holden
.wiki
Home
Main Menu
Home
Main Menu
MODEL SELECTION INDEX
SERVICE TECHLINES - MENU
1999 - SERVICE TECHLINES
GROUP 0B - GENERAL
MONTEREY BULL BAR - MONTEREY/ JACKAROO
REGISTRATION PLATE RATTLE - WH
SERVICING DOOR CHECK LINKS - VT II, WH
SERVICE SCHEDULE REVISION - UES FRONTERA
SERVICE INFORMATION IN-DEALERSHIP PROCESS - ALL
GROUP 1 - BODY
HINT: PREVENTING FRONT SEAT SIDE OUTER COVERS CRACKING - VT
CREAK FROM LOWER LHS DASH - VT
CREAK FROM THE RH LOWER CORNER WINDSCREEN AREA SERVICE RECTIFICATION - VT
WATER STAINED HEADLINING - VT
CHASSIS PLUGS - FRONTERA
FRONT DOOR CHECKLINK NOISE - VT, JR, JS
DOORS HARD TO OPEN USING EXTERIOR DOOR HANDLE - VT
WATER LEAK – WAGON REAR LOAD COMPARTMENT - VT
HINT: KNOCK/CREAK FROM FOOTWELL AREA - VT
OVERSLAM OF THE DECK LID CAUSING PAINT REMOVAL FROM REAR BUMPER - VT, WH
WATER LEAK INTO CABIN AREA – DOOR BELT LINE END CAPS - VT
FRONT DOOR GLASS NOT FULLY COVERED BY DOOR GLASS WEATHER STRIP SEALING LIP - VT
HEAD RESTRAINT RATTLE - VT
FRONT SEAT RECLINER SHAFT AND KNOB INSTALLATION - VT
FRONT SEAT ROCKING - VT
JR/JS- FRONT SEAT HEIGHT ADJUSTER CREAK - JR, JS
DECKLID BOUNCES AFTER OPENING - JR/JS (SEDAN)
REGULAR SUNROOF DRAINAGE MAINTENANCE - VT
CENTRE REAR SEAT UNABLE TO RETURN TO THE UPRIGHT POSITION - VT WAGON
FUEL FILLER DOOR NOT OPENING - VT, WH
TICK NOISE FROM DASH PANEL AREA - VT, WH
“CREAK” OR “RATTLE” NOISE FROM ROOF AREA - JR
REAR WINDSCREEN MOULDING DISTORTION (SERVICE HINT) - VT
GROUP 2 - HEATING & A/COND.
VIBRATION OR RUMBLE FROM V8 A/C COMPRESSOR – BRACE - VT V8
EXCESSIVE PAG OIL IN A/C SYSTEM CAUSING FAST CYCLING OF THE A/C COMPRESSOR - VT
RODEO FAN MOTOR / RESISTOR FAILURE - 1999 RODEO
RODEO 4X4 & 4X2 AIR CONDITIONER KITS INTERCHANGEABILITY - 1999 RODEO
SERVICE MANUAL CORRECTION - A/C SUCTION/DISCHARGE HOSE ASSEMBLY SECURING NUT TORQUE - VT
BLOWER MOTOR RESISTOR FAILURE - VT
AIR CONDITIONING INFORMATION - 1999 FRONTERA
POOR HEATER PERFORMANCE VT & WH WITH ECC
A/C COMPRESSOR, REPEAT FAILURES - 1994 GMC AMBULANCE
NEW A/C KIT FOR DIESEL 2000 MODEL YEAR RODEO - RODEO
REFRIGERANT CHARGE QUANTITY - TF RODEO
WHISTLE NOISE FROM HVAC FRESH/RECIRC DOOR - VT
GROUP 3 - FRONT SUSPENSION
VEHICLE VEERS LEFT - VT
GROUP 4 - REAR SUSPENSION
LSD “CHATTER” NOISE - VT WITH LSD (March 99)
LSD "CHATTER" NOISE - VT WITH LSD (Nov 99)
GROUP 5 - BRAKES
HINT: DIAGNOSING ABS WHEEL SPEED SENSOR DTC’S 21, 23, 25, 27 - VT
BRAKE SHUDDER – RECOMMENDED SERVICE PROCEDURES FOR DISC MACHINING & INSTALLATION - VT
BRAKE SHUDDER – RECOMMENDED SERVICE PROCEDURES FOR DISC MACHINING, INSTALLATION & PAD REPLACEMENT - VT
ON-CAR HUB MOUNTED BRAKE LATHES - ALL
ABS BRAKE BLEEDING - SB, TR, TS, JR, JS
BRAKE PAD BEDDING IN PROCEDURE - VT, WH
ABS MODULATOR SPRING PLATES DELETION - VT, WH, JS, JS, YE
REAR BRAKE SQUEAL NOISE - TS
GROUP 6A - ENGINE
PULLEY TO CRANKSHAFT BOLT REPLACEMENT - SB, TS (ALL ENGINES)
ENGINE DRIVE BELT SQUEAL NOISE - VT V8 & A/C
ENGINE STALL CHECK LIST - SB (C14NZ)
PULLEY TO CRANKSHAFT BOLT REPLACEMENT - SB, TR, TS, JR, JS, YE, UT (All Engines)
REAR MAIN OIL SEAL HOUSING REPLACEMENT REQUIREMENT - VS V6 & VT V6
ENGINE OIL PAN SEALANT - TS
4JX1 FLYWHEEL SETUP PROCEEDURE - JACKAROO
4JX1 ENGINE OIL SPECIFICATION - JACKAROO
4JX1- TC MODIFIED TURBOCHARGER AND HOSE - JACKAROO
4JX1 - TC JACKAROO DIESEL SECOND OIL FILTER - JACKAROO
ENGINE REPAIR RECOMMENDATION - ALL MODELS
OIL LEAK DIAGNOSIS - ALL MODELS
VALVE CLEARANCE SHIM CALCULATION - 4JX1 JACKAROO
ENGINE COVER RATTLE NOISE - VT, WH with LS1 GEN III
GROUP 6C - ENGINE MANAGEMENT
TECH 1 & TECH 2 USAGE SERVICE HINT - VS V8 P.O. LB9, XT9
ENGINE – NO RESTART AFTER STOP - VT V8 with A/T
ENGINE MANAGEMENT CALIBRATION - DIAGNOSIS HINT - SB, JR, JS, TS
ENGINE ROUGH IDLE ( Diagnosis Hint) - TS
DTC P0706 (PRNDL) – FALSELY SETS VT, WH with Gen III (5.7l) Engine & A/T
HARD START ON LPG - VT, V6 & A/T (LPG)
COLD START HESITATION or STALL - VT, V6 & A/T (Petrol)
DTC P0115 - ENGINE COOLANT TEMPERATURE SENSOR VOLTAGE HIGH - TS
DTC P0327 SETTING - KNOCK SENSOR SENSITIVITY REVISION - VT, WH with LS1 GEN III
ECU RESETTING PROCEDURE - TS
GROUP 6K - ENGINE COOLING
REVISED ENGINE COOLING FAN OPERATION - VT with V6 (non-S/C)
RADIATOR HOSE ABRASION - VT V6
DRIVE BELT TENSIONER REPLACEMENT - TC/TK Light Truck (Ambulance) with 6.5 Litre Turbo Diesel - MY 1996 onwards
REVISION OF COOLING SYSTEM - 2.2 TF RODEO
DTC P0115 - ENGINE COOLANT TEMPERATURE SENSOR VOLTAGE HIGH TS
GROUP 6M - ENGINE FUEL SYSTEM
ENGINE STALL - TR, JR (4 Cyl.)
ENGINE STALL - JR & JS; 4Cyl. Engines
4JX1 INJECTOR CALIBRATION - JACKAROO
FUEL SYSTEM SPECIAL REMOVAL TOOL - VT, WH
INJECTION TIMING ADJUSTMENT - RODEO with 4JB1T
REVISED ENGINE CRANKS BUT WILL NOT RUN PROCEDURE - JACKAROO with 4JX1T
ENGINE STALL ON DECELERATION OR HIGH ENGINE IDLE - JR, JS C20SEL, C22SEL
WHISTLE NOISE FROM ENGINE BAY - JR, C20SEL; JS, C22SEL
ENGINE STALL ON DECELERATION OR HIGH ENGINE IDLE - JR, JS with C20SEL or C22SEL Engine
GROUP 6Y - ENGINE ELECTRICAL
SPARK PLUG LEAD REVISIONS - VT & VS
ENGINE MISFIRE/KNOCKING SOUND HINT - VT with V8
MISFIRE OR SPARK PLUG LEAD DAMAGE DURING ASSEMBLY - VS, VT
SPARK PLUG SERVICING - VT II & WH, Gen III Engine
SPARK PLUG USAGE CORRECTION - VS, VT, WH with S/C V6
4JX1 - TC QUICK WARM UP SYSTEM - JACKAROO
SPARK PLUG LEAD REPLACEMENT - VT, VS with S/C V6
GROUP 7A - MANUAL TRANSMISSION AND CLUTCH
DECLUTCH GROWL NOISE - VT with V8 & M/T
OIL LEAK DIAGNOSIS - ALL MODELS
SPECIFIC OIL LEVEL CHECKING & REFILLING PROCEDURE - JS Series II (F23 M/T)
M/T OIL SPEC. REVISION - JS, JR, TS, SB (GSI)
M/T SERVICE INFORMATION - VT with LS1 GEN III
GROUP 7B - AUTOMATIC TRANSMISSION
A/T “DEEP” PAN & FILTER SERVICING - VS A/T
CLUNK” WHEN SELECTING “PARK” FROM THE CONSOLE AREA - VT with A/T
OIL LEAK DIAGNOSIS - ALL MODELS
4L30E AUTOMATIC TRANSMISSION FLUID LEVEL CHECKING PROCEDURE - JACKAROO, RODEO, FRONTERA
GROUP 8 - FUEL TANK & EXHAUST
KNOCK NOISE FROM EXHAUST ON COLD START - JR, LS 4 Cyl.
FUEL FILLER - RODEO CREW CAB
EXHAUST HEAT INSULATORS - FITTING INFORMATION - VT, WH
GROUP 9 - STEERING
HINT: SQUEAK FOM STEERING GEAR INPUT SHAFT SEAL - JR
STEERING COLUMN INSTALLATION PROCEDURE - TS
TILT/REACH HANDLE INSTALLATION PROCEDURE SERVICE MANUAL REVISION - VT , WH
SERVICE MANUAL REVISION – STEERING GEAR TO CROSS MEMBER MOUNTING NUT TORQUE - VT, WH
GROUP 10 - WHEELS & TYRES
FLATSPOTTING OF TYRES - ISUZU ALL
GROUP 12 - ELECTRICAL GENERAL
REVISED ALTERNATOR B+ NUT, STARTER MOTOR NUT - VS, VT
IGNITION SWITCH FAILURE - TS
POOR “AM” RADIO RECEPTION - TS
INSTRUMENT CLUSTER WITH CHECKSUM ERROR-DTC 24 - VT
ENGINE COOLING DIAGNOSTIC LAMP ILLUMINATES – FUSE 8 BLOWS - TS
NO START – LACK OF FUEL PRESSURE - VT
JACKAROO ANTI THEFT & IMMOBILISER - JACKAROO
SIDE AIR BAG DIAGNOSIS (VERSION 8.1) - VT
JACKAROO IMMOBILISER - JACKAROO
BRAKE LIGHT / CRUISE CONTROL MALFUNCTION - TS ASTRA
SPEEDO “PPK” PROGRAMMING - VT
SIDE AIR BAG CONNECTOR DAMAGE - VT
EMBEDDED SECURITY SYSTEM - HSV- VT SERIES II and WH
RESETTING SERVICE REMINDER FUNCTION - VT SERIES II
SDM MODULE CONNECTOR COVER - VT
IGNITION BARREL STICKING - VT, VT SERIES II
4JX1-TC DIESEL JACKAROO RADIO FILTER KIT - JACKAROO
REMOTE KEY INOPERATIVE - JR MY97’, JS MY98’
ENGINE COOLING DIAGNOSTIC LAMP ILLUMINATES - FUSE 8 OR 4 BLOWS - TS
MULTI INFO DISPLAY UNIT (MID), CODE INDEX PROGRAMMING - JS SERIES II, C22SEL
PROGRAM INDEX CODES - SB, TR, TS, JR, JS
INTERIOR LAMP/S REMAIN ON WITH DOORS CLOSED - WH, VT
BOOT REMOTE (KEY) OPENING DELAY - VT, WH
