holden.wiki

• MODEL SELECTION INDEX
• MY 2003 VY & V2 II SERIES - SERVICE INFORMATION
• SECTION 2B - HVAC CLIMATE CONTROL (MANUAL A/C) – REMOVAL AND INSTALLATION
  • 1. GENERAL INFORMATION
  • 2. MANUAL HVAC CONTROLLER
    • REMOVE
    • REINSTALL
    • 2.1 WATER VALVE VACUUM SWITCH
      • REMOVE
      • REINSTALL
    • 2.2 AIR MIX DOOR ROD RETAINER
      • REMOVE
      • REINSTALL
    • 2.3 FRONT HOUSING/SWITCH ASSEMBLYAND PRINTED CIRCUIT BOARD
      • REMOVE
      • REINSTALL
    • 2.4 MODE SWITCH VACUUM VALVE
      • REMOVE
      • REINSTALL
  • 3. HEATING, VENTILATION AND AIR CONDITIONING (HVAC) UNIT
    • REMOVE
    • REINSTALL
  • 4. EVAPORATOR CORE
    • REMOVE – LHD
    • REINSTALL – LHD
    • REMOVE – RHD
    • REINSTALL – RHD
  • 5. HEATER CORE
    • REMOVE – LHD
    • REINSTALL – LHD
    • REMOVE – RHD
    • REINSTALL – RHD
  • 6. BLOWER MOTOR AND FAN ASSEMBLY
    • REMOVE – LHD
    • REINSTALL – LHD
    • REMOVE – RHD
    • REINSTALL – RHD
  • 7. BLOWER MOTOR RESISTOR
    • REMOVE – LHD
    • REINSTALL – LHD
    • REMOVE – RHD
    • REINSTALL – RHD
  • 8. VACUUM TANK AND VACUUM ACTUATORS
    • 8.1 VACUUM TANK
      • REMOVE – LHD
      • REINSTALL – LHD
      • REMOVE – RHD
      • REINSTALL – RHD
    • 8.2 FRESH/RECIRCULATION (INTAKE) ACTUATOR
      • REMOVE – LHD
      • REINSTALL – LHD
      • REMOVE – RHD
      • REINSTALL – RHD
    • 8.3 FACE ACTUATOR
      • REMOVE – LHD
      • REINSTALL – LHD
      • REMOVE – RHD
      • REINSTALL – RHD
    • 8.4 FOOT ACTUATOR
      • REMOVE – LHD
      • REINSTALL – LHD
      • REMOVE – RHD
      • REINSTALL – RHD
    • 8.5 DEMIST ACTUATOR – LHD ONLY
      • REMOVE
      • REINSTALL
  • 9. AIR CONDITIONING HOSE AND PIPE CONNECTIONS AND RETAINERS
    • REMOVE AND REINSTALL
  • 10. THERMAL EXPANSION VALVE (TXV)
    • REMOVE
    • REINSTALL
  • 11. A/C PRESSURE TRANSDUCER
    • REMOVE AND REINSTALL
  • 12. CONDENSER
    • 12.1 V6 AND V6 SUPERCHARGED ENGINE
      • REMOVE
      • REINSTALL
    • 12.2 GEN III V8 ENGINE
      • REMOVE
      • REINSTALL
  • 13. FILTER DRIER RECEIVER
    • REMOVE
    • REINSTALL
  • 14. A/C DRIVE BELT AND PULLEYS
    • 14.1 A/C DRIVE BELT – V6 ENGINE
      • REMOVE
      • REINSTALL
    • 14.2 A/C DRIVE BELT – V6 SUPERCHARGED ENGINE
      • REMOVE
      • REINSTALL
    • 14.3 A/C DRIVE BELT – GEN III V8 ENGINE
      • REMOVE
      • REINSTALL
    • 14.4 A/C DRIVE BELT IDLER PULLEY ASSEMBLY – V6 AND V6 SUPERCHARGED ENGINE
      • REMOVE
      • REINSTALL
    • 14.5 A/C DRIVE BELT IDLER PULLEY ASSEMBLY – GEN III V8 ENGINE
      • REMOVE
      • REINSTALL
    • 14.6 A/C DRIVE BELT TENSIONER PULLEY ASSEMBLY – GEN III V8 ENGINE
      • REMOVE
      • REINSTALL
  • 15. A/C COMPRESSOR
    • 15.1 V6 AND V6 SUPERCHARGHED ENGINE
      • REMOVE
      • REINSTALL
    • 15.2 GEN III V8 ENGINE
      • REMOVE
      • REINSTALL
  • 16. MINOR A/C COMPRESSOR REPAIR PROCEDURES
    • 16.1 A/C COMPRESSOR CONTROL VALVE
      • REMOVE
      • REINSTALL
    • 16.2 A/C CLUTCH DRIVE PLATE AND HUB ASSEMBLY
      • REMOVE
      • REINSTALL
    • 16.3 A/C CLUTCH PULLEY AND BEARING ASSEMBLY
      • REMOVE
      • REINSTALL
  • 17. UNDER HOOD HEATER COMPONENTS
    • 17.1 WATER VALVE
      • REMOVE
      • REINSTALL
    • 17.2 HEATER HOSES AND VACUUM LINES
      • REMOVE AND REINSTALL
  • 18. HVAC INLET, DUCTS AND VENTILATION OUTLETS
    • 18.1 HVAC INLET SCREEN
      • REMOVE
      • REINSTALL
    • 18.2 HVAC SYSTEM DUCTS
      • REMOVE – DRIVER’S SIDE OUTER DUCT
      • REINSTALL – DRIVER’S SIDE OUTER DUCT
      • REMOVE – DRIVER’S SIDE INNER DUCT
      • REINSTALL – DRIVER’S SIDE INNER DUCT
      • REMOVE – PASSENGER SIDE DUCT
      • REINSTALL – PASSENGER SIDE DUCT
      • REMOVE – FLOOR CONSOLE REAR DUCT
      • REINSTALL – FLOOR CONSOLE REAR DUCT
      • REMOVE – FLOOR CONSOLE FRONT DUCT
      • REINSTALL – FLOOR CONSOLE FRONT DUCT
      • REMOVE – FOOT DUCT, LHD
      • REINSTALL – FOOT DUCT, LHD
      • REMOVE – FOOT DUCT, RHD
      • REINSTALL – FOOT DUCT, RHD
    • 18.3 CABIN VENTILATION OUTLETS
      • REMOVE AND REINSTALL
    • 18.4 BODY VENTILATION OUTLETS
      • REMOVE – SEDAN AND COUPE
      • REINSTALL – SEDAN AND COUPE
      • REMOVE – WAGON
      • REINSTALL – WAGON
      • REMOVE – UTILITY
      • REINSTALL – UTILITY
  • 19. TORQUE WRENCH SPECIFICATIONS
  • 20. SPECIAL TOOLS