holden.wiki

• MODEL SELECTION INDEX
• RA RODEO
• SECTION 6E - Y24SE ENGINE DRIVEABILITY AND EMISSIONS
  • ABBREVIATIONS CHARTS
  • COMPONENT LOCATOR
  • ECM CIRCUIT DIAGRAM
  • GROUND POINT CHART (1/4)
  • LOCATION
  • CABLE HARNESS & CONNECTOR LOCATION
  • CONNECTOR LIST
  • RELAY AND FUSE
    • RELAY AND FUSE BOX LOCATION
    • RELAY AND FUSE BOX LOCATION
    • FUSE AND RELAY LOCATION
  • ECM WIRING DIAGRAM (1/8)
  • ECM WIRING DIAGRAM (2/8)
  • ECM WIRING DIAGRAM (3/8)
  • ECM WIRING DIAGRAM (4/8)
  • ECM WIRING DIAGRAM (5/8)
  • ECM WIRING DIAGRAM (6/8)
  • ECM WIRING DIAGRAM (7/8)
  • ECM WIRING DIAGRAM (8/8)
  • ECM CONNECTOR PIN ASSIGNMENT & OUTPUT SIGNAL
  • GENERAL DESCRIPTION FOR ECM AND SENSORS
    • Engine Control Module (ECM)
    • Manifold Absolute Pressure (MAP) Sensor
    • Throttle Position Sensor (TPS)
    • Idle Air Control (IAC) Valve
    • Crankshaft Position (CKP) Sensor
    • Knock Sensor (KS)
    • Engine Coolant Temperature (ECT) Sensor
    • Intake Air Temperature (IAT) Sensor
    • Vehicle Speed Sensor (VSS)
    • Heated Oxygen (O2 Pre) Sensor
    • Heated Oxygen (O2 Post) Sensor
    • Vertical G (RRID) Sensor
  • GENERAL DESCRIPTION FOR FUEL METERING
    • Battery Voltage Correction Mode
    • Clear Flood Mode
    • Deceleration Fuel Cut Off (DFCO) Mode
    • Engine Speed/ Vehicle Speed/ Fuel Disable Mode
    • Acceleration Mode
    • Fuel Cut Off Mode
    • Starting Mode
    • Run Mode
    • Fuel Metering System Components
    • Fuel Injector
    • Fuel Pressure Regulator
    • Fuel Rail
    • Fuel Pump Electrical Circuit
    • Thottle Body Unit
  • GENERAL DESCRIPTION FOR ELECTRIC IGNITION SYSTEM
    • Spark Plug
  • GENERAL DESCRIPTION FOR EVAPORATIVE EMISSION SYSTEM
    • EVAP Emission Control System Purpose
    • EVAP Emission Control System Operation
    • System Fault Detection
  • POSITIVE CRANKCASE VENTILATION (PCV) SYSTEM
    • Crankcase Ventilation System Purpose
  • A/C CLUTCH DIAGNOSIS
    • A/C Clutch Circuit Operation
    • A/C Clutch Circuit Purpose
    • A/C Request Signal
  • HOLDEN STRATEGY BASED DIAGNOSTICS
    • Overview
  • STRATEGY BASED DIAGNOSTICS CHART
    • Diagnostic Thought Process
    • 1. Verify the Complaint
    • 2. Perform Preliminary Checks
    • 3. Check Bulletins and Troubleshooting Hints
    • 4. Perform Service Manual Diagnostic Checks
    • 5a and 5b. Perform Service Manual Diagnostic Procedures
    • 5c. Technician Self Diagnoses
    • 5d. Intermittent Diagnosis
    • 5e. Vehicle Operates as Designed
    • 6. Re-examine the complaint
    • 7. Repair and Verify Fix
  • GENERAL SERVICE INFORMATION
    • On-Board Diagnostic (OBD)
    • On-Board Diagnostic Tests
    • The Diagnostic Executive
    • Diagnostic Information
    • Malfunction Indicator (Check Engine) Lamp
    • Data Link Connector (DLC)
    • Verifying Vehicle Repair
    • Reading Diagnostic Trouble Codes Using a Tech 2
    • Diagnosis With Tech 2
    • Tech 2 Operating Flow Chart (Start Up)
    • TYPICAL SCAN DATA & DEFINITIONS (ENGINE DATA 1)
    • F3: ACTUATOR TEST
    • F6: ECU Control
    • F0: Injector Cutoff Test
  • PLOTTING SNAPSHOT GRAPH
    • Plotting Graph Flow Chart (Plotting graph after obtaining vehicle information)
    • Flow Chart for Snapshot Replay (Plotting Graph)
  • SNAPSHOT DISPLAY WITH TIS2000
  • SERVICE PROGRAMMING SYSTEM (SPS)
  • HOW TO USE BREAKER BOX
    • Breaker Box Connection Type A
    • Breaker Box Connection Type B
  • ON-BOARD DIAGNOSTIC (OBD) SYSTEM CHECK
    • Circuit Description
    • Diagnostic Aids
    • Test Description
  • ON-BOARD DIAGNOSTIC (OBD) SYSTEM CHECK
  • NO CHECK ENGINE LAMP (MIL)
    • Circuit Description
    • Diagnostic Aids
    • No Check Engine Lamp (MIL)
  • CHECK ENGINE LAMP (MIL) “ON” STEADY
    • Circuit description
    • Diagnostic Aids
    • Check Engine Lamp (MIL) “ON” Steady
  • NO SERVICE VEHICLE SOON LAMP (SVS)
    • Circuit Description
    • Diagnostic Aids
  • NO SERVICE VEHICLE SOON LAMP (SVS)
  • SERVICE VEHICLE SOON (SVS) “ON” STEADY
    • Circuit description
    • Diagnostic Aids
    • SERVICE VEHICLE SOON (SVS) “ON” STEADY
  • FUEL METERING SYSTEM CHECK
  • FUEL INJECTOR COIL TEST PROCEDURE AND FUEL INJECTOR BALANCE TEST PROCEDURE
    • Test Description
    • Injector Coil Test Procedure (Steps 1-6) and Injector Balance Test Procedure (Steps 7-11)
    • Injector Coil Test Procedure (Steps 1-6) and Injector Balance Test Procedure (Steps 7-11)
  • FUEL SYSTEM ELECTRICAL TEST
    • Circuit Description
    • Diagnostic Aids
    • Fuel Pressure Relief Procedure
    • Fuel Pressure Gauge Installation
    • Fuel System Electrical Test
  • FUEL SYSTEM DIAGNOSIS
    • Circuit Description
    • Test Description
    • Fuel Pressure Relief Procedure
    • Fuel Pressure Gauge Installation
    • Fuel System Diagnosis
  • ECM DIAGNOSTIC TROUBLE CODES (DTC)
  • DTC DIAGNOSTIC TABLE
  • DIAGNOSTIC TROUBLE CODE (DTC) P0107 MANIFOLD ABSOLUTE PRESSURE CIRCUIT LOW INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0107 Manifold Absolute Pressure Circuit Low Input
  • DIAGNOSTIC TROUBLE CODE (DTC) P0108 MANIFOLD ABSOLUTE PRESSURE CIRCUIT HIGH INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0108 Manifold Absolute Pressure Circuit High Input
  • DIAGNOSTIC TROUBLE CODE (DTC) P0112 INTAKE AIR TEMPERATURE SENSOR LOW INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0112 Intake Air Temperature Sensor Low Input
  • DIAGNOSTIC TROUBLE CODE (DTC) P0113 INTAKE AIR TEMPERATURE SENSOR HIGH INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0113 Intake Air Temperature Sensor High Input
  • DIAGNOSTIC TROUBLE CODE (DTC) P0117 ENGINE COOLANT TEMPERATURE SENSOR LOW INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0117 Engine Coolant Temperature Sensor Low Input
  • DIAGNOSTIC TROUBLE CODE (DTC) P0118 ENGINE COOLANT TEMPERATURE SENSOR HIGH INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0118 Engine Coolant Temperature Sensor High Input
  • DIAGNOSTIC TROUBLE CODE (DTC) P0122 THROTTLE POSITION SENSOR LOW INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0122 Throttle Position Sensor Low Input
  • DIAGNOSTIC TROUBLE CODE (DTC) P0123 THROTTLE POSITION SENSOR HIGH INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0123 Throttle Position Sensor High Input
  • DIAGNOSTIC TROUBLE CODE (DTC) P0131 O2 SENSOR CIRCUIT LOW VOLTAGE (Bank 1 Sensor 1 PRE)
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0131 O2 Sensor Circuit Low Voltage (Bank 1 Sensor 1 PRE)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0132 O2 SENSOR CIRCUIT HIGH VOLTAGE (Bank 1 Sensor 1 PRE)
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0132 O2 Sensor Circuit High Voltage (Bank 1 Sensor 1 PRE)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0134 O2 SENSOR NO ACTIVITY DEFECTED CIRCUIT (Bank 1 Sensor 1 PRE)
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0134 O2 Sensor Circuit No Activity Detected (Bank 1 Sensor 1 PRE)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0135 O2 SENSOR HEATER CIRCUIT (Bank 1 Sensor 1 PRE)
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0135 O2 Sensor Heater Circuit (Bank 1 Sensor 1 PRE)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0137 O2 SENSOR CIRCUIT LOW VOLTAGE (Bank 1 Sensor 2 POST)
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0137 O2 Sensor Circuit Low Voltage (Bank 1 Sensor 2 POST)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0138 O2 SENSOR CIRCUIT HIGH VOLTAGE (Bank 1 Sensor 2 POST)
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0138 O2 Sensor Circuit High Voltage (Bank 1 Sensor 2 POST)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0140 O2 SENSOR NO ACTIVITY DEFECTED CIRCUIT (Bank 1 Sensor 2 POST)
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0140 O2 Sensor Circuit No Activity Detected (Bank 1 Sensor 2 POST)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0141 O2 SENSOR HEATER CIRCUIT (Bank 1 Sensor 2 POST)
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0141 O2 Sensor Heater Circuit (Bank 1 Sensor 2 POST)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0201 INJECTOR 1 CONTROL CIRCUIT
  • DIAGNOSTIC TROUBLE CODE (DTC) P0202 INJECTOR 2 CONTROL CIRCUIT
  • DIAGNOSTIC TROUBLE CODE (DTC) P0203 INJECTOR 3 CONTROL CIRCUIT
  • DIAGNOSTIC TROUBLE CODE (DTC) P0204 INJECTOR 4 CONTROL CIRCUIT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0201 Injector 1 Control Circuit
    • Diagnostic Trouble Code (DTC) P0202 Injector 2 Control Circuit
    • Diagnostic Trouble Code (DTC) P0203 Injector 3 Control Circuit
    • Diagnostic Trouble Code (DTC) P0204 Injector 4 Control Circuit
  • DIAGNOSTIC TROUBLE CODE (DTC) P0325 KNOCK SENSOR (KS) CIRCUIT MALFUNCTION
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0325 Knock Sensor Module Circuit
  • DIAGNOSTIC TROUBLE CODE (DTC) P0327 KNOCK SENSOR (KS) CIRCUIT LOW INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0327 Knock Sensor Circuit
  • DIAGNOSTIC TROUBLE CODE (DTC) P0336 CRANKSHAFT POSITION (CKP) SENSOR CIRCUIT RANGE/PERFORMANCE (58X)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0337 CRANKSHAFT POSITION (CKP) SENSOR CIRCUIT LOW INPUT (58X)
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0336 Crankshaft Position Sensor Circuit Range/performance (58x)
    • Diagnostic Trouble Code (DTC) P0337 Crankshaft Position Sensor Circuit Low Input (58x)
  • DIAGNOSTIC TROUBLE CODE (DTC) P0351 IGNITION 1 CONTROL CIRCUIT
  • DIAGNOSTIC TROUBLE CODE (DTC) P0352 IGNITION 2 CONTROL CIRCUIT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0351 Ignition 1 Control Circuit
    • Diagnostic Trouble Code (DTC) P0352 Ignition 2 Control Circuit
  • DIAGNOSTIC TROUBLE CODE (DTC) P0443 EVAPORATIVE EMISSION (EVAP) CONTROL SYSTEM PURGE CONTROL VALVE CIRCUIT MALFUNCTION
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0443 Evap Emission Control System Purge Control Circuit
  • DIAGNOSTIC TROUBLE CODE (DTC) P0502 VEHICLE SPEED SENSOR (VSS) CIRCUIT LOW INPUT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0502 Vehicle Speed Sensor Circuit Low Input
  • DIAGNOSTIC TROUBLE CODE (DTC) P0562 SYSTEM VOLTAGE LOW
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0562 System Voltage Low
  • DIAGNOSTIC TROUBLE CODE (DTC) P0563 SYSTEM VOLTAGE HIGH
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0563 System Voltage High
  • DIAGNOSTIC TROUBLE CODE (DTC) P0601 ECM MEMORY CHECKSUM
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0601 ECM Memory Checksum
  • DIAGNOSTIC TROUBLE CODE (DTC) P0602 PROGRAMMING ERROR
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0602 Programming Error
  • DIAGNOSTIC TROUBLE CODE P0650 MALFUNCTION INDICATOR LAMP (MIL) CONTROL CIRCUIT MALFUNCTION
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P0650 Malfunction Indicator Lamp (MIL) Control Circuit Malfunction
  • DIAGNOSTIC TROUBLE CODE (DTC) P1167 FUEL SUPPLY SYSTEM RICH DURING DECELERATION FUEL CUT OFF
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1167 Fuel Supply System Rich During Deceleration Fuel Cutoff
  • DIAGNOSTIC TROUBLE CODE (DTC) P1171 FUEL SUPPLY SYSTEM LEAN DURING POWER ENRICHMENT
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1171 Fuel Supply System Lean During Power Enrichment
  • DIAGNOSTIC TROUBLE CODE (DTC) P1391 RRID G Sen Rationality
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1391 RRID G Sen Rationality
  • DIAGNOSTIC TROUBLE CODE (DTC) P1392 RRID G Sen Short Low
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1392 RRID G Sen Short Low
  • DIAGNOSTIC TROUBLE CODE (DTC) P1393 RRID G Sen Short High
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1393 RRID G Sen Short High
  • DIAGNOSTIC TROUBLE CODE (DTC) P1625 ECM SYSTEM RESET
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1625 ECM System Reset
  • DIAGNOSTIC TROUBLE CODE (DTC) P1626 IMMOBILISER NO SIGNAL
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1626 Immobiliser No Signal
  • DIAGNOSTIC TROUBLE CODE (DTC) P1631 IMMOBILISER WRONG SIGNAL
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1631 Immobiliser Wrong Signal
  • DIAGNOSTIC TROUBLE CODE (DTC) P1648 WRONG SECURITY CODE ENTERED
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1648 Wrong Security Code Entered
  • DIAGNOSTIC TROUBLE CODE (DTC) P1649 IMMOBILISER FUNCTION NOT PROGRAMMED
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1649 Immobiliser Function Not Programmed
  • DIAGNOSTIC TROUBLE CODE (DTC) P1693 TACHOMETER OUTPUT LOW VOLTAGE
    • Circuit Description
    • Diagnostic Aids
    • Diagnostic Trouble Code (DTC) P1693 Tachometer Output Low Voltage
  • SYMPTOM DIAGNOSIS
    • PRELIMINARY CHECKS
    • VISUAL/PHYSICAL CHECKS
    • INTERMITTENT PROBLEMS
    • ENGINE CRANKS BUT WILL NOT RUN
    • HARD START SYMPTOM
    • ROUGH, UNSTABLE, OR INCORRECT IDLE, STALLING SYMPTOM
    • SURGES AND/OR CHUGS SYMPTOM
    • HESITATION, SAG, STUMBLE SYMPTOM
    • CUTS OUT, MISSES SYMPTOM
    • LACK OF POWER, SLUGGISH OR SPONGY SYMPTOM
    • DETONATION/SPARK KNOCK SYMPTOM
    • POOR FUEL ECONOMY SYMPTOM
    • EXCESSIVE EXHAUST EMISSIONS OR ODOURS SYMPTOM
    • DIESELING, RUN-ON SYMPTOM
    • BACKFIRE SYMPTOM
  • ON-VEHICLE SERVICE PROCEDURE
    • ENGINE CONTROL MODULE (ECM)
    • CRANKSHAFT POSITION (CKP) SENSOR
    • ENGINE COOLANT TEMPERATURE (ECT) SENSOR
    • INTAKE AIR TEMPERATURE (IAT) SENSOR
    • MANIFOLD ABSOLUTE PRESSURE (MAP) SENSOR
    • THROTTLE POSITION (TPS) SENSOR
    • IDLE AIR CONTROL (IAC) VALVE
    • KNOCK SENSOR (KS)
    • VERTICAL-G (RRID) SENSOR
    • HEATED OXYGEN (HO2S) SENSORS
    • EVAP CANISTER PURGE VALVE SOLENOID
    • FUEL PRESSURE RELIEF
    • FUEL RAIL ASSEMBLY
    • FUEL INJECTOR
    • FUEL PRESSURE REGULATOR
    • IGNITION COIL
    • SPARK PLUGS
    • SPARK PLUG CABLES
  • SPECIAL SERVICE TOOLS