holden.wiki

• MODEL SELECTION INDEX
• SERVICE TECHLINES - MENU
• 2005 - SERVICE TECHLINES
  • GROUP OB - GENERAL INFORMATION
    • Tech 2, TIS 2000 Model Year Selection - All Models
    • Fluid Leak Diagnosis Using Black Light And Dye - All Models
    • Holden Contacts and procedures - All Models
    • Finding D.T.C’s on LCV SIP - All LCV Models
    • Tis 2000 and Tech 2 ECU Programming Terminology
    • TIS 2000 Security Access and SPS Issues Due To Hardware Key Incompatibility With New PC - All Models
    • TIS Approval with Tech 2 - All Vehicle Types
    • Checking TIS 2000 Version Number
    • Techline Correction “Fuel Gauge Reads Empty With 25 Litres Left In The Tank – RA Diesel”
    • Searching for Techlines, Dealer Letters etc. on Holden Lionheart (Portal)
    • TIS 2000 VIN validation failed message
    • TAS Vehicle Call Groups
    • Requesting Immobiliser Security Codes - All Models
    • Tech 2 Custom Downloads - All
    • Fuel Filler Neck Modification Required on New Vehicles Being Fitted With a Tray - RA Rodeo Long Wheelbase with Petrol engine
  • GROUP 1 - BODY
    • Seat Belts Replaced For Complaint Of Not Extending - UES Frontera, YG Cruze, RA Rodeo
    • Seat Belts Replaced For Complaint Of Not Extending - UES Frontera, YG Cruze, RA Rodeo
    • Use of Correct Adhesives For Fixed Glass - All Vehicles
  • GROUP 2 - HEATING & A/COND.
  • GROUP 3 - FRONT SUSPENSION
  • GROUP 4 - REAR SUSPENSION
    • Explanation of Driveline “Clunk” or “Backlash Noise"
    • Rear Limited Slip Differential Operation – Driving Hint - RA Rodeo, UBS Jackaroo
  • GROUP 5 - BRAKES
    • Brake Light Stays On
    • ABS Light Flashing After ABS Module Replacement - YG Cruze
  • GROUP 6A - ENGINE
    • Engine Vibration / Drone Noise at 2500-3000 RPM - RA Rodeo Diesel 4JH1 With A/C
    • Turbocharger Diagnosis / Oil Seep From Intake Ducts - RA Rodeo - 4JH1 TC, UBS Jackaroo 4JX1
    • Poor Performance Due To Plug Dislodging From Rear Of The Intake Manifold - RA with 3.0L 4JH1 Diesel Engine
    • Oil Rail Draining Procedure - UBS Jackaroo with 4JX1 Diesel engine
    • Flywheel Timing Procedure - UBS Jackaroo 4JX1 Diesel
    • Oil Refill Capacity - TF & RA Rodeo - 4JH1 TC
    • Oil Consumption - Catalytic Converter Replacement - RA with V6 Engine
  • GROUP 6C - ENGINE MANAGEMENT
    • Engine Surge or Low Power After Engine or Gearbox Repair - RA Rodeo 3.5 L 6VE1
    • Accelerator sensitivity at slow speeds and over rough terrain - RA ROdeo 4JH1-TC Diesel with Manual transmission
    • Hard Start or No start
    • Poor Engine Performance After Driving Through Water or Washing Engine - RA with 3.0L 4JH1 Diesel Engine
    • DTC P0107 – MAP Sensor Circuit Low Voltage - UBS 4JX1
    • MAP Sensor Blocked With Carbon - UBS - 4JX1
    • Preliminary Checks for Complaint of Low Power - RA Rodeo with 4JH1 diesel engine
  • GROUP 6M - ENGINE FUEL
    • Leak Testing Injectors in 4JX1 Engine - UBS Jackaroo & Monterey
    • Ethanol Fuel Usability - All Post - 1986 Holden Vehicles
  • GROUP 7A - MANUAL TRANSMISSION
    • Manual Transmission Front Countershaft Roller Bearing Noisy - RA Rodeo with M/T
    • Manual Transmission Rattle Noise in Nuetral at idle - RA 4JH1 Diesel with M/T
    • Manual Transmission Rattle Noise in Neutral at Idle - RA 4JH1 Diesel with M/T
  • GROUP 7B - AUTOMATIC TRANSMISSION
    • Release of Dexron III (“H” Revision) Automatic Transmission Fluid (ATF) - All models with A/T
    • Cracked Flex Plate Caused By Missing Dowel - Pins - RA Rodeo with Auto. Trans
  • GROUP 8 - EXHAUST SYSTEM
    • Muffler Cracks at inlet and outlet pipes - RA Rodeo V6 Petrol Engine
    • Check 4WD Light Illuminated - RA Rodeo
    • Oil Consumption - Catalytic Converter Replacement - RA with V6 Engine
  • GROUP 9 - STEERING
    • Noise From Steering (Tie Rod Inner Ball Joint Wear) - RA Rodeo
  • GROUP 10 - WHEELS & TYRES
  • GROUP 12 - CHASSIS ELECTRICAL
    • First Steps In Electrical Problem Diagnosis (Check Earth Points) - RA Rodeo (and other models)
    • Location of Mobile Phone Wiring Connector - RA Rodeo
    • Erratic Tachometer Operation, and/or 4WD Not Operating (if fitted) RA Petrol or Diesel
    • Towbar Harness Breakout Revision - RA Rodeo Fitted With Genuine Accessory Tow Bar