97

C000298 DOOR DRAIN PLUGS REPLACE VT 0.3 TIB GRP 01 07/97

C000301 ADD SPACER — R/H FRONT WINDOW REGULATOR VT 0.6 TIB GRP 01 07/97

C000304 ADD SPACER — L/H FRONT WINDOW REGULATOR VT 0.6 TIB GRP 01 07/97

C000307 ADJUST & GREASE DOOR LOCK RHF VT 0.4 TIB GRP 01 04/99

C000310 ADJUST & GREASE DOOR LOCK LHF VT 0.4 TIB GRP 01 04/99

C000313 FIT ROD, ADJUST & GREASE DOOR LOCK BOTH REAR VT 0.8 TIB GRP 01 04/99

C000319 ADJUST & GREASE DOOR LOCK ALL VT 1.3 TIB GRP 01 04/99

C000322 ADD FLOCK TAPE TO FRONT DOORS VT 0.3 TIB GRP 01 01/98

C000325 RH FRONT SEAT MAP POCKET REPLACE VT 0.3 TIB G RP 01 02/98

C000328 LH FRONT SEAT MAP POCKET REPLACE VT 0.3 TIB GRP 01 02/98

C000331 CONSOLE FACIA REWORK VT 0.4 TIB GRP 12 04/98

C000334 FIT EXTERIOR MIRROR SEALS VT 0.7 TIB G RP 01 04/98

C000337 TAPE RH PRETENSIONER CONNECTOR VT 0.4 TIB GRP 12 04/98

C000340 TAPE LH PRETENSIONER CONNECTOR VT 0.4 TIB GRP 12 04/98

C000343 FIT DAMPING TAPE TO PARCEL SHELF SUPPORT TR 0.2 TIB GRP 01 04/98

C000355 FIT REVISED REAR SEAT LOCKS VT (WAG) 1.0 TIB GRP 01 08/98

C000358 DOOR CHECK SHAFT BOLTS REPLACE BOTH VT, JR, JS 0.3 TIB GRP 01 10/00

C000370 MODIFY ‘‘A’’ PILLAR CLOSING PLATE CLEARANCE VT 0.4 TIB GRP 01 10/98

C000373 BELT LINE MOULDING END CAPS — REPLACE ALL VT, WH 0.6 TIB GRP 01 07/99

C000376 WINDOW STOPS — ADJUST VT 0.5 TIB GRP 01 07/99

C000379 DECK LID BUFFERS — REPLACE VT, WH 0.3 TIB GRP 01 07/99

C000385 FIT SPRING TO SEAT HEIGHT ADJUSTER VT 0.6 T IB GRP 01 07/99

C000388 CENTRE REAR SEATBELT ESCUTCHEON — REPLACE VT (WAGON) 0.6 TIB GRP 01 08/99

OPERATION SPECIAL TASK OPERATION NUMBERS

LAB. OP. MODEL &/OR STD. LETTER GROUP ISSUE

NUMBER OPERATION DESCRIPTION SERIES TIME TYPE /NO. /DATE

SPECIAL OPERATIONS

SECTION No.

WARRANTY

PROCESSING

99-150 — 2

C000391 WASHER, DECKLID HINGE — REPLACE JR, JS (SEDAN) 0.6 TIB GRP 01 06/00

C000394 RESEAL ROOF BOW TO ROOF JR 1.0 TIB GRP 01 10/99

C000397 REPLACE RECLINER & LUMBAR KNOBS VT, WH 0.3 TIB GRP 01 02/00

C000400 CORRECT HEADLINING WATER LEAKS SB (CABRIO) 0.6 TIB GRP 01 03/00

C000415 FIT CLIPS TO BOTH FRONT SEAT INNER RAIL COVERS VT, WH 0.3 TIB GRP 01 10/00

C000421 REPLACE REAR SEAT BELT SIDE ESCUTCHEON VX, VT, WH (SEDAN) 0.2 TIB GRP 01 02/01

C000424 SHORTEN REAR CARGO FLOOR DRAIN TUBES VU 0.3 TIB GRP 01 03/01

C000427 REPLACE ROOF FINISHER MOULDING END CAPS VT, VX 0.3 TIB GRP 01 07/01

C000430 REMOVE REAR SIDE TONNEAU COVER FINGER LOOPS VU 0.3 TIB GRP 01 04/01

C000433 REPLACE FRONT WINDOW REGULATOR RIVETS

— BOTH SIDES TS 1.4 TIB GRP 01 06/01

C000436 REPLACE FRONT WINDOW REGULATOR RIVETS

— RH SIDES TS 0.8 TIB GRP 01 06/01

C000439 REPLACE FRONT WINDOW REGULATOR RIVETS

— LH SIDES TS 0.8 TIB GRP 01 06/01

C000442 FIT ECC FOAM PAD VT, VX, WH 0.3 TIB GRP 02 11/01

C000445 R&R RH REAR QUARTER WINDOW & ADD

ANTI SQUEAK TAPE TS (3 DOOR) 0.7 TIB GRP 01 11/01

C000448 R&R LH REAR QUARTER WINDOW & ADD

ANTI SQUEAK TAPE TS (3 DOOR) 0.7 TIB GRP 01 11/01

C000451 FIT SPRINGS TO BOTH FRONT SEAT BOLSTERS JR, JS (CD SEDAN) 1.5 TIB GRP 01 04/02

C000454 FIT FRONT & REAR ASH TRAYS & CIGARETTE LIGHTER XC 0.4 ARL

C000493 FIT CLEVIS NUT TO RHF SEAT VX, VY, V2, VU, WH 1.0 TIB GRP 01 09/03

C000496 FIT CLEVIS NUT TO LHF SEAT VX, VY, V2, VU, WH 1.0 TIB GRP 01 09/03

C000499 TRIM RHF SEAT SIDE COVER VY BUILT APRIL 03 ON 0.4 TIB GRP 01 10/03

C000502 REPLACE TONNEAU BAR BRACKETS VU, VY UTE 0.2 TIB GRP 01 10/03

C000505 REWORK RH EXTERIOR MIRROR MOUNTING BOSS V2 0.5 TIB GRP 01 10/03

C000508 REWORK LH EXTERIOR MIRROR MOUNTING BOSS V2 0.5 TIB GRP 01 10/03

C000511 GLUE ALLOY PAD TO ACCELERATOR PEDAL XC, TS 0.3 TIB GRP 01 11/03

C000517 FIT M/FLAP MOUNTING BRACKET SCREW TS 0.4 TIB GRP 01 03/04

C000520 FRONT SEAT ADJUSTER CABLE DISLODGES ZC 0.7 TIB GRP 01 07/04

C000523 INSTALL RETAINER CLIP TO CARPET LOAD AREA WAGON VY 0.3 TIB GRP 01 07/04

C000526 REPLACE SEAT TRACK LEAD SCREW WASHER VT, VX, V2, VY, WH, WK 0.6 TIB GRP 01 07/04

C000529 RHF DOOR LOCK PADDLE LINKAGE RIVETT REWORK VY,V2,WK 0.8 TIB 08/04

C000532 LHF DOOR LOCK PADDLE LINKAGE RIVETT REWORK VY,V2,WK 0.8 TIB 08/04

C000535 RHR DOOR LOCK PADDLE LINKAGE RIVETT REWORK VY,V2,WK 0.6 TIB 08/04

C000538 LHR DOOR LOCK PADDLE LINKAGE RIVETT REWORK VY,V2,WK 0.6 TIB 08/04

D000149 SEAL DUCT/SECURE FRESH/RECIRC DOORS SB 1.0 TIB GRP 02 03/95

D000152 INSTALL BLOWER INLET SCREEN VR 0.3 T IB GRP 02 08/95

D000155 INSTALL COMPRESSOR BRACE VP-VR(V8) 0.5 TIB GRP 02 04/95

D000158 A/C 5-POINT IMPROVEMENT PACKAGE SB 2.5 ADL 20/95 05/95

D000164 FIT SEALING WASHER TO A/C DOOR PIVOT VR/VS 0.4 TIB GRP 02 06/95

D000167 REPLACE DRIVE BELT IDLER PULLEY/SUP’T VS V6 0.4 ADL 19/96 05/95

D000170 ECC MODULE CHECK VS 0.4 ADL 24/96 04/96

D000173 ECC MODULE CHECK AND REPLACE VS 0.7 ADL 24/96 04/96

D000185 FRONT DEMISTER VENTS REPLACE BOTH JM/JP 0.3 TIB GRP 01 05/97

D000188 A/C BLOWER MOTOR & RESISTOR REPLACE VT 0.4 TIB GRP 02 06/98

D000194 DEMIST/FLOOR DOOR ACTUATING GEAR REPLACE VT 0.3 TIB GRP 02 08/98

OPERATION SPECIAL TASK OPERATION NUMBERS

LAB. OP. MODEL &/OR STD. LETTER GROUP ISSUE

NUMBER OPERATION DESCRIPTION SERIES TIME TYPE /NO. /DATE

SPECIAL OPERATIONS

SECTION No.

WARRANTY

PROCESSING

99-150 — 3

D000197 DIAGNOSE & REPLACE A/C HIGH PRES TRANSDUCER VT (A/C) 0.4 TIB GRP 02 08/98

D000200 VACUUM SWITCH, TEMP CONTROL REPLACE TR (A/C) 0.9 TIB GRP 02 09/98

D000203 INSTALL V8 COMPRESSOR BRACE VT (V8 + A/C) 0.5 T IB GRP 02 01/99

D000215 FRESH/RECIRC. ACTUATOR ROD — REPLACE VT 0.5 TIB GRP 02 09/99

D000221 ADD A/C PIPE RETAINING BRACKET JR, JS (A/C) 0.8 TIB GRP 02 08/00

D000227 RE-ATTACH A/C DISCHARGE MUFFLER INSULATION TS (X18XE1 + A/C) 0.4 TIB GRP 02 10/01

D000330 FIT HVAC WHISTLE FIX KIT WH, VX, V2, VU, VT 0.5 TIB GRP 02 01/02

D000333 INSTALL VACUUM DELAY VALVE K IT TO MODE

ACTUATORS VT (C61, CJ2), WH 0.8 TIB GRP 02 07/02

E000240 FIT FRONT SPRINGS & RR STABILISER BAR VT, V8 (POLICE) 3.0 ADL 08/98 03/98

E000302 FIT STEERING COUPLING REPAIR KIT JR 0.8 TIB GRP 09 05/98

E000308 INSPECT FRONT LOWER CONTROL ARMS (ALL) YE 0.5 ADL 84/98 12/98

E000311 INSPECT FRONT LOWER CONTROL ARMS &

REPLACE RH SIDE YE 1.0 ADL 84/98 12/98

E000314 INSPECT FRONT LOWER CONTROL ARMS &

REPLACE LH SIDE YE 1.0 ADL 84/98 12/98

E000317 INSPECT FRONT LOWER CONTROL ARMS &

REPLACE BOTH SIDES YE 1.5 ADL 84/98 12/98

E000323 WHEEL COVERS REPLACE (ONE OR ALL) JS 0.2 TIB GRP 10 12/98

E000329 TORQUE CHECK FRONT BEARING HUB TO

KNUCKLE BOLTS VS, VT 0.5 ADL 03/99 02/99

E000332 CORRECT VEER LEFT CONDITION VT (NON S OR SS) 0.5 TIB GRP 03 03/99

ADD: FOR WHEEL

ALIGNMENT 0.7

E000335 CORRECT VERR LEFT CONDITION VT (S OR SS) 0.5 TIB GRP 03 03/99

ADD: FOR WHEEL

ALIGNMENT 1.2

E000344 INSTALL INNER STABILISER BAR BUSHES SB (18,20&22 mm BAR) 0.7 TIB GRP 03 06/00

E000347 FIT FRONT STRUT UPPER DUST SEALS VX, VU, VT, WH 1.2 T IB GRP 03 04/01

E000358 ALLOY WHEEL — REPLACE TS 0.4 TIB GRP 08 02/02

ADD FOR: EACH 0.3

ADDITIONAL WHEEL

E000364 FIT TYRE PLACARD TS (CONVERTIBLE) 0.4 ARL

E000370 INVERT FRONT SPRINGS VX,VY,WH,WK,V2 2.2 T IB 07/04

F000138 REAR AXLE COVER/REMOVE & MODIFY VP-VS WITH IRS 0.8 TIB GRP 04 07/96

F000150 CORRECT CENTRE BEARING ANGLE VT (V6 WAG) 0.3 TIB GRP 04 01/98

F000153 REAR SHOCKER MOUNTING ADJUST VT/VS (FE2) 0.3 TIB GRP 04 02/98

F000156 DIFFERENTIAL REVERSE LOAD CHECK VS, VT (AUTO) 0.5 ADL 47/98 08/98

F000159 DIFFERENTIAL REVERSE LOAD CHECK & REPLACE VS, VT (AUTO) 2.7 ADL 47/98 08/98

F000168 REAR SHOCKER UPPER RUBBERS — REPLACE WH 0.4 TIB G RP 04 10/00

F000171 FIT V8 LSD CHATTER FIX KIT VX,VU,VS, VT, WH (LSD) 0.7 ARL 30/02 05/02

ADD FOR: DUEL

INTERMEDIATE EXH 0.5

OPERATION SPECIAL TASK OPERATION NUMBERS

LAB. OP. MODEL &/OR STD. LETTER GROUP ISSUE

NUMBER OPERATION DESCRIPTION SERIES TIME TYPE /NO. /DATE

SPECIAL OPERATIONS

SECTION No.

WARRANTY

PROCESSING

99-150 — 4

F000176 FIT REAR CAMBER CASTER KIT V&W MODLES 3.4 ARL 01/73 09/01

F000179 REPLACE REAR CROSS MEMBER FOR MOAN

AT 105-110 km/h WH, VX (GEN 3 + A/T) 3.6 TIB GRP 04 11/02

F000185 INSTALL INSULATOR — REAR CROSSMEMBER

BOTH SIDES VY (GEN 3 + M/T) 0.5 TIB GRP 04 02/03

F000191 REAR AXLE ASM. - REPLACE FOR DISC SCRAPE VY REGULAR CAB &

CREWMAN 2.1 TIB GRP 4 & 5 10/03

F000194 REALIGN BOTTOM LEAF OF REAR SPRING VY REGULAR CAB &

CREWMAN 0.3 TIB GRP 4 05/04

H000195 MACHINE 4 DISCS & INDEX TO HUB (OFF CAR) VX, VY, V2, WH, WK, VU 1.4 ARL 12/98

H000198 MACHINE FRONT DISCS & INDEX TO HUB (OFF CAR) VX, VY, V2, WH, WK, VU 0.8 ARL 12/98

H000201 MACHINE REAR DISCS & INDEX TO HUB (OFF CAR) VX, VY, V2, WH, WK, VU 0.8 ARL 12/98

H000204 MACHINE 4 DISCS & INDEX TO HUB (ON CAR) VX, VY, V2, WH, WK, VU 0.5 ARL 12/98

H000207 MACHINE FRONT DISCS & INDEX TO HUB (ON CAR) VX, VY, V2, WH, WK, VU 0.3 ARL 12/98

H000210 MACHINE REAR DISCS & INDEX TO HUB (ON CAR) VX, VY, V2, WH, WK, VU 0.4 ARL 12/98

H000213 REPOSITION BRAKE PIPES JS (ABS) 0.3 ADL 06/99 02/99

H000216 INSTALL RETAINING CLIP TO LHF ABS SENSOR LEAD VT (ABS), WH 0.3 TIB GRP 05 01/00

H000222 NEW FRONT BRAKE PADS (SQUEAL ON NON-ABS) TS 0.9 ADL 72/01 05/02

H000234 INSPECT & REPLACE FRONT DISC PADS VXII POLICE VEHICLES 0.5 RDL 09/02 01/02

H000237 INSTALL PARK BRAKE CABLE GUIDE —

MASS DAMPER TYPE TS, TT 0.4 ARL 43/02 06/02

H000240 INSTALL ADDITIONAL CLIP TO BRAKE PIPES VTII, VX,VU,VY,WH 0.2 TIB GRP 05 02/03

H000248 LUBE PARK BRAKE SHOE CONTACT POINTS VT,VX,VY,VU,V2,WH 1.0 TIB GRP 05 04/03

H000251 FRONT ROTOR REPLACE VX, VY, V2, VU, WH, WK 0.8 ARL 11/03

H000254 REAR ROTOR REPLACE VX, VY, V2, VU, WH, WK 0.9 ARL 11/03

H000257 “REAR ROTORS REMOVE, MACHINE AND REFIT” VY REGULAR CAB,

CREWCA 0.4 + 0.4 ARL 12/0

H000260 INSTALL PARK BRAKE SHOE SPRING KIT - BOTH SIDES VX, VY, V2, WH, WK, VU 1.2 TIB

J000469 FUEL TANK VENTING REVISED VR(Exc. Ute) 0.2 TIB GRP 08 01/95

J000478 REPLACE STARTER WITH DV TYPE VR(5.7L) 0.9 TIB GRP 6Y 03/95

J000496 V8 MECHANICAL REPLACEMENT (PCM) VS 0.6 ADL 68/95 12/95

J000511 FIT TWIN TRACK WATER PUMP PULLEY VR, VS (V8) 0.7 ADL 48/96 07/96

J000532 OIL CONSUMPTION — REPLACE 2 HEADS VS-V6 6.6 ADL 80/96 11/96

J000535 OIL CONSUMPTION — CHECK & REPLACE

HEADS & PISTONS VS-V6 11.4 ADL 80/96 11/96

J000538 OIL CONSUMPTION — CHECK & REFIT

HEADS & REPLACE PISTONS VS-V6 11.4 ADL 80/96 11/96

J000541 REPLACE INCORRECT ENGINE THERMOSTAT TR-L4 0.7 TIB GRP 6A 01/97

J000544 OIL CONSUMPTION — CHECK & REPLACE HEADS

& REPLACE PISTONS VS-V6 11.4 ADL 80/96 11/96

J000547 OIL CONSUMPTION — CHECK & REPLACE HEADS VS-V6 6.6 ADL 80/96 11/96

J000550 OIL CONSUMPTION — CHECK & REPLACE DIPSTICK VS-V6 0.3 ADL 54/97 10/97

OPERATION SPECIAL TASK OPERATION NUMBERS

LAB. OP. MODEL &/OR STD. LETTER GROUP ISSUE

NUMBER OPERATION DESCRIPTION SERIES TIME TYPE /NO. /DATE

SPECIAL OPERATIONS

SECTION No.

WARRANTY

PROCESSING

99-150 — 5

J000553 OIL CONSUMPTION — CHECK HEADS & REFIT VS-V6 7.2 ADL 80/96 11/96

J000556 REPLACE STARTER MOTOR & IGNITION SWITCH SB 1.1 TIB GRP 6Y 1/97

J000559 DTC 72 — RE-ROUTE HARNESS VS-V8 AT 2.0 TIB GRP 12 04/97

J000562 VALVE STEM SEALS & DIP STICK REPLACE VS WITH V6 2.8 ADL 54/97 10/97

J000568 VALVE STEM SEALS, DIP STICK REPLACE &

REPAIR VALVES VS WITH V6 2.8 ADL 54/97 10/97

J000580 ENGINE TORQUE ROD REWORK JR (C20SEL) 0.5 TIB GRP 6A 06/97

J000586 REPLACE AIR FLOW METER CONNECTOR JR 0.5 TIB GRP 6Y 03/98

J000589 FIT REVISED PROM (POLICE) VT, V8 AUTO 0.7 ADL 15/98 04/98

J000595 TORQUE CHECK CRANKSHAFT PULLEY BOLTS VS, VT (V8) 0.3 ADL 35/98 07/98

J000598 TORQUE CHECK CRANKSHAFT PULLEY BOLTS

& REPLACE BROKEN BOLTS VS, VT (V8) 0.7 ADL 35/98 07/98

J000604 PULLEY A/C IDLER ADJUST VT (V8 & A/C) 0.3 TIB GRP 6A 01/99

J000607 FIT V8 HARD RESTART MEMCAL VT (V8) 0.4 TIB GRP 6C 02/99

J000610 RESET ENGINE IDLE SPEED JR, JS 0.6 TIB GRP 6M 08/99

J000616 POWERTRAIN INTERFACE MODULE — REPLACE VT, WH (GEN 3) 0.7 ADL 47/99 07/99

J000622 FIT COLD START HESITATION/STALL OR

HARD START MEMCAL VT (V6 AUTO) 0.4 TIB GRP 6C 07/99

J000631 FIT PCV OIL SEPARATOR JR, JS (C20SEL, C22SEL) 0.8 TIB GRP 6M 10/99

J000636 TAKE-OFF VIBRATION CORRECTION JR (C22SEL A UTO) 1.5 TIB GRP 6A 01/00

J000639 COLD STALL — LIFTER REPLACE SB (C14NZ) 1.3 TIB GRP 6A 01/00

J000654 TORSIONAL DAMPER INSPECTION JR, JS (X25XE) 0.4 ADL 50/00 08/00

J000657 TORSIONAL DAMPER INSPECT AND REPLACE JR, JS (X25XE) 0.7 ADL 50/00 08/00

J000666 REPROGRAM ECU TS (MAN) 0.4 TIB GRP 6C 08/00

J000669 REPROGRAM PCM VT, WH (GEN 3 MAN) 0.4 TIB GRP 6C 08/00

J000678 FIT LACK OF RESPONSE MEMCAL VT, WH (V6 AUTO) 0.4 TIB GRP 6C 10/00

J000681 CROSS OVER PIPE HOSE CLAMPS — REPLACE VT, WH (GEN 3) 0.3 TIB GRP 6K 10/00

J000683 DESTRESS EXHAUST/POWERTRAIN & REFLASH PCM VX, VU, VT,

WH-GEN III AUTO 0.8 T IB GRP 6C & 08 05/01

J000686 REPLACE IACV (ENGINE STALL AT HIGH IDLE SPEED) JR, JS (C20SEL & C22SEL)

TR (X20XEV) 0.6 TIB G RP 6C 02/03

J000689 INTERMITTENT NO START & DCT P1612 OR P1613 TS (Z18XE) 0.4 TIB GRP 6C 09/01

J000690 LEFT HAND OXYGEN SENSOR CONNECTOR WATER VTII, VX, VU, WH

ENTRY (GEN III + AUTO) 0.5 TIB GRP 6C 09/01

J000692 FIT LH O2 SENSOR & RELOCATE HARNESS CONNECTOR VX, VU, WH, VT11,

(GEN III & AUTO) 0.5 TIB GRP 6C 01/02

J000698 INSTALL ALTERNATOR DECOUPLER PULLEY TR (C16SE, C18SEL, X20XEV),

TS (X18XE1, X18XE) 1.0 TIB GRP 6Y 03/03

J000701 CLEAN EGR VALVE & REFLASH ECU XC (Z14XE) 0.7 TIB GRP 6C 11/01

J000704 REPLACE/TIGHTEN REAR ENGINE MOUNT BOLTS TS 0.3 TIB GRP 6A 03/02

J000707 DIAGNOSE/CORRECT DTC P0335 TS (Z18XE) 0.4 TIB GRP 6C 06/03

J000710 REPLACE BUMPERS ON EXISTING ENGINE COVER

SUPPORT BRAKETS VX, VU, V2, VT, WH (GEN III)0.3 TIB GRP 6A 05/02

J000713 REFLASH PCM VTII, WH (LS1 PRE A8A) 0.4 TIB GRP 6A 08/02

J000716 REPAIR A/T SHIFTER & FIT NEW REAR

TRANS MOUNT VX, VU, V2, WH (V6 + A/T) 1.1 TIB GRP 7B 09/02

J000725 FIT ENGINE COVER RATTLE FIX PARTS V&W MODLES (GEN III) 0.3 TIB GRP 6A 08/03

OPERATION SPECIAL TASK OPERATION NUMBERS

LAB. OP. MODEL &/OR STD. LETTER GROUP ISSUE

NUMBER OPERATION DESCRIPTION SERIES TIME TYPE /NO. /DATE

SPECIAL OPERATIONS

SECTION No.

WARRANTY

PROCESSING

99-150 — 6

J000740 CABIN BOOM FROM 80-100 KMH VY REGULAR CAB,

CREW CAB 0.4 TIB GRP 1 11/03

J000749 REPLACE ALT PULLEY (DECOUPLER) VS, VT, VX, VY 0.5 TIB

J000755 FIT AIR SHUTE TO HSV AVALANCHE HSV AVALANCHE 0.3 HSV

J000758 INSPECT AIR SHUTE TO HSV AVALANCHE HSV AVALANCHE 0.7 HSV

J000761 REPLACE CRANKSHAFT BALANCER BOLT VZ 0.6 ADL

K000219 TRANS. SUPT C/MEMBER TORQUE CHECK VR 0.3 ADL 53/94 10/95

K000225 A/T CHANGEOVER VR/VS 3.0 ADL 22/96 03/96

K000234 FIT M/T ANTI-JUMPOUT KIT VS 2.6 TIB GRP 7A 02/96

K000240 REPLACE OIL PUMP COVER VS AUTO 3.5 TIB GRP 7B 07/96

K000243 INSPECT & TIGHTEN END SHIELD BOLTS T R, M/T 0.4 ADL 78/97 12/97

K000246 INSPECT & REPLACE END SHIELD GASKET TR, M/T 2.1 ADL 78/97 12/97

K000252 INSPECT & REPLACE DIP STICK VS, V6 AUTO 0.3 ADL 79/97 12/97

K000255 FIT CLUTCH FLUID LINE DAMPER VT (V8 & MAN) 0.4 TIB GRP 7A 03/99

K000261 FIT HSV NOISE REDUCTION PACKAGE VT (GEN 3 MAN) 0.5 TIB GRP 7A 05/00

K000276 REPLACE 1-2 ACCUMULATOR & REFLASH PCM VX, VUI, WH & A8A

(GENIII & AUTO) 0.8 TIB GRP 7B 02/02

K000279 GLUE GEARSHIFT KNOB TO GEARSHIFT LEVER VTII, VX, VU, V2

(GENIII & MAN) 0.3 TIB GRP 7A 02/02

K000288 FIT MANUAL SHIFTER REINFORCING PLATE GEN III + M/T 2.7 TIB GRP 7A 04/03

K000291 REPLACE TRANSMISSION SHIFTER ASSEMBLY VTII, VX, VU, VY,

V2 (MM6) 1.7 TIB GRP 07A 08/03

K000294 GEAR SHIFTER RATTLE/BUZZ GEN III MANUAL 1 TIB GRP 7A 11/03

L000139 ADD DRAIN PIPE TO CANISTER VR(ALL) 0.3 TIB GRP 08 03/95

L000142 CANISTER REPLACE/ADD DRAIN PIPE VR(UTE) 0.3 TIB GRP 08 03/95

L000145 CANISTER & FUEL TANK REPLACE VR(UTE) 1.7 TIB GRP 08 03/95

L000148 CANISTER REPLACE/ADD DRAIN PIPE VR(NON UTE) 0.3 T IB GRP 08 03/95

L000157 INSPECT FILLER NECK JOINT VS(SED) 0.4 ADL 83/96 11/96

L000160 LPG HEAT SHIELD VS 0.4 ADL 08/97 3/97

L000169 FIT EXH FLEX JOINT & HANGERS TR (C16SE) 1.0 TIB GRP 08 01/98

L000172 FIT EXH FLEX JOINT & HANGERS &

INTERMEDIATE PIPE TR (C16SE) 1.5 TIB GRP 08 01/98

L000175 INSPECT & ADD FUEL FILTER BRACKET SCREW VT 0.3 ADL 40/98 07/98

L000187 CANISTER PURGE HOSE — REPLACE JR, JS (C20, C22, X25) 0.6 TIB GRP 6M 09/00

L000190 FIT REVISE CANSISTER VENT PIPE SB (C14SE) 0.7 T IB GRP 08 10/00

L000211 REPOSITION FUEL TANK VENT LINE TS (Z18XE) 0.3 TIB GRP 08 11/02

L000217 REPLACE FRONT EXHAUST PIPE HEAT SHIELDS WK (GEN III) 0.5 TIB GRP 08 08/03

L000220 CRIMP FRONT EXH HEAT SHIELDS ONLY WK (GEN III) 0.3 TIB GRP 08 08/03

L000223 REPLACE EXHAUST PIPE HEAT SHIELDS WK VY SS (GEN III) 0.5 TIB G RP 08 01/04

L000226 REPLACE FUEL FILLER HOSE AND SEAL B PILLAR VY, VU UTE ONLY 0.9 TIB GRP 08 03/04

L000242 INSTALL WIRE INTO MRA AUXILIARY PIPE VY REGULAR CAB,

CREWCAB 0.9-1.1 TIB GRP 08 05/04

OPERATION SPECIAL TASK OPERATION NUMBERS

LAB. OP. MODEL &/OR STD. LETTER GROUP ISSUE

NUMBER OPERATION DESCRIPTION SERIES TIME TYPE /NO. /DATE

SPECIAL OPERATIONS

SECTION No.

WARRANTY

PROCESSING

99-150 — 7

M000163 STEERING COLUMN — DETERMINE CLAMPING

FORCE WITH SHIMS TS 1.0 ADL 79/98 12/98

M000166 FIT FELT DOT TO RAMP ON STEERING HUB JR, JS 0.6 TIB GRP 09 10/98

M000172 ADD STRAP TO POWERING STEERING HOSE VT, WH (GEN 3) 0.3 TIB GRP 09 01/00

M000175 FIT SRS CAUTION LABEL JM, JP, LE, LF 0.4 ADL 05/00 02/00

M000178 FIT POWER STEERING SPACER WASHER TS 0.4 TIB GRP 09 03/00

M000181 ALIGN POWER STEERING PUMP PULLEY VX, VU, VT,

WH - WITH GEN III 0.7 TIB GRP 6A 05/01

M000184 REBUILD STEERING GEAR JR, JS 3.7 ADL GRP 09 08/03

M000187 REMOVE SRS BAR CODE LABEL VY 0.3 TIB GRP 12 01/03

M000190 ADD TIE STRAP TO STEERING COLUMN

ADJUST SPRING V & W MODELS 0.2 TIB GRP 09 03/03

M000196 INSTALL P/S OIL ADDITIVE ONLY JR,JS 0.2 TIB GRP 09 08/03

M000205 INSTALL REVISED HIGH PRESS POWER STEERING

HOSE (STEERING SHUDDER) VY V6 0.5

N000243 V8 A/C COND. FAN WIRING REWORK VS 0.4 ADL 18/96 03/96

N000252 T/S CANCEL CAM REPLACE VS 0.4 TIB GRP 6Y 2/97

N000258 SENSOR — COOLANT TEMP REPLACE VS WITH V6 0.2 TIB GRP 12 04/97

N000261 RESEAL ALL DOOR HARNESS GROMMETS VT 0.7 ADL 51/97 09/97

N000267 INSTALL DRIVERS SEAT EARTH LEAD VT 0.5 TIB GRP 12 01/98

N000270 TELSTRA HEADLIGHT ON REWORK VS, VT 0.8 ADL 13/98 03/98

N000282 ALTERNATOR WIRING UPGRADE VS (V8) 0.9 TIB GRP 12 05/98

N000285 ALTERNATOR WIRING UPGRADE VS (V6) 1.0 TIB GRP 12 05/98

N000288 INSPECT ABS HARNESS CONNECTOR VT 0.4 TIB GRP 12 05/98

N000291 BATTERY, REMOTE KEY — REPLACE JR 0.2 TIB GRP 12 08/98

N000297 FIT ENGINE EARTH STRAP JR 0.3 TIB GRP 12 07/98

N000300 BATTERY HARNESS UPGRADE VT (V8 + 9C1) 1.4 TIB GRP 12 07/98

ADD: IF SUMP GUARD

FITTED 0.1

N000303 REPLACE GNB BATTERY WITH A CENTURY

YUASA BATTERY VT (V6 + 9C1) 0.3 ADL 61/98 09/98

N000306 FIT INSERTS & SEALS TO DECKLID DECOR VT 1.0 TIB GRP 01 08/98

N000309 FIT RUBBER BUSH TO REAR WIPER MOTOR JS 0.4 ADL 73/98 12/98

N000315 ANTENNA CONNECTION — TIGHTEN TS 0.5 TIB GRP 12 06/02

N000318 RE-PROGRAM SPEEDO VT (EQUIPE) 0.3 ADL 40/99 07/99

N000324 REMOVE GLUE REFIT REAR WIPER MOTOR COVER TS HATCH 0.9 TIB GRP 12 11/01

N000327 FIT REVISED CRUISE CONTROL MODULE MOUNTINGS WH, VX, VT 0.3 TIB GRP 12 11/00

N000333 BATTERY REPLACEMENT – CENTURY YUASA WH, VX, VT (9C1) 0.3 ADL 01/08 01/01

N000336 REPLACE BCM & PATCH HARNESS INSTALLATION VX , VT 0.7 ADL 01/10 03/03

N000339 REPLACE LOW BEAM & FUEL PUMP RELAYS VX, VT, WH 0.3 ADL 43/01 05/01

N000351 REPLACE HAZARD WARNING SWITCH VX, VT, WH 0.4 ADL 43/01 05/01

N000354 CORRECT TAIL LAMP WIRING SHORT VX (WAGON), VU 0.4 TIB GRP 12 06/01

N000360 REPLACE AMBIENT TEMP SENSOR CONNECTOR VT, VX, WH (C61, CJ2) 0.5 TIB GRP 02 11/01

N000363 REWORK BATTERY CABLE AND COOLANT HOSE TS (X18XE1/X18XE) 0.4 TIB GRP 12 05/02

N000366 ROTATE RH REAR SPEAKER V2 0.6 TIB GRP 12 01/02

OPERATION SPECIAL TASK OPERATION NUMBERS

LAB. OP. MODEL &/OR STD. LETTER GROUP ISSUE

NUMBER OPERATION DESCRIPTION SERIES TIME TYPE /NO. /DATE

SPECIAL OPERATIONS

SECTION No.

WARRANTY

PROCESSING

99-150 — 8

N000369 REMOVE SPEED SIGNAL CONVERTOR TS (ABS) 0.2 TIB GRP 12 02/02

N000372 CENTRAL LOCKING MODULE & REMOTES - REPLACE TS (Convertible) 0.6 TIB GRP 12 05/03

N000375 ROOF MODULE - REPLACE TS (CONVERTIBLE) 0.5 TIB

N000378 GLUE HIGH MOUNTED STOP LAMP LED V2 0.4 TIB GRP 12 03/02

N000381 FIT ONE PIECE ANTENNA LEAD TS 1.5 TIB GRP 12 06/02

N000384 REPLACE ELECTRONIC POWER STEERING EARTH LEAD XC 0.9 TIB GRP 12 08/02

N000387 FIT TRICO RR WIPER MOTOR & BRACKET VT, VX (WAGON) 0.7 TIB

N000390 APPLY GREASE TO REAR DOOR HARNESS CONNECTORSTS 0.3 TIB GRP 12 07/02

N000393 REPLACE FUEL TANK SENDER UNIT UES 0.9 TIB GRP 08 07/02

N000396 APPLY GREASE/TIE STRAP TO INSTRUMENT

CLUSTER CONNECT OR XC 0.9 TIB GRP 12 08/02

N000399 REPLACE CHMSL & ROOF MOULDING VUII 0.3 TIB GRP 02 08/02

N000402 TELEMATICS MODULE SOFTWARE UPGRADE VX, WH, V2 SERIES 1 1.0 TIB GRP 12 04/03

N000405 REPLACE TAIL LAMP STUD VY 0.4 TIB GRP 12 10/02

N000408 TELEMATICS MODULE - REPLACE VY 0.6

N000411 UPGRADE FUEL PUMP WIRING HARNESS VY 0.4

N000414 FIT GLOVE BOX LIGHT KIT VY 0.4 TIB GRP 12 01/03

N000417 RE CALIBRATE INSTRUMENT CLUSTER VY (Police vehicles) 0.5 ARL 01/03 12/02

N000420 ANTENNA CONNECTOR TIGHTEN TS (Convertible) 0.6 TIB GRP 12 02/03

N000423 INSTALL SLIP RING PATCH HARNESS VT,VX,VU,V2 (CV6) 0.4 TIB GRP 12 03/03

N000426 DRY WATER OUT OF ANTENNA CONNECTOR VY, V2II 0.4 TIB GRP 12 03/03

N000438 REPROGRAMME TELEMATICS MODULE VY,V2II,WK (UE1) 0.3 TIB GRP 12 08/03

N000441 BCM - REPLACE (VARIATRONIC STEERING FIX) WH,VX,VTII (NV7) 0.8 TIB GRP 12 09/03

N000444 REFIT KEY CAPTURE RELAY TO CIM ZC (AUTO) 0.5 TIB GRP 12 08/03

N000453 REPROGRAM FUEL GUAGE CALIBRATION VYI,VYII,V2II,V2III,WK 0.3 ARL 12/03

N000457 VY UTE REAR DEMISTER REWORK (HBD CANOPY) VYI,VYII 0.7 HBD

N000460 REPLACE ANTENNA CONNECTOR VY, V2, WK 0.5 TIB GRP 12 04/04

N000466 DISMANTLE HORN CONTACTS AND CLEAN XC SRI 0.4 TIB GRP 11 04/04

R000070 REPLACE ANTENNA ROD SB 0.2 TIB GRP 12 07/95

R000073 INSTALL 2 DOOR & 2 RR SPEAKERS SB 1.0 ADL 65/95 11/95

R000082 REROUTE RADIO ANTENNA LEAD JR 0.7 TIB GRP 12 07/98

R000088 FIT 10 DISC CD CHANGER WH 0.8 ADL 32/00 06/00

R000091 CARGO BARRIER TRIM PLUGS — REPLACE VT (WAGON) 0.2 TIB GRP 01 09/00

R000094 FIT TOW BAR ANTI RATTLE SCREW VS, VT, WH 0.4 TIB GRP 01 10/00

R000106 INSPECT RADIO REMOTE SWITCHES &

TRIM HORN BAR VY 0.5 TIB GRP 12 11 /02

R000112 FIT REVISED NUMBER PLATE BRACKET

(TRIPLE M TRAY) VY REGULAR CAB 0.4 TIB GRP 1 09/03

R000115 INSTALL ANTI RATTLE BOLT IN TOWBAR ADVENTURER 0.7 TIB GRP 1 05/04

R000118 ADD SPACER TO CRUISE CONTROL MODULE MOUNT VY, WK 0.3 T IB GRP 12 06/04

R000224 REPLACE REAR SEAL KIT (HARD TONNEAU COVER) VU,VY 0.7 TIB GRP 01 07/04

OPERATION SPECIAL TASK OPERATION NUMBERS

LAB. OP. MODEL &/OR STD. LETTER GROUP ISSUE

NUMBER OPERATION DESCRIPTION SERIES TIME TYPE /NO. /DATE

SPECIAL OPERATIONS

SECTION No.

WARRANTY

PROCESSING

99-150 — 9

S010000 WH STATESMAN/CAPRICE 10,000 KM SERVICE ALL 0.5 WD 15/03 07/03

S020000 WH STATESMAN/CAPRICE 20,000 KM SERVICE ALL 0.8 WD 15/03 07/03

S010000 WK STATESMAN/CAPRICE 10,000 KM SERVICE V6 (LPG), V8 0.5 WD 15/03 07/03

S015000 WK STATESMAN/CAPRICE 15,000 KM SERVICE V6, V6 (SC) 0.7 WD 15/03 07/03

S020000 WK STATESMAN/CAPRICE 20,000 KM SERVICE V8 0.8 WD 15/03 07/03

ADD: V6 (LPG) 0.6

S030000 WK STATESMAN/CAPRICE 30,000 KM SERVICE V6 0.6 WD 15/03 07/03

ADD: V6 (SC) 0.3

FOOTNOTE: ARL = ALL RETAILER LETTER, TIB = TECHNICAL INFORMATION BULLETIN

SB = SERVICE BULLETIN, WD = WARRANTY PROCESSING BULLETIN

SECTION No.

WARRANTY

PROCESSING SEALING, PAINT, DIAGNOSIS, SPECIAL

OPERATIONS, CAMPAIGNS

99-200 — CAMPAIGNS

LAB. CAMPAIGN MODEL &/OR STD. ISSUE

OP. NO. NUMBER DESCRIPTION SERIES TIME DATE

T080101 90-H-01 REMOVE SUNSHADE & SEAL ATTACHING POINTS VN 0.5 07/90

T080102 90-H-01 PAINT & REFIT SUNSHADE VN 2.0 07/90

T080401 90-H-02 INSPECT SECONDARY LATCH LE 0.2 07/90

T080402 90-H-02 INSPECT LATCH & REPLACE HOOD (INCL. PAINT) LE ST 07/90

T080501 90-H-03 REPLACE AIR CLEANER BAFFLE SLE APOLLO JK 0.3 09/90

T080502 90-H-03 REPLACE AIR CLEANER BAFFLE SLE APOLLO JK ST 09/90

T108102 91-H-01 REPLACE RH BRAKE HOSE (INCL. INSPECT) JK 0.6 03/91

T108103 91-H-01 REPLACE LH BRAKE HOSE (INCL. INSPECT) JK 0.6 03/91

T108104 91-H-01 REPLACE BOTH BRAKE HOSES (INCL. INSPECT) JK 1.0 03/91

T180101 91-H-01 BRAKE HOSE INSPECT ONLY (ROUTING CORRECT) JK 0.3 03/91

T180301 91-H-03 INSPECT & REWORK BRAKE PIPE VN,VG,VQ 0.3 05/91

T180302 91-H-03 REPLACE BRAKE PIPE (INCLUDES INSPECT) VN,VG,VQ 1.0 05/91

T180401 91-H-04 INSPECT SPARE WHEEL HOIST CABLE & FIT

COMPRESSION SPRING WASHER & LABEL VG 0.4 10/91

T180402 91-H-04 INSPECT SPARE WHEEL HOIST CABLE & REPLACE,

FIT COMPRESSION SPRING WASHER & LABEL VG 0.5 10/91

T280101 02-H-01 REPLACE LPG SUPPLY LINES VX,VT 2.0 02/02

T280201 92-H-02 INSTALL DOOR LOCK SUB RELAY & PATCH HARNESS JK 0.5 07/92

T280301 02-H-02 INSPECT SEAT RAILS XC 0.5 03/02

T280302 02-H-02 INSPECT & REPLACE ONE SEAT RAILS XC 2.0 03/02

T280303 02-H-02 INSPECT & REPLACE BOTH SEAT RAILS XC 4.0 03/02

T280401 02-H-04 INSPECT TYRE PLACARD TF (8DS62) 0.3

T280699 MRA R/W REPLACE FUEL PUMP MRA WHII, VXII, V2,

VU, (LS1, LN3) 1.1 07/02

ADD: FOR UTE 0.3

T380201 93-H-01 REPLACE BRAKE HOSE BANJO BOLT VP,VQ 0.7 01/93

T380301 93-H-02 CRUISE CONTROL CABLE RETENTION VR 0.4 11/93

T380401 03-H-01 FIT PROTECTIVE SLEEVE TO SEAT HARNESS V2 II 0.8

T380402 03-H-01 REPLACE SEAT HARNESS V2 II 0.9

T380403 03-H-01 INSPECT SEAT FOR HARNESS CLIP V2 III 0.5 12/03

T380404 03-H-01 INSPECT SEAT AND FIT HARNESS CLIP V2 III 0.6 12/03

T480501 94-H-01 DRIVERS SEAT BELT STALK ASSEMBLY INSP/ADJUST VN/VG 0.3 05/94

T480502 94-H-01 DRIVERS SEAT BELT STALK ASSEMBLY INSP/REPLACE VN/VG 0.4 05/94

T480701 94-H-02 TORQUE STEERING WHEEL NUT JM 0.4 06/94

T480801 04-H-01 REPLACE STEERING WHEEL TORX SCREWS XC 0.5 03/04

T480901 04-H-01 REPLACE INCORRECT COMPLIANCE PLATE VY 1 TONNER &

CREWMAN 0.5 04/04

T481001 04-H-03 REPLACE POWER STEERING COOLE HOSES VY, WK 0.5 04/04

T481101 04-H-04 VY RH SEAT SLIDE INSPECTION VY CALAIS 0.5 04/04

T481102 04-H-04 VY RH SEAT SLIDE REPLACE VY CALAIS 1.0 04/04

T580501 95-H-01 JACK REPLACEMENT (YE TURBO) YE (TURBO) 0.8 02/95

T580601 95-H-02 JACK REPLACEMENT (SB & YE NON-TURBO) SB, YE 0.4 02/95

T580701 95-H-03 AIR BAG (SRS) ELECTRICAL CONNECTOR CHECK SB, YE 0.4 03/95

T580901 95-H-04 FRT. SUSP. STRUT TO KNUCKLE ATTACHING BOLTS/INSPECT VS 0.3 07/95

T580902 95-H-04 FRT. SUSP. KNUCKLE ATTACH. BOLTS REPL. VS 1.3 07/95

T581001 95-H-05 WAGON 3RD SEAT ACCESS. PKG. VR 1.0 07/95

T581101 95-H-06 FRONT SEAT TRACK LOCKING MECHANISM JM 0.4 07/95

T581201 95-H-07 THROTTLE CABLE ATTACHING NUT VS 0.5 10/95

T581501 95-H-08 TELSTRA WAGON ROOF RACK VS 0.3 12/95

T680401 96-H-01 A/T OIL COOLER HOSE/CLAMPS VR, VS 0.6 01/96

T680501 96-H-02 HEADLIGHT DIMMER SWITCH JM 1.1 04/96

T680502 96-H-02 HEADLIGHT DIMMER SWITCH (+ HARNESS) JM 1.3 04/96

T680701 96-H-03 A/T OIL CONTAINMENT (WITH TOW BAR) VR, VS 0.5 11/96

99-200 — 2

SEALING, PAINT, DIAGNOSIS, SPECIAL

OPERATIONS, CAMPAIGNS

CAMPAIGNS

SECTION No.

WARRANTY

PROCESSING

T680702 96-H-03 A/T OIL CONTAINMENT (WITHOUT TOW BAR) VR, VS 0.5 11/96

T780704 97-H-02 REPLACE FUEL HOSE & AUXILIARY POWER HARNESS

POSITIONING CLIPS VS, V8 (POLICE) 1.0 08/97

T880201 98-H-01 INSPECT & REPLACE SEAT MOTO R HARNESS VT (POLICE) 1.3 03/98

T880202 98-H-01 INSPECT SEAT MOTOR HARNESS & FIT TUBING VT (POLICE) 0.7 03/98

T880701 98-H-02 PROOF TEST BRAKE PEDAL VT 0.5 05/98

T880702 98-H-02 PROOF TEST & REPLACE BRAKE PEDAL VT 2.0 05/98

T880901 98-H-03 INSPECT & SEAL HEADLAMP PATCH HARNESS CONNECTOR VR, VS 0.5 10/98

T880902 98-H-03 INSPECT, REPLACE & SEAL HEADLAMP PATCH

HARNESS CONNECTOR VR, VS 1.0 10/98

T880903 98-H-03 INSPECT & REPLACE HEADLAMP PATCH HARNESS

& SEAL CONNECTOR VR, VS 0.5 10/98

T881001 98-H-04 REPLACE BRAKE FLUID RESERVOIR CAP & BLEED SYSTEM JR 0.5 10/98

T889902 98-H-05 REPLACE BRAKE FLUID RESERVOIR CAP & BLEED SYSTEM JS 0.5 10/98

T980401 99-H-01 INSPECT REAR SUSPENSION CONTROL ARMS JS 0.5 02/99

T980402 99-H-01 INSPECT REAR SUSPENSION CONTROL ARMS &

REPLACE RH LOWER ARM JS 1.0 02/99

T980403 99-H-01 INSPECT REAR SUSPENSION CONTROL ARMS &

REPLACE LH LOWER ARM JS 1.0 02/99

T980404 99-H-01 INSPECT REAR SUSPENSION CONTROL ARMS &

REPLACE RH UPPE R ARM JS 0.8 02/99

T980405 99-H-01 INSPECT REAR SUSPENSION CONTROL ARMS &

REPLACE LH UPPER ARM JS 0.8 02/99

T980801 99-H-02 INSPECT BOTH FRONT SEAT HARNESSES FOR SLEEVES VT 0.4 03/99

T980802 99-H-02 INSPECT & REPLACE RH FRONT SEAT HARNESS VT 0.8 03/99

T980803 99-H-02 INSPECT & REPLACE LH FRONT SEAT HARNESS VT 0.8 03/99

T980804 99-H-02 INSPECT & REPLACE BOTH FRONT SEAT HARNESSES VT 1.2 03/99

T980901 99-H-03 REWORK CHILD SEAT ANCHORAGE JS HATCH 1.1 04/99

T981001 99-H-04 INSPECT SRS MODULE VT 0.8 04/99

T981002 99-H-04 INSPECT AND REPLACE SRS MODULE VT 1.0 04/99

T981201 99-H-05 INSPECT POWER STEERING GEAR VT 0.5 07/99

T981202 99-H-05 INSPECT & REPLACE POWER STEERING GEAR VT 2.5 07/99

T981301 99-H-06 REPLACE FRONT SUSPENSION/STEERING KNUCKLES VT 2.5 11/99

T981401 99-H-07 REPLACE BOTH REAR SEMI TRAILING ARMS VT 4.0 11/99

T080801 00-H-01 CHECK & ENABLE SRS WARNING LAMP VT (GTS) 0.7 09/00

T080901 00-H-02 HOSE, FUEL FEED TO ENGINE — REPLACE VT, VS 1.0 12/00

T080902 00-H-02 HOSE, FUEL FEED TO ENGINE – INSPECT VT,VS

(5.0L,5.7L) 0.2 12/00

T180501 01-H-01 FIT SEAT RAIL REINFORCEMENT TO PASSENGER SEAT SB 0.3 02/01

T180502 01-H-01 FIT SEAT RAIL REINFORCEMENT TO BOTH SEATS SB 0.4 02/01

T180503 01-H-01 INSPECT SEAT RAIL REINFORCEMENT BOTH SEATS SB 0.2 02/01

T180601 01-H-02 REPLACE BOTH FRONT SEAT BELT BUCKLES SB 1.1 02/01

T180602 01-H-02 INSPECT BOTH FRONT SEAT BELT BUCKLES SB 0.2 02/01

T180801 01-H-04 REPLACE TOW BAR TONGUE VX,VT,VU,WH,TS 0.4 11/01

SECTION No.

WARRANTY

PROCESSING SEALING, PAINT, DIAGNOSIS, SPECIAL

OPERATIONS, CAMPAIGNS

99-300 — 1 REQUEST FOR REVIEW FORMS

FORM No. 2000-3-996

REQ UEST FOR REVIEW

ZONE OFFICE: ......................................................... DATE: ......................................................................

(LOCATION)

FROM: DEALER NAME: ........................................... DEALER CODE: .....................................................

CITY/TOWN: ............................................................. STATE: ....................................................................

WE REQUEST THAT THE TIME ALLOW ANCE FOR THE FOLLOWING OPERATION BE REVIEWED.

OPERATION NUMBER: ............................................ TIME ALLOWANCE (HRS): ....................................

NAME OF OPERATION: ......................................................................................................................................

SUGGESTED TIME ALLOWANCE: ....................... (HRS) REFERENCE NO: ...........................................

(HOLDEN’S OFFICE USE ONLY)

SIGNED: ................................................................... TITLE: .....................................................................

PRINT YOUR NAME HERE: ...............................................................................................................................

ON COMPLETION — MAIL THI S FORM TO Y OUR ZONE FIXED OPERATIONS MANAGER, FIELD

EXEC U TIVE OR D.S.M.

VEHICLE IDENTIFICATION

MODEL & YEAR: ...................................................... ENGINE NO: ...........................................................

VEHICLE SERIAL NO. - V.I.N.: ............................................................................................................................

ACCESSORIES AND OPTIONS WHICH ALSO AFFECT THIS OPERATION

..............................................................................................................................................................................

ON THE BACK OF THIS SHEET, DESCRIBE IN DETAIL EXACTLY HOW THE OPERATION WAS

PERFORMED, WHAT SPECIAL TOOLS AND EQUIPMENT WERE USED AND WHAT STEPS, IF ANY,

PRESENTED A SPECIFIC PROBLEM.

* THIS FORM MUST ALSO BE USED TO REQUEST THE ADDITION OF AN OPERATION TO THE LABOUR

TIME GUIDE.

SECTION No.

WARRANTY

PROCESSING

DESCRIPTION OF WORK PERFORMED

IN ORDER TO ADEQUATELY EVALUATE AND TAKE ACTION ON YOUR STANDARD TIME CHANGE

REQUEST, WE MUST HAVE A DETAILED DESCRIPTION OF EACH MAJOR STEP REQUIRED TO

PERFORM THE OPERATION. THE STATEMENT ‘FOLLOWED SHOP MANUAL PROCEDURE’ IS NOT

SUFFICIENT EXPLANATION SINCE THE ORIGINAL SHOP MANUAL PROCEDURE MAY HAVE

BEEN REVISED IN LATER SERVICE PUBLICATIONS.

TIME TAKEN

STEP NO. IN MINUTES

1/ ...........................................................................................................................................................................

2/ ...........................................................................................................................................................................

3/ ...........................................................................................................................................................................

4/ ...........................................................................................................................................................................

5/ ...........................................................................................................................................................................

6/ ...........................................................................................................................................................................

7/ ...........................................................................................................................................................................

ACTUAL TIME REQUIRED TO PERFORM OPERATION IN OUR SHOP: (MORE THAN ONE STUDY WHEN

POSSIBLE)

FIRST TIME STUDY: ..................................... (HRS) SECOND TIME STUDY: .............................. (HRS)

THIRD TIME STUDY: .................................... (HRS)

COMMENTS: .......................................................................................................................................................

..............................................................................................................................................................................

TO BE COMPLETED BY HOLDEN L IMITED

ZONE REPRESENTATIVE COMMENTS: ...........................................................................................................

..............................................................................................................................................................................

I HAVE REVIEWED THE REQUEST AND AGREE THAT THE LISTED OPERATION SHOULD BE REVIEWED

BY CENTRAL OFFICE SERVICE DEPARTMENT.

SIGNED: ................................................................... DATE: ......................................................................

(ZONE FIXED OPERATIONS MANAGER, FIELD EXECUTIVE, OR DSM)

REQUEST FOR REVIEW FORMS

FORM No. 2000-3-996

SEALING, PAINT, DIAGNOSIS, SPECIAL

OPERATIONS, CAMPAIGNS

99-300 — 2